Gulf of Mexico Shelf Region
Waste Management Procedures
Oil Spill Related Wastes
Before you begin
Description
Contaminated debris, oily rags or absorbent pads used to clean up spills of:
 crude oil
 lube oil
 hydraulic oil
 diesel
 jet fuel
Category
E & P Exempt Waste
 Crude oil
 Solvent -------E & P Exempt Waste (if used downhole)
Non-exempt waste
 Lube oil
 Hydraulic oil
 Diesel ------------- Non-exempt unless used as specific mud stream
 Jet fuel
 Solvent ----------- Non-exempt (if used on the surface)
Analysis
Accumulation
Oil Spill Related Waste:
 No laboratory analysis required
 Identification by ingredients on label and Material Safety Data Sheet, (MSDS)

Place in closed container. Keep drum closed unless materials are being
added or removed.
Continued on next page
Version 2, October 2011
Page 1 of 5
Gulf of Mexico Shelf Region
Waste Management Procedures
Oil Spill Related Wastes
Before you begin,
Waste
Reduction
Disposal
(continued)
Very few waste reduction options exist. When possible:
 Use absorbents that can be wrung out and reused. This reduces the
volume of waste pads.

Return liquid to the crude oil stream if it is any of the following petroleum
distillates
 Aviation Fuel (Turbine Engine)
 Crankcase oil
 Crude oil
 Diesel Fuel
 Hydraulic Fluid
 Varsol
 Other non-hazardous petroleum distillates

Do not return halogenated solvents (such as 1,1,1 trichloroethane) to the
crude oil stream. Look for halogens by the “chloro” , “fluoro”, or “bromo” in
the name on the MSDS.
Certain debris that will not burn (such as oil contaminated soil & sand) will
need to be sent to an approved disposal site. (For shipments beginning in
Louisiana, mark as 16 Oil Spill Waste on the UIC – 28 Form)
Debris that will burn (such as oily rags soaked with crude oil, vegetation
covered with crude oil): (NOTE: DO NOT BURN OFFSHORE)
 Send pads to a facility that will beneficially reuse the pads as blended
fuel.
 Do not place in trash or allow to be placed in landfill.
Recordkeeping



