Uploaded by Norbert Mikeles

electrodiag us

advertisement
Notes
ELECTRODIAGNOSTIC
Contents
- List of families in the wiring diagrams
- List of electrical components
- List of indicator lights/connectors/specific cases
- Technical abbreviations and interpretation/Identification of wires
- Identification of connectors
- Numbering of wires
- Multiplexing and intersystem
- List of cable functions
- Wiring diagrams explanation
- Principles of multiplexing/Multiplexing application
- Multiplex system precautions
- Initialising engine management computers
- Maintenance indicators initialisation procedure
- Location of electrical parts (main) for all models
- Boxer transponder system/Engine systems interface/CV00
- Special notes on 206 CC & 307 CC
- Coolant temperature sensor function
- Radios: Abbreviation/Decoding/Identification/Removal
- Transponder immobiliser/Locking/Key programming/Windows
- Airbag/Pyrotechnic seat belts/Centralised airbag system/ Sunroof 307
- Diagnostic connectors/PPS/Branching wiring bundles
- Refrigeration capacities/Features of lubricants
- Diesel and petrol engine identification list/Oil capacity
- Abbreviation of depollution standards
- Vehicle identification
- Manufacturing location identification
2
3 - 21
21 - 24
24 - 25
26
27 - 29
30
32 - 54
55 - 59
60 - 77
75
76 - 78
79
80 - 156
157 - 159
160 - 165
166
167 - 175
176 - 190
191 - 197
198 - 208
209 - 217
218 - 229
226
228 -242
243
List of families in the wiring diagrams
4310
Family 5 - Washers, wipers
50. Windscreen wipers
51. Windscreen washer
52. Rear screen wiper
53. Rear screen washer
54. Headlight wipers, Headlight washers
Family number
Function number
Family 1 - Engine and transmission assembly
10. Starting, current generation
11. Ignition, preheating
12. Carburettor supply, injection
13. Carburettor supply, injection
14. Engine fault finding
15. Cooling
16. Gearbox, transmission
17. Electrical motor supply, batteries
18. Gas circuit
19. Alternating current starter
Family 6 - Various assistance mechanisms
60. Front electric windows
61. Rear electric windows
62. Central locking
63. Electrically controlled seat
64. with 6449 electric door mirror
6450 to 6469 blind spot detection
6470 to 6499 steering column
65. Passive safety seat belts
66. Headlight attitude corrector
67. Gearbox and
transmission information
68. Sunroof, quarter panels
Family 2 - Signalling, exterior lighting.
20. Rear fog lights
21. Brake lights
22. Reversing lights
23. Indicators, side repeaters
side lights, hazard lights
24. Daytime running lights, dimmed lights
25. Horns
26. Headlights, Rear lights,
number plate lights, side lights
Family 7 - Driving assistance
70. Braking
71. Variable power-assisted steering
72. Multifunction display, trip
computer, clock
73. Cruise control
74. Black ice warning
75. Front and side proximity detection
76. Under-inflation detection (DSG)
77. Suspension (CSS)
78. Electronic stability program (ESP)
Family 3 - interior lighting
30. passenger compartment lighting
31. closed compartment lighting
Family 4 - Driver information
40. Engine coolant and miscellaneous
coolant information,
current generation
41. Engine oil information
42. Engine air and engine speed information
43. Fuel and preheating information
44. Brake information
45. Suspension information
46. Gearbox and
transmission information
47. Audible warning information
48. Engine management information
49. Opening elements information
Family 8 - Driving comfort
80. Climate control, air conditioning
81. heating equipment: rear screen and windscreen, windows, rear view mirror, cigarette lighter
82. Coded immobiliser with transponder
83. Heated seats
84. Radio, aerial, radiotelephone
85. Navigation, road information
86. Forced entry alarm
87. Electrically controlled blind
88. Towing
89. Storage compartments (glove box, armrests, etc.)
Family 9 - Multiplexing
90. Multiplex network computers
Numbering of devices
0002
0004
0005
1000
1001
1002
1003
1005
1006
1007
1010
1015
1020
1021
1022
1025
1026
1028
1029
1030
1031
1032
1033
1034
1040
1041
1042
1043
1044
1045
1050
1086
1087
1088
1089
1100
1101
1102
1103
1104
1105
1106
1107
1108
1109
1110
1111
1115
1116
1117
1118
1119
1120
1121
1122
1125
1127
1130
1131
1132
1133
1134
1135
1136
1137
1138
1140
1141
1142
1143
1145
1146
1147
1148
1149
1150
1151
1155
1156
1157
1158
1159
1160
1161
1162
1163
1164
1190
1191
1192
1200
1201
1202
1203
1204
1205
1206
1207
1208
1209
1210
1211
1212
1213
Signalling lighting switch
Controls
Wiper switch
Starting safety switch
Cold starting relay
Cold starting pump
Cold starting solenoid valve
Starting prevention relay
Engine blocking actuator
Body tilt sensor
Starter
Stop and start check computer
Alternator
Reversible alternator
Alternator filtering condenser
Dual battery unit
Energy accumulator
Electrical networks supply protective unit.
Network isolation unit
Engine running information relay
Battery charge status unit
Battery cable protection unit
Fuse box from battery
Front fuses information display
General power supply maintenance relay
Emergency stop switch
General relay
Reset switch
Diode unit
Auxiliary reset switch
Starting heating resist. solenoid valve ctrl
Antitheft alarm starting cut-off relay
Starting solenoid valve relay
Trailer cooling supply relay
12V socket supply relay
Distributor
Advance module engine coolant thermistor
Advance module
Advance correction solenoid valve resistance
Advance correction solenoid valve
Ignition module
Valve lift motor (VVT)
Variable valve position sensor
Valve control computer
Cylinder deactivation SV
Ignition distributor
Valve lift motor relay (VVT)
Cylinder reference sensor
Cylinder reference sensor 1
Cylinder reference sensor 2
Inlet cylinder reference sensor
Exhaust cylinder reference sensor
Pinking sensor
Pinking sensor 1
Pinking sensor 2
Accelerator pedal switch
Ignition supply relay
Ignition computer
Cylinder 1 ignition coil
Cylinder 2 ignition coil
Cylinder 3 ignition coil
Cylinder 4 ignition coil
Ignition coil
Ignition coil condenser
Cylinder 5 ignition coil
Cylinder 6 ignition coil
Antipol. module for the carburettor
Coolant reheating plug 1 supply relay
Coolant reheating plug 2 supply relay
Coolant reheating plug 3 supply relay
Throttle opening SV
Coolant reheating spark plugs 1-2 supply relay
Coolant reheating spark plugs 3-4 supply relay
Engine coolant reheating relay 1
Engine coolant reheating relay 2
Preheating unit
Heated fuel filter relay
Preheating relay
Postheating relay
Postheating thermal switch
Pre/postheating control unit
Heater plugs supply link
Heater plugs
Cylinder 1 heater plugs
Cylinder 2 heater plugs
Cylinder 3 heater plugs
Cylinder 4 heater plugs
Coolant circuit reheater
Ignition coil + cylinder reference
Eccentric shaft actuator
Fuel pump relay
Injection pump relay
Tachometric relay
Inertia switch
Impact safety relay
Fuel pump fuse
Transition pump control unit
Transition pump
Diesel injection pump
Low-pressure pump
Fuel pump
Fuel pump-sender unit
Fuel tank air SV
Air pump relay
1214
1215
1216
1217
1218
1219
1220
1221
1222
1223
1224
1225
1226
1227
1228
1229
1230
1231
1232
1233
1234
1235
1236
1237
1238
1239
1240
1241
1242
1243
1244
1245
1246
1247
1248
1249
1250
1251
1252
1253
1254
1255
1256
1257
1258
1259
1260
1261
1262
1263
1264
1265
1266
1267
1268
1269
1270
1271
1272
1273
1274
1275
1276
1277
1278
1279
1280
1281
1282
1283
1284
1285
1286
1287
1288
1289
1290
1291
1292
1293
1294
1295
1296
1297
1298
1299
13A0
13A1
13A2
13A3
13A4
13A5
1300
1301
1302
1303
1304
1305
1306
1307
1308
1309
1310
1311
1312
1313
1314
1315
Shift indicator light
Canister bleed SV
Resistance simulation canister
Canister bleed cut-off SV
Ignition advance cut-off SV
Automatic gearbox inject. throttle potent.
Engine coolant temperature sensor
Diesel fuel thermistor
Accelerometer
Injection air solenoid valve
Absorber closing solenoid valve
Idle speed regulation stepper motor (MMBA)
Idle regulation motor and idle switch
Fuel tank pressure sensor
Idle regul. motor/idle sensor + Hall effect sens.
Variable geometry turbo regulation SV
Additional air control
Automatic gearbox idle speed support unit
Idle speed maintenance SV
Turbocharging pressure regulation SV
Carburettor damper SV
Carburettor breather SV
Deceleration cut-off SV
Pulsair SV
Variable air duct inlet SV (AFP)
Idle speed regulation SV
Inlet air temperature sensor
Pulsair pump
Pulsair relay
Variable distribution SV 1
EGR proportional SV
Altitude switch
EGR function supply relay
EGR engine coolant thermal switch
EGR calibration resistor
Load lever potentiometer (EGR)
Exhaust gas recirc. calc. (EGR)
EGR vacuum pump
Diesel advance correct. relay
EGR all or nothing SV
Load lever switch (EGR)
Pump cut-off SV
Diesel advance SV
- Flow SV (Diesel)
+ Flow SV (Diesel)
+/- Flow SV (Diesel)
Injector needle lift sensor
Accelerator pedal position sensor
Motorised throttle
EGR SV + throttle
Swirl SV
Carburettor reheating thermal switch.
Carburettor reheating relay
Diesel throttle SV (air inlet)
Variable distribution SV 2
Fuel reheating resist. relay
Throttle valve reheating resistor
Damper SV
Damper assembly
Oil vapour rebreathing reheating resistor 1
Oil vapour rebreathing reheating resistor 2
Carburettor
Diesel heater
HP pump 3rd piston deactiv. SV
Discharge start sensor
Fuel high pressure regulation SV
Long variable air duct inlet (AFP) SV
Short variable air duct inlet (AFP) SV
Fuel additive computer
Fuel additive pump
Fuel additive injector
Air inlet heating SV
Diesel fuel heater relay
Diesel heating resistor
Diesel heating thermal switch
Inlet coolant heating SV
Injection potentiometer
Degassing coolant SV
Fuel filter relay
Coolant unit integr. proport. coolant SV
Vacuum pump
Turbine discharge SV
Variable air inlet SV
Electric EGR SV
Air vacuum proport. SV
Bypass throttle solenoid valve
Intake air heater metering
System air cooler meter feedback sensor
EGR bypass feedback sensor
Inlet air pressure and temp sensor
Engine management single relay 2
System air cooler bypass
Coolant emulsion sensor
Automatic gearbox signal relay (injection)
Injection supply relay
Ignition and injection supply relay.
Injection duplicate multifunction relay
Richness potentiometer
Automatic gearbox relay shunt
Power multif. double relay
Engine oil pressure sensor
Turbocharger air thermistor
Air flow sensor
Turbocharging overpressure sensor
Air intake pressure sensor
Engine speed sensor
Altitude sensor
Injection resistor
1316
1317
1318
1319
1320
1321
1322
1323
1324
1325
1326
1327
1328
1329
1330
1331
1332
1333
1334
1335
1336
1337
1338
1339
1340
1341
1342
1343
1344
1345
1346
1347
1348
1349
1350
1351
1352
1353
1354
1355
1356
1357
1358
1359
1360
1361
1362
1363
1364
1365
1366
1367
1368
1369
1370
1371
1372
1373
1374
1375
1376
1377
1378
1379
1380
1381
1382
1383
1384
1385
1386
1387
1388
1389
1390
1391
1392
1393
1394
1395
1396
1397
1398
1399
1400
1401
1405
1410
1411
1412
1413
1414
1500
1501
1502
1503
1504
1505
1506
1507
1508
1509
1510
1511
1512
1513
1514
1515
Throttle position sensor
Diesel pump lever position sensor
Throttle switches
Injection coding resistor
Engine management computer
Diesel high pressure sensor
Diesel high pressure regulator
Exhaust gas high temp. sensor
Proportional dosing SV
Fuel high pressure sensor
Injection computer supply fuse
Cam position sensor (Diesel pump)
Rotor position sensor (Diesel pump)
Slide position sensor (D pump)
Injector
Cylinder 1 injector
Cylinder 2 injector
Cylinder 3 injector
Cylinder 4 injector
Cylinder 5 injector
Cylinder 6 injector
Cylinder 7 injector
Cylinder 8 injector
Cylinder 9 injector
Cylinder 10 injector
Particle filter differential pressure sensor
Engine multifunction computer
Downstream exhaust gas high temp. sensor
Upstream exhaust gas high temp. sensor
Oxygen sensor heating relay
Air flow sensor A
Air flow sensor A
Oxygen sensor heating fuse
Material temperature sensor
Upstream oxygen sensor
Downstream oxygen sensor
Front downstream oxygen sensor
Front upstream oxygen sensor
Rear downstream oxygen sensor
Rear upstream oxygen sensor
Braking vacuum sensor
Proportional oxygen sensor
Cat. downstream exhaust gas high temp. sens. A
Cat. upstream exhaust gas high temp. sens. A
ADC1 gateway unit
Turbocharging air heating SV 1
Turbocharging air heating SV 2
Cat. downstream exhaust gas high temp. sens. B
Cat. upstream exhaust gas high temp. sens. B
Heating bracket relay
Heating bracket
Electric. controlled turbocharger. + local contr. A
Electric. controlled turbocharger. + local contr. B
Diesel volumetric regulator
Engine management single relay
Unlocked CCM multif. double function relay
Intake air heating position feedback sensor.
Turbocharging air heating pos. feedback sens.
Turbocharging position feedback sensor
Vertical linkage SV 1
Turbocharging pressure sensor
Electric EGR SV A
Electric EGR SV B
Vertical linkage SV 2
Controlled thermostat (S2RE)
Fuel injection supply cut-off relay
Dual mode exhaust SV
Particle filter upstream exhaust high temp. sens.
Pre-cat. downstream exhaust high temp. sens. A
Pre-cat. upstream exhaust high temp. sens. A
Pre-cat. downstream exhaust high temp. sens. B
Pre-cat. upstream exhaust high temp. sens. B
Oil vap. rebreathing heating res.
EGR motorised throttle valve
Inlet air pressure sensor 2
Air flow sensor 2
WG1 proportional SV
Turbocharger proportional SV 2
EGR bypass throttle SV
Air inlet temperature sensor 2
Gas recirculation SV 2
Compressor SV 2
Intake VANOS SV
Exhaust VANOS SV
TDC sensor
Brake amplifier pressure sensor
Neutral sensor
Exhaust temp. recovery SV
Exhaust temp. recovery pump
Exhaust temp. recovery temperature switch
RTE coolant temperature sensor
Engine speed sensor unit
Engine cooling fan relay (GMV)
Engine cooling fan fuse (GMV)
Left-hand engine cooling fan supply relay
Right-hand engine cooling fan supply relay
Right and left engine cooling fan supply relay
Fan trigger temp.switch.
GMV dual speed resist.
GMV control thermistor
Low speed GMV supply relay
High speed GMV supply relay
Engine cooling fan (GMV)
Right-hand engine cooling fan
Left-hand engine cooling fan
GMV electronic chopper
Medium speed engine cooling fan supply relay
Left interference suppression filter
1516
1517
1518
1519
1520
1521
1522
1523
1524
1525
1526
1527
1528
1529
1530
1531
1532
1533
1550
1551
1552
1555
1556
1600
1601
1602
1603
1606
1607
1610
1611
1612
1613
1615
1620
1621
1622
1623
1624
1625
1626
1627
1628
1629
1630
1631
1632
1633
1634
1635
1636
1637
1638
1639
Right interference suppression filter
Controlled flap for cooling fan
GMV three-speed resistor
GMV dual speed resistor
Engine post-cooling temp.switch
Variable speed GMV el. unit
Dual speed GMV control elec. unit
Variable speed GMV assembly 2
Power supply cut-off relay
Engine post-cooling relay
Engine post-cooling timer
Supply cut-off relay 2
Single speed GMV control elec. unit
GMV control electric unit
Post-cooling shunt
Turbo-alternator additional cooling fan
GMV speed switching relay
GMV speed switching add. relay
Turbocharger cooling water pump
Turbocharger cooling water pump fuse
Disconnectable coolant pump
Turbo cooling water pump ctrl relay
Oil pressure regulation solenoid
Selection lever position switch
One-touch ctrl lever sensor
One-touch ctrl switch
Automatic gearbox control assembly
Parking pos. buzzer supply relay
Grille + select. light supply relay
Exchanger flow control SV
Clutch pedal angle position sensor
Diagnostic neutral switch
Automatic gearbox engine speed sensor
Automatic gearbox pressure sensor
Vehicle speed sensor
Automatic gearbox vehicle speed sensor
Automatic gearbox output speed sensor
Hydraulic slave cylinder sensor
Gear change sensor
Vehicle speed interface module
Control lever
Clutch power module
Gear change power module
Selection power module
Automatic gearbox computer
Torque reduction SV
Pedal position switch
Selection sensor
Clutch sensor
Automatic gearbox electrohydraulic unit
Automatic gearbox position sensor
Automatic gearbox kickdown switch
Automatic gearbox lever blocking actuator
No load accel. pedal switch
1640
1642
1643
1644
1645
1646
1647
1650
1651
1655
1660
1661
1662
1663
1664
1665
1666
1667
1668
1669
1670
1671
1672
1700
1701
1702
1703
1704
1705
1706
1707
1708
1709
1710
1711
1712
1713
1714
1715
1716
1718
1722
1724
1725
1727
1728
1729
1730
1732
1733
1740
1746
1747
1748
Automatic gearbox program selector
Gear lever block. actuator ctrl relay
Key blocking actuator ctrl relay
Key blocking actuator
Automatic gearbox electronic control
Automatic gearbox solenoid block
Clutch SV
Controlled elec. gearbox computer
Automatic gearbox elec. control computer
Electrically controlled gearbox power relay
Controlled manual gearbox computer
Gear selector
Controlled manual gearbox inlet speed sensor
Change actuator
Selection actuator
Clutch actuator
Gear control on steering wheel
Gear selector lighting
Hydraulic throw-out bearing sensor
Controlled manual gearbox pump assembly
Controlled manual gearbox auto mode switch
Control. manual gearbox engag. pos. sensor
Control. manual gearbox selection pos. sensor
Electronic management computer
Lower front batt. volt./temp. module
Upper front batt. volt./temp. module
Rear batt. volt./temp. monitoring module
Relay unit
Electronic tool kit
Sector supply filter
Traction batt. management computer
Elec. converter electronics casing
Electric machine
Hybrid traction chain supervis. computer
Electric cooling pump (CTH)
Heater matrix coolant pump (CTH)
Accelerator potentiometer
Energy gauge
Elec. cooling pump relay (CTH)
Heater matrix coolant pump relay (CTH)
Electric motor cooling blower ctrl thermistor.
