MAY.2002
BR-1180
SERVICE NOTES
Issued by RJA
TABLE OF CONTENTS
SPECIFICATIONS.............................................................2
LOCATION OF CONTROLS ..........................................4
LOCATION OF CONTROLS PARTS LIST ..................5
EXPLODED VIEW 1 .........................................................6
EXPLODED VIEW 2 .........................................................7
EXPLODED VIEW 3 .........................................................8
EXPLODED VIEW PARTS LIST .....................................9
PARTS LIST......................................................................10
CHECKING THE VERSION NUMBER.......................15
USERS DATA SAVE AND LOAD................................15
RESTORING THE FACTORY SETTINGS...................16
SYSTEM SOFTWARE UPDATE PROCEDURE .........17
TEST MODE.....................................................................17
BLOCK DIAGRAM.........................................................20
CIRCUIT BOARD(MAIN) .............................................22
CIRCUIT DIAGRAM(MAIN 1/4) ................................24
CIRCUIT DIAGRAM(MAIN 2/4) ................................26
CIRCUIT DIAGRAM(MAIN 3/4) ................................28
CIRCUIT DIAGRAM(MAIN 4/4) ................................30
CIRCUIT BOARD(SW SHEET ASSY) ..........................32
CIRCUIT BOARD(ANALOG).......................................34
CIRCUIT DIAGRAM(+5V BOARD).............................36
CIRCUIT DIAGRAM(SW) .............................................38
ERROR MESSAGES ........................................................40
CDI-BR-1..........................................41
SPECIFICATIONS...........................................................41
PARTS LIST......................................................................42
INSTALLING THE CDI-BR-1........................................43
The wiring exchange method ........................................44
Copyright © 2002 ROLAND CORPORATION
All rights reserved. No part of this publication may be reproduced in any form without the written permission
of ROLAND CORPORATION.
17058069E0
Printed in Japan (0800) (NB)
MAY.2002
SPECIFICATIONS
Recommended Load Impedance
LINE OUT jack: 20 k ohms or greater
BR-1180: Digital Recording Studio
BR-1180CD: Digital Recording Studio (built-in CD-R/RW drive)
Tracks
Track: 10
*
Maximum Useful Capacity/Recording Time
Internal Hard Disk: 20 G bytes
Recording time
60 hours
120 hours
160 hours
190 hours
240 hours
(conversion in 1 track, times approximate)
*
*
Residual Noise Level
LINE OUT jack: -87dBu or less
V-Track: 80 (8 V-Tracks per each Track)
Up to 2 tracks can be recorded simultaneously, and up to 10 tracks can be played
back simultaneously.
Data type
LIN
MT1
MT2
LV1
LV2
PHONES jack: 8-50 ohms
The above-listed recording times are approximate. Times may be slightly shorter
depending on the number of songs and size of imported loop phrase that were
created.
The above number is the total for all the tracks that are used. If each of the ten
tracks contain an equal amount of data, the length of the resulting song will be
approximately 1/10 of the above.
(INPUT SELECT: GUITAR/BASS, input terminated with 1 k?, INPUT SENS:
CENTER, IHF-A, typ.)
Interface
DIGITAL OUT: S/PDIF (Optical type)
Display
64 x 40mm (Backlit LCD)
Connectors
MIDI IN connector
MIDI OUT connector
DIGITAL OUT connector (optical type)
FOOT SW jack (1/4 inch phone type)
EXP PEDAL jack (1/4 inch phone type)
PHONES jack (Stereo 1/4 inch phone type)
LINE OUT jack L/R (RCA Phono type)
LINE IN jack L/R (RCA Phono type)
MIC 1, 2 jack (TRS balanced, 1/4 inch phone type)
Signal Processing
AD Conversion: 24 bit, AF Method (Guitar/Bass)
24 bit, AF Method (Mic)
24 bit, ∆∑ Modulation (Line)
24 bit, ∆∑ Modulation (Simul)
DA Conversion: 24 bit, ∆∑ Modulation
Internal Processing: 24 bit (digital mixer section)
MIC 1, 2 connector (XLR balanced)
GUITAR/BASS jack (1/4 inch phone type)
Power Supply
DC 12 V; Supply AC Adaptor (Roland PSB-3U)
Power Consumption
Recording Data: 16 bit linear (data type: LIN)
3A
Sample Rate
Dimensions
44.1 kHz
460 (W) x 273 (D) x 87 (H) mm
Frequency Response
20 Hz-20 kHz (+1/-3 dB)
Total Distortion
18-1/8 (W) x 10/3/4 (D) x 3-7/16 (H) mm
Weight
BR-1180CD: 3.85 kg/8 lbs 8 oz
BR-1180: 3.50 kg/7 lbs 12 oz
(Excluding AC Adaptor)
0.15 % or less
(INPUT SENS : CENTER, 1 kHz at nominal output level, data type: LIN)
Accessories
Nominal Input Level (Variable)
AC Adaptor: PSB-3U (#02900423)
GUITAR/BASS jack: -10 dBu
AC CORD 100V(#00894367)
MIC 1, 2 jack: -40 dBu
120V(#00894378)
LINE jack: -10 dBu
230V(#00894389)
240VE(#00907001)
Input Impedance
GUITAR/BASS jack: 1 M ohms
MIC 1, 2 jack (TRS): 2.2 k ohms (HOT-COLD)
1.1 k ohms (HOT-GND, COLD-GND)
MIC 1, 2 jack (XLR): 2.2 k ohms (HOT-COLD)
1.1 k ohms (HOT-GND, COLD-GND)
LINE IN jack: 50 k ohms
240VA(#23495124)
Owner’s Manual Japanese(#72018489)
English(#72018367)
Roland Service (information sheet)(#********)
DISCRETE DRUMS (CD-ROM(#********); BR-1180CD only)
Options
CD-R/RW drive (for BR-1180): CDI-BR-1
Nominal Output Level
LINE OUT jack: -10 dBu
Expression Pedal: EV-5 (Roland)
Foot Switch: FS-5U
Pedal Switch: DP-2 (Roland)
Output Impedance
*
0dBu = 0.775V rms
LINE OUT jack: 2 k ohms
*
In the interest of product improvement, the specifications and/or appearance of
this unit are subject to change without prior notice.
PHONES jack: 100 ohms
2
BR-1180
3
MAY.2002
LOCATION OF CONTROLS
fig.panel_top-rear.eps
[TOP]
l
b n
z
a
k
w
q
g
r
e
p
h
c
v
s
f
p
s
a
d
p
t
y
o
u x
y
i
uj
[REAR]
3
1
; 9 8
4
7
6
1
5
4
2
;
BR-1180
LOCATION OF CONTROLS PARTS LIST
No.
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
PART CODE
00569278
01239890
13449258
02900478
01340412
02900467
02568778
13429825
02900312
22365714
02896767
02896756
02011456
01340290
22485303
01905467
00900190
01340290
01234090
01340290
02013090
01340290
01904178
01670512
01340290
02123467
01340290
01783945
01340290
15029348
01904112
00900145
01340290
01904112
00900156
01340290
01904112
00900189
01340290
00904245
01340290
00904256
01340290
02457512
02896701
22495277
01340290
01904112
01902289
01677312
00900167
01340290
01904112
22495271
01340290
22355334
02896789
17041159
02896790
02457512
02896712
01904189
15039237
15029347
PART NAME
6.5MM JACK
XLR JACK
6.5MM JACK
RCA(PIN JACK)
P R-KNOB
9M/M ROTARY POTENTIOMETER
IC (OPTICAL CONNECTOR)
MIDI CONNECTOR
DC JACK
CORD HOOK
BOTTOM COVER
TOP CASE
Y S-KEYTOP
TACT SWITCH
D R-KNOB(ALPHA-DIAL)
ROTARY ENCODER
D S-KEYTOP
TACT SWITCH
D T-KEYTOP
TACT SWITCH
F C-KEYTOP
TACT SWITCH
LED (CLR)
F C-KEYTOP
TACT SWITCH
F C-KEYTOP
TACT SWITCH
N S-KEYTOP
TACT SWITCH
LED (GREEN)
LED
D S-KEYTOP
TACT SWITCH
LED
D S-KEYTOP
TACT SWITCH
LED
D S-KEYTOP
TACT SWITCH
D S-KEYTOP
TACT SWITCH
D S-KEYTOP
TACT SWITCH
J R-KNOB
9M/M ROTARY POTENTIOMETER
D S-KEYTOP
TACT SWITCH
LED
U S-KNOB
POTENTIOMERTER (SLIDE)
D S-KEYTOP
TACT SWITCH
LED
DS-KEYTOP
TACT SWITCH
FOOT MKS
DISPLAY COVER
LCD
PANEL SHEET
J R-KNOB
9M/M ROTARY POTENTIOMETER
LED
LED
LED (RED)
DESCRIPTION
LGR4609-7100
NC3FAH2-0
HLJ4306-01-3080
YKC21-3282
SF-A BLK/LCG
EVJC25FB6A54 50KAX2
GP1FA350TZ
YKF51-5054 2PZ
HEC0470-01-640
236-714
SX1H BLK
EVQ11A H=5.0
L BLK 248-303
EVE GC1 F20 24B
SX2H BLK
EVQ11A H=5.0
MX4B BLK
EVQ11A H=5.0
MX1H CLR
EVQ11A H=5.0
SPR-505MVWT31
SX1H BLK
EVQ11A H=5.0
MX1H BLK
EVQ11A H=5.0
MD3H
EVQ11A H=5.0
SLR-342MCT32 (PLAY)
SLR-342VCT32 .NP.Q RANK (REC)
SD1H BLK
EVQ11A H=5.0
SLR-342VCT32 N.P.Q RANK
SD2H BLK
EVQ11A H=5.0
SLR-342VCT32 N.P.Q RANK
SX1H BLK
EVQ11A H=5.0
SX3H BLK
EVQ11A H=5.0
SX4H BLK
EVQ11A H=5.0
SFA BLK/LCG
EVUF2K4A15 100KA
MD1H BLK 249-277(W/WINDOW)
EVQ11A H=5.0
SLR-342VCT32 N.P.Q RANK
M BLK LCG
EWAP1AC10 B54 50KB
SD3H BLK
EVQ11A H=5.0
SLR-342VCT32 N.P.Q RANK
MX4H BLK 249-271
EVQ11A H=5.0
235-334
F-51320GNY-LY-AA W/TAPE
SFA BLK/LCG
EVUF2KFK4B54 50KB
SEL2210R D RANK
SLR-342MC3F (GREEN)
SLR-342VC3F
Q’TY
4
2
2
1
1
1
1
1
1
1
1
1
1
1
1
1
2
2
1
4
12
12
12
2
2
1
1
1
3
1
6
6
6
2
4
4
1
1
1
3
1
4
2
2
1
1
1
11
11
1
3
3
1
4
4
1
1
1
1
1
3
1
1
5
MAY.2002
EXPLODED VIEW 1
fig.bunkai-1
A
d
s
A
u
W
p
o
a
r
i
t
w
w
q
e
7
y
0
9
3
5
7
6
5
3
9
BA
4
3
E
8
1
2
6
BR-1180
EXPLODED VIEW 2
fig.bunkai-2
f
C
D
h
E
g
P8 [HDD]
F
P8 [CDRW]
G
$
%
(
J
I
G
D
C
&
D
)
H
C
j
Q
G
7
MAY.2002
EXPLODED VIEW 3
HHD
fig.bunkai-3
K
j
z
b
K
v
c
k
;
K
l
x
;
K
j
k
l
CDRW
fig.bunkai-3
.
L
n
,
!
M
m
M
#
/
8
BR-1180
EXPLODED VIEW PARTS LIST
[Parts]
No.
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
51
52
53
Parts Code
17041159
02896756
00900145
22495277
00900189
00904256
00900156
00904245
01670512
22495271
00900167
00900190
01234090
02123467
02013090
01783945
02011456
********
02121456
02673245
02673223
02124845
02896778
22355334
02896767
02896801
02904778
02904745
02904756
02904767
02896823
02896812
02897167
02904623
02900412
02899445
72017823
02899434
02902156
02899401
02899412
01016223
02782990
72015301
********
02124845
01340412
********
22365714
02896834
02896956
02903223
02896978
Parts Name
LCD F-51320GNY-LY-AA W/TAPE
TOP CASE
D S-KEYTOP SD1H BLK
D S-KEYTOP MD1H BLK
D S-KEYTOP SX1H BLK
D S-KEYTOP SX4H BLK
D S-KEYTOP SD2H BLK
D S-KEYTOP SX3H BLK
F C-KEYTOP SX1H BLK
D S-KEYTOP MX4H BLK
D S-KEYTOP SD3H BLK
D S-KEYTOP SX2H BLK
D T-KEYTOP MX4B BLK
F C-KEYTOP MX1H BLK
F C-KEYTOP MX1H CLR
N S-KEYTOP MD3H
Y S-KEYTOP SX1H BLK
SW BOARD ASSY (on 72015312 SW SHEET ASSY)
BNCD-P=1.25-K-14-220
BNCD-P=1.25-K-16-220
BNCD-P=1.25-K-18-90
BNCD-P=1.25-K-18-150
CHASSIS
FOOT MKS
BOTTOM COVER
CDRW COVER
HDD SIDE CUSHION
HDD BUSH VB-1209-55
HDD COLLAR
HDD FRONT CUSHION
HDD HOLDER R
HDD HOLDER L
HDD MAXTOR 541DX 2B 020HI
WIRING HDD IDE
WIRING HDD POWER
INSULATING SHEET CDRW
CDI-BR-1 PCB ASSY
DD HOLDER CDRW STOP
WIRING IDE
DD HOLDER CDRW L
DD HOLDER CDRW R
FOOT 01016223
ATAPI CD-RW DRIVE UJDA340
MAIN BOARD ASSY
ANALOG BOARD ASSY (on 72015312 SW SHEET ASSY)
BNCD-P=1.25-K-18-150
P R-KNOB SF-A BLK/LCG
+5V POWER BOARD ASSY (on 72015312 SW SHEET ASSY)
CORD HOOK
INSULATING SHEET MAIN
WIRING 5V POWER
RIBBON CABLE JWFV 2X70-P2.0
WIRING 2 LCD
[Screws]
No.
A
B
C
D
E
F
G
H
I
J
K
L
M
Parts Code
40011278
40457245
40012534
40011312
40011490
40015956
40012512
40233012
40019134
40019123
40450367
40233978
40455867
Parts Name
SCREW 3x8 BINDING TAPTITE P ZC
WASHER M3x12x1 ZC
SCREW 3x6 BINDING TAPTITE S BZC
SCREW 3x8 BINDING TAPTITE P BZC
SCREW M3x6 PAN HEAD W/SW+PW BZC
SCREW 3x12 BINDING TAPTITE S BZC
SCREW 3x6 BINDING TAPTITE S ZC
SCREW 2.6x8 BINDING TAPTITE P BZC
SCREW M4x8 BINDING TAPTITE S W/INTERNAL TOOTH WASHER BZC
SCREW 3x8 BINDING TAPTITE S BZC
SCREW 6-32UNC 1008SR/KM003
SCREW M2x8 PAN HEAD W/SW+PW ZC
SCREW 2x2.5 BINDING MACHINE ZC
9
MAY.2002
PARTS LIST
fig.part1e
SAFETY PRECAUTIONS:
The parts marked
have
safety-related characteristics. Use
only listed parts for replacement.
CONSIDERATION ON PARTS ORDRING
When ordering any parts listed in the parts list, please specify the following items in the order sheet.
QTY
PART NUMBER
DESCRIPTION
MODEL NUMBER
Ex.
10
22575241
Sharp Key
C-20/50
15
2247017300
Knob (orange)
DAC-15D
Failure to completely fill the above items with correct number and description will result in delayed or even
undelivered replacement.
NOTE: The parts marked # are new. (initial parts)
CASING
#
#
#
#
02896756
02896801
02896767
02896789
TOP CASE
CDRW COVER
BOTTOM COVER
DISPLAY COVER
Q'ty
1
1
1
1
CHASSIS
#
#
#
#
#
#
02896778
02896812
02896823
02899401
02899412
02899434
CHASSIS
HDD HOLDER L
HDD HOLDER R
DD HOLDER CDRW L
DD HOLDER CDRW R
DD HOLDER CDRW STOP
BR-1180CD ONLY
BR-1180CD ONLY
BR-1180CD ONLY
1
1
1
1
1
1
KNOB, BUTTON
02013090
00900145
00900156
00900167
00900189
00900190
00904245
00904256
01234090
01670512
01783945
02011456
02123467
22495271
22495277
02457512
01340412
22485303
01902289
F C-KEYTOP
D S-KEYTOP
D S-KEYTOP
D S-KEYTOP
D S-KEYTOP
D S-KEYTOP
D S-KEYTOP
D S-KEYTOP
D T-KEYTOP
F C-KEYTOP
N S-KEYTOP
Y S-KEYTOP
F C-KEYTOP
DS-KEYTOP
D S-KEYTOP
J R-KNOB
P R-KNOB
D R-KNOB(ALPHA-DIAL)
U S-KNOB
MX1H CLR
SD1H BLK
SD2H BLK
SD3H BLK
SX1H BLK
SX2H BLK
SX3H BLK
SX4H BLK
MX4B BLK
SX1H BLK
MD3H
SX1H BLK
MX1H BLK
MX4H BLK 249-271
MD1H BLK 249-277(W/WINDOW)
SFA BLK/LCG
SF-A BLK/LCG
L BLK 248-303
M BLK LCG
12
6
2
1
2
2
1
1
1
2
1
1
1
1
1
3
1
1
11
EVQ11A H=5.0
TACT SWITCH
SW1,SW2,SW3,SW4,SW5,SW6,SW7,SW8,SW9,S
W10,SW11,SW12,SW13,SW14,SW15,SW16,SW17,
SW18,SW19,SW20,SW21,SW22,SW23,SW24,SW2
5,SW26,SW27,SW28,SW29,SW30,SW31,SW32,SW
33,SW34,SW35,SW36,SW37,SW38,SW39,SW40,S
W41,SW42,SW43,SW44,SW45,SW46,SW47,SW48,
SW49,SW50,SW51,SW52,SW53,SW54 on SWB
54
YKF51-5054 2PZ
LGR4609-7100
HEC0470-01-640
NC3FAH2-0
YKC21-3282
HLJ4306-01-3080
MIDI CONNECTOR
6.5MM JACK
DC JACK
XLR JACK
RCA(PIN JACK)
6.5MM JACK
JK9 on MB
JK1 on ANB. JK7,10,11 on MB
JK8 on MB
JK2,JK4 on ANB
JK5 on ANB
JK3,JK6 on ANB.
