MATERIAL SAFETY DATA SHEET
This MSDS complies with OSHA’S Hazard Communication Standard 29 CFR 1910.1200 and OSHA Form 174
IDENTITY AND MANUFACTURER’S INFORMATION
NFPA Rating: Health-2: Flammability-2: Reactivity-0: Specific-Corrosive
HMIS Rating: Health-2 : Flammability-2: Reactivity-0: Personal Protection-B
Manufacturer’s Name: Laun-Dry Supply Co., Inc.
Address:
3800 Durazno Avenue
El Paso, Texas 79905
Date Prepared:
09-13-99 Revised; 09-21-2006 Prepared By: STAFF
Information Calls: 915-533-8217
EMERGENCY RESPONSE NUMBER 1(800) 255-3924
DOT: Corrosive liquids, n.o.s., 8, UN1760, PG II
Identity (trade name as used on label)
VERSATOL
MSDS Number C0906
Revision – 3
NOTICE: JUDGMENT BASED ON INDIRECT TEST DATA
SECTION 1 - MATERIAL IDENTIFICATION AND INFORMATION
CAS
OSHA PEL
Number
(ppm)
ACGIH
TLV (ppm)
Carcinogen
Ref.
Sources**
50 PPM
25 PPM SKIN
2 MG/M3
1000 PPM
15 MG/M3
2 MG/M3
1000 PPM
10 MG/M3
d
d
d
d
COMPONENTS-CHEMICAL NAMES AND COMMON NAMES
(Hazardous Components 1% or greater; Carcinogen 0.1% or greater)
BUTYL CELLOSOLVE
SODIUM HYDROXIDE
DENATURED ALCOHOL
SODIUM METASILICATE
111-72-6
1310-73-2
64-17-5
6834-92-0
SECTION 2- PHYSICAL/CHEMICAL CHARACTERISTICS
Boiling Point Range: 93 0 C.
Specific Gravity (H2O = 1): 1.07 -1.08
Vapor Pressure: PSIG @ 70 0 F. (Aerosols): N/D
Vapor Pressure(Non-Aerosols)(mmHg & Temperature): N/D
Vapor Density (Air = 1): >1
Evaporation Rate (Water = 1) 1
Solubility in Water: Total
Water Reactive: No
'Undo All Changes
Appearance and Odor: Clear red liquid, pleasant aroma
SECTION 3 - FIRE AND EXPLOSION HAZARD DATE
Flammability Limits in Air by % in Volume:
FLAMMABILITY as per USA FLAME PROJECTION TEST
Auto Ignition Temperature
% LEL: N/D
% UEL: N/D
(aerosols) N/D
N/D
FLASH POINT AND METHOD USED(non-aerosols): 61 0 C.
EXTINGUISHER MEDIA: Alcohol Foam, Carbon Dioxide, Dry Chemical, Water
Fog
Unusual
Fire & Explosion Hazards: None known
SPECIAL FIRE FIGHTING PROCEDURES: Keep container cool with water; toxic
vapors may be released if this produce is involved in a fire.
SECTION 4 - REACTIVITY HAZARD DATA
STABILITY :
[ X ] STABLE
[
] UNSTABLE
HAZARDOUS POLYMERIZATION: WILL NOT OCCUR
Incompatibility (Mat. to avoid): Acids and strong oxidizing agents.
Conditions to Avoid: None known.
Hazardous Decomposition Products: None identified
SECTION 5 - HEALTH HAZARD DATE
PRIMARY ROUTES OF ENTRY: [ ] INHALATION [ X ]INGESTION [ X ]SKIN ABSORPTION [ X ]EYE [
] NOT HAZARDOUS
ACUTE EFFECTS:
Inhalation: Inhalation of spray or mist is highly irritating to respiratory tract and mucous membranes. Prolonged contact may result in tissue damage.
Eye Contact: Extremely irritating. Can cause conjunctiva burning
Skin Contact: Irritant
Ingestion: Can cause severe gastrointestinal irritation.
CHRONIC EFFECTS: Skin burns can occur with alkaline fluids.
Medical Conditions Generally Aggravated by exposure: None Identified
EMERGENCY FIRST AID PROCEDURES
Eye Contact: Flush with water for 15 minutes. If irritation persists, get medical attention.
Skin Contact: Wash with soap & water, neutralize with vinegar, and rinse with water. If irritation persists, get medical attention.
Inhalation: Remove individual to fresh air. If breathing is difficult, administer oxygen, If not breathing, give artificial respiration..
Ingestion: Induce vomiting as directed by medical personnel. Drink 3 to 4 glasses of water. Get immediate medical attention.
SECTION 6 - CONTROL AND PROTECTIVE MEASURES
Respiration Protection: None usually required if used without creating spray mist or vapors.
Protective Gloves: Rubber or plastic
Eye Protection: Eye shield or splash goggles.
Ventilation Requirements: Local exhaust is adequate
Other Protective Clothing & Equipment: Apron and boots, if desired.
Hygienic Work Practices: Do not eat, drink or smoke in work area. Wash hands after handling.
SECTION 7 - PRECAUTIONS FOR SAFE HANDLING AND USE
Steps To Be Taken If Material Is Spilled Or Released: Contain spill and neutralize with a mild acid such as vinegar. Absorb on inert substance for
Waste Disposal Methods: Dispose of in accordance with all local, state and federal regulations.
disposal.
Precautions To Be Taken In Handling & Storage: Store in original containers. Keep closed when not is use.
Other Precautions &/or Special Hazards: KEEP OUT OF REACH OF CHILDREN. Read & follow label directions.
We believe the statements, technical information and recommendations contained herein are reliable, but they are given without warranty or guarantee.
** Chemical Listed as Carcinogen or Potential Carcinogen. [a] NTP [b] ARC Monograph [c] OSHA [d] Not Listed [e] Animal Data Only