1
--------------------------------------------------------------------------SECTION 1 - CHEMICAL PRODUCT AND COMPANY IDENTIFICATION
--------------------------------------------------------------------------CHEMICAL PRODUCT IDENTIFICATION:
PRODUCT ID . . . . . . . . . . : 722L/COLORS
PRODUCT CLASS . . . . . . . . . : PAINT, WATER BASE
TRADE NAME . . . . . . . . . . : ROMATEX ACRYLIC TEXTURE FINISH
FORMULA ID . . . . . . . . . . : 722L
MSDS PREPARATION DATE . . . . . . : 03/11/2009
MANUFACTURER IDENTIFICATION:
NAME . . . . . . . . . . . . . : LEVWALL, INC.
ADDRESS . . . . . . . . . . . . : 816 A PICKENS INDUSTRIAL DRIVE
MARIETTA, GA 30062
TELEPHONE . . . . . . . . . . . : 678-819-4444
EMERGENCY CONTACT . . . . . . . : CHEMTREC
EMERGENCY TELEPHONE . . . . . . : (800) 424-9300
--------------------------------------------------------------------------SECTION 2 - COMPOSITION, INFORMATION ON INGREDIENTS
--------------------------------------------------------------------------1
CAS# 107-21-1
ETHYLENE GLYCOL
PCT BY WT: 1.1300 VAPOR PRESSURE:
.080 MMHG @ 68F
2
EXPOSURE LIMIT:
ACGIH TLV/TWA:
OSHA PEL/TWA:
39.4 ppm
PEL: 50 ppm
OSHA CEILING:
50 ppm
LC50:
Acute Inhalation: None
LD50:
Acute Oral: 4.0 g/kg (Rat); Acute Dermal: N
--------------------------------------------------------------------------2
HYDRATED ALUMINUM SILICATE
PCT BY WT: .5 - 5
EXPOSURE LIMIT:
--------------------------------------------------------------------------3
CAS# 13463-67-7
TITANIUM DIOXIDE
PCT BY WT: .5 - 5
EXPOSURE LIMIT:
ACGIH TLV/TWA:
OSHA PEL/TWA:
TLV: 10 mg/cu m TWA
PEL: 15 mg/cu m TWA
LC50:
Inhalation,Rat: >6.82 mg/l (4 Hr.)
LD50:
Oral,Rat: >25 g/kg; Dermal,Rabbit: >10 g/kg
---------------------------------------------------------------------------
3
4 CAS# 1317-65-3
CALCIUM CARBONATE
PCT BY WT: 25 - 35
EXPOSURE LIMIT:
ACGIH TLV/TWA:
OSHA PEL/TWA:
10 mg/cu m Total Dust
15 mg/cu m Total Dust; 5 mg/cu m Respirable D
OTHER LIMITS:
CARCINOGENICITY: NTP/IARC -NO
OSHA - NO
4
--------------------------------------------------------------------------LEVWALL, INC.
MATERIAL SAFETY DATA SHEET
722L
2
----------------------------------------------------------------------------------------------------------------------------------------------------5 CALCINED KAOLIN
CAS# 1332-58-7
ALUMINIUM SILICATE
PCT BY WT: .5 - 5
EXPOSURE LIMIT:
ACGIH TLV/TWA:
OSHA PEL/TWA:
TLV: 2 mg/cu m Respirable fraction
PEL: 10 mg/cu m Total Dust; 5 mg/cu m Resp.
OTHER LIMITS:
CARCINOGENICITY:
OSHA/NTP/IARC - NO
--------------------------------------------------------------------------6 CAS# 12001-26-2
MICA
PCT BY WT: 6.2090
EXPOSURE LIMIT:
ACGIH TLV/TWA:
TWA: 20 mppcf
ACGIH TLV/STEL:
STEL - 3 mg/cu m
5
OTHER LIMITS:
CARCINOGENICITY:
IARC/NTP/OSHA - NO
--------------------------------------------------------------------------7
CAS# 14808-60-7
CRYSTALLINE SILICA - QUARTZ
PCT BY WT: 11.3870
EXPOSURE LIMIT:
ACGIH TLV/TWA:
OSHA PEL/TWA:
TWA - 0.10 mg/cu m (Respirable Dust)
TWA - 0.10 mg/cu m
OTHER LIMITS:
CARCINOGENICITY:
IARC: SUSPECT CARCINOGEN.