1
4
1
2
1
2
SWITCH
01340290
JACK, EXT TERMINAL
13429825
00569278
#
02900312
01239890
#
02900478
13449258
DISPLAY UNIT
17041159
F-51320GNY-LY-AA W/TAPE
LCD
NOTE: Replacement F-51320GNY-LY-AA should be made on a unit base.
10
1
BR-1180
DISK DRIVE UNIT
#
02897167
MAXTOR 541DX 2B 020HI
HDD
NOTE: Replacement MAXTOR 541DX 2B 020HI should be made on a unit base.
02782990
UJDA340
ATAPI CD-RW DRIVE
NOTE: Replacement UJDA340 should be made on a unit base.
1
BR-1180CD ONLY
PCB ASSY
#
72015301
MAIN BOARD ASSY
#
72015312
SW SHEET ASSY
NOTE: ‘SW SHEET ASSY’ includes the following parts.
********
BR-1180 ANALOG BOARD ASSY
Assy(Unit)
********
BR-1180 +5V POWER BOARD ASSY
Assy(Unit)
********
BR-1180 SW BOARD ASSY
Assy(Unit)
NOTE: ‘BR-1180 SW BOARD ASSY’ includes the following parts.
#
02903223
RIBBON CABLE
JWFV 2X70-P2.0
40013334
SPACER PLASTIC PIPE
3.2X5X10 CLARYTY
40344367
LED SPACER
POLYCARBONATE-PIPE 3X6X10.5
1
1
1
1
1
1
1
2
5
#
72017823
PCB ASSY
BR-1180CD ONLY
1
#
02900434
02231767
02896745
02568489
02457634
02451434
02892334
02900267
02458090
01672623
01121845
01348912
02124934
00458034
00346445
15189261
01458445
02903734
01899790
02563467
02900201
01785178
02903745
02568778
15289124
15189250
15189190
02898412
02673812
UPD7031060A058-UEN
RA0A-101 (TC223C080AF-101)
S1L50753F27B000
GM71V18163CT-6
MBM29LV160BE70TN-K
AK4552VT
TC74LCX245FT(EL)
TC7S66F(TE85R)
TC4066BFT(EL)
TC74HC4053AFT(EL)
TC7W04FU TE12L
TC7SH08FU(TE85L)
TC74VHC541FTEL
TC75S51F TE85R
NJM2100M(TE3)
M5218AFP-600E
UPC29M33T-T1
TA78M09F(TE16L)
UPC29L33T-E2
NJM2374AM-TE1
M62270GP-C60J
TC9271FS
S-80930CNMC-G80
GP1FA350TZ
PC-4007
M5218AL
M5216L-600Y
NJM2374AD
HY57V641620HGT-P
IC (CPU 16BIT)
IC (DSP)
IC (I/F)
IC (DRAM)
IC (FLASH MEMORY)
IC (AD/DA)
IC (CMOS)
IC (CMOS)
IC (CMOS)
IC (TTL)
IC (CMOS)
IC (CMOS)
IC (CMOS)
IC (OP AMP)
IC (BIPOLAR OP AMP)
IC (BIPOLAR OP AMP)
IC (REGULATOR)
IC (REGULATOR)
IC (REGULATOR)
IC (SWITCHING REGULATOR)
DC-DC IC(REGULATOR)
IC (DIGITAL OUT IF)
IC (RESET)
IC (OPTICAL CONNECTOR)
IC (PHOTO COUPLER)
IC (BIPOLAR OP AMP)
IC (BIPOLAR OP AMP)
IC (SWITCHING REGULATOR)
IC (DRAM)
TRANSISTOR
02780423
15309104
#
02900301
15329501
00239812
02340645
#
02900212
#
02900234
15129179
15139123
#
02896734
#
02904634
POWER MOSFET CPH6302-TL
2SA1586-GR(TE85R)
TPC8303(TE12L)
DTA143EK T146
DTC114EUT106
RN1441-A(TE85L)
M54563FP-200D
M54585KP-200D
2SC2458-GR(TPE4)
2SK184-GR(TPE4)
RN1241-A(TAPE4)
2SJ438
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
Q29 on MB
Q7 on MB
Q21,Q22,Q31 on MB
Q38 on MB
Q2,Q3,Q4,Q5,Q6,8,12,14,23,24,27,30,33,34,36 on MB
Q11,Q13 on MB
IC38 on MB
IC41 on MB
Q16,Q17,Q18,Q19 on SWB
Q1 on ANB
Q9,Q10 on ANB
Q20 on +5PB
1
1
3
1
15
2
1
1
4
1
2
1
15339119T0
01780045
15339120T0
15019126
1SS352(TPH3)
RB051L-40
1SS302(TE85R)
1SS133 T-77
SWITCHING DIODE
SCHOTTKY DIODE
ARRAY DIODE
SWITCHING DIODE
3
2
2
52
01904189
SEL2210R D RANK
LED
D1,D57,D58 on MB
D55,D56 on MB
DA1,DA2 on MB
D3,D5,D6,D7,D8,D9,D10,D11,D12,D13,D14,D15,
D16,D17,D18,D19,D20,D21,D22,D23,D24,D25,D2
6,D27,D28,D29,D30,D31,D32,D33,D34,D35,D36,D
37,D38,D39,D40,D41,D42,D43,D44,D45,D46,D47,
D48,D49,D50,D51,D52,D53,D100,D101 on SWB
LED1,LED2,LED17,LED18,LED19 on SWB
IC
#
#
#
#
#
#
IC28 on MB.
IC27 on MB
IC36 on MB
IC47 on MB
IC24 on MB
IC5 on MB
IC35,IC39 on MB
IC46 on MB
IC2,IC6,IC13 on MB
IC29,IC32 on MB
IC23 on MB
IC40 on MB
IC37,IC42 on MB
IC33 on MB
IC3 on MB
IC7,IC8 on MB
IC49 on MB
IC48 on MB
IC1 on MB
IC9 on MB
IC22 on MB
IC25 on MB
IC34 on MB
CN1 on MB
IC26 on MB
IC20 on SWB. IC4,IC11,IC12 on ANB
IC10 on ANB
IC21 on +5PB
IC30 on MB
1
1
1
1
1
1
2
1
3
2
1
1
2
1
1
2
1
1
1
1
1
1
1
1
1
4
1
1
1
DIODE
5
11
MAY.2002
DIODE
01904112
SLR-342VCT32 N.P.Q RANK
LED
LED3,LED4,LED5,LED8,LED9,LED10,LED11,LE
D12,LED13,LED14,LED15,LED16,LED20,LED30,
LED32 on SWB
LED34 on SWB
LED31 on SWB
LED33 on SWB
LED6,LED7,LED21,LED22,LED23,LED24,LED25,
LED26,LED27,LED28,LED29,LED35 on SWB
D54 on +5PB
15
15029347
15029348
15039237
01904178
SLR-342VC3F
SLR-342MCT32
SLR-342MC3F
SPR-505MVWT31
LED (RED)
LED (GREEN)
LED (GREEN)
LED (CLR)
15019297
30DF2-FC
DIODE
00567156
RPC05T 102 J
MTL.FILM RESISTOR
L41,L42,L46,R42,R141,R147,R153,R164,R182,R188
,R191,R218,R274 on MB
R167 on MB
R36,R151,R159 on MB
R4 on MB
R150 on MB
L16L,26,L28,R275 on MB
R6,R7,R23,R24,R31,R32,R33,R34,R35,R38,R41,R77
,R84,R89,R92,R96,R101,R138,R139,R143,R144,R14
6,R232,R233,R234,R235,R236,R237,R259,R260,R26
2,R263,R264,R265 on MB
R11,R20,R40 on MB
R48,R63 on MB
R1,R2,R5,R15,R45,R46,R49,R60,R61,R64,R148,R15
2,R155,R156,R158,R163,R174,R179,R185,R186,R18
7,R189,R190,R192,R210,R219,R222,R225,R230,R23
8,R249,R250,R270 on MB
R47,R62,R231 on MB
R17,R21,R74,R79 on MB
R81,R94,R160,R161,R162,R165,R166,R168,R169,R
170,R171,R172,R173,R175,R176,R177,R178,R180,R
181,R183,R193,R194,R195,R196,R197,R198,R199,R
200,R201,R202,R203,R204,R205,R206,R207,R208,R
209,R211,R212,R213,R214,R215,R216,R217,R248,R
251,R253,R254,R255,R269 on MB
R149,R227,R228 on MB
R229,R226 on MB
R220,R221 on MB
R154 on MB
R39 on MB
R18 on MB
R37 on MB
R44,R58 on MB
R43,R184 on MB
R273 on MB
R261 on MB
RA38,RA39 on MB
RA25,RA26,RA27,RA30,RA31,RA32 on MB
RA1,RA2,RA15,RA16,RA20,RA33,RA34 on MB
RA17,RA18,RA21,RA23,RA28 on MB
RA3,RA4,RA5,RA6RA7,RA8,RA11,RA12,RA,13,
RA14,19 on MB
RA40,RA41 on MB
RA9,RA10,RA22,RA24 on MB
R108 on SWB. R9,R127 on ANB
R111,R115,R130,R133 on SWB. R13,R14,R68,R73,
R75,R90,R95,R99,R103,R104 on ANB
R113,R132,R259 on SWB
R107,R110,R126,R129 on SWB. R22,R27,R51,R52,
R57,R66,R67,R71 on ANB. R134 on +5PB
R109,R128 on SWB.
R112,R131 on SWB. R53,R54,R69,R70,
R83,R85,R86,R87,R97,R98 on ANB
R88,R100 on ANB.
R8,R12,R257,R258 on ANB
R76,R91 on ANB
R16,R25,R26,R59,R65,R78,R82,R105,R106 on ANB
R19,R28,R56,R72 on ANB
R80,R93 on ANB
R29,R30,R50,R55 on ANB
R140 on +5PB
R136 on +5PB
R137,R135 on +5PB
13
00567501
00567023
00566867
01454890
01011856
00567412
RPC05T 474 J
RPC05T 101 J
RPC05T 100 J
MCR50 JZH J 220
RPC05T 0R0 J
RPC05T 104 J
MTL.FILM RESISTOR
MTL.FILM RESISTOR
MTL.FILM RESISTOR
MTL.FILM RESISTOR
MTL.FILM RESIST0R
MTL.FILM RESISTOR
00567345
00567323
00567289
RPC05T 333 J
RPC05T 223 J
RPC05T 103 J
MTL.FILM RESISTOR
MTL.FILM RESISTOR
MTL.FILM RESISTOR
00567256
00567245
00566967
RPC05T 562 J
RPC05T 472 J
RPC05T 470 J
MTL.FILM RESISTOR
MTL.FILM RESISTOR
MTL.FILM RESISTOR
00566912
00566934
00567012
00567034
00567045
00567190
00567234
00567312
00567378
01670256
15399945
01011845
00126112
00126134
00909590
01013578
RPC05T 220 J
RPC05T 330 J
RPC05T 820 J
RPC05T 121 J
RPC05T 151 J
RPC05T 222 J
RPC05T 392 J
RPC05T 183 J
RPC05T 473 J
SR73K2ETD 0.22OHMJ
MCR100 101J
EXBV8V0R000V
EXBV8V101JV
EXB-A10E103J
EXBV8V330JV
EXBV8V470JV
MTL.FILM RESISTOR
MTL.FILM RESISTOR
MTL.FILM RESISTOR
MTL.FILM RESISTOR
MTL.FILM RESISTOR
MTL.FILM RESISTOR
MTL.FILM RESISTOR
MTL.FILM RESISTOR
MTL.FILM RESISTOR
MTL.FILM RESISTOR
RESISTOR
RESISTOR ARRAY
RESISTOR ARRAY
RESISTOR ARRAY
RESISTOR ARRAY
RESISTOR ARRAY
03015667
15409113
01897723
01897745
EXBV8V471JV
EXBV8V103JV
RD16ST26A 105 J
RD16ST26A 472 J
RESISTOR ARRAY
RESISTOR ARRAY
CARBON RESISTOR
CARBON RESISTOR
01897545
01788301
RD16ST26A 101 J
RD16ST26A 102 J
CARBON RESISTOR
CARBON RESISTOR
01788389
01897712
RD16ST26A 183 J
RD16ST26A 104 J
CARBON RESISTOR
CARBON RESISTOR
01897578
01897645
01897667
01897690
01897823
01788267
02903201
01900912
02907389
01458689
RD16ST26A 331 J
RD16ST26A 103 J
RD16ST26A 223 J
RD16ST26A 473 J
RD16ST26A 333 J
RD16ST26A 221 J
RSS1/2 T26 682 J
SN14K2CT26 2201F
SN14K2CT26 7501F
SRPX2 L15 0.1 J
CARBON RESISTOR
CARBON RESISTOR
CARBON RESISTOR
CARBON RESISTOR
CARBON RESISTOR
CARBON RESISTOR
MTL.OXIDE RESISTOR
MTL.FILM RESISTOR
MTL.FILM RESISTOR
MTL.FILM RESISTOR
EVUF2K4A15 100KA
EVUF2KFK4B54 50KB
EWAP1AC10 B54 50KB
9M/M ROTARY POTENTIOMETER
9M/M ROTARY POTENTIOMETER
POTENTIOMERTER (SLIDE)
EVJC25FB6A54 50KAX2
9M/M ROTARY POTENTIOMETER
1
1
1
12
1
RESISTOR
#
#
POTENTIOMETER
#
02896701
#
02896712
01677312
#
12
02900467
VR2,VR9 on SWB
VR8 on SWB
VR3,VR4,VR5,VR6,VR7,VR10,VR11,VR12,
VR13,VR14,VR15 on SWB
VR1 on ANB
1
3
1
1
4
34
3
2
33
3
4
50
3
2
2
1
1
1
1
2
2
1
1
2
6
7
5
11
2
4
3
14
4
13
2
12
2
4
2
9
4
2
4
1
1
2
2
1
11
1
BR-1180
CAPACITOR
C50 on MB
C146,C147,C148,C149,C150,C151,C161,C162,C16
3,C164,C165,C210,C213,C214,C215,C216,C217,C2
18,C219,C220,C221,C222,C223,C224,C225,C226,C
228,C233,C234,C235,C236,C237,C238,C239,C240,
C241,C242,C243,C244,C245,C246,C247,C248,C28
7,C314,C316,C318 on MB
C296,C297,C298,C299,C300,C301,C302,C303,C30
4,C305,C306 on MB
C12,C23,C176,C177 on MB
C51,C59 on MB
C54,C65 on MB
C259,C260 on MB
C1,C3,C4,C7,C8,C20,C41,C42,C90,C91,C111,C113
,C117,C118,C121,C123,C124,C126,C127,C128,C13
0,C131,C132,C133,C134,C135,C136,C137,C138,C1
39,C140,C141,C142,C143,C144,C152,C154,C155,C
156,C157,C158,C159,C166,C167,C168,C170,C171,
C175,C179,C180,C181,C182,C183,C184,C185,C18
6,C187,C188,C189,C190,C195,C196,C197,C198,C1
99,C200,C201,C202,C203,C205,C208,C209,C211,C
212,C227,C229,C230,C231,C232,C249,C250,C251,
C252,C253,C254,C255,C257,C267,C289,C292,C29
3,C294,C308 on MB
C43,C115,C116,C129,C145,C153,C204,C206,C258
on MB
C2,C5,C6,C9,C18,C26,C27,C73,C79,C89,C125,C16
0,C169,C174,C310 on MB
C112,C119,C120,C286 on MB
C17,C25,C40,C288,C295 on MB
C44 on MB
C45 on MB
C46,C49 on MB
C21,C256,C261,C262,C263 on MB
C310 on MB
C97,C102 on SWB. C10,C34,C35,C36,C48,C97 on ANB
C95,C104 on SWB. C31,C58 on ANB
C94,C96,C98,C99,C100,C101,C103,C105,C106,C1
07 on SWB
C71,C82 on ANB
C13 on ANB
C32,C37,C60,C61,C78,C87 on ANB
C16,C24,C30,C39,C57,C66,C92 on ANB
C14,C15,C19,C22,C33,C47,C52,C53,C55,C62,C63,
C67,C68,C69,C70,C72,C74,C76,C77,C81,C85,C86,
C88,C93 on ANB
C29,C38,C56,C65 on ANB
C75,C84 on ANB
C110 on ANB
C109 on +5PB
C2 on +5PB
1
47
1
1
2
2
29
CHOKE COIL
EMI FILTER
CHOKE COIL
L5 on MB
FL1 on MB
L4,L13 on MB
L14 on MB. L13 on +5PB
L10,L11,L15,L17,L18,L19,L20,L21,L22,L23,L24,L2
5,L29,L30,L32,L33,L34,L35,L36,L37,L38,L39,L40,
L43,L44,L45,L47,L48,L49 on MB
L16 on ANB
L15 on ANB
L12 on +5PB
CX-49G 5MHZ
SG-8002JC 67.7376MHZ PC
CRYSTAL
CRYSTAL
X1 on MB
X2 on MB
1
1
01905467
EVE GC1 F20 24B
ROTARY ENCODER
EN1 on SWB
1
CONNECTOR
01908656
01908645
#
02896934
13369570
02237512
02349545
18FE-BT-VK-N
16FE-BT-VK-N
52559-3092
B2B-PH-K-S (2P)
75501-0X0-B
P/N 75401-0X0-B
CONNECTOR
CONNECTOR
CONNECTOR
CONNECTOR
CONNECTOR P/N
CONNECTOR
CN110,112,113 on MB. CN104 on ANB
CN111 on MB
CN6 on MB
CN115 on MB
CN5 on MB. CN101 on CDB BR-1180CD ONLY
CN4 on MB
4
1
1
1
2
1
#
#
#
#
01674401
01674612
ECUV1H331JCV
ECJ1VB1H103K
CERAMIC CAPACITOR
CERAMIC CAPACITOR
01674334
ECUV1H101JCV
CERAMIC CAPACITOR
01674167
01674312
01674478
01674556
01674701
ECUV1H100DCV
ECUV1H820JCV
ECJ1VB1H122K
ECJ1VB1H472K
ECJ1VF1E104Z 0.1UF/16VK
CERAMIC CAPACITOR
CERAMIC CAPACITOR
CERAMIC CAPACITOR
CERAMIC CAPACITOR
CERAMIC CAPACITOR
02014356
ECEV1CA101WP
CHEMICAL CAPACITOR
15369152
ECEV1CA100SR
CHEMICAL CAPACITOR
02897056
01904856
02897012
02897034
02897045
15369262
03015678
13519452
13519692
02897890
ECEV1CA471UP
ECEV1CA470WR
ECEV1HA330UP
ECEV1HA101UP
ECEV1CA220WR
ECEV1HA010SR
ECEV1AA101WR
DD306-959F104Z25(100NF/25V Z)
DD104-989SL100D50
RC3-16V100M-T2
CHEMICAL CAPACITOR
CHEMICAL CAPACITOR
CHEMICAL CAPACITOR
CHEMICAL CAPACITOR
CHEMICAL CAPACITOR
CHEMICAL CAPACITOR
CHEMICAL CAPACITOR
CERAMIC CAPACITOR
CERAMIC CAPACITOR
CHEMICAL CAPACITOR
13519667
13519671
13519673
