01/01/14
1. IDENTIFICATION OF THE SUBSTANCE/PREPARATION AND THE COMPANY
PRODUCT NAME:
SUPPLIER:
HPC 06 Nu-Guard Clear A.F.
Hydron Protective Coatings Ltd
Unit 7 Phoenix Road, Wednesfield, Wolverhampton, WV11 3PX
TEL: 01902 450950
FAX: 01902 451050
………………………………………………………………………………………………………………………………………………………
2. COMPOSITION/INFORMATION OF INGREDIENTS
INGREDIENT NAME
% CONC RANGE
EINECS NO
SYMBOL
Naphtha (petroleum)
43-49
R10
……………………………………………………………………………………………………………………………………………………..
3. HAZARDS IDENTIFICATION
Flammable. Harmful: may cause lung damage if swallowed.
………………………………………………………………………………………………………………………………………………………
4. FIRST AID MEASURES
Eye Contact:
Remove any contact lenses holding the eyelids apart irrigate
copiously with clean water for at least10 min. Seek medical advice
Skin Contact:
Wash off with soap and water apply emollient cream. do not use
solvents or thinner
Inhalation:
Remove to fresh air keep the patient warm and at rest. If breathing
stops gives artificial respiration. If unconscious place in recovery
potion and seek medical advice.
Ingestion:
Rinse mouth out with water and seek medical attention if irritation
persists. Do not induce vomiting.
………………………………………………………………………………………………………………………………………………………….
5. FIRE FIGHTING MEASURES
Extinguishing media:
Not to be used:
Alcohol resistant foam, CO2 powder water spray.mist
Water Jets. Fire will produce dense black smoke containing
hazardous products of combustion. Appropriate self contained
breathing apparatus may be required. Cool container exposed to fire
with water spray. Do not allow to run into drains or water courses.
……………………………………………………………………………………………………………………………………………………….
6. ACCIDENTAL RELEASE MEASURES
Exclude sources of ignition and ventilate area. Exclude non-essential personnel. Avoid breathing
vapours. Contain and collect
Spillages with non combustible absorbent materials e.g. sand earth, vermiculite, diatomaceous earth
and place in a suitable
Container for disposal in accordance with the waste regulations.
Nu-Guard Clear A.F.
Page 1
01/01/14
7. HANDLING AND STORAGE
Keep containers tightly closed in flammable store. Do not incinerate even when empty. Do not spray
on or near naked flame or incandescent materials. Do not smoke, eat or drink whilst handling
product.
Prevent contact with eyes and skin.
…………………………………………………………………………………………………………………………………………………………
8. EXPOSURE CONTROLS / PERSONAL PROTECTION
Use gloves and overalls to prevent contact with skin and eyes. Always ensure good ventilation and
avoid inhaling vapours. In areas where OES may be exceeded a self contained breathing apparatus
should be used.
O.E.S. L.T.E.L. 8 Hours - -100ppm (575) mg/m³
S.T.E.L. 15 Minutes - 150 ppm (720 mg.m³)
………………………………………………………………………………………………………………………………………………………..
9. PHYSICAL AND CHEMICAL PROPERTIES
PHYSICAL FORM:
Viscous Liquid.
APPEARANCE/ODOUR: Various VISCOSITY:
WATER MISCIBILITY: Partially Miscible
SPECIFIC GRAVITY :
9 to 11
EXPLOSIVE LIMITS:
BOILING POINT:
FLASH POINT:
Lower: .8%
N/A
32-55 C
………………………………………………………………………………………………………………………………………………………..
10. STABILITY AND REACTIVITY
Stability: Stable under recommended storage and handling conditions. In a fire hazardous
decomposition products such as smoke Carbon monoxide carbon dioxide and oxides of nitrogen may
be produced. Keep away from oxidising agents, strong alkaline and strongly acidic materials.
…………………………………………………………………………………………………………………………………………………….
11. TOXICOLOGICAL INFORMATION
There is no data available on the preparation themselves. Exposure to organic vapours may result in
adverse health effects such as irritation of the mucous membrane, and respiratory system and
adverse effects on the renal and central nervous system.
Symptoms include headache, dizziness, fatigue, muscular weakness drowsiness ad in extreme cases
loss of consciousness.
……………………………………………………………………………………………………………………………………………………..
12. ECOLOGICAL INFORMATION
There is no data available on the preparations themselves. The products should not be allowed to
enter drains or water courses.
Or be deposited where they can affect the ground or surface waters..
Nu-Guard Clear A.F.
Page 2
01/01/14
13. DISPOSAL CONSIDERATIONS
Dispose of in accordance with all applicable local and regulation or use a registered waste disposal
contractor.
Do not allow to enter drains or watercourses.
………………………………………………………………………………………………………………………………………………………
14. TRANSPORT INFORMATION
Road and Rail UN Number 1263
Sea
UN Number 1263
Air
UN Number 1263
Class 3 Packing Group III
Class 3 Packing Group III
Class 3 Packaging Group III
Hazard ID – 30
Marine Pollutant
Packing Instruction 310
………………………………………………………………………………………………………………………………………………………..
15. REGULATORY INFORMATION
Supply Classification:
HARMFUL
Contains:
NAPTHA
Safety Phrases:
S2 Keep out of reach of children
S23 Do not breath vapour or spray
S24 Avoid contact with
S43 In case of fire use dry sodium carbonate
S61 Avoid release to the environment
S62 If swallowed do not induce vomiting seek medical advice immediately .
Risk Phrases:
R10 Flammable
R65 Harmful may cause lung damage if swallowed
skin R66 Repeated exposure may cause skin dryness or cracking
………………………………………………………………………………………………………………………………………………………….
16. OTHER INFORMATION
The information contained on this Safety Data Sheet is based on the present state of knowledge and
current national legislation
It provides guidance on health, safety and environmental aspects of the product and should not be
construed as any quarantine of technical performance or suitability for particular applications:
Further information and relevant advice can be found in:The Control of Substances Hazardous to Health Regulations 1994 (S1 1994 : 3246)
The Storage of Flammable Liquids in Containers. HS (G) 51 (if applicable)
The Storage of Packaged Dangerous Substances HS (g) 71 (if applicable)
The Environmental Protection (Duty of Care) Regulations 1992 (S1 1988 : 283
Nu-Guard Clear A.F.
Page 3