GAF MATERIALS CORPORATION
MATERIAL SAFETY DATA SHEET
MSDS # 2038
MSDS DATE: 06/03
SECTION 1: PRODUCT AND COMPANY IDENTIFICATION
PRODUCT NAME:
EverGuard® EPDM Water-Based Bonding Adhesive
CHEMICAL NAME/SYNONYM:
CHEMICAL FAMILY:
MANUFACTURER:
ADDRESS:
24 HOUR EMERGENCY
PHONE:
CHEMTREC PHONE:
PREPARED BY:
APPROVED BY:
Proprietary Emulsion
Mixture
GAF Materials Corporation
1361 Alps Road, Wayne, NJ 07470
800-424-9300
800-424-9300
Bill Kuhn
Dan Helman
NFPA HAZARD RATING:
0
1
0
Health
Flammable
Reactive
Special Hazards
OSHA HAZARDOUS:
HMIS HAZARD RATING:
1
1
0
Health
Flammable
Reactive
Special Hazards
Yes
No
SECTION 2: COMPOSITION/INFORMATION ON INGREDIENTS
CHEMICAL NAME
Antimony Pentoxide
Mineral Spirits
Nonhazardous as per 29
CFR 1910.1200.
COMMON NAME
Stibic
CAS #
Anhydride
% (BY WT)
1314-60-9 1.6)
Stoddard
Solvent
None
8052-51-3
7
EPA TSCA
Registered
>91.4
EXPOSURE LIMITS
PEL 0.5 mg/M3 (as Sb
TLV 0.5 mg/M3 (as Sb)
PEL 500 ppm TLV 100
ppm
None Established
SECTION 3: HAZARDS IDENTIFICATION
PRIMARY ROUTE OF EXPOSURE:
SIGNS & SYMPTONS OF EXPOSURE
ACUTE HEALTH HAZARDS:
CHRONIC HEALTH HAZARDS:
CARCINOGENICITY:
Inhalation and ingestion
No health hazards have been identified for this product. Antimony compounds may cause local
irritation to the skin and mucous membranes. Antimony Pentoxide may be toxic through an
intraperitoneal route into the body. LD50 = 4 mg/kg, rats, Antimony Pentoxide (intraperitoneal)
N/a
No known adverse effects
Antimony compounds have not been classified as carcinogens by OSHA, ACGIH, NIOSH, IARC,
or NTP. Inhalation of Antimony (CAS 7440-36-0) has been reported to cause lung, thorax or
respiratory system tumors in rats. LCLo = 50 mg/M3/7H/52W-I. (Journal of Toxicology and
Environmental Health, Vol 18, pg 607, 1986)
SECTION 4: FIRST AID MEASURES
FIRST AID PROCEDURES:
NOTES TO PHYSICIANS OR FIRST AID
PROVIDERS:
PAGE 1 OF 4
For eyes, flush with large amounts of water, lifting upper and lower lids occasionally, get
medical attention. For skin contact, wash affected area thoroughly with soap and water. For
inhalation, remove to fresh uncontaminated air. In case of accidental ingestion, do not induce
vomiting. Get medical attention and advise the physician of the nature of the material.
N/a
GAF MATERIALS CORPORATION
MATERIAL SAFETY DATA SHEET
MSDS # 2038
MSDS DATE: 06/03
SECTION 5: FIRE-FIGHTING PROCEDURES
SUITABLE EXTINGUISHING MEDIA:
HAZARDOUS COMBUSTION PRODUCTS:
For the dried product, Water spray, Alcohol foam, or Carbon Dioxide.
Thermal decomposition products may include hydrocarbons, oxides of carbon,
nitrogen and sulfur, acid gases (HCl and HBr).
RECOMMENDED FIRE FIGHTING PROCEDURES:
Wear impermeable protective clothing and self-contained breathing apparatus.
UNUSUAL FIRE & EXPLOSION HAZARDS:
None
SECTION 6: ACCIDENTAL RELEASE MEASURES
N/a
ACCIDENTAL RELEASE MEASURES:
SECTION 7: HANDLING AND STORAGE
HANDLING AND STORAGE:
Store between 45°F and 90°F. Keep containers tightly sealed.
OTHER PRECAUTIONS:
STEPS TO BE TAKEN IN CASE MATERIAL IS
REALEASED OR SPILLED:
PRECAUTIONS TO BE TAKEN IN HANDLING
& STORAGE:
N/a
Absorb liquid on inert material. Transfer to secured container for proper disposal.
Store between 45°F and 90°F. Keep containers tightly sealed.
SECTION 8: EXPOSURE CONTROLS/PERSONAL PROTECTION
ENGINEERING CONTROLS:
VENTILATION:
RESPIRATORY PROTECTION:
EYE PROTECTION:
SKIN PROTECTION:
OTHER PROTECTIVE CLOTHING OR
EQUIPMENT:
WORK HYGIENIC PRACTICES:
N/a
Use in a well ventilated area.