Battery coolant cooling fan ctrl thermistor.
Additional heater switch
Inverter electronic unit, elec. machine
Traction battery coolant pump
Computer coolant pump
Electric vehicle coded immobiliser relay
Coded immobiliser shunt
Battery heating relay
Battery heating resistance
Electric drive motor
Electric motor cooling blower
Charging socket
Battery charging socket unit
1749
1750
1800
1801
1802
1803
1804
1805
1806
1807
1808
1809
1810
1811
1812
1813
1814
1815
1816
1817
1818
1819
1820
1821
1822
1823
1824
1825
1826
1827
1828
1829
1830
1831
1832
1833
1834
1835
1836
1837
1839
1840
1841
1842
1843
1844
1845
1846
1847
1848
1849
1850
1851
1852
Heating cut-off self-energising relay
Fast recharging switch
Gas computer
Absolute pressure sensor
Metering SV (Solenoid valve)
Tank SV
Vaporiser SV
3 relay unit
Oxygen sensor relay
Diode bridge
Gas supply unit
Linear actuator
Gas/fuel switch
Gas/fuel timer relay
Gas supply fuse block
Diagnostic warning light cut-off relay
Gas pressure indicator
LPG/Fuel double relay
12V/5V voltage adaptor assembly
Gas gauge
Engine coolant thermistor (15°)
LPG tank sender pressure absorbing unit
Gas distribution motor
Gauge + LPG SV
12V/5V adaptor assembly diode
12V/5V conversion resistance
Air inlet flap SV
Gas supply SV
Fuel pump cut-off relay
Tank SV control relay
LPG distributor
LPG distributor pressure sensor
LPG expansion valve vap. temp. sensor
LPG switch relay
Cylinder 1 LPG injector
Cylinder 2 LPG injector
Cylinder 3 LPG injector
Cylinder 4 LPG injector
LPG general relay
Fuel booster relay
Expansion valve SV
Gas return SV relay
Gas injector relay
Gas return SV
Gas pump current sensor
Gas SV fuse holder
Gas injectors fuse holder
Gas computer supply fuse holder
Gas gen. relay supply fuse holder
Gas pressure/temp. sensor
Gas injector rail SV
Vaporiser SV control relay
Gas pressure management unit
Cylinder 1 gas injector
1853
1854
1855
1856
1857
1858
1859
1860
1861
1862
1863
1864
1865
1900
1901
1902
1903
1904
1905
1906
1907
1908
1909
1910
1911
1912
1913
1914
1915
2000
2001
2002
2003
2004
2005
2006
2007
2008
2010
2011
2015
2016
2100
2101
2110
2111
2112
2120
2200
2202
2210
2215
2300
2305
Cylinder 2 gas injector
Cylinder 3 gas injector
Cylinder 4 gas injector
Fuel injector management unit
Gas expansion valve vap.
Vaporiser gas pressure sensor
Vaporiser coolant temp. sensor.
Absolute low pressure sensor
Absolute high pressure sensor
Gas information display
Gas temperature sensor
Gas supply SV 2
Gas supply SV 3
Starter/alternator check computer
Starter/alternator engine management
Starter/alternator electric machine.
Heater matrix coolant pump
Electronic cooling coolant pump.
Coolant temperature electronic sensor
Clutch pedal switch
Gearbox neutral sensor
Coolant circuit heating plugs 1
Coolant circuit heating plugs 2
Coolant circuit heating plugs 3
Starter/alternator fuse power
Stop/start switch
High pressure battery fan
High pressure battery temp. sensor
Battery temperature sensor
Rear fog lights switch
Wiping/lighting controller
Driving school buzzer (Germany)
Driving school monitor unit (Germany)
Driving school jack socket (Germany)
Rear fog lights relay
Driving school switch (Germany)
Driving school footwell lighting (Germany)
Driving school interface unit
Rear left fog light
Central rear fog light
Rear right fog light
Rear fog lights control unit
Brake light switch
Redundant brake light switch
Additional brake light
Left additional brake light
Right additional brake light
Brake dual function switch
Reversing lights switch
Reversing ctrl switch
Left reversing light
Right reversing light
Hazard warning lights switch
Flasher sensor
2310
2320
2325
2330
2335
2340
2345
2400
2401
2402
2403
2404
2410
2411
2415
2500
2501
2505
2510
2520
2521
2522
2523
2524
2525
2530
2531
2532
2535
2600
2601
2602
2605
2606
2607
2610
2611
2612
2615
2616
2617
2620
2625
2630
2631
2632
2633
2634
2635
2636
2637
2638
2639
2640
2641
2642
2643
2644
2645
2646
2647
2648
2649
2650
2651
2655
2656
2657
2658
2659
2660
2662
2665
2670
2675
2676
2680
2685
2690
2695
3000
3001
3002
3003
3004
3005
3006
3007
3008
3009
3010
3011
3012
3013
3014
3015
3019
3020
3021
3022
3023
3024
3025
3028
3029
3030
3031
3032
Indicator switch
Front left direction indicator light
Front right direction indicator light
Rear left direction indicator light
Rear right direction indicator light
Left-hand side repeater light
Right-hand side repeater light
Daytime running lights side light line relay
Daytime running lights dipped headlights relay
Daytime running lights relay shunt
Rear side lights relay
Daytime running lights relay
Dipped headlights relay
Dim dip lights relay
Dim dip lights resistance
Horn switch
Horn steering wheel switch
Horn compressor relay
Horn compressor
Horn
Low-pitched horn
High-pitched horn
Pedestrian buzzer
Pedestrian horn
Horn compressor fuse
Siren unit (police)
Siren switch (police)
Day-night siren switch (police)
Siren loudspeaker (police)
Lighting coil turret
Front slope sensor
Rear slope sensor
Dipped headlights relay
Main beam headlights relay
Main beam headlights relay 2
Left-hand headlight
Left-hand turning headlight
Left-hand additional headlight
Right-hand headlight
Right-hand turning headlight
Additional right-hand headlight
FR LH side light
FR RH side light
RR LH light on body
RR RH light on boot lid
RR LH light on boot lid
Right-hand licence plate light
Jack socket shunt
RR RH light on body
Left-hand licence plate light
Jack plug socket for revolving flashing light
Revolving flashing light
Revolving flashing light switch
FR LH side clearance light
FR RH side marker
FR LH side marker
RR RH side marker
RR LH side marker
FR RH clearance light
RR LH light on upper body
RR RH light on upper body
Left central clearance light
Right central clearance light
RR LH clearance light
Roof-mounted police sign
RR RH clearance light
Rondo lights (Rear roof lights)
Central Rondo lights (Rear roof lights)
Rondo lights switch (Rear roof lights)
Orange lights switch
Fog lights switch
Front fog lights inhibition relay
Front fog lights relay
Left fog lights headlight
Right fog light headlight
Additional headlights shunt
Long range headlights switch
Long range headlights relay
Left long range headlights
Right long range headlights
FR LH door sill switch
FR RH door sill switch
FR LH door sill switch
FR RH door sill switch
Lighting timer unit
Courtesy light timer relay
Courtesy lights switch
Courtesy light relay
Interior lighting ctrl elec. unit.
Ambient lighting dimmer switch
Front interior lights
Front central interior light
FR LH courtesy light
FR RH courtesy light
Driver's side sill contactor
Roof console + integrated funct.
Rear courtesy light switch
Rear courtesy lights
Rear central courtesy lights
Left rear courtesy lights
Right rear courtesy lights
Left courtesy light
Right courtesy light
Boot lid courtesy light
Central courtesy light switch
Central courtesy light
FR RH reader
FR LH reader
3089
3090
3091
3092
3093
3094
3095
3100
3101
3102
3104
3105
3106
3107
3108
3109
3110
3115
3116
3117
3118
3119
3120
3121
3122
3123
3125
3126
4000
4001
4002
4005
4010
4012
4015
4020
4021
4025
4026
4030
4035
4040
4050
4060
4100
4101
4102
4103
4104
4105
4106
4110
4111
4120
3033
3034
3035
3036
3037
3038
3039
3040
3041
3042
3043
3044
3045
3046
3047
3048
3049
3050
3051
3052
3053
3054
3055
3056
3057
3058
3059
3060
3061
3062
3063
3064
3065
3066
3067
3068
3069
3070
3071
3072
3073
3074
3075
3076
3077
3078
3079
3080
3085
RR RH reader
RR LH reader
Footwell light
FR RH footwell light
FR LH footwell light
RR RH footwell light
RR RH footwell light
FR LH door sill plate light
Reading light on left-hand 2nd row seat
RR LH door sill plate light
RR LH int. door opening switch light
RR RH int. door opening switch light
FR RH door sill plate light
Reading light on right-hand 2nd row seat
RR RH door sill plate light
FR LH int. door opening switch light
FR RH int. door opening switch light
Lighting dimmer
Air conditioning light (heating ctrl)
Console light
Cigarette lighter light
Ashtray light
Radio cover control light
Ashtray cover control light
Left air vent light
Right air vent light
Central air vent light
Driver's courtesy mirror light
Passenger courtesy mirror light
Rear ashtray light
Roof light
Dashboard light
Card light
FR LH armrest light
FR RH armrest light
RR LH armrest light
RR RH armrest light
Gear selector light
Centre pillar light
Front left door light
Front right door light
Roof light 2
Anti-theft light
Driver dashboard light
Passenger dashboard light
Front left seat back table light
Front right seat back table light
Police visor light
Central ceiling switch and white
passenger light
3086 Central ceiling switch and blue
passenger light
3087 Parking lights switch
3088 Parking lights relay
Front roof console LED module
Row 3 rear left seat light timed relay
Row 3 rear right seat light timed relay
Row 3 rear left seat light switch
Row rear right seat light switch
Row 3 rear left footwell light
Row 3 rear right footwell light
Boot lid switch
Detachable boot light
Cooled central storage compartment light
Shutter light
Boot light (or rear shutter)
Rear boot left-hand light
Rear boot right-hand light
CD console light switch
Secondary boot light
Glove box light switch
Glove box light
FR LH storage compartment light
FR RH storage compartment light
Front right storage tray light
Front left storage tray light
Bonnet switch
Engine compartment light
Engine compartment light switch
Central storage tray light switch
Boot light relay
Boot light timed relay
Controls centralised electronic module
Head-up view unit
Head-up view control plate
Engine coolant temperature sensor
Engine coolant level switch
Offset controls unit
Engine coolant level unit
Engine coolant thermal switch
Engine temperature thermal switch
Engine coolant thermal switch-temp. sensor
Engine coolant temperature indicator
Engine coolant thermistor (indicator)
Pre-warning thermal switch
Refrigeration and engine coolant thermistor
Water presence sensor (separator)
Battery charge indicator
Engine oil level + temp. ind.
Engine oil temperature indicator
Engine oil level indicator
Engine oil temperature sensor
Engine oil pressure sensor
Engine oil pressure indicator
Engine oil pressure switch/sensor
Engine oil pressure switch
Engine oil thermal switch + temp. sensor
Engine oil level sensor
4130
4131
4132
4200
4205
4210
4240
4241
4300
4310
4311
4315
4320
4330
4335
4340
4341
4400
4401
4402
4405
4410
4420
4430
4431
4432
4433
4440
4445
4450
4500
4600
4605
4610
4620
4625
4630
4635
4640
4645
4700
4701
4702
4703
4704
4705
4710
4715
4716
4720
4725
4730
4731
4732
Engine oil thermal switch
Engine oil level and temperature sensor
Engine oil level and temp. grade sensor
Starter switch
Air filter pressure switch
Rev counter (if separate)
Inlet pressure sensor
Turbocharger pressure indicator
Fuel min. level switch
Fuel gauge
Fuel pump electronic shock absorber unit
Fuel gauge (sender)
Tank cap presence switch
Fuel flow sensor (computer)
Consumption interface unit
Consumption computer
Fuel instant. consumption indic.
Parking brake switch
Parking brake light diode
Reversing buzzer diode
Brake servo vacuum check vacuum switch
Brake fluid level switch
ABS warning light relay
FR LH brake pad wear switch
FR RH brake pad wear switch
RR LH brake pad wear switch
RR RH brake pad wear switch
Burned out bulbs detection unit
Burned out bulbs relay (warning light)
Brake warning light (Australia)
Trim height corr. fluid level switch
Automatic gearbox gear lever position switch
Automatic gearbox prog. or selection display
Gearbox oil temperature switch
Vehicle speed sensor
Vehicle speed interface unit
Vehicle speedometer
Tachograph electronic converter.
Odometer (if separate)
Odometer/warning lights electronic unit
FR LH lock switch
FR RH lock switch
RR LH lock switch
RR RH lock switch
Bonnet closed switch (bonnet open detection)
Bonnet lock switch (bonnet open detection)
Hazard lights relay
Open door buzzer
Parking position reminder buzzer
Lights on reminder buzzer
Lighting reminder + key presence buzzer
FR LH seat belt switch
FR RH seat belt switch
RR LH seat belt switch
4733
4734
4735
4736
4737
4738
4739
4740
4741
4742
4743
4744
RR RH seat belt switch
RR C seat belt switch
Seat belt buzzer
Seat belt buckle management unit
Detection panel
RR L centre seat belt switch
RR R centre seat belt switch
Overspeed buzzer
RR LH 3rd row seat belt switch
RR RH 3rd row seat belt switch
RR RH + RR centre seat belt switch
Seat belt switch
RR centre and RR LH
4745Seat belt switch
RR LH and RR RH row
4746 Belt unbuckled warning lights unit
4747 Centr/rear right/rear left seat belt switch
4750 Anti-lock braking system buzzer
4760 Immobiliser key presence switch
4761 Ignition key presence switch
4765 Key in immobiliser buzzer relay
4790 Electric motor reminder buzzer
4800 Catalytic converter temperature sensor
4805 Catalytic converter temperature unit
4900 Fault detection indicator symbol
4905 Points information display
4990 Loading flap open monitoring switch
5001 Rain sensor
5002 Rain sensor speed control relay
5003 Rain sensor gear control relay
5004 Automatic wiper computer
5005 Windscreen wiper relay
5006 Windscreen/rear screen wiper relay
5007 Rain/light sensor
5008 Rain/Light/Tunnel Sensor
5009 Windscreen wiper de-icer
5010 Windscreen wiper timer
5011 Windscreen wiper de-icer relay
5012 Light sensor
5015 Windscreen wiper motor
5016 Parking stop unit
5020 Cleaning fluid heater
5021 Pipe heater
5025 Front left wiper motor
5030 Front right wiper motor
5100 Windscreen washer pump
5105 Left heated windscreen washer jet
5106 Right heated windscreen washer jet
5110 Cleaning fluid level sensor
5115 Windscreen/rear screen washer pump
5202 Rear screen wiper switch
5203 Rear screen washer switch
5204 Rear screen wiper motor switch
(if separate)
