MSDS Health Hazard Data
for the chemicals used in the
“Chip Fabrication Process”
===========================================================================
Health Hazard Data: ACETONE
===========================================================================
LD50-LC50 Mixture: (ORAL-RAT)8.5-10.7 G/KG;ALMOST NON-TOXIC
Route Of Entry - Inhalation: YES
Route Of Entry - Skin: YES
Route Of Entry - Ingestion: NO
SLIGHTLY IRRITATING. INHALATION:CENTRAL NERVOUS SYSTEM DEPRESSION.
DERMATITIS. INHALATION:CNS DEPRESSION. INGESTION:NOT A LIKELY ROUTE OF
ENTRY.
Carcinogenicity - NTP: NO
Carcinogenicity - IARC: NO
Carcinogenicity - OSHA: NO
Explanation Carcinogenicity: THIS MATERIAL IS NOT CONSIDERED TO BE A
CARCINOGEN BY NTP, IARC, OR OSHA.
Signs/Symptoms Of Overexp: EYES:IRRITATION. SKIN:REDDNESS, EDEMA OR DRYING
OF THE SKIN. INHALATION:DROWSINESS, NARCOSIS, AND UNCONSCIOUSNESS.
INGESTION:NOT A LIKELY ROUTE OF ENTRY.
Med Cond Aggravated By Exp: NONE SPECIFIED BY MANUFACTURER.
Emergency/First Aid Proc: EYES:FLUSH WITH WATER FOR AT LEAST 15 MIN. GET
MEDICAL ATTENTION. SKIN:WASH EXPOSED AREA WITH SOAP AND WATER.
INHALATION:REMOVE TO FRESH AIR. APPLY ARTIFICIAL RESPIRATION IF NECESSARY.
INGESTION:DO NOT INDUCE VOMITING. ASPIRATION MAY CAUSE CHEMICAL PNEUMONIA.
===========================================================================
Health Hazard Data: METHANOL
===========================================================================
LD50-LC50 Mixture: ORAL LD50:9100MG/KG IN RATS.
Route Of Entry - Inhalation: YES
Route Of Entry - Skin: YES
Route Of Entry - Ingestion: NO
Health Haz Acute And Chronic: LIQ/VAP CAN PENETRATE SKIN/MUCOUS MEMBRANE
THERFORE CONTROL OF INHAL MAY NOT BE SUFFICIENT TO TPEVNET EXCESSIVE DOSE.
HARMFUL IF INHAL/ABSORBED THRU SKIN,CAUSES DMG TO LIVER/KIDNEY/NERVOUS
SYST.CAUSES EYE/SKIN/NOSE/THROAT IRRIT.MAY BE FATAL/CAUSE BLINDNESS IF
SWALLOWED.CAN'T BE MADE NON-POISONOUS.
Carcinogenicity - NTP: NO
Carcinogenicity - IARC: NO
Carcinogenicity - OSHA: NO
Explanation Carcinogenicity: PER MSDS:LISTED AS CARCINOGEN IN:IARC/NTP/
OSHA:NO.
Signs/Symptoms Of Overexp: ACUTE:NON-SPEC DISCOMFT(NAU,WEAK),TEMP CNS
DEPRESS W/ANETHETIC EFFECTS(DIZZ,HEAD,CONFUSION,INCOORD,UNCONSC),BLINDNESS.
HIG EXPO:ABNOR LIVER/KIDNEY FUNCTION DETECTED BY LAB TEST,FATALITY FROM
GROSS EXPO.INGEST(AS LITTLE AS 60ML)MAY CAUSE BLINDNESS,FATALITY.SKIN
PERMEATION CAN OCCUR IN AMTS-PRODUCES SYS TOXICITY.
Med Cond Aggravated By Exp: INDIVIDUALS W/PRE-EXISTING DISEASES OF RETINA
OR LIVER MAY HAVE INCREASED SUSCEPTIBILITY TO TOXICITY OF EXCESSIVE
EXPOSURES.
Emergency/First Aid Proc: EYE:FLUSH IMMED/THOROUGHLY FOR 15MINS W/
WATER.IRRIT PERSISTS GET MED ATTN.SKIN:IMMED FLUSH W/PLENTY OF WATER FOR
@LEAST 15MINS WHILE REMOVING CONTAMIN CLOTH/SHOES.CALL DR.INHAL:IMMED MOVE
TO FRESH AIR.NOT BREATHING GIVE ART RESP;BREATHING DIFFICULT GIVE OXY.CALL
DR.INGEST:AS LITTLE AS 60ML MAY CAUSE BLINDNESS/FATALITY.IMMED GIVE 2 GL
7
===========================================================================
Health Hazard Data: AMMONIUM HYDROXIDE
===========================================================================
Route Of Entry - Inhalation: YES
Route Of Entry - Skin: YES
Route Of Entry - Ingestion: YES
Health Haz Acute And Chronic: CONSIDERED A POISON BY CONSUMER PRODUCTS
SAFETY COMMISION BECAUSE OF STRENGTH.
