Page: 1/6
Material Safety Data Sheet (MSDS)
according to Section 31 1907/2006/EC
Printed on: 27.08.2013
Version number 5
revised on: 26.08.2013
1 Identification of the substance or mixture and the company
• Product ID
• Trade name: Universal cleaner solution used at 1:10
• Relevant identified uses of the substance or mixture and uses that are not advised
No further relevant information available.
• Use of the substance / compound: Cleaner
• Details of the supplier providing the material safety data sheet
• Manufacturer / supplier:
HSK Kotlewski Wiehenstrasse. 21 32289 Rödinghausen, Germany Tel./Fax.:
05746/911171
• Further information can be obtained from: Product Safety department
• Emergency telephone number:
Poisons Information Centre North of the states of Bremen, Hamburg, Lower Saxony and Schleswig-Holstein (GIZ
Nord),
Georg August University of Goettingen, Centre for Pharmacology and Toxicology,
Robert Koch Straße 40,
37075 Göttingen, Germany Tel.: 0551/192 40 Fax: 0551/383 1881 Email: giznord@giz-nord.de Emergency
telephone number: +49(0)551/19240
2 Potential hazards
• Classification of the substance or mixture ■ Classification according to Regulation (EC) no. 1272/2008
Eye irritant 2 H319 Causes severe eye irritation.
• Classification according to Directive 67/548/EEC or Directive 1999/45/EC not applicable.
• Special information on hazards to humans and the environment:
The product is not subject to classification based on the calculation procedure of the "General Classification
Guideline for Compounds of the EU" in the latest valid version.
• Classification system:
The classification is in line with current EC lists, but it is supplemented by information from specialised literature
and company information.
• Labelling elements
• Labelling according to EU guidelines:
Precautions that usually apply to handling of chemicals shall be observed.
The product is not subject to classification under EC Directives / GefStoffV - Ordinance on Hazardous Materials.
• Special labelling of certain preparations:
Material safety data sheet available for professional users on request.
• Other hazards
• Results of PBT and vPvB assessment
• PBT: Not applicable.
• vPvB: Not applicable.
DE
(Continued on page 2)
Page: 2/6
Material Safety Data Sheet (MSDS)
according to Section 31 1907/2006/EC
Printed on: 27.08.2013
Version number 5
revised on: 26.08.2013
Trade name: Universal cleaner solution used at 1:10
(Continued on page 1)
3 Composition / information on constituents
• Chemical characterisation: Mixtures
• Description: Mixture of substances listed below with non-hazardous additives.
Hazardous constituents:
Decan-1-ol, ethoxylated (8 EO)
■ \ nR22; |A/M
<$> Eye Dam. 1, H318; <|> Acute Tox. 4, H302
• Additional information: For the wording of the listed risk phrases, refer to section 16.
•
< 2.5%
4 First aid measures
• Description of first aid measures
• General information: No special measures required.
• After inhalation: Provide fresh air, seek medical advice in case of complaints.
• After skin contact: In general, the product does not irritate the skin.
• After eye contact: Flush eyes for several minutes under running water with eyelids open.
• After swallowing: Consult a doctor if symptoms persist.
• Note to physician:
• Both acute and delayed symptoms and effects
No further relevant information available.
• Information on immediate medical attention and special treatment
No further relevant information available.
5 Fire-fighting measures
• Fire-extinguishing media
• Suitable fire-extinguishing media: Apply fire-fighting measures that suit the environment.
• Special hazards arising from the substance or mixture No further relevant information available.
• Advice for fire fighting
• Special protective equipment: No special measures required.
6 Accidental release measures
• Personal precautions, protective equipment and emergency procedures
Not mandatory.
• Environmental precautions:
Dilute with plenty of water.
Do not discharge into the drains / surface waters or allow percolation into the groundwater.
• Methods and material for containment and cleaning up:
Absorb with liquid-binding material (sand, diatomite, acid binders, universal binders, sawdust).
• Reference to other sections
For information on safe handling, refer to section 7.
For information on personal protection equipment, refer to section 8.
For disposal information, refer to section 13.
7 Handling and storage
• Handling:
• Precautions for safe handling no special measures required.
• Precautions against fire and explosion: No special measures required.
(Continued on page 3) (Continued on page 2)
Conditions for safe storage, including any incompatibilities
• Storage:
■
DE
Page: 3/6
Material Safety Data Sheet (MSDS)
according to Section 31 1907/2006/EC
Printed on: 27.08.2013
Version number 5
revised on: 26.08.2013
Trade name: Universal cleaner solution used at 1:10
•
•
•
•
•
•
Requirements to be met by storerooms and containers: No special requirements.
Information on joint storage: Not mandatory.
Further information about storage conditions: None.
Storage class: 10
Classification under BetrSichV (Ordinance on Industrial Safety and Health): Specific end use: no further relevant information available.
8 Limitation and monitoring of exposure / personal protection equipment
• Additional information about design of technical facilities: No further data; see section 7.
• Control parameters
• Components with workplace-related limits to be monitored:
The product does not contain any relevant quantities of materials with workplace-related exposure limits to be
monitored.
• Additional information: The lists valid during the drafting process were used as basis.
• Limitation and monitoring of exposure
• Personal protective equipment:
• General safety and hygiene measures:
The usual precautionary measures for handling chemicals should be followed.
• Respiratory protection: Not mandatory.
• Protection of hands: Not mandatory.
• Material of gloves
The selection of suitable gloves does not only depend on the material, but also on other quality characteristics
and varies from manufacturer to manufacturer. As the product is a compound made of several substances, the
resistance of the glove material cannot be calculated in advance and therefore, has to be checked prior to the
application.
• Penetration time of glove material
The exact penetration time has to be obtained from the safety glove manufacturer and must be observed.