10
6105
6110
6115
6116
6120
6121
6122
5205 Rear screen wiper relay
5210 Rear screen wiper timer
5211 Left rear screen wiper motor
5212 Right rear screen wiper motor
5215 Rear screen wiper motor
5300 Rear screen washer pump
5400 Headlight washer timer relay
5401 Headlight washer relay
5405 Headlight washer pump
5406 Headlight washer switch
6000 Left door L elect. window switch
6001 Left electr. window switch
6002 Right electr. window switch
6003 Pass. electr. window driver's switch
6004 Passenger electr. window switch
6005 Right door R electr. window switch
6007 Driver's electr. window driver's switch
6010 Right door L electr. window switch
6015 Left door R electr. window switch
6016 Elect. window + sunroof circuit diode
6017 Pass. electr. window pass. switch
6020 Pass. electr. window pass. switch
6021 Electric window relay
6025 Elect. window + sunroof resupply relay
6029Driver's door standard windows/
anti-pinch unit
6030 Standard electr. window unit
6031 Pass. seq. FR el. window unit + mot.
6032 Driver seq. FR el. window unit + mot.
6033 Anti-pinch unit
6034 Anti-pinch sensor
6035 Driver anti-pinch electr. window motor
6036 Driver's door mirror/el. window ctrl board
6037 Pass. door mirror/el. window cntrl board
6038 Pass. door anti-pinch electr. window motor
6039 Rear micro-lower anticipation unit
6040 Driver's electr. window motor
6041 Driver's door interior handle sensor
6042 Driver's door exterior handle sensor
6043 Passenger door interior handle sensor
6044 Passenger door exterior handle sensor
6045 Passenger electric window motor
6046 Rear left door exterior handle contact
6047 Rear right door exterior handle contact
6048 Front micro-lower anticipation unit
6049 Driver's door ext. handle contact
6050 Passenger door ext. handle contact
6051 FR right electr. window unit + motor
6052 FR left electr. window unit + motor
6053 Driver's door lock./el. window cntrl board
6060 Centralised electric window switch
6100 Rear left rear switch
6101 RR right seq. electr. window + motor
6102 RR left seq. electr. window + motor
6125
6126
6130
6131
6132
6133
6134
6135
6140
6150
6155
6200
6201
6202
6203
6204
6205
6206
6207
6208
6209
6210
6211
6212
6213
6214
6215
6216
6217
6218
6219
6220
6221
6222
6223
6224
6225
6226
6228
6229
6230
6231
6232
6233
6234
6235
11
Rear right electr. window rear switch
Rear left electr. window front switch
Rear right electr. window front switch
Rear electr. window control board
Rear electr. window locking switch
Rear functions locking relay
Rear electric window locking switch
and alarm cut-out
Rear electric window relay
+aa rear electric window relay
RR LH electric window motor
Rear right electric window unit + motor
Rear right electric window unit + motor
RR LH door anti-pinch el. window motor
RR RH door anti-pinch el. window motor
RR RH electric window motor
Heated seat + rear electr. window relay
LH electric quarter light motor
RH electric quarter light motor
FR LH open door switch
Left open door switch diode
FR LH door lock assembly
Switch isolation diode (FR/RR door)
Right open door switch diode
FR RH open door switch
Child locking switch
FR RH door lock assembly
Left engine catch
Right engine catch
RR LH open door switch
Lock switch
RR LH door lock assembly
FR left ext. opening ctrl sensor
FR right ext. opening ctrl sensor
Rear right open door switch
Open boot switch
RR RH door lock assembly
RR RH hinged door lock assembly
Door locking security relay
Doors central locking switch
RR RH hinged door locking switch
Boot locking assembly
Window locking assembly
Left shutter lock assembly
Right shutter lock assembly
Fuel filler flap relay
El. window/door locking unit
Locking prevention/locking switch
Infrared receiver (remote)
Central locking HF receiver
Central locking HF transmitter
FR LH door lock assembly
Door actuator cut-off unit
Central locking unit
6236
6237
6238
6239
6240
6241
6242
6243
6244
6245
6246
6247
6248
6249
6250
6251
6252
6253
6254
6255
6256
6257
6258
6259
6260
6261
6262
6263
6264
6265
6266
6267
6268
6269
6270
6271
6272
6273
6274
6275
6276
6277
6278
6279
6280
6281
6282
6283
6284
6285
6286
6287
6288
6289
6290
6291
6292
6293
6294
6295
6296
6297
6298
6299
6300
6301
6302
6303
63A1
63A2
63A3
63A4
63A5
63A6
63A7
63A8
63A9
63B0
Left sliding door end of opening switch
Boot locking switch
Right sliding door end of opening switch
Sliding side door module
FR LH door lock motor
Fuel filler flap switch
FR left door deadlocking motor
Left sliding side door motor
Left sliding side door FR LH switch
FR RH door lock motor
Left sliding side door RR LH switch
FR right door deadlocking motor
Right sliding side door motor
Right sliding side door FR RH switch
RR LH door lock motor
Right sliding side door RR RH switch
FR left door deadlocking motor
RR left hinged door locking motor
Front right door lock assembly
RR RH door lock motor
Rear doors lock motor
RR right door deadlocking motor
RR right hinged door locking motor
RR RH hinged door deadlocking motor
Boot lock motor
Shutter lock motor
Boot deadlocking motor diode
Left door child safety motor
Child safety relay
Fuel filler flap lock motor
Loading flap lock motor
Right door child safety motor
RR LH child safety LED
RR RH child safety LED
Left sliding door brake sensor
Right sliding door brake sensor
Left lock opening actuator
Right lock opening actuator
Left lock with integrated switch
Right lock with integrated switch
Boot lock actuator
Moving terminal switch
Left sliding side door switch
Right sliding side door switch
Right sliding side door split switch
Window opening switch
Boot opening switch
Rear shutter window opening switch
Rear shutter window lock actuator
Open rear window switch
Rear screen/boot authorisation relay
Boot opening relay
Rear screen opening relay
Boot striker panel
63B1
63B2
6365
6366
6367
6368
6369
6370
6371
6372
6373
6374
6375
6376
6377
6378
6379
6380
6381
6382
6383
6384
6385
6386
6387
6388
6389
12
Boot manoeuvre unit
Fixed terminal switch
Boot switch
Left sliding side door split switch
Boot shared relay
Left anti-pinch sensor
Right anti-pinch sensor
Shutter opening position switch
Rear access lock
Central locking HF aerial
Driver's seat advance switch
Rear view mirror + seat pos. mem. unit
Driver's seat adjustment assembly
Passenger seat adjustment assembly
Passenger seat adjustment assembly
Passenger seat motor assembly
Rear right headrest folding motor
Rear left headrest folding motor
Rear seats unlocking unit
Rear left seat unlocking button
Rear right seat unlocking button
Rear left seat unlocking actuator
Rear right seat unlocking actuator
Driver's seat folded backrest position
micro switch
Driver's seat backrest comfort position
micro switch
Passenger seat backrest comfort
position micro switch
Front RH seat adjustment relay
Front RH seat high-speed runner motor
Front LH seat high-speed runner motor
Front LH seat vertical lumbar pos. sensor
Front RH seat vertical lumbar pos. sensor
Seat movement slave unit
Driver's seat fan
Passenger seat fan
Front LH seat front stop pos. micro-switch
Front LH seatback locked pos. micro-switch
Adjust. pump + SV assembly front RH seat
Front RH seat front stop pos. micro-switch
Front RH seat folded backrest microswitch
Front RH seat locked backrest micro-switch
Front RH seat memory backrest micro-switch
Rear seat cushion adjustment switch
Rear seat cushion adjustment motor
Rear RH seat adjustment switch
Rear LH seat adjustment switch
Rear RH seat adjustment motor
Rear LH seat adjustment motor
Rear RH head restraint retraction switch
Rear LH head restraint retraction switch
Rear RH head restraint motor
Rear LH head restraint motor
6501
6502
6503
6505
6506
6510
6515
6520
6524
6525
6530
6535
6539
6540
6541
6542
6543
6544
6546
6547
6548
6549
6550
6551
6552
6553
6555
6558
6559
6560
6561
6562
6563
6564
6565
6566
6567
6568
6569
6570
6571
6572
6573
6574
6575
6576
6577
6578
6579
6580
6581
6582
6583
6584
6390 Rear head restraint retraction switch
6391 Rear RH seat adjustment assembly
6392 Rear LH seat adjustment assembly
6393 Front LH seat plate
6394 Front RH seat plate
6395 Driver's seat
6396 Passenger seat
6397 5 movements seat master unit
6398 5 movements seat slave unit
6399 2 movements seat slave unit
6400 LH rear view mirror switch
6404 Memory and lighting unit
passenger rear view mirror
6405 RH rear view mirror switch
6406 Rear view mirrors switch
6407 Folding rear view mirror unit
6408 Rear view mirrors folding relay
6409 Rear view mirrors fold-out relay
6410 Driver's rear view mirror
6411 LH rear view mirror
6415 Passenger rear view mirror
6416 RH rear view mirror
6420 Folding rear view mirror switch
6421 Reverse gear indexing unit
6422 Reverse gear indexing switch
6430 Electric interior rear view mirror
6435 Anti-dazzle module
6440 Electrochrome interior rear view mirror
6450 Blind spot monitoring module
6451 LH camera
6452 RH camera
6470 Steering wheel adjustment switch
6471 Steering wheel height adjustment motor
6472 Steering wheel depth adjustment motor
6473 Steering wheel depth/height adj. motor
6500 Front LH passive seat belt switch
65A0 Row 2 seat 1 right seat belt switch
65A1 Row 2 seat 1 left seat belt switch
65A2 Row 2 seat 2 right seat belt switch
65A3 Row 2 seat 2 left seat belt switch
65A4 Row 2 seat 3 right seat belt switch
65A5 Row 2 seat 3 left seat belt switch
65A6 El. connection unit without contact row
2 seat 1
65A7 El. connection unit without contact row
2 seat 2
65A8 El. connection unit without contact row
2 seat 3
65A9 Electric connection unit, with no body
contact, row 2
65B0 Driver's side impact sensor
65B1 Passenger's side impact sensor
65B2 Driver's side airbag module
65B3 Passenger's side airbag module
13
Front LH pyrotechnic seat belt inertia reel
Front RH head side airbag module
Front LH head side airbag module
Front RH passive seat belt switch
Front RH pyrotechnic seat belt inertia reel
Front LH passive seat belt module
Front RH passive seat belt module
Passive seat belt timer relay
Front LH strap return pretensioner
Front RH airbag neutralised warning light
Front LH passive seat belt motor
Front RH passive seat belt motor
Central front pretensioner
FR LH pyrotechnic seat belt module
FR RH Pyrotechnic seat belt module
Pyrotechnic seat belt module
Front left seat occupant detector
Front RH strap return pretensioner
Front right seat occupant detector
Front LH seat position sensor
Front LH knee-level airbag module
Front RH knee-level airbag module
Front RH seat position sensor
RH curtain airbag module
LH curtain airbag module
Airbag shunt resistor
Central front airbag module
Rear LH roll bar
Rear RH roll bar
Rear safety support control unit
Airbag ECU anti-interference coil
Front right side airbag module
Front left side airbag module
Front RH airbag module
Front LH airbag module
Rear RH side airbag module
Rear LH side airbag module
Front RH strap return pretensioner
Front RH airbag neutralisation switch
Airbags and pretensioner unit.
Right side airbag unit
Left side airbag unit
Front LH impact sensor
Front RH impact sensor
Front LH pretensioner
Front RH pretensioner
Rear LH pretensioner
Rear RH pretensioner
Central rear pretensioner
Rear LH impact sensor
Rear RH impact sensor
Front LH front impact sensor
Front RH front impact sensor
Front right active anti-sub. module
6750
6755
6760
6800
6801
6802
6803
6804
6805
6806
6807
6808
6809
6810
6811
6812
6813
6814
6815
6816
6817
6818
6819
6820
6821
6822
6823
6824
6825
6826
6827
6828
6829
6830
6831
6832
6833
6834
6835
6840
6841
6842
6845
6847
6850
6851
6852
6853
6854
6855
6856
6858
6859
6860
6585 Front front impact sensor
6586 Rear right strap return pretensioner
6587 Rear left strap return pretensioner
6588 Front LH strap return pretensioner
6590 Pedestrian impact detection control unit
6591 Front RH pedestrian impact detect. accel. sens.
6592 Front LH pedestrian impact detect. accel. sens.
6593 Pedestrian impact detection force sens.
6594 RH bonnet hinge actuator
6595 LH bonnet hinge actuator
6596 LH rear 3rd row pretensioner
6597 RH rear 3rd row pretensioner
6598 Driver pretensioner
6599 Passenger pretensioner
6600 Headlights corrector switch
6601 Vehicle height switch
6605 Headlights corrector unit
6606 Headlights dyn. corr. unit
6610 LH headlight corrector
6615 RH headlight corrector
6616 Front body height sensor
6617 Rear body height sensor
6620 Vehicle height corr. ctrl fuse
6621 Vehicle height corr. motor fuse
6625 Vehicle high position switch
6630 Parking brake signal relay
6631 Brake pedal signal relay
6632 Hydraulic circuit liquid press. switch
6635 Vehicle height corr. sensor/ECU
6636 Vehicle height corr. motor relay
6637 Vehicle height corr. SV relay
6640 Vehicle height corr. electric pump mot.
6645 Vehicle height correction SV
6646 Vehicle height corr. fluid level switch
6700 Differential lock ctrl switch
6701 Rear differential lock ctrl SV
6702 Engage 4x4 control SV
6703 Hold 4x4 control SV
6705 Differential lock fuse
6706 Engage 4x4 control relay
6707 Engage 4x4 switch
6708 Engage
4X4 and differential lock control switch
6709 Gear downshift closing contact
6710 Front diff. lock pos. switch
6711 Engage 4x4 closing sensor
6712 Rear diff. lock opening sensor
6713 Differential engine speed sensor (CTH)
6715 Rear differential lock position switch
6720 Differential lock ECU
6721 4 wheel drive computer
6730 Front differential lock motor
6735 Rear differential lock motor
6740 Differential lock relay
14
Controlled differential ECU
Traction control cut-out switch
Controlled differential proportional SV
Sunroof switch
Sunroof runner limit switch
Sunroof tilt limit switch
Sunroof runner control relay
Sunroof tilt control relay
Sunroof relay
Sunroof zero pos. switch
Sunroof relay in sunroof assembly
Intermediate position sunroof switch
Rear screen actuator power supply relay
Sunroof motor
One-touch sunroof motor
Level 2 one-touch sunroof motor
Level 3 one-touch sunroof motor
LH rear screen switch
RH rear screen switch
Mechanism opening switch
Level 2 and 3 sunroof front switch
Level 2 sunroof switch
Level 3 sunroof switch
Sunroof assembly
Anti-pinch sensor
LH rear screen actuator
RH rear screen actuator
Rear screen opening switch
Sunroof infrared transmitter
Sunroof infrared receiver
LH mechanism actuator
RH mechanism actuator
Mechanism actuator supply relay
Sunroof module
LH roll bar switch
RH roll bar switch
LH mechanism switch
RH mechanism switch
Sunroof control module
LH electric quarter light switch
Quarter light relay
LH electr. quarter light return switch
RH electric quarter light switch
RH electr. quarter light return switch
LH electric quarter light motor
Folding roof switch
Folding roof adjustment SV
Folding roof hydraulic unit R1 relay
Folding roof hydraulic unit R2 relay
RH electric quarter light motor
Roof locking/unlocking switch
Folding roof mechanism LH cover switch.
Folding roof mechanism RH cover switch.
Electric hood module
7016
7017
7018
7019
7020
7025
7026
7027
7028
7029
7030
7031
7040
7041
7045
7046
7048
7049
7050
7051
7055
7060
7065
7070
7071
7075
7076
7077
7078
7080
7090
7091
7092
7095
7100
7105
7110
7111
7112
7113
7114
7115
7120
7121
7122
7125
7126
7127
7128
7129
7130
7200
7201
7202
6861 Electric hood switch
6862 Hood electric pump motor
6863 Rear part open SV
6864 Rear part closed SV
6865 Electric hood closure SV
6866 Electric hood opening SV
6867 Cover open SV
6868 Cover closing SV
6870 Electric hood electric pump motor relay
6871 Rear part jack switch
6872 Electric hood cylinder switch
6873 Cover jack switch
6874 Electric hood switch
6875 Electric hood buzzer
6876 Electric hood buzzer diode
6877 Boot opening diode
6878 LH closed roof switch
6879 RH closed roof switch
6880 Open roof switch
6881 Boot switch
6882 Folding roof flap motor
6883 LH locked roof switch
6884 RH locked roof switch
6885 Hydraulic pump unit
6886 Blind switch
6887 RH boot locked switch
6888 LH boot locked switch
6889 Roof closed switch
6890 Boot open switch
6891 Cover panel retracted switch
6892 Cover panel out switch
6893 Folding roof ECU
6894 Sunroof cover panel retracted/out switch
6895 Centr. electric window folding roof switch plate
6896 Folding roof assembly
6897 LH locked boot switch
6898 RH locked boot switch
6899 Open boot switch
6900 Luggage cover curtain switch
6901 Curtain switch
6910 Moving protector
70A1 ABS motor power supply relay
70A2 ABS solenoid valve power supply relay
70A3 Front right wheel speed sensor
70A4 Front left wheel speed sensor
70A5 Rear right wheel speed sensor
70A6 Rear left wheel speed sensor
7000 Front LH ABS sensor
7001 Power-assisted steering fluid pressure switch
7005 Front RH ABS sensor
7010 Rear LH ABS sensor
7013 Gear lever in neutral switch
7014 Rear wheels ABS gyro sensor
7015 Rear LH ABS sensor
15
ABS accelerometer sensor
ABS ECU fuse
ABS ECU relay
Idle speed maintenance simulation res.
ABS ECU
ABS hydraulic assembly
Braking assistance electric pump
ABS solenoid valves fuse
ABS shunt
ABS pump fuse
Pump assembly (GEP)
GEP relay
Additional regulation unit
Additional regulation unit electric plate
Clutch pedal signal switch
Clutch position potentiometer
Controlled braking amplifier
Controlled braking amplifier ECU
Traction control computer
Traction control plus control
Traction control hydraulic unit
Traction control throttle actuator
Traction control throttle potentiometer
Brake electro-hydraulic unit
Brake pedal travel sensor
Traction control cut-out switch
Traction control switch warning light relay
Hill holder cut-off switch
Hill holder buzzer
Brake fluid level signal diode
Braking assistance vacuum pump
Braking assistance pressure switch
Electric handbrake control
Electric handbrake assembly
Power-assisted steering regulator servo
Variable power-assisted steering ECU
Power-assisted steering servo
Variable power-assisted steering proport. SV
Power-assisted steering pressure sensor
Power-assisted steering limit sensor
Variable power-assisted steering valve
Power-assisted steering control relay
Power-assisted steering electric pump motor
Power-assisted steering pump diode
Power-assisted steering pump assembly
Power-assisted steering power relay
Power-assisted steering ECU
EPAS steering wheel angle sensor
Electric power-assisted steering torque sens.
Electric power-assisted steering motor
Multiplex steering wheel angle sensor
Regulator-computer signal relay
Colour screen control module
Colour screen infrared receiver
7205
7206
7207
7210
7211
7214
7215
7216
7220
7222
7225
7226
7300
7301
7302
7305
7306
7307
7308
7309
7310
7311
7312
7315
7316
7318
7320
7325
7400
7500
7501
7502
7503
7504
7505
7506
7507
7508
7509
7510
7511
7512
7513
7514
7515
7516
7517
7518
7519
7520
7521
7522
7525
7526
7530
7550
7551
7552
7553
7554
7555
7556
7559
7561
7562
7563
7564
7565
7566
7569
7570
7571
Scrolling switch (computer)
Check switch
Controls information scroll control
Trip computer
Police trip computer
Screen tilt motor
Multifunction screen
Multifunction screen keypad
Clock
External temperature sensor
Ext. temperature display + clock
External temperature display
Cruise control switch
Cruise control rotary switch
CC/SL sensor
Cruise control switch
Cruise control safety switch (clutch)
Cruise control safety relay
Cruise control safety switch (brake)
Engine management/cruise control circuit shunt
Cruise control ECU
Cruise control fuse
Cruise control switch warning light diode
Vacuum pump assembly
Speed limiter switch
Speed limiter analogue/digital conversion unit
Cruise control safety SV
Cruise control control
External temperature display
Parking aid ECU
Laser telemeter
Laser telemeter switch
Parking aid front speaker
Parking aid rear speaker
Parking aid inhibit switch
Ext. front LH proximity sensor
Int. front LH proximity sensor
Ext. front RH proximity sensor
Int. front RH proximity sensor
Ext. rear LH proximity sensor
Int. rear LH proximity sensor
Ext. rear RH proximity sensor
Int. rear RH proximity sensor
Parking aid buzzer
Parking aid cut-off switch
LH free space measurement prox. sensor
RH free space measurement prox. sensor
Middle front left proximity sensor
Middle front right proximity sensor
Parking aid camera
Space available measurement switch
Parking aid video screen
Overtaking aid camera
Vehicle in blind spot warning light
7600
7601
7602
7605
7606
7607
7608
7609
7610
7611
7612
7700
7701
7702
7703
7704
7705
7706
7707
7708
7709
7710
7711
7712
7713
7714
7715
7716
7717
7718
7719
7720
7721
7722
16
Overtaking aid management module
Lateral trajectory monitoring ECU
Lateral trajectory monitoring LH 1 sensor
Lateral trajectory monitoring LH 2 sensor
Lateral trajectory monitoring LH 3 sensor
Lateral trajectory monitoring LH 4 sensor
Lateral trajectory monitoring LH 5 sensor
Lateral trajectory monitoring LH 6 sensor
Lateral trajectory monitoring LH vibrator
Lateral trajectory monitoring RH 1 sensor
Lateral trajectory monitoring RH 2 sensor
Lateral trajectory monitoring RH 3 sensor
Lateral trajectory monitoring RH 4 sensor
Lateral trajectory monitoring RH 5 sensor
Lateral trajectory monitoring RH 6 sensor
Lateral trajectory monitoring RH vibrator
Lateral trajectory monitoring switch
Inter-vehicle safe distance warning
computer sensor
Tyres under-inflated detection ECU
Under-inflation detect. HF receiver
Wheel transmitter module
Under-inflation reset switch
Front LH tyre pressure detection low freq. trans.
Front RH tyre pressure detection low freq. trans.
Rear LH tyre pressure detection low freq. trans.
Rear RH tyre pressure detection low freq. trans.
Front tyre pressure detection high freq. trans.r
Rear tyre pressure detection high freq. trans.
