MATERIAL SAFETY DATA SHEET
PRODUCTS IDENTIFICATION :
UV FINISHED HARDWOOD PLYWOOD (CARB CERTIFIED II)
SYNONYMS:
NONE
TRADE NAME:
UV FANCY PLYWOODS (MAPLE / WALNUT / RED OAK / BIRCH )
DESCRIPTION:
THIS PANEL PRODUCT CONTAINS A HARDWOOD VENEER
FACE BONDED TO WOOD COMPONENTS SUCH AS OTHER
WOOD VENEER LUMBER OR VENEER STRIPS USING
UREA-FORMALDEHYDE RESIN. PRODUCTS HAVE ONE OR
TWO SIDES WITH UV FINISHING. THESE COATINGS ARE MADE
UP OF LLIGOMERS, MONOMERS, PHOTO INITIATORS &
EXTENDERS.
POTENTIAL AIRBORNE RELEASES:
THIS PRODUCT MAY RELEASE NO MORE THAN 0.05PPM
QUANITIES OF FORMALDEHYDE EMISSIONS PER THE CARB
PHASE II REQUIREMENTS. TPC 3 CERTIFIED.
MANUAL OR MECHANICAL CUTTING OR ABRASION PROCESSES
PERFORMED ON THE PRODUCTS CAN RESULT IN GENERATION
OF DUST.
PHYSICAL DATA:
BOILING POINT:
NOT APPLICABLE
SPECIFIC GRAVITY(H20-1):
<1
VAPOR DENSITY:
NOT APPLICABLE
% VOLATIES BY VOL:
0
MELTING POINT:
NOT APPLICABLE
VAPOR PRESSURE:
NOT APPLICABLE
SOLUBILITY IN H20(% BY WGT):
<0.1%
EVAPORATION RATE (BUTYL ACCIATE-1): NOT APPLICABLE
PH:
NOT APPLICABLE
APPEARANCE & ODOR:
LIGHT TO MEDIUM COLOR. COLOR & ODOR ARE DEPENDENT
UPON WOOD SPECIES.
THIS FACT SHEET IS FOR PRODUCTS THAT HAVE BEEN FINISHED (COATED OR LAMINATED, OR TREATED.
(FOR EXAMPLE, WITH UV FINISHING OR PRESERVATIVE OF FIRE RETARDANT)
FIRE & EXPLOSION DATA:
1
FLASH POINT:
NOT APPLICABLE
AUTO IGNITION TEMPERATURE;
NOT AVAILABLE(WILL DEPEND UPON DURATION OF
EXPOSURE TO HEAT SOURCE & OTHER VARIABLES)
EXPLOSIVE LIMITS IN AIR:
SEE BELOW UNDER “UNUSUSAL FIRE AND EXPLOSION
HAZARDS”
EXTINGUISHING MEDIA:
WATER CARBON DIOXIDE & SAND
SPECIAL FIRE FIGHTING PROCEDURES:
NONE
UNUSUAL FIRE & EXPLOSION HAZARDS:
SAWING, SANDING OR MACHINING CAN PRODUCE WOOD DUST
AS A BY PRODUCT, WHICH MAY PRESENT AN EXPLOSION
HAZARD IF A DUST CLOUD CONTACTS AN IGNITION SOURCE.
AN AIRBORNE CONCENTRATION OF 40 GRAMS OF DUST PER
CUBIC METER OF AIR IS OFTEN USED AS THE L.E.L. FOR WOOD
DUST.
REACTIVITY DATA:
CONDITIONS CONTRIBUTING TO
INSTABILITY:
INCOMPATIBILIITY:
STABLE UNDER NORMAL CONDITIONS
AVOID CONTACT WITH OXIDIZING AGENTS. AVOID OPEN
FLAME. PRODUCT MAY IGNITE IN EXCESS OF 400F.