NTP: ANTICIPATED CARCINOGEN.
OSHA: NO.
THIS LISTING IS CONTROVERSIAL.
---------------------------------------------------------------------------
************************************************************************
This product contains one or more reported carcinogens or suspected
carcinogens which are noted NTP, IARC, or OSHA-Z in the other limits
recommended column.
************************************************************************
6
************************************************************************
This substance is classified as a hazardous air pollutant.
************************************************************************
************************************************************************
This product contains pigments which may become a dust nuisance when
removed by abrasive blasting, sanding, or grinding.
************************************************************************
************************************************************************
This product contains one or more reported or suspected reproductive
toxins which are noted NTP, IARC, or OSHA-Z in the other limits recommended
column.
7
--------------------------------------------------------------------------LEVWALL, INC.
MATERIAL SAFETY DATA SHEET
722L
2
---------------------------------------------------------------------------
************************************************************************
************************************************************************
This product contains one or more reported teratogens or suspected
teratogens which are noted NTP, IARC, or OSHA-Z in the other limits
recommended column.
************************************************************************
--------------------------------------------------------------------------SECTION 3 - HAZARDS IDENTIFICATION
--------------------------------------------------------------------------MEDICAL CONDITIONS AGGRAVATED BY EXPOSURE
None generally recognized.
ROUTE(S) OF EXPOSURE
Exposure may be INHALATION and/or SKIN or EYE contact, depending on
conditions of use. To minimize exposure, follow recommendations for
proper use, ventilation, and personal protective equipment.
SKIN: N/A
INGESTION: N/A
8
INHALATION: With poor ventilation, vapor or spray mist may irritate
respiratory mucous membranes, causing headache & nausea.
EYE CONTACT: Primary irritant.
CHRONIC HEALTH HAZARDS: Applicable, only if Crystalline Silica (Quartz,
Cristobalite) is present in Section 2, Ingredients. Crystalline
Silica is listed by IARC. Long term exposure to high levels of silica dust
which can occur only when sanding or abrading the dry film, may cause lung
damage (silicosis) and possibly cancer.
CARCINOGENICITY: Refer to Section II, if applicable.
--------------------------------------------------------------------------SECTION 4 - FIRST AID MEASURES
--------------------------------------------------------------------------EYE CONTACT: Flush at once with large amounts of luke warm water for at
least 15 minutes and get medical attention.
SKIN CONTACT: Remove from skin with soap and water. Remove drenched
clothing. If irritation persists, consult a physician.
INHALATION: If affected by inhalation of vapor or spray mist, remove to
fresh air. If necessary, restore breathing; in this case
contact physician at once.
INGESTION:
If victim is conscious, give 2 glasses of water to dilute.
Do not induce vomiting. Consult physician or poison control
center at once.
NOTE TO PHYSICIAN: N/A
9
--------------------------------------------------------------------------SECTION 5 - FIRE FIGHTING MEASURES
--------------------------------------------------------------------------UNUSUAL FIRE AND EXPLOSION HAZARD
Closed containers may explode when exposed to extreme heat; use water
spray to cool. Product in open containers may spatter when temperature
exceeds boiling point of water.
FIRE-FIGHTING PROCEDURES AND EQUIPMENTS
10
--------------------------------------------------------------------------LEVWALL, INC.
MATERIAL SAFETY DATA SHEET
722L
2
--------------------------------------------------------------------------Full protective equipment including self-contained breathing apparatus
should be used. Water spray may be ineffective. If water is used, fog
nozzles are preferable.