No special requirements are expected under normal conditions and use.
Wear safety glasses or chemical splash goggles when pouring, mixing or applying
this material.
Wear chemical resistant gloves when pouring, mixing or applying this material.
Impervious clothing and boots if appropriate.
Wash exposed skin prior to eating, drinking or smoking and at the end of each shift.
Wash contaminated clothing prior to reuse.
EXPOSURE GUIDELINES:
SECTION 9: PHYSICAL AND CHEMICAL PROPERTIES
APPEARANCE & ODOR:
FLASH POINT:
METHOD USED:
EVAPORATION RATE:
pH (undiluted product):
SOLUBILITY IN WATER:
VAPOR DENSITY:
Grey colored liquid, slight odor
170 F
Unknown
Not Applicable
7.5 – 8.5
Dilutable
Equal to Water
Equal to Water
VAPOR PRESSURE:
VOLATILE ORGANIC COMPOUNDS (VOC)
N/a
WITH WATER (LBS/GAL):
N/a
MOLECULAR WEIGHT:
PAGE 2 OF 4
LOWER EXPLOSIVE LIMIT:
UPPER EXPLOSIVE LIMIT:
BOILING POINT:
MELTING POINT:
SPECIFIC GRAVITY:
PERCENT VOLATILE:
None
None
212 F
Not Applicable
1.03
WITHOUT WATER (LBS/GAL):
N/a
43% (wt) at
70° F
GAF MATERIALS CORPORATION
MATERIAL SAFETY DATA SHEET
MSDS # 2038
MSDS DATE: 06/03
SECTION 10: STABILITY AND REACTIVITY
THERMAL STABILITY:
CONDITIONS TO AVOID (STABILITY):
STABLE
UNSTABLE
Do not allow this product to freeze. This product is incompatible with strong oxidizing agents,
acids, and bases.
N/a
INCOMPATIBILITY (MATERIAL TO
AVOID):
HAZARDOUS DECOMPOSITION OR BYPRODUCTS:
HAZARDOUS POLYMERIZATION:
N/a
Will not occur
_________________________________________________________________________________________________________________
SECTION 11: TOXICOLOGICAL INFORMATION
TOXICOLOGICAL INFORMATION:
N/a
SECTION 12: ECOLOGICAL INFORMATION
ECOLOGICAL INFORMATION:
N/a
_________________________________________________________________________________________________________________
SECTION 13: DISPOSAL CONSIDERATIONS
WASTE DISPOSAL METHOD:
RCRA HAZARD CLASS:
N/a
N/a
SECTION 14: TRANSPORT INFORMATION
U.S. D0T Highway
Transportation
U.S. DOT Water
Transportation
U.S. DOT Air Transportation
PROPER SHIPPING NAME:
HAZARD CLASS:
ID NUMBER:
PACKING GROUP:
LABEL STATEMENT:
Not Applicable
Not Applicable
Not Applicable
Not Applicable
Not Applicable
PROPER SHIPPING NAME:
Not Applicable
HAZARD CLASS:
ID NUMBER:
PACKING GROUP:
LABEL STATEMENT:
Not Applicable
Not Applicable
Not Applicable
Not Applicable
PROPER SHIPPING NAME:
HAZARD CLASS:
ID NUMBER:
PACKING GROUP:
LABEL STATEMENT:
Not Applicable
Not Applicable
Not Applicable
Not Applicable
Not Applicable
PROPER SHIPPING NAME:
HAZARD CLASSIFACTION:
ID NUMBER:
LABELS REQUIRED:
OTHER REQUIREMENTS:
Not Applicable
Not Applicable
Not Applicable
Not Applicable
Not Applicable
OTHER REGULATORY
AGENCIES
PAGE 3 OF 4
GAF MATERIALS CORPORATION
MATERIAL SAFETY DATA SHEET
MSDS # 2038
MSDS DATE: 06/03
SECTION 15: REGULATORY INFORMATION
U.S. FEDERAL REGULATIONS:
TSCA (TOXIC SUBSTANCE CONTROL ACT):
CERCLA (COMPREHENSIVE RESPONSE
COMPENSATION, AND LIABILITY ACT):
SARA TITLE III (SUPERFUND AMENDMENTS AND
REAUTHORIZATION ACT):
311/312 HAZARD CATEGORIES:
313 REPORTABLE INGREDIENTS:
N/a
N/a
N/a
N/a
N/a
N/a
_________________________________________________________________________________________________________________
SECTION 16: OTHER INFORMATION
ADDITIONAL COMMENTS:
VOC content is 118 gm/l.
DATE OF PREVIOUS MSDS:
CHANGES SINCE PREVIOUS MSDS:
TELEPHONE NUMBER FOR ADDITIONAL
INFORMATION:
10/02
Phone Numbers
800-766-3411
PAGE 4 OF 4