U L T R A
V IO L E T
W
A T E R
D IS IN F E C T IO N
S Y S T E M S
Presenting the DaRo UV Systems Saphir UV
water disinfection system.
The Saphir system is a compact, economical UV system that is
designed with the consumer in mind. The Saphir system utilises
commonplace single ended low pressure UV lamp technology, thus
making the system not only economical for energy running costs,
but also for replacement UV lamps. The single ended UV lamp also
makes servicing the equipment very simple.
EXPERTI SE
• Decades of experience in design and
manufacture of UV disinfection systems
• Wealth of water treatment knowledge
• We are happy to help choose the
DaRo UV Systems are specialists in ultraviolet disinfection and have
been manufacturing systems for over 25 years.
correct systems to meet your
requirements
Q U A LI TY
• Products are designed, manufactured
and tested in our modern manufacturing
facilities in the UK
• Products are manufactured and tested
in accordance with BSEN: ISO9001
A PPR O VED
• Our technology is a proven method of
disinfection, approved by health
specialists
STA N D A R D FE ATU R E S
• Water Resistant power control module (IP55)
• Long life / High Reliability UV Lamp
• Minimum 10 Bar Working Pressure
• Simple To Install
• Lamp On Indicator
• Simple To Service
• Electropolished Chamber
• Commonplace UV Lamps
O PTI O N S
• Lamp / Electrical Failure
Indicator
• UV Lamp Status Indicator
• Volt free contacts
Please see Saphir+ data sheet
for further details
PER FO R MA N C E
• All systems comply with
international UV dose
standards.
• All units are designed to meet
standards even at end of lamp life.
• All systems are WRAS (Water
Regulations Advisory Scheme)
approved and certified
EC O N O MI CA L
• Very low running costs – less than
5p per 24-hour period.
• Utilising commonplace UV Lamps.
• Designed for ease of installation and
maintenance.
T H E S P E C IA L IS T S IN
U L T R A V IO L E T L IG H T
T: 0131 553 4001 www.ferrierpumps.co.uk
U L T R A
V IO L E T
W
A T E R
D IS IN F E C T IO N
S Y S T E M S
C H O O SI N G YO UR SYSTE M
The following table gives performance details on the Saphir range. To choose the correct unit simply match the
application against the unit required. If in doubt, please contact your local stockist or our head office
Type
Flow rate*
30mJ/cm²
Flow rate* Connection
40mJ/cm²
UV lamp
Typical
Application
Lamp life
Construction
Power
supply
Chamber
length
18 L/min
13.5 L/min 3/4" male
bsp thread
GER15SE
Small dwelling
8760 hours
(Approx 1 year)
316 SS
240v 50hz
single phase
405mm
Saphir 2 30 L/min
22.5 L/min 3/4" male
bsp thread
GER25SE
Whole house
(Family home)
8760 hours
(Approx 1 year)
316 SS
240v 50hz
single phase
554mm
Saphir 3 53 L/min
40 L/min
3/4" male
bsp thread
GER25SEXO Large dwelling
(Family home)
8760 hours
(Approx 1 year)
316 SS
240v 50hz
single phase
554mm
Saphir 4
60 L/min
45 L/min
1" male
bsp thread
GER36SE
8760 hours
(Approx 1 year)
316 SS
240v 50hz
single phase
962mm
Saphir 7
118 L/min 90 L/min
1" male
bsp thread
GER36SEXO Multiple properties
(Guest house)
8760 hours
(Approx 1 year)
316 SS
240v 50hz
single phase
962mm
1.5" male
bsp thread
GER36SEXO Multiple properties
(Hotel)
8760 hours
(Approx 1 year)
316 SS
240v 50hz
single phase
962mm
Saphir 1
Saphir 10 160 L/min 120 L/min
Large dwelling
* Transmission = 98% per 1cm at end of lamp life
STA I N LE SS STE E L
Our stainless steel chambers have over 25 years of
proven reliability. Our extensive range of 316 stainless
steel chambers are designed to meet the stringent
requirements of industry.
D ATA SH EETS
DaRo UV Systems strive to keep abreast of new
developments in disinfection. Further datasheet
information on specific applications is available,
please contact us for further details.
All units use high efficiency lamps, requiring only
annual replacement.
FI LTR ATI O N
It is important that sediment in the water does not
obstruct the UV light. We strongly advise that a 5micron sediment pre filter is fitted before the chamber
to remove contamination. DaRo UV systems have an
extensive range of compatible filter units in stock to
match the UV chambers capacity. We will be pleased
to advise when choosing a unit and propose
corrective measures for other water problems
LA R G E R U N I TS
DaRo UV Systems can offer a range of larger standard
units. Our expertise in design and manufacture enables
us to tailor systems to specific site situations. The
systems that we have manufactured are in regular
use in a wide range of applications, from vending
machines to municipal drinking water treatment.
