VIRGINIA D10e DEGREASING SOLVENT
Material Safety Data Sheet
SECTION I - COMPANY IDENTIFICATION
PRODUCT: D10e - Degreasing Solvent Aerosol
CAT. NO.: D10e14
MANUFACTURED BY:
Virginia KMP Corporation
4100 Platinum Way
Dallas, Texas 75237
TELEPHONE NUMBERS:
Office:
1-(214) 330-7731
Emergency Only: 1-(800) 424-9300
SECTION II - HAZARDOUS INGREDIENTS
OSHA Hazardous Components (29 CFR 1910.1200)
EXPOSURE LIMITS: 8 HR. TWA
OSHA PEL
ACGIH TLV
*Medium aliphatic solvent naphtha (CAS# 64742-88-7)
Propylene glycol propyl ether (CAS# 1569-01-3)
n-Methyl pyrrolidone (CAS# 872-50-4)
Monoethanolamine (CAS# 141-43-5)
*Aromatic hydrocarbon mixture exact composition may vary.
100 ppm
None established
None established
3 ppm
100 ppm recommended
25 ppm
100 ppm recommended
3 ppm
SECTION III - HAZARDS IDENTIFICATIONS
EMERGENCY OVERVIEW:
WARNING! Flammable Aerosol.
Irritating to eyes, skin, mucous membranes, and respiratory tract.
POTENTIAL HEALTH EFFECTS:
INHALATION: Irritating to respiratory tract, may cause difficult breathing on prolonged exposure.
EYE CONTACT: Vapors and liquids irritating to eyes.
SKIN CONTACT: Liquid irritant to skin. Product may be absorbed on prolonged contact.
INGESTION: Irritating to internal tract, may cause nausea and vomiting.
CHRONIC Effects: UNKNOWN
NOTE: Studies on test animals of n-Methyl pyrrolidone have been reported to contribute to effects of fertility (fetotoxicity).
CARCINOGENICITY: LISTED IN NTP? NO
IARC? NO
OSHA Regulated? NO
SECTION IV - FIRST AID MEASURES
INHALATION: Remove to fresh air. If not breathing, apply artificial respiration. Keep victim warm. Seek medical advice.
EYE CONTACT: Flush with large amounts of running water for 15 minutes occasionally lifting lower and upper eyelids. Seek medical advice.
SKIN CONTACT: Wash exposed area with soap and water. Remove contaminated clothing. Seek medical advice if symptoms develop.
INGESTION: Give water. Do NOT induce vomiting. Aspiration into lungs may cause chemical pneumonia. Seek immediate medical attention.
Do not give anything by mouth to an unconscious person. If spontaneous vomiting occurs, keep head below hips.
SECTION V - FIRE FIGHTING MEASURES
FLAMMABILITY: (per the USA Flame Projection Test (aerosols)): Flammable
FLASHPOINT (TEST METHOD) (non-aerosol i.e. base stock):
102 oF (CC)
FLAMMABLE LIMITS (non-aerosol i.e. base stock):
LOWER: 0.8%
AUTOIGNITION TEMPERATURE(non-aerosol i.e. base stock): 520 oF
UPPER: 9.5%
GENERAL HAZARD: WARNING! Product under pressure, may explode from excessive heat. Water may be ineffective to fight fire. Toxic gases
may be produced in fire.
FIRE FIGHTING INSTRUCTIONS: Do not enter without full bunker of equipment including self contained breathing apparatus. Stay upwind, keep all
personnel away. Cool fire exposed containers with water.
EXTINGUISHING MEDIA: Use carbon dioxide, alcohol foam, water spray, water fog.
HAZARDOUS COMBUSTION PRODUCTS: Smoke, fumes, oxides of carbon, and nitrogen compounds.
SECTION VI - ACCIDENTAL RELEASE MEASURES
Isolate hazard area. Keep unnecessary and unprotected personnel away. Clean up spills and leaks immediately to prevent soil and water
contamination.
LAND SPILL: Absorb spill with inert, non-combustible material, then place in a chemical waste container.
WATER SPILL: Product is a floating hazard. If possible try to contain floating material. Collect and store in a chemical waste container.
SECTION VII - HANDLING AND STORAGE
HANDLING:
STORAGE:
Use with adequate ventilation. Ground and bond containers when transferring material. Use spark-proof tools. Avoid skin/eye
contact and breathing vapors. Empty containers retain product residue (liquid and/or vapors). DO NOT CUT, WELD, BRAZE,
SOLDER, DRILL, OR EXPOSE TO HEAT, FLAME, SPARKS, STATIC ELECTRICITY.