Carcinogenicity - NTP: NO
Carcinogenicity - IARC: NO
Carcinogenicity - OSHA: NO
Signs/Symptoms Of Overexp: RASPY CONTINUOUS COUGHING, RUNNY NOSE, EYE,
SKIN AND/OR THROAT IRRITATIONS.
Med Cond Aggravated By Exp: SKIN CUTS, BURNS, OR ABRASIONS. IRRITATED
EYES. RESPIRATORY AILMENTS.
Emergency/First Aid Proc: EYES: FLUSH W/LRG QTY WATER 15 MIN. CALL
PHYSICIAN. SKIN: REMOVE CLOTHING/WASH AREA WITH WATER. INGESTION: DO NOT
GIVE LIQUID IF VICTIM IS UNCONSCIOUS OR DROWSY. OTHERWISE, DRINK PROMPTLY
LRG QTY OF WTER. FOLLOW WITH FRUIT JUICE AND VEGETABLE OIL. AVOID ALCOHOL.
CALL PHYSICIAN IMMEDIATELY.
===========================================================================
Health Hazard Data: HYDROGEN PEROXIDE
===========================================================================
LD50-LC50 Mixture: UNKNOWN
Route Of Entry - Inhalation: YES
Route Of Entry - Skin: NO
Route Of Entry - Ingestion: YES
Health Haz Acute And Chronic: PRODUCT MAY BE CORR TO EYES/SKIN & IRRIT TO
RESP TRACT.ACUTE:MODERATELY TOXIC. CHRONIC:NOT DETERMINED.
Carcinogenicity - NTP: NO
Carcinogenicity - IARC: NO
Carcinogenicity - OSHA: NO
Explanation Carcinogenicity: PER MSDS:EXPERIMENTAL MUTAGEN.
Signs/Symptoms Of Overexp: CAUSES BURNS; DECOMPOSES IN THE BOWEL BEFORE
ABSORPTION YIELDING LARGE VOLUME OF OXYGEN WHICH MAY CAUSE BOWEL TO
RUPTURE.
Med Cond Aggravated By Exp: PERSONS W/PRE-EXISTING EYE OR SKIN DISORDERS
OR CHRONIC RESPIRATORY DISEASE MAY BE MORE SUSCEPTIBLE TO THE EFFECTS OF
THE SUBSTANCE.
Emergency/First Aid Proc: EYE/SKIN:IMMED FLUSH EYE/SKIN W/WATER FOR
15MINS. REMOVE CONTAMINATED CLOTHING. CALL PHYSICIAN. INGEST:DO NOT INDUCE
VOMITING. GIVE 1-2 GLASSES OF WATER. CALL PHYSICIAN IMMED. NEVER GIVE
ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON. INHAL:REMOVE TO FRESH AIR.
ASSES OF WATER.INDUCE VOMIT.CALL DR.NEVER GIVE ANYTHING (SUPPLEM)
===========================================================================
Health Hazard Data: HYDROCHLORIC ACID
===========================================================================
LD50-LC50 Mixture: LD50:ORAL(RBT) 900 MG/KG
Route Of Entry - Inhalation: YES
Route Of Entry - Skin: YES
Route Of Entry - Ingestion: YES
Health Haz Acute And Chronic: CONTACT CAUSES PERMANENT DAMAGE TO EYES,
SEVERE BURNS, AND ULCERATIONS ON SKIN. INHALATION OF VAPORS WILL DAMAGE
RESPIRATORY TRACT.
Carcinogenicity - NTP: NO
Carcinogenicity - IARC: NO
Carcinogenicity - OSHA: NO
Explanation Carcinogenicity: NOT RELEVANT.
8
Signs/Symptoms Of Overexp: SEE HEALTH HAZARDS.
Med Cond Aggravated By Exp: NONE SPECIFIED BY MANUFACTURER.
Emergency/First Aid Proc: EYES: FLUSH WITH WATER FOR AT LEAST 15 MIN; GET
IMMED MED ASSISTANCE. SKIN: REMOVE CONTAMINATED CLOTHING AND WASH WITH SOAP
AND WATER. INHAL: MOVE TO FRESH AIR AND GIVE ARTF RESP IF BREATHING HAS
STOPPED. INGEST: DO NOT INDUCE VOMITING. GIVE MILK OR WATER IF CONSCIOUS.
