THERMAL BLOCK
Material Safety Data Sheet
SECTION I - COMPANY IDENTIFICATION
PRODUCT: THERMAL BLOCK
CAT. NO.:
TB11
DISTRIBUTED BY:
Virginia KMP Corporation
4100 Platinum Way
Dallas, Texas 75237
TELEPHONE NUMBERS:
Office:
1-(214) 330-7731
Emergency Only: 1-(800) 424-9300
SECTION II - HAZARDOUS INGREDIENTS
OSHA Hazardous Components (29 CFR 1910.1200)
EXPOSURE LIMITS: 8 HR. TWA
OSHA PEL
ACGIH TLV
The components of this product are non hazardous. The product contains
water and an assortment of clays for thickening.
NE
NE
SECTION III - HAZARDS IDENTIFICATIONS
EMERGENCY OVERVIEW: No hazard under normal undustrial use.
POTENTIAL HEALTH EFFECTS:
INHALATION:
NA
EYE CONTACT:
Mild irritant to eyes.
SKIN CONTACT: Substance does not generally irritate.
INGESTION:
Small amounts (a tablespoonful) swallowed during normal handling operations are not likely to cause injury,
swallowing amounts larger than that may cause injury.
CHRONIC Effects: None known at present.
NOTE:
CARCINOGENICITY: LISTED IN NTP?
No
IARC?
No
OSHA Regulated?
No
SECTION IV - FIRST AID MEASURES
INHALATION:
EYE CONTACT:
SKIN CONTACT:
INGESTION:
No specific treatment is necessary since this material is not likely to be hazardous by inhalation. If exposed to excessive levels
of dusts or fumes, remove to fresh air and get medical attention if cough or other symptoms develop.
Flush with water to clear product.
Wash with soap and water.
Swallowing less than an ounce will not cause significant harm. For larger amounts, do not induce vomiting, but give one or two
glasses of water to drink and get medical attention.
SECTION V - FIRE FIGHTING MEASURES
FLASHPOINT (TEST METHOD):
FLAMMABLE LIMITS:
AUTOIGNITION TEMPERATURE:
NA
LOWER:
NA
NA
UPPER:
NA
GENERAL HAZARD:
No hazard in normal undustrial use.
FIRE FIGHTING INSTRUCTIONS:
NA
EXTINGUISHING MEDIA:
NA
HAZARDOUS COMBUSTION PRODUCTS:
None.
Normal combustion products - carbon dioxide and carbon monoxide.
SECTION VI - ACCIDENTAL RELEASE MEASURES
LAND SPILL:
WATER SPILL:
Rinse spill area with water and scrape residue.
Will dissolve in water completely. Notify proper authorities.
SECTION VII - HANDLING AND STORAGE
HANDLING:
No special handling requirements necessary.
STORAGE:
Follow normal storage practices. No special requirements recommended.
THERMAL BLOCK
SECTION VIII - EXPOSURE CONTROLS/PERSONAL PROTECTION
ENGINEERING CONTROLS: Natural ventilation.
PERSONAL PROTECTION: None required.
SECTION IX - PHYSICAL AND CHEMICAL PROPERTIES
VAPOR PRESSURE @ 20 C: NA
SPECIFIC GRAVITY (H2O=1): >1
SOLUBILITY IN WATER: Soluble
pH: Neutral
BOILING POINT: 212 F
APPEARANCE & ODOR: Beige paste, negligible odor.
VAPOR DENSITY (Air=1): NA
EVAPORATION RATE (H2O=1): <1
VOC (LB/GAL): NAP
FREEZING POINT: NAP
SECTION X - STABILITY AND REACTIVITY
STABILITY:
Stable.
CONDITIONS TO AVOID:
None known.
MATERIALS TO AVOID:
None.
HAZARDOUS DECOMPOSITION PRODUCTS: None.
HAZARDOUS POLYMERIZATION:
Will not occur.
SECTION XI - TOXICOLOGICAL INFORMATION
NA
SECTION XII - ECOLOGICAL INFORMATION
NA
SECTION XIII - DISPOSAL CONSIDERATIONS
No special disposal considerations.
SECTION XIV - TRANSPORTATION INFORMATION
PROPER SHIPPING NAME: Not regulated.
HAZARD CLASS:
IDENTIFICATION NUMBER:
DOT Emergency Guide #:
Reportable Quantity (RQ):
International:
NA
NA
NA
NA
NA
SECTION XV - REGULATORY INFORMATION
TSCA (Toxic Substance Control Act): Components of this product are listed on the TSCA Inventory.
CERCLA (Comprehensive Environmental Response, Compensation and Liability Act):
NA
SARA TITLE III (Superfund Amendments and Reauthorization Act):
CALIFORNIA PROPOSITION 65:
NA
NA
SECTION XVI - OTHER INFORMATION
State Right-to-Know Programs:
NFPA Ratings
Health:
Flammability:
Reactivity:
HMIS Protective Equipment:
0
0
0
X
See your supervisor
Prepared by: Virginia KMP Corporation
revised: 2/12/2016
This information is furnished without warranty, expressed or implied, except that it is accurate to the best knowledge of Virginia KMP. The data on
this sheet related only to specific material designated herein. Virginia KPM assumes no legal responsibility for use or reliance upon these data.