Under-inflation detection high frequency
aerial
Steering wheel angle sensor
Steering wheel angle computer
Body front height sensor
Body rear height sensor
Body height potentiometer
Body height sensor
Brake pressure switch
Accelerator pedal sensor
Front wheel travel sensor
Rear wheel travel sensor
Suspension switch
FR RH wheel travel sensor
FR LH wheel travel sensor
RR RH wheel travel sensor
RR LH wheel travel sensor
Suspension ECU
Front suspension SV
Rear suspension SV
Roll correction SV
Anti-roll electro-hydraulic unit
Front LH shock absorber actuator
Front LH shock absorber interference coil
Active anti-roll computer
7723
7724
7725
7726
7727
7728
7729
7730
7731
7732
7733
7734
7735
7736
7737
7738
7739
7740
7741
7742
7743
7744
7745
7746
7747
7748
7749
7750
7751
7752
7753
7754
7755
7756
7757
7758
7759
7760
7769
7770
7771
7772
78A1
78A2
7800
7801
7802
7803
7804
7805
7806
7807
7808
7809
7810 Front LH stability program sensor
7815 Front RH stability program sensor
7820 Rear LH stability program sensor
7825 Rear RH stability program sensor
80A0 Multifunction blower relay
80A1 Rear RH mixing flap gear motor
80A2 Rear LH mixing flap gear motor
80A3 Rear LH pass. comp. air thermistor
80A4 Rear RH pass. comp. air thermistor
80A5 Add. unit evaporator thermistor
80A6 Rear LH add. blower control module
80A7 Rear RH add. blower control module
80A8 Rear LH additional blower
80A9 Rear RH additional blower
80B0 Independent air reheater control module
80B1 Additional unit dist. flap gear motor
80B2 Additional heating relay 1
80B3 Additional heating relay 2
80B4 Additional heating relay 3
80F1 Additional air conditioning P-fuse 1
80F2 Additional air conditioning P-fuse 2
8000 Air conditioning switch
8001 Air conditioning compressor relay shunt
8002 Internal ventilation switch
8003 Internal ventilation motor
8004 Air conditioning cut-off module
8005 Air conditioning compressor relay
8006 Evaporator thermistor (if separate)
8007 Pressure switch
8008 Refrigeration and engine coolant thermistor
8009 Freon pressure sensor
8010 Coolant temperature module
8011 Warm loop coolant pump control relay
8012 Air conditioning cut-off pressure switch
8013 Additional air conditioning SV
8014 Idle speed stability SV
8015 Compressor cut-off relay by temp. module
8016 Relay for compress. cut-off via CCM ECU
8017 Warm loop SV control relay
8018 Blower high speed control relay
8019 Blower low speed control relay
8020 Air conditioning compressor
8021 Front LH air conditioning control panel
8022 Air conditioning motor coolant thermal switch
8023 Front RH air conditioning control panel
8024 LH passenger compartment air thermistor
8025 Air conditioning control panel (if separate)
8026 Additional air conditioning control panel
8027 Additional air conditioning control switch
8028 RH passenger compartment air thermistor
8029 Air condit. central storage compartment
8030 Passenger compartment air thermistor
8031 Coolant thermistor
8032 External air thermistor
Active anti-roll accelerometer
Variable damping accelerometer
Front RH shock absorber actuator
Front RH shock absorber interference coil
Rear active anti-roll accelerometer
Front LH active anti-roll accelerometer
Front RH active anti-roll accelerometer
Rear LH shock absorber actuator
Rear LH shock absorber interference coil
Front active anti-roll accelerometer
Rear LH active anti-roll accelerometer
Rear RH active anti-roll accelerometer
Rear RH shock absorber actuator
Rear RH shock absorber interference coil
Suspension compressor
Suspension inhibit switch
Central electronic unit motor
Suspension electro-hydraulic unit
Front RH hydraulic suspension SV unit
Front LH hydraulic suspension SV unit
Rear RH hydraulic suspension SV unit
Rear LH hydraulic suspension SV unit
Vehicle height selector
Controlled rear axle pad SV
Front suspension SV
Rear suspension SV
Boot height selector
Suspension control panel
Front LH body height sensor
Front RH body height sensor
Rear LH body height sensor
Rear RH body height sensor
Front suspension pressure sensor
Rear suspension pressure sensor
Pump assembly power supply current cut-off relay
Variable shock absorber ECU
Elec. unit motor cut-off relay
CAN bridge
Suspension buzzer
Hydraulic fluid pressure and/or level buzzer.
Tank SV
Suspension computer fuse holder
ESP motor power supply relay
ESP solenoid valve power supply relay
Stability program ECU (ESP)
ESP cut-off switch
ESP relay
ESP steering wheel angle sensor
ESP accelerometer gyrometer
ESP pre-charge pump
ESP hydraulic unit
Braking circuit pressure 1 sensor
Braking circuit pressure 2 sensor
ESP bridge
17
8033
8034
8035
8036
8037
8038
8039
8040
8041
8042
8043
8044
8045
8046
8047
8048
8049
8050
8051
8052
8053
8054
8055
8056
8057
8058
8059
8060
8061
8062
8063
8064
8065
8066
8067
8068
8069
8070
8071
8072
8073
8074
8075
8076
8077
8078
8079
8080
8081
8082
8083
8084
8085
8086
8087
8088
8089
8090
8091
8092
8093
8094
8095
8096
8097
8098
8099
8100
8105
8106
8110
8111
8112
8115
8116
8118
8119
8120
8121
8122
8125
8130
8140
8141
8145
8146
8200
8201
8203
8204
8205
8206
8207
8208
8209
8210
8220
8221
8235
8240
8241
8242
8243
8244
8245
8246
8247
8248
Brightness thermistor
Footwell air thermistor
Passenger compart. temp. electron. thermostat
Temperature display control
Air vent air thermistor
Light sensor
Front seat air blower
Blower speed control
Centre rear air blower
Rear air blower
RH blower control module
LH blower control module
Blower control module (if separate)
Blower speed resistor (if separate)
Blower speed switch
Blower relay
Addit. air conditioning blower resistor
Blower motor (if separate)
RH blower motor
LH blower motor
LH addit. blower speed switch
RH addit. blower speed switch
First resistor unit control relay
2nd resistor unit control relay
3rd resistor unit control relay
R2 and R3 control relay
Additional air con blower motor
Air conditioning heater unit
Air conditioning heater unit relay
Air conditioning heater unit shunt
RH mixer flap gear motor
LH mixer flap gear motor
Mixer flap gear motor
Rear air conditioning heater unit
Air inlet flap control
LH air inlet flap gear motor
RH air inlet flap gear motor
Air inlet flap gear motor
Distribution flap gear motor
Airflow flap gear motor
Footwell/de-icing flap gear motor
Chopper valve
RH distribution flap gear motor
LH distribution flap gear motor
Rear blower speed switch
Rear blower motor
Air quality sensor
Air conditioning ECU
Rear LH air conditioning control panel
Mixer flap gear motor control relay.
Rear RH air conditioning control panel
Passenger compartment air heating resistor
Power blower motor
LH additional blower unit
18
RH additional blower unit
Additional heating control panel
Additional heater SV fuse
Compressor protection diode
Independent/additional heater control relay
Additional heater switch
Additional heater fuel pump
Additional heater fuse
Additional heater control fuse
Additional heater on signal diode
Fuel heating control switch
Additional heater
Independent/add. heater igniter
Front cigarette lighter
Rear cigarette lighter
Rear cigarette lighter 2
Heated rear screen switch
Demisting switch
Rear screen demisting sensor
Heated rear screen relay
Heated rear screen timer relay
LH heated rear screen
RH heated rear screen
Heated rear screen
Rear screen demisting motor
Top heated rear window
Front LH heated rear view mirror
Front RH heated rear view mirror
Heated windscreen
Heated windscreen switch
Heated windscreen relay
Heated windscreen timer module.
Coded immobiliser keypad
Coded immobiliser LED
Injection ECU power supply relay warning light
Injection ECU resupply relay
Diagnostic light circuit warning light
Coded immobiliser door circuit warning light
Coded immobiliser relay for diesel pump
Coded immobiliser/transponder electr. module
Transponder coil
Transponder relay shunt
Analogue module transponder
Control module transponder
Engine start switch
Hands-free starting access electronic module
Passenger compartment internal aerial 1
Passenger compartment internal aerial 2
Boot internal aerial
Emergency aerial
Front LH external aerial
Front RH external aerial
Rear LH external aerial
Rear RH external aerial
8249
8300
8301
8302
8303
8305
8306
8307
8308
8310
8311
8312
8313
8314
8315
8316
8317
8318
8319
8320
8321
8322
8323
8324
8325
8326
8327
8328
8329
8330
8331
8332
8333
8334
8335
8336
8340
8345
8346
8347
8348
8349
8350
8351
8352
8353
8354
8355
84A1
84A2
84A3
84A4
84A5
84A6
84A7 Branded emergency call button
84A8 Emergency call button
84A9 Rear LH multimedia screen
84A0 Rear RH multimedia screen
84B1 Central front medium speaker
84B2 Radio supply relay
84B3 Control bitmap display
84B4 Mobile multimedia unit
84B5 Front LH door tweeter
84B6 Front RH door tweeter
84B7 Front LH door speaker
84B8 Front RH door speaker
84B9 Hands-free kit computer
84B0 Rear multimedia screen reader
84C1 Multimedia interface unit
84C2 Steering wheel telephone voice control
8401 Resistance adapter
8402 Aerial cable
8403 Aerial filter
8404 Aerial
8405 Electric aerial
8406 Aerial amplifier
8407 Duplexer
8408 Radio amplifier
8409 Heated rear screen aerial assembly
8410 Car radio
8411 Front LH/RH radio balance
8412 Front/Rear radio balance
8413 Car radio control
8414 Navigation audio line transform.
8415 CD changer
8416 CD interface
8417 Radio receiver/transmitter fan
8418 Radio aerial adapter
8419 Radio amplifier relay
8420 Front LH door speaker
8421 Front speaker
8422 Front LH speaker
8423 Front RH speaker
8424 Audio amplifier
8425 Front RH door speaker
8426 Bass speaker
8427 Bass boost speaker
8428 Rear LH hifi coaxial
8429 Rear RH hifi coaxial
8430 Rear LH speaker
8431 Rear LH central speaker
8432 Aerial filter 2
8433 Radio power supply filter
8435 Rear RH speaker
8436 Rear RH central speaker
8440 Front LH tweeter speaker
8442 Front LH medium speaker
8443 Front LH boomer speaker
Boot external aerial
Front LH heated seat switch
Heated seats regulation unit
Front LH heated seat rheostat
Front RH heated seat rheostat
Front RH heated seat switch
Rear LH heated seat switch
Rear RH heated seat switch
Heated seats relay
Front LH heated seat
Heated seat thermostat
Front LH heated seat relay
Front RH heated seat relay
Passenger heated bench seat
Front RH heated seat
Heated cushion adjustment module
Heated backrest adjustment module
Rear LH heated seat rheostat
Rear RH heated seat rheostat
Rear heated seat
Front LH heated seat timer relay
Front RH heated seat timer relay
Rear LH heated seat timer relay
Rear RH heated seat timer relay
Rear LH heated seat
Rear RH heated seat
Front LH seat cushion heating element
Front LH seat back heating element
Front RH seat cushion heating element
Front RH seat back heating element
Front LH heated seat adjustment module
Front RH heated seat adjustment module
Front LH heated seat sensor
Front RH heated seat sensor
Central seat cushion heating element
Seat massage switch
Front LH heated seat adjustment assembly
Front RH heated seat adjustment assembly
Front RH heated seat switch
Front LH heated seat switch
Front RH heated seat timer relay
Front LH heated seat timer relay
Front RH heated seat
Front LH heated seat
Driver's seat neck-level heating
Passenger seat neck-level heating
Driver's seat neck-level heating rheostat
Passenger seat neck-level heating rheostat
Front centre console USB socket
MP3 player jack socket
Aerial filter + heated rear screen
Aerial filter + heated rear screen
Telematics transceiver service module
SIM card reader
19
8444
8445
8447
8448
8449
8450
8451
84A1
84A2
84A3
84A4
84A5
8800
8452
8453
8454
8455
8457
8458
8459
8460
8461
8462
8463
8464
8465
8470
8471
8472
8473
8475
8476
8477
8478
8479
8480
8481
8482
8483
8484
8485
8486
8487
8488
8489
8490
8491
8492
8493
8494
8495
8496
8497
8498
8499
8500
8501
8502
8503
8504
8505
8506
8507
8508
8509
8510
8511
8512
8520
8521
8522
8523
8600
8601
8602
8603
8604
8605
8606
8607
8608
8609
Front LH woofer speaker
Front RH tweeter speaker
Front RH medium speaker
Front RH boomer speaker
Front RH woofer speaker
Rear LH tweeter speaker
Front LH heated seat
Front centre console USB socket
MP3 player jack socket
Aerial filter + heated rear screen
Aerial filter + heated rear screen
Telematic transceiver service module
Trailer refrigeration control relay
Rear LH medium speaker
Rear LH boomer speaker
Rear LH subwoofer speaker
Rear RH tweeter speaker
Rear RH medium speaker
Rear RH boomer speaker
Rear RH subwoofer speaker
Rear LH headphones socket
Resistor 1 (Japan)
Resistor 2 (Japan)
Resistor 3 (Japan)
Resistor 4 (Japan)
Rear RH headphones socket
Front police radio power supply
Rear police radio power supply 1
Rear police radio power supply 2
Rear police radio power supply 3
Mobile phone handset
Radio telephone control electronic module A
Radio telephone control electronic module B
Auto PC micro
PC auto switch
Telematics transceiver
Radiotelephone speaker
Radiotelephone microphone
Radiotelephone on buzzer
Radiotelephone aerial
Radiotelephone keypad
External video audio input unit
Multimedia assembly
PC auto colour screen
PC auto connection unit
PC auto central unit
Aerial switching module
Hands-free kit
Telematics receiver control
Telephone charge power supply
Television aerial assembly (Japan)
Electronic toll system (Japan)
Filter (Japan)
AM/FM aerial (Japan)
8610
8611
8612
8613
8614
8615
8616
8617
8618
8630
8700
8701
8800
8801
8802
8900
8901
8902
8702
9000
9005
9010
9015
9020
9025
20
External audio input unit
Navigation computer
GPS aerial
Navigation speaker
Control keypad
Traffic info module
Traffic info switch
RH audio/nav line conversion
LH audio/nav line conversion
Navigation repeat switch
Traffic condition signal warning light
Navigation assembly (Japan)
Brake signal warning light (Japan)
Traffic info. transceiver unit
Authorised speed control module
Dialogue unit
Authorised speed stop switch
System data/transm. acquis +recovery.
Anti-theft alarm module
Switch with anti-theft alarm key
Anti-theft alarm movement detection unit
Anti-theft alarm switch
Movement detection sensor
Anti-theft alarm siren
Anti-theft alarm warning light
Ultrasound transmitter
Ultrasound receiver
Ultrasound transmitter/Anti-theft alarm
warning light
Anti-theft alarm boot lid switch
Anti-theft alarm bonnet switch
Alarm rear RH hinged door switch
Alarm rear LH door switch
Alarm rear RH door switch
Alarm dipped beam power relay
Anti-theft alarm relay
Anti-theft alarm relay
Anti-lift switch
Protection module
Electric blind motor
Electric blind front switch
Trailer refrigeration control relay
Trailer double relay
Trailer socket fuse holder
Glove box lock assembly
Armrest assembly
Interior storage comp. locks control relay
Electric blind rear switch
Central module
Front LH light ECU
GMV ECU
Front RH light ECU
Washer/wiper ECU
Sensor acquisition ECU
9030
9031
9032
9033
9035
9040
9045
9050
9055
9056
9060
9065
9070
9075
9080
9085
Front LH door ECU
Seat ECU
Rear LH door ECU
Rear RH door ECU
Controls ECU
Display ECU
Passenger compartment ECU
Front RH door ECU
Signalling switching ECU
Automatic lighting ECU
Wipers switching ECU
Console ECU
Trailer ECU
Rear LH light ECU
Hatch ECU
Rear RH light ECU
ECU = electronic multiplex computer
"V" warning light numbers
V004
V100
V101
V102
V117
V110
V115
V120
V123
V130
V170
V171
V172
V173
V180
V200
V201
V230
V231
V232
V233
V260
V261
V262
V266
V401
V417
V402
V404
V405
V411
V412
V413
V420
V425
V430
V432
V440
V441
V442
V443
V444
V450
V460
V461
V470
V471
V472
V473
V480
V625
V656
V657
V658
V664
V670
V679
V700
V701
V705
V706
V731
V707
V770
V780
V818
V811
V822
V823
V824
Stop warning
Charge
Traction batt. charge OK
Traction batt. discharge
12V converter fault
Ignition test
Preheating
Injection test
Pump cut-off
Ignition/injection test
Temporary fault
Forward drive
Reverse drive
Insulation fault
Gas supply warning light
Rear fog light
Front fog light
Hazard warning lights
LH/RH direction indicator
LH direction indicator
RH direction indicator
Side lights
Dipped headlights
Main beam headlights
Fog light warning light
Engine coolant level
Battery electrolyte low
Engine coolant temperature
Screen washer fluid level low
Water detected in separator
Engine oil pressure
Engine oil level
Engine oil temperature
Starter warning light
Clogged air filter
21
Petrol level low
Filler cap open
Parking brake
Brake fluid level
Handbrake 1 fluid level
Brake pads worn
Bulbs blown
Suspension fluid level
Gear lever position
Gearbox oil temperature
Open door
Front doors and 2 side doors
Front doors and 1 side door
Seat belt buckle
Catalytic converter temperature
Deadlocking
Front airbag
Side airbag
Passenger airbag inhibition
Ride height corr. fluid level
Differential lock test
Reduction gear shift
ABS test
ABS active
Traction control
Traction control function
Cruise control
Brake pedal pos. (starting authorised)
Suspension diagnostic
Stability diagnostic (ESP)
Additional heater min. level
Heated rear screen
Transponder
Left-hand indicator lights display
Right-hand indicator lights display
Numbering of "C" special function connectors
C001
C002
C004
C103
C104
Diagnostic connector
Connector for troubleshooting wires
Controls test connector
Engine running signal test connector
Emergency stop switch fuse holder
connector
C105 General short-circuit optional
connector
C109 Ignition test connector
C110 Ignition anti-interference connector
C111 Ignition adjustment connector for idle
speed
C120 Injection test connector
C125 Anti-pollution adjustment connector
C126 Power supply pump fuse holder
connector
C127 EGR test connector
C128Carburettor heating resistor
fuse holder connector
C130 Ignition/injection test connector
C131 Vehicle/engine interconnection
connector
C132 Vehicle/auto gearbox interconnection
connector
C133 Ignition/injection computer fuse holder
connector
C136 Heated bracket fuse holder connector
C137 Oxygen sensor heating fuse holder
connector
C140 TDC connector
C145 System development connector
C150 Fan assembly operation test
connector
C163 Automatic gearbox test connector
C170 Electronic management test connector
C180 Gas diagnostic 1 connector
C181 Gas diagnostic 2 connector
C182 Rich gas connector
C183
C200
C231
C260
C310
C311
C464
C623
C630
C654
C656
C657
C664
C680
C686
C700
C701
C705
C710
C721
C722
C771
C800
C820
C840
C860
C861
C863
22
Lean gas connector
Caravan socket power supply
connector
Driving school dual control
connector
Front fog light fuse holder
connector
Caravan lighting + permanent power
supply connector
Brake switch connection connector
Chronotachograph power supply fuse
holder connector
Locking test connector
Seat memory test connector
Pyrotechnic seat belt test connector
Airbag test connector
Airbag and pretensioner test
connector
Ride height correction circuit bleed
connector
Sunroof connection connector
Electric hood test connector
ABS test connector
ABS power fuse holder connector
Traction control test connector
Variable power-assisted steering test
connector
Multifunction screen test connector
Navigation pre-equipment connector
Suspension test connector
Air conditioning test connector
Coded immobiliser test connector
Radio power supply + permanent
supply
connector
Anti-theft alarm test connector
Anti-theft alarm supply connector
Protection module test connector
Numbering for special cases
AE00
B001
B002
B003
B004
B005
B006
B007
B008
B009
B010
B011
B012
B013
B014
B015
B016
B017
B018
B019
B020
B021
B022
B023
B024
BB00
BB01
BB02
BB03
BB04
BB05
BB06
BB07
BB08
BB10
BB12
BCM0
BCM1
BCM2
BCM3
BCM4
BCM5
BCM9
BCP3
BF00
BF01
BF02
BFDB
BFH1
BFH2
BGP0
Electric anti-theft
Equipotential terminal 1
Equipotential terminal 2
Equipotential terminal 3
Equipotential terminal 4
Equipotential terminal 5
Equipotential terminal 6
Equipotential terminal 7
Equipotential terminal 8
Equipotential terminal 9
Equipotential terminal 10
Equipotential terminal 11
Equipotential terminal 12
Equipotential terminal 13
Equipotential terminal 14
Equipotential terminal 15
Equipotential terminal 16
Equipotential terminal 17
Equipotential terminal 18
Equipotential terminal 19
Equipotential terminal 20
Equipotential terminal 21
Equipotential terminal 22
Equipotential terminal 23
Equipotential terminal 24
Battery
Rear battery assembly
Front lower battery assembly
Front upper battery assembly
Central battery assembly
Starter battery
Service battery
Alternator-starter power battery
Traction battery (Hybrid Traction System)
Power supply module
+ battery connection terminal
Multifunction switch unit
LH multifunction switch unit
RH multifunction switch unit
LH multifunction switch unit
RH multifunction switch unit
Multifunction switch unit
under the steering wheel
Right-hand multifunction switch unit NG4
3 relay protection and switching module
Passenger compartment fuse box
Engine compartment fuse box
Boot fuse box
Fuse box from battery
Passenger compartment 5-fuse box 1
Passenger compartment 5-fuse box 2
Central management unit (police)
BH12
BH28
BM27
BM34
BMF1
BMF2
BMF3
BMF4
BPCB
BSC1
BSI1
BSR1
BTC1
CA00
CBE1
CCS1
CJ01
CJ02
CP00
CP01
CP02
CP03
CP04
CP05
CP06
CPC0
CPC1
CT00
CPH
CV00
DRA0
DRA1
ECV0
IC02
IC02B
IC02C
IC02D
MF00
MF01
MF02
MF175
MFM1
MFAV
PC01
PC02
PC03
PFC1
PR02
PR01
PRF1
23
Passenger compartment 12-fuse box
Passenger compartment 28-fuse box
27-fuse engine systems interface
34-fuse engine systems interface
Maxi-fuse module 1
Maxi-fuse module 2
Maxi-fuse module 3
Maxi-fuse module 4
Battery cable protection unit
Boot accessory unit
Built-in systems interface (BSI)
Tow support unit
Body transformer unit
Anti-theft switch
Electronic handbook (police)
Signal. central. ctrl assembly (police)
Junction connector 1
Junction connector 2
Rear 12V socket
Front 12V socket
Rear LH 12V socket on centre console
Rear RH 12V socket on centre console
Rear central 12V socket
Boot 12V socket
Dashboard 12V socket
LH sliding side door switch assembly
RH sliding side door switch assembly
Steering wheel rotary switch
Passenger compartment protection
unit (module)
Switch module under steering wheel
(COM200X)
Drain (shielding)
Drain 1 (shielding)
Control assembly in steering wheel
Engine main wiring harness interconnect.
