PERIODIC MAINTENANCE
ENGINE AND EMISSION CONTROL MAINTENANCE
(R9M DIESEL ENGINE for NEW ZEALAND)
Abbreviations: I = Inspect: correct or replace if necessary, R = Replace, [ ] = At the specified mileage only
MAINTENANCE OPERATION
MAINTENANCE INTERVAL
Perform at a kilometer (mile) or month interval, whichever comes first.
km x 1,000
(Miles x 1,000)
Months
10
20
30
40
50
60
70
80
(6)
(12)
(18)
(24)
(30)
(36)
(42)
(48)
6
12
18
24
30
36
42
48
Engine compartment and under vehicle
Timing chain
See NOTE (1)
Drive belt
See NOTE (2)
I
I
I
I
Crankshaft pulley
See NOTE (3)
I
I
I
I
Engine oil (Use recommended oil)
See NOTE (4)
R
R
R
R
Engine oil filter (Use recommended oil filter)
See NOTE (4)
R
R
R
R
I
I
I
I
Cooling system
Engine coolant (Use genuine NISSAN Engine Coolant or equivalent
in its quality)
See NOTE (5)
Air cleaner filter
Intake & exhaust valve clearance
See NOTE (7)
D
D
D
[R]
Maintenance items with “
R
I
I
See NOTE (6)
Fuel lines
Fuel filter
R
D
[R]
D
D
[R]
” should be performed more frequently according to “Maintenance Under Severe Driving Conditions”.
NOTE:
・ (1) Every replace at 300,000 km (180,000 miles)/120 months.
・(2) Replace every 160,000 km (96,000 miles)/72 months
・(3) Replace every 160,000 km (96,000miles) / 240 months
・ (4) If the oil replacement indicator is displayed, change the engine oil and filter as soon as possible. After replacing the engine oil, reset the display.
・ (5) Use Genuine NISSAN Engine Coolant (blue) or equivalent in its quality, in order to avoid possible aluminum corrosion within the engine cooling system caused by
the use of non-genuine engine coolant. Check and correct the engine coolant mixture ratio every 40,000km (24,000miles) or 24 months.
First replacement interval is 160,000 km (96,000 miles) or 96 months. After first replacement, replace every 80,000 km (48,000miles) or 48 months.
・ (6) If valve noise increases, check valve clearance.
・ (7) Drain water when water level sensor lamp turns on in combination meter.
1
D
D
[R]
CHASSIS AND BODY MAINTENANCE
(R9M DIESEL ENGINE for GOM)
Abbreviations: I = Inspect: correct or replace if necessary, R = Replace, [ ] = At the specified mileage only
MAINTENANCE OPERATION
MAINTENANCE INTERVAL
10
20
30
40
50
60
70
80
(6)
(12)
(18)
(24)
(30)
(36)
(42)
(48)
6
12
18
24
30
36
42
48
Brake & clutch, systems and fluids (For level & leaks)
I
I
I
I
I
I
I
I
Brake & clutch, exhaust systems
I
I
I
I
I
I
I
I
Perform at kilometers (miles) interval or months interval, whichever comes first.
km x 1,000
(Miles x 1,000)
Months
Underhood and under vehicle
Brake fluid
R
R
Brake booster vacuum hoses, connections & check valve
I
I
See NOTE (1)
CVT fluid (For level & leaks)
I
I
I
I
Steering gear & linkage, axle & suspension parts, propeller shaft & drive shafts
I
I
I
I
Wheel alignment(If necessary, rotate & balance wheels)
I
I
I
I
Brake pads, rotors & other brake components
I
I
I
I
I
I
I
I
Lock, hinges & hood latch
L
L
L
L
L
L
L
L
Seat belts, buckles, retractors, anchors & adjuster
Foot brake, parking brake & clutch (For free play, stroke & operation)
I
I
Air conditioner filter
Maintenance items with “
I
I
I
R
I
R
I
I
I
R
I
I
I
R
” should be performed more frequently according to “Maintenance Under Severe Driving Conditions”.
NOTE:
(1) Use only Genuine NISSAN CVT fluid. If towing a trailer, using a camper or a car-top carrier, or driving on rough or muddy roads, inspect CVT fluid deterioration at NISSAN dealers
every 100,000 km (60,000 miles), then change CVT fluid if necessary.
And if the inspection is not performed, change (not just inspect) CVT fluid every 100,000 km (60,000 miles).
Using transmission fluid other than Genuine NISSAN CVT Fluid will damage the CVT, which is not covered by the warranty.
Refer to owner's manual for more information regarding correct fluids.
1
MAINTENANCE UNDER SEVERE DRIVING CONDITIONS
(R9M DIESEL ENGINE for NEW ZEALAND)
The maintenance intervals shown on the preceding pages are for normal operating conditions. If the vehicle is mainly operated
under severe driving conditions as shown below, more frequent maintenance must be performed on the following items as shown
in the table.
Severe driving conditions
A
B
C
D
E
F
G
H
I
J
K
Driving under dusty conditions
Repeatedly driving short distances
Towing a trailer or caravan
Extensive idling
Driving in extremely adverse weather conditions or in areas where ambient temperatures are either extremely low or extremely high
Driving in high humidity areas or in mountainous areas
Driving in areas using salt or other corrosive materials
Driving on rough and/or muddy roads or in the desert
Driving with frequent use of braking or in mountainous areas
Frequent off road use or driving in water
Sustained high speed driving
L
M
Repeated short journeys, cold engine at low temperature
Low speed driving (Average speed < 30 km/h)
Operation : Inspect = Inspect and correct or replace as necessary.
Driving Condition
Maintenance item
Maintenance
operation
Maintenance interval
A .
.
D
.
.
.
.
.
.
.
.
M Air cleaner filter
Replace
More frequently
A B
C
D
.
.
.
.
.
.
.
.
.
Replace
Every 10,000 km (6,000 miles) or 6
months
.
.
C
D
.
.
.
.
.
.
.
.
M Drive belt
Replace
Every 80,000 km (48,000 miles) or 36
months
.
.
C
D
.
.
.
.
.
.
.
.
M Crankshaft pulley
Replace
Every 80,000 km (48,000 miles) or 120
months
A .
C
D
.
.
.
.
.
.
.
.
M Fuel filter
Replace
Every 10,000 km (6,000 miles) or 12
months
.
.
.
.
.
F
.
.
.
.
.
.
.
Brake fluid
Replace
Every 20,000 km (12,000 miles) or 12
months
.
.
.
.
.
.
G
H
.
.
.
.
.
Steering gear & linkage, axle & suspension parts, propeller shaft & drive
shafts
Inspect
Every 10,000 km (6,000 miles) or 6
months
A .
C
.
.
.
G
H
I
.
.
.
.
Brake pads, rotors & other brake components
Inspect
Every 5,000 km (3,000 miles) or 3
months
.
.
.
.
.
.
G
.
.
.
.
.
.
Lock, hinges & hood latch
Lubricate
Every 5,000 km (3,000 miles) or 3
months
A .
.
.
.
.
.
.
.
.
.
.
.
Air conditioner filter
Replace
More frequently
Engine oil & engine oil filter
1