SNORKEL PRO-66
DAILY INSPECTION AND MAINTENANCE CHECKLIST
At the start of each work day a certified operator must perform the DAILY INSPECTION AND
MAINTENANCE CHECKLIST (below). The equipment must not be operated if not in proper
mechanical condition. All defects must be reported to the Electric Shop Foreman immediately.
Picture details are located on pages10-2 - 10-12 of the Operation Manual
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
ITEM
Engine fuel level
Fuel tank cap
SERVICE REQUIRED
Check fuel gauge
Visually inspect (installation)
Engine oil
Check dipstick (between lines)
Fuel leaks
Wiring harnesses
Battery terminals
Battery fluid level
Hydraulic Oil
Hydraulic Oil leaks
Tires
Bolts and fasteners
Structural damage and welds
Guard rails
Platform gravity gate
Lanyard anchor points
Emergency power motor/pump
Air filter
Charging system
Ground-control panel switches and alarms
Level sensor
Platform-control box switches and alarms
Placards and decals
Slide pads
Whiffles and wire ropes
Visually inspect (hoses, connections, etc.)
Visually inspect (installation, condition)
Visually inspect ( corrosion)
Check fluid level (in contact with filler neck)
Check oil level (between lines on gauge)
Visually inspect (hoses, tubes, fittings)
Visually inspect (condition)
Visually inspect (looseness)
Visually inspect (weld cracks, dents)
Visually inspect condition
Visually inspect (operation)
Visually inspect condition
Check operation (causes correct motion)
Visually inspect (gauge)
Visually inspect (gauge)
Actuate and visually check for operation
Actuate and listen for alarm to sound
Actuate and visually check for operation
Visually inspect (installation, condition)
Visually inspect (boom wear marks)
Visually inspect (even tension)
Prior approval must be obtained for getting on
grass or sidewalks.
25 Grounds Maintenance Authorization
Name of Operator:________________________________
Name of Passenger:_______________________________
Date:______________
Shop:_____________
I have performed the above checklist and the Snorkel-Lift is in satisfactory operating condition.
This form is to be returned to the BMC Electric Shop at the end of the day or the end of the job, whichever comes first.
Beginning Hours: ______________
Ending Hours:
______________
Fuel (DIESEL):
________gallons
List all deficiencies on the back side of this
form. Call them to the attention of the
Electric Shop Foreman immediately.
PPOP 02.11
Attachment A
05/06/02
PPOP 02.11
Attachment A
05/06/02