HAZARDOUS DECOMPOSITION PRODUCTS: THERMAL AND/OR THERMAL OXIDATIVE DECOMPOSITION
CAN PRODUCE IRRITATING AND TOXIC FUMES & GASES,
INCLUDING CARBON MONOXIDE, HYDROGEN, CYANIDE,
ALDEHYDES, ORGANIC ACIDS & POLYNUCLEAR AROMATIC
COMPOUNDS.
HAZARDOUS POLYMERIZATION:
NOT APPLICABLE
HEALTH EFFECTS INFORMATION:
EXPOSURE LIMITS:
FORMALDEHYDE:
CARB PHASE II
0.05 PPM
WOOD DUST (ALL SOFT & HARD
WOODS EXCEPT WEST. RED CEDAR)
OSHA PEL-TWA
OSHA PEL-STEL
5 MG/M3
10 MG/M3
HEALTH EFFECTS INFORMATION (CONTINUED)
2
EYE CONTACT:
GASEOUS FORMALDEHYDE MAY CAUSE TEMPORARY IRRITAITON OR A
BURNING SENSATION. WOOD DUST CAN CAUSE MECHANAICAL IRRITATION.
SKIN CONTACT:
BOTH FORMALDEHYDE & VARIOUS SPECIES OF WOOD DUST MAY EVOKE
ALLERGIC CONTACT DERMATITS INSENSITIZED INDIVIDUALS.
INGESTION:
NOT LIKELY TO OCCUR.
INHALATION:
GASEOUS FORMALDEHYDE: MAY CAUSE TEMPORARY IRRITATION TO EYES
NOSE, THROAT. SOME REPORTS SUGGEST THAT FORMALDEHYDE MAY CAUSE
RESPIRATORY SENSITATION SUCH AS ASTHMA, AND THAT PER EXISTING
RESPIRATORY DISORDERS MAY BE AGGRIVATED BY EXPOSURE.
FORMALDEHYDE IS LISTED BY INTERNATIONAL AGENCY FOR RESEARCH ON
CANCER(LACR) AS A PROBABLE HUMAN CARCINOGEN THE NATIONAL
TOXICOLOGY PROGRAM(NTF) INCLUDES FORMALDEHYDE IN THE ANNUAL
REPORT ON CARCINOGENS. FORMALDEHYDE IS REGULATED BY OSHA AS A
POTENTIAL CANCER AGENT AND REGULATED BY CARB.
IN STUDIES INVOLVING RATS, FORMALDEHYDE HAD BEEN SHOWN TO CAUSE
NASAL CANCER AFTER LONG TERM EXPOSURE TO VERY HIGH
CONCENTRATIONS(14+PPM), FAR ABOVE THOSE NORMALLY FOUND IN THE
WORKPLACE USING THIS PRODUCT.
THE NATIONAL CANCER INSTITUTE(NCI) CONDUCTED AN EPIDEMIOLOGICAL
STUDY OF INDUSTRIAL WORKERS EXPOSED TO FORMALDEHYDE(PUBLISHED
JUNE 1986). THE NCI CONCLUDED THAT THE DATA PROVIDE LITTLE EVIDENCE
THAT MORTALITI FROM CANCER IS ASSOCIATED WITH FORMALDEHYDE
EXPOSURE AT THE LEVELS EXPERIENCED BY WORKERS IN THE STUDY.
WOOD DUST:
MAY CAUSE NASAL DRYNESS, IRRATATION AND OBSTRUCTION, COUGHING,
WHEEZING AND SNEEZING, SINUSITIS & PROLONGED COLDS HAVE ALSO BEEN
REPORTED. DEPENDING ON SPECIES MAY CAUSE RESPIRATORY
SENSITIZATION AND/OR IRRITATION. PROLONGED EXPOSURE TO WOOD DUST
HAS BEEN REPORTED BY SOME OBSERVES TO BE ASSOCIATED WITH NASAL
CANCER. WOOD DUST IS NOT LISTED AS A CARCINOGEN BY IARC, OR NTP, OR
OSHA. THE POSSIBLE BUILDING OF FORMALDEHYDE GAS PARTICULARLY
WHEN HIGH TEMPERATURES OCCUR.