Store in a cool, dry place away from heat, ignition sources, oxidizers, and strong acids.
VIRGINIA D10e DEGREASING SOLVENT
SECTION VIII - EXPOSURE CONTROLS/ PERSONAL PROTECTION
ENGINEERING CONTROLS: Adequate ventilation to control vapor accumulation.
PERSONAL PROTECTION:
If TLV exceeded, NIOSH vapor mask recommended. Wear chemical goggles or full face shield and
chemical impervious apron to protect from splashing. Wear chemical impervious gloves. Wash clothing before
reuse.
SECTION IX - PHYSICAL AND CHEMICAL PROPERTIES
For base stock:
VAPOR PRESSURE: <10 mmHg @ 20 oC
SPECIFIC GRAVITY: 0.75 - 0.82
SOLUBILITY IN WATER: Miscible
pH: NA
BOILING POINT: 310 oF - 340 oF
APPEARANCE & ODOR: Water-white liquid with mild amine odor.
VAPOR DENSITY (Air=1) : >2
EVAPORATION RATE (N-BUTYL ACETATE=1): <1
VOC (G/L): 820.4
FREEZING POINT: ND
SECTION X - STABILITY AND REACTIVITY
STABILITY: Stable
CONDITIONS TO AVOID: Avoid excessive heat, ignition sources, and flames. Isolate from oxidizers and strong acids.
MATERIALS TO AVOID: Isolate from strong oxidizers such as permanganates, chromates & peroxides.
HAZARDOUS DECOMPOSITION PRODUCTS: Carbon Monoxide, Carbon Dioxide, Nitrogen Oxide vapors from burning.
HAZARDOUS POLYMERIZATION: Will not occur.
SECTION XI - TOXICOLOGICAL INFORMATION
n-Methyl pyrrolidone
LD50: 3914 mg/kg (oral-rat)
LD50: 8000 mg/kg (dermal-rabbit)
LD50: 3500 mg/kg (oral-rabbit)
Propylene glycol propyl ether
LD50: 2504 mg/kg (oral-rat)
LD50: 3550 mg/kg (dermal-rabbit)
SECTION XII - ECOLOGICAL INFORMATION
No Data Available.
SECTION XIII - DISPOSAL CONSIDERATIONS
Classification of waste required before disposal. Follow all local, state,
and federal regulations.
SECTION XIV - TRANSPORTATION INFORMATION
PROPER SHIPPING NAME: Consumer Commodity, ORM-D
HAZARD CLASS: Not Applicable
IDENTIFICATION NUMBER: Not Applicable
DOT Emergency Guide #: Not Applicable
Reportable Quantity (RQ): Not Applicable
International: Aerosol Dispensers, 9 UN1950, IMDG 9022
SECTION XV - REGULATORY INFORMATION
TSCA (Toxic Substance Control Act): Components of this product are listed on the TSCA Inventory.
CERCLA (Comprehensive Environmental Response, Compensation and Liability Act): None
We recommend you contact local authorities for other reporting requirements.
SARA TITLE III (Superfund Amendments and Reauthorization Act): Medium Aliphatic Solvent Naphtha 70-75%, Propylene Glycol Propyl Ether
20-25%
311/312 Hazard Categories: Acute, Ignitable
313 Reportable Ingredients: NONE
CALIFORNIA PROPOSITION 65: This product contains no chemicals known to the State of California to cause cancer or reproductive toxicity.
SECTION XVI - OTHER INFORMATION
State Right-to-Know Programs: Massachusetts, Pennsylvania, New Jersey
NFPA Ratings
Health:
Flammability:
Reactivity:
2
2
0
Prepared by: Virginia KMP Corporation
revised 2/16/2016
This information is furnished without warranty, expressed or implied, except that it is accurate to the best knowledge of Virginia KMP. The data on
this sheet related only to specific material designated here in. Virginia KMP assumes no legal responsibility for use or reliance upon these data.
VIRGINIA D10e DEGREASING SOLVENT
HMIS Protective Equipment: X
See your supervisor
Prepared by: Virginia KMP Corporation
revised 2/16/2016
This information is furnished without warranty, expressed or implied, except that it is accurate to the best knowledge of Virginia KMP. The data on
this sheet related only to specific material designated here in. Virginia KMP assumes no legal responsibility for use or reliance upon these data.