1L1
1L 2
110562
NOTE 3:
A: ON 115V MACHINES THE WASH TANK HEATER IS 3 kW.
B: THE kW RATING OF THE BOOSTER ELEMENT IS
DEPENDENT UPON THE VOLTAGE AND DEGREE RISE OF THE
SYSTEM. SINGLE PHASE MACHINES W/ ELEC. BOOSTER ARE 40°F
RISE ONLY. 40°F RISE UNITS USE 7.5/10 OR 9 kW ELEMENTS.
70°F RISE UNITS USE 13.5/18 OR 17.7 kW ELEMENTS.
NOTE 1: IF SUPPLY IS 115V, T1 IS NOT USED.
WIRES #1 AND 2 ARE CONNECTED TO THE FUSE
BLOCK IN PLACE OF #39 AND 40.
NOTE 2: USED ON MACHINES WITH INDEPENDENT
FRONT DOOR OPTION.
ON SINGLE PHASE
MACHINES OMIT L3.
L1
L2
50
L1
L2
L3
1MOL
50
24
25
1MOL
1M
MODEL
1MTR
28
24
25
26
L3
DH1, DHB
DH1, DHB
27
28
29
CKT. BD.
PART NUMBER
UP TO D3857
112676 REV C
OPEN
CLOSED
OPEN
113597 REV G
CLOSED
CLOSED
OPEN
113597 REV G
OPEN
CLOSED
OPEN
113597 REV H
OPEN
OPEN
OPEN
D35858-D0816800
ALL
DLF
1MTR
K
DH1/B (E*)
D08016801 - UP
T1 NOT USED WITH
115V LINE SUPPLY
SEE NOTE 1
3CR
FUH 30
L2
31
HC1
L1
L2
L3
FUH 30
31
32
FUH 30
31
32
HC1
DS1
33
34
5
DS2
6
F1
4
H
4.7KW
2
N
1CRA
T7
START
SWITCH
T8
DOOR
SWITCH
9
FSW
10
T9
37
T10
BC1
POWER
LED
T1
8
1CRB
WASH
OUTPUT
T2
36
L2
2
3CR
5 X 20 MM
FAST ACTING
FUSE 1A
33
34
35
BC1
4
1CR
4.7KW
35
RINSE
OUTPUT
13
1M
12
T3
1MOL
14
JB3
1CRC
15
JB1
HEATERS
OUTPUT
FLOAT
SWITCH
16
2CR
AS
17
18
HCHL
19
LAMP
OUTPUT
LEDs
AS
T6
20 BCHL
21
TSBC
38
RINSE
WASH
JB2
22
2CRA
1M
4
36
37
38
HC1
T5
TSHC
EXTENDED
WASH
FILL
BC1
DR.BY
DATE
J.NEWTON
20MAY99
SCALE
SHEET
1
NONE
OF
1
G
H
I
DESCRIPTION
ADD JUMPER / SN INFORMATION. REVISE NOTE 3.
ADDED ARC SUPPRESSORS
CORRECTED BOARD# 'S. WAS 113457 & 112676
G
RINSE AID SIGNAL
41
DATE
BY
1NOV 02 MJM
13MAR03 JAM
2/4/04
WB
(IF USED)
RELAY
NO
NC
23
2
DETERGENT SIGNAL
120V SIGNAL TO
VENT FAN CONTACTOR
IF USED
REV.
2
LT1
43
CUSTOMER TO SUPPLY RATED VOLTAGE/PHASE/Hz,
AS SPECIFIED PER ORDER,TO DISCONNECT SWITCH.
ALL POWER SUPPLIED TO EACH CONNECTION POINT
MUST COMPLY WITH ALL LOCAL ELECTRIC CODES.
TO TEST INPUTS T7, T8, AND T9 A METER
CAPABLE OF READING DC VOLTAGES MUST
BE USED.
1.) SET METER TO READ DC VOLTAGE
2.) PLACE BLACK LEAD TO T2
3.) PLACE RED LEAD TO TERMINAL BEING TESTED
e.g. , PLACE RED LEAD TO T8 TO TEST DOOR SW.
