MICROWAVE
RF
PRODUCTS
CATALOG
Operations and MW Business Line
MICROWAVE
RF
PRODUCTS
CATALOG
Operations and MW Business Line
48 Mivtza Kadesh St., Bene Beraq 5121701 Israel
Tel. +972-3-6175655 Fax. +972-3-6175299
Website: www.mw-elisra.com
E-mail: microwave@elbitsystems.com
Catalog Reference No. 45140537
For custom electrical and mechanical specifications,
Please contact EW and Sigint- ELISRA
Sales: microwave@elbitsystems.com (or) +972-3-6175655
© 2015 All materials in this issue are subject to copyrights owned by Elbit Systems-EW and SIGINT-Elisra and other individuals or entities.
All Other Rights Reserved. The Elbit logo is a trademark of Elbit Systems. Other companies and brands, products and service names are trademarks or
registered trademarks of their perspective holders. This document is preliminary and specifications may be subject to change without further notice.
Table of Contents
Elisra-MW Business Line
5
General
Subsystems & SuperComponenets
In House MMIC Development Suit
Micro-Electronics
Transmitters
Activities
Modern Facilities and Experienced Staff
5
6
6
6
6
7
7
COMPONENTS PRODUCTS
10
RF Switches
Transfer Switches
Hight Power Switches
Frequency Translators
Frequency Discriminator
Mixers
COMB
Limiter
Active Multiplier
Digitally Controlled Attenuators
LOG IF Amplifier
Linear IF Amplifier
Limiter IF Amplifier
DLVAs
Detector Video Amplifiers
Threshold Detector Amplifires
Low Noise Amplifiers
Power Amplifires
Pulse Power Amplifiers
MMIC
11
12
12
13
13
14
15
15
16
17
18
19
19
20
21
21
22
23
23
24
ASSEMBLIES PRODUCTION MIC’s
26
Dual Channel Unit (DCU)
Up Converter
Super Heterodyne Receiver (SHR)
Dual Channel Front End Receiver
Dual Input Front-End Receiver
RF Receiver
Switched Filter
Up/Down Converter
27
27
28
28
29
29
30
30
3
S-Band Transponder
Polarity Switch
Dual Band LO Distributor
Dual Output Front End Receiver
DIFM Receiver
Built in Test (BIT) Unit
Dual Output AGC Unit
Amplifier & Detector
T/R Module
FTO
Input Amplifiers
Data Link Front End
Data Link Transmitter
X-Band RF Front End
Extended Range DLVA Assy
Frond End Receiver
Test Oscillator
Frequency Synthesizer
31
31
32
32
33
33
34
34
35
35
36
36
37
37
38
38
39
39
SOLID STATE TRANSMITTERS
42
High Power Systems 1MHz-6GHz, up to 2000Watts
Solid State Power Amplifier 30MHz-500MHz
43
44
4
MICROWAVE RF PRODUCTS • CATALOG NO. 45140537
Elisra-MW Business Line
Assemblies and Subsystems in Various
RF & Microwave Technologies
General
Elisra-MW Business Line is a recognized leader in
sophisticated electronic systems, subsystems and
supercomponents (Integrated Multi-function
Assemblies) for the defense and commercial
markets.
Elisra-MW Business Line has over 45 years of proven
experience in supplying best-of-class and state-ofthe-art supercomponents and subassemblies for a
wide variety of RF and microwave applications
covering the frequency range of DC to 50 GHz.
Elisra-MW Business Line has gained vast experience
in all relevant technologies required to design,
develop and produce passive and active microwave
products as follows:
Main Technologies Vs Products
Technologies
Products
Multi-Layer RF Circuits
Recievers
High Reliability MIC & MMIC
Transmitters
MCM
Transponders
Connectoriesed Integration
Power Amplifiers
Si, GaAs, GaN, V/LDMOS
Components
Synthesizers & RF Sources
Thin-Film & Thick-Film
Datalink Transmitters
Opto-Electronics Packaging
Repeaters
RF & Digital Integration
Low & High Power PIN Diode
Switches
Modern production facilities operating under a
stringent framework of quality assurance standards
have established Elisra-MW Business Line as a
world class and preferred supplier of products with
unsurpassed reliability.
The Elisra-MW Business Line has cooperated with
major EW system suppliers throughout the world.
Our teams have worked with other development
teams and shared efforts in a large variety of
EW programs, such as RWRs, ECMs, ESMs, Elint,
MWS COM-JAM, SIGINT and others. The mutual
efforts of our engineers together with the EW
system engineers generate definition of microwave
subsystems which enable the system to achieve
optimization in performance and costs which has
been implemented in technologies within Elisra-MW
Business Line’s Microwave control and expertise
such as Supercomponents and MCMs, discrete
components sub-assemblies and more.
DLVA's
Digital & Analog MCM
Elisra-MW Business Line’s highly skilled teams of
engineers and technicians, renowned for their
technological expertise, has been the cornerstone
of our leadership status in both military and
commercial markets. Elisra-MW Business Line is an
excellence center in global scale for microwave and
miniaturization technologies.
5
Subsystems & SuperComponenets Micro-Electronics
Elisra-MW Business Line can provide excellent costeffective solutions to these challenges.
Such intimate effort of our and your engineering
teams can generate subsystems such as superheterodyne receivers (SHR), IFM receivers, lowpower RF ECM Systems, video transmitters, Front
End Receivers (FER), etc.
Implementation of such subsystems can result in a
line replaceable unit (LRU), stand alone units/boxes
or shop replaceable units (SRU) or subassemblies.
SuperComponenets (Integrated Multi-function
Assemblies)
A complete miniaturized subsystem, consisting of
quality microwave components densely packaged
into one enclosure.
Supercomponents represent an answer to the everpresent challenge of integrating high microwave
performance into small packages.
As a recognized leader in the development and
manufacture of supercomponents, Elisra-MW
Business Line has leveraged its knowledge-base of
diverse technologies and microwave components
into providing the best possible subassemblies on
the market today.
These miniaturized subsystems consist of numerous
microwave components which are assembled into
a small package. The package includes such diverse
components as amplifiers, switches, oscillators,
filters and MMIC devices.
Every component is carefully designed and adapted
to meet full performance custom-specifications,
while taking into account the particularly compact
supercomponent enclosure requirements.