Engine main wiring harness interconnect.
Engine main wiring harness interconnect.
Engine main wiring harness interconnect.
Service battery maxi-fuse
Alternator maxi-fuse
Starter battery maxi-fuse
175A engine comp. MEGA-fuse
Engine comp. MEGA-fuse 1
Front fuses information display
Rear RH power socket
Rear LH power socket
220V socket on centre console
Boot fuse holder 1
Engine relay support plate
Passenger compartment relay support plate
Engine compartment 1 fuse/relay holder
PSF2
PT00
PCF1
PFPR
RP00
VMF1
PRF2 Engine compartment 2 fuse/relay
holder
PS00 Support plate (if separate)
PSF0 Passenger compartment fuse modulesupport plate
PSF1 Engine comp. fuse module-support plate
Boot fuse module-support plate
Transformer socket
Boot fuse holder 1
Trailer presence power supply fuse holder
BSI power relay
Steering wheel with fixed central.control
Technical abbreviations and interpretations
AAC
AAS
ADDGO
A/C
ABS (ABR)
ADAM (AFU)
ADC
AET
AMVAR
ASR
BRAC
BEE
BM (BSM)
BMC
BSE
BSI
BTE
BTO
BVA
BVM
CAN
CBC
CCM (ECM)
CD
CDS (ESP)
CEE
COM200X
CPH
CR
CTN
CV00
DAE
DAV
DNS (1/2)
DSG
ECM (CCM)
EEPROM
EDC
EGR
EMF
EOBD
EPROM
ESMC
Camshaft
Parking aid
Diesel additive
Air Conditioning
Anti-Lock Braking System
Advanced Dynamic Aid Mechanism
Coded immobiliser
Electronic immobiliser with transponder
Suspension with electronic management
Wheel traction control (Acceleration Slip Regulation)
Cooling requirement for air conditioning
Water inlet unit
Engine systems interface (Example BM34)
Bulk moulding compound
Water outlet unit
Built-in systems interface
Folding roof unit
Odometer warning lights unit
Automatic gearbox
Manual gearbox
Controller Area Network
Corner brake control
Engine management computer
Compact Disc
Electronic stability program
European Economic Community
Switching module under the steering wheel (CV00)
Passenger compartment protection unit
Common Rail (single distributor)
Negative temperature coefficient
Switching module under the steering wheel (COM200X)
Electric power-assisted steering
Variable power-assisted steering
Domain Name Server (1 or 2 Internet providers)
Under-inflation detection
electronic engine management
Electrically Erasable Programmable ROM
electronic diesel test
Exhaust Gas Recirculation
Multifunction screen
European On-Board Diagnostics
Erasable Programmable ROM
Extreme sheet moulding compound
24
ESP (CDS)
ESV
EU
SV
SVA
FAP
FRIC
GEP
GMV
GNV
GRA
HDC
HDI
HF
HP
HPI
HSN
IR
JDD
LAD
LIN
LVV
MSR
PLC(M)
PSF
PTFE
RAA
RAS
RCO
REF
REAR
REF
RF
RFTA
RFTD
RVV
SAI
SHED
SMC
SWIRL
TE
TO
VAN
VTC
VVT
Electronic stability program
Wiper
European Union
Solenoid valve
Emergency Valve Assistant (Emergency Brake Assist)
Particle filter
Cooling function integrated in the ECU
Electro-pump assembly
Cooling fan unit
Natural Gas Vehicle
Additional regulation assembly
Top of Column
High pressure direct injection
High frequency
Speaker
High pressure injection (direct - petrol)
High Silicon Nitrile
Infrared
Fault log
Discharge bulb
Local Interconnect Network
Vehicle speed limiter
Motor Schleppmoment Regelung (Engine torque adjustment)
Sliding side door (motorised)
Fuse support plate
Poly Tetra Fluoro Ethylene
Intake air heater
System air cooler
Opening cyclic ratio
Electronic braking distribution
Rear additional blower air flow regulation
Electronic braking distribution
A/C (manual adjustment)
A/C with automatic adjustment
(passenger compartment temperature/flow of air/air distribution)
A/C (adjustment: air flow/passenger compartment temp.)
Cruise control
Integrated intake system
Sealed Housing for Evaporation Determination
Sheet moulding compound
Air turbulence
Folding roof
Sunroof
Vehicle Area Network
Valve Timing Camshaft (Variable distribution)
Variable Valve Timing
25
Identification of connectors
B A: White
BE: Blue
BG: Beige
GR: Grey
JN: Yellow
MR: Brown
NA: Natural
NR: Black
OR: Orange
RG: Red
RS: Pink
VE: Green
VI: Purple
VJ: Green/Yellow
Identification of earths, connectors and differentiators
(605 to AM 94, 106 and 405 to AM 92)
Loca tion:
C Boot
H Passenger
compartment
M Engine comp.
HM26
Identification:
C Connector
D Differetiator
DM Earth differentiator
E Parallel connection
M Earth
Number
Identification of earths, parallel connections,
connectors and differentiators
(1007, 106 from MJ93/206, 207, 306, 307, 405 from MJ93/406, 407, 605
from MJ95/607/806/807/Expert/Partner)
M 015A
Alphabetical index
Number
B
E
EM
IC
M
26
Equipotential terminal (diff.)
Parallel connection
Earth splice
Interconnection
Earth
Numbering of wires (diagrams without BSI)
After fuse
power supply
AA . . . . . (+AA) . .
BB . . . . . . . . . . . . CC . . . . . (+CC) . .
FF . . . . . . . . . . . . KK . . . . . . . . . . . . LL . . . . . . . . . . . . VV . . . . . . . . . . . . Before fuse
power supply
A . . . . . . . . . . . . . B . . . . . . . . . . . . . C . . . . . . . . . . . . . F . . . . . . . . . . . . . K . . . . . . . . . . . . . L . . . . . . . . . . . . . V . . . . . . . . . . . . . P . . . . . . . . . . . . . T . . . . . . . . . . . . . Description
+ Accessories feed
+ Battery feed
+ After ignition feed
Engine running + battery feed
+ After ignition feed cut-off
+ Plus alternator
+ Side light
+ Headlights
Timed + battery feed
Diverse power supply
CE
After fuse + battery feed power supply
(fuse box in engine compartment)
+ Lighting after ignition feed power supply
(anti-theft output to lighting switch)
CR
Dipped/main beam power supply output (lighting switch)
PA
Additional driving lights power supply
PB
Front fog lights power supply
PC
Dipped headlights power supply
PR
Main beam headlights power supply
RC
Dipped/main beam power supply output (lighting switch)
VR
+ Side light after rheostat power supply
D
Drain
M
Earth
+P
Plus permanent
BM
Earths
D
Drain
M
Earth
MP
Headlights earth
MV
Warning light earth
Multiplexing
90 ..
Multiplexing wires
27
Examples
256
Wire number
Function number (25 = horn)
AA1
Wire number
Before fuse + accessories feed power
B02
supply
Fuse number
After fuse + battery feed power supply
V091
Wire number
Fuse number
+ Side light after fuse power supply
M101
Wire number
Function number (10 = starting)
Earth
28
Numbering of wires (diagrams with BSI)
Power supply
A
AE
AH
AM
B
BD
BE
BECE
BF
BH
BM
BM1
BM2
BS
C
CE
CE1
CE2
CH
CM
D
DE
K
KE
KH
KM
L
LH
LM
P
PE
PM
R
RCD
T
V
VE
XC
XC1
XC2
XC3
XE
Z
Earth
M
BL
MC
ME
MM
SF
+ accessories feed
BSI output + accessories feed
Passenger compartment fuse box outlet + accessories feed
BM34 output + accessories feed
direct + battery feed
starting + battery feed
BSI output + battery feed
BSI + battery output /BSI output + after ignition feed (park shunt)
Max fuse output service + battery
Passenger compartment fuse box output + battery
BM34 output + battery
protected BM34 output + battery
unprotected BM34 output + battery
service + battery
+ after ignition feed
BSI output+ after ignition feed
protected BSI output + after ignition feed
unprotected BSI output + after ignition feed
passenger compartment fuse box outlet + after ignition feed
BM34 output + after ignition feed
+ starting
after relay + starting
+ after ignition feed (cut-off on starting)
BSI output + after ignition feed (cut-off on starting)
passenger compartment fuse box output + after ignition feed (cut-off on starting)
BM34 output + after ignition feed (cut-off on starting)
direct + alternator
Passenger compartment fuse box output + alternator
BM34 output + alternator
+ engine running
BSI output + engine running
BM34 output + engine running
+ rheostat side light
+ REMOTE CTRL WAKE UP
+ timed (10 minutes)
+ side lights
BSI output + side lights
+ VAN body
+ VAN body 1
+ VAN body 2
+ VAN body 3
+ VAN comfort
+ CAN
Earth
shielding
body earth
electronic earth
engine earth
wireless equipotential
29
Intersystem and Multiplexing (link bus)
9000 CAN HIGH intersystem
9A00 CAN HIGH intersystem (FSC required)
9001 CAN LOW intersystem
9A01 CAN LOW intersystem (FSC required)
9002 VAN DATA body
9003 VAN DATA B body
9004 VAN DATA comfort
9005 VAN DATA B comfort
9006K line diagnostic (gearbox + engine manag.)
9007L line diagnostic (gearbox + engine manag.)
9008 Headlights corr./BSI K3 line diagnostic
9009 CDS/ABS / AMVAR K4 line diagnostic
901 CCS_CMM K6 line diagnostic
9010 CAN HIGH intersystem 2
9011 CAN LOW intersystem 2
9012 VAN DATA body 1
9013 VAN DATA B body 1
9014 Alternator-starter line K5 diagnostic
9015 Variable power-assisted steering line
K9 diagnostic
9016 Intersystem wake-up signal
9017 CAN HIGH low speed body
9018 CAN LOW low speed body
9019 CAN HIGH low speed safety
9020 CAN LOW low speed safety
9021 BSI wake-up output
9022 VAN DATA body 2
9023 VAN DATA B body 2
9024 CAN DATA HIGH comfort
9025 CAN DATA LOW comfort
9026 CAN DATA HIGH body
9027 CAN DATA LOW body
9028 CAN DIAGNOSTIC HIGH (BSI)
9029 CAN DIAGNOSTIC LOW (BSI)
9030
9031
9032
9033
9040
9041
9042
9043
9044
9045
9046
9047
9048
9049
9050
9051
9060
9100
9110
9111
9112
9113
9989
9990
9991
9992
9993
9994
9995
9996
9997
9998
9999
CAN HIGH intersystem 4
CAN LOW intersystem 4
CAN HIGH isolated intersystem
CAN LOW isolated intersystem
LIN 1
LIN 2
LIN STL
LIN headlight
LIN passenger compartment 1
BSI/ADML wake-up signal
LIN DATA
Left-hand headlight internal
Right-hand headlight internal
LIN Engine
PCS wake-up signal
LIN engine systems interface
Gas diagnostic line K
BSI K diagnostic
CAN HIGH intersystem 3
CAN LOW intersystem 3
CCS dedicated CAN HIGH
CCS dedicated CAN LOW
Anti-pinking deactivation info
CAN LOW micro 1
CAN HIGH micro 1
CAN LOW micro 2
CAN HIGH micro 2
S_ANA A micro 1
S_ANA B micro 1
S_ANA A micro 2
S_ANA B micro 2
Line K micro 1
Line K micro 2
Fuse-protected power supply
Non fuse-protected power supply
Wire number: A
Wire number: 03
Fuse number: 03
Type of power supply:
direct + battery feed
Type of power supply: + after ignition feed
Fuse-protected power supply
Earth
Wire number: A
Wire number: G
Function number 004 (handset)
Fuse number: 16
Type of power supply: + VAN bodywork
Earth
Diagnostic or multiplex link bus
Wire number: J
Intersystem CAN HIGH bus
30
Notes
31
List of cable functions
STARTING - POWER GENERATION
PREHEATING - IGNITION
100
1000
1001
1002
1003
1004
1010
1011
1012
1013
1120
1121
1125
1126
113
1130
1131
1132
1133
1134
1135
1136
1141
1142
1143
1145
1146
1147
1150
1151
1152
1153
1154
1155
1156
1157
1158
1181
1182
1183
1184
1185
1186
1187
1188
1189
1014
1015
102
1020
1021
1022
1024
1025
1026
1027
1028
1029
103
1030
1035
1036
1037
1038
1039
104
1040
1041
1042
1045
1050
1052
1053
1055
1057
1058
1060
1065
1070
1074
1075
1085
1086
1087
SOLENOID CONTROL
COLD STARTING CONTROL
COLD STARTING POWER SUPPLY
COLD STARTING PUMP
COLD STARTING SV
COLD STARTING SV + PUMP
STARTER ANALOGUE EARTH OUTPUT
ENGINE SPEED INCREASE REQUEST OUTPUT
CONTACT CONDITION RELAY CONTROL OUTPUT
RELAY CONTROL OUTPUT ACCORDING TO
AC STATUS
RELAY CONTROL OUTPUT ACCORDING TO
LOAD-SHEDDING STATUS
RELAY CONT. OUTPUT ACC TO
OPERATIONAL GENERATOR STATUS
+ STARTER SIGNAL
STARTING BY CCM + CTRL
HANDS-FREE STARTING CTRL
BACKUP BATTERY INPUT
STARTER WARNING LIGHT OUTPUT
IMPLEMENT STARTER REQUEST
STARTER IMPLEMENTATION COMMAND
ENGINE LOCKING COMMAND
LOCKER POS. SENSOR POWER SUPPLY
LOCKER POS. SENSOR SIGNAL
STARTER FAULT SIGNAL
BATTERY CHARGE WARNING LIGHT ACTIV.
COMMAND
SHIELD MONITORED VOLTAGE OUTPUT
BSI OUTPUT/P SHIELD CTRL SIGNAL
SHIELD IP CTRL SIGNAL
SHIELD DIAGNOSTIC SIGNAL
SHIELD DIAGNOSTIC SIGNAL EARTH
ALTERNATOR CHARGE SIGNAL
STARTER MOTOR EXCIT. PUMP COMMAND
ENGINE UNLOCKING COMMAND
ENGINE FUNCTION POWER SUPPLY
BLOCKER POS. SENSOR EARTH
ANTI-THEFT SWITCH + BATTERY POWER SUPPLY
LOW CURRENT IMMOBILISER INPUT
IMMOBILISER KEY POSITION INPUT
ANTI-THEFT SIGNAL POWER SUPPLY
EL. IMMOBILISER SAFETY OUTPUT
EL. IMMOBILISER POWER SUPPLY OUTPUT
PSF1+ ACCESSORIES PANEL + AFTER
IGNITION FEED
AFTER IGNITION FEED INPUT
ENGINE STALLING INFO. (BSI)
ENGINE RUNNING + COMMAND
ENGINE RUNNING INFORMATION
ALTERNATOR-REGULATOR CONTROL.