Version 2, October 2011
Complete entry in General Cargo Section [Section II] of the Apache
Shipping Manifest (See example).
Maintain a copy of the shipping manifest while shipment is active.
Retain records for three years.
Page 2 of 5
Gulf of Mexico Shelf Region
Waste Management Procedures
Shipping Instructions: OIL SPILL RELATED WASTES
1.
Call or FAX Dock/Base to schedule shipment.
2.
Package Oil Spill Related Wastes as follows:
a.
Non-Bulk Packaging:
1.
Removable-head 1H2 poly drum is preferred, 1A2 steel drum is acceptable
2.
Prevent contamination from rainwater
b.
Bulk Packaging:
1.
DOT 51, 52, 53, 56, 57, or 60 Portable Tanks
2.
Marine Portable Tank
3.
Cuttings Barge
3.
Mark Package:
a.
"Oil Spill Waste, not regulated by DOT"
b.
Stencil Container-"Apache" and the generator's location (i.e. Eugene Island 158)
4.
Label Package:
a.
No labels required by DOT
5.
Prepare shipping papers:
a.
Complete entry in General Cargo Section [Section II] of the Apache Shipping
Manifest (See example). (See Example)
b.
For shipments to shorebases in Louisiana, Prepare Non-hazardous Oilfield Waste
Shipping Control Ticket Form UIC-28 in Louisiana (See Example). DO NOT SIGN
THIS CONTROL TICKET. Sign the ticket in the presence of the truck driver.
Dock personnel must sign.
c.
For shipments to shorebases in Alabama, Prepare State Oil and Gas Board of
Alabama Waste Liquids Manifest.
d.
For shipments to shorebases in Texas, or Mississippi no state documents are
required.
6.
Placard Vehicle/Vessel:
a.
No Placard Required
7.
Load cargo in accordance with the following shipping limitations:
AIR
Passenger Aircraft
Cargo Aircraft
WATER
Cargo and passenger vessels
Other Requirements
8.
RESTRICTIONS (49 CFR 172.101)
No Requirement
No Requirement
RESTRICTIONS
No Requirement
None
Include MSDS of material with which the rags are soaked (crude oil, etc.)
Version 2, October 2011
Page 3 of 5
Gulf of Mexico Shelf Region
Waste Management Procedures
NONHAZARDOUS OILFIELD WASTE SHIPPING CONTROL TICKET
STATE OF LOUISIANA
OFFICE OF CONSERVATION
P.O. BOX 94275
BATON ROUGE, LA 70804-9275
UIC - 28
1567899
Manifest No.
CONSERVATION COPY
ORIGINAL
1726545
1 END
PART I
TO BE COMPLETED BY GENERATOR
Generator
Apache Corporation
2014 W. Pinhook Road, Suite 800
Lafayette, LA, 70510
CODES
↔
0152
Address
City/State/Zip
(337) 735-8210
Telephone No.
ORIGINATION OF WASTE (see instructions on back)
↔
↔
999997
5
Well Name & No. / Description
LUW Type
OCS-G-1220
Eugene Island 175
Field
WASTE IDENTIFICATION AND AMOUNT (IN 42 GALLON BARRELS)
01 Salt Water
07 Prod. Sands/Solids
13 BS &W Waste
02 Oil Base Mud
08 Fresh Water
14 Pipeline Test Water
03 Water Base Mud
09 Rainwater
15 Com. Facility Waste
04 Completion Fluids
10 Washout Water
16 Oil Spill Waste
05 Prod. Pit Sludges
11 Washout Pit Water
50 Salvage Crude Oil
06 Prod Tank Sludges
12 Gas Plant Waste
99 Other
DESTINATION OF WASTE
Commercial Facility (Company) Name
SITE CODE
5101
↔
CERTIFICATION:
20
Aaron Oil Company
206 Sandra Street Berwick, La. 70342
NOTE: MUST BE SIGNED IN THE PRESENCE OF THE TRANSPORTER!
Site Name
The waste described above was consigned to the carrier named below. I certify that the foregoing is true and correct to the best of my
knowledge
Sam Bourque
am
1/1/11
Signature of Generator’s Authorized Agent
pm
Date and Time of Shipment
PART II:
TO BE COMPLETED BY TRANSPORTER IN PRESENCE OF GENERATOR
Transporter
Graham Gulf, Inc.
PSC PERMIT
9997
↔
Address
City/State/Zip
(985) 385-3475
Telephone No.
P.O. Box 2291
Truck License No.
Morgan City, LA, 70380
Trailer License No.
If transported by barge, barge and tug identification
Barge and Tug Id.
CERTIFICATION:
I certify that the waste in quantity above was received by me for shipment to the above destination.
am
pm
Signature of Transporter’s Authorized Agent
PART III
Date and Time Received
TO BE COMPLETED BY COMMERICAL FACILITY
SITE CODE
5101
↔
Facility (Company) Name
Site Name
Aaron Oil Company
206 Sandra Street Berwick, La. 70342
CHEMICAL ANALYSIS
Chloride (mg/l)
CERTIFICATION:
Conductivity (mmhos/cm)
pH
I certify that the waste described in Part I was received by me via the transporter described in Part II
Signature of Facility Agent
Version 2, October 2011
Date and Time Received
Page 4 of 5
Gulf of Mexico Shelf Region
Waste Management Procedures
FORM OGB-26 STATE OIL AND GAS BOARD OF ALABAMA
420 Hackberry Lane
5 / 00
To be filled in by Operator
P. O. Box 869999
Tuscaloosa, Alabama 35486-6999
(205) 349-2852 Fax (205) 349-2861
www.ogb.state.al.us
AP3
OCSG 5058 #001
Operator Code
Manifest Number
WASTES MANIFEST
PART I: TO BE COMPLETED BY THE OPERATOR
Operator Name:
Apache Corporation (Mobile 821)
7778 Dauphin Island Parkway, Theodore, AL 36582
Address:
(251) 449-7244
Origination of Waste Liquids
Operator Name:
AP3
(337) 735-8220
Operator Type
NATURAL GAS
Field
County
MOBILE 821 FIELD
FEDERAL WATERS
Description of Waste
OIL SPILL WASTE
Quantity of Waste
20 BARRELS
Destination:
Disposer’s Name
Aaron Oil Company
Business Address
Disposal Site Address
Disposal Method
SEPARATION AND DEWATERING
Certification:
The waste described above was consigned to the carrier named below. I certify that the foregoing is true and correct to
the best of my knowledge
Sam Bourque
06/1/2011
Signature of Operator’s Agent
2:30 p.m.
Date and Time Shipped
PART II: TO BE COMPLETED BY TRANSPORTER(Note: To be completed in presence of Operator)
Transporter’s Name
Code No.
Gulf Glory
ALR000011247
Business Address
Graham Gulf Inc. P.O.Box 309, Bayou La Batre, AL 36509 (251) 824-1834
License Plate of Truck
License of Trailer
If Transported by Barge, Barge and Tug Identification
Certification:
I certify that the waste in the quantity above was received by me for shipment to the above destination
Bill Jones
07 / 01 / 00
Signature of Transporter’s Agent
2:30 p.m.
Date and Time Received
PART III: TO BE COMPLETED BY DISPOSER
Disposer’s Name
Aaron Oil Company
Disposal Site Address
Certification:
I certify that the waste in the quantity and description above was received by me for proper disposal.
Sam Bourque
7/2011
Signature of Disposer’s Agent
1:30 p.m.
Date and Time Received
INSTRUCTIONS
Read Carefully and Comply Fully
1.
2.
3.
4.
5.
6.
7.
8.
Every shipment of wastes liquids shall be accompanied by this form.
At the time of transport, the operator shall initiate the manifest by completing and signing Part I. The operator shall assign a sequential manifest number in the upper right corner. The
number should be preceded by the operator code number provided by the State Oil and Gas Board.
The transporter shall complete and sign Part II.
The operator shall copy form and mail to the Board within ten (10) days.
The original shall accompany the wastes shipment.
Upon receipt of the wastes, the disposer shall complete and sign Part III.
The transporter shall retain a copy.
The disposer shall retain a copy and mail a copy to the operator and the original to the Board within ten (10) days.
Version 2, October 2011
Page 5 of 5