N5890 Staff Report 6-24

advertisement
Michigan Department of Environmental Quality
Air Quality Division
State Registration Number
N5890
RENEWABLE OPERATING PERMIT
STAFF REPORT
ROP Number
MI-ROP-N5890-2013
Ottawa Generating Station
SRN: N5890
Located at
15362 68th Avenue, Coopersville, Michigan 49404
Permit Number:
MI-ROP-N5890-2013
Staff Report Date:
April 8, 2013
This Staff Report is published in accordance with Sections 5506 and 5511 of Part 55, Air Pollution
Control, of the Natural Resources and Environmental Protection Act, 1994 PA 451, as amended (Act
451). Specifically, Rule 214(1) requires that the Michigan Department of Environmental Quality (MDEQ),
Air Quality Division (AQD), prepare a report that sets forth the factual basis for the terms and conditions
of the Renewable Operating Permit (ROP).
Page: 1
TABLE OF CONTENTS
April 8, 2013 STAFF REPORT
3
May 9, 2013 STAFF REPORT ADDENDUM
8
Page: 2
Michigan Department of Environmental Quality
Air Quality Division
State Registration Number
ROP Number
RENEWABLE OPERATING PERMIT
N5890
MI-ROP-N5890-2013
April 8, 2013 STAFF REPORT
Purpose
Major stationary sources of air pollutants, and some non-major sources, are required to obtain and
operate in compliance with a ROP pursuant to Title V of the federal Clean Air Act of 1990 and
Michigan’s Administrative Rules for air pollution control pursuant to Section 5506(1) of Act 451. Sources
subject to the ROP program are defined by criteria in Rule 211(1). The ROP is intended to simplify and
clarify a stationary source’s applicable requirements and compliance with them by consolidating all state
and federal air quality requirements into one document.
This report, as required by Rule 214(1), sets forth the applicable requirements and factual basis for the
draft permit terms and conditions including citations of the underlying applicable requirements, an
explanation of any equivalent requirements included in the draft permit pursuant to Rule 212(5), and any
determination made pursuant to Rule 213(6)(a)(ii) regarding requirements that are not applicable to the
stationary source.
General Information
Stationary Source Mailing Address:
Ottawa Generating Station
15362 68th Avenue
Coopersville, Michigan 49404
N5890
221119
Source Registration Number (SRN):
North American Industry Classification System
(NAICS) Code:
Number of Stationary Source Sections:
Is Application for a Renewal or Initial Issuance?
Application Number:
Responsible Official:
AQD Contact:
Date Permit Application Received:
Date Application Was Administratively Complete:
Is Application Shield In Effect?
Date Public Comment Begins:
Deadline for Public Comment:
1
Renewal
201200131
Marc Pauley, Operations Manager
517-372-8330
Dave Morgan, Environmental Quality Analyst
616-356-0009,
August 22, 2012
September 5, 2012
Yes
April 8, 2013
May 8, 2013
Page: 3
Source Description
The Ottawa Generating Station (OGS) located at 15362 68th Street, in Coopersville, Ottawa County,
Michigan, is a landfill gas treatment and electric generating facility owned and operated by the Granger
Electric Company. The Ottawa Generating Station consists of two landfill gas treatment systems, six
Caterpillar model G3516LE internal combustion engines, and one Caterpillar model G3520C internal
combustion engine. Landfill gas from the Ottawa County Farms Landfill (OCFL) is piped through two
landfill gas treatment systems where the gas is filtered, dewatered, compressed, and cooled. There are
no atmospheric vents or emissions from the landfill gas treatment systems. After treatment, the landfill
gas is combusted in the engines to generate electricity for sale; the engines operate 24 hours per day, 7
days per week. Six of the internal combustion engines are exempt from permitting under Rule 285(g).
The seventh engine is installed under Permit to Install (PTI) No. 173-05A. An eighth engine is permitted
under PTI No. 203-10 but has not yet been installed. Any gas not burned in the engines is routed to an
open flare. The open flare is exempt from permitting under Rule 285(aa) and there are no specific
requirements in the ROP because the open flare is burning gas that has been conditioned in the
treatment systems.
Since the Ottawa Generating Station controls emissions from the NSPS subject landfill, it is also subject
to 40 CFR Part 60, Subparts A and WWW.
OGS and OCFL have a contractual agreement in which the OFCL sells landfill gas to the OGS for
combustion in engines to produce electricity. The contractual and spatial relationship of the two facilities
establishes OCFL and OGS as a single stationary source based on the definition in Michigan’s
Rule 336.1119(r). However, based on an agreement between the AQD and management of OCFL and
OGS, the two facilities will be issued separate State Registration Numbers and ROPs.
The following table lists stationary source emission information as reported for the 2011 calendar year to
the Michigan Air Emissions Reporting System.
