www.thaikits.com CH-012 Transistor Curve Tracer Adapter for OSC This board has to be used with analog or digital oscilloscope which can display the signal in x-y mode, it is designed to has 2 ranges of Ib to bias 2 types of transistor , Small transistor / Power transistor and requires dual power supply +15V and -15V, due to main of components are op-amp which need dual supply to operate Technical information. -Require Power supply +15VDC/-15VDC (1A ) -Capable to check IV curve both NPN / PNP Power Transistor / Small Transistor -8 step Ib 0uA,24uA,48uA,72uA,96uA,120uA,144uA,168uA for small transistor -8 step Ib 0.0mA,0.32mA,0.64mA,0.96mA,1.28mA,1.6mA,1.92mA,2.24mA, Vce = +10V for NPN and -10V for PNP -Switching frequency 642Hz -2 Jumper to select ranges of Ib and type of transistor { NPN / PNP } -hole PCB for wiring to external 2 way switches to select ranges of ib and type of transistor -Require 2 CH Analog or Digital Oscilloscope in x-y mode to connect both CH to this adapter board ( CH1 is X-Axis and CH2 is Y-Axis ) -PCB size 9.0cm x 10.0cm How to setup - Switch on OSC - Connect X to CH1 of OSC and Y to CH2 of OSC - Connect dual power supply to the board { don’t swop between +15V and -15V } - Set time base of OSC to 500us to 1ms - Volt per DIV of CH1 = 2V / DIV - Volt per DIV of CH2 = 20-100mV / DIV - Put jumper to be suitable with your transistor NPN/PNP , first start with small transistor range . - Put transistor on test DUT socket, please put correct pin E , C , B. Don’t swop - Power on the IV curve tracer board - If no graph or you see only a few IV curves, this means that ib are not enough. Change jumper to select power transistor Warning : Don’t select between NPN / PNP during transistor is on the test DUT. Transistor maybe damaged. Note : Please ignore RCA connector on PCB layout. We stopped to use this RCA connector since 2014. So, No RCA connector in this kit. www.thaikits.com Diagram how to set-up Example how to calculate hfe of transistor 1 2 3 4 5 6 +6.2V 100K D +15VDC 1N5234 100K 1N5234 1N4148 100K 1N4148 100K D 100uF/35V Small Transistor GND 1N5234 1N4148 100K 1N5234 Power Transistor 1N4148 +6.2V RY2/1 -6.2V -15VDC 14 1N4148 8 10 13 NC NC NC 2 RST GND CLK VCC X? 1 Q1 Q2 Q3 Q4 Q5 Q6 Q7 7K5 7K5 DUT PNP 1N4148 12 11 9 6 5 4 3 1K 1 2 3 4 NPN 1N4148 RY1/2 1K E B C E 7K5 Small Transistor 1N4148 7K5 7K5 1N4148 7 4024 C C Power Transistor 1N4148 RY2/2 -6.2V 1N4148 +15V 1N4148 1N4148 100nF 11 BD139 1nF 14 13 2 220K TL074 1 TL074 2 390 390 B Y 10 BD140 NPN 1N4148 470K RY1/1 11 TL074 1N4148 1N4148 J2 2 1 4 8 1 J1 11 4 9 10 3 PNP U?D 470K 560K +15VDC X 1 4 680K B +15VDC 4 U?C 12 U?B 6 7 100K 1N4148 220nF -15V 4K7 5 RY1 TL074 11 100 RY2 1N4148 A A Title Size B Date: File: 1 2 3 4 5 CH-012 Transistor Curve Tracer Adapter for OSC Number http://www.thaikits.com 13-Dec-2013 D:\CH-0121.DDB Revision 1.00 Sheet of Drawn By: 6