Material Safety Data Sheet
May be used to comply with OSHA's Hazard Communication Standard,
29CFR 1910. Standard must be consulted for specific requirements
QUICK IDENTIFIER: ERS-200-N
Common Name: NON-FIBRATED
P/N: 020-0015,0016,0017,0018
ASPHALT EMULSION
SECTION 1 Manufacturer's
Name
Address
City, State, ZIP
Ecology Roof Systems
9821 Olde Eight Road, Unit F
Northfield, OH 44067
Signature of Person
Responsible for Preparation (Optional)
Date Prepared
IN CASE OF CHEMICAL EMERGENCY
SPILL, LEAK, FIRE, EXPOSURE, OR ACCIDENT
CALL CHEMTREC DAY OR NIGHT:
(800) 424-9300
For Additional Information Call
10-31-2007
(800) 553-3833
SECTION 2 - HAZARDOUS INGREDIENTS/IDENTITY
Ingredient Name
Clay, Bentonite
Kaolin
Kathon LX-1.5 Biocide
Asphalt
CAS Number
1302-78-9
1332-58-7
26172-55-4
8052.42.4
OSHA_PEL
AGGIH_TL
15 mg/m3
0.1 mg/m3
2.0 mg/m3
0.3 mg/m3
0.5 mg/m3
Other Limits
F1, F2, F3
F1, F2, F3
Notes: F1: Contains quartz which is a carcinogen (OSHA, IARC, and NTP). Risk of cancer depends on duration and level of exposure.
F2: OSHA PEL Quartz (total dust) = 30 divided by (% quartz + 2) in mg/m3
F3: ACGIH TLV Quartz = 0.025 mg/m3
There are no SARA 313 ingredients in this material in excess of de minimis amounts. “Asphalt may contain
detectable amounts of chemicals known to the State of California to cause cancer or reproductive harm.
SECTION 3 - PHYSICAL & CHEMICAL CHARACTERISTICS
Boiling Point
212ºF
N/A
Vapor Pressure (mm Hg)
>1
Vapor Density (Air = 1)
Black brown
Color
Negligible
Odor
1.06
Specific Gravity
N/A
Melting Point
<1
Evaporation Rate (Butyl Acetate = 1)
Weight Per Gallon
Solubility in Water
Appearance
PH
Max VOC
Max VOS
Water (weight)
Volatile (weight)
8.8 lbs
Dispersible
Black fluid
N/A
0 g/l
0 lbs/gal
< 53%
< 53%
SECTION 4 - FIRE & EXPLOSION DATA
Flash Point Method
Flash Point Temperature
LEL Flammable Limit
UEL Flammable Limit
Extinguishing Media
Fire Fighting Procedures
Additional Procedures
Unusual Fire and Explosion Hazards
N/A
> 212ºF
N/A
N/A
Foam, CO2, Dry Chemical; Water Fog
Dried residue, use self-contained breathing apparatus
None
Closed containers could burst due to steam generation
SECTION 5 - PHYSICAL HAZARDS (REACTIVITY DATA)
Material is stable
Avoid freezing
Strong Oxidants
Fumes, CO2, Carbon Monoxide if combustion is
incomplete, Smoke
May Not Occur
N/A
Stability
Conditions to Avoid
Incompatibility (Materials to Avoid)
Hazardous Decompositions or
Byproducts
Hazardous Polymerization
Conditions to Avoid
1 of 3
SECTION 6 - HEALTH HAZARDS
Routs of Entry
Eyes
Symptoms
Tearing, redness, or swelling
Slight irritation
Ingestion
May be a health hazard if
ingested in large quantities
N/A
Possible dermatitis or
allergenic reaction on
repeated contact
Inhaled
Skin
Emergency & First Aid Procedures
Flush gently with large amounts of water for at least 15
minutes, lifting upper and lower lids occasionally, Get
immediate medical attention.
Get prompt medical attention
N/A
Remove contaminated clothes and wash with a
waterless hand cleaner or soap and water.
Flush with clean cool water.
SECTION 7 - PRECAUTIONS FOR SAFE HANDLING & USE
Steps to be taken in case
material is released or
spilled
Waste disposal method
Precautions for handling
and storage
Other precautions
Keep people away. Recover free liquid. Add absorbent sand, earth,
sawdust, etc. to spill area.
Assure conformity with applicable disposal regulations
KEEP FROM FREEZING. Keep containers closed when not in use. Do
not handle or store near heat or strong oxidants. Adequate ventilation
required.
Avoid prolonged or repeated contact with skin. Remove contaminated
clothing and launder before reuse. Remove contaminated shoes and
thoroughly dry before reuse. Wash skin thoroughly with soap and water
after contact.
SECTION 8 - INDUSTRIAL HYGIENE CONTROL MEASURES
Local Exhaust
Mechanical (General)
Special Ventilation
Other
Respirator
Gloves
Goggles
Clothing
Ventilation
Protective Equipment
Required
Work Hygienic Practices
N/A
N/A
N/A
N/A
N/A
Normal work gloves
Wear eye protection
Other clothing to avoid repeated skin contact
Practice good work hygiene
SECTION 9 - SPECIAL PRECAUTIONS FOR SAFE HANDLING & STORAGE
Precautions for handling and storage
Other precautions
KEEP FROM FREEZING
N/A
SECTION 10 - TRANSPORTATION DATA
DOT
Non-Bulk
Not regulated (Water based material
Non-bulk - PROTECT FROM
FREEZING)
Not regulated (Water based material
Bulk - PROTECT FROM FREEZING)
N/A
PROTECT FROM FREEZING
PROTECT FROM FREEZING
Bulk
IMDG
IATA
Note
Not Regulated
Not Regulated
2 of 3
SECTION 11 - STATE ADDENDUM
Ingredient
Kaolin
CAS Number
1332-58-7
Calcium
Metasilicate
(NYG, WOL)
Water
Asphalt
13983-17-0
7732-18-5
8052-42-4
Notes
A Minnesota Hazardous Substance List material
A Pennsylvania Hazardous Substance List material
A New York List of Hazardous Substances materials
See current Material Safety Data Sheet
A Florida Toxic Substances List material
A Massachusetts Hazardous Substance List material
A Minnesota Hazardous Substance List material
A Pennsylvania Hazardous Substance List material
A Washington State Permissible Exposure for Air Contaminants
material
Asphalt may contain detectable amounts of chemicals known to the
State of California to cause cancer or reproductive harm.
SECTION 12 - OTHER INFORMATION
HEALTH
FLAMMABILITY
REACTIVITY
PERSONAL PROTECTION
HMIS
1
0
0
A
SECTION 13 - DISCLAIMER
The information contained herein is furnished without warranty of any kind. Users should consider this data
only as a supplement to there information gathered by them and must make independent determinations of
suitability and completeness of information from all sources to assure proper use and disposal of these
materials and the safety and health of employees and customers.
Information on this form is furnished solely for the purpose of compliance with OSHA Hazard Communication
Standard, 20 CFR 1910.1200, the Workplace Hazardous Material Information System (WHMIS) and shall
not be used for any other purpose.
3 of 3