Since compact integration eliminates many
connector interfaces, overall electrical performance
is often enhanced. Our supercomponents frequently
demonstrate improved VSWR and enhanced gain
and phase characteristics.
In House MMIC Development Suit
Passive and Active 0.15um PHEMT GaAs MMICs
D.C-50GHz
Passive components printed on Hard substrates
Multi Function Integrated Circuits
Multi - Layer Technology
In House On-Wafer (Probe Station) Testing
Multi Layer Buried Components
Elisra-MW Business Line’s Microelectronics group
has been a leader in the innovative utilization of
hybrid technologies for over 45 years. Our hybrid
products are key elements in EW systems produced
by some of the major manufacturers of the world.
With core competencies in hybrid technologies we
have been able to offer advanced products with
superior and reliable performance, such as:
Detector Log Video Amplifiers (DLVAs)
Logarithmic IF Amplifiers
Frequency Discriminators
Expertise in thin/thick film and MCM technologies,
backed by modern facilities and know-how, has
made Elisra-MW Business Line a distinguished
contender in the hybrid product arena.
Transmitters
Elisra-MW Business Line’s RF Transmitter Activity, a
section within the company’s Microwave Business
Line, is a technological leader in the design and
development of a wide range of compact reliable
RF transmitters and amplifiers for communications
and ECM applications. Our RF Transmitter section
capabilities are proven in the microprocessor
control and computer interfaces used in its
transmitters and amplifiers. Our development Main
Features enable sophisticated real-time control of
amplitude, frequency, modulation type and in-depth
BIT. Just as well, our products offer high speed solidstate switching and frequency hopping technologies.
Our standard product range is enhanced by
flexible production facilities, enabling us to handle
customized orders rapidly and cost effectively. The
facility at Elisra-MW Business Line is equipped to
deal with most methods of environmental testing.
Tests are performed during R&D qualification
(MIL-STD-810). Environmental stress screening
(utilizing MILSTD- 2164) is applied on 100% of our
amplifiers. Our growing list of satisfied clients list
includes notable companies from Europe, Asia and
Israel
Optimal Operating Efficiency and Linearity
(Class AB)
Solid State Architecture: GaAs, GaN, MOSFET,
LDMOS, Bipolar
Digital full Status Monitoring
System Structures include: Amplifiers, OPU,
Antennas and Installation Support.
Remote Operation: RS232 / RS422 / RS485/ USB /
Dry Contact
6
MICROWAVE RF PRODUCTS • CATALOG NO. 45140537
Activities
Modern Facilities and Experienced
Microwave Multi-function Assemblies
Staff
Multi-Function Assemblies (MIC’s)
CAD Tools
Frequency Synthesizers
Clean Room
RF & Microwave- Receivers
Automatic Bonder
mmw Sub-Assemblies
Automatic Test Setup
Pin Diode Control Devices
Laser Welder
High Power Systems SS HPA
Hp Switches
Pulsed AMPS
TWT Replacement
Hermetically Sealing
Environmental Lab
Thermal Vacuum Chamber
Quality Assurance
Microwave Links
Transmitters
Microelectronics & Electroptics
Receiving Products
MCM’s
Custom Hybrids
Laser Receivers
7
P
COMPONENT
COMPONETS
PRODUCTS
PRODUCT
COMPONENTS
PRODUCTS
RF Switches
11
Transfer Switches
12
Hight Power Switches
12
Frequency Translators
13
Frequency Discriminator 13
Mixers14
COMB15
Limiter15
Active Multiplier
16
Digitally Controlled Attenuators
17
LOG IF Amplifier18
Linear IF Amplifier
19
Limiter IF Amplifier
19
DLVAs
20
Detector Video Amplifiers
21
Threshold Detector Amplifires
21
Low Noise Amplifiers
22
Power Amplifires
23
Pulse Power Amplifiers
23
MMIC24
10
MICROWAVE RF PRODUCTS • CATALOG NO. 45140537
RF Switches
(Series of SPST to SP16T Switches)
Main Features
Narrow, wide and Ultra-wide band: 0.5-18GHz
Solid State
Low Insertion Loss: 1.2dB to 2.8dB
(Depend on the type of the switch)
High Isolation: 60dB typ.
VSWR: 1:8:1 typ.
Integral TTL driver
Bias VCC: (+5V/ -12V)
(Unless it will be define differently)
Power Handling Capability: 100mW to 1W
Operating Temperature Range: -55°C to +105°C
Storage Temperature Range: -65°C to +125°C
Reflective Switching Speed: 25 ns typ.
Non- Reflective Switching Speed: 35 ns typ.
Hermetically sealed
Options
Low Video Leakage
Switches Without Drivers
Another Frequency Band
Lower Insertion Loss Can Be Provided
For custom electrical and mechanical specifications, please contact
EW and Sigint- ELISRA Sales: microwave@elbitsystems.com (or) +972-3-6175655
COMPONENTS PRODUCTS 11
Transfer Switches
Hight Power Switches
Main Features
Main Features
Narrow, wide and Ultra-wide band: 0.5-18GHz
Power Handling 100 Watt CW
Low Insertion Loss: 1.5dB typ.
6-8 GHz Frequency Range Coverage
High Isolation: 50dB typ.
Patented Transition Technology
VSWR: 1:5:1 typ.
SPDT Configuration
Integral TTL driver
Low Loss 1.0 dB typ.
Bias VCC: (+5V/ -12V)
(Unless it will be define differently)
High Isolation 24dB typ.
Power Handling Capability: 200mW
VSWR
Operating Temperature Range: -55°C to +105°C
Storage Temperature Range: -65°C to +125°C
Hermetically sealed
Compact and Lightweight
Highly Reliable MIC Technology
Integral TTL Driver
Switching Speed
Special Heat Dissipation Methodology
Options
Other Frequency Bands are Available
Higher Isolation is Available
Options
RF Connectors are SMA Female
Includes Built-in Driver
CASE 1
Switches Can Be "Tailored" to Customer's
Requests
CASE 2
For custom electrical and mechanical specifications, please contact
EW and Sigint- ELISRA Sales: microwave@elbitsystems.com (or) +972-3-6175655
12
MICROWAVE RF PRODUCTS • CATALOG NO. 45140537
Frequency Translators
Frequency Discriminator
(Phase shifter)
Main Features
Change of center frequency & Bandwidth
Main Features
Internal limiter amplifier
High Performance
MIC Quadrature Hybrid Design
6 Bit TTL Digital Drive
Change of center frequency accuracy
DC Power supply: (+12V/ -12V)
VSWR: 2:1 typ.
