SAFEGARD
Mandora, Louise Margaret Road, Aldershot, Hampshire GU11 2PW.
Telephone 01252 352000
COSHH ASSESSMENT RECORD
Ref No: 6/HE333
PRODUCT NAME:
Aseptopol 251NP
HAZARD
Irritant
PURPOSE
Bactericidal Manual Dishwashing Detergent
Dark green liquid used greatly diluted in water.
SUPPLIER
Ecolab Ltd, David Murray John Building, Swindon SN1 1NH.
Telephone: 01793 511221.
HAZARDOUS CONTENTS
Nonionic surfactants, 10-20%
Didecylmethylammonium chloride, 2-5%
Propan-2-ol, 1-2%
WEL: 400ppm, 999 mg/m3 LTEL
WEL: 500ppm, 1250 mg/m3 STEL
RISKS
Irritant. Risk of serious damage to eyes.
SAFETY PRECAUTIONS
Avoid contact with eyes and skin. Wear eye protection.
Wear suitable protective gloves.
Do not mix with other chemicals.
Keep out of reach of children.
HARMFUL EFFECTS
EYES:
Severe irritant. May cause serious damage.
INHALATION:
Not a normal route of exposure.
SKIN:
No specific hazard. May cause irritation on repeated or prolonged
contact.
INGESTION:
No specific hazard.
FIRST AID
EYES:
INHALATION:
SKIN:
INGESTION:
Wash immediately with water for 10 minutes holding eyelids open.
Seek immediate medical attention.
Remove to fresh air.
Wash thoroughly with water. If irritation persists, seek medical attention.
Remove contaminated clothing and wash before re-use.
Remove product from mouth. Give plenty of water to drink.
Do not induce vomiting. Seek medical attention.
WEL – Workplace Exposure Limit
LTEL – Long-term Exposure Limit (8 hour TWA reference period). TWA – Time Weighted Average
STEL – Short-term Exposure Limit (15 minute reference period)
6/HE333
FREQUENCY AND DURATION OF EXPOSURE
Daily. As detailed in cleaning schedule.
CONTROL MEASURES IN USE
All personnel needing to use this product are trained in its safe use before starting the
cleaning operation. Protective butyl or nitrile rubber gloves and eye protection shall be worn
when using the concentrated product. Product is dispensed via manual dispenser and is
greatly diluted in water for use. The diluted product is not classified as hazardous.
ASSESSMENT OF EXPOSURE
None in normal use. The Workplace Exposure Limit for propan-2-ol is not exceeded in
normal use.
STORAGE
Store upright in original closed containers in a cool dry place.
SPILLAGE
Wear suitable gloves and eye protection. Hose down area with plenty of water and run to
waste unless this would contaminate a water course or vegetation in which case absorb with
dry sand or other absorbent material and dispose of safely as commercial waste.
FLAMMABILITY
Non-flammable. Use water spray, foam, dry chemical or carbon dioxide fire extinguishers.
DISPOSAL
For small quantities wear suitable gloves and eye protection. Dilute with water and run to
waste diluting greatly with running water. Disposal of larger quantities should be in line with
National Regulations, e.g. The Hazardous Waste (England & Wales) Regulations 2005.
OTHER INFORMATION
SG 1.005. pH 4. Hand protection should meet EN 374 and eye protection should meet EN
166.
DECLARATION
This product has been assessed and is considered to present no risk in normal use, if the
precautions outlined above and in the Safety Data Sheets are followed. These precautions
are assessed to be adequate controls.
Company Chemist.
Manager.
L R Brawn
Date
14/04/08
Date
Note: The Assessment for this product shall be reviewed within five years, or earlier if its use
or composition alters.