01454889
01900823
DD104-989SL470J50
DD104-989SL101J50 100PF 50VK
DD105-989SL151J50
RA2-16V470MT2 470UF/16V
RA2-16V100M-T2
CERAMIC CAPACITOR
CERAMIC CAPACITOR
CAPACITOR
CHEMICAL CAPACITOR
CHEMICAL CAPACITOR
01900845
01900834
13519628
00679089
02239623
RA2-50V470M-T2
RA2-16V101M-T2
DD104-989B331K50
16MV2200HC
RA2-16V102M-T2
CHEMICAL CAPACITOR
CHEMICAL CAPACITOR
CERAMIC CAPACITOR
CAPACITOR
CHEMICAL CAPACITOR
LQH4N151K04
SH-202
ELL6SH2R7M
ELC10D470E
N1608Z601T01
COIL
CHOKE COIL
CHOKE COIL
CHOKE COIL
FERRITE-BEAD
TSL0709RA-151KR52
SBT-0260TF
TSL1315S-101
INDUCTOR, COIL, FILTER
01893634
00237212
02780378
02780389
01565578
02238234
00891689
01904001
CRYSTAL, RESONATOR
02673267
02672401
11
4
2
2
2
93
9
15
4
5
1
1
2
5
1
7
4
10
2
1
6
7
24
4
2
1
1
1
1
1
1
ENCODER
13
MAY.2002
CONNECTOR
13369594
02010867
02010878
02122456
01908634
02782645
B4B-XH-A
16FE-ST-VK-N
18FE-ST-VK-N FOR WIRING
14FE-ST-VK-N
14FE-BT-VK-N
24 5600 050 100 883
CONNECTOR
CONNECTOR
CONNECTOR
CONNECTOR
CONNECTOR
CONNECTOR
WIRING, CABLE
#
02904623
#
02896956
#
02896978
#
02900412
02673223
02124845
02121456
02673245
#
02902156
WIRING
WIRING
WIRING
WIRING
BAN CARD
BAN CARD
BAN CARD
BAN CARD
WIRING
HDD IDE
5V POWER
2 LCD
HDD POWER
BNCD-P=1.25-K-18-90
BNCD-P=1.25-K-18-150
BNCD-P=1.25-K-14-220
BNCD-P=1.25-K-16-220
IDE
#
40450367
40233012
40011278
40011312
40019123
40019134
40012534
40012512
40015956
40011490
40457245
40233978
40455867
SCREW 6-32UNC
SCREW M2.6X8
SCREW 3X8
SCREW 3X8
SCREW 3X8
S-TITE BINDING 4*8 ZC
SCREW 3X6
SCREW 3X6
SCREW M3X12
SCREW M3X6
PLAIN WASHER 3X12X1
SCREW M2X8
SCREW M2X2.5
1008SR/KM003
BINDING TAPTITE FEBZC
BINDING TAPTITE P FE ZC
BINDING TAPTITE P BZC
BINDING TAPTITE S BZC
WITH SPRING LOCK WASHER
BINDING TAPTITE S FE BZC
BINDING TAPTITE S ZC
BINDING HEAD S-TIGHT BZC
PAN MACHINE W/SW BZC
ZC
PAN MACHINE W/SW+PW ZC
PAN MACHNE W/SW
PACKING
#
#
#
#
#
#
#
02904712
02904723
02904990
02904989
02896845
02904912
02907178
UPPER PAD
LOWER PAD
SIDE PAD R
SIDE PAD L
PACKING CASE
OUTER PACKING CASE
PACKAGE LABEL
MISCELLANEOUS
#
02907145
22365714
22355334
#
02896790
#
02896834
#
02904756
#
02904767
#
02904778
#
02904745
01016223
#
02899445
#
40458189
40456956
WARNING LABEL
CORD HOOK
FOOT MKS
PANEL SHEET
INSULATING SHEET
HDD COLLAR
HDD FRONT CUSHION
HDD SIDE CUSHION
ISOLATOR
FOOT
INSULATING SHEET
CORD BINDER
LABEL
ADAPTOR TAG
236-714
235-334
ACCESSORIES (STANDARD)
#
02900423
00894367
00894378
00894389
00907001
23495124
#
********
#
72018489
#
72018367
40232389
AC ADAPTOR
AC CORD SET
AC CORD SET
AC CORD SET
AC CORD SET
AC CORD SET
DISCRETE DRAMS CDROM
OWNER’S MANUAL SET
OWNER’S MANUAL SET
WARRANTY CARD
PSB-3U DC
100V SP18A+IS14 VCTF2X0.75
120V SP301+IS14 SJT18/3
230V SP22+IS14 H05VV-F3G1.0
240VE KP-610 GTTBS-3 KS-31A
240VA SC-144-JO1 ES303-10HMA
BR-1180CD ONLY
JAPANESE
ENGLISH
FOR BOSS JAPAN ONLY
CN114 on +5PB
CN108 on SWB
CN106,107 on SWB
CN105 on SWB
CN103 on ANB
CN102 on CDB
BR-1180CD ONLY
3
1
2
1
1
1
BR-1180CD ONLY
1
1
1
1
2
1
1
1
1
SCREW
#
14
BR-1180CD ONLY
BR-1180CD ONLY
4
4
17
12
1
1
5
12
7(4)
7(4)
1
2
4
1
1
1
1
1
1/2
1
MAIN
VB-1209-55 FOR HDD
30X10X3
CDRW
CB-4 CLEAR
CD R/W LABEL
BR-1180CD ONLY
BR-1180CD ONLY
BR-1180CD ONLY
1
1
4
1
1
4
2
3
4
1
1
1
1
1
1
1
1
1
1
1
1
1
1
BR-1180
CHECKING THE VERSION
NUMBER
3.
Using [CURSOR] again to select the “INFO” icon, then press [ENTER].
The size of each drive (partition) appears.
The currently selected drive is indicated by an asterisk (“*”).
fig.R19-41
Press the [POWER] button while pressing the [REC TRACK1] and [UNDO/
REDO] buttons.
The test mode screen will be displayed and the version numbers for the CPU
mask and FLASH ROMs will be displayed.
*
*
Continue pressing the [REC TRACK1] and [UNDO/REDO] buttons until the
test mode screen is displayed.
How to exit
1.
Press the [EXIT] button.
2.
“Press Power SW” is displayed.
3.
Press the [POWER] button for at least 2 seconds.
4.
The unit’s power will be turned off.
The BR-1180/BR-1180CD is set with one drive at the factory, so only one
drive will appear in the display.
4.
*
5.
If you want to switch the drive being used, use [CURSOR] to move the
cursor to the drive you want to use, then press [ENTER].
If you are in the process of recording a song at this point, the message “Save
Current?” appear. If you want to save the current song, press [YES]; press
[NO] if you do not need to save the song.
The message “Now Loading...” appears.
When “Complete!” appears, the switch is completed.
USERS DATA SAVE AND
LOAD
When saving or reloading user data, check the hard disk partitions by viewing
“hard disk information” and perform as follows for all pratitions of the hard
disk.
*
Installation of CD-R/W drive is necessary when performing the following steps
on the BR-1180. Contact the Roland Service Center for the method of installing
the CD-R/W drive. See the “CDI-BR-1 Installation Procedures” in this service
note for the installation procedure.
*
Drives can be switched only when multiple drives have been created.
Saving the content of the hard disk
to CD-R/RW discs (HDD Backup)
1.
Place a writable CD-R/RW disc (a blank disc) in the CD-R/RW drive.
2.
After the CD-R/RW drive’s indicator has stopped flashing, press [DATA
SAVE/LOAD].
3.
Use [CURSOR] to select the “BACKUP” icon, then press [ENTER].
fig.R16-05
Viewing information about the
hard disk
(Hard Disk Information)
You can display information about the hard disk.
1.
Press [UTILITY].
2.
Use [CURSOR] to select the “HDD” icon, then press [ENTER].
fig.R19-40
4.
Using [CURSOR] again to select the “HDD” icon, then press [ENTER].
The message “HDD Backup Ok?” appears.
fig.R16-54
*
If a CD-R/RW disc that already has data written to it is loaded, the message
“Not Blank Disc” appears, and you cannot proceed with the backup. Be sure to
use only blank discs. If a CD-RW disc is inserted, the message “Erase Disc?”
appears. Pressing [ENTER] here begins erasure of the disc.
15
MAY.2002
5.
*
Press [YES].
4.
If you are in the process of recording a song at this point, the message “Save
Current?” may appear. If you want to save the current song to the hard disk,
press [YES]; press [NO] if you do not need to save the song. Note, though, that if
you do press [NO], the data currently being recorded will be lost.
fig.R16-55
Using [CURSOR] again to move the cursor to “HDD,” then press
[ENTER].
The message “HDD Recover Ok?” appears.
The message “Write Speed?” appears.
fig.R16-92
5.
Press [YES], and when the message “Initialize HDD?” appears, press
[YES] again.
The hard disk is initialized, then the recovery begins.
6.
When “Complete!” appears, the loading is finished.
Set the write speed.
If the write speed indicated is acceptable, go on to Step 8.
*
If you want to change the write speed, rotate the TIME/VALUE dial to
change the value, then proceed to Step 7.
When you execute HDD Recover, all data stored on the hard disk up to that
point is erased and overwritten by the data on the CD-R/RW disc. Note that this
data cannot be recovered once it has been erased.
Write Speed:
x2 (352 kbps)
*
7.
Writes twice as fast.
x4 (704 kbps)
Writes four times as fast.
x8 (1408 kbps)
Writes eight times as fast.
With some media, the range of write speeds may be limited. In such cases, the
values that can be set with the TIME/VALUE dial may also be limited.
Press [ENTER].
The message “Write Sure?” appears.
*
8.
To cancel, press [NO].
RESTORING THE FACTORY
SETTINGS
Initializing hard disk
*
Note that all user and demo song data are lost when this operation is performed.
Press [ENTER].
Writing to the CD-R/RW disc begins.
The backup begins.
1.
When “Complete!” appears, the backup is finished.
*
If the content of the hard disk does not fit on one CD-R/RW disc, the backup is
then made to multiple discs. In this case, have a number of blank discs on hand,
and replace the discs according to the instructions as they appear on the screen.
Loading the saved content of the
hard disk to the BR-1180CD
(HDD Recover)
1.
Place the CD-R/RW disc containing the saved hard disk data in the CDR/RW drive.
2.
After the CD-R/RW drive’s indicator has stopped flashing, press [DATA
SAVE/LOAD].
3.
Use [CURSOR] to select the “RECOVER” icon then press [ENTER].
fig.R16-06
Press the [POWER] button while pressing the [REC TRACK5] and
[UNDO/REDO] buttons.
Continue pressing the switch until 1 TEST MENU is displayed.
2.
Select “23 INITIALIZE HDD” by turning the [TIME/VALUE] knob.
3.
Press the [ENTER] button.
4.
“Initialize OK?” is displayed.
5.
Press the [ENTER] button again.
The initializing begins .
6.
“24 POWER OFF” is displayed.
7.
The unit’s power is turned off when the [POWER] button is pressed for at
least 2 seconds.
Loading the demo song
*
Note that all user data are lost when this operation is performed.
*
There is data which is not initialized only by load operation of a Demo song.
Please operate the above “Initializing hard disk” when you exchange the hard
disk.
1.
Press the [POWER] button while pressing the [REC TRACK7] and
[UNDO/REDO] buttons.
Continue pressing the button until “Insert Disc” is displayed.
2.
Place the CD-R (#17041161) for loading the demo song on the tray.
3.
“Initialize HDD?” is displayed.
4.
Press [ENTER]
The hard disk is initialized, then the loading demo song begins.
5.
16
The unit’s power will be turned off automatically.
BR-1180
SYSTEM SOFTWARE UPDATE
PROCEDURE
TEST MODE
Required Item
Updating from CD-R
•
Ocscillator
•
Uscilloscope
•
Foot switch (FS-5U etc)
•
Expression Pedal (EV-5 etc)
Update data CD-ROM for service (#17041160)
•
MIDI Cable
Press the [POWER] button while pressing the [STOP] and [PLAY]
buttons.
•
Audio or Headphone
•
Tester
Current version number is displayed.
•
Pharutom
•
Noise Meter
•
Blank CD-RW
•
Device (inclade the Dgital In terminal)
Required Items
•
1.
2.
When “Insert Disk” is displayed, take out the tray by pressing the eject
button for CD-R/RW.
3.
Set the CD-R for updating into the tray and close it.
4.
The new version number, date and check sum are displayed.
5.
When the system displays “Update OK?”, press the [ENTER/YES]
button.
6.
“Now Writing....” is displayed.
Press the [POWER] button while pressing the [REC TRACK1] and [UNDO/
REDO] buttons.
7.
When “Complete” is displayed, press the [POWER] button and turn off
the unit’s power.
“1 DEVICE screen” is displayed, and the device check for test mode, item 1
will start.
8.
If you fail the update, please redo from Procedure 1.
Updating for SMF
Required Items
•
Update data CD-ROM for service (#17041160)
Pleaseuse if from CD-R, changing in to media for sequencers.
How to enter the test mode
*
Continue pressing the [REC TRACK 1] and [UNDO/REDO] buttons until the
test mode screen appears.
Test item
The test mode items are as follows.
1.
DEVICE
2.
SW
3.
FOOT SW
4.
EXP PEDAL
Current version number is displayed.
5.
ENCODER & LCD
2.
When “Waiting SMF” is displayed, send the SMF data (32 files) from the
sequencer, etc.
6.
FADER
3.
7.
This work is repeated 32 times.
LED
8.
MIDI
9.
MUTE
*
1.
The SMF data contents of 32 files.
Press the [POWER] button while pressing the [STOP], [PLAY] and [REC]
buttons.
NOTE: Whe you sent the next file, please wait about 5 seconds.
4.
When “Complete” is displayed, press the [POWER] button and turn off
the unit’s power.