Low Insertion Loss
Power Handling Capability: 0.1W (CW)
Operating Temperature: -55°C to+105°C
Range Temperature Coefficient: 0.025 dB/°C
Switching Time: 30 ns max
Power Supply Req. at 50 mA: 5V at 200 mA
Frequency Translation: 0 to 100 kHz
RF Connectors: SMA female
Video load: 100ohm
Operating Temperature Range: -55°C to +105°C
Storage Temperature Range: -65°C to +125°C
Very good Rise time / fall time
SMA connectors or Drop in Pins.
Hermetically sealed
Options
Change of Slope
Options
Other Frequency Ranges
Matching between units
External offset adjustment
Limited IF output of +10dBm
For custom electrical and mechanical specifications, please contact
EW and Sigint- ELISRA Sales: microwave@elbitsystems.com (or) +972-3-6175655
COMPONENTS PRODUCTS 13
Mixer Drive Level Characterestics
Mixers
Drive
Local Drive
Level
Level
Suffix
Local
Drive
Level
Range
(dBm)
Low Drive
L
+10 to
+13
+4
+14
Med. Drive
M
+13 to
+15
+8
+17
Operating Temperature Range: -55°C to +105°C
High Drive
H
+17 to
+19
+11
+20
Storage Temperature Range: -65°C to +125°C
Super High
Drive
S
+20 to
+23
+16
+25
Main Features
Narrow, wide and Ultra: wide band 0.5-18GHz
Local Drive level: Low, Med., High & Super high
Low Insertion Loss: 8dB typ.
Isolation L to I: 25 to 30dB typ.
Isolation L to R: 25 to 30dB typ.
VSWR: 2.5:1 typ.
Hermetically sealed
Typical Input
Typical 1 dB
Intercept
Compression
Point per
Point (dBm) min LO Drive
(dBm)
Intermodulation Suppression
Low Frequency Mixers
High Frequency Mixers
FLO
HARMONICS
FLO
HARMONICS
1
2
3
4
5
1
-
25
10
30
30
2
40
45
50
55
55
3
63
70
69
>70
64
4
>70 >70 >70 >70 >70
1
2
3
4
5
1
0
25
18
40
35
2
40
40
50
55
55
3
65
>70
65
>70
65
>70 >70 >70 >70 >70
5
>70 >70 >70 >70 >70
FRF
HARMONICS
4
FRF
HARMONICS
For custom electrical and mechanical specifications, please contact
EW and Sigint- ELISRA Sales: microwave@elbitsystems.com (or) +972-3-6175655
14
MICROWAVE RF PRODUCTS • CATALOG NO. 45140537
COMB
Limiter
Main Features
Main Features
Change of center frequency & Bandwidth.
Frequency range: 20MHz to 18 GHz
Input VSWR: 2:1 typ.
Insertion loss: 2.0 dB typ.
Excellent spurious rejection
DC Block: Built-In DC Block
Power Handling 10mW typ.
VSWR: 2 : 1
Very good phase noise (offset)
Typical LIM Threshold: +6.0 dBm
Bias VCC (+5V) unless it will be define differently.
Leakage Power @ +20dBm: 12dBm typ.
Operating Temperature Range: -55°C to +105°C
Leakage Power @ +30dBm [1Watt]: 14dBm typ.
Storage Temperature Range: -65°C to +125°C
Operating Temp.: -45ºC to +85ºC
Hermetically sealed
Storage Temp.: -65ºC to +125ºC
Temp. Cycling: -65ºC to +125ºC
Options
Other modules of Combs are available upon
request.
Shock: 50 G,11mSec
Vibration: 20 G, 100 to 2KHz
Options
CASE 1
Other modules of limiters are available upon
request.
16.52
16.00
IN
5.1
4.75
OUT
2.58
6.4
0.39
CASE 2
CASE 3
For custom electrical and mechanical specifications, please contact
EW and Sigint- ELISRA Sales: microwave@elbitsystems.com (or) +972-3-6175655
COMPONENTS PRODUCTS 15
Active Multiplier
Main Features
Input frequency range: 103.5 to 110 MHz
Input power range: +5 to +9dBm
Output frequency range: 8.38 to 8.88 GHz
Output Power: -25dBc minimum
Harmonics: 8±2 dBm minimum
Subharmonics and Spurious: -50dBc minimum
Isolation between outputs-40 dB minimum
Switching speed: 30 nSec maximum
Video leakage: -50dBc minimum
(For PRF -180μSec and pulse width 330 nSec,
pulse rise and fall time -20nSec, measured with
spectrum Analyzer)
Control: 1 TTL lines
Control logic
"0" logic : Out 1
"1" logic : Out 2
DC power +15V/425mA max
-15V/20 mA max
Additional spurious due to modulation on the DC
line: -50dBc
(when 1KHz pulses with amplitude 1OOmV will
be applied to the +15Vdc pin)
Connectors
RF: SMA-F
DC: RFI solder pins
Control: Solder pins
SMA/F
(x3)
6 MOUNTING THREADS
NC 4-40
2.5
Options
24.20
Other modules of active multipliers are available
upon request.
42.0
48.50
12.5
95.00
111.0
OUT1
5.0
10.00
IN
OUT2
MOUNTING SURFACE
6.5
20.0
30.0
40.0
50.00
60.00
For custom electrical and mechanical specifications, please contact
EW and Sigint- ELISRA Sales: microwave@elbitsystems.com (or) +972-3-6175655
16
MICROWAVE RF PRODUCTS • CATALOG NO. 45140537
20.00
CON -15V +15V GND
Power Divider/Combiners
Digitally Controlled Attenuators
Main Features
Main Features
Narrow, wide and Ultra-wide band 0.5-18GHz
High performance
High performance
MIC Quadrature Hybrid Design
Low Insertion Loss: 1.0dB typ.
