COLD GALVANIZING SPRAY
Material Safety Data Sheet
SECTION I - COMPANY IDENTIFICATION
PRODUCT: COLD GALVANIZING SPRAY
CAT. NO.:
CG16
DISTRIBUTED BY:
Virginia KMP Corporation
4100 Platinum Way
Dallas, Texas 75237
TELEPHONE NUMBERS:
Office:
1-(214) 330-7731
Emergency Only: 1-(800) 424-9300
SECTION II - HAZARDOUS INGREDIENTS
OSHA Hazardous Components (29 CFR 1910.1200)
EXPOSURE LIMITS: 8 HR. TWA
OSHA PEL
ACGIH TLV
Metallic Zinc (CAS# 7440-66-6)
*Toluene (CAS# 108-88-3)
Naphtha (CAS# 8030-30-6)
Isobutane (CAS# 75-28-5)
Propane (CAS# 74-98-6)
NE
200
NE
NE
1000
NE
100
400
NE
NE
* A chemical known to the State of California to cause birth defects or other reproductive harm.
SECTION III - HAZARDS IDENTIFICATIONS
EMERGENCY OVERVIEW: WARNING! Vapors can cause dizziness and nausea.
POTENTIAL HEALTH EFFECTS:
INHALATION:
Can cause dizziness, light headedness and nausea at high concentrations.
EYE CONTACT:
Can cause eye irritation.
SKIN CONTACT: May cause skin irritation on prolonged and repeated contact.
INGESTION:
May cause stomach irritation.
CHRONIC Effects: Prolonged exposure above OSHA permissible exposure limits may result in kidney and liver damage.
NOTE:
CARCINOGENICITY: LISTED IN NTP?
No
IARC?
No
OSHA Regulated?
No
SECTION IV - FIRST AID MEASURES
INHALATION:
EYE CONTACT:
SKIN CONTACT:
INGESTION:
Remove from exposure immediately. If breathing is stopped or irregular, begin artificial respiration and administer oxygen.
Flush with water for 15 minutes or until irritation subsides.
Wash with soap and water.
Do not induce vomiting. Drink lots of water, contact a physician.
SECTION V - FIRE FIGHTING MEASURES
FLASHPOINT (TEST METHOD):
FLAMMABLE LIMITS:
AUTOIGNITION TEMPERATURE:
-50 F TCC
LOWER: 1.2
NA
GENERAL HAZARD:
FIRE FIGHTING INSTRUCTIONS:
Self-contained breathing apparatus with full facepiece and protective clothing.
UPPER:
9.5
EXTINGUISHING MEDIA:
Carbon dioxide, dry chemical and foam.
HAZARDOUS COMBUSTION PRODUCTS:
Combustion products may yield carbon dioxide and/or carbon monoxide.
SECTION VI - ACCIDENTAL RELEASE MEASURES
LAND SPILL:
WATER SPILL:
Ventilate area. Remove all sources of ignition.
respirator and protective clothing.
Notify operators of nearby water intake.
Evacuate the hazard area of unprotected personnel.
Wear appropriate
SECTION VII - HANDLING AND STORAGE
HANDLING:
Handle containers with care. Do not puncture or incinerate. Empty containers may be disposed of through normal channels.
Full or partially filled containers are considered hazardous.
STORAGE:
Do not store in direct sunlight, near open flames or at temperatures exceeding 120 F. Do not smoke while spraying.
COLD GALVANIZING SPRAY
SECTION VIII - EXPOSURE CONTROLS/PERSONAL PROTECTION
ENGINEERING CONTROLS: Mechanical ventilation recommended.
PERSONAL PROTECTION: Use chemical resistant gloves, goggles with side shield.
SECTION IX - PHYSICAL AND CHEMICAL PROPERTIES
VAPOR PRESSURE @ 20 C: 47 psi
SPECIFIC GRAVITY (H2O=1): >2
SOLUBILITY IN WATER: Negligible
pH: NAP
BOILING POINT: NA
APPEARANCE & ODOR: Grey color, ethereal odor.
VAPOR DENSITY (Air=1): >1
EVAPORATION RATE (H2O=1): <1
VOC (LB/GAL): NA
FREEZING POINT: NA
SECTION X - STABILITY AND REACTIVITY
STABILITY:
Stable.
CONDITIONS TO AVOID:
Open flames, sparks, electrical sparks.
MATERIALS TO AVOID:
Strong oxidizing agents, strong acids or bases, water.
HAZARDOUS DECOMPOSITION PRODUCTS: Thermal decomposition may yield carbon monoxide and/or carbon dioxide.
HAZARDOUS POLYMERIZATION:
Will not occur.
SECTION XI - TOXICOLOGICAL INFORMATION
Metallic Zinc
300 mg / 3 day interval
TCLo:
124 mg/m3 / 50 m
LD50:
0.5 to 5 g/kg
Toluene (Grade 2)
(skin - human)
(inh - human)
(toxicity by ingestion)
SECTION XII - ECOLOGICAL INFORMATION
NA
SECTION XIII - DISPOSAL CONSIDERATIONS
Ventilate area. Remove all sources of ignition. Clean up with inert materials and dispose of in accordance with all local, state and federal
regulations.
SECTION XIV - TRANSPORTATION INFORMATION
PROPER SHIPPING NAME: Consumer Commodity, ORM-D
HAZARD CLASS:
IDENTIFICATION NUMBER:
DOT Emergency Guide #:
Reportable Quantity (RQ):
International:
9
UN 1950
12
Zinc - 1000 lbs., Toluene - 1000 lbs.
Aerosol Dispensers, 9, UN 1950, IMDG 9022
SECTION XV - REGULATORY INFORMATION
TSCA (Toxic Substance Control Act): Components of this product are listed on the TSCA Inventory.
CERCLA (Comprehensive Environmental Response, Compensation and Liability Act): Reportable quantities for zinc and toluene are 1000
pounds.
Contact local authorities for other reporting requirements.
SARA TITLE III (Superfund Amendments and Reauthorization Act):
Toluene - 17.8% by weight.
CALIFORNIA PROPOSITION 65:
WARNING: This product contains Toluene, a chemical known to the State of California to cause birth
defects or other reproductive harm.
SECTION XVI - OTHER INFORMATION
State Right-to-Know Programs:
NFPA Ratings
Health:
Flammability:
Reactivity:
HMIS Protective Equipment:
2
4
1
X
See your supervisor
Prepared by: Virginia KMP Corporation
revised 2/6/2016
This information is furnished without warranty, expressed or implied, except that it is accurate to the best knowledge of Virginia KMP. The data on
this sheet related only to specific material designated here in. Virginia KMP assumes no legal responsibility for use or reliance upon these data.