1,5W DC-DC Converter P1Q-Series
●
●
●
●
●
●
●
●
2:1 Wide Input Voltage Range
Long Life Without Electrolytic Capacitor
Low Ripple & Noise
Five-Sided Shield
Over Current Protection
Short Circuit Protection
Package 28 x 16 x 7,8 mm
Adjustable Output Voltage
Model selection guide
Typ
Input
nominal
voltage
Single output
P1Q05S33
P1Q05S05
P1Q05S12
P1Q12S33
P1Q12S05
P1Q12S12
P1Q24S33
P1Q24S05
P1Q24S12
P1Q48S33
P1Q48S05
P1Q48S12
Dual output
P1Q05D12
P1Q12D12
P1Q24D12
P1Q48D12
Input
current
full-load
Output
voltage
Output
voltage
Range
Output
current
Efficiency
typ.
Capacitor
load max.
[VDC]
[mA]
[VDC]
[VDC]
[mA]
[%]
[uF]
4,5…9
4,5…9
4,5…9
9…18
9…18
9…18
18…36
18…36
18…36
36…75
36…75
36…75
426
469
455
167
181
176
84
88
88
42
44
44
3.3
5
12
3.3
5
12
3.3
5
12
3.3
5
12
2,84..3,67
4,3..6
12..15
2,84..3,67
4,3..6
12..15
2,84..3,67
4,3..6
12..15
2,84..3,67
4,3..6
12..15
400
300
125
400
300
125
400
300
125
400
300
125
66
68
70
70
73
75
70
75
75
70
75
75
1650
750
350
1650
750
350
1650
750
350
1650
750
350
4,5…9
9…18
18…36
36…75
450
174
85
43
±12
±12
±12
±12
±12..±15
±12..±15
±12..±15
±12..±15
±60
±60
±60
±60
68
73
75
75
2 x 120
2 x 120
2 x 120
2 x 120
Output voltage adjustment
Designation
suffix
……S33
……S05
……S12
……D12
VOUT @ pin 5
open
3.3 V
5.0 V
12.0 V
±12.0 V
VOUT @ RTrim up
3.3…3.67 V
5.0…6.0 V
12.0…15 V
±12.0…±15 V
Trim up Resistor
[kΩ]
Vout=(3.3*R+36.7)/(R+10)
Vout=2.5*(2+2.7)/(R+6.8)
Vout=2.5+9.5*(R+10.9)/(R+8.2)
Vout=2.5+22*(R+12.7)/(R+10)
VOUT @ RTrim down
3.3…2.84 V
5.0…4.3 V
Output can be externally trimmed by using the method shown below.
4(3)
5(5)
Trim down Resistor
[kΩ]
Vout=(3.3*R+36.7)/(R+12.92)
Vout=2.5*(2+2.7)/(R+6.8)
( ) for dual output
TRIM UP
TRIM DOWN
6(6)
Page 1 of 2
Deutschland:
Inselkammerstraße 10
D-82008 Unterhaching
Tel.: 089 614 503-10
E-Mail: power@hy-line.de
Schweiz:
Gründenstraße 82
CH-8247 Flurlingen
Tel.: 052 647 42 00
E-Mail: power@hy-line.ch
1,5W DC-DC Converter P1Q-Series
Specifications
Input
Voltage range
Filter
Input surge voltage for
100mS max.
Output
Power
Voltage accuracy
Voltage adjustability range
Ripple and noise @ 50MHz
bandwidth
Short circuit protection
Over current protection
Line voltage regulation
Load voltage regulation
10%…100%
Temperature coefficient
Minimum load
4.5..9, 9..18, 18..36, 36..75VDC
LC type
5V type : 15 VDC max.
12V type : 36 VDC max.
24V type : 50 VDC max.
48V type : 100 VDC max.
1,5 W max
Single & Dual
See table
120mVp-p, max
±2%
Continuous, automatic recovery
180 %, typ.
0.2%
0.5%
± 0.02% / °C max.
0%
General
Efficiency
Switching frequency
Transient response recovery time
Isolation voltage
Isolation Resistance
Isolation Capacitance
Case material
Base material
MTBF
Bellcore TR-NWT-000332
Environmental
Operating temperature
Storage temperature
Cooling
Thermal shock
Vibration @ no operation
Shock
Humidity range
Physical
Dimensions
500µs
650 Fit, @Ta 40°C, 100%
6
stress: 1.5x10 hrs
-20 °C to +70 °C
with derating
-40 °C to +85 °C
Nature convection
MIL-STD-810D
10..55..10Hz, sweep for 15min,
1.5mm, (9G, X, Y, Z for 2 hrs each)
100G
20% to 95% RH
1.1 x 0.63 x 0.31 inches
28 x 16 x 7.8 mm
8g
Weight
Dimensions
See table
100…1500 kHz
@25% load change
500 VDC
6
50 Ω @ 500 VDC
300 pF, typ.
Metal
None
Derating
Pin connections
PIN
1
2
3
4
5
6
Single
+ Input
- Input
No Pin
- Output
TRIM Input
+ Output
Dual
+ Input
- Input
- Output
Common
+ Output
TRIM Input
Life Support Policy: HY-LINE does not authorize
the use of any of its products for use in life support
devices or systems without the express written
approval of an officer of the Company. Life support
systems are devices which support or sustain life,
and whose failure to perform, when properly used
in accordance with instructions for use provided in
the labeling, can be reasonably expected to result
in significant injury to the user.
Rev: 10 / 2004 f
All dimensions in inches (mm)
Pin Pitch tolerance ± 0.014 (0.35)
Page 2 of 2
Deutschland:
Inselkammerstraße 10
D-82008 Unterhaching
Tel.: 089 614 503-10
E-Mail: power@hy-line.de
Schweiz:
Gründenstraße 82
CH-8247 Flurlingen
Tel.: 052 647 42 00
E-Mail: power@hy-line.ch