EXTINGUISHING MEDIA
Use extinguishing media appropriate for surrounding fire. After water
evaporates, remaining material will burn; use CO2, dry chemical or foam
(National Fire Protection Association Class B extinguisher).
FIRE AND EXPLOSIVE PROPERTIES OF THE CHEMICAL:
Flammability Classification . . . . . : N/A
Flashpoint . . . . . . . . . . . . . : N/A
Explosion Level . . . . . . . . . . . : Low
- 3.20
High - 15.30
--------------------------------------------------------------------------SECTION 6 - ACCIDENTAL RELEASE MEASURES
--------------------------------------------------------------------------CLEAN-UP
Collect by absorption, shovel and/or wet moping.
11
STEPS TO BE TAKEN IN CASE MATERIAL IS RELEASED OR SPILLED
Ventilate as described in Section VIII. Avoid unnecessary skin
contact. Stop and/or contain spill if it can be done safely, avoiding
discharge into drains, sewers or waterways.
--------------------------------------------------------------------------SECTION 7 - HANDLING AND STORAGE
--------------------------------------------------------------------------SPECIAL COMMENTS
Do not take internally. Wash with soap and water before eating,
drinking, smoking or using toilet. Avoid FREEZING this product.
STORAGE
Do not store above 120 degrees F. Close container after each use.
HANDLING
Transfer only to approved containers with complete & appropriate
labeling. Do not take internally. Keep out of the reach of children.
--------------------------------------------------------------------------SECTION 8 - EXPOSURE CONTROLS, PERSONAL PROTECTION
--------------------------------------------------------------------------PRECAUTIONS TO BE TAKEN IN USE
Use only with adequate ventilation. Avoid breathing vapor & spray
mist. Avoid contact with skin and eyes. Wash hands after using.
This coating may contain materials classified as nuisance particulates (listed "as Dust" in Section II) which may be present at hazardous
12
levels only during sanding or abrading of the dried film. If no specific
dusts are listed in Section II, the applicable limits for nuisance dusts
are ACGIH TLV 10 mg/m3 (total dust), OSHA PEL 15 mg/m3 (total dust),
5 mg/m3 (respirable fraction).
EYE PROTECTION
Wear safety spectacles with unperforated sideshields.
PROTECTIVE GLOVES
13
--------------------------------------------------------------------------LEVWALL, INC.
MATERIAL SAFETY DATA SHEET
722L
2
--------------------------------------------------------------------------None required.
RESPIRATORY PROTECTION
When you don't have adequate protection, use a NIOSH approved
respirator.
VENTILATION
Local exhaust preferable. General exhaust acceptable if the exposure
to materials in Section II is maintained below applicable exposure limits.
Refer to OSHA Standards 1910.94, 1910.107, 1910.108.
--------------------------------------------------------------------------SECTION 9 - PHYSICAL AND CHEMICAL PROPERTIES
--------------------------------------------------------------------------Vapor Density . . . . . . . . . . . . : N/A
Vapor Pressure . . . . . . . . . . . : 17mmHg@ 68 Degrees F (water)
Physical State . . . . . . . . . . . .: LIQUID
Boiling Range . . . . . . . . . . . . : Lower - 379.00 øF
Higher - 401.50 øF
Specific Gravity . . . . . . . . . . : 1.5930
14
Formula Weight per Volume . . . . . . :
VOC . . . . . . . . . . . . . . . . . :
Evaporation Rate . . . . . . . . . :
13.26150 LB/GL
49 G/L .41 LB/GL
.0100 (n-Butyl Acetate = 1
Volatile by Weight . . . . . . . . . : 32.347
Volatile by Volume . . . . . . . . . : 51.328
--------------------------------------------------------------------------SECTION 10 - STABILITY AND REACTIVITY
--------------------------------------------------------------------------HAZARDOUS PRODUCTS OF DECOMPOSITION
Heating to decomposition, as in a fire or welding, may produce
hazardous fumes. Fumes may contain carbon monoxide, carbon dioxide and
oxides of nitrogen.