STARTER EXCITATION (ALARM)
ALTERNATOR EXCITATION CONTROL
CYLINDER DEACTIVATION SV CTRL
CYLINDER DEACTIVATION SV POWER SUPPLY
VALVE ECU FUNCTIONING SAFETY LINE +
VALVE ECU FUNCTIONING SAFETY LINE CAMSHAFT POWER SUPPLY 2+
CCS_CMM EARTH
CAMSHAFT SIGNAL
CAMSHAFT INFO
+ CAMSHAFT SIGNAL
- CAMSHAFT SIGNAL
IGNITION INT. PHASE DET. SIGNAL
CAMSHAFT EARTH 2COOLANT HEATER PLUG 1 POWER SUPPLY
COOLANT HEATER PLUG 2 POWER SUPPLY
COOLANT HEATER PLUG 3 POWER SUPPLY
THROTTLE SV CONTROL
COOLANT HEATER PLUG 1-2 POWER SUPPLY
COOLANT HEATER PLUG 3-4 POWER SUPPLY
IGNITION COILS POWER SUPPLY
IGNITION CTRL 1
IGNITION CTRL 2
IGNITION CTRL 3
IGNITION CTRL 4
IGNITION CTRL 5
IGNITION CTRL 6
IGNITION CTRL 1-4
IGNITION CTRL 2-3
PRE/POSTHEATING UNIT CONTROL
PRE/POSTHEATING WARNING LIGHT CONTROL.
PRE/POSTHEATING PLUGS CONTROL
POSTHEATING PLUGS CONTROL 1
POSTHEATING PLUGS CONTROL 2
POSTHEATING PLUGS CONTROL 3
POSTHEATING PLUGS CONTROL 4
POSTHEATING PLUGS CONTROL 5
POSTHEATING PLUGS CONTROL 6
INJECTION/CARBURETTOR POWER SUPPLY
120
121
1200
1201
1202
1203
1204
1205
1206
1207
1208
1209
1210
1211
1212
1213
32
BSM SUPPLY VIA INJECTION RELAY
FREQ. AIR FLOW SENSOR SIGNAL A
FUEL PRESSURE SENSOR SIGNAL.
FUEL PUMP CONTROL
POWER LATCH RELAY CONTROL
INJECTION COMPUTER POWER SUPPLY
TANK SV CONTROL
EXHAUST AIR INJECT. SV CTRL
SWIRL PHASE 1 STEPPER MOTOR CTRL
SWIRL PHASE 2 STEPPER MOTOR CTRL
SWIRL PHASE 3 STEPPER MOTOR CTRL
SWIRL PHASE 4 STEPPER MOTOR CTRL
EOBD EMISSION CONTROL WARNING LIGHT CTRL
CYLINDER INJECTOR CTRL 1 (+)
CYLINDER INJECTOR CTRL 2 (+)
CYLINDER INJECTOR CTRL 3 (+)
1214
1215
1216
1217
1218
1219
1220
122
1221
1222
1223
1224
1225
1226
1227
1228
1229
123
1230
1231
1232
1233
1234
1235
1236
1237
1238
1239
124
1240
1241
1242
1243
1244
1245
1246
1247
1248
1249
125
1250
1251
1252
1253
1254
1255
1256
1257
1258
1259
126
1260
1261
1262
1263
1264
1265
1266
1267
1268
1269
127
1270
1271
1272
1274
1275
1276
1277
1278
1279
CYLINDER INJECTOR CTRL 4 (+)
CYLINDER INJECTOR CTRL 5 (+)
CYLINDER INJECTOR CTRL 6 (+)
SWIRL POSITION FEEDBACK SIGNAL
THROTTLE POTENTIOM. POS. SIGNAL 1
THROTTLE POTENTIOM. POS. SIGNAL 2
THROTT. POT. 5V POWER SUPPLY
CAT. LAMBDA SENSOR HEATING CTRL
FUEL PRESS. REG. SV CTRL
CANISTER VENT SV CTRL
ENGINE MANAGEMENT MAIN RELAY
POWER SUPPLY
3RD PISTON DEACTIVATION CONTROL (INJ
PUMP)
ENGINE MANAGEMENT POWER RELAY
POWER SUPPLY
ENGINE MANAGEMENT POWER RELAY CTRL
INJECTOR CTRL +
POWER RELAY CTRL VIA IGNITION
ENGINE MANAGEMENT MAIN RELAY CTRL
UPSTREAM B LAMBDA HEATING CTRL
BODY ACCELERATION EARTH
BODY ACCELERATION SIGNAL
CANISTER BLEED SV CTRL
BODY ACCELERATION POWER SUPPLY
AC/OUT COMPRESSOR RELAY CTRL
PETROL PUMP CTRL
PETROL PUMP RELAY CTRL
VARIABLE AIR DUCT INLET SV CTRL (SHORT)
ADVANCE CORRECTION SV CTRL
ENGINE SWITCH
DOWNSTREAM C LAMBDA HEATING CTRL
VARIABLE TIMING SV POWER SUPPLY
VTC1
VARIABLE TIMING SV CTRL
VTC2
VARIABLE TIMING SV CTRL
VTC
VARIABLE TIMING SV CTRL
AIR INLET 1 STEPPER MOTOR CTRL
AIR INLET 2 STEPPER MOTOR CTRL
AIR INLET 3 STEPPER MOTOR CTRL
AIR INLET 4 STEPPER MOTOR CTRL
VARIABLE TIMING SV 2 POWER SUPPLY
FLOW SENSOR SIGNAL (+)
DOWNSTREAM D LAMBDA HEATING CTRL
FLOW SENSOR SIGNAL (-)
OIL VAPOUR RECYCLING REHEATING
POWER SUPPLY
ENGINE CUT-OFF IN CASE OF IMPACT
EGR THROTTLE MANAGEMENT CTRL
EGR SV POWER SUPPLY
THROTTLE VALVE HEATING POWER SUPPLY
EGR SOLENOID VALVE CONTROL
EGR SOLENOID VALVE EARTH
PROPORTIONAL SENSOR + SIGNAL
PROPORTIONAL SENSOR - SIGNAL
THROTTLE + EGR SV CTRL
PROP. SENSOR COMPEN. RESIST. SIGNAL
PROP.SENSOR CURRENT PUMP SIGNAL.
PROP. SENSOR HEATING POWER SUPPLY
PROP. SENSOR HEATING CONTROL
128
1280
1281
1282
1283
1284
1285
1286
1287
1288
1289
129
1290
1291
1292
1293
1294
1295
1296
1297
1298
1299
12A0
130
1300
1301
1302
1303
1304
1305
1306
1307
1308
1309
131
1310
1311
1312
1313
1314
1315
1316
33
EXHAUST GAS HT SENSOR 2 + SIGNAL.
EXHAUST GAS HT SENSOR 2 - SIGNAL.
CAT A UPSTREAM GAS TEMP. SENSOR SIG.
CAT B UPSTREAM GAS TEMP. SENSOR SIG.
CAT A DOWNSTREAM GAS TEMP. SENSOR SIG.
CAT B DOWNSTREAM GAS TEMP. SENSOR SIG.
INLET AIR HEATING SV CTRL.
TURBOCHARGING PRESSURE SV CTRL
VARIABLE GEOM TURBO SV CTRL
ACAV SOLENOID VALVES POWER SUPPLY
EXHAUST GAS HT SENSOR + SIGNAL.
EXHAUST GAS HT SENSOR - SIGNAL.
VARIABLE AIR DUCT INLET SV CTRL (LONG)
DENSO SENSOR + SIGNAL
DENSO SENSOR - SIGNAL
ENGINE MANAGEMENT DIAG. WARNING
LIGHT CTRL
BSE INT. PROPORT. COOLANT SV CTRL
DIESEL PUMP FLOW CTRL
PIEZO REFERENCE SIGNAL
FUEL ADDITIVE INJECTION CTRL (+)
FUEL ADDITIVE INJECTION CTRL (-)
FUEL ADDITIVE PUMP +CTRL
FUEL ADDITIVE PUMP -CTRL
FUEL ADDITIVE PUMP + THERM
FUEL ADDITIVE PUMP - THERM
PIEZO MEASUREMENT SIGNAL
IDLE SPEED SV CTRL (F)
FREQ. AIR FLOW SENSOR SIGNAL B
IDLE SPEED SV CTRL (O)
STOP SOLENOID VALVE CTRL
DIAG WARNING LIGHT CTRL
COOLANT HEATING SV CTRL
EQUIPMENT TEMP. SENSOR SIGNAL
FUEL VOLUME ADJ. SV CTRL
ELECTRIC TURBO CTRL
VERTICAL LINK ROD 1 SV CTRL
VERTICAL LINK ROD 2 SV CTRL
BYPASS VALVE SV CONTROL
DIESEL HEATING DIAG.
UPSTREAM CAT A (+) LAMBDA SENSOR SIG.
UPSTREAM CAT B (+) LAMBDA SENSOR SIG.
UPSTREAM CAT B (-) LAMBDA SENSOR SIG.
DOWNSTREAM CAT C (+) LAMBDA SENSOR SIG.
DOWNSTREAM CAT C (-) LAMBDA SENSOR SIG.
DOWNSTREAM CAT. D (+) LAMBDA SENSOR SIG.
DOWNSTREAM CAT. D (-) LAMBDA SENSOR SIG.
PARTICLE FILTER DIFFERENTIAL PRESS. SIG.
FAP DIFF. PRESSURE SENSOR POWER SUPPLY
A+ EGR MOTOR CTRL
TURBOCHARGING PRESSURE B SV CTRL
UPSTREAM CAT A (-) LAMBDA SENSORS SIG.
EGR SV POTENTIOMETER POWER SUPPLY
INJECT. FAN SV CTRL
ENGINE SPEED SENSOR POWER SUPPLY
ENGINE SPEED SENSOR EARTH
EGR A POTENTIOMETER EARTH
EGR B POTENTIOMETER EARTH
A- EGR MOTOR CTRL
1366
1367
1368
1369
137
1370
1371
1372
1373
1374
1375
1376
1377
1378
1379
138
1380
1381
1382
1383
1384
1385
1386
1387
1388
1389
1317
1318
1319
132
ALTIMETRIC SENSOR SIGNAL
ON/OFF SWIRL VALVE SWITCH
EGR SV POTENTIOMETER EARTH
2.5V POTENTIAL. (ENGINE MANAGEMENT
SENSOR.)
1320 INJECTORS POWER SUPPLY
1321 CYLINDER 1 INJECTOR (-) CTRL
1322 CYLINDER 2 INJECTOR (-) CTRL
1323 CYLINDER 3 INJECTOR (-) CTRL
1324 CYLINDER 4 INJECTOR (-) CTRL
1325 CYLINDER 5 INJECTOR (-) CTRL
1326 CYLINDER 6 INJECTOR (-) CTRL
1327 B+ EGR MOTOR CTRL
1328 + 5V LINE 4
1329 + 5V LINE 3
133 EGR FEEDBACK INFORMATION A
133A FLOW SENSOR SIGNAL (+)
133B FLOW SENSOR SIGNAL (-)
1330 ENGINE SPEED SIGNAL
1331 + 5V LINE 1
1332 + 5V LINE 2
1333 INLET AIR FLOW SENSOR SIGNAL
1334 INTAKE AIR ELECT. MOT. CTRL (+)
1335 INTAKE AIR ELECT. MOT. CTRL (-)
1336 FLOW SENSOR EARTH
1337 FLOW SENSOR POWER SUPPLY
1338 FLOW SENSOR SIGNAL
1339 FREQUENTIAL AIR FLOW SIGNAL
13390 FREQ. AIR FLOW METER SIGN. A
13391 FREQ. AIR FLOW METER SIGN. B
134 PINKING SIGNAL A (+)
1340 FLOW SENSOR AIR TEMP SIGN.
1341 AIR TEMPERATURE SIGNAL
1342 EXHAUST AIR INJ. PUMP POWER SUPPLY.
1343 EXHAUST AIR INJ. PUMP REL. CTRL
1344 EXHAUST AIR INJ. PUMP CUT-OFF SV CTRL
1345 EXHAUST AIR INJ. PUMP REL. POWER SUPPLY
1346 EGR SV RECOPY SENSOR SIGNAL
1347 CTP1 RELAY CTRL
1348 CTP2 RELAY CTRL
1349 DUAL MODE EXHAUST SV CTRL
135 PINKING SIGNAL A (-)
1350 EAM SENSOR SIGNAL (PINKING DW10)
1351 LAMBDA SENSOR HEATING POWER SUPPLY
1352 AAC SENSOR POWER SUPPLY
1353 No. 1 CAMSHAFT SENSOR SIGNAL
1354 No. 2 CAMSHAFT SENSOR SIGNAL
1355 CANISTER SV POWER SUPPLY
1356 CAMSHAFT SENSOR EARTH
1357 INJECT. ENGINE COOLANT TEMP. EARTH
1358 BRAKE VACUUM SENSOR SIGNAL
1359 BRAKE VACUUM SENSOR EARTH
136 PINKING SIGNAL B (+)
1360 BRAKE VACUUM SENSOR POWER SUPPLY
1361 ENGINE SPEED SENSOR + SIGNAL
1362 ENGINE SPEED SENSOR - SIGNAL
1363 INTAKE AIR PRESSURE SENSOR POWER SUPPLY
1364 INTAKE AIR PRESSURE SENSOR EARTH
1365 INTAKE AIR TEMP. SENSOR EARTH
139
1390
1391
1392
1393
1394
1395
1396
1397
1398
1399
13A1
13A2
13A3
13B3
13B4
13B5
13B6
13B7
13C0
13C1
13C2
13C3
13C4
13C5
13C6
13C7
13C8
13C9
13D1
13D2
13D3
34
ENGINE COOLANT TEMP. SIGNAL (INJEC.)
MOTOR. THROTTLE POTENT. EARTH
FUEL CONSUMPTION SIGNAL
CONTROLLED FLAPS CONTROL
PINKING SIGNAL B (-)
THROTTLE FEEDBACK SIGNAL 1
THROTTLE MOTOR CTRL VIA +
THROTTLE MOTOR CTRL VIA LINEAR EGR SV CTRL
THROTTLE FEEDBACK SIGNAL 2
THROTTLE POSITION SIGNAL
PRE/POSTHEATING UNIT CONTROL
ACCELERAT. PEDAL 1 POS. SIGNAL
ACCELERAT. PEDAL 2 POS. SIGNAL
ACCELERAT. PEDAL POS EARTH.
EGR FEEDBACK INFORMATION B
ACCEL. PEDAL POS. +5 VOLT POWER SUPPLY
DIESEL FLOW ACTUATOR SIGNAL
FUEL HP REG. SV POWER SUPPLY
VEHICLE SPEED SENSOR POWER SUPPLY
ACTION ON CLUTCH SIGNAL
FUEL TEMP. SENSOR SIGNAL
PRE/POSTHEATING DIAG. SIGNAL
POSTHEATING CTRL
NEEDLE LIFT SIGNAL
CATALYTIC CONVERTER TEMPERATURE
SIGNAL
ECU COOLING FAN CTRL.
NO LOAD SWITCH
MIL-REQUEST SIGNAL
EOBD WARNING SIGNAL
INLET AIR PRESSURE SIGNAL
VTC POS. FEEDBACK SENSOR SIGNAL
VEHIC. VERTIC. ACCEL. SENSOR SIG.
ANTI-EVAP. CIRCUIT DIAG. SIG.
PRE-CATALYTIC CONVERTER TEMP. SIG.
FUEL PRESSURE CTRL
DRIVER INPUT SIGNAL
AUTO GEARBOX TURBINE SPEED SENS. + SIG.
AUTO GEARBOX TURBINE SPEED SENS. - SIG
FREQ. AIR FLOW SENSOR SIGNAL A
FREQ. AIR FLOW SENSOR SIGNAL B
+5V SUPPLY CH VCC1
+5V SUPPLY CH VCC2
+5V SUPPLY CH VCC3
+5V SUPPLY CH VCC4
+5V SUPPLY CM VCC1
+5V SUPPLY CM VCC2
+5V SUPPLY CM VCC3
+5V SUPPLY CM VCC4
+5V SUPPLY CM VCC5
+5V SUPPLY CM VCC6
+5V SUPPLY CM VCC7
+5V SUPPLY CM VCC8
+5V SUPPLY CM VCC9
+5V SUPPLY CM VCC10
EARTH CH1 CMM
EARTH CH2 CMM
EARTH CH3 CMM
13D4
13D5
13D6
140
1400
1401
1402
1403
1404
1405
1406
1407
1408
1409
1410
1411
1412
1413
1414
1415
1416
1417
1418
1419
142
1420
1421
1422
1423
1424
1425
1426
1427
1428
1429
143
1430
1431
1432
1433
1434
1435
1436
1437
1438
1439
1440
1442
1443
1444
1445
1446
1447
1448
1449
145
1450
1451
1452
1453
1454
1455
1456
1457
1458
1459
COMPR. AIR TEMP. SIGNAL 2
COMPR. 2 INT. AIR TEMP/C EARTH
POWER SUPPLY VIA AIR PUMP RELAY
RECIRCULATION VALVE 2 SIGNAL
COMPRESSOR VALVE 2 SIGNAL
VVT1 SENSOR INPUT
VVT1 SENSOR OUTPUT
VVT2 SENSOR INPUT
VVT2 SENSOR OUTPUT
VVT SENSOR POWER SUPPLY
VVT SENSOR TIMING
VVT SENSOR EARTH
EXHAUST TEMP RECOV. PUMP POWER
SUPPLY.
1460 EXHAUST TEMP. RECOV. SV CTRL (RTE)
1461 RTE TEMPERATURE SWITCH SIGNAL
1462 PROPORTIONAL SENSOR (NERNST)
MEASUREMENT CELL VOLTAGE
1463 PROPORTIONAL SENSOR EARTH
1464 RTE COOLANT TEMP. SENSOR
1465 RTE COOLANT TEMP. SENSOR EARTH
1466 ACCELERAT. PEDAL POS 2 EARTH.
1467 TURBO AIR HEATER SV SUPPLY
1468 WASTEGATE/TURBO PRESSURE REG SV
SUPPLY
1469 DUAL MODE EXHAUST SV SUPPLY
1470 FUEL VOLUME REG/INJECTION PUMP SV
SUPPLY
1471 AUTO GEARBOX COOLING SV CTRL
1472 EGR BYPASS CONTROL SIGNAL
1473 EGR BYPASS POS. FEEDBACK SENSOR
SUPPLY
1474 EGR VALVE BYPASS POSITION FEEDBACK
SENSOR EARTH
1475 EGR VALVE BYPASS POS. FEEDBACK
SENSOR SIGNAL OUTPUT
14A0 FORCED PARTICLE FILTER REGENERATION
14A1 TURBO 2 POS. FEEDBACK SENSOR EARTH
14A2 TURBO 2 POS. FEEDBACK SENSOR SIGNAL
14A3 TURBO A CONTROL - SIGNAL
14A4 TURBO B CONTROL - SIGNAL
14A5 VAR. VALVE TIMING (VVT) ENGINE SUPPLY
14A6 VVT RELAY CONTROL
14A7 TURBO AIR HEAT. ELECTRO. CTRL
14A8 SYSTEM AIR COOLER EL. BYPASS + ENG. CTRL
14A9 SYSTEM AIR COOLER EL. BYPASS - ENG. CTRL
EARTH CH4 CMM
EARTH CH5 CMM
EARTH CH6 CMM
POWER SUPPLY VIA BSM POWER RELAY
DRIVER INPUT POTENTIOM. + SUPPLY.