10. GUITAR A/B
11. AF/AD
12. MIC2 PHANTOM
13. GTR/MIC2 AUDIO
14. MIC1 A/B
15. MIC1 PHANTOM
16. MIC1 AUDIO
17. SUB MIX
18. SUB MIX AUDIO
19. LINE ON/OFF
20. LINE AUDIO
21. HARD DISK
22. CD-RW DRIVE
23. INITIALIZE HDD
24. POWER OFF
17
MAY.2002
Moving through test items
6.FADER
Cursor [RIGHT]: proceeds to the next item
KNOB/FADER name to be operated is displayed.
Cursor [LEFT]: returns to previous item
1.
Turn the INPUT LEVEL knob from MIN to MAX.
2.
Move TRACK faders 1 to 11 sequentially from MIN to MAX.
3.
Move the MASTER fader from MIN to MAX.
*
*
You can forcefully move through items by performing the above operation while
pressing the [STOP] button.
If all faders are “OK”, the system will automatically proceed to the next
item.
For 3 FOOT SW and later items, the test mode can be exited midway and the
unit’s power turned off by pressing the [POWER] button.
If a fader different from the one displayed is moved, “Err:Other moved t”
is displayed.
Other settings
7.LED
1.
Set the FOOT SW (FS-5U) polarity switch to the jack side.
2.
Please connect the FOOT SW (FS-5U etc)
When you enter this item, all LEDs other than PEAK come on.
3.
Please connect the Expression pedal (EV-5 etc)
1.
Test contents
1. DEVICE
1.
The version numbers for the CPU mask and FLASH ROMs are displayed.
The system proceeds to the following tests automatically.
When an error occurs, the device that the error has occurred on will be
displayed.
•
RAM check inside the CPU
•
ROM check inside the CPU
•
SDRAM check
•
FLASH ROM (MEMORY) check
•
GATE ARRAY check
•
ESP check
2.
The device name is displayed during the check.
3.
If no error occurs, “Device OK!” will be displayed.
4.
Press the [RIGHT] cursor button and proceed to the next item.
2.SW
The LEDs come on one by one in the following order when the [RIGHT]
cursor button is pressed.
[INPUT SELECT GUITAR] -> [INPUT SELECT MIC1] -> [INPUT SELECT
LINE] -> “MIDI” -> “HD ACCESS” -> [EFECT] -> [TUNER] -> [REC MODE
INPUT] -> [REC MODE BOUNCE] -> [REC MODE MASTERING] -> [AUTO
PUNCH IN] -> [AUTO PUNCH OUT] -> [AUTO PUNCH ON/OFF] ->
[REPEAT] -> [PLAY] -> [REC] -> [REC TRACK 1](GREEN)(RED) -> [REC
TRACK 2] (GREEN)(RED) -> [REC TRACK 3](GREEN)(RED) -> [REC TRACK
4](GREEN)(RED) -> [REC TRACK 5](GREEN)(RED) -> [REC TRACK
6](GREEN)(RED) -> [REC TRACK 7](GREEN)(RED) -> [REC TRACK
8](GREEN)(RED) -> [REC TRACK 9/10] (GREEN)(RED) -> [LOOP PHRASE
IMPORT](GREEN)(RED) -> [DATA SAVE/LOAD](GREEN)(RED) -> [AUDIO
CD WRITE/PLAY](GREEN)(RED) -> [RHYTHM EDIT] -> [RHYTHM ON/
OFF] -> [MASTERING TOOL KIT] -> [TIME STRETCH] -> [CENTER
CANCEL] -> Return
2.
When the [RIGHT] cursor button is pressed, the LEDs for [REC TRACK]
1 to 9/10 and CD-R/RW sections all come on in red.
3.
When the [RIGHT] cursor button is pressed, the LEDs for [REC TRACK]
1 to 9/10 and CD-R/RW sections all come on in green.
4.
Press the [RIGHT] cursor button and proceed to the next item.
8 MIDI
1.
Confirm that “NG” is displayed when the MIDI cable is not connected.
2.
Connect MIDI OUT and MIDI IN using the MIDI cable and confirm that
“OK” is displayed.
Press the [RIGHT] cursor button and proceed to the next item.
1.
Press the button according to the LCD display.
2.
When the button is pressed, the button to be pressed next is displayed on
the LCD screen.
3.
If a button different from the one displayed is pressed, “Err:Check NG!”
is displayed.
9.MUTE
Lastly, press the [LOOP PHRASE IMPORT] button to proceed to the next item.
1.
Internal oscillation signal (1kHz: Sine wave) is output and on and off of
mute is repeated at regular intervals.
2.
Confirm that the waveforms for LINE OUT and PHONE appear and
disappear at regular intervals.
*
Since this mute occurs on analog circuits, some sound leaks in even during
MUTE.
3.
3.FOOT SW
1.
Step on the FOOT switch.
When the FOOT switch is pressed, it will automatically proceed to the
next item.
3.
4.EXP PEDAL
1.
Bring back the EXP PEDAL to the front and press down again.
2.
Confirm that “127 OK” is displayed.
3.
Confirm that the value remains as “127” even when the EXP PEDAL plug
is pulled out.
4.
Press the [RIGHT] cursor button and proceed to the next item.
5.ENCODER & LCD
1.
All dots are displayed when the encoder is turned.
Press the [RIGHT] cursor button and proceed to the next item.
10.GUITAR A/B
1.
Input a 40mV, 1kHz rectangular wave to MIC2(XLR)
2.
Confirm that the waveforms for the L/R channels of LINE OUT
alternately appear and disappear.
11.AF/AD
1.
Input a 200mVp-p, 1kHz sine wave to GUITAR/BASS jack.
2.
Lower SENS of GUITAR/BASS, and confirm that the size of L and R
when LINE OUT Rch distortion disappears is equal.
2.
Turn the encoder to the right and confirm that the LCD display becomes darker.
3.
Pull out the GUITAR/BASS jack after inspection.
3.
Turn the encoder to the left and confirm that the LCD display becomes lighter.
4.
Press the [RIGHT] cursor button and proceed to the next item.
4.
Press the [RIGHT] cursor button and proceed to the next item.
18
BR-1180
12 MIC2 PHANTOM
18.SUB MIX AUDIO
1.
Pressing the [ENTER] button switches PHANTOM on and off .
1.
Input a 1kHz 400mVp-p rectangular wave to LINE IN L/R.
2.
Using a tester, measure the voltage between the MIC2(XLR) 2(HOT) and
3(COLD) pins and 1(GND) while PHANTOM is on, and confirm that it is
45V to 50V.
2.
Confirm that waveform is output from LINE OUT L/R.
3.
Press the [RIGHT] cursor button and proceed to the next item.
3.
Connect an instrument (condenser mic, etc) compatible with PHANTOM
power to MIC2 and confirm that the waveform that is input is output
from LINE OUT.
19.LINE ON/OFF
1.
Input a 1kHz 400mVp-p rectangular wave to LINE IN L/R.
4.
Press the [RIGHT] cursor button and proceed to the next item.
2.
Confirm that the waveforms for the L/R channels of LINE OUT appear
and disappear.
3.
Press the [RIGHT] cursor button and proceed to the next item.
13.GTR/MIC2 AUDIO
1.
Input a 40mV, 1kHz rectangular wave to MIC2(XLR).
2.
Move the SENS knob of GUITAR/BASS from MAX to MIN to MAX, and confirm
that the waveform for the L/R channels of LINE OUT changes smoothly.
3.
Confirm that the PEAK LED starts to come on when the SENS knob is
turned to 2 o’clock.
20.LINE AUDIO
1.
Input a 1kHz rectangular wave to LINE IN L/R.
2.
Confirm that the waveform is output from LINE OUT L/R.
3.
Turn the [PHONE VOLUME] knob and confirm that the waveform
changes smoothly.
4.
Pull out the plug for LINE IN L/R.
5.
Confirm that residual noise for LINE OUT L/R is -80dBm(JIS-A) or
under.
Press the [RIGHT] cursor button and proceed to the next item.
4.
Confirm that the waveform disappears when a short plug is inserted into
MIC2(TRS).
5.
Pull out the short plug.
6.
Pull out MIC2(XLR).
7.
Turn SENS of MIC2 to MAX and confirm that the residual noise level for
LINE OUT L/R is -78dBu(JIS-A).
6.
8.
Press the [RIGHT] cursor button and proceed to the next item.
21.HARD DISK
14.MIC1 A/B
1.
Input a 40mVp-p, 1kHz rectangular wave to MIC1(XLR)
2.
Confirm that waveforms for the L/R channels of LINE OUT appear and
disappear alternately
3.
Press the [RIGHT] cursor button and proceed to the next item.
15 MIC1 PHANTOM
1.
Pressing the [ENTER] button switches PHANTOM on and off.
2.
Using a tester, measure the voltage between the MIC1(XLR) 2(HOT) and
3(COLD) pins and 1(GND) while PHANTOM is on, and confirm that it is
45V to 50V.
3.
Connect an instrument (condenser mic, etc) compatible with PHANTOM power
to MIC1 and confirm that the waveform that is input is output from LINE OUT.
4.
Press the [RIGHT] cursor button and proceed to the next item.
Reading, writing and verification of the hard disk is performed.
If no error occurs, it will automatically proceed.
22.CD-RW DRIVE
The firmware and the model name for the CD-RW drive are displayed.
1.
Place the CD-RW(CD-R) media on the tray.
2.
CD-RW writing and verification are performed.
*
The test can be performed 99 times with one CD-R.
When using a CD-RW, erase data using CD ERASE of user mode after
testing 99 times.
23.INITIALIZE HDD
*
All contents of the hard disk are lost when this item is executed.
If not executing, press the [RIGHT] cursor button and proceed to the next
item.
16.MIC1 AUDIO
1.
Pressing the [ENTER] button initializes the hard disk.
1.
Input a 40mVp-p, 1kHz rectangular wave to MIC1(XLR).
2.
2.
Move the SENS knob of MIC1 from MAX to MIN to MAX, and confirm
that the waveform for the L/R channels of LINE OUT changes smoothly.
If no error occurs “OK” is displayed, and it will automatically proceed to
the next item.
3.
Confirm that the PEAK LED starts to come on when the SENS knob is
turned to 2 o’clock.
4.
Confirm that the waveform disappears when a short plug is inserted into
MIC1(TRS).
5.
Pull out the short plug.
6.
Pull out MIC1(XLR).
7.
Turn SENS of MIC1 to MAX and confirm that the residual noise level for
LINE OUT L/R is -78dBu(JIS-A).
8.
Press the [RIGHT] cursor button and proceed to the next item.
24.POWER OFF
1.
Input signal with level high enough to light up the PEAK LED for
MIC2(XLR).
2.
Press the [POWER] switch for at least 2 seconds.
3.
Confirm that LCD backlight and “PEAK LED” go out.
Check items for user mode
Checking DIGITAL OUT
17.SUB MIX
1.
Connect an instrument with optical DIGITAL IN.
1.
Input a 1kHz 400mVp-p rectangular wave to LINE IN L/R.
2.
2.
Confirm that the waveforms for the L/R channels of LINE OUT appear
and disappear.
Play the BR-1180 and confirm that the signal is output from DIGITAL
OUT.
3.
Press the [RIGHT] cursor button and proceed to the next item.
19
MAY.2002
BR-1180
BLOCK DIAGRAM
fig.block
ANALOG BOARD
SENS
PEAK
SENS
PEAK
GUITAR IN
MIC2(PHONE)
:PHANT0M
47.4[v]
MIC2(XLR)
C
C
N 14P N
1
1
0 CABLE 0
3
5
LINE OUT L
MIC1(PHONE)
SELECTOR
IC2
MIC1(XLR)
CODEC
IC5
AF-AD
IC46
LINE OUT R
LINE IN L
C
N
6
LCD UNIT
C
C
N 16P N
1
1
0 CABLE 1
8
1
LED MATRIX
SW BOARD
3.3V->
5V
LEVEL
IC38,41
HEADPHONE
DIGITAL
OUT
DIGITAL OUT
IF
IC25
GA
IC36
C
C
N 18P N
1
1
1 CABLE 1
7
2
SW MATRIX &
TAP SW
DA DATA
MCK,LRCK,BCK
00.00.00-00
AD DATA
LINE IN R
DRAM
IC47
DSP
IC27
RIBON CABLE 2P
POWER SW
X2
MULTIPLEX
IC32,29
ENCODER
C
C
N 18P N
1
1
0 CABLE 1
6
0
CPU
IC28
SDRAM
IC30
FADER&INPUT VR
FLASH