INCOMPATIBILITIES (Materials to Avoid)
None known.
HAZARDOUS POLYMERIZATION: Will not occur.
STABILITY
This product is stable.
CONDITIONS TO AVOID
High temperatures.
--------------------------------------------------------------------------SECTION 11 - TOXICOLOGICAL INFORMATION
--------------------------------------------------------------------------No data available.
15
--------------------------------------------------------------------------SECTION 12 - ECOLOGICAL INFORMATION
--------------------------------------------------------------------------No data available.
16
--------------------------------------------------------------------------LEVWALL, INC.
MATERIAL SAFETY DATA SHEET
722L
2
----------------------------------------------------------------------------------------------------------------------------------------------------SECTION 13 - DISPOSAL CONSIDERATIONS
--------------------------------------------------------------------------WASTE DISPOSAL
Dispose of this product in accordance with applicable local, county
state and federal regulations, by incinerating, or treating and disposing
in approved facility. Do not incinerate closed containers.
--------------------------------------------------------------------------SECTION 14 - TRANSPORT INFORMATION
--------------------------------------------------------------------------DOT Packaging Group . . . . . . . : N/A
DOT LABEL . . . . . . . . . . . . : NONE
DOT SHIPPING NAME . . . . . . . . : PAINT
DOT PLACARD . . . . . . . . . . . : NONE
UN/NA NUMBER . . . . . . . . . . .: NONE
IATA/IMO INFORMATION . . . . . . .: N/A
DOT Hazard Class . . . . . . . . : N/A
17
--------------------------------------------------------------------------SECTION 15 - REGULATORY INFORMATION
--------------------------------------------------------------------------FEDERAL REGULATIONS:
SARA 313 INFORMATION:
This product contains the following substances subject to the
reporting requirements of Section 313 of Title III of the Superfund
Amendments and Reauthorization Act of 1986 and 40 CFR Part 372:
ETHYLENE GLYCOL
CAS# 107-21-1
PCT BY WT: 1.1300
--------------------------------------------------------------------------STATE REGULATIONS:
INTERNATIONAL REGULATIONS:
************************************************************************
18
--------------------------------------------------------------------------LEVWALL, INC.
MATERIAL SAFETY DATA SHEET
722L
2
--------------------------------------------------------------------------This Material Safety Data Sheet conforms to the Hazard Communication
Standard, 29 CFR 1910.1200(g)(4).
The above information pertains to this product as currently formulated
and is based on the information available at this time. Addition of
reducers or other additives to this product may substantially alter the
composition and hazards of the product. Since conditions of use are outside our control, we make no warranties, express or implied, and assume
no liability in connection with any use of this information.
************************************************************************
Abbreviations used: int - interior; ext - exterior; MSDS - Material Safety
Data Sheet; HMIS - Hazardous Materials Information System; CAS - Chemical
Abstracts Services; pct - percent; wt - weight; mmHg - millimeters of
mercury; F - Fahrenheit; ACGIH - American Conference of Governmental
Industrial Hygienists; TLV - Threshold Limit Value; OSHA - Occupational
Safety and Health Administration; PEL - Permissable Exposure Limit; TWA Time-Weighted Average; STEL - Short Term Exposure Limit; N/A- Not available
or not established; IARC - International Agency for Research on Cancer;
19
NTP - National Toxicological Program; CFR - Code of Federal Regulations;
OSHA -Z - 29CFR 1910, Subpart Z; VOC - Volatile Organic Compounds; TCC Tag Closed Cup; LEL - Lower Explosive Limit; Mg/m3 or Mg/Cu M - milligram
per cubic meter; MPPCF - millions of particles per cubic foot; PPM - parts
per million; NIOSH - National Institute of Occupational Safety and Health;
MSHA - Mine Safety and Health Administration.
Back to RomaTex Page