MATERIAL SAFETY DATA SHEET
PRODUCT: JOHNNY WIPE TYRE SHINE
Date of Issue: Oct. 2011
1. IDENTIFICATION OF CHEMICAL PRODUCT AND SUPPLIER
PRODUCT IDENTIFICATION:
Product Names:
JOHNNY WIPE TYRE SHINE
Supplier’s Product Code: na
Other Names:
Recommended Use:
Nil
Tyre shine
Formula:
Chemical family
Silicone/hydrocarbon liquid
Supplier:
Address:
Telephone Number:
Emergency Telephone:
ABN:
Johnny Wipe Enterprises Pty Ltd
401 Pacific Hwy.,
Heatherbrae, NSW 2324
(02) 4983 1164
O438 858 918 or Poisons Information Centre 131126
35 077 106 631
2. HAZARDS IDENTIFICATION
HAZARDOUS SUBSTANCE. DANGEROUS GOODS
Classified as hazardous according to the criteria of NOHSC.
Harmful
Hazard Category:
R38 Irritating to skin. R48/20 Harmful: danger of serious damage to health by
Risk phrases:
prolonged exposure through inhalation. R62 Possible risk of impaired fertility.
R65 Harmful: may cause lung damage if swallowed. R67 vapours may cause
drowsiness and dizziness.
S9 Keep container in a well-ventilated place. S16 Keep away from sources of
Safety phrases:
ignition – No smoking. S23 Do not breathe gas/fumes/vapour/spray S24 Avoid
contact with skin. S43A In case of fire use sand, earth, chemical powder or foam.
S62 If swallowed do not induce vomiting seek medical attention immediately and
show this MSDS or label.
5
SUSDP Classification:
Class 3
ADG Classification:
3. COMPOSITION/INFORMATION ON INGREDIENTS
Synonyms:
Nil
Appearance:
Clear liquid
Ingredients:
Chemical Name, CAS No
Silicon fluid
Hydrocarbon solvent 64742-49-0
Proportion
10 - <30%
>60%
Risk Phrases
R38 R48/20 R62 R65 R67
All the constituents of this material are listed on the Australian Inventory of Chemical Substances (AICS).
Page 1 of 4
JOHNNY WIPE TYRE SHINE
Date of Issue: Oct. 2011
4. FIRST AID MEASURES
Poison Information Centres in each state can provide additional assistance for scheduled poisons. Phone 131126 from
anywhere in Australia.
Ingestion:
Do NOT induce vomiting. Never give anything by mouth to an unconscious person. Seek medical advice
immediately, show doctor MSDS
Eye Contact:
Immediately flush the contaminated eye(s) with plenty of water for 15 minutes, holding the eyelid(s) open. If
irritation persists seek medical attention.
Skin Contact:
If product contacts skin wash well with soap and water. Seek medical advice if redness, swelling, itching or burning
persists.
Inhalation:
Immediately remove affected victim from exposure. Administer artificial respiration if breathing has stopped. Seek
medical advice immediately if irritation, cough, shortness of breath or other respiratory problems occur.
Other First Aid:
Consult a physician and/or Poison Information Centre.
Notes to physician:
Treat symptomatically.
5. FIRE FIGHTING MEASURES
Specific hazards:
Combustible material
Fire fighting further advice:
Flammable hydrocarbon liquid.
Suitable Extinguishing media:
Use sand, earth, water fog, foam, carbon dioxide or dry chemical.
6. ACCIDENTAL RELEASE MEASURES
Small Spills: Contain using, paper, sand or diatomaceous earth. Collect and seal in properly labelled drums. Wash
remaining area with water.
Large Spills:
PRECAUTIONS Restrict access to area. Clear area of unprotected personnel. Remove chemicals which may react
with the spilled material. Spills are slippery.
CLEANUP Contain spill or leak by dyking with inert material, such as sand or diatomaceous earth. Do not allow
entry into sewers or waterways. Collect and seal in properly labelled drums. Wash area with water.
DISPOSAL Federal, state and local regulations should be reviewed prior to disposal.
7. HANDLING AND STORAGE
HANDLING: Avoid inhalation of fumes or vapour. Avoid contact with skin and eyes.
STORAGE CONDITIONS: Store in suitably labelled containers. Keep containers closed when not in use or when empty.
Protect from damage. Recommended storage temp. 5C-35C.
8. EXPOSURE CONTROLS/PERSONAL PROTECTION
Exposure Standards:
No values assigned by NOHSC Australia.
Engineering Controls:
equipment.)