MEMORY
IC24
FLAT C
CABLE N
4
40P
HDD
DRIVE
EXP PEDAL
RESET
IC34
FOOT SW
MIDI IN
IDE
INTERFACE
IC35,39,42
DATA/ADDRESS
PC
IC26
X1
DATA/ADDRESS
CN5
FLAT
CABLE
50P
CN101
CDI-BR-1 PWB
CN102
CD RW DRIVE
IC23
MIDI OUT
20
21
MAY.2002
CIRCUIT BOARD(MAIN)
fig_MAIN.eps
View from components side
View from foil side
22
BR-1180
23
MAY.2002
BR-1180
CIRCUIT DIAGRAM(MAIN 1/4)
fig.main1-c
A[0:19],A[21:22]
AVSS
IC32
FLASH_CONTROL
CODEC_RESET#
MEMORY_RESET#
C287 C161 C162 C163 C164 C165
0.01 0.01 0.01 0.01 0.01 0.01
A +3. 3
R164
DA1
A +3. 3 1SS302
2
R167
470K
TP103
DACK2#
DACK1#
DACK0#
1K
1
C170
0.1
D
3
L21 N1608Z601
L22 N1608Z601
JK10
2
4
3
1
C173
NIU
D
D
R182
3
-
4
1
+
1K
D
C174
R184
47K
10/16
TC75S51F
IC33B
TC75S51F
-
R186
10K
N1608Z601
R188
2
4
3
1
FOOT SW
D
10P
D
C177
D
3
L24
JK11
D
39
40
41
42
43
44
45
46
L32
N1608Z601
83
84
DOUT COPY
85
DSP_INT#
1 86
TP110
60
C176
C175
0.1
2
D + 3. 3
DMAAK3/PBD3
DMAAK2/PBD2
DMAAK1/PBD1
DMAAK0/PBD0
TO01/P13
IP011/P12
TIO10/IP010/P11
PWM1/P10
TC3/IP113/P27
TC2/IP112/P26
TC1/IP111/P25
TC0/IP110/P24
TO02/P23
IP021/P22
TIO20/IP020/P21
NMI/P20
FOOT#
62
X1
CX-49G/5MHz
63
1
1
1
1
1
36
40
47
TP100
TP101
TP102
TP104
TP105
R166
R168
R170
R171
47
47
47
47
WE#
RD#
UDQM
WR#
47
CS7#
47
47
47
47
47
47
47
47
47
1K
61
CS4#
CS3#
CS2#
CS1#
CS0#
SDRAS
#
SDCAS#
SDCLK
SDCKE
2
3
4
5
6
7
8
9
CS7#
CS4#
CS3#
CS2#
CS1#
CS0#
2
3
4
5
6
7
8
9
C178
NIU
C179
0.1
D
64
59
D
R189
10K
D
IC34
18
57
58
VPP/MODE2
MODE1
MODE0
X2
R192
10k
C210
0.01
D
D
R187
10k
D
NC
C208
0.1
C205 S-80930CNM
C
0.1
D
D
134
124
112
98
81
37
47
27
8
VDD
VDD
VDD
VDD
VDD
VDD
VDD
VDD
VDD
CVSS
RESET
C196 C197C198C199C200C201 C202C203
0.1 0.1 0.1 0.1 0.1 0.1 0.1 0.1
D
D
C311 C312 C313 C314
NIU
NIU
NIU
0.01
C315 C316 C317 C318
NIU
0.01 NIU
0.01
C250 C251
C252
0.1
0.1
0.1
D
TP229
1
L41
L42
L43
L44
L45
L46
L47
L48
20
1k
1k
N1608Z601
N1608Z601
N1608Z601
1k
N1608Z601
N1608Z601
TP230
1
C255 C256
0.1
1/50
D +3. 3
R232
100K
R234
100k
R233
100K
R236 100k
ENC-B
ENC-A
R235
100k
D
VCC
GND
10
RA22
EXBV8V103JV
1
1
1
1
1
1
1
TP19 6
TP19 7
TP19 8
TP19 9
TP20 0
TP20 1
TP20 2
KD0
KD1
KD2
KD3
KD4
KD5
KD6
KD7
1
1
1
1
1
1
1
1
TP20 3
TP20 4
TP20 5
TP20 6
TP20 7
TP20 8
TP20 9
TP21 0
47
47
47
47
47
47
47
47
1
2
3
4
1
2
3
4
2
1
3
4
D
C233 C234 C235 C236
0.01 0.01 0.01 0.01
C237 C238 C239 C240
0.01 0.01 0.01 0.01
D + 3. 3
C257
0.1
D
2
3
4
5
6
7
8
9
109
KL6 110
KL5 111
KL4 112
KL3 113
KL2 114
KL1 115
KL0 116
8
RA25
7 EXBV8V101JV
6
5
RA26
8
7 EXBV8V101JV
6
5
RA27
7
8 EXBV8V101JV
6
5
50
49
48
47
46
45
44
43
40
41
39
107
106
105
ENC_INT#
127
D +3. 3
1
R260
100k
C258
100/16
10
128
TAP_INT
D
RA34
EXBA10E103J
67
62
68
63
69
64
DREQ0#
DACK0#
DREQ1#
DACK1#
DREQ2#
DACK2#
1
1
1
1
TP171
TP172
TP173
TP174
CODEC_AD
CODEC_LRCK
TRR5
TRR4
TRR3
TRR2
1
1
1
1
TP175
TP176
TP177
TP178
TP159 1 129
TP160 1 130
TP161 1 132
R169
47 133
R172
47 134
TP164 1 135
137
47 138
CODEC_BCK
R175
CODEC_MCK
R178
47 139
TP167 1 141
76
131
31
18
59
93
128
DA7
DA6
DA5
DA4
DA3
DA2
DA1
DA0
AD3
AD2
AD1
AD0
LRCK1
LRCK0
BCK1
BCK0
WE
CAS
RAS
MCK1
MCK0
XTESTT
XTEST
S
TESTB
1
2
3
4
1
2
3
4
1
2
3
4
1
2
3
4
1
2
3
4
RA35
NIU
RA36
NIU
RA37
NIU
RA38
EXBV8VR000V
RA39
EXBV8VR000V
1
TP162
TP163
1
1
TP165
TP166
1
8
7
6
5
8
7
6
5
8
7
6
5
8
7
6
5
8
7
6
5
18
34
35
17
33
IO11
IO10
IO9
IO8
IO7
IO6
IO5
IO4
IO3
IO2
IO1
IO0
IO7
IO6
IO5
IO4
IO3
IO2
IO1
IO0
11
D 15
16
36
40
NC
NC
A9
A8
A7
A6
A5
A4
A3
A2
A1
A0
49
48
47
46
44
43
42
41
10
9
8
7
5
4
3
2
I/O15
I/O14
I/O13
I/O12
I/O11
I/O10
I/O9
I/O8
I/O7
I/O6
I/O5
I/O4
I/O3
I/O2
I/O1
I/O0
RAS
UCAS
LCAS
WE
OE
D
IO15
IO14
IO13
IO12
IO11
IO10
IO9
IO8
IO7
IO6
IO5
IO4
IO3
IO2
IO1
IO0
1
2
3
4
1
2
3
4
IO11
IO10
IO9
IO8
D +3. 3
8
7
6
5
8
7
6
5
RA9
EXBV8V103JV
RA10
EXBV8V103JV
L28
0
D +3. 3
C169
10/16
26
45
50
VSS
VSS
VSS
GM71V18163CT
- 6
D
D
HD power
C166
0.1
C167
0.1
12 V
CN3
1
2
3
4
B4B-XH-A
D +5
12
13
14
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
IDE_RESET#
DD7
DD8
DD6
DD9
DD5
DD10
DD4
DD11
DD3
DD12
DD2
DD13
DD1
DD14
DD0
DD15
DIOW#
DIOR#
D +3. 3
IORDY
D
D +3. 3
C209
0.1
R190
10k
INTRQ
DA1
D
LED_LVL
LED_LINE7
LED_LINE6
LED_LINE5
LED_LINE4
LED_LINE3
LED_LINE2
LED_LINE1
LED_LINE0
2
R248
ESPCLK
IN
ESP_TRS5
ESP_TRS4
ESP_TRS3
ESP_TRS2
23
47
28 TRS5
29 TRS4
30 TRS3
31 TRS2
D
GND
OUT
2
3
4
5
6
7
8
9
D7
D8
D6
D9
D5
D10
D4
D11
1
3
SG-8002JC(67.7376MHz)
19
1
C211
0.1
A1
A2
A3
A4
A5
A6
A7
A8
OE
DIR
RA19 EXBV8V470JV
LED_DATA7
LED_DATA6
LED_DATA5
LED_DATA4
LED_DATA3
LED_DATA2
LED_DATA1
LED_DATA0
OUT
ESP_TRR5
ESP_TRR4
ESP_TRR3
ESP_TRR2
TRCKI
N
ESP_SYNC
XRST
CPUCLK
KEY_LINE7
KEY_LINE6
KEY_LINE5
KEY_LINE4 SCAN LINE H
=
KEY_LINE3
KEY_LINE2
KEY_LINE1
KEY_LINE0
KEY_DATA7
KEY_DATA6
KEY_DATA5
KEY_DATA4
KEY_DATA3
KEY_DATA2
KEY_DATA1
KEY_DATA0
XKEY_INT
OE
XRD
XWR
XCS
CA6
CA5
CA4
CA3
CA2
CA1
CA0
CD15
CD14
CD13
CD12
CD11
CD10
CD9
CD8
CD7
CD6
CD5
CD4
CD3
CD2
CD1
CD0
GATE ARRAY
PULLDOWN
LDC_DATA7
LDC_DATA6
LDC_DATA5
LDC_DATA4
LDC_DATA3
LDC_DATA2
LDC_DATA1
LDC_DATA0
LCD_E
LCD_A
LCD_RW
TST1
TST0
ENC_B
ENC_A
XENC_INT
34
35
36
37
1
2
3
4
8
7
6
5
IC35
TC74LCX245FT
TRR5
TRR4
TRR3
TRR2
96
95
94
93
92
91
90
88
87
86
85
84
83
82
81
78
77
76
75
74
73
72
71
RD#
WR#
CS2#
A7
A6
A5
A4
A3
A2
A1
D15
D14
D13
D12
D11
D10
D9
D8
D7
D6
D5
D4
D3
D2
D1
D0
1
1
1
TP215
TP216
TP217
18
17
16
15
14
13
12
11
DA0
DA2
IDE_CS0#
IDE_CS1#
R210
10k
0.1
D
C230
2
3
4
5
6
7
8
9
D3
D12
D2
D13
D1
D14
D0
D15
D +3. 3
D
1
4
19
1
2
IC40
A1
A2
A3
A4
A5
A6
A7
A8
75401-0X0-B-S
TO HDD
CDR_5V
RA20
EXBA10E103J
OE
DIR
B1
B2
B3
B4
B5
B6
B7
B8
IC39
TC74LCX245FT
D
TC7SH08FU
18
17
16
15
14
13
12
11
RA21
EXBV8V330JV
8 DD3
7 DD12
6 DD2
5 DD13
1
2
3
4
1
2
3
4
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
IDE_RESET#
DD7
DD8
DD6
DD9
DD5
DD10
DD4
DD11
DD3
DD12
DD2
DD13
DD1
DD14
DD0
DD15
8 DD1
7 DD14
6 DD0
5 DD15
RA23
EXBV8V330JV
D +3. 3
D
R219
10k
IDE_WAIT
#
IDE_WAIT#
R220
82
IORDY
IDE_INT
IDE_INT
R221
82
INTRQ
IDE_RES#
R222
10k
R225
10k
61
60
D 0.1
C249
WR#
RD#
A2
A1
A3
CS7#
CS1#
D
2
3
4
5
6
7
8
9
19
1
A1
A2
A3
A4
A5
A6
A7
A8
G2
G1
Y1
Y2
Y3
Y4
Y5
Y6
Y7
Y8
R226
33
IC42
R227
22
DIOW#
18
17
16
15
14
13
12
11
R228
22
DIOR#
R229
1
2
3
4
33
8
7
6
5
IDE_RESET#
DA1
DA0
DA2
IDE_CS0
#
IDE_CS1
#
DIOW#
DIOR#
IORDY
INTRQ
DA1
DA0
DA2
IDE_CS0
#
IDE_CS1
#
D +3. 3
R230
10k
CDR_5V
R231
5.6k
CN5
1 +5V
2 GND
3 +5V
4 GND
5 +5V
6 GND
7 RESET#
8 GND
9 DD7
10 DD8
11 DD6
12 DD9
13 DD5
14 DD10
15 DD4
16 DD11
17 DD3
18 DD12
19 DD2
20 DD13
21 DD1
22 DD14
23 DD0
24 DD15
25 GND
26 (KEY)
27 DMARQ
28 GND
29 DIOW#
30 GND
31 DIOR#
32 GND
33 IORDY
34 CSEL
35 DMACK#
36 GND
37 INTRQ
#
38 IOCS16
39 DA1
40 PDIAG#
41 DA0
42 DA2
43 CS0#
44 CS1#
45 DASP#
46 GND
47 +5V
48 +5V
49 GND
50 TYPE#
75501-0X0-B-S
D
RA28
EXBV8V330JV
D
TO
CD-RW
10
TC74VHC541
D
2
1
30
29
28
27
26
25
24
23
22
21
20
19
18
17
16
15
14
13
12
11
10
9
8
7
6
5
4
3
2
1
30
29
28
27
26
25
24
23
22
21
20
19
18
17
16
15
14
13
12
11
10
9
8
7
6
5
4
3
2
1
TP231
TP2 32
TP233
TP234
TP235
TP236
TP2 37
TP238
TP239
D
D
D +3. 3
CN 4
1 RESET#
2 GND
3 DD7
4 DD8
5 DD6
6 DD9
7 DD5
8 DD10
9 DD4
10 DD11
11 DD3
12 DD12
13 DD2
14 DD13
15 DD1
16 DD14
17 DD0
18 DD15
19 GND
20 (KEY)
21 DMARQ
22 GND
23 DIOW#
24 GND
25 DIOR #
26 GND
27 IORDY
28 CSEL
29 DMACK#
30 GND
31 INTRQ
#
32 IOCS16
33 DA1
34 PDIAG#
35 DA0
36 DA2
37 CS0#
38 CS1#
39 DASP#
40 GND
D
RA18
EXBV8V330JV
D +3. 3
D
GA_RES
#
D
TAP_SWOUT
1
2
3
4
1
2
3
4
D +3. 3
TAP_SWIN
XDREQ0
XDACK0
XDREQ1
XDACK1
XDREQ2
XDACK2
B1
B2
B3
B4
B5
B6
B7
B8
C229
TRCKO
SYO
50MHz
100 RD#
97 WR#
101 CS2#
RA17
EXBV8V330JV
8 DD7
7 DD8
6 DD6
5 DD9
8 DD5
7 DD10
6 DD4
5 DD11
D
0.1
26
25
53
102
1
2
3
4
D
TC223C080AF-101(ESP4)
VDD
TO HDD
POWER
C168
0.1
R193
47
4
2
3
D
1
6
25
VCC
VCC
VCC
NC
NC
NC
NC
NC
D
D
C260
0.0047
VDD
30
19
20
32
31
30
29
28
27
24
23
22
21
D
D +3. 3
SIL50753
D
C259
0.0047
D
2
1
14
15
16
17
18
19
20
21
KD7 118
KD6 119
KD5 120
KD4 121
KD3 122
KD2 123
KD1 124
KD0 125
126
R261
100(1W)
D
TRS5
TRS4
TRS3
TRS2
118
119
121
122
123
125
R162
47 126
TP158 1 127
TP149 1
TP151 1
TP153 1
TP155 1
R161
47
19
18
3
9
SYO
IC47
D +3. 3
10k
28
27
25
24
23
21
20
19
17
16
50
49
48
47
46
45
43
42
41
40
39
38
35
34
33
32
10
9
8
7
5
4
3
2
LRS
EMPH
TRCKO
142
143
X2
LD7
LD6
LD5
LD4
LD3
LD2
LD1
LD0
KEY_INT#
C232
0.1
C296
100p
C298
100p
C300
100p
C302
100p
C304
100p
C306
100p
ED23
ED22
ED21
ED20
ED19
ED18
ED17
ED16
ED15
ED14
ED13
ED12
ED11
ED10
ED9
ED8
ED7
ED6
ED5
ED4
ED3
ED2
ED1
ED0
OSC
D
RA16
EXBA10E103J
IC36
TP218
TP219
TP2 20
TP221
TP222
TP223
TP224
TP2 25
TP226
TP227
TP228
RA24
KL0
KL1
KL2
KL3
KL4
KL5
KL6
R209
R211
R212
R213
R214
R215
R216
R217
KD0
KD1
KD2
KD3
KD4
KD5
KD6
KD7
R237 100k
LCD_BACKLI
T
19
1
D
D
EXBV8V103JV
D
C297
100p
C299
100p
C301
100p
C303
100p
C305
100p
G2
G1
KL0
KL1
KL2
KL3
KL4
KL5
KL6
R218
1k
TO
SWITCH
BOARD
CN107
C253 C254
0.1
0.1
A1
A2
A3
A4
A5
A6
A7
A8
D
SCAN_R1
SCAN_R2
SCAN_R3
SCAN_R4
SCAN_R5
SCAN_R6
SCAN_R7
SCAN_R8
18FE-BT-VKN
1
47
47
47
47
47
47
47
Y1
Y2
Y3
Y4
Y5
Y6
Y7
Y8
2
3
4
5
6
7
8
9
8
7
6
5
11
NC
LL0
LL1
LL2
LL3
LL4
LL5
LL6
LL7
10
NC
IC41
M54585KP
2
3
4
5
6
7
8
9
SCAN_S1
SCAN_S2
SCAN_S3
SCAN_S4
SCAN_S5
SCAN_S6
SCAN_S7
DIRECT
CTYPE
EAMPX
RFRSH
PWRSAV
GRAMC
SHRMD
D
1
1
1
1
1
1
1
1
1
20
C241 C242 C243 C244
0.01 0.01 0.01 0.01
C245 C246 C247 C248
0.01 0.01 0.01 0.01
I1
I2
I3
I4
I5
I6
I7
I8
CODEC_DA
1
1
1
1
1
1
1
1
1
1
1
TO SWITCH
BOARD
CN108
COM
D 0.1
19
18 O1
17 O2
16 O3
15 O4
14 O5
13 O6
12 O7
O8
16FE-BT-VKN
D
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
DIF_DATA
C158
0.1
C157
C159
0.1
0.1
D
1
LL7 4
LL6 5
LL5 6
LL4 7
LL3 8
LL2 9
LL1 10
LL0 11
KL[0:6],KD[0:7]
1
2
3
4
NC
R194
R195
R196
R197
R198
R199
R200
3.3V_CPU
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
1
D +5
IC37
TC74VHC541
8
7
6
5
1
2
3
4
1
2
3
4
C231
0.1
18
17
16
15
14
13
12
11
CN112
11
NC
I1
I2
I3
I4
I5
I6
I7
I8
CS
WR
RD
M2
M1
XI
EXBV8V470JV
8 TRS5
7 TRS4
6 TRS3
5 TRS2
ESP_CLK
C195
0.1
1
2
3
4
O1
O2
O3
O4
O5
O6
O7
O8
110
111
112
113
114 1
115 1
117
TP138
RA4
1
2
3
4
TP139
TP140
L30
N1608Z601
D
C213 0.01
C214 0.01
C215 0.01
C220 0.01
C221 0.01
C222 0.01
C228 0.01
LD0
LD1
LD2
LD3
LD4
LD5
LD6
LD7
C156
0.1
D +3. 3
D
D
2
3
4
5
6
7
8
9
30
C204
100/16
D
C212
D +5
IC38
M54563FP
D
19
18
17
16
15
14
13
12
20
GND
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
C227
0.1
EA9
EA8
EA7
EA6
EA5
EA4
EA3
EA2
EA1
EA0
