MATERIAL SAFETY DATA SHEET
PRODUCT NAME:
REVISION DATE:
Econo-Max
OCTOBER 1, 2010
For Chemical Emergency (Spill, Leak, Fire, Exposure or Accident)
CALL CHEMTREC Day or Night 800-424-9300
For International, Call 703-527-3887 (Collect Calls Accepted)
** FOR INDUSTRIAL USE ONLY **
Section I - Product Information and Company Identification
Product:
Econo-Max
General Description: Clay Control Agent
Chemical Family: Blend
Primary Hazard: May Cause Irritation
DOT: Not Regulated
Section II – Composition, Information on Ingredients
CAS #
Mixture
Chemical Name
Proprietary
Percent
Hazardous
100
No
Section III – Hazards Identification
Hazard Overview: Colorless to light amber solution; slight amine (fish-like) odor; poses
little or no immediate hazards.
Section IV – First Aid Measures
Eyes: Flush with clean, low pressure water for at least 15 minutes while occasionally
lifting eyelids. If irritation occurs and persists, get medical attention.
Inhalation: No adverse effects anticipated by breathing small amounts during proper
industrial handling. If there is difficulty breathing, remove to fresh air and get medical
attention.
Skin: Wash with water, use soap if available. If extensive skin contact occurs, remove
contaminated clothing and wash contacted skin with soap and water. In the unlikely event
that irritation does occur/persist after contact, check with medical personnel. Wash
contaminated clothing before reuse.
Ingestion: See medical attention
Economy
Polymers & Chemicals
P.O. Box 450246
Houston, TX 77245-0246
USA Toll free: (800) 231-2066
Phone: (713) 723-8416
Fax: (713) 723-1845
URL: www.EconomyPolymers.com
E-mail: economy@economypolymers.com
Section V - Fire & Explosion Hazard Data
Flammable Properties: Flash point - >200F; Method: Closed Cup
Flammable Limits: Lower Flammable Limit (LFL) - not applicable
Upper Flammable Limit (UFL) - not applicable
Auto Ignition Temperature: Not available
Hazardous Combustion Products: No specific hazards. Combustion will produce
compounds of carbon, hydrogen, nitrogen and chlorine including carbon monoxide and
hydrogen chloride. The exact composition of the products of combustion will depend on
the conditions of combustion. This product will not support combustion until all water is
boiled off.
Other Fire and Explosion Hazards: None
Extinguishing Media: Water, foam, CO2, dry chemical
Fire Fighting Equipment. Full protective equipment (Bunker Gear) and NIOSH/MSHA
approved SCBA should be used for all indoor and any significant outdoor fires. For small
outdoor fires which may easily be extinguished with a portable dire extinguisher, use of a
SCBA may not be required.
Fire Fighting Instructions: Water run off can cause environmental damage. Dike and
collect water used to fight fires.
Section VI – Accidental Release Measures
Use absorbent, vacuum or sweep material and place in a disposal container.
Section VII – Handling and Storage
Shelf Life: Use within 1 year.
Special Sensitivity: None
Section VIII - Personal Protection Information
Engineering Controls: Provide ventilation and particulate control to maintain airborne
levels below the exposure guidelines.
Eye Protection: Use safety glasses. If there is a potential for exposure to particulates
which would cause mechanical injury to the eye, wear chemical goggles.
Respiratory Protection: For most conditions no respiratory protection should be needed;
however, in confined or poorly ventilated areas of emergency and other conditions where
the exposure guidelines may be greatly exceeded, use an approved positive pressure selfcontained breathing apparatus.
Skin Protection: As a general precaution use gloves. No additional precautions other
than clean body covering clothing should be needed.
Economy
Polymers & Chemicals
P.O. Box 450246
Houston, TX 77245-0246
USA Toll free: (800) 231-2066
Phone: (713) 723-8416
Fax: (713) 723-1845
URL: www.EconomyPolymers.com
E-mail: economy@economypolymers.com
Section IX - Physical Data
Flash Point:
>200 F
Pour Point:
Initial Boiling Point: Not Determined
pH range (neat):
Color:
Clear Liquid
Odor:
Vapor Density:
Not Determined
Specific Gravity:
Density:
1.08 KG/L
Viscosity:
Vapor Pressure:
Not Determined
Evaporation Rate:
o
<-60oC
6.5-9.5
Mild
1.08
~25cst @ 40oC
Not Determined
Section X - Reactivity Data
Stability: Stable Hazardous Polymerization: Will not occur
Conditions to avoid: None
Incompatibility (Materials to Avoid): Strong oxidizers (eg. Chlorine, peroxides,
chromates, nitric acid, perchlorates, concentrated oxygen, permanganates)
Hazardous Decomposition Products: Fumes produced when heated to
decomposition may include: CO, CO2, NOx
NFPA RATINGS: HEALTH 1, FLAMMABILITY 0, REACTIVITY 0
HIMS RATINGS: FLAMMABILITY 0, REACTIVITY 0, HEALTH 1
Section XI – Toxicological Information
LD50 - 3400 mg/kg oral (rat)
Section XII – Ecological Information
No information available.
Section XIII – Disposal Considerations
Disposal: Disposal: If this product becomes a waste, it does not meet the criteria of a
hazardous waste as defined under the RCRA 40 CFR 261. Dispose in accordance with all
local, state, & federal regulations.
Section XIV – Transport Information
DOT: Not Regulated
Section XV – Regulatory Information
The following regulations apply to this product:
Federal Regulations:
OSHA’s Hazard Communication Rule, 219 CFR 1910.1200: None
Economy
Polymers & Chemicals
P.O. Box 450246
Houston, TX 77245-0246
USA Toll free: (800) 231-2066
Phone: (713) 723-8416
Fax: (713) 723-1845
URL: www.EconomyPolymers.com
E-mail: economy@economypolymers.com
SARA/Superfund Amendments and Reauthorization Act of 1986 Title (III) –
Sections 302, 311, 312 and 313: Section 311 and 312-MSDS Requirements (40 CFR
370) – Not Hazardous
Toxic Substance Control Act (TSCA) (40 CFR 710): The chemical ingredients in this
product are on the 8(b) inventory list.
Section XVI – Miscellaneous
Disclaimer: **This information is furnished without warranty, expressed or implied, as to accuracy for
completeness. This information is obtained from various sources including the manufacturer and other
third party sources. The information may not be valid under all conditions nor if this material is used in
combination with other materials or in any process. Final determination of suitability of any material is the
sole responsibility of the user
Economy
Polymers & Chemicals
P.O. Box 450246
Houston, TX 77245-0246
USA Toll free: (800) 231-2066
Phone: (713) 723-8416
Fax: (713) 723-1845
URL: www.EconomyPolymers.com
E-mail: economy@economypolymers.com