Dynamic Range: 60dB
High Isolation: 18dB typ.
Temperature Compensated
VSWR: 1:5:1 typ.
Non Reflective
Phase Balance: ±0.8° typ.
VVA upon request
Amplitude Balance: ±0.2dB typ.
Power Handling 100mW (CW)
Power Handling Capability: 100mW to 1W
Minimum Attenuation Range 60dB
Operating Temperature Range: -55°C to +105°C
Accuracy of Attenuation ±1dB
Storage Temperature Range: -65°C to +125°C
Operating Temperature Range: -55°C to +105°C
Hermetically sealed
Storage Temperature Range: -65°C to +125°C
Hermetically sealed
Options
Options
Other frequency bands are available
Lower Insertion Loss is available
Other Models of Digitally Controlled
Attenuators are Available Upon Request
CASE 1
CASE 1
CASE 2
CASE 2
CASE 3
H4
H2
H2
H5
J9
For custom electrical and mechanical specifications, please contact
EW and Sigint- ELISRA Sales: microwave@elbitsystems.com (or) +972-3-6175655
COMPONENTS PRODUCTS 17
LOG IF Amplifier
Main Features
Extended frequencies Bandwidth between
30MHz up to 630MHz
Dynamic range: 80dB
Log Linearity: ±0.6dB
DC Power supply: (+12V / -12V)
VSWR: 2:1 typ.
Video load: 100ohm
Operating Temperature Range: -55°C to +105°C
Storage Temperature Range: -65°C to +125°C
Excellent Rise time / fall time
SMA connectors or Drop in Pins
Hermetically sealed
Options
Change of center frequency & Bandwidth
Change of Slope
Matching between units
External offset adjustment
Limited IF output of +10dBm
CASE 1
CASE 3
CASE 2
For custom electrical and mechanical specifications, please contact
EW and Sigint- ELISRA Sales: microwave@elbitsystems.com (or) +972-3-6175655
18
MICROWAVE RF PRODUCTS • CATALOG NO. 45140537
Linear IF Amplifier
Limiter IF Amplifier
Main Features
Main Features
Frequency Bandwidth: 10MHz or 20MHz
Frequency Bandwidth: 10MHz or 20MHz
RF Gain to Video: 80dB
Phase variation: ±3º
IF Output: +10dBm
IF Output: +10dBm
Gain control: 50dB
Dynamic range: 65dB
microwave
DC Power supply:
(+12V/ -12V)Division
Receiving IF Products - Package Outline
DC Power supply: (+12V/ -12V)
VSWR: 1.5:1 typ.
VSWR: 1.5:1 typ.
Video load: 100ohm
Video load: 100ohm
Operating Temperature Range: -55°C to +105°C
Operating Temperature Range: -55°C to +105°C
Storage Temperature Range: -65°C to +125°C
Storage Temperature Range: 65°C to +125°C
SMA connectors or Drop in Pins
SMA connectors or Drop in Pins
Hermetically sealed
Hermetically sealed
A1, A2
B1, B10
Options
Options
Change of center frequency & Bandwidth
Change of center frequency & Bandwidth
Note:
1 Offset potentiometer (optional)
2 For A2 package, without IF OUT connector
Note:
1 Offset potentiometer (optional)
2 For A2 package, without IF OUT connector
A3
B2, B11
For custom electrical and mechanical specifications, please contact
EW and Sigint- ELISRA Sales: microwave@elbitsystems.com (or) +972-3-6175655
COMPONENTS PRODUCTS 19
DLVAs
Main Features
Typicals of DLVAs:
- DC Coupled
- CW IMMUNE
- AC Coupled
- SDLVA
- Successive
Excellent Accuracy & Stability
Low power consumption
Dynamic range: 50dB
Fast Rise time and fall times
DC Power supply: (+12V/ -12V)
Video load: 100ohm
Operating Temperature Range: -55°C to +105°C
Storage Temperature Range: -65°C to +125°C
SMA connectors or Drop in Pins
Subminiature Hermetic package
Options
Change of Slope.
Other wide-band frequency ranges from 0.5
to 40 GHz or narrower bands with optimized
performance characteristics.
CASE 2
CASE 1
For custom electrical and mechanical specifications, please contact
EW and Sigint- ELISRA Sales: microwave@elbitsystems.com (or) +972-3-6175655
20
MICROWAVE RF PRODUCTS • CATALOG NO. 45140537
Detector Video Amplifiers
Threshold Detector Amplifires
Main Features
Main Features
Operating Frequency: 8.9 – 10 GHz
Frequency Range: 6-18/18-40 GHz
Operating Voltage: ±15V ±1v
Sensitivity: -20dBm
Current drain(max): 40mA
Dynamic Range: -20 to 0dBm
Video Output Voltage for
(-20dBm RF power input): 200±35mV
Coupling: DC Coupled
RF connectors(RF In): SMA female
Synthetic Video Output: TTL
VSWR (maximum): 2:1
Operating Temperature Range: -62 to + 85 deg C
Load impedance :50 Ohm
DcVoltages,Vout,Gnd: Via solder pins
TTL response for pulse length (0. to 65 uSec):
<20nSec
RF Input Power: -20 to 0dBm
Application
Raw Video Output: Linear
Pulse Width: 100nSec to CW
Pulse Rise Time: 20nSec Max.
Raw Video Output Impedance: 1K ohm
Synthetic Video Output Impedance: 1K ohm
Input Impedance: 50 ohm
Power Handling: 17dBm Max.