TOTAL STATIONARY SOURCE EMISSIONS
Pollutant
Carbon Monoxide (CO)
Nitrogen Oxides (NOx)
Particulate Matter (PM)
Sulfur Dioxide (SO2)
Volatile Organic Compounds (VOCs)
Non-methane organic compounds
(NMOC)
Tons Per Year
(Ottawa County
Farms Landfill)
Tons Per Year
(Ottawa Generating
Station)
Total
Tons per Year
0.05
0.02
5.69
0.004
0.0005
25.72
200.47
101.91
17.92
4.97
58.78
0.0
200.52
101.93
23.61
4.97
58.78
25.72
In addition to the pollutants listed above that have been reported in MAERS, the potential to emit of
Greenhouse Gases in tons per year of CO2e is greater than 100,000. CO2e is a calculation of the
combined global warming potentials of six Greenhouse Gases (carbon dioxide, methane, nitrous oxide,
hydrofluorocarbons, perfluorocarbons, and sulfur hexafluoride).
See Parts C and D in the draft ROP for summary tables of all processes at the stationary source that are
subject to process-specific emission limits or standards.
Page: 4
Regulatory Analysis
The following is a general description and history of the source. Any determinations of regulatory nonapplicability for this source are explained below in the Non-Applicable Requirement part of the Staff
Report and identified in Part E of the ROP.
The stationary source is located in Ottawa County, which is currently designated by the U.S.
Environmental Protection Agency (USEPA) as attainment/unclassified for all criteria pollutants.
As previously discussed, OCFL and OGS were determined by the AQD to be a single stationary source
based on the criteria listed under Rule 336.1119(r). OGS’s landfill gas treatment system and seven
internal combustion engines are located on a contiguous and adjacent property and is dependent upon
OCFL to supply the landfill gas which is combusted in its engines. As indicated in the August 7, 1980,
Federal Registry (45 FR 52695), “one source classification encompasses both the primary and support
facilities, even when the latter includes units with a different two-digit SIC code. Support facilities are
typically those which convey, store, or otherwise assist in the production of the principal product.” OGS
assists OCFL in the destruction of landfill gas produced by the landfill. Since the destruction of landfill
gas is essential to OCFL’s lawful operation, OGS is considered to be a support facility to the OFCL.
Therefore, OCFL and OGS constitute a single stationary source.
Although the two facilities are considered to be the same source for Title V applicability, discussions
between the management of each facility and the AQD resulted in an agreement by which each facility
will be issued a separate ROP. The initial ROP for the source contained one section for OCFL and a
separate section for OGS. Despite separate ROPs, OCFL and OGS, are still considered to be a single
stationary source for new source review permitting purposes. In other words, emissions from the
facilities will be considered aggregately instead of separately when future rule applicability
determinations are made by the AQD.
OGS is subject to 40 CFR Part 70 because it is subject to 40 CFR Part 60, Subpart WWW which
requires the stationary source to obtain a ROP.
The stationary source is considered a major source of Hazardous Air Pollutant (HAP) emissions
because the potential to emit of any single HAP regulated by the federal Clean Air Act, Section 112 is
greater than 10 tons per year; the potential to emit of all HAPs combined is greater than 25 tons per
year.
EUTREATMENTSYS is subject to the New Source Performance Standards (NSPS) for Municipal Solid
Waste Landfills promulgated in 40 CFR Part 60, Subparts A and WWW and is also subject to the
Maximum Achievable Control Technology (MACT) Standard for Municipal Solid Waste Landfills
promulgated in 40 CFR Part 63, Subparts A and AAAA.
EURICEENGINE7 and EURICEENGINE8 at the stationary source are subject to the NSPS for
Stationary Spark Ignition Internal Combustion Engines promulgated in 40 CFR Part 60, Subparts A and
JJJJ and are subject to the major source MACT Standard for Stationary Reciprocating Internal
Combustion Engines promulgated in 40 CFR Part 63, Subparts A and Subpart ZZZZ.
EURICEENGINE7 and EURICEENGINE8 at the stationary source were subject to review under the
Prevention of Significant Deterioration regulations of Part 18, Prevention of Significant Deterioration of
Air Quality, of Act 451 because at the time of New Source Review permitting the potential to emit of
carbon monoxide was greater than 250 tons per year.
Page: 5
The potential to emit of Greenhouse Gases is 100,000 tons per year or more calculated as carbon
dioxide equivalents (CO2e) and 100 tons per year or more on a mass basis.
At this time, there are no GHG applicable requirements to include in the ROP. The mandatory
Greenhouse Gas Reporting Rule under 40 CFR 98 is not an ROP applicable requirement and is not
included in the ROP.
The monitoring conditions contained in the ROP are necessary to demonstrate compliance with all
applicable requirements and are consistent with the "Procedure for Evaluating Periodic Monitoring
Submittals."