GET IMMED MED ATTN. GET MED ASSISTANCE FOR ALL CASES OF OVEREXPOSURE.
===========================================================================
Health Hazard Data: HMDS PRIMER
===========================================================================
LD50-LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry - Inhalation: YES
Route Of Entry - Skin: YES
Route Of Entry - Ingestion: YES
Health Haz Acute And Chronic: ACUTE:VAPORS ARE IRRITATING TO EYES, NOSE &
RESPIRATORY TRACT. OVEREXPOSURE TO VAPORS MAY RESULT IN HEADACHE, NAUSEA,
VOMITING. VAPORS HAVE OBJECTIONABLE ODOR. INGESTION MAY CAUSE HEADACHE,
NAUSEA, VOMITING & ABDOMINAL PAINS. INGESTION MAY CAUSE MODERATE TOXICITY.
CONTACT W/EYES & SKIN CAUSES SEVERE (EFTS OF OVEREXP)
Carcinogenicity - NTP: NO
Carcinogenicity - IARC: NO
Carcinogenicity - OSHA: NO
Explanation Carcinogenicity: NOT RELEVANT
Signs/Symptoms Of Overexp: HLTH HAZ:IRRITATION & MAY CAUSE CHEMICAL BURNS.
CHRONIC:PROLONGED, REPEATED CONTACT MAY RESULT IN DERMATITIS. PROLONGED OR
WIDESPREAD CONTACT W/SKIN MAY LEAD TO ABSORPTION OF HARMFUL AMOUNTS OF
MATERIAL.
Med Cond Aggravated By Exp: NONE SPECIFIED BY MANUFACTURER.
Emergency/First Aid Proc: INGEST:CONT MD AT ONCE. EYE:FLUSH IMMED W/
PLENTY OF WATER FOR AT LST 15 MINS. CONT MD AT ONCE. SKIN:FLUSH IMMED W/
PLENTY OF WATER FOR AT LST 15 MINS. REMOVE CONTAM CLTHG. CONT MD. WASH
CLTHG BEFORE REUSE. INHAL:REMOVE TO FRESH AIR. IF NOT BRTHG, GIVE ARTF
RESP. IF BRTHG IS DFCLT, GIVE OXYGEN. CONT MD AT ONCE. NOTE TO MD:THERE IS
NO SPECIFIC ANTIDOTE. TREAMENT OF OVEREXP SHLD BE DIRECTED AT(SUPDAT)
===========================================================================
Health Hazard Data: SHIPLEY PHOTORESIST
===========================================================================
Toxicity Data: Toxicological properties have not been thoroughly investigated.
Effects:
·
Acute Effects: Corrosive to all body tissues. Eye and skin contact, inhalation and ingestion can cause severe
irritation and burns. Onset of symptoms may be delayed.
·
Chronic Effects: Prolonged, repeated contact with skin can cause drying, cracking, defatting, dermatitis.
·
Routes of Entry: Inhalation of mists or vapors, eye and skin contact, ingestion, skin absorption.
First Aid:
·
Inhalation: Move to fresh air. If not breathing, give artificial respiration. If breathing is difficult, give oxygen.
Contact physician at once.
·
Skin: Flush immediately with plenty of water for at least 15 minutes. Remove contaminated clothing. Contact
physician. Wash clothing before reuse.
·
Eyes: Flush immediately with plenty of water for at least 15 minutes. Contact physician.
·
Ingestion: Do not induce vomiting. Give large amounts of water. Never give anything by mouth to an
unconscious person. Contact physician.
===========================================================================
Health Hazard Data: SHIPLEY DEVELOPER
===========================================================================
Toxicity Data: Toxicological properties have not been thoroughly investigated.
Effects:
9
·
Acute Effects: Corrosive to all body tissues. Eye and skin contact, inhalation and ingestion can cause severe
irritation and burns. Onset of symptoms may be delayed.
·
Chronic Effects: Prolonged, repeated contact with skin can cause drying, cracking, defatting, dermatitis.
·
Routes of Entry: Inhalation of mists or vapors, eye and skin contact, ingestion, skin absorption.
First Aid:
·
Inhalation: Move to fresh air. If not breathing, give artificial respiration. If breathing is difficult, give oxygen.
Contact physician at once.
·
Skin: Flush immediately with plenty of water for at least 15 minutes. Remove contaminated clothing. Contact
physician. Wash clothing before reuse.
·
Eyes: Flush immediately with plenty of water for at least 15 minutes. Contact physician.
·
Ingestion: Do not induce vomiting. Give large amounts of water. Never give anything by mouth to an
unconscious person. Contact physician.
10