DRILLING, SAWING, SANDING OR MACHINING WOOD PRODUCTS GENERATES
WOOD DUST, A SUBSTANCE KNOWN TO THE STATE OF CALIFORNIA TO CAUSE
CANCER. HIGHLY ADVISED TO AVOID INHALING WOOD DUST OR USE A DUST
MASK OR OTHER SAFEGUARDS FOR PERSONAL PROTECTION. CALIFORNIA
HEALTH AND SAFETY CODE SECTION 25249.6.
PRECAUTIONS, SAFE HANDLING:
3
FORMALDEHYDE:
PROVIDE ADEQUATE VENTILATION TO REDUCE THE
POSSIBLE BUILDING OF FORMALDEHYDE GAS,
PARTICULARLY WHEN HIGH TEMPERATURES OCCUR.
WOOD DUST:
AVOID DUSTY CONDITIONS AND PROVIDE GOOD
VENTILATION.
GENERALLY APPLICABLE CONTROL MEASURES:
VENTILATION:
PROVIDE ADEQUATE GENERAL AND LOCAL EXHAUST
VENTILATION TO KEEP AIRBORNE CONTAMINANT
CONCENTRATION LEVELS BELOW THE OSHA PEL.
PERSONAL PROTECTIVE EQUIPMENT:
WEAR GOGGLES OR SAFETY GLASSES WHEN MANUFACTURING
OR MACHINING THE PRODUCT. WEAR NOSH/MSHA APPROVED
RESPIRATOR WHEN THE ALLOWABLE EXPOSURE LIMITS MAY
BE EXCEEDED. OTHER PROTECTIVE EQUIPMENT SUCH AS
GLOVES AND OUTER GARMENTS MAY BE NEEDED DEPENDING
ON DUST CONDITIONS.
EMERGENCY & FIRST AID PROCEDURES:
EYES:
FLUSH EYES WITH LARGE AMOUNTS OF WATER REMOVE TO
FRESH AIR.
IF IRRITATION PERSISTS, GET MEDICAL
ATTENTION.
SKIN:
WASH AFFECTED AREAS WITH SOAP AND WATER. GET
MEDICAL ADVISE IF RASH OR PERSISTENT IRRITATION OR
DERMATITIS OCCURS.
INHALATION:
REMOVE TO FRESH AIR, GET MEDICAL ADVICE IF PERSISTENT
IRRITATION, SEVERE COUGHING OR BREATHING DIFFICULTY
OCCURS.
INGESTION:
NOT APPLICABLE
IMPORTER NAME & ADDRESS
DATE
4
SUPERSEDED DATA
PREPARED BY
AMERICAN PACIFIC PLYWOOD INC.
414 FIRST STREET
SOLVANG, CA 93463
01-05-11
N/A
STAFF
IMPORTANT: THE INFORMATION AND DATA HEREIN ARE BELIEVED TO BE ACCURATE
AND HAVE BEEN COMPILED FROM SOURCES BELIEVED TO BE RELIABLE. IT IS OFFERED
FOR YOUR CONSIDERATION, INVESTIGATION AND VERIFICATION. AMERICAN PACIFIC
MAKES NO WARRANTY OF ANY KIND, EXPRESS OR IMPLIED CONCERNING THE
ACCURACY OR COMPLETENESS OF THE INFORMATION AND DATA HEREIN. AMERICAN
PACIFIC WILL NOT BE LIABLE FOR CLAIMS RELATING TO ANY PARTYS USE OFF OR
RELIANCE ON INFORMATION AND DATA CONTAINED HEREIN REGARDLESS OD
WHETHER IT IS CLAIMED THAT THE INFORMATIONAND DATA ARE INACCURATE,
INCOMPLETE OR OTHERWISE MISLEADING. IT IS INCUMBENT UPON THE USER TO
OBTAIN THE MOST UP TO DATE INFORMATION.
5