S T O C K I S T
Ferrier Pumps Limited
Edinburgh Depot
Burlington Street, Leith, Edinburgh, EH6 5JL
Tel: 0131 553 4001 Fax: 0131 553 1272
Glasgow Depot
71 Cumbernauld Road, Dennistoun, Glasgow, G31 2SN
Tel: 0141 554 3454 Fax: 0141 554 2772
Aberdeen Depot
Units 4 & 5, Barclayhill Place, Portlethen, Aberdeen AB12 4PF
Tel: 01224 782022 Fax: 01224 780050
Quick Change RO
ESPA Tecnoplus
Daro UV - Saphir
Ultra Violet Systems
The Saphir system is compact & economical
The system utilises commonplace single ended
low pressure UV lamp technology, thus making
the system not only economical for energy
running costs, but also for replacement lamps.
The single ended UV lamp also makes servicing
the equipment very simple.
ECONOMICAL
• Very low running costs
• Utilising commonplace UV Lamps.
• Designed for ease of installation and
maintenance.
ITT Teknospeed
PERFORMANCE
• All systems comply with international UV dose
standards.
• All units are designed to meet standards even at
end of lamp life.
• All systems are fully WRAS Approved.
*
FERRIER PUMPS LTD
Burlington Street
Leith
Edinburgh
EH6 5JL
Tel: 0131 553 4001
Fax: 0131 553 1272
Sahpir 1
18 l/min
3/4” Male
BSP
GER15SE
Small dwelling
8760 Hours
230v 50Hz
Single Phase
304 SS
405 mm
Sahpir 2
25 l/min
3/4” Male
BSP
GER25SE
Whole House
8760 Hours
230v 50Hz
Single Phase
304 SS
554 mm
Sahpir 3
45 l/min
3/4” Male
BSP
GER25SEXO
Large dwelling
8760 Hours
230v 50Hz
Single Phase
304 SS
554 mm
Sahpir 4
60 l/min
1” Male
BSP
GER36SE
Larger dwelling
8760 Hours
230v 50Hz
Single Phase
304 SS
962 mm
Sahpir 7
90 l/min
1” Male
BSP
GER36SEXO Multiple properties
8760 Hours
230v 50Hz
Single Phase
304 SS
962 mm
Sahpir 10
160 l/min
11/2” Male
BSP
GER36SEXO Multiple properties
8760 Hours
230v 50Hz
Single Phase
304 SS
962 mm
* Not Guarantied (Recommend changing after 10-12 months).
Tel:
0131 553 4001
Fax:
0131 553 1272
e-mail:
info@ferrierpumps.co.uk
www.ferrierpumps.co.uk
Website: www.ferrierpumps.co.uk
Introducing the DaRo
UV Systems Saphir+ System
In addition to the standard Saphir system, we would like to introduce
the new Saphir+ system. The Saphir+ system offers additional telemetry.
The Saphir+ has additional lamp status information, an hour counter and a
volt free contact facility for remote monitoring of lamp status, via a plug and socket
(which is sealed and capped when not in use. Both capped and plugged configurations
are rated to >IP65).
The Saphir+ Range has the following features:
• UV Lamp running Indicator
• UV Lamp status - three way indicator display showing the status of the system
• Switch to reset the internal hour counter
• Volt Free Contact output for remote display of lamp on indicator
UV Lamp Running Indicator
The control box has a blue “lamp running” indicator on the front panel display, which is on if and only if lamp is running correctly.
System status indicators
The table below shows the details of the system status indicators.
System Status
Power On
Lamp On
System operating correctly, lamp less than 11 months old
Green
Blue
Green
System operating correctly, lamp between 11 and 12 months old
Green
Blue
Alternating Green & Red
Lamp still operating, but more than 12 months old
Green
Blue
Red
Lamp failed
Green
Off
Red
UV Lamp status Indicator
Lamp status indicator, Remote lamp on indicator via internal
volt free contacts. The display gives a hidden indication of
the age of the lamp. The “Lamp On” and “Lamp Status”
indicators will blink off for a half second period once every
minute. The number of blinks show how many year quarters
(three months) have passed, before the “Lamp Status”
indicator alternates from green to red in the twelfth month:
Lamp Status
Age of Lamp
One to three months (first quarter)
Number of blinks
1
Four to six months (second quarter)
2
Seven to nine months (third quarter)
3
Ten to eleven months (fourth quarter)
Twelve months and above
4
Continuous Red
FERRIER PUMPS LIMITED
Edinburgh • Glasgow • Aberdeen
www.ferrierpumps.co.uk