Threshold Setting: -20 to 0dBm
Power Supply: +15V ; 30mA -15V ; 30mA
EW Systems
Environmental Spec.: MIL-E-16400
Operating Temperature: -20 to +55°C
Technology
Thin & Thick Film
Application
PIN Diode Switches
Drop in Hybrid Amplifiers
Hermetically Sealed (Laser)
EW Systems
Technology
Thin & Thick Film
PIN Diode Switches
Drop in Hybrid Amplifiers
Hermetically Sealed (Laser)
For custom electrical and mechanical specifications, please contact
EW and Sigint- ELISRA Sales: microwave@elbitsystems.com (or) +972-3-6175655
COMPONENTS PRODUCTS 21
Low Noise Amplifiers
Main Features
Narrow, Wide, and Ultra-Wide Band 0.5 - 18 GHz
Low Noise:
2 dB Ultra-Wide, 0.9dB Narrow Band
Output Power up to 37dBm Sat (5W)
Gain: between 7 to 70 dB
Custom Defined Amplifiers & Modules
SMA connectors or Drop in Pins
Subminiature Hermetic package
Options
Slope Amplifier between 2-18GHz
Temperature Compensation
Input Power Limiting
Gain Match
Phase Match
Any type of Screening
CASE 1
CASE 2
For custom electrical and mechanical specifications, please contact
EW and Sigint- ELISRA Sales: microwave@elbitsystems.com (or) +972-3-6175655
22
MICROWAVE RF PRODUCTS • CATALOG NO. 45140537
Power Amplifires
Pulse Power Amplifiers
Main Features
Main Features
High power, High efficiency
High power output: up to 200Watt
Reliability MIC Technology
Integrated power supply: 16 to 32 Volt
Internally built in protections:
Over voltage, Reverse Polarity, Supply Sequencing and Load Mismatch
Fast switching speed: 200 nSec typ
Gain: Between 7 to 70 dB
Custom Defined Amplifiers & Modules
Connectorized or Drop in Pins
Hermetic package
Built in test circuit
Variable duty cycle: up to 10%
External synchronization
Load VSWR protected
Connectorized
Hermetic package
Options
Gain temperature compensation
CASE 1
Extended operating temperature
Dual matched outputs (Gain, Power and Phase)
TTL controlled DC shut down
CASE 2
For custom electrical and mechanical specifications, please contact
EW and Sigint- ELISRA Sales: microwave@elbitsystems.com (or) +972-3-6175655
COMPONENTS PRODUCTS 23
MMIC
Monolithic Microwave Integrated Circuit
Key Technologies
0.15μm PHEMT GaAs MMICs Products
Customized Millimeter Wave MMICs
High frequency up to 50GHz
Multi-Function Chips
Capabilities
Passive and Active 0.15μm PHEMT GaAs
MMICs DC-50GHz
Passive components printed on Hard
substrates
Multi Function Integrated Circuits
Multi - Layer Technology
In House On-Wafer (Probe Station) Testing
Multi Layer Buried Components
Advantages
In House MMIC development suit (simulators,
analysis etc.)
Customized design
In House RF integration and testing
capabilities
Experienced teams of engineers, technicians,
assembles etc.
GaAs Products examples
Amplifiers
Switches
Mixers
Multipliers
DCAs
Attenuators
Equalizers
Phase Shifters
For more information -
Multi Function Integrated Circuits - RF Core.
See Catalog Number 45140538
For custom electrical and mechanical specifications, please contact
EW and Sigint- ELISRA Sales: microwave@elbitsystems.com (or) +972-3-6175655
24
MICROWAVE RF PRODUCTS • CATALOG NO. 45140537
ASSEMBLIES
ASSEMBLIES
PRODUCTION
MIC’s
PRODUCTIO
MIC’s
ASSEMBLIES
PRODUCTION
MIC’s
Dual Channel Unit (DCU)
27
Up Converter
27
Super Heterodyne Receiver (SHR)
28
Dual Channel Front End Receiver
28
Dual Input Front-End Receiver
29
RF Receiver
29
Switched Filter
30
Up/Down Converter
30
S-Band Transponder
31
Polarity Switch
31
Dual Band LO Distributor
32
Dual Output Front End Receiver
32
DIFM Receiver
33
Built in Test (BIT) Unit
33
Dual Output AGC Unit
34
Amplifier & Detector
34
T/R Module
35
FTO35
Input Amplifiers
36
Data Link Front End
36
Data Link Transmitter
37
X-Band RF Front End
37
Extended Range DLVA Assy
38
Frond End Receiver 38
Test Oscillator
39
Frequency Synthesizer
39
26
MICROWAVE RF PRODUCTS • CATALOG NO. 45140537
Dual Channel Unit (DCU)
Up Converter
Super Heterodyne Receiver
Main Features
Frequency: 0.1-18 GHz
Main Features
Frequency Coverage: VHF to S Band
2 Phase and amplitude matched channels
Instantaneous Band Width: up to 500 MHz
High sensitivity (Front end depended)
Contains DCAs to Set the Gain
Modulation of Signal (Phase, Amplitude,
and Pulse Modulation)
Very Fast Settling Time: 100nSec
Wide dynamic range
Suppression of Unwanted Signals to
All Local oscillators are internal and synthesized
with external reference CK
prevent them from Reaching the
Transmitter
Fast setting time: 100 nSec
Low Overall Noise Floor
Small size: 3U cut out (16x10x2 cm)
Small Size: 3U Cut-Out: 16x10x2 cm
Applications
Applications
EW Receiver
EW Systems
Technologies
Technologies
SMT
RF Multilayer including Micro Strip, MMIC & SMT
For custom electrical and mechanical specifications, please contact
EW and Sigint- ELISRA Sales: microwave@elbitsystems.com (or) +972-3-6175655
ASSEMBLIES PRODUCTION MIC’s 27
Super Heterodyne Receiver (SHR)
Dual Channel Front End Receiver
Main Features
Main Features
RF Input Frequency Range: 0.5 - 18 GHz
Frequency Range: 0.5-18, 1-18, 2-18 GHz
Triple Down-Conversion
High Output 1 dB Compression: +18 dBm
Dynamic Range @ Input: -70 to 0 dBm
Low Noise Figure: 10 dB
Noise Figure: 17 dB Typ
Integrated Test Generator
Phase Tracking (Pairs): ±4°
B.I.T Capabilities: TTL Compatible
Switching Speed: 250 nSec
Low Power Consumption: 10 Watts
Spurious: 45 dBc
IF Output Frequency Range Wide Band 1: 2-6 GHz
Wide Band 2: 50 - 630 MHz (AUX)
Variable Bandwidth BW1:
500 MHz
BW2:
140 MHz
BW3:
40 MHz
BW4:
4 MHz
Phase Matching (Pairs): ±15º
Low Power Consumption 5W
Application
EW Systems
Technology
Microstrip MIC
MMIC Switches
Comb Generator
SMD
Hermetically Laser Sealing
Applications
EW Receiver
Technologies
MIC
Hermetically Sealed (Laser)
For custom electrical and mechanical specifications, please contact
EW and Sigint- ELISRA Sales: microwave@elbitsystems.com (or) +972-3-6175655
28
MICROWAVE RF PRODUCTS • CATALOG NO. 45140537
Dual Input Front-End Receiver
RF Receiver
Main Features
Main Features
Wide Band Coverage: 18 to 40 GHz
Frequency Range: 2-18 GHz
Down-Converted: 2 to 16.5 GHz
The frequency range is divided to five sub bands
Q1- Q5 (band edge cross-over frequency)
High-Input Dynamic Range
High Power Protection
RF to IF Output
Internal MMW Bit Generators
RF to Video Output
Supports Two Receiving Antennas
High Dynamic Range RF to IF Converter
Extermely Compact Housing
VSWR in/out: 2:1 max.
