MATERIAL SAFETY DATA SHEET
Page 01
SPILKLEEN
2395 DREW ROAD, UNIT 1, MISSISSAUGA, ONTARIO L5S 1A1
PRODUCT NAME :
VYTAC MVS
SECTION 01 : CHEMICAL PRODUCT and COMPANY IDENTIFICATION
MANUFACTURER : Same as above
PREPARED BY : Production Department
PREPARATION DATE : 11 / 15 / 2013
TELEPHONE NO. : (905) 293 9995 or (877) 455 5336
EMERGENCY PHONE NUMBER : As above
CHEMICAL FAMILY:
MOLECULAR WEIGHT:
CHEMICAL FORMULA : Not Applicable
MATERIAL USE : Please refer to technical literature
Not Applicable
SECTION 02 : COMPOSITION / INFORMATION on INGREDIENTS
HAZARDOUS INGREDIENTS
SULPHUR
SECTION 03 :
ROUTE OF ENTRY:
SKIN CONTACT
EYE CONTACT
INHALATION
INGESTION
SECTION 04 :
INSTRUCTIONS:
For eye contact
For skin contact
For ingestion
For inhalation
SECTION 05:
CONC. APPROX.%
60-100
C.A.S #
LD/50 (RAT-ORAL)
LC/50 ( RTE/SPEC)
5 GR./ KG.
N./ AVAIL.
7704-34-9
TLV
HAZARDS IDENTIFICATION
May be mildly irritating
May cause irritation
Dust may be irritating to nasal passages, and respiratory tract
May be harmful if swallowed
FIRST AID MEASURES
Wash the eyes with water for 15 minutes. If irritation persists seek medical attention
Wash off with soap and water
Five 3 - 4 glasses of water, if conscious, and seek medical attention
Remove to fresh air.
FIRE AND EXPLOSION HAZARD AND FIRE FIGHTING MEASURES
FLAMMABILITY:
Combustible
IF YES , UNDER WHICH CONDITIONS: This product contains sulphur. High concentrations of MVS dust might be ignited by sparks
or open flame.
FLASH POINT (TCC) (C):
187
LEL(% by vol): N.Av.
UEL(% by vol): N.Av.
AUTO IGNITION TEMPERATURE (C): 232 C
EXTINGUISHING MEDIA: Water spray, alcohol foam, dry chemical, CO2
SPECIAL PROCEDURES: N.Av.
HAZARDOUS COMBUSTION PRODUCTS: Sulfur Dioxide
UNUSUAL FIRE AND EXPLOSION HAZARDS: NIL
SENSITIVITY TO MECHANICAL IMPACT: NIL
SENSITIVITY TO STATIC DISCHARGE: N.Av.
SECTION 06:
ACCIDENTAL RELEASE MEASURES
LEAK AND SPILL PROCEDURE: Sweep up spilled material. Uncontaminated material may be recovered and used for its intended
purpose.
SECTION 07:
HANDLING AND STORAGE
HANDLING PROCEDURES AND EQUIPMENT: Avoid inhalation of large amounts of dust and avoid contact with eyes.
STORAGE REQUIREMENTS: Keep containers closed when not in use. Store in a cool , dry location.
VYTAC MVS
Page 02
SECTION 08:
GLOVES / TYPE:
RESPIRATOR / TYPE:
EYE / TYPE:
FOOTWEAR / TYPE:
CLOTHING /TYPE:
OTHER / TYPE:
ENGINEERING CONTROLS:
SECTION 09:
PERSONAL PROTECTIVE EQUIPMENT / EXPOSURE CONTROLS
Chemical resistant
“Nuisance dust” filter mask ( Mercury vapour filter mask recommended as well)
Eye protectors
As required
As required for dealing with a mercury spill
Have access to eye bath and safety shower
Natural ventilation is adequate
PHYSICAL AND CHEMICAL PROPERTIES
PHYSICAL STATE / APPEARANCE: Free flowing yellow powder
ODOUR: None
ODOUR THRESHOLD: Not available
VAPOUR PRESSURE (mm Hg @ 20C):
< .05
VAPOUR DENSITY (Air = 1) : 8.8
EVAPORATION RATE ( WATER = 1) : Nil
SPECIFIC GRAVITY : Approx. 2
BOILING POINT (C): 445
FREEZING POINT (C): N.Av.
pH ( % SOLUTION): N.Ap.
SOLUBILITY IN WATER (% W/W): < .1
% VOLATILE (WT): Nil
SECTION 10:
STABILITY AND REACTIVITY
CHEMICALLY STABLE:
Yes
IF NO, UNDER WHICH CONDITIONS? :
INCOMPATIBILITY WITH OTHER SUBSTANCES : Yes
IF YES, WITH WHICH ONES? : Strong oxidizing agents, halogen gases, hydrocarbons at high temperatures.
SPECIAL REACTIVITY AND UNDER WHAT CONDITIONS:
HAZARDOUS DECOMPOSITION PRODUCTS:
N.Av.
SECTION 11:
TOXICOLOGICAL INFORMATION
EXPOSURE LIMIT OF MATERIAL :
N.Av.
LC 50 OF MATERIAL, SPECIES AND ROUTE : N.Av.
LD 50 OF MATERIAL, SPECIES AND ROUTE : N.Av.
CARCINOGENICITY OF MATERIAL: N.Av.
REPRODUCTIVE EFFECTS :
N.Av.
IRRITANCY OF MATERIAL :
See section 02
SENSITIZING CAPABILITY OF MATERIAL : See section 03
SYNERGISTIC MATERIALS :
N.Av.
SECTION 12:
AQUATIC TOXICITY:
SECTION 13:
ECOLOGICAL CONSIDERATIONS
N.Av.
DISPOSAL CONSIDERATIONS
WASTE DISPOSAL : In accordance with municipal, provincial and federal regulations
SECTION 14:
TRANSPORT INFORMATION
Non Regulated
SECTION 15:
REGULATORY INFORMATION
WHMIS CLASSIFICATION: B4. D2B
CPR COMPLIANCE: This product has been classified in accordance with the hazard criteria of the CPR and the MSDS contains
all the information required by the CPR.
SECTION 16:
ABBREVIATIONS USED :
OTHER INFORMATION
N.Av. = Not Available
N.Ap. = Not applicable