The stationary source is not subject to the federal Compliance Assurance Monitoring (CAM) rule under
Title 40 of the Code of Federal Regulations, Part 64, because the emission limitation(s) or standard(s)
for municipal solid waste landfills and reciprocating internal combustion engines are covered by 40 CFR
Part 60, Subparts WWW and JJJJ and 40 CFR Part 63, Subparts AAAA and ZZZZ. Therefore,
EUTREATMENTSYS, EURICEENGINE7 and EURICEENGINE8 are exempt from CAM requirements.
Please refer to Parts B, C and D in the draft ROP for detailed regulatory citations for the stationary
source. Part A contains regulatory citations for general conditions.
Source-wide Permit to Install (PTI)
Rule 214a requires the issuance of a Source-wide PTI within the ROP for conditions established
pursuant to Rule 201. All terms and conditions that were initially established in a PTI are identified with
a footnote designation in the integrated ROP/PTI document.
The following table lists all individual PTIs that were incorporated into previous ROPs. PTIs issued after
the effective date of ROP No. MI-ROP-N3294-2008 are identified in Appendix 6 of the ROP.
173-05
NA
PTI Number
NA
NA
Streamlined/Subsumed Requirements
This permit does not include any streamlined/subsumed requirements pursuant to Rules 213(2) and
213(6).
Non-applicable Requirements
Part E of the draft ROP lists requirements that are not applicable to this source as determined by the
AQD, if any were proposed in the application. These determinations are incorporated into the permit
shield provision set forth in Part A (General Conditions 26 through 29) of the draft ROP pursuant to
Rule 213(6)(a)(ii).
Processes in Application Not Identified in Draft ROP
The following table lists processes that were included in the ROP application as exempt devices under
Rule 212(4). These processes are not subject to any process-specific emission limits or standards in
any applicable requirement.
Page: 6
Exempt
Emission Unit ID
EU-ENGINES
Description of
Exempt Emission Unit
Six internal combustion engines are
low emission landfill gas engines that
fire the lean fuel mixtures. Each
engine has a power rating of 1,138
horse power and a maximum
operating fuel requirement of
approximately 8.6 million BTU per
hour.
Rule 212(4)
Exemption
R 336.1212(4)(d)
Rule 201
Exemption
R 336.1285(g)
EU-USEDOIL-GR
Used oil tanks inside treatment
system building.
R 336.1212(4)(c)
R 336.1284(i)
EU-NEWOIL-GR
New oil tanks inside treatment
system building.
R 336.1212(4)(c)
R 336.1284(i)
EU-PROPANE-GR
One 500 gal and one 300 gal
propane tanks located outside Plant
2.
R 336.1212(4)(c)
R 336.1284(b)
Draft ROP Terms/Conditions Not Agreed to by Applicant
This permit does not contain any terms and/or conditions that the AQD and the applicant did not agree
upon pursuant to Rule 214(2).
Compliance Status
The AQD finds that the stationary source is expected to be in compliance with all applicable
requirements as of the effective date of this ROP.
Action taken by the DEQ
The AQD proposes to approve this permit. A final decision on the ROP will not be made until the public
and affected states have had an opportunity to comment on the AQD’s proposed action and draft permit.
In addition, the U.S. Environmental Protection Agency (USEPA) is allowed up to 45 days to review the
draft permit and related material. The AQD is not required to accept recommendations that are not
based on applicable requirements. The delegated decision maker for the AQD is Heidi G. Hollenbach,
Grand Rapids District Supervisor. The final determination for ROP approval/disapproval will be based
on the contents of the permit application, a judgment that the stationary source will be able to comply
with applicable emission limits and other terms and conditions, and resolution of any objections by the
USEPA.
Page: 7
Michigan Department of Environmental Quality
Air Quality Division
State Registration Number
RENEWABLE OPERATING PERMIT
ROP Number
N5890
May 9, 2013 STAFF REPORT ADDENDUM
MI-ROP-N5890-2013
Purpose
A Staff Report dated April 8, 2013, was developed in order to set forth the applicable requirements and
factual basis for the draft Renewable Operating Permit (ROP) terms and conditions as required by
R 336.1214(1). The purpose of this Staff Report Addendum is to summarize any significant comments
received on the draft ROP during the 30-day public comment period as described in R 336.1214(3). In
addition, this addendum describes any changes to the draft ROP resulting from these pertinent
comments.
General Information
Responsible Official:
AQD Contact:
Marc Pauley, Operations Manager
517-372-8330
Dave Morgan, Environmental Quality Analyst
616-356-0009
Summary of Pertinent Comments
No pertinent comments were received during the 30-day public comment period.
Changes to the April 8, 2013 Draft ROP
No changes were made to the draft ROP.
Page: 8
Download