DRIVER INPUT POTENTIOM. EARTH
DRIVER INPUT SIGNAL
ENGINE SPEED + SIGNAL
ENGINE SPEED - SIGNAL
TURBO 1 SV +5V POWER SUPPLY
TURBO 1 SV PWM CTRL
TURBOCHARGING 1 SV EARTH
TURBO 2 SV +5V POWER SUPPLY
TURBO 2 SV PWM CTRL
TURBOCHARGING 2 SV EARTH
TURBO 1 SV SENSOR SIGNAL
TURBO 2 SV SENSOR SIGNAL
PF PRESSURE SENSOR SIGNAL
PF PRESSURE SENSOR EARTH
PF PRESSURE SENSOR +5V POWER SUPPLY
TURBO. AIR HEAT. POS. FEEDBACK
SENSOR POWER SUPPLY.
TURBO. AIR HEAT. POS. FEEDBACK
SENSOR EARTH
TURBO. AIR HEAT. POS. FEEDBACK
SENSOR SIG.
TURBO POS. FEEDBACK SENSOR SIGNAL
TURBO A CTRL SIGNAL
TURBO POS. FEEDBACK SENSOR EARTH
TURBO POS. FEEDBACK SENSOR SIGNAL
AIR INLET HEAT. POS. FEEDBACK SENSOR
POWER SUPPLY
AIR INLET HEAT. POS. FEEDBACK SENSOR
EARTH
AIR INLET HEAT. POS. FEEDBACK SENSOR SIG.
TURBO A+B EARTH-PRE/POST UNIT
B- EGR MOTOR CTRL
UPSTREAM EXHAUST TEMP. SENSOR EARTH
UPSTREAM EXHAUST TEMP. SENSOR EARTH
FUEL RAIL PRESS. SENSOR EARTH
TURBO B CTRL SIGNAL
ECU CHECK INPUT
FUEL RAIL PRESSURE SENSOR POWER SUPPLY
UPSTREAM EXHAUST TEMP. SENSOR EARTH
DOWNSTREAM EXHAUST TEMP. SENSOR EARTH
INJECTORS 1-3 POWER SUPPLY
INJECTORS 2-4 POWER SUPPLY
TURBO AIR INLET PRESSURE SIGNAL
TURBO AIR INLET PRESSURE SENSOR
POWER SUPPLY
TURBO AIR INLET PRESS./C EARTH
DC MOTOR +
DC MOTOR -1441
TPS SIGNAL
COMPR. 2 INT. AIR PRESS. SIGNAL
COMPR. 2 INT. AIR PRESS/C EARTH
COMPR. 2 INT. AIR PRESS/C POWER SUPPLY
TURBO 1 WG SIGNAL
TURBO 2 WG VALVE SIGNAL
TURBO 2 BYPASS VALVE SV CTRL
COOLING
151
1510
1511
1512
1514
152
1552
1553
153
154
35
HIGH SPEED GMV CTRL
GMV 1 FUNCTIONING SIGNAL
HIGH/LOW SPEED GMV CTRL
AVERAGE/LOW SPEED GMV CTRL
GMV CTRL
LOW SPEED GMV CONTROL
TURBO-ALTERN. ADDIT. GMV CTRL
TURBO-ALTERN. ADDIT. GMV DIAG INFO
MID SPEED GMV SWITCH
GMV 1 CONTROL (+)
1540
155
1550
1551
1560
1561
1562
1570
1580
1581
1582
1583
1585
1586
1587
1588
1589
1590
1591
1592
1593
1595
1598
1599
GMV 1 CONTROL (-)
GMV 2 CONTROL (+)
GMV 2 CONTROL (-)
GMV 2 CONTROL SIGNAL (+)
COOLANT TEMP WARNING LIGHT SWITCH
COOLANT TEMP. INDIC. SWITCH
DEGASSING COOLANT SV CTRL
CONTROLLED THERMOSTAT CONTROL
TURBO COOLANT PUMP POWER SUPPLY
TURBO COOLANT PUMP CTRL
DISCONNECTABLE COOLANT PUMP
POWER SUPPLY
DISCONNECTABLE COOLANT PUMP CTRL
GMV SPEED SIGNAL
GMV FAULT SIGNAL
LH GMV POWER SUPPLY
RH GMV POWER SUPPLY
GMV MODULE POWER SUPPLY
GMV RELAY POWER SUPPLY
POST COOLING RELAY CTRL
LOW SPEED RELAY CONTROL
MID SPEED RELAY CONTROL
HIGH SPEED RELAY CTRL
COOLANT PUMP CTRL
GMV DIAGNOSTIC SIGNAL
1709
1710
1711
1712
1713
1714
1715
1716
1717
1718
1719
1720
1721
1722
1723
1724
GAS SUPPLY
1801
1802
1803
1804
1805
1806
1807
1808
1809
1810
1811
1812
CONTROLLED MANUAL GEARBOX
1600
1601
1602
1603
1604
1660
1661
1662
1663
1664
1665
1666
1667
1668
+ BVA 2 POS. SIGNAL
- BVA 2 POS. SIGNAL
BVA 2 POS. REF.
MOTOR 2 POS. SENSOR POWER SUPPLY
MOTOR 2 POS. SENSOR EARTH
CONTROLLED BVM PUSH BUTTON LED OUTPUT
CONTROLLED BVM INPUT SPEED + SIGNAL
CONTROLLED BVM INPUT SPEED - SIGNAL
SHIFT SENSOR FEEDBACK SIGNAL
SELECTION SENSOR FEEDBACK SIGNAL
CLUTCH SENSOR FEEDBACK SIGNAL
DOOR SWITCH BSI SIGNAL
AUTOMATIC MODE SWITCH SIGNAL
AUTOMATIC MODE SWITCH WARNING
LIGHT CTRL.
1669 CLUTCH 2 SENSOR FEEDBACK SIGNAL
1670 CONTROLLED BVM (BSI) OUTPUT
1813
1814
1815
1816
1817
1818
1819
1820
1821
1822
1825
1830
1831
1832
1833
1834
1835
ELECTRIC POWER SUPPLY
1700
1701
1702
1703
1704
1705
1706
1707
1708
ELEC. COOLANT PUMP RELAY CTRL
ELEC. COOLANT PUMP POWER SUPPLY
TRACTION BATTERY + TERMINAL
TRACTION BATTERY - TERMINAL
TOOL RD RESERVE
TOOL SD RESERVE
TRACTION BATTERY CONNECT. SIGNAL
EMERGENCY STOP SIGNAL
HIGH VOLTAGE RELAY CUT-OFF
EMERGENCY STOP EARTH
BODY ANGLE SENSOR POWER SUPPLY
BODY ANGLE SENSOR SIGNAL
BODY ANGLE SENSOR EARTH
TRACT. BATT. + AFTER IGNITION FEED CUT-OFF
FAST RECHARGE PUSH CONTROL
FAST RECHARGE WARNING LIGHT OUTPUT
DIFFERENTIAL SPEED SENSOR POWER SUPPLY
DIFFERENTIAL SPEED SENSOR SIGNAL
DIFFERENTIAL SPEED SENSOR EARTH
TRACTION CONTROL LEVER 1 SIGNAL
TRACTION CONTROL LEVER 1 EARTH
TRACTION CONTROL LEVER 2 SIGNAL
TRACTION CONTROL LEVER 2 EARTH
HEATER UNIT COOLANT PUMP RELAY CTRL
HEATER MATRIX COOLANT PUMP POWER
SUPPLY
1836
1837
1838
1839
1840
1841
1842
36
LPG WARNING LIGHT CTRL
LPG GENERAL RELAY CTRL
LPG GEN. RELAY SUPPLY INPUT
LPG INJECTOR SUPPLY
LPG ECU SUPPLY
LPG GAUGE + SIGNAL
LPG GAUGE EARTH
LPG SWITCH CTRL
LPG SWITCH LED CTRL
TANK SV CONTROL
EVAPORATOR SV CTRL
ABSOLUTE PRESSURE SENSOR POWER
SUPPLY
ABSOLUTE PRESSURE SENSOR SIGNAL
ABSOLUTE PRESSURE SENSOR EARTH
LPG SV POWER SUPPLY
No. 1 CYLINDER LPG INJECTOR CTRL
No. 2 CYLINDER LPG INJECTOR CTRL
No. 3 CYLINDER LPG INJECTOR CTRL
No. 4 CYLINDER LPG INJECTOR CTRL
LPG MAIN RELAY POWER SUPPLY OUTPUT
PETROL LOW PRESSURE RELAY POWER
SUPPLY
TDC SIGNAL
LPG THROTTLE POSITION SENSOR
GAS FILTERED INJECTORS SUPPLY
GAS INJECTORS RELAY CONTROL
GAS FAULT SIGNAL
GAS LEVEL SIGNAL
GAS RESERVOIR TEMP. INFO.
SOLENOID VALVE CONTROL
GAS EXPANSION VALVE
GAS RAIL SOLENOID VALVE CTRL
PETROL BOOSTER RELAY CTRL
GAS INJECTORS POWER SUPPLY
GAS TYPE SELECTION
(RICH OR LEAN)
GAS PRESS. SENSOR +5V SUPPLY
GAS PRESSURE SIGNAL
GAS TEMPERATURE SIGNAL
1843
1844
1845
1846
1847
1848
1849
1850
1851
1852
1853
1854
1855
1856
1857
1860
1861
1862
1863
1940
1941
1942
1943
1945
1946
CMAD SENSOR EARTH
START-ALT CTRL ECU SENSOR EARTH
BATTERY 42V EARTH
AUXILIARY 42V EARTH
ROTOR - EXCITATION
ELEC. MACHINE SENSOR POWER SUPPLY
EARTH
1947 BATTERY TEMPERATURE
GAS LEVEL SIGNAL
GAS CTRL COMMON
1/4 LEVEL GAS LED
AUTOMATIC GAS FUNCTION LED
GAS TANK CTRL
GAS SAFETY SV CONTROL
GAS INJECTOR RETURN
GAS TEMP./PRESS./LEVEL EARTH
GAS CTRL
2/4 LEVEL GAS LED
3/4 LEVEL GAS LED
4/4 LEVEL GAS LED
GAS ACTUATOR RELAY
GAS WARNING BUZZER
PETROL OPERATION SWITCH
No. 1 CYL. GAS INJECTOR CTRL
No. 2 CYL. GAS INJECTOR CTRL
No. 3 CYL. GAS INJECTOR CTRL
No. 4 CYL. GAS INJECTOR CTRL
EXTERNAL LIGHTING
20A0
20A5
20B5
200
201
202
203
205
2051
2052
2053
2055
2056
206
2060
2061
2062
2063
207
21A0
21A1
21A2
21A5
21B0
21B1
21B2
210
214
215
22A1
ALTERNATOR-STARTER
1900
1901
1902
1903
1904
1905
1906
1907
1910
1911
1912
1913
1914
1915
192
1920
1921
1922
1923
1924
1925
1926
1927
1928
1929
1930
1931
1932
1933
1934
1935
1936
1937
1938
1939
PARTIAL VOLTAGE REF. SIGNAL
PARTIAL VOLTAGE 1 SIGNAL
PARTIAL VOLTAGE 2 SIGNAL
PARTIAL VOLTAGE 3 SIGNAL
PARTIAL VOLTAGE 4 SIGNAL
BATTERY VENTILATION CTRL
HIGH VOLTAGE BATT. 1 TEMP. SIG.
HIGH VOLTAGE BATT. 2 TEMP. SIG.
NEUTRAL STATUS SIGNAL
ALTERNATOR-STARTER COOLANT TEMP. SIG.
CLUTCH PEDAL STATUS SIGNAL
BRAKE PRESSURE STATUS SIGNAL
ISOVAC PRESSURE SENSOR SIGNAL
ALTERNATOR-STARTER MONITORING ECU
SENSOR +5V
STOP GO STARTER SECURISATION
CMAD WAKE-UP SIGNAL
PROTECTION RELAY CONTROL
ELECTRIC MACHINE TEMP. SIG.
ELECTRIC MACHINE IDENTIFIC. SIG
STOP GO WARNING LIGHT CONTROL
STARTER ALTERNATOR COOLANT PUMP
CTRL
HEATER UNIT COOLANT PUMP CTRL
HIGH VOLTAGE BATT. BLOWER CTRL
STOP GO PUSH-BUTTON SIGNAL
STOP GO AUTHORISATION
ELEC. MACHINE PHASE U POWER SUPPLY
ELEC. MACHINE PHASE V POWER SUPPLY
ELEC. MACHINE PHASE W POWER SUPPLY
BATTERY + 42V
AUXILIARY + 42V
ROTOR + EXCITATION
ELEC. MACHINE U ROTOR POS.
ELEC. MACHINE V ROTOR POS.
ELEC. MACHINE W ROTOR POS.
ELECT. MACHINE SENSOR +5V SUPPLY
22A2
22A3
2100
2101
2102
2103
220
221
222
2200
2201
2202
2203
230
231
232
37
TRAILER FOG LIGHTS CTRL
TRAILER REAR LH FOG LIGHTS SUPPLY
TRAILER REAR RH FOG LIGHTS SUPPLY
FOG LIGHTS CONTROL
FOG LIGHTS POWER SUPPLY
RH BLIND OUTPUT
LH BLIND OUTPUT
FOG LIGHTS RELAY CTRL
REAR FOG LIGHT SIGNAL (BSI)
REAR LH FOG LIGHT POWER SUPPLY
REAR RH FOG LIGHT POWER SUPPLY
BOOT/HATCH FOG LIGHT OUTPUT
BOOT/HATCH RR LH FOG LIGHT OUTPUT
FOG LIGHTS CTRL
FR LH FOG LIGHTS CTRL
FR RH FOG LIGHTS CTRL
FR LH FOG LIGHTS POWER SUPPLY
FR RH FOG LIGHTS POWER SUPPLY
FOG LIGHT WARNING LIGHT CTRL
TRAILER RH BRAKE LIGHTS CTRL
TRAILER BRAKE LIGHTS CONTROL
TRAILER PRESENCE POWER SUPPLY
TRAILER ADD. BRAKE LIGHTS POWER SUPPLY
TRAILER LH BRAKE LIGHTS CTRL
TRAILER BRAKE LIGHTS POWER SUPPLY
TRAILER BRAKE LIGHTS POWER SUPPLY AUTH
BRAKE LIGHTS CTRL
ADD. BRAKE LIGHTS CTRL. (BSI)
ADD. BRAKE LIGHTS POWER SUPPLY
TRAILER LH REVERSING LIGHTS POWER
SUPPLY
TRAILER RH REVERSING LIGHTS POWER
SUPPLY
TRAILER REVERSING LIGHTS CONTROL
RR RH BRAKE LIGHTS CTRL (BSI)
RR LH BRAKE LIGHTS CTRL (BSI)
RR RH BRAKE LIGHTS POWER SUPPLY
RR LH BRAKE LIGHTS POWER SUPPLY
REVERSING LIGHT CONTROL
RR LH REVERSING LIGHTS POWER SUPPLY
RR RH REVERSING LIGHTS POWER SUPPLY
REVERSING LIGHTS POWER SUPPLY (BSI)
HATCH/BOOT RH REV. LIGHT OUTPUT
HATCH/BOOT LH REV. LIGHT OUTPUT
REVERSING LIGHT SIGNAL OUTPUT
DIRECTION INDICATOR CTRL
INDICATOR CONTROL
LH INDICATOR CONTROL
233
234
240
2400
2401
2405
241
242
250
2500
2501
2502
25
252
2530
2531
2532
2533
254
2550
2555
2558
2559
2570
2571
260
2600
2601
2602
2603
2604
2605
2606
2607
261
262
263
26A3
26A4
26B3
26B4
2631
264
2640
2641
2642
265
2650
266
2660
270
2700
2701
2702
2705
2706
2707
2708
2709
2710
271
2715
2716
272
273
275
276
277
278
279
2809
280
2801
2802
2803
281
282
283
284
RH INDICATOR CONTROL
DRIVING SCHOOL INDICATOR CTRL
DAYTIME RUNNING LIGHTS CTRL
FR LH DAYTIME RUNNING LIGHT CTRL
DAYTIME RUNNING LIGHT SIGNAL
FR RH DAYTIME RUNNING LIGHT CTRL
FLASHING ROOF LIGHT CTRL
RONDO LIGHTS CTRL
HORN CONTROL
LOW-PITCHED HORN CTRL
HIGH-PITCHED HORN CTRL
PEDESTRIAN HORN CTRL
HORN RELAY CTRL
HORN SIGNAL (BSI)
POLICE SIREN + POWER SUPPLY
POLICE SIREN - POWER SUPPLY
POLICE SIREN MODULE + POWER SUPPLY
POLICE SIREN MODULE - POWER SUPPLY
SIREN RELAY CTRL
SIREN CONTROL (JACK)
SIREN CTRL
INPUT DAY/NIGHT SIREN SIGNAL
OUTPUT DAY/NIGHT SIREN SIGNAL
JACK PLUG + CONTROL
JACK PLUG - CONTROL
SIDE LIGHTS CTRL
AUTOM. HEADLIGHTS SAFETY REL. CTRL
LH SIDE LIGHTS CTRL
RH SIDE LIGHTS CTRL
FR LH SIDE LIGHTS CTRL
FR RH SIDE LIGHTS CTRL
FR LH LAT. SIDE LIGHTS CTRL
FR RH LAT. SIDE LIGHTS CTRL
FR LAT. SIDE LIGHTS CTRL
FR LH SIDE LIGHTS POWER SUPPLY
FR RH SIDE LIGHTS POWER SUPPLY
RR LH SIDE LIGHTS POWER SUPPLY
TRAILER REAR LH POS. LIGHTS SUPPLY
TRAILER REAR RH POS. LIGHTS SUPPLY
BTC OUTPUT LH POSITION LIGHT
BTC OUTPUT RH POSITION LIGHT
SIDE LIGHT RETURN
RR RH SIDE LIGHTS POWER SUPPLY
TRAILER LIGHT RELAY CTRL
SIDE LIGHT RETURN
RR ADD. SIDE LIGHT OUTPUT (BSI)
SWITCH + SIDE LIGHT POWER SUPPLY
SWITCH + SIDE LIGHT POWER SUPPLY
WITHOUT RHEOSTAT
DRIVING SCHOOL SIDE LIGHTS CTRL
PEDAL ACTIVATION ACQUISITION
DIPPED BEAM CTRL
INTER HEADLIGHTS COMMUNICATION
LH DIPPED BEAM CTRL
RH DIPPED BEAM CTRL
LH STATIC TURNING LIGHT CTRL
RH STATIC TURNING LIGHT CTRL
LH ANGLED LIGHT CTRL
LH ANGLED LIGHT EARTH
285
286
287
288
289
29A0
290
2900
2901
2905
291
292
293
2930
2931
2932
2933
2934
2935
294
295
296
2960
2961
RH ANGLED LIGHT CTRL
RH ANGLED LIGHT EARTH
LH DIPPED BEAM POWER SUPPLY
LH STATIC TURNING LIGHT EARTH
RH STATIC TURNING LIGHT EARTH
RH DIPPED BEAM POWER SUPPLY
DRIVING SCHOOL DIPPED BEAM CTRL
HEADLIGHT LEVELLER + CTRL.
