40 Litre Electric Cool Box
ITEM CODE-237466
• This unit has two power options:
1. 12v cigarette lighter power cord for use in a car.
2. 230v three pin mains plug for use in the home.
• Simply plug into the car socket or mains supply.
• The unit is suitable for keeping foodstuff cool.
• Convenient cable compartment in lid for storage of both power cords.
• Two sturdy wheels and multi-functional pull-out handle for easy movement.
• Fits Fits three 2-litre bottles standing.
TO OPERATE
1.
The cooling performance is similar to that of a household fridge (NOT a freezer).
2.
If the unit is operated continuously, it will lower the temperature inside to about 16°C below that of
the surrounding air.
3.
The best performance will be obtained if the unit is loaded with food and drinks that are already
cold.
4.
For best cold retention after disconnection, keep the lid tightly closed.
ADVICE
1.
DO NOT block the air flow.
The unit must have a clear flow of air to remove excess heat in order to work effectively.
For best results:
Don’t operate in a confined space such as a car boot.
Don’t leave the unit in a sealed car or boot whilst in use.
2.
Shade the unit from direct sunlight and leave windows slightly open to allow for air circulation.
3.
The unit is designed for operation in vehicles with a negative earth. If your vehicle has a positive
earth terminal, a competent electrician must rewire the cigarette lighter end of the adaptor.
4.
Ice-cream should not be refrozen after storage in the unit.
5.
Performance will be impaired by the addition of any substantial amount of items at room
temperature.
6.
When not in use the unit must be stored open to prevent mould growth.
7.
NEVER fill the unit with water. DO NOT immerse the unit in water.
8.
Always disconnect the unit from electricity for cleaning. Wipe clean using a mild detergent solution.
9.
Disconnect the unit while the vehicle motor stop working otherwise the power in the cell might be
off.
TROUBLESHOOTING
If the unit does not appear to function correctly, unplug the unit and check the following:
Fault
Possible cause
Suggested remedy
Your cooler does not function
(DC plug is inserted, LED on
the plug does not glow).
There is no voltage flowing
from the 12V socket
(cigarette lighter) in your vehicle.
The ignition must be switched on
in most vehicles for voltage to
flow at the cigarette lighter.
Your cooler does not function
(AC plug is inserted).
No voltage present in the AC
voltage socket.
Try using another plug socket.
Your cooler does not cool
(plug is inserted, LED on the
DC plug glows).
The inner fan or the cooling
element is defective.
This can only be repaired by an
authorized customer services
unit.
The cigarette lighter socket is
dirty. This results in a poor
electrical contact.
If the plug of your cooler
becomes very warm in the 12V
cigarette lighter socket, either
the socket is not clean or the
plug has not been inserted
correctly into the socket.
Remove dirt from the plug and/
or socket using a non metallic
tool.
The ignition is on and the
cooler is not working or keeps
switching off
(DC Plug is inserted, LED on
the plug is not glowing or not
glowing continuously)
The plug has not been inserted
properly into the socket, poor
electrical contact.
Extract plug gently from the
socket and reinsert firmly.
Repeat the operation until the
proper position is found, the plug
is aligned firmly into the socket.
The fuse of the 12V plug has
blown.
Replace the fuse (8A) in the 12V
plug.(unscrew the tip)
The vehicle fuse has blown.
Replace the vehicle's 12V
socket fuse (usually 15A).
Please refer to the operating
manual of your vehicle.
There is water inside the cooler
Moisture in the air, trapped
inside the cooler, is condensed
by the low temperature.
This is not a product fault, the
inner of the cooler is not
ventilated. Dry the condense
water periodically.
There is ice formation near the
inner ventilator
Moisture in the air, trapped
inside the cooler, is condensed
to water and freezes in contact
with the ventilator. Ice formation
can block the ventilator and
damage the unit.
This is not a product fault.
Switch the unit off and let the
ice melt, remove gently, check
the unit periodically if it is used
continuously.
TECHNICAL SPECIFICATIONS
Capacity 40 Litres
Weight
8.35 kg
Exterior Dimensions (approx.)
Length
: 57.1 cm
Height
: 43.2 cm
Width
: 37.8 cm
Voltage
: 12 Volts DC / 240 Volts AC / 50 Hz built-in adaptor
Current
: DC 3.5A /AC ~ 0.4A
Power Consumption :
DC : 42 Watts ; AC : 55 Watts
Refrigeration system :
Thermo electric solid state heat pump
Insulation Material
:
High quality full foam insulation of polyurethane, CFC-free
Case
:
polypropylene
12V
:
2.7 metre (approx.)
Power cord 240V
:
1.5 metre (approx.)
Power cord
Battery consumption : fully charge the battery by running the engine prior to using the unit for any
extended period when stationary.
If the battery runs down in this time you may have a faulty battery or alternator.
The unit can be used continuously while the vehicle is running, since the alternator provides more than
enough power.
OPERATION FROM 240V MAINS: THE UNIT MAY BE OPERATED CONTINUOUSLY.
Halfords Ltd., Washford, Redditch B98 0DE