4.) AN OPEN SWITCH WILL READ 4.7-5.3VDC
A CLOSED SWITCH WILL READ 0-1VDC
RWV
T4
DOOR SWITCH RELAY
RINSE AID SIGNAL RELAY
POWER ON RELAY
WASH MOTOR CONTACTOR
WASH MOTOR OVERLOAD
WASH MOTOR
ARC SUPPRESSOR
BOOSTER TANK CONTACTOR OR STEAM VALVE
BOOSTER TANK HIGH LIMIT (ELECTRIC HEAT ONLY)
DOOR SAFETY SWITCH, FRONT DOOR
DOOR SAFETY SWITCH, SIDE DOORS
DRAIN VALVE
TIMER BOARD FUSE
FLOAT SWITCH
TANK HEAT FUSES
TRANSFORMER FUSES
TANK HEAT CONTACTOR OR STEAM VALVE
TANK HEAT HIGH LIMIT
INTERVAL TIMER
RINSE TIME SELECT JUMPER
CYCLE SELECT JUMPER
CYCLE SELECT JUMPER
CYCLE LIGHT
MAIN POWER SWITCH
POWER SWITCH CIRCUIT BREAKER
RINSE WATER VALVE
LINE:120V TRANSFORMER
BOOSTER TANK THERMOSTAT
WASH TANK THERMOSTAT
IF CHANGE AND/OR REVISE MAKE SURE TO UPDATE
PART# 113142, SCHEMATIC PEEL-OFF LABEL
ELECTRIC HEAT ONLY
36
37
BC1
DV
SEE NOTE 2
ELECTRIC BOOSTER HEAT IF USED (SEE NOTE 3B)
L1
L2
L3
3
56
LOAD
4
L1
L2
L3
2
WHITE BASE
START
L1
1
LINE
CLOSED JUMPER SHOWN FROM SIDE
4.7KW
34
HC1
10 MINUTE
33
SEE NOTE 3A
L1
L2
L3
2
IT
55
PCB
BLACK JUMPER SHOWN CLOSED.
LIFT & REMOVE TO OPEN.
PRINTED CIRCUIT BOARD
L1
T1
1
E* - Energy Star Qualiÿed Product, starting with serial# D08016801
ELECTRIC TANK HEAT IF USED
40
39
JUMPER SETTINGS
JB1
JB2
JB3
MACHINE
SERIAL NUMBER
FUT
FUT
VERIFY THE MODEL AND SERIAL NUMBER OF THE DISHWASHER,
THE CIRCUIT BOARD PART NUMBER, AND THEN SET THE POSITION
OF THE JUMPERS (JB1, JB2, JB3) AS SHOWN IN THE TABLE BELOW.
27
1CR
2CR
3CR
1M
1MOL
1MTR
AS
BC1
BCHL
DS1
DS2
DV
F1
FSW
FUH
FUT
HC1
HCHL
IT
JB1
JB2
JB3
LT1
MPS
PCB
RWV
T1
TSBC
TSHC
L2
! IMPORTANT !
IMPROPER JUMPER SETTINGS WILL CAUSE ERRATIC MACHINE OPERATION.
1M
GND
L1
L1 L2 L3
ON SINGLE PHASE
MACHINES OMIT L3.
L1 L2 L3
PER LOCAL ELECTRICAL CODE
REV.
J
K
L
DESCRIPTION
REMOVED ARC SUPPRESSOR FROM DOOR SWITCH
CHANGED JUMPERS' CONFIGURATION (CS-676H)
CHANGED VENT FAN SWITCH OPTION
DATE
14DEC04
10/1/07
6JUN08
COIL
COMMON
CHAMPION DOOR MACHINE
DH1/B-E - STEAM/ELECTRIC - 1 & 3 PHASE
BY
JAM
JAM
JAM
DIAGRAM STATE
POWER OFF
DOORS CLOSED
TANKS EMPTY
END OF CYCLE
The Dishwashing Machine Specialists
B
701650
REV.
L
**