Recovery time: 100 nSec max.
Applications
Power Handling Capability: +24 dBm max
EW Systems
Third Order Intercept Point: +18 dBm min
Technologies
Isolation of the SPDT switch: 45 dB min
MMIC & SMT
Hermetically Sealed (Laser)
Integrated unit
Application
EW Systems
Technology
Hermetically Sealed (Laser)
Suspended Quintuplexer
PIN Diode Switches
Microstrip
MMIC
For custom electrical and mechanical specifications, please contact
EW and Sigint- ELISRA Sales: microwave@elbitsystems.com (or) +972-3-6175655
ASSEMBLIES PRODUCTION MIC’s 29
Switched Filter
Up/Down Converter
Main Features
Main Features
Frequency Range: 6-18 GHz
Frequency Range: 6-18 GHz
6 Channel Preselector
IF Output: 3 GHz
High Speed Switching
High Dynamic Range Down Converter
High Rejection Filters
High Speed Switches
Out of Band Rejection: 55 dBc min.
Gain: 3 –12 dB
VSWR In/Out: 2:1 max.
1 dB Compression Point (Output): +13 dBm min.
Application
EW Systems
Technology
Noise Figure: 14 dB max.
Drop in Components
3rd Order Intercept Point (Output): +20 dBm min
MMIC Switches
Switching Speed: 45 nsec min.
Hermetically Sealed (Laser)
SP4T Isolation: 70 dB min.
Application
EW Systems
Technology
Microstrip
MMIC Amplifier
PIN Diode Switches
Comb Filters
Hermetically Sealed (Laser)
For custom electrical and mechanical specifications, please contact
EW and Sigint- ELISRA Sales: microwave@elbitsystems.com (or) +972-3-6175655
30
MICROWAVE RF PRODUCTS • CATALOG NO. 45140537
S-Band Transponder
Polarity Switch
Main Features
Main Features
S-Band Full Duplex
1-18GHz SPDT with Limiters
High Selectivity
Wide Dynamic Range, AGC (Up Converter &
Down Converter)
Power Handling:
CW: +30dBm (1W)
Pulse: 100W (1uSec pulse width @ 2% DC)
Built-In Test (BIT)
Isolation: 30dB Min.
Off-the-Shelf Components
(Special Design: Filters, Power Amplifiers.)
Power supply: +12VDC/65mA
Applications
EW Systems, Missiles
Technologies
SMT
VSWR: 1.8:1
Temperature range: -540C to +850C
Application
EW Systems
Technology
Microstrip MIC
SMT
Hermetically Laser Sealing
For custom electrical and mechanical specifications, please contact
EW and Sigint- ELISRA Sales: microwave@elbitsystems.com (or) +972-3-6175655
ASSEMBLIES PRODUCTION MIC’s 31
Dual Band LO Distributor
Dual Output Front End Receiver
Main Features
Main Features
Frequency Range:DUAL BANDS
Frequency Range: 2-18 GHz
X: 8÷9 GHz
Low Noise Figure: 10 dB
UHF: 870 MHz
High Output 1 dB Compression: +18 dBm
Splitting & Amplifying
High Path Isolation: 60 dB
Detects Input/Output Power Level:
TTL Compatible
Low Power Consumption: 9W
Excellent In/Out VSWR: 1.3:1
Internal Noise Source For BIT
Excellent Output Stability:
Less than ±1 dBm
High Channel Isolation: 60 dB min
Low Output Spurious Level
Over All Power Consumption: 12W
Low Spurious Level
Application
EW-Front End Receivers
Technology
Microstrip, Strip Line
MIC, MMIC
Application
EW Systems
Comb Generator
Transponders
SMD
Rx/Tx Assemblies
Hermetically Laser Sealing
Technology
Couplanar Wave Guide
MIC For X-Band
SMD, MMIC For UHF Channel
For custom electrical and mechanical specifications, please contact
EW and Sigint- ELISRA Sales: microwave@elbitsystems.com (or) +972-3-6175655
32
MICROWAVE RF PRODUCTS • CATALOG NO. 45140537
DIFM Receiver
Built in Test (BIT) Unit
Main Features
Main Features
Digital Instantaneous Frequency Measurement
Output Frequency: 5/8/12/15 GHz
Frequency range: 0.5-18GHz
Frequency Accuracy: ±5 MHz
Output: 12 Bit TTL
Harmonics: Better than -25 dBc
Internal or external triggering
Spurious: Better than -60 dBc
Frequency resolution: 1.1MHz
Type of Output: CW / Pulse
Pulse width range: 50nSec to CW
Attenuation Control (DCA):
Low: No Attenuation
High: 30 dB Attenuation
SNR: 3dB
Noise level: -50dBm
No need for calibration
Application
EW-Front End Receivers
Technology
Pulse Command (BMP): Differential TTL
Rise Time: 25nSecMax.