HEADLIGHT LEVELLER POS. CTRL
HEADLIGHT LEVELLER - CTRL
HEADLIGHT LEVELLER POWER SUPPLY
HEADLIGHT LEVELLER + MODULE VIA RELAY
TRAILER REAR LH DIRECTION INDICATOR CTRL
HEADLIGHT MAIN BEAM CTRL
LH HEADLIGHT MAIN BEAM CTRL
RH HEADLIGHT MAIN BEAM CTRL
HEADLIGHT MAIN BEAM POWER SUPPLY
LH HEADLIGHT MAIN BEAM POWER SUPPLY
RH HEADLIGHT MAIN BEAM POWER SUPPLY
ADDITIONAL HEADLIGHT CTRL
DRIVING SCHOOL HEADLIGHT MAIN BEAM
CTRL
LH SIDE REPEATER OUTPUT (BSI)
RH SIDE REPEATER OUTPUT (BSI)
FR LH DIRECTION INDICATOR OUTPUT (BSI)
FR RH DIRECTION INDICATOR OUTPUT (BSI)
RR LH DIRECTION INDICATOR OUTPUT (BSI)
TRAILER REAR RH DIRECTION INDICATOR CTRL
RR RH DIRECTION INDICATOR OUTPUT (BSI)
FR BUMPER SIDE MARKER OUTPUT (SIDE-MA.)
RR BUMPER SIDE MARKER OUTPUT (SIDE-M)
NUMBER PLATE LIGHTS ( BSC )
LH INDICATOR LIGHT CLUSTER OUT. (BSI)
RH INDICATOR LIGHT CLUSTER OUT. (BSI)
LH SIDE INDICATORS STEERING COL.
INPUT (BSI)
RH/LH DIRECTION INDICATOR CTRL (BSI)
FR/RR FOG LIGHTS CTRL (BSI)
DIPPED/MAIN BEAM SWITCH CTRL (BSI)
NAV. SCREEN LIGHTING CUT-OFF CTRL (BSI)
CUT-OFF EARTH (BSI)
BSI EARTH
RH SIDE INDICATORS STEERING COL. INPUT (BSI)
HAZARD LIGHTS SWITCH INPUT
HAZARD LIGHTS SWITCH INDICATOR OUTPUT
HAZARD LIGHTS SIGNAL INDICATOR INFO
HAZARD LIGHTS CTRL
HORNS
250
2500
2501
251
252
2530
2531
2532
2533
38
HORN CTRL
LOW NOTE HORN
HIGH NOTE HORN
HORN RELAY CONTROL
HORN SIGNAL (BSI)
POLICE SIREN + POWER SUPPLY
POLICE SIREN - POWER SUPPLY
POLICE SIREN MODULE + POWER SUPPLY
POLICE SIREN MODULE - POWER SUPPLY
254
2550
2555
2558
2559
2570
2571
319
3190
3191
3192
320
321
3210
3211
SIREN RELAY CTRL
SIREN CONTROL (JACK)
SIREN CTRL
INPUT DAY/NIGHT SIREN SIGNAL
OUTPUT DAY/NIGHT SIREN SIGNAL
JACK PLUG + CONTROL
JACK PLUG - CONTROL
INTERIOR LIGHTING
300
3000
3001
3002
3003
3004
3005
3006
3007
3008
3009
301
3010
3011
3012
3013
3014
3015
3016
3017
3018
302
3020
3021
3022
3023
3024
3025
3026
3027
303
3030
3035
3050
3051
3060
3061
3062
3063
3064
3065
310
318
BOOT LIGHTING CTRL
BOOT LIGHTING POWER SUPPLY
MOVEABLE BOOT LIGHT CTRL
BOOT CLOSED PUSH-BUTTON LIGHT CTRL
LH VANITY MIRROR POWER SUPPLY
LH VANITY MIRROR EARTH
RH VANITY MIRROR POWER SUPPLY
RH VANITY MIRROR EARTH
ENGINE FUEL OIL COOLANT SIGNAL
FRONT COURTESY LIGHT SWITCH
FR LH DOOR SILL LIGHTING CTRL
FR RH DOOR SILL LIGHTING CTRL
FOOTWELL LIGHTING POWER SUPPLY
FR SILL LIGHTS POWER SUPPLY
RR SILL LIGHTS POWER SUPPLY
FR FOOTWELL LIGHTING POWER SUPPLY (BSI)
RR FOOTWELL LIGHTING POWER SUPPLY (BSI)
LH REAR VIEW MIRROR SILL LIGHTING CTRL
RH REAR VIEW MIRROR SILL LIGHTING CTRL
AMBIENT LIGHTING PUSH-BUTTON
COURTESY LIGHT TIMER + CTRL
AMBIENT LIGHTING - PUSH-BUTTON
EARTH INT. LIGHT MODULE OUTPUT
+ACC INT. LIGHT MODULE OUTPUT
INSET LIGHTING OUTPUT
ROOF LIGHTING OUTPUT
DASHBOARD LIGHTING OUTPUT
UNDER-DASHBOARD LIGHTING OUTPUT
AMBIENT LIGHTING INHIBIT REQUEST
EXT. SIDE LIGHTS CTRL
FR/RR COURTESY LIGHTS CTRL
REAR COURTESY LIGHTS CTRL
REAR COURTESY LIGHT SIGNAL
DRIVER'S STORAGE TRAY LIGHT CONTROL
PASSENGER STORAGE TRAY LIGHT CONTROL
DRIVER'S DOOR INSET LIGHTING CONTROL
PASSENGER DOOR INSET LIGHTING CONTROL
DRIVER'S DOOR INT OPENING LIGHT CONTROL
PASSENGER DOOR INT OPENING LIGHT
CONTROL
FR COURTESY LIGHT SIGNAL
CENTRAL COURTESY LIGHTS CTRL
FRONT COURTESY LIGHT SIGNAL/
EXTINCTION
LIGHTING DIMMER + SIGNAL
LIGHTING DIMMER - SIGNAL
LH HEATING PANEL PUSH-BUTTON LIGHT CTRL
RH HEATING PANEL PUSH-BUTTON LIGHT CTRL
RR LH HEATING PANEL PUSH-BUTTON
LIGHT CTRL
RR RH HEATING PANEL PUSH-BUTTON
LIGHT CTRL
FR LH HEATING PANEL PUSH-BUTTON
LIGHT CTRL
FR RH HEATING PANEL PUSH-BUTTON
LIGHT CTRL
GLOVE BOX LIGHTING CTRL
HATCH LIGHTING CTRL
400
4000
401
402
4020
403
4030
4031
4035
404
405
406
410
411
412
4120
4121
4122
4123
413
414
415
416
4150
4200
4201
421
4210
422
430
431
4310
4311
4312
4315
4316
432
433
434
435
4398
4399
COOLANT TEMPERATURE SIGNAL
COOLANT TEMPERATURE SENSOR EARTH
COOLANT TEMPERATURE SIGNAL
COOLANT LEVEL SIGNAL
ENGINE COOLANT LEVEL INPUT
WATER IN DIESEL DETECTION SIGNAL
DIESEL TEMP. SENSOR EARTH
WATER IN DIESEL DETECT. EARTH
WATER IN DIESEL DETECT. POWER SUPPLY
COOLANT TEMP. PRE-WARNING SIGNAL
COOLANT TEMP. WARNING CTRL
EGR A AND EGR B EARTH
MIN. OIL PRESSURE SIGNAL
OIL TEMPERATURE SIGNAL
OIL PRESSURE SIGNAL
OIL PRESSURE REGULATION SOLENOID
VALVE CONTROL
REGULATED OIL PUMP CTRL
OIL PRESSURE + 5V SIGNAL
ENGINE OIL PRESSURE SENSOR EARTH
MAX. OIL TEMPERATURE SIGNAL
OIL LEVEL SIGNAL
OIL LEVEL - SIGNAL
OIL TEMP./LEVEL REFERENCE
ENGINE OIL LEVEL ANALOG. EARTH
CAP OPEN INPUT SIGNAL
CAP OPEN OUTPUT SIGNAL
FUEL FILLER CAP OPEN SIGNAL
FUEL FILLER FLAP PUSH-BUTTON INPUT (BSI)
FUEL PRESSURE SENSOR SIGNAL
FUEL MIN. LEVEL SIGNAL
FUEL CUT-OFF CTRL
FUEL FILLER CAP INPUT (BSI)
INERTIA SWITCH INPUT (BSI)
FUEL ANALOG. EARTH INPUT (BSI)
FUEL GAUGE ANALOG. EARTH
BSI FUEL FILLER CAP ANALOG. EARTH OUTPUT
FUEL CUT-OFF SIGNAL
FUEL GAUGE 1 SIGNAL
FUEL GAUGE 2 SIGNAL
LPG FUEL GAUGE SIGNAL
SUPPLIER 1 DIAGNOSTIC
SUPPLIER 2 DIAGNOSTIC
BRAKING
440
441
39
HANDBRAKE SIGNAL
HYD. CIRC. BRAKE FLUID HANDBRAKE SIG.
4411
442
4420
4425
4430
4431
4432
4433
444
4440
4441
445
4450
4451
446
4460
4461
447
448
4481
4482
HANDBRAKE SWITCH SIGNAL
BRAKE FLUID LEVEL SIGNAL
EL. STATION BRAKE PUSH-BUTTON INPUT
EL. STATION BRAKE PUSH-BUTTON LIGHT CTRL
ELECTRIC HANDBRAKE 1 CTRL
ELECTRIC HANDBRAKE 2 CTRL
ELECTRIC HANDBRAKE 3 CTRL
ELECTRIC HANDBRAKE 4 CTRL
BRAKE PAD WEAR
BRAKE LIGHT BULB BLOWN WARNING SIGNAL
BRAKE PAD WEAR SIGNAL
FR LH PAD WEAR SIGNAL
INT. FR LH PAD WEAR SIGNAL
EXT. FR LH PAD WEAR SIGNAL
FR RH PAD WEAR SIGNAL
INT. FR RH PAD WEAR SIGNAL
EXT. FR RH PAD WEAR SIGNAL
RR LH PAD WEAR SIGNAL
RR RH PAD WEAR SIGNAL
EL. BRAKE CALLIPER ACTUATOR CTRL
EL. HANDBRAKE ACTUATOR CTRL
ELECTRIC WINDOWS
60A1
60A2
60A3
60A4
60A5
60A6
60A7
6000
6001
6002
6003
6004
6005
6006
6007
6008
6010
6011
6012
6013
6015
6016
6017
6018
6020
6021
6022
6023
6024
6025
603
6030
6031
6032
6033
6034
6035
6036
6037
6038
6039
604
6041
6042
6045
6046
6050
6052
6053
6054
6060
6061
6062
6063
6064
607
6070
WASH/WIPE
500
501
5010
5013
5014
502
503
505
506
5060
507
508
509
510
511
512
520
5200
5201
521
522
526
5261
5262
5263
5264
5265
530
531
540
542
5420
LOW SPEED MOTOR CTRL
HIGH SPEED MOTOR CTRL
WIPER MOTOR SWITCH COMMUN.
FRONT LH WIPER POWER SUPPLY
FRONT RH WIPER POWER SUPPLY
WIPER PARK CONTROL
MOTOR PARK CONTROL
INTERMITTENCE CONTROL
LOW SPEED FR WIPER SIGNAL
FR WIPER MOTOR SIGNAL
HIGH SPEED FR WIPER SIGNAL
HIGH SPEED RELAY CTRL
MOTOR CONTROL VIA RELAY
FRONT WASHER PUMP CONTROL
FRONT WASHER PUMP SIGNAL
WASHER MIN. WATER LEVEL SIGNAL
REAR SCREEN WIPER CONTROL
RR LH WIPER MOTOR CONTROL
REAR WIPER POWER SUPPLY
RR WIPER MOTOR CTRL
RR WIPER MOT. PARK CTRL
REAR WIPER SIGNAL
LOW/HIGH SPEED LOW.RAIN SENS.LINK
INPUT (BSI)
RAIN SENSOR POWER SUPPLY OUTPUT (BSI)
WIPER MOT. AF SIG. RAIN SENSOR
OUTPUT (BSI)
SENSOR RAIN QUANTITY INPUT (BSI)
FRONT WIPER RELAY OUTPUT
REAR WASHER PUMP CTRL
REAR WASHER PUMP SIGNAL
HEADLIGHT WASHER WATER MIN.
WARNING LIGHT CTRL.
HEADLIGHT WASHER PUMP CONTROL
HEADLIGHT WASHER PUMP RELAY CTRL.
40
FRONT RH ELECTRIC WINDOW RAISE CTRL
FRONT RH ELECTRIC WINDOW LOWER CTRL
FRONT LH ELECTRIC WINDOW RAISE CTRL
FRONT LH ELECTRIC WINDOW LOWER CTRL
PASS ELECTRIC WINDOW RAISE CTRL
PASS ELECTRIC WINDOW LOWER CTRL.
CENTRAL. ELEC. WINDOW CONT SUPPLY
DR ONE-TOUCH ELECTRIC WINDOW SIGNAL
FR RH WINDOW SWITCH POWER SUPPLY
FR LH CONTROL PANEL SHUNT (RH/LH DRIVE SEL.)
DR WINDOW TORQUE SENSOR SIGNAL
DR WINDOW POS. SENSOR SIGNAL
FR RH WINDOW SWITCH LIGHTING
DRIVER'S CONTROL PANEL LIGHTING + CTRL
DRIVER'S CONTROL PANEL - CONTROL
RR WINDOW INHIBIT SIGNAL
DR WINDOW LIFT SIGNAL
DR WINDOW LIFT CTRL
DRIVER OT WINDOW OUTPUT (BSI)
PASSENGER OT/EL WINDOW OUTPUT.
ELEC. WINDOW CTRL VIA RELAY
MULTIPLEX LH DOOR PANEL AUTH.
SIGN LH DOOR PANEL AUTH.
FR ONE-TOUCH ELEC. WINDOWS REMOTE
DR ELECTRIC WINDOW LOWER SIGNAL
DR ELECTRIC WINDOW LOWER CTRL
FR LH ELECTRIC WINDOW ANALOGUE SIG.
FR RH ELECTRIC WINDOW ANALOGUE SIG.
RR LH ELECTRIC WINDOW ANALOGUE SIG.
RR RH ELECTRIC WINDOW ANALOGUE SIG.
RR MICRO-LOWER ANTICIP. UNIT (BSI)
PASS ELEC. WINDOW SWITCH RAISE SIG.
PASS ELEC. WINDOW SWITCH LOWER SIG.
RR LH ELEC WINDOW SWITCH RAISE SIGNAL
RR LH ELEC WINDOW SWITCH LOWER SIGNAL
RR RH ELEC WINDOW SWITCH RAISE SIGNAL
RR RH ELEC WINDOW SWITCH LOWER SIGNAL
RR LH MICRO-LOWER REQ SIG.
RR RH MICRO-LOWER REQ SIG.
FR LH MICRO-LOWER REQ SIG.
FR RH MICRO-LOWER REQ SIG.
FR LH ELECTRIC WINDOW CTRL
FR LH ELECTRIC WINDOW AUTOM. CTRL
LH ELEC. WINDOW LOWER SIGNAL
LH MICRO-LOWER REQ SIGNAL
RH MICRO-LOWER REQ.
RH ONE-TOUCH ELEC. WINDOW SIG.
LH ELEC. WINDOW RAISE SIGNAL
RH ELECTRIC WINDOW TORQUE SENSOR SIGNAL
RH ELECTRIC WINDOW POS. SENSOR SIGNAL
RH ELECTRIC WINDOW RAISE SIGNAL
RH ELECTRIC WINDOW RAISE CTRL
PASS ELECTRIC WINDOW RAISE VIA DR SIGNAL
CENTRAL WINDOW RAISE SIGNAL
CENTRAL WINDOW LOWER SIGNAL
JOINT LH ELEC. WINDOW CTRL
PASS ELECTRIC WINDOW LOWER SIGNAL
6071 PASS ELECTRIC WINDOW LOWER CTRL
6072 PASS ELECTRIC WINDOW LOWER VIA DR
SIGNAL
608 FR RH ELECTRIC WINDOW CONTROL
6081 PASS. ELECTRIC WINDOW AUTO CTRL
6082 RH ELECTRIC WINDOW RAISE SIGNAL
6092 RH ELECTRIC WINDOW LOWER SIGNAL
610 REAR FUNCT. CENTRAL LOCKING CTRL
6100 RR LH 1-TOUCH WINDOW SIGNAL
6101 REAR ELEC. WINDOW POWER SUPPLY VIA
INHIB. RELAY
6102 RR ELECTRIC WINDOW INHIBIT CTRL
6103 RR LH ELEC. WINDOW TORQUE SENSOR
SIGNAL
6104 RR LH ELECTRIC WINDOW POS. SENSOR
SIGNAL
6105 BSI EW CENTRAL CLOSING CTRL
6110 RR LH ELECTRIC WINDOW RAISE SIGNAL
6111 RR LH ELECTRIC WINDOW RAISE CTRL
6112 RR LH ELECTRIC WINDOW RAISE SIGNAL
6120 RR LH ELECTRIC WINDOW LOWER SIGNAL
6121 RR LH ELECTRIC WINDOW LOWER CTRL
6122 RR LH ELECTRIC WINDOW LOWER SIGNAL
VIA DR
614 RR LH ELECTRIC WINDOW CTRL
6150 RR RH ONE-TOUCH ELECTRIC WINDOW
SIGNAL
6153 RR RH ELEC. WINDOW TORQUE SENSOR
SIGNAL
6154 RR RH ELECTRIC WINDOW POS. SENSOR
SIGNAL
6160 RR RH ELECTRIC WINDOW RAISE SIGNAL
6161 RR RH ELECTRIC WINDOW RAISE CTRL
6162 RR RH ELECTRIC WINDOW RAISE SIGNAL
VIA DR
6163 ELECTRIC WINDOW POWER SUPPLY
617 COMMON RH ELEC. WINDOW CTRL
6170 RR RH ELECTRIC WINDOW LOWER SIGNAL
6171 RR RH ELECTRIC WINDOW LOWER CTRL
6172 RR RH ELECTRIC WINDOW LOWER SIGNAL
VIA DR
6173 BSI SUNROOF AND FR ELEC. WINDOW
SUPPLY