MATERIAL SAFETY DATA SHEET
PRODUCT NAME: LIQUID BRUSH
PRODUCT CODE: 01-1-111
MANUFACTURER’S NAME:
DATE PRINTED: 1/7/2010
AMERICLEAN, INC.
4100 S. 76TH CIRCLE
OMAHA, NE 68127
888-593-9229
EMERGENCY PHONE:
SECTION I – HAZARDOUS INGREDIENTS/ SARA III INFORMATION
REPORTABLE COMPONENTS
CAS#
WEIGHT % TLV/PEL TWA STEL/CEILING SKIN
SODIUM HYDROXIDE
1310-73-2
1-3%
2mg/m3
N/A
2mg/m3
SODIUM ETHLENEDIAMINA
TETRAACETATE
64-02-8
1-3%
N/A
N/A
N/A
SODIUM NITRILOTRIACETATE
5064-31-2
1-3%
N/A
N/A
N/A
NONYLPHENOLPOLY(OXYETHYLENE) 9016-45-2
1-3%
N/A
N/A
N/A
*Sodium Hydroxide is a SARA TITLE III SECTION 304 materials subject to reporting by user within the
manufacturing section.
SECTION II – PHYSICAL / CHEMICAL CHARACTERISTICS
BOILING POINT: 212
SPECIFIC GRAVITY: (H2O=1)
VAPOR DENSITY: (AIR=1) >1
EVAPORATION RATE: >1
PH CONCENTRATE: 13.2
SOLUBILITY IN WATER: 100%
APPEARANCE: GREEN
1.09
FREEZE POINT: 30F/-1C
PHYSICAL STATE: LIQUID
VAPOR PRESSURE: 17mmHg
1% PH DILUTION:
ODOR:
11.7
CITRUS
SECTION III – FIRE AND EXPLOSION HAZARD DATA
FLASH POINT: NONE
METHOD USED: T.C.C.
FLAMMABLE LIMITS IN AIR BY VOLUME – LOWER: N/A
UPPER: N/A
EXTINGUISHING MEDIA: WATER SPRAY, WATER FOG, FOAM
HAZARDOUS COMBUSTION BY-PRODUCTS: NONE
SPECIAL FIRE FIGHTING EQUIPMENT: FIREFIGHTERS SHOULD WEAR WATERPROOF PROTECTIVE CLOTHING.
UNUSUAL FIRE AND EXPLOSION HAZARDS: NONE
SECTION IV – REACTIVITY DATA
STABILITY: STABLE, EXCEPT AS SPECIFIED ABOVE.
CONDITIONS TO AVOID: EXTREME HIGH HEAT.
INCOMPATIBILITY (MATERIALS TO AVOID): STRONG ACIDS
HAZARDOUS DECOMPOSITION OR BY-PRODUCTS: NONE
HAZARDOUS POLYMERIZATION: DOES NOT OCCUR.
SECTION V – HEALTH HAZARD DATA
PRIMARY ROUTE(S) OF ENTRY INTO BODY: SKIN CONTACT, INGESTION
ACUTE EFFECTS: EYES: REDNESS, WATERING. SKIN: REDNESS, IRRITATION. INHALATION:
IRRITATION, COUGHING. INGESTION: BURNING SENSATION, NAUSEA.
CHRONIC EFFECTS: NONE KNOWN
EMERGENCY FIRST AID PROCEDURES:
SKIN: WASH WITH WATER FOR FIFTEEN MINUTES, REMOVE CONTAMINATED CLOTHING. IF IRRITATION
OCCURS, GET MEDICAL ATTENTION.
EYES: FLUSH WITH CLEAN WATER FOR FIFTEEN MINUTES, LIFTING UPPER AND LOWER LIDS, SEEK
IMMEDIATE MEDICAL ATTENTION.
INHALATION: REMOVE TO FRESH AIR IMMEDIATELY, IF SYMPTOMS PERSIST, GET IMMEDIATE MEDICAL
ATTENTION.
INGESTION: DO NOT INDUCE VOMITING, IF CONSCIOUS, GIVE LARGE AMOUNTS OF WATER AND FRUIT
JUICE, AND SEEK IMMEDIATE MEDICAL ATTENTION.
NOTE TO PHYSICIAN: CONTAINS SODIUM HYDROXIDE
SECTION VI – PRECAUTIONS FOR SAFE HANDLING
STORAGE: STORE AT TEMPERATURES BELOW 120 F. DO NOT ALLOW TO FREEZE.
HANDLING: WEAR PROPER GLOVES, BOOTS, EYE AND FACE PROTECTION WHEN HANDLING.
PRECAUTIONARY LABELING: CORROSIVE.
STEPS TO BE TAKEN IF MATERIAL IS SPILLED: SMALL LEAK OR SPILL – NEUTRALIZE WITH VINEGAR OR
CITRIC ACID. LARGE LEAK OR SPILL – MOP UP EXCESS. NEUTRALIZE WITH VINEGAR OR CITRIC ACID.
COLLECT SOLUTION IN CONTAINERS FOR DISPOSAL. SPILL REPORTABLE QUANTITY –20,000 POUNDS OR
MORE.
WASTE DISPOSAL METHOD: DISPOSE OF ACCORDING TO APPLICABLE STATE, FEDERAL AND LOCAL
LAWS.
OTHER PRECAUTIONS: EMPTY CONTAINERS – TRIPLE RINSE.
ENVIRONMENTAL TOXICITY DATA: BIODEGRADABLE.
SECTION VII – OCCUPATION CONTROL PROCEDURES
VENTILATION: LOCAL EXHAUST.
PERSONAL PROTECTION:
RESPIRATOR TYPE- NONE REQUIRED IF CONCENTRATION IS BELOW TLV/PEL. OTHERWISE, USE NIOSH
APPROVED CCROV OR BETTER RESPIRATOR.
GLOVES – CHEMICAL RESISTANT GLOVES RECOMMENDED
EYE PROTECTION – CHEMICAL SPLASH GOGGLES.
SECTION VIII – SHIPPING INFORMATION
D.O.T. CLASSIFICATION: CORROSIVE LIQUID, N.O.S (CONTAINING SODIUM HYDROXIDE)
CLASS: 8 UN1760 PG II
SECTION IX – PRECAUTIONARY STATEMENT
WARNING: THE INFORMATION CONTAINED IN THIS MSDS IS BASED ON THE DATA AVAILABLE TO US
FROM SOURCES WE BELIEVE TO BE RELIABLE. NO WARRANTY OR GUARANTY EXPRESSED OR IMPLIED
IS MADE REGARDING THE ACCURACY OF THIS DATA OR THE RESULTS OBTAINED FROM THE RELIANCE
ON THIS DATA. THE MANUFACTURER ASSUMES NO RESPONSIBILITY FOR INJURY FROM THE USE OF
THIS PRODUCT. TO BE SAFE – ALL PERSONS WHO MAY BE EXPOSED TO THIS PRODUCT SHOULD READ
THIS SAFETY INFORMATION. THIS IS REQUIRED BY FEDERAL LAW.