Application
EW Systems
Technology
SMT
SMT
MIC
Hermetically Laser Sealing
MIC
Hermetically Laser Sealing
For custom electrical and mechanical specifications, please contact
EW and Sigint- ELISRA Sales: microwave@elbitsystems.com (or) +972-3-6175655
ASSEMBLIES PRODUCTION MIC’s 33
Dual Output AGC Unit
Amplifier & Detector
Main Features
Main Features
Frequency Range: 2-6 GHZ
Frequency Range: 12-18.5 GHz
Gain @ “0” Att.: 40 dB
Input Power: -32dBm min, to -10dBm max
Attenuation Range: 0-31 dB
Output Power: +13dBm min, to +16dBm max
Switching Speed: 250 nSec
N.F.: 7.0 dB max
Flatness: ±1 dB max
Application
VSWR: 1.7:1 max
EW Systems
DC Supply: +12V / 420mA
Technology
RF Leakage: 90dBc
Thin Film
Spurious: 70dBc
Hybrid Balanced Amplifiers
Recovery Time: 10 ns max
PIN Diode Switches
Detection for CW and Pulse Signals
Hermetically Sealed (Laser)
Output Voltage @ +13dBm Output Power:
500mV min
Output Voltage @ +10dBm: 400mV max
Rise / Fall Time: 15ns
Detector Load: 100 ohm
Application
EW Systems
Technology
Microstrip MIC
Hermetically Laser Sealing
For custom electrical and mechanical specifications, please contact
EW and Sigint- ELISRA Sales: microwave@elbitsystems.com (or) +972-3-6175655
34
MICROWAVE RF PRODUCTS • CATALOG NO. 45140537
T/R Module
FTO
Main Features
Main Features
2-6 / 6-18 GHz
Frequency Range: X-band
5 bits 3600 Digital-controlled phase shifter
Tx Power: up to 1 Watt
5 bits, 31 dB Digital controlled attenuator
Rx NF: < 1.4 dB
High Power MMIC amplifiers (4 Watts typ.)
Amplitude Control: Tx and Rx
Low noise MMIC amplifiers
Phase Control: Common
High power protector switch / limiter
Switching Speed: 25 nSec
T/R switches and Circulator
Designated digital control Circuit
Application
Airborne
Radar
Application
EW Systems
Technology
Radar
Microstrip MIC
Technologies
Hermetically Laser Sealing
MMIC & SMT
GaN Power Amplifier
For custom electrical and mechanical specifications, please contact
EW and Sigint- ELISRA Sales: microwave@elbitsystems.com (or) +972-3-6175655
ASSEMBLIES PRODUCTION MIC’s 35
Input Amplifiers
Data Link Front End
Main Features
Main Features
Frequency 2-18 GHz
TX Up Conversion
Contain BIAS TEE drivers which enable external
RX Down Conversion
power feed of Amplifier
To set the Noise Figure of the RF chain it is
connected to.
Contain Test source for calibration.
Application
High Performance:
RX NF 3 dB
RX Group Delay 2 nSec
Application
EW Systems
EW Systems
Technologies
Technologies
Micro strip
Micro strip
MIC & MMIC
MIC & MMIC
Hermetically Sealed (Laser)
Hermetically Sealed (Laser)
For custom electrical and mechanical specifications, please contact
EW and Sigint- ELISRA Sales: microwave@elbitsystems.com (or) +972-3-6175655
36
MICROWAVE RF PRODUCTS • CATALOG NO. 45140537
Data Link Transmitter
X-Band RF Front End
Main Features
Main Features
No. of Channels: Two (I&Q channels)
Frequency range: 10.3-10.5GHz
Type of Modulation: BPSK
Frequency selection: Through three wire serial
link (Data, Clock, Strobe), 160 Bit serial
Phase imbalance: ±2o
IF Frequency: Designer can select
Transmit Frequency: X Band (10.3 to 10.5 GHz)
Output power abd Flatness: 25W
Carrier Rejection: 26 dBm min.
Power Supply: 28 ±4V
Size: 260mm X 90mm X 89mm (H)
Weight: <2.8 Kg
Noise Figure: Better than 3.5dB, better than
4.5dB @+71°C
RF threshold input level: -110dB (typ.)
Input signal range: -110 to-40dBm
No of freq spots of operation: 20(min)
Final IF output Freq.: 19.8 MHz ± 2.0KHz
IF bandwidth: ±10 MHz
Input signal dynamic range: 70 dB(min)
Applications
Max input power (survival): +30dBm CW
Power input: 28 ± 4 Volt
EW Systems, Missiles
RRSI: 0 to 5Volt range
Technologies
Applications
SMT
EW Systems
MIC & MMIC
Hermetically Sealed (Laser)
Technologies
SMT
MIC & MMIC
Hermetically Sealed (Laser)
For custom electrical and mechanical specifications, please contact
EW and Sigint- ELISRA Sales: microwave@elbitsystems.com (or) +972-3-6175655
ASSEMBLIES PRODUCTION MIC’s 37
Extended Range DLVA Assy
Frond End Receiver
Main Features
Main Features
Frequency Range: 1-18 GHz
Frequency Range: S Band
TSS (20 MHz Video BW): -67 dBm
It is an outdoor unit and it located nearby the
antenna
Logging Range: -67 to 0 dBm
Max. RF Input Power: 5W CW
Max. Peak (1μs width: 1 kHz PRF): 500W peak
SP2T RF Switch Isolation: 60 dB min.
RF Output: 0 dBm min. at -40dBm input
2nd harmonic level 7 dBc min.
Pulse Width: 50 nsec to 150μsec
The FE module has two main routes Tx and Rx
At RX rote Low NF (2dB typ.)
At TX rote High power transmitted
(up to 500W CW)
IP3 30dBm
High out of band rejection
DC Power Protected for Reverse Polarity:
Over Voltage up to ±18V Short Circuit Protection
and EMI/EMC
-15 VDC; 1.3A max. (1A Typ)
-15 VDC; 300 max.
Tx/Rx ISO 28dB
Log Slop: 70mV typ
Quarter Wave Lightning Protector built in
Log Linearity: (-64 to 0 dBm) ±2 dB
Protection against open/short
Log Accuracy: ±3 dB
The FE uses an external DC Power Supply
DC Offset: ±100 mV
The FE communicates with a central controller
via RS-485 interface bus and discrete control
inputs
Matching Between Units: ±3 dB
Frequency Flatness: ±0s1.5 dB
Application
Built In Test
RSSI ability
Self-cooling
The FE support software updates from the main
connector
Application
EW Systems
EW-Front End Receiver.