Use in well-ventilated area. Use local exhaust if necessary (explosion-proof ventilation
Personal Protection:
Avoid contact with skin and eyes - wear impervious chemical gloves and chemical safety
glasses or goggles. Avoid inhalation, if risk exists wear an organic vapour respirator meeting the requirements of AS1715
and AS 1716.
9. PHYSICAL & CHEMICAL PROPERTIES
Appearance:
Clear colourless liquid
Odour:
Solvent odour
Melting Point:
Not available
Page 2 of 4
JOHNNY WIPE TYRE SHINE
Specific Gravity:
Vapour Pressure:
Vapour Density:
Boiling Point/Range:
Flash Point:
Explosive Limits:
pH:
Solubility in water:
Date of Issue: Oct. 2011
approx 0.8
Not available
Not available
75-115C approx. (solvent)
Low -15C (solvent)
between 1and 7 vol%
Not applicable
Insoluble
10. STABILITY AND REACTIVITY
INCOMPATIBILITY – Do not mix with other materials.
HAZARDOUS DECOMPOSITION PRODUCTS Oxides of carbon, CO ,CO2
HAZARDOUS POLYMERIZATION
Does not occur
CORROSIVITY TO METALS
Non-corrosive
EXPLOSION DATA - SENSITIVITY TO MECHANICAL IMPACT
Not applicable
EXPLOSION DATA - SENSITIVITY TO STATIC CHARGE
Not applicable
FIRE HAZARD COMMENTS
Will burn or support combustion.
FIRE EXTINGUISHING AGENTS
Use sand, earth, water fog, foam, carbon dioxide or dry chemical.
FIRE FIGHTING PROCEDURES
As for flammable liquid
COMBUSTION PRODUCTS
Oxides of carbon, CO ,CO2
11. TOXICOLOGICAL INFORMATION
Acute Effects:
Ingestion:
Not a likely route of entry during normal use. Low toxicity. Liquid ingested into respiratory system during ingestion or
from vomiting may cause bronchopneumonia or pulmonary edema.
Eye contact:
May cause eye irritation and discomfort.
Skin contact:
Low order of toxicity. Skin contact may cause irritation. Frequent or prolonged contact may cause defatting of the skin
leading to drying, cracking or dermatitis.
Inhalation:
Vapour may be irritating to eyes and respiratory tract and may cause headaches, dizziness and have effect on central
nervous system.
Long term Effects:
No data available
Toxicity Data:
No data currently available.
12. ECOLOGICAL INFORMATION
No data is currently available. Avoid contaminating waterways. Expected to be toxic to aquatic organisms.
13. DISPOSAL CONSIDERATIONS
Refer to State Land Waste Management Authority.
14. TRANSPORT INFORMATION
UN No:
Proper Shipping Name:
Class:
Packing Group:
Hazchem Code:
EPG
Segregation Dangerous Goods
3295
Hydrocarbon Liquid N.O.S.
3
II
3WE
3A1
As per ADG
Page 3 of 4
JOHNNY WIPE TYRE SHINE
Date of Issue: Oct. 2011
15. REGULATORY INFORMATION
Classified as hazardous according to the criteria of NOHSC, Schedule 5 per SUSDP, Dangerous good according to ADG
code.
R-phrases:
R38 Irritating to skin. R48/20 Harmful: danger of serious damage to health by prolonged exposure
through inhalation. R62 Possible risk of impaired fertility. R65 Harmful: may cause lung damage if swallowed. R67
vapours may cause drowsiness and dizziness.
S-phrases:
S9 Keep container in a well ventilated place. S16 Keep away from sources of ignition – No smoking.
S23 Do not breathe gas/fumes/vapour/spray S24 Avoid contact with skin. S43A In case of fire use sand, earth, chemical
powder or foam. S62 If swallowed do not induce vomiting seek medical attention immediately and show this MSDS or
label.
16. OTHER INFORMATION
References:
(1) National Code of Practice for the preparation of MSDS [NOHSC:2011(2003), (2) List of Designated Hazardous
Substances [NOHSC:10005:1999] (3) ADG Code 6 th Edition (4) Manufacturer’s MSDS
Contact Point: Company Manager Tel (02) 4983 1164
DISCLAIMER: All information given in this data sheet and by the company's technical staff is compiled from the best information currently available to the company. The
company accepts no responsibility whatsoever for its accuracy or for any results which may be obtained by customers. Any customer who relies upon any advice or information
given in this data sheet by the company or by its technical staff does so entirely at its own risk, and the company will not be liable for any loss or damage thereby suffered
notwithstanding any want of care on the part of the company or its staff in compiling or giving the advice or information.
Page 4 of 4