9 Physical and chemical properties
• Information on basic physical and chemical properties
•General Information
•Appearance:
Form:
Fluid
Colour:
According to product specification
• Odour:
Characteristic
• Odour threshold:
Not determined.
• pH:
• Change in state
Melting point / range:
Boiling point / range:
Not determined.
• Flash point:
• Flammability (solid, gaseous):
> 100 °C
Not applicable.
• Ignition temperature:
• Decomposition temperature:
200 °C
Not determined.
• Self-ignitability:
Product is not self-ignitable.
Not determined.
100 °C
(Continued on page 4)
DE
Page: 4/6
Material Safety Data Sheet (MSDS)
according to Section 31 1907/2006/EC
Printed on: 27.08.2013
Version number 5
revised on: 26.08.2013
Trade name: Universal cleaner solution used at 1:10
(Continued on page 3)
• Danger of explosion:
■
Explosion limits:
Lower:
Upper:
Product is not explosive.
Not determined.
Not determined.
• Steam pressure at 20 °C:
• Density:
• Relative density
• Vapour density
• Evaporation rate
23 hPa
Not determined.
Not determined.
Not determined.
Not determined.
• Solubility in / miscibility with
Water:
Fully miscible.
■ Partition coefficient (n-octanol/water): Not determined.
■Viscosity:
Dynamic:
Not determined.
Kinematic:
Not determined.
■Solvent content:
Organic solvent:
Water:
VOC (EU)
0.0 %
97.8 %
0.00 %
Solid content old:
• Other information
0.3 %
No further relevant information available.
10 Stability and reactivity
• Reactivity
• Chemical stability
• Thermal decomposition / conditions to be avoided:
No decomposition if used according to specifications.
• Possibility of hazardous reactions No dangerous reactions known.
• Conditions to be avoided No further relevant information.
• Incompatible materials: No further relevant information available.
• Hazardous decomposition products: No dangerous decomposition products.
11 Toxicological information
•
•
•
•
•
•
•
Information on toxicological effects
Acute toxicity:
Primary irritant effect:
On the skin: No irritant effect.
On the eye: No irritant effect.
Sensitisation: No sensitising effects known.
Additional toxicological information:
The product is not subject to classification based on the calculation procedure of the "General Classification
Guideline for Compounds of the EU" in the latest valid version.
Based on our experience and the information provided to us, the product does not have any adverse health effects
when used and handled according to specifications.
DE
(Continued on page 5)
Page: 5/6
Material Safety Data Sheet (MSDS)
according to Section 31 1907/2006/EC
Printed on: 27.08.2013
Version number 5
revised on: 26.08.2013
Trade name: Universal cleaner solution used at 1:10
(Continued on page 4)
12 Environment-related information
• Toxicity
• Aquatic toxicity: No further relevant information available.
• Persistence and degradability No further relevant information available.
• Behaviour in environmental systems:
• Bio-accumulative potential No further relevant information available.
• Mobility in soil No further relevant information available.
• Additional ecological information:
• General information: Water hazard class 1 (self-assessment): slightly hazardous for water
• Results of PBT and vPvB assessment
• PBT: Not applicable.
• vPvB: Not applicable.
• Other adverse effects No further relevant information available.
13 Disposal instructions
• Waste treatment methods
• Recommendation: Smaller quantities can be disposed of with household waste.
• Contaminated packaging:
• Recommendation: Disposal according to official regulations.
• Recommended cleaning agent: Water together with cleansing agents, if necessary.
14 Transport information
■
■
UN number
ADR, ADN, IMDG, IATA
Not applicable
■
■
Proper UN shipping name
ADR, ADN, IMDG, IATA
Not applicable
■ Transport hazard
■
■
ADR, ADN, IMDG, IATA
Class
■
■
■
■
Packing group
ADR, IMDG, IATA
Environmental hazards:
Marine pollutant:
Not applicable
Not applicable
No
■ Special precautions for user Not applicable.
• Transport in bulk according to Annex II of
MARPOL convention 73/78 and the IBC Code
• UN "Model Regulation ":
Not applicable.
-
15 Legal provisions
• Safety, health and environmental regulations / specific legal provisions for the substance or mixture
• National regulations:
• Classification under BetrSichV (Ordinance on Industrial Safety and Health): (Continued on page 5)
(Continued on page 6)
DE
Page: 6/6
Material Safety Data Sheet (MSDS)
according to Section 31 1907/2006/EC
Printed on: 27.08.2013
Version number 5
revised on: 26.08.2013
Trade name: Universal cleaner solution used at 1:10
Water hazard class: Class 2 (self-assessment): hazardous for water.
• Material safety assessment: A material safety assessment has not been carried out.
■
16 Other Information
This information is based on our present state of knowledge; it is provided without any warranty of product
features and shall not establish a legally valid contractual relationship.
• Relevant phrases
H302 Harmful if swallowed.
H318 Causes severe eye damage.
R22 Harmful if swallowed.
R41 Risk of serious damage to eyes.
• Department issuing the MSDS: Product Safety department
• Contact: Dr. Bruder
• Abbreviations and acronyms:
ADR: Accord européen sur le transport des marchandises Dangereuses par Route (European Agreement concerning the International
Carriage of Dangerous Goods by Road)
IMDG: International Maritime Code for Dangerous Goods IATA: International Air Transport Association
GHS: Globally Harmonized System of Classification and Labelling of Chemicals EINECS: European Inventory of Existing Commercial
Chemical Substances ELINCS: European List of Notified Chemical Substances CAS: Chemical Abstracts Service (division of the
American Chemical Society)
GefStoffV: Gefahrstoffverordnung (Ordinance on Hazardous Substances, Germany)
VOC: Volatile Organic Compounds (USA, EU)
DE