COPY
NC
NC
CKS
14
CODEC_MC
K
C206
100/16
10
8
7
6
5
8
7
6
5
D
LDATA0
LDATA1
LDATA2
LDATA3
LDATA4
LDATA5
LDATA6
LDATA7
LSCAN0
LSCAN1
LSCAN2
LSCAN3
LSCAN4
LSCAN5
LSCAN6
LSCAN7
47
47
47
47
47
47
47
47
VCC
R201
R202
R203
R204
R205
R206
R207
R208
D
GND
RA41
EXBV8V471J
V
N1608Z601
N1608Z601
N1608Z601
N1608Z601
N1608Z601
N1608Z601
N1608Z601
N1608Z601
INT1
INT0
D
RA15
EXBA10E103J
CPUVDD
LL[0:7],LD[0:7]
L33
L34
L35
L36
L37
L38
L39
L40
12
46
6
52
28
41
54
10
D +3. 3
1
N1608Z601
CVDD
D +3. 3
C216 C217 C218 C219
0.01 0.01 0.01 0.01
C223 C224 C225 C226
0.01 0.01 0.01 0.01
65
66
67
68
69
70
71
10K
RA33
EXBA10E103J
L29
9
28
48
38
82
99
113
125
135
4
77
78
79
CS3#
WR#
RD#
D + 3. 3
0
D +3. 3
D + 3. 3 R163
1
3.3V_CPU
X1
D
TP179
TP180
TP181
TP182
TP183
TP184
TP185
TP186
1K
SYO
SYI
10
5
26
13
H:enable
MUTE
D +3. 3
D
CKSEL
1
2
3
OUT
VDD
VSS
1
1
1
1
1
1
1
1
R191
CD
LD0
LD1
LD2
LD3
LD4
LD5
LD6
LD7
5
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
NC
10
74
75
P52/TO03
P51/IP031
P50/IP030/TI030
PCM5/SELFREF
CPUVDD
3.3V_CPU
LGR4609-7000
CN111
NC
10P
C292
0.1
R275
1
14
27
3
49
9
43
D
SDRAS#
SDCAS#
SDCLK
SDCKE
WE#
RD#
UDQM
WR#
1
DSP_INT#
C160
10/16
VSSQ
VSSQ
VSSQ
VSSQ
VSS
VSS
VSS
D
L25
N1608Z601
RA40
EXBV8V471J
V
DQMU
DQML
TRS5
TRS4
TRS3
TRS2
TRS1
TRS0
TRCKO
10k
10k
MEMORY_RESET#
1
R158
TP14 1
50MHz
IDE_WAIT#
R173
100
TP107
101 1
102 1
TP108
R176
103
104
R177
R180
105
R181
106
107
R183
R165
108
109
R253
R254
110
R255
111
PCS7/CS7
PCS6/CS6/RAS6
PCS5/CS5/IORD
PCS4/CS4/RAS4
PCS3/CS3/RAS3
PCS2/CS2/IOWR
PCS1/CS1/RAS1
PCS0/CS0
PCD3/UBE/SDRAS
PCD2/LBE/SDCAS
PCD1/SDCLK
PCD0/SDCKE
R185
10K
D
+
1
D +3. 3
MUTE
5
A +3. 3
DA2
D +3. 3 1SS302
2
G-SEL-A#
G-SEL-B#
M-SEL-A#
M-SEL-B#
L-SEL#
phantom on/off
SUBMIX_SEL#
R179
10K
IC33A
C172
NIU
29
30
31
32
33
34
35
36
R160
90
91
87
88
89
92
93
94
95
96
97
PCM1/CLKO/BUSCL
PCM0/WAIT
PCM4/REFRQ
PCM3/HLDRQ
PCM2/HLDAK
PCT7/BCYST
PCT6/OE
PCT5/WE
PCT4/RD
PCT1/UCS/UW/UDQ
PCT0/LCS/LW/LD
Q
A +3. 3
C171
0.1
10K
LGR4609-7000
L23
N1608Z601
CDR-POWER
ON/OFF
POWERON/OFF
AF_AD#
D
R174
1
EXP PEDAL
1
DRQ3/IP103/P07
DRQ2/IP102/P06
DRQ1/IP101/P05
DRQ0/IP100/P04
TO00/P03
IP001/P02
TIO00/IP000/P01
PWM0/P00
39
15
OUT
CD7
CD6
CD5
CD4
CD3
CD2
CD1
CD0
52
53
54
DOUT COPY
TRR5
TRR4
TRR3
TRR2
R155
R156
OUTPUT MUTE
H:MUTE
29
28
21
20
DD[0:15]
TC74HC4053AF
D
19
20
21
22
23
24
25
26
UDQM
WR#
VDD
VDD
VDD
VDDQ
VDDQ
VDDQ
VDDQ
CKE
CLK
IC30
HY57V641620HGT-P
99
100
102
103
104
105
106
107
RST2
RST1
VPOUT
63
62
61
60
58
57
56
DA[0:2],IDE_CS[0:1}#,DIOR#,DIOW#,IDE_RESET#,IORDY,INTR
Q
7
VEE
1
DREQ2
#
DREQ1
#
DREQ0
#
37
38
64M
SDRAM
D7
D6
D5
D4
D3
D2
D1
D0
TRR5
TRR4
TRR3
TRR2
TRR1
TRR0
TRCKI
N
IS2
IS1
1
10
TP96
D
SDCKE
SDCLK
FLASH_CONTROL
IN
CKA2
CKA1
FR32
LBIT
D
12
11
10
C
B
A
INH
D15
D14
D13
D12
D11
D10
D9
D8
D7
D6
D5
D4
D3
D2
D1
D0
D15
D14
D13
D12
D11
D10
D9
D8
D7
D6
D5
D4
D3
D2
D1
D0
CA13
CA12
CA11
CA10
CA9
CA8
CA7
CA6
CA5
CA4
CA3
CA2
CA1
CA0
UBDA
VLDY
25
27
R250
10k
1
8
GND
9
10
11
6
8
7
6
5
8
7
6
5
8
7
6
5
8
7
6
5
53
51
50
48
47
45
44
42
13
11
10
8
7
5
4
2
81
82
83
84
86
87
88
89
91
92
94
95
96
97
FS2
FS1
2
3
4
5
6
7
8
9
TO SWITCH
BOARD CN106
1
2
3
4
1
2
3
4
1
2
3
4
1
2
3
4
D +3. 3
D
1
C155
0.1
P77/ANI7
P76/ANI6
P75/ANI5
P74/ANI4
P73/ANI3
P72/ANI2
P71/ANI1
P70/ANI0
0.1
CTG3
CTG2
CTG1
2
8
C267
0.1
V
G
I
D
2
3
4
5
6
7
8
9
AN5
AN4
AN3
AN2
AN1
AN0
A +3. 3
16
VCC
73
74
75
76
77
78
79
80
D
144
1
2
3
4
5
6
7
10
11
12
13
14
15
16
17
PDL15/D15
D14/PDL14
D13/PDL13
D12/PDL12
D11/PDL11
D10/PDL10
D9/PDL9
D8/PDL8
D7/PDL7
D6/PDL6
D5/PDL5
D4/PDL4
D3/PDL3
D2/PDL2
D1/PDL1
D0/PDL0
D
AN3
AN4
AN5
C141
IC27
BLOCK
24
23
22
20
D
4
15
14
ZCOM
YCOM
XCOM
DQ15
DQ14
DQ13
DQ12
DQ11
DQ10
DQ9
DQ8
DQ7
DQ6
DQ5
DQ4
DQ3
DQ2
DQ1
DQ0
CS
RAS
CAS
WE
0.1
17
16
1
6
15
22
29
36
44
55
64
72
80
85
98
108
116
124
136
144
18FE-BT-VK-N
1Z
0Z
1Y
0Y
1X
0X
2
3
5
1
2
13
12
RA32
EXBV8V101JV
CS4# 19
SDRAS# 18
SDCAS# 17
16
WE#
0.1
C140
VCC
72
0.1
C138
GND
C154
0.1
C136
DO2
DO1
L16
0
10
C153
100/16
AVDD/AVREF
0.1
20
RA31
EXBV8V101JV
71
0.1
C139
VCC
TC74HC4053AF
100
0.1
C137
DATA
LRCK
BCK
D +3. 3
GND
7
VEE
A +3. 3
D +3. 3
R159
D
C145
100/16
BA0(A13)
BA1(A12)
A11
A10
A9
A8
A7
A6
A5
A4
A3
A2
A1
A0
C135
7
4
6
DIF_DATA
CODEC_LRCK
CODEC_BCK
D +3. 3
CN1
GP1FA350TZ
10
8
7
6
5
D
TP187
TP188
TP189
TP190
TP191
TP192
TP193
TP194
1
2
3
4
C
B
A
INH
1
1
1
1
1
1
1
1
VR9
VR10
VR11
VR12
RA30
EXBV8V101JV
LL0
LL1
LL2
LL3
LL4
LL5
LL6
LL7
VR5
VR6
VR7
VR8
8
7
6
5
8
7
6
5
SCK0/P42
RXD0/SIO/P41
TXD0/SO0/P40
20
21
35
22
34
33
32
31
30
29
26
25
24
23
0.1
1
1
2
3
4
1
2
3
4
VR1
VR2
VR3
VR4
68
69
70
C144
0.1
16M FLASH
D
A22
A21
A12
A11
A10
A9
A8
A7
A6
A5
A4
A3
A2
A1
0.1
C134
20
C152
0.1
8
SCK1/P45
RXD1/SI1/P4
4
TXD1/SO1/P43
C132
VCC
VCC
GND
9
10
11
6
SI2/IP131/P31
SO2/IP130/P30
0.1
GND
65
66
67
IDE_RES#
A19
A18
A17
A16
A15
A14
A13
A12
A11
A10
A9
A8
A7
A6
A5
A4
A3
A2
A1
A0
0.1
C133
5
55
56
ENC_INT#
IDE_INT
A +3. 3
8
7
6
5
8
7
6
5
8
7
6
5
8
7
6
5
8
7
6
5
C131
DIGITAL OUT
C125
10/16
D
3
AN0
AN1
AN2
16
1
2
3
4
1
2
3
4
1
2
3
4
1
2
3
4
1
2
3
4
MEMORY_RESET#
R249
10k
1
1
1
1
4
15
14
ZCOM
YCOM
XCOM
R269 47
R251 47
A22
A21
TP211
TP212
TP213
TP214
1Z
0Z
1Y
0Y
1X
0X
VSS
VSS
VSS
VSS
VSS
VSS
VSS
VSS
VSS
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
AN[0:5]
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
3
5
1
2
13
12
A +3. 3
CN110
PAH9/A25
PAH8/A24
PAH7/A23
PAH6/A22
PAH5/A21
PAH4/A20
PAH3/A19
PAH2/A18
PAH1/A17
PAH0/A16
PAL15/A15
PAL14/A14
PAL13/A13
PAL12/A12
PAL11/A11
PAL10/A10
PAL9/A9
PAL8/A8
PAL7/A7
PAL6/A6
PAL5/A5
PAL4/A4
PAL3/A3
PAL2/A2
PAL1/A1
PAL0/A0
RXD2/IP120/P34
TXD2/IP133/P33
SCK2/IP132/P32
C291
NIU(0.1)
D +3. 3
D
D
R267
R270
NIU(4.7K)
10k
MBM29LV160BE
A13
A12
A11
A10
A9
A8
A7
A6
A5
A4
A3
A2
A1
A0
TP1 95
IC29
ADTRG/IP123/P37
IP122/P36
IP121/P35
R266
NIU(100)
C290
D NIU(0.1)
27
46
VSS
VSS
TSTEN
INP0
INP1
INP2
52
53
54
GA_RES#
KEY_INT#
D
114 1
115 1
116 1
117
118
119
120
121
122
123
126
127
128
129
130
131
132
133
136
137
138
139
140
141
142
143
VCC
0.1
0.1
55
56
57
58
TAP_INT
LCD_RESE
T
NIU(IL-S-7P-S2T2)
D
ENC-A
ENC-B
49
50
51
FOOT#
CE
WE
OE
RY/BY
BYTE
RESET
0.1
C147 C148 C149 C150 C151
0.01 0.01 0.01 0.01 0.01
BR-1180 MASK CPU(UPD703106GJ-XXX-8EN@)
C181
C146
0.01
IC28
1
2
3
4
5
6
7
C130
IC25
TC9271F
S
C190 0.1
1
2
3
4
5
6
7
C129
100/16
10
0.1
VSS
CN2
D
IC26
PC400
D
D
37
C188 0.1
C143
0.1
CS0#
WR#
RD#
10
1
C127
VSS
VSS
VSS
VSS
VSS
VSS
VSS
VSS
VSS
VSS
VSS
VSS
VSS
VSS
VSS
VSS
VSS
3.3V_CPU
D +3. 3
C186
5
0.1
C128
D +3. 3 RA2
EXBA10E103J
Q37
NIU(DTA143EKA)
2
D +3. 3
10
13
14
NC
NC
NC
C126
1VDD
1VDD
1VDD
1VDD
1VDD
1VDD
1VDD
1VDD
1VDD
1VDD
1VDD
YKF51-505
4
3
D +3. 3
26
11
28
15
47
12
C184 0.1
L20 N1608Z601
EXBV8V470JV
EXBV8V470JV
EXBV8V470JV
EXBV8V470JV
EXBV8V470JV
EXBV8V470JV
EXBV8V470JV
EXBV8V470JV
EXBV8V470JV
C124
0.1
1
15
RA3
RA5
RA6
RA7
RA8
RA11
RA12
RA13
RA14
TP90
TP91
TP92
D +3. 3
D +3. 3
VDD3
VDD3
VDD3
VDD3
R153
1k
4
0
C189 0.1
1
JK9
C187 0.1
120
D +3. 3
C142
0.1
2
3
4
5
6
7
8
9
2
3
4
5
6
7
8
9
D15
D14
D13
D12
D11
D10
D9
D8
D7
D6
D5
D4
D3
D2
D1
D0
VSS
VSS
VSS
VSS
VSS
VSS
VSS
VSS
VSS
VSS
VSS
VSS
VSS
VSS
VSS
VSS
R154
D57
1SS352
C182 0.1
100
DQ15/A-1
DQ14
DQ13
DQ12
DQ11
DQ10
DQ9
DQ8
DQ7
DQ6
DQ5
DQ4
DQ3
DQ2
DQ1
DQ0
D15
D14
D13
D12
D11
D10
D9
D8
D7
D6
D5
D4
D3
D2
D1
D0
C185 0.1
D +3. 3
22 1/2W
R151
1
N1608Z601
2
5
4
2
IN
R150
D
N1608Z601
L19
D +3. 3
L26
1
11
26
37
51
73
90
101
109
120
140
N1608Z601
L18
15
12
14
6
6
5
2
OUT
4
MIDI
L17
25
22
24
1 2
A19
A18
A17
A16
A15
A14
A13
A12
A11
A10
A9
A8
A7
A6
A5
A4
A3
A2
A1
A0
45
43
41
39
36
34
32
30
44
42
40
38
35
33
31
29
2
12
22
24
32
38
42
51
54
65
70
79
89
98
103
117
7
TRR[2:5]
D + 3. 3
VDD5
VDD5
VDD5
VDD5
VDD5
VDD5
VDD5
VDD5
VDD5
VDD5
VDD5
22
9
16
17
48
1
2
3
4
5
6
7
8
18
19
20
21
22
23
24
25
C180 0.1
R149
TRS[2:5]
RA1
EXBA10E103J
IC24
A21
A19
A18
A17
A16
A15
A14
A13
A12
A11
A10
A9
A8
A7
A6
A5
A4
A3
A2
A1
0.1
N1608Z601
R148
10k
A19
A18
A17
A16
A15
A14
A13
A12
A11
A10
A9
A8
A7
A6
A5
A4
A3
A2
A1
A0
C183 0.1
L15
IC23C
TC7W04FU
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
3
13
27
33
52
59
66
80
99
104
108
30
40
50
60
IC23A
TC7W04FU
TP7 1
TP7 2
TP7 3
TP7 4
TP7 5
TP7 6
TP7 7
TP7 8
TP7 9
TP8 0
TP8 1
TP8 2
TP8 3
TP8 4
TP8 5
TP8 6
TP8 7
TP8 8
TP8 9
TP170
1
D
A22
A21
3
D +3. 3
D
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
3
4
5
TP168
TP169
TP54
TP55
TP56
TP57
TP58
TP59
TP60
TP61
TP62
TP63
TP64
TP65
TP66
TP67
TP68
TP69
8
IC23D
TC7W04FU
D +3. 3
D15
D14
D13
D12
D11
D10
D9
D8
D7
D6
D5
D4
D3
D2
D1
D0
D[0:15]
IC23B
TC7W04FU
R238
10K
CN115
B2B-PH-K-S
24
TO LCD BACK LIT
CN6
52559-3092
C261 C262 C263
1/50 1/50 1/50
TO
LCD
D
LCD_RESET
25
MAY.2002
BR-1180
CIRCUIT DIAGRAM(MAIN 2/4)
fig.main2-c
TO SWITCH BOARD
CN105
C13
100p
R9
A
+9V
PHONE R
PHONE L
+9V
MUTE
+48V
+48V
LINE OUT R
GND
LINE OUT L
GUITAR
GND
MIC
GND
LINE INL
GND
LINEI NR
GND
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
1
2
3
4
5
6
7
8
9
10
11
12
13
14
10k
L16
TSL0709_151u F +
10k
2 -
10/16
+
A
R258
C14
1M
LGR4609-7000
GUITARIN
MI C
3 +
R12
10k
R13
4.7k
1
IC4A
M5218AL
C15
C92
C16
47/16
47/16
10/16
A
A
A
C24
R14
4.7k
C19
10/16
10/16
R53
100k
IC4B
M5218AL
cold
hot
C29
47/50
L2
NIU
2
4
7
3
1
C37
150p
NIU
R54
100k
C30
R22
C31
1k
10p
YKC21-3282
L
L7
NIU
LINE OUT
42
R
A
31
2
30dB_gain
A
L15
47/16
R25
47k
SBT-0260TF
2 -
R26
47k
C39
L14
NIU
47/16
R27
IC11A
M5218AL
1k
R28 33k
10/16
R66
R69
100k
R
1
3 +
HLJ4306-01-3080
A
10/16
Q9
RN1241
33k
A
L3
A
1k
A
10/16
R19
C62
C32
150p
JK5B
L6
NIU
C53
1k
R67
C63
1k
10/16
Q10
RN1241
1
A
R70
100k
A
A
2
JK3
MIC 2
1k
1
10
1
3
2
R16
47k
C38
47/50
R52
32
C22
A
R51
7
5 +
A
C52
47/16
6 -
3
JK2
NC3FAH
3
GUITAR/BASS
R257
Q1
2SK184GR
2
10k
3
2
4
3
1
1
C10
0.1
R8
JK1
1
2
3
4
5
6
7
8
9
10
11
12
13
14
+
+
L1
NIU
CN104
18FE-BT-VK- N
GND
+9V
GND
+9V
MICIN
GND
GND
GUITAR
GND
GND
GND
GND
CN103
14FE-ST-VK-N
TO MAIN BOARD
CN113
L
C68
A
C69
10/16
JK4
NC3FAH
R29
6.8k(MF)1/2W
R30
6.8k(MF)1/2W
10/16
R75
4.7k
R76
22k
C71
47p
C70
12
R56
C57
L9
C60
150p
47/16
R59
47k
6 -
NIU
HLJ4306-01-3080
C61
150p
A
A
R65
47k
R71
47/16
1k
A
4.7k
R91
22k
C82
47p
A
10/16
A
C84
6 -
A
C85
100/16
10/16
R68
4.7k
R98
100k
IC10B
M5216L
R97
100k
C87
150p
33k
R73
4.7k
220
A
+
R72
R93
7
5 +
+
IC11B
M5218AL
220
C81
7
5 +
C66
R90
10p
1k
C78
150p
10/16
C58
R57
R80
R83
100k
R88
330
