WARRIOR CHECKLIST • Fuel CABIN CHECK • Ignition Key • Documents (AROW) • Hobbs Meter • Control Lock • Pitot & Static Drains • Flaps • Electrical & Avionics • Master Switch • Fuel Gauges • Annunciator Panel • Exterior Lights • Master Switch • Parking Brake EXTERIOR INSPECTION • Right Flap & Alieron • Fuel Quantity (Right Side) • Wing Tie Down • Fuel Sump • Fuel Vent • Main Wheel Tire/Brakes • Chocks • Engine Oil Level • Right Cowling • Propeller & Spinner • Alternator Belt • Landing Light • Carburetor Air Filter • Nose Wheel Strut & Tire • Nose Chocks • Left Cowling • Fuel Quantity (Left Tank) • Fuel Strainer • Wing Tie Down • Fuel Sump • Main Wheel Tire/Brakes • Chocks • Pitot/Static Head • Fuel Tank Vent • Stall Warning Horn • Left Flap & Aileron • Fuselage Left Side • Elevator/Rudder • Tail Tie Down • Fuselage Right Side • Overall Conditon CHECK (122.85) ON GLARESHIELD CHECK CHECK TIME REMOVE DRAIN CHECK OFF ON CHECK CHECK CHECK OFF ON CHECK CHECK VISUALLY REMOVE SAMPLE CLEAR CHECK REMOVE CHECK (Min. 5 Qts) SECURE CHECK CHECK CHECK CONDITION CHECK CHECK REMOVE SECURE CHECK VISUALLY SAMPLE REMOVE SAMPLE CHECK REMOVE CHECK CLEAR CHECK CHECK CHECK CHECK REMOVE CHECK REVIEWBEFORE WARRIOR CHECKLIST BEFORE ENGINE START • Flaps • Seatbelts/Shoulder Harness • Brakes • Fuel Selector • Circuit Breakers • Avionics Switch • Battery/Alternator • Fuel Pump • Beacon • Carburetor Heat • Mixture • Throttle • Prime • Propeller Area RETRACT FASTENED TEST & SET LOWEST TANK CHECK OFF ON ON ON COLD RICH OPEN 1/2 INCH AS REQUIRED CLEAR ENGINE START • Ignition Switch • Oil Pressure • Throttle • Mixture • Fuel Pump • Avionics/Radios START CHECK 1000 RPM LEANED OFF (Check Pressure) ON TAXI • Brakes • Magnetic Compass • Flight Instruments CHECK MOVEMENT FREE CHECK BEFORE TAKEOFF • Parking Brakes • Flight Controls • Flight Instruments • Fuel Selector • Elevator & Rudder Trim • Mixture • Throttle • Annunciator Panel • Suction • Ammeter • Engine Instruments. • Carburetor Heat • Magnetos • Throttle • Radios Final Items • Brakes • Door/Windows • Flaps • Mixture • Fuel Pump SET FREE & CORRECT SET FULLEST TANK SET RICH 2000 RPM CHECK CHECK CHECK CHECK CHECK (SLIGHT DROP) CHECK (125/50) 1000 RPM SET RELEASE CLOSED AS REQUIRED RICH (BELOW 3000 FT) ON WARRIOR CHECKLIST TAKEOFF • “LIGHTS” (ALL) • “CAMERA” (Transponder) • “ACTION” (RPM, Oil Pres., Time) • Climb Speed ON ON CHECK 70-80 KTS BEFORE LANDING • • • • • • • • • Seatbelts Fuel Selector Fuel Pump Engine Gauges Heading Indicator Altimeter Setting Auto Pilot Radios Approach Speed Final Items • Mixture • Flaps AFTER LANDING CHECK • “LIGHTS” (Except Beacon) • “CAMERA” (Transponder) • “ACTION” Carb Heat Mixture Flaps Fuel Pump ENGINE SHUTDOWN • Throttle • Mags • Throttle • Avionics/Electrical Equip. • Mixture • Master/Alternator Switch • Ignition Switch • Ignition Key ADJUST FULLEST TANK ON CHECK ALIGNED CHECK OFF SET 70 KTS RICH DOWN OFF OFF OFF LEANED RETRACT OFF IDLE GROUND CHK. 1000 RPM OFF CUTOFF OFF OFF GLARESHIELD SECURING AIRCRAFT • • • • Hobbs & Tach Control Lock Tiedowns/Chocks Propeller (For Fuel) RECORD INSTALL INSTALL VERTICAL • • • • • • • • • • • • • • • • ON ON SWICH TANKS RICH BOTH IN & LOCKED 73 KTS 63 KTS CUTOFF OFF OFF AS REQUIRED OFF TIGHT UNLATCH SLIGHTLY TAIL LOW APPLY HEAVILY ALTERNATOR FAILURE Alternator Annunciator Light On Ammeter CHECK Alternator OFF Alternator Circuit Breaker CHECK-RESET Avionics Power Switch OFF Non Essential Equipment OFF Alternator ON IF LOW VOLTAGE LIGHT ON AGAIN Airspeed Mixture Fuel Selector Ignition Switch Wing Flaps Master Switch Seatbelts Door Touchdown Brakes EMERGENCY LANDING WITHOUT POWER • Airspeed FLY THE AIRPLANE • Carburetor Heat • Fuel Pump • Fuel Selector Valve • Mixture • Ignition Switch • Primer ENGINE FAILURE DURING FLIGHT CUTOFF OFF OFF OFF BLOW OUT FIRE EXECUTE Frequency Volume/Squelch Speaker/Phones Switch Headset Jacks O/H Speaker-Handmike Circuit Breakers Other Radio VOR Frequency Squawk Tower Lights Signals 19711 Campus Dr., #150 Santa Ana, CA 92707 (949) 756-1300 • Fax (949) 756-0727 www.ocflightcenter.com OCFC Warrior CHECK CHECK CHECK SELECTION RESET TRY BOTH CHECK IF AVAILABLE MONITOR 7600 OBSERVE COMMUNICATION LOSS Master Switch OFF Avionics OFF All Other Switches OFF Vents OPEN Cabin Heat OFF LAND AS SOON AS PRACTICAL ELECTRICAL FIRE IN FLIGHT Mixture Fuel Selector Master Switch Cabin Heat & Air Increase Airspeed Forced Landing Orange County FLIGHT CENTER • • • • • • • • • • • • • • • • • • • • • • ENGINE FIRE IN FLIGHT ENGINE FAILURE IMMEDIATELY AFTER TAKEOFF • Fuel Selector SWITCH TANKS • Fuel Pump CHECK ON • Airspeed 65 KTS IF ENGINE FAILS TO RESTART • Mixture CUTOFF • Fuel Shut Off Valve OFF • Ignition Switch OFF • Master Switch OFF • Engine Failure After Takeoff 63 KTS • Maneuvering Speed: 2325 LBS/111 KTS • 1531 Lbs/88 • Maximum Glide 73 KTS • Landing Without Engine Power: Flaps Up 73KTS Flaps Down 63 KTS FIRE DURING START OR GROUND • Cranking CONTINUE FOR START If Engine Fails To Start • Throttle FULL OPEN • Mixture CUTOFF • Fuel Pump OFF • Ignition Switch OFF • Master Switch OFF • Fuel Selector Valve OFF AIRSPEEDS FOR EMERGENCY OPERATIONS E M E R G E N C Y PROCEDURES