Technology
Broadband
Thin & Thick Film
Technology
PIN Diode Switches
Drop in Hybrid Amplifiers
Microsrrip
Hermetically Sealed (Laser)
MIC, MMIC
SMT
Hermetically Laser Sealing
For custom electrical and mechanical specifications, please contact
EW and Sigint- ELISRA Sales: microwave@elbitsystems.com (or) +972-3-6175655
38
MICROWAVE RF PRODUCTS • CATALOG NO. 45140537
Test Oscillator
Frequency Synthesizer
Main Features
Main Features
Frequency Coverage: 0.5-20 GHz
Frequency Coverage: 2-18 GHz
Step size: 10 MHz
Low Spurious: <-70 dBc
Harmonic: 35 dBc
Harmonics: -50 dBc max
Setting Time: 150 uSec
Noise Floor: -140 dBc
Phase-noise: -105 dBc/Hz@1 KHz
Applications
Ultra Wideband Frequency Coverage
Naval
Setting time: <200 nSec
EW Systems
Resolution 1 Hz
Technologies
Phase and Frequency Coherent
SMT
FM Modulations Built-in
MIC
Front Panel Control: Option
Hermetically Laser Sealing
Applications
EW
Radar
Technologies
SMT
MIC
Hermetically Laser Sealing
For custom electrical and mechanical specifications, please contact
EW and Sigint- ELISRA Sales: microwave@elbitsystems.com (or) +972-3-6175655
ASSEMBLIES PRODUCTION MIC’s 39
40
MICROWAVE RF PRODUCTS • CATALOG NO. 45140537
SOLID
SOLID
STATE
TRANSMITTERS
STATE
TRANSMITTER
SOLID STATE
TRANSMITTERS
High Power Systems 1MHz-6GHz, up to 2000Watts
Solid State Power Amplifier 30MHz-500MHz
42
MICROWAVE RF PRODUCTS • CATALOG NO. 45140537
43
44
High Power Systems 1MHz-6GHz,
up to 2000Watts
Main Features
Optimal Operating Efficiency and Linearity
(Class AB)
Solid State Architecture: GaAs, GaN, MOSFET,
LDMOS
Full rated power at VSWR 3:1 with constant
current consumption @ ambient temperature of
55°C
LPF and Dummy Load switch included internally
Digital full Status Monitoring
High speed T/R switch (optional )
System Structures include: Amplifiers, OPU,
Antennas and Installation Support.
High reliability, fully qualified to meet the most
extreme environmental conditions
Remote Operation: RS232 / RS422 / RS485/ USB
Fully protected against high VSWR (open/short),
high input power, thermal overload, over/under
voltage and reverse polarity, graceful degradation
Quality Control System based on AS9100
Together with the following standards:
MIL-M-38510, MIL-STD-810, MIL-E-5400,
MIL-E-16400, MIL-STD-2164, MIL-STD-461/462,
IPC 610A, IPC 620
Model
Number
Frequency
Rated
Range (MHz) Power
(Watt)
Min.
Technology
4500A10000
1.5-30
1000W
LDMOS
4D01A00000
1.5-30
1000W
LDMOS
4910A10000
1-30
1500W
4600A10000
20-100
4D02A00000
20-100
4600A20000
AC Supply: 100:240 VAC
Main Feature
Power
Weight
Consumption in kg
max.
Size
28V/110A
50
19''X7U
28V/110A
50
19''X7U
LDMOS
48V/100A
55
19''X7U
500W
LDMOS
28V/80A
52
19''X5U
1000W
LDMOS
28V/168A
51
19''X7U
100-500
250W
LDMOS
28V/75A
51
19''X5U
4D03A00000
100-500
500W
LDMOS
28V/120A
62
19''X7U
4930A10000
100-500
800W
LDMOS
48V/70A
55
19''X7U
4500A20000
30-520
500W
GaN
28V/78A
55
19''X7U
4500A40000
30-520
1000W
GaN
28V/150A
71
19''X7U
4920A10000
30-520
1500W
LDMOS
48V/160A
71
19''X7U
4600A30000
500-1000
200W
LDMOS
28V/65A
42
19''X5U
4174A00000
500-1000
500W
LDMOS
28V/154A
48
19''X5U
4930A20000
500-1000
800W
LDMOS
48V/80A
58
19''X7U
4920A20000
500-1000
1500W
LDMOS
48V/140A
60
19''X7U
4620A60000
500-1500
250W
GaN
28V/45A
40
19''X7U
4620A40000
1000-2500
500W
GaN
28V/100A
45
19''X7U
4600A40000
1000-3000
100W
GaN
Fast T/R
Included
28V/32A
42
19''X5U
4940A10000
1000-3000
300W
GaN
Bank
Included
48V/90A
55
19''X7U
4800A20000
500-3000
2x100W
LDMOS&GaN
Fast Bank Filters
28V/110A
Included
50
19''X7U
4900A40000
3000-6000
45
19"X3U
4620A20000
100-500
51
19''X5U
Fast T/R
Included
SW.
SW.
Filters
100W
GaN and mechanical specifications, please contact
28V/35A
For
custom electrical
EW and 500W
Sigint- ELISRA Sales:
microwave@elbitsystems.com
(or)
+972-3-6175655
LDMOS
28V/110A
SOLID STATE TRANSMITTERS 43
Solid State Power Amplifier
30MHz-500MHz
Main Features
Innovative GaN Transistor Module Technology
Broad Band Frequency Range of 30-500MHz
Full RF Power of 1KW for up to VSWR of 2:1
Extractable Amplifier Modules for Ease of
Configuration / Maintenance
Space Saving 19”x7U Drawer
New Cooling Combination of Heat Pipes / Air
Conduction
For custom electrical and mechanical specifications, please contact
EW and Sigint- ELISRA Sales: microwave@elbitsystems.com (or) +972-3-6175655
44
MICROWAVE RF PRODUCTS • CATALOG NO. 45140537
Catalog Reference No. 45140537
For custom electrical and mechanical specifications,
Please contact EW and Sigint- ELISRA
Sales: microwave@elbitsystems.com (or) +972-3-6175655
Operations and MW Business Line
Elbit Systems Ltd. - EW and SIGINT-Elisra
Operations and MW Business Line
48 Mivtza Kadesh St., Bene Beraq 5121701 Israel
Tel. 972-3-6175655 Fax. 972-3-6175299
Website: www.mw-elisra.com
E-mail: microwave@elbitsystems.com