VR1C
EVJC25 50kA L15
10
2
4
7
3
1
C55
30dB_gain
L8
NIU
JK6
IC10A
M5216L
R85
100k
A
33k
100/16
1
3 +
10/16
21
11
6.8k(MF)1/2W
C56
47/50
C75
2 -
A
C76
22
6.8k(MF)1/2W
R55
C65
47/50
10/16
20
R50
A
MIC 1
VR1B
EVJC25 50kA L15
23
13
10
1
3
cold 2
hot
VR1A
EVJC25 50kA L15
R100
330
C67
R103
4.7k
10/16
A
A
C93
10/16
R104
4.7k
R105 47k
A
JK5A
YKC21-3282
C72
12
2 -
L
LINE IN
10/16
C77
1
3 +
C74
10/16
IC12A
M5218AL
22
R
A
R78 47k
10/16
11
A
R86
100k
R87
100k
A
A
R106
JK5C
YKC21-3282
47k
R82 47k
+
6 R95
4.7k
C86
10/16
7
5 +
IC12B
M5218AL
IC4C
M5218AL
IC12C
M5218AL
A
C48
+
0.1
C33
10/16
A
-
C34
0.1
+
A
A
-
C35
0.1
+
A
-
C36
0.1
+
4
-
4
10/16
4
C47
4
A
26
IC11C
M5218AL
8
+
IC10C
M5216L
8
+
8
C88
10/16
8
10
R99
4.7k
A
A
27
MAY.2002
BR-1180
CIRCUIT DIAGRAM(MAIN 3/4)
fig.main3-c
R11
47/16
33k
13
5
4
3
R18
2.2k
C288
1
C25
C23
47/16
TC7S66F
1
R42
1k
3
C50
330p
NJM2374AM
A
A
+
C27
10/16
A
A
+
R31
100k
R21
4.7k
Q2
DTC114EU
A
1
A
8
4
+
R32
100k
phantom on/off
+
R33
100k
Q3
DTC114EUA
1
M-SEL-A#
H:OFF/L:ON
2
0.1
A
A
A
G-SEL-B#
H:OFF/L:ON
R35
100k
Q5
DTC114EUA
1
A
A
A
Q6
DTC114EUA
1
G-SEL-A#
H:OFF/L:ON
IC2E
TC4066BFT
H
+
IC13E
TC4066BFT
14
+
14
IC6E
TC4066BFT
C3
0.1
+
R34
100k
Q4
DTC114EUA
1
M-SELB #
H:OFF/L:ON
C90
0.1
C91
0.1
A
A
AF_AD#
:OFF/L:ON
A
D
A
5
+
R263
22/16
R45
R47
5.6k
10
IC6D
TC4066BFT
11
R265
6
IC13D
TC4066BFT
10
11
12
+
10k
R46
10k
1
IC7A
M5218AFP
2 R49
10k
R58
L
18k
C59
R60
R89
100k
Q12
DTC114EU
A
1
R101
100k
C89
1
3 +
IC8A
M5218AFP
+
+
IC13C
TC4066BFT 100k
8
9
3 +
C54
0.0012
10/16
5
IC6C
TC4066BFT
9
82p
2 -
C79
12
8
18k
R48
22k
A
6
R92
100k
22/16
C51
R84
100k
R264
100k
+
+
R44
+
IC13B
TC4066BFT
3
4
13
IC13A
TC4066BFT
1
2 100k
C49
IC6B
TC4066BFT
3
4
3
A
+ R262
IC6A
TC4066BFT
1
2 100k
H:OFF/L:ON
L-SEL#
R62
R63
5.6k
22k
C64
0.0012
+
A
10k
R61
82p
6 -
10dB
fc=23k
SUBMIX_SEL#
2
R77
100k
13
D
C42
+
C309
NIU
A
+
0.1
A
C46
D
C41
+
14
47k
A
C308
0.1
-
+
phantom power supply
H:ON/L:OF
F
10/16
R43
A
IC8C
M5218AFP
+
3
A
C40
R17
4.7k
1
Q8
DTC114EUA
A
Q7
2SA1586GR
IC7C
M5218AFP
A
7
CT
R41
100k
D
7
GND
A
+
10/16
7
4
A
5
A
3
VIN-
+
3
VCC
R40
33k
2
2
IPK
ES
6
R38
100k
C21
1/50
A
2
CS
C45
100/50
C20
0.1
7
5 +
2
CD
C44
33/50
8
14
CODEC_DA
CODEC_LRCK
CODEC_MCK
CODEC_BCK
CODEC_RESET#
CODEC_AD
3
7
R37
3.9k
1
VCOM
IC3B
NJM2100M
2
150
A
A
47.4V
3
8
+
1SS352
3
R39
R24
100k
SDTO
LRCK
MCLK
BCLK
DEM1
DEMO
PDN
A
C26
3
LQH4N151K0
4
IC9
100
2
2
C43
100/16
R36
D1
1
R20
33k
47/16
R23
100k
10p
16
ROUT
SDTI
2
IC46
6 -
12
+
RIN
10
11
12
7
6
13
CODEC
IC5
AK4552VT
(1.8Vpp)
1
3
IC2D
TC4066BFT
11
10
A
15
LOUT
10/16
R15 10k
A
C5
A
LIN
9
9
0.1
+
A
2
2
L5
C18
C289
0.1
A
L4
ELL6SH2R7M(2.7uH
)
1
3 +
IC2C
TC4066BFT
R2
10k
R4
10
C6
10/16
IC3A
NJM2100M
18FE-BT-VK-N
+
10p
2 A
+
8
C9
10/16
A
2
IC2B
TC4066BFT
3
4
C17
C8
0.1
10/16
5
TO ANALOG BOARD
CN104
1
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
1
2
3
4
5
6
7
8
LINE OUTL
9
GND 10
LINE OUTR
11
+9V 12
PHONER 13
PHONEL 14
+9V 15
MUTE 16
+48V 17
+48V 18
C12
C7
0.1
A
R5 10k
R7
100k
C4
-
IC2A
TC4066BFT
A
CN113
GUITAR
GND
MIC
GND
LINE INL
GND
LINE INR
GND
+
R6
100k
2
+
A
4
+
Q13
RN1441
1
R1
10k
5
3
47
A
C2
10/16
8
D
4
A
8
C1
0.1
A
IC3C
NJM2100M
1
OUT
4
A
IN
VA
R
R94
3
6
2
A
R276
NIU
40mA/0.35W
IC1
UPC29L33T
+
C307
NIU
VD
2
DTC114EUA
L49
N1608Z601
VSS
2
Q34
LGR4609-7000
C83
NIU
3
3
DTA143EKA
1
MUTE
A
C310
10/16
HEADPHONE
C80
NIU
1
Q38
2
H:ON/L:OFF
L11
N1608Z601
JK7
GND
Q11
RN1441
1
R152
10k
2
4
3
1
47
3
D58
1SS352
2
1
+
L10
N1608Z601
R81
+
5 +
10k
7
IC7B
M5218AFP
6 R64
10k
R
7
5 +
IC8B
M5218AFP
H:OFF/L:ON
A
R74
4.7k
10/16
+
C73
10/16
R79
4.7k
3
R96
100k
A
A
1
2
Q14
DTC114EUA
A
28
29
MAY.2002
BR-1180
CIRCUIT DIAGRAM(MAIN 4/4)
fig.main4-c
R139
2
R138
digital power
supply(5V)
CN109
3
Q23
DTC114EUA
1
Q24
DTC114EUA
1
2
B4B-XH-A
CDR power
supply(5V)
100k
3
100k
1
2
3
4
2
TO +5V POWER BOARD
CN114
1
2
3
4
Q22A
CDR_5V
TPC8303
8
1
7
2
Q21A
TPC8303 D +5
8
1
7
4.5Amax
D
D
D
R141 1k
CDR-POWER ON/OFF
H:ON/L:OFF
C111
0.1
D
Q31B
LCD_BACKLIT
TPC8303
5
3
6
HD power
3
D
3
100k
Q36
DTC114EUA
1
2
Q27
DTC114EUA
1
C295
47/16
2
C294
0.1
OUT
hard disk power
supply(12V)
100k
D
2
GND
IN
C113
0.1
3
IC49
UPC29M33T
1
C112
470/16
3.3V_CPU
4
R259
R143
4
Q22B
TPC8303
5
3
6
D
D
R274
1k
2.5Amax
1
D
IC22
C117
0.1
R144
D
D
100k
3
D
CLM
1
OUT
digital power
supply(3.3V)
Q30
DTC114EUA
1
2
GND
2
5
C116
100/16
D55
RB051L-40
D
4
VCC
D +3. 3
4
C115
100/16
Q21B
TPC8303
5
3
6
L14
ELC10D470E(47uH)
2
2.4Amax
R273
0.22(0.1W)
3
L13
ELL6SH2R7M(2.7uH)
Q29
CPH6302
6
5
2
4
1
D
3
IN
M62270GP
Q31A
TPC8303
8
1
7
1
FL1
2
RB051L-40
HEC0470-01-640
C121
0.1
1
4
2
3
C120
470/16
C286
470/16
C293
0.1
3
R146
C118
0.1
C119
470/16
analog power
supply(+9V)
2
D56
OUT
+
100k
3
2
1
3
IN
2
1
JK8
GND
IC48
TA78M09F
SH-202
Q33
DTC114EUA
2
1
3Amax
A
A
R147 1k
POWER ON/OFF
H:ON/L:OFF
C123
0.1
D
30
31
MAY.2002
BR-1180
CIRCUIT BOARD(SW SHEET ASSY)
fig_ANALOG.eps
32
33
MAY.2002
BR-1180
CIRCUIT BOARD(ANALOG)
fig.analog-c
TO SWITCH BOARD
CN105
C13
100p
R9
A
+9V
PHONE R
PHONE L
+9V
MUTE
+48V
+48V
LINE OUT R
GND
LINE OUT L
GUITAR
GND
MIC
GND
LINE IN L
GND
LINE IN R
GND
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
GUITAR IN
10k
L16
TSL0709_151uF +
10k
2 -
10/16
+
A
GND
+9V
GND
+9V
MIC IN
GND
GND
GUITAR
GND
GND
GND
GND
1
2
3
4
5
6
7
8
9
10
11
12
13
14
C14
1M
LGR4609-7000
R258
3 +
R12
10k
R13
4.7k
1
IC4A
M5218AL
C15
C92
C16
47/16
47/16
10/16
A
A
A
C24
R14
4.7k
C19
10/16
10/16
R53
100k
IC4B
M5218AL
cold
hot
2
4
7
3
1
C37
150p
NIU
C30
R22
C31
1k
10p
YKC21-3282
L
L7
NIU
LINE OUT
42
R
A
31
A
L15
47/16
R25
47k
SBT-0260TF
2 -
R26
47k
C39
L14
NIU
47/16
R27
IC11A
M5218AL
1k
R28 33k
10/16
R66
1k
R69
100k
R
1
3 +
HLJ4306-01-3080
A
R54
100k
2
30dB_gain
L3
A
10/16
Q9
RN1241
33k
A
C62
C32
150p
JK5B
L6
NIU
C53
R67
C63
1k
10/16
Q10
RN1241
1
A
R70
100k
A
A
2
JK3
MIC 2
1k
A
10
1
3
2
C29
47/50
L2
NIU
1k
1
10/16
R19
R16
47k
C38
47/50
R52
32
C22
A
R51
7
5 +
A
C52
47/16
6 -
3
JK2
NC3FAH
3
GUITAR/BASS
R257
Q1
2SK184GR
2
10k
3
2
4
3
1
1
C10
0.1
R8
JK1
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
+
+
L1
NIU
CN104
18FE-BT-VK-N
1
2
3
4
5
6
7
8
9
10
11
12
13
14
MIC
CN103
14FE-ST-VK-N
TO MAIN BOARD
CN113
L
C68
A
C69
10/16
JK4
NC3FAH
R29
6.8k(MF)1/2W
R30
6.8k(MF)1/2W
10/16
R75
4.7k
R76
22k
C71
47p
C70
12
R56
C57
C58
R57
L9
C60
150p
47/16
R59
47k
6 -
HLJ4306-01-3080
C61
150p
A
A
47/16
R91
22k
C82
47p
A
10/16
A
C84
6 -
A
C85
100/16
10/16
R68
4.7k
R98
100k
R97
100k
C87
150p
IC10B
M5216L
R72
33k
R73
4.7k
220
A
+
1k
R93
7
5 +
+
IC11B
M5218AL
R71
4.7k
C81
7
5 +
R65
47k
C66
R90
10p
1k
NIU
A
10/16
10
2
4
7
3
1
220
R88
330
VR1C
EVJC25 50kA L15
30dB_gain
L8
NIU
JK6
C55
R80
R83
100k
C78
150p
IC10A
M5216L
R85
100k
A
33k
100/16
1
3 +
10/16
21
11
6.8k(MF)1/2W
C56
47/50
C75
2 -
A
C76
22
6.8k(MF)1/2W
R55
C65
47/50
10/16
20
R50
A
MIC 1
VR1B
EVJC25 50kA L15
23
13
10
1
3
cold 2
hot
VR1A
EVJC25 50kA L15
R100
330
C67
R103
4.7k
10/16
A
A
C93
10/16
R104
4.7k
R105 47k
A
JK5A
YKC21-3282
C72
12
2 -
L
LINE IN
10/16
C77
1
3 +
C74
10/16
IC12A
M5218AL
22
R
A
R78 47k
10/16
11
A
R86
100k
R87
100k
A
A
R106
JK5C
YKC21-3282
47k
R82 47k
+
6 R95
4.7k
C86
10/16
7
5 +
IC12B
M5218AL
IC12C
M5218AL
A
C48
+
0.1
C33
10/16
A
-
C34
0.1
+
A
A
-
C35
0.1
+
A
-
C36
0.1
+
4
-
4
10/16
4
C47
4
A
34
IC11C
M5218AL
8
IC4C
M5218AL
+
8
IC10C
M5216L
+
8
C88
10/16
8
10
R99
4.7k
A
A
35
MAY.2002
BR-1180
CIRCUIT DIAGRAM(+5V BOARD)
fig.5vboard-c
Q20
2SJ438
R134 1K
2
1
3
L12
TSL1315S-101
2
R260
100
D54
30DF2-FC
IC21
R137
0.1(2W)
8
CD
CS
1
R136
7.5k(matal)
C109
2200/16
1
R135
0.1(2W)
7
IPK
ES
6
C02
1000/16
GND
D
D
VCC
VIN-
4
2
CT
5
R140
2.2k(metal)
3
NJM2374AD
C110
330p
D
D
D
D
L13
ELC10D470E(47uH)
CN114
TO MAIN BOARD CN3
1
2
3
4
1
2
3
4
B4B-XH-A
D
36
37
MAY.2002
BR-1180
CIRCUIT DIAGRAM(SW)
fig.sw-c
VR8
EVUF2K 50kB
GUITAR
SENS
C102
0.1
20
R126
1k
3
1
VR6A
EWAP1@50kB
VR4A
EWAP1@50kB
TRACK6
TRACK8
TRACK11
1
1
2
4
3
C98
10/16
3
3
2
4
3
3
2
4
VR14B
EWAP1@50kB
VR13B
EWAP1@50kB
VR12B
EWAP1@50kB
VR11B
EWAP1@50kB
D
20
10
20
D
D
D
VR3B
EWAP1@50kB
20
10
VR4B
EWAP1@50kB
10
D
VR5B
EWAP1@50kB
20
VR6B
EWAP1@50kB
10
20
10
D
VR7B
EWAP1@50kB
10
20
20
D
VR10B
EWAP1@50kB
10
A
20
D
A
A
10
C106
10/16
C107
10/16
VR15B
EWAP1@50kB
D
Q19
2SC2458GR
TO MAIN BOARD
CN112
D
D
TO MAIN BOARD
CN111
CN107
REC
CLEAR
EFFECTS
PAN
V-TRACK
TRACK2
1
2
1
2
1
2
1
2
RED
RED
GREEN
3
1
R ED
GREEN
3
1
GREEN
3
1
2
LED35
SPR-505MVW
AUDIO CD
REC
PUNCH IN
PUNCH OUT
PUNCH ON/OFF
RED
LED21
SPR-505MVW
1
TRACK1
LED30
SLR-342VC
RED
2
2
LED9
SLR-342VC
RED
GREEN
3
1
RED
TRACK2
1
TRACK3
LED22
SPR-505MVW
2
2
LED23
SPR-505MVW
1
LED10
SLR-342VC
RED
GREEN
3
1
RED
GREEN
3
1
TRACK4
2
LED11
SLR-342VC
RED
2
2
LED24
SPR-505MVW
1
1
TRACK5
RED
GREEN
3
1
RED
GREEN
3
1
2
2
1
LED32
SLR-342VC
RED
REPEAT
1
RED
GREEN
3
1
RED
GREEN
3
1
LED8
SLR-342VC
RED
LED25
SPR-505MVW
2
2
TRACK6
2
2
1
TRACK7
LED26
SPR-505MVW
2
1
LED27
SPR-505MVW
CENTER CANCEL
LED20
SLR-342VC
RED
TIMESTRETC
H
BOUNCE
RIGHT
GREEN
INPUT
TUNER
EFFECTS
LED31
SLR-342M C
LINE
1
RED
LED13
SLR-342VC
RED
LED12
SLR-342VC
2
RED
LED14
SLR-342VC
2
LED16
SLR-342VC
1
1
RED
2
LED15
SLR-342VC
2
RED
1
1
LED17
SEL2210R
1
MASTERING
RED
2
LED18
SEL2210R
2
2
RED
2
LED19
SEL2210R
1
1
1
2
RED
2
1
D53
1SS133
SW51
EVQ11A05R
1
2
RHYTHM PATTERN
MIC1
GUITAR
GREEN
LED33
SLR-342MC
PLAY
MIDI
2
1
D7
1SS133
SW4
EVQ11A05R
1
2
2
1
D11
1SS133
SW8
EVQ11A05R
1
2
2
1
D18
1SS133
SW15
EVQ11A05R
1
2
2
1
D100
1SS133
SW52
EVQ11A05R
1
2
2
1
1
D27
1SS133
SW24
EVQ11A05R
1
2
2
POWER
D26
1SS133
SW23
EVQ11A05R
1
2
2
2
SW1
EVQ11A05R
RHYTHM ON/OFF
LED3
SLR-342VC
RED
R259 100
UTILITY
D36
1SS133
SW34
EVQ11A05R
1
2
TRACK8
1
1
1
1
RHYTHMPATTERN
UP
D12
1SS133
SW9
EVQ11A05R
1
2
MASTERING TOOL
LED4
SLR-342VC
RED
2
TRACK3
D37
1SS133
SW35
EVQ11A05R
1
2
2
D38
1SS133
SW36
EVQ11A05R
1
2
RHYTHM ON/OF
F
D28
1SS133
SW26
EVQ11A05R
1
2
2
TRACK4
D29
1SS133
SW27
EVQ11A05R
1
2
2
1
MASTERING
TOOL
2
D39
1SS133
SW37
EVQ11A05R
1
2
D21
1SS133
SW18
EVQ11A05R
1
2
2
1
2
TRACK8
1
1
2
1
2
TRACK1
REC MODE
D43
1SS133
SW41
EVQ11A05R
1
2
2
1
2
1
1
2
1
2
1
D48
1SS133
SW46
EVQ11A05R
1
2
2
1
D16
1SS133
SW13
EVQ11A05R
1
2
TRACKMUTE
EQ
MARK
D101
1SS133
SW53
EVQ11A05R
1
2
TRACK9/10
CHORUS
D8
1SS133
SW5
EVQ11A05R
1
2
D9
1SS133
SW6
EVQ11A05R
1
2
1
SEARCH<<
D30
1SS133
SW28
EVQ11A05R
1
2
D14
1SS133
SW11
EVQ11A05R
1
2
2
1
2
D49
1SS133
SW47
EVQ11A05R
1
2
LED28
SPR-505MVW
2
GREEN
3
1
UNDO/REDO
LEFT
LED7
SPR-505MVW
LOOP PHRASE
LED5
SLR-342VC
RED
1
2
1
D20
1SS133
SW17
EVQ11A05R
1
2
LED29
SPR-505MVW
TRACK9/10
1
TRACK5
D45
1SS133
SW43
EVQ11A05R
1
2
2
1
D40
1SS133
SW38
EVQ11A05R
1
2
LED 6
SPR-505MVW
DATAS/L
2
EXIT
2
1
AUDIO CD
REVERB
LINE
D3
1SS133
SW54
EVQ11A05R
1
2
2
1
D15
1SS133
SW12
EVQ11A05R
1
2
2
1
2
D17
1SS133
SW14
EVQ11A05R
1
2
LED34
SLR-342VC
RED
HD ACCESS
2
LDATA0
LDATA1
LDATA2
LDATA3
LDATA4
LDATA5
LDATA6
LDATA7
LSCAN0
LSCAN1
LSCAN2
LSCAN3
LSCAN4
LSCAN5
LSCAN6
LSCAN7
RED
1
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
RED
TRACK6
DATAS/L
1
D44
1SS133
SW42
EVQ11A05R
1
2
2
1
D41
1SS133
SW39
EVQ11A05R
1
2
ENTER
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
GREEN
3
1
TRACK7
2
1
2
D52
1SS133
SW50
EVQ11A05R
1
2
2
1
2
1
1
2
D46
1SS133
SW44
EVQ11A05R
1
2
2
1
2
1
2
1
1
2
1
LOOP PHRASE
D42
1SS133
SW40
EVQ11A05R
1
2
2
PLAY
D19
1SS133
SW16
EVQ11A05R
1
2
1
1
D25
1SS133
SW22
EVQ11A05R
1
2
D31
1SS133
SW29
EVQ11A05R
1
2
SEARCH>>
2
1
2
1
2
TIMESTRETCH
MIC1
TUNER
2
1
STOP
CN131
1
PUNCH IN
2
1
2
1
2
D24
1SS133
SW21
EVQ11A05R
1
2
D32
1SS133
SW30
EVQ11A05R
1
2
2
1
D10
1SS133
SW7
EVQ11A05R
1
2
ZERO
CN130
1
PUNCH DELETE
2
TAP
D33
1SS133
SW31
EVQ11A05R
1
2
2
1
D6
1SS133
SW3
EVQ11A05R
1
2
REW
SW25
EVQ11A05R
D13
1SS133
SW10
EVQ11A05R
1
2
D47
1SS133
SW45
EVQ11A05R
1
2
16FE-ST-VK-N
2
SCAN_R1
SCAN_R2
SCAN_R3
SCAN_R4
SCAN_R5
SCAN_R6
SCAN_R7
SCAN_R8
1
PUNCH OUT
SW2
EVQ11A05R
1
2
CENTER CANCEL
GUITAR
D51
1SS133
SW49
EVQ11A05R
1
2
D5
1SS133
2
FF
D34
1SS133
SW32
EVQ11A05R
1
2
2
D22
1SS133
SW19
EVQ11A05R
1
2
PUNCH ON/OFF
D50
1SS133
SW48
EVQ11A05R
1
2
2
REPEA
T
D35
1SS133
SW33
EVQ11A05R
1
2
2
SCAN_S5
SCAN_S6
SCAN_S7
1
SCAN_S4
2
SCAN_S3
D23
1SS133
SW20
EVQ11A05R
1
2
2
SCAN_S1
SCAN_S2
1
CN108
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
18FE-ST-VK-N
2
2
4
+3. 3
18FE-ST-VK-N
10
R131
100k
Q18
2SC2458GR
R132 100
3
D
38
2
4
VR3A
EWAP1@50kB
D
20
10/16
A
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
2
4
3
2
4
3
2
4
3
2
4
3
2
4
3
2
4
1
TRACK9/10 MASTER A
1
TRACK7
1
TRACK5
1
TRACK3
1
TRACK1
1
VR5A
EWAP1@50kB
1
VR7A
EWAP1@50kB
1
VR11A
EWAP1@50kB
1
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
VR13A
EWAP1@50kB
3
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
VR15A
EWAP1@50kB
20
3
IC20B
M5218AL
VR10A
EWAP1@50kB
TRACK4
10
R129 1k
1
5 +
LED2
SEL2210R
2
C105
7
VR12A
EWAP1@50kB
TRACK2
2
R128 18k
R130
4.7k
1
MIC
PEAK
C104 10p
A
TO MAIN BOARD
CN110
+
A
VR14A
EWAP1@50kB
0.1
10
+
C97
20
-
C103
10/16
R133
4.7k
1
2
3
A
8
IC20C
M5218AL
3
R127 1M
+
10
1
2
A
+
6 -
D
A +3. 3
D
CN106
2
MIC
SENS
B
2
C100
10/16
A
VR9
EVUF2K 100kA
L=17.5+7.5
1
Q17
2SC2458GR
1
1
R112
100k
A
14FE-ST-VK-N
A
10/16
C101
10/16
A
EN
A
1
R115
4.7k
EN1B
B EVE_GC1_F20_24B
D
Q16
2SC2458GR
R113 100
3
3
IC20A
M5218AL
R111
4.7k
C99
10/16
R110 1k
1
3 +
A
2
C96
2 +
4
GND
+9V
GND
+9V
MICIN
GND
GND
GUITAR
GND
GND
GND
GND
R109 18k
1
2
3
4
5
6
7
8
9
10
11
12
13
14
1
2
3
4
5
6
7
8
9
10
11
12
13
14
EN
LED1
SEL2210R
10p
C01
NIU
2
D
2
MIC
GUITAR
PEAK
+
CN105
GUITARIN
R107
1k
R108 1M
C95
EN1A
EVE_GC1_F20_24B
+
3
C94
10/16
TO JACK BOARD
CN103
A +3. 3
INPUT LEVEL
TIME/VALUE
2
VR2
EVUF2K 100kA
L=17.5+7.5
1
L=17.5+7.5
DOWN
39
MAY.2002
ERROR MESSAGES
SW test
If an operational problem occurs while in mode, the following message is displayed.
Err: Check NG!
Description: button other than the one specified is pressed.
Device test
NG: CPU RAM
Description: RAM inside the CPU cannot be read or written properly.
Cause:
CPU malfunction.
NG DRAM
Description: DRAM externally connected to the CPU cannot be read or written
properly.
Cause:
DRAM malfunction.
Pattern short, pattern shortage or solder malfunction between
CPU and DRAM.
NG: ESP IRAM0
NG: ESP IRAM1
NG: ESP GRAM
NG: ESP PRAM0
NG: ESP PRAM1
Description: internal memory cannot be read or written properly.
Cause:
ESP malfunction.
Pattern short, pattern shortage or solder malfunction between
ESP and CPU.
NG: ESP ERAM A0
Cause:
FADER test
Err: Others moved
Description: fader other than the one specified was moved.
Cause:
HDD Verify Error!!
Description: read and write failure to HDD.
Cause:
NG: ESP ERAM D0
NG: ESP ERAM D1
Description: DRAM externally connected to ESP cannot be read or written properly.
Cause:
external DRAM malfunction.
Data bus malfunction between ESP and external DRAM.
NG: GATE ARRAY MARQ
Description: HDD does not return response.
Cause:
GATE ARRAY malfunction.
Pattern short, pattern shortage or solder malfunction between
CPU and GATE ARRAY.
Clock is not supplied to GATE ARRAY.
Synchronized signal from ESP is not input to GATE ARRAY.
pattern shortage between HDD and CPU.
Connection failure of HDD.
No Disc!
Description: HDD cannot be recognized.
Cause:
pattern shortage between HDD and CPU.
Connection failure of HDD.
Incompatible drive is connected.
CD-RW test
Write Error!
Read Error!
Verify Error!
Description: CD-RW disc read and write failure .
Cause:
Description: DMA request from GATE ARRAY to CPU is not executed.
Cause:
Pattern short or pattern shortage between HDD and CPU.
HDD Time Out!!
Description: DRAM externally connected to ESP cannot be read or written properly.
external DRAM malfunction.
Address bus malfunction between ESP and external DRAM.
operational error.
Short circuit between the faders.
Abnormal analog reference voltage.
HDD test
NG: ESP ERAM A1
Cause:
operational error.
Switch detection circuit malfunction.
Pattern short or pattern shortage between CD-RW and CPU.
Abnormal power supply to the CD-RW drive
CD-RW drive connection failure.
Incompatible CD-RW drive is connected.
Finalized Disc!
Description: since the disc is already finalized, it cannot be written.
(Replace with an empty disk)
NG: GATE ARRAY READ
Disc Full!
Description: Reading cannot be made properly from GATE ARRAY.
Description: CD-RW disc is full.
(This will be displayed when this test is repeated several times on
the same disc. Either replace with an empty disc, or erase data on
the disc prior to use)
Cause:
GATE ARRAY malfunction.
Pattern shortage, pattern short or solder malfunction between
CPU and GATE ARRAY.
NG: GATE ARRAY VERIFY
Description: sound signal sent to GATE ARRAY does not return to CPU properly.
Cause:
40
GATE ARRAY malfunction.
Pattern short, pattern shortage or solder malfunction between
CPU and GATE ARRAY.
Pattern short, pattern shortage or solder malfunction between
ESP and GATE ARRAY.
Clock is not input to ESP correctly.
ESP malfunction.
MIDI test
NG
Description: MIDI IN and MIDI OUT are not connected.
Cause:
MIDI OUT error.
MIDI IN error.
MIDI cable break.
BR-1180
CDI-BR-1
fig.cover2
SPECIFICATIONS
BR-1180 will become the same
specification as BR-1180CD,
when CDI-BR-1 is attached.
ACCESSORIES
OWNER’S MANUAL ENGLISH/JAPANESE(#72017812)
DISCRETE DRUM CD-ROM (#********)
41
MAY.2002
PARTS LIST
fig.part1e
SAFETY PRECAUTIONS:
The parts marked
have
safety-related characteristics. Use
only listed parts for replacement.
CONSIDERATION ON PARTS ORDRING
When ordering any parts listed in the parts list, please specify the following items in the order sheet.
QTY
PART NUMBER
DESCRIPTION
MODEL NUMBER
Ex.
10
22575241
Sharp Key
C-20/50
15
2247017300
Knob (orange)
DAC-15D
Failure to completely fill the above items with correct number and description will result in delayed or even
undelivered replacement.
NOTE: The parts marked # are new. (initial parts)
CHASSIS
02899401
02899412
02899434
Q'ty
1
1
1
DD HOLDER CDRW L
DD HOLDER CDRW R
DD HOLDER CDRW STOP
DISK DRIVE UNIT
02782990
UJDA340
ATAPI CD-RW DRIVE
NOTE: Replacement UJDA340 should be made on a unit base.
1
PCB ASSY
#
72017823
PCB ASSY
CDI-BR-1
CONNECTOR
02237512
02782645
75501-0X0-B
24 5600 050 100 883
CONNECTOR P/N
CONNECTOR
WIRING, CABLE
02902156
WIRING
IDE
1
40233978
40011490
40455867
SCREW M2X8
SCREW M3X6
SCREW M2X2.5
PAN MACHINE W/SW+PW ZC
PAN MACHINE W/SW BZC
PAN MACHNE W/SW
2
3
4
02899378
02899356
02899389
PAD LOWER
PACKING CASE
OUTER PACKING CASE
1
CN101 on CDB
CN102 on CDB
1
1
SCREW
PACKING
#
#
#
MISCELLANEOUS
01016223
02899445
40456956
FOOT
INSULATING SHEET
LABEL
ACCESSORIES (STANDARD)
********
DISCRETE DRAMS CDROM
#
72017812
OWNER’S MANUAL SET
42
1
1
1
30X10X3
CDRW
CD R/W LABEL
ENGLISH/JAPANESE
1
1
1
1
BR-1180
INSTALLING THE CDI-BR-1
6.
When installing CDI-BR-1, perform as follows.
fig.05
1.
Turn off the power to the BR-1180 and any connected devices, and
disconnect the AC adapter and all other connector cables.
2.
Turn the BR-1180 over, remove the screws at the positions shown in the
figure, and remove the cover.
Tighten the screws included with the CDI-BR-1 in the positions indicated
in the figure (C) until snug, tighten the cover attachment screws until
they are snug, and then securely tighten all of the screws.
(C)
fig.01
(C)
(C)
(B)
(A)
7.
Turn the BR-1180 back over to its original position.
8.
Check the operation of the unit.
Confirm operation through “Test mode: 22.CD-RW DRIVE”.
*
3.
If the test mode does not operate properly, turn off the power, then repeat from
INSTALLING THE CDI-BR-1 operation 1.
Align the CDI-BR-1’s connector with the BR-1180’s socket and insert the
connector securely.
fig.02
4.
Position the CDI-BR-1 as shown in the figure so that the CDI-BR-1’s and
BR-1180’s attachment holes are aligned.
fig.03
5.
Replace the cover with the positions of the (A) and (B) sections of the
cover are reversed relative to their positions prior to the cover’s removal.
fig.04
(A)
(B)
43
MAY.2002
The wiring exchange method
BAN CARD BNCD-P=1.25-K-18150(#02124845)
When BNCD-P=1.25-K-18-150 (#02124845) is exchanged, please fix BAN
CARD to a chassis in the following procedure.
1.
1. You sticks 3M copper tape #2245 (#40346367) on the portion with which
BAN CARD and chassis are in contact
fig0004.jpg
2.
BAN CARD and a chassis are fixed by 3M copper tape #2245 (#40346367).
fig0003.jpg
3.
In addition, filament tape #3883 (#40122645) is stuck on a copper tape.
fig0002.jpg
44
WIRING 5V POWER(#02896956)
When WIRING 5V POWER (#02896956) is exchanged, please fix to a chassis by
filament tape #3883 (#40122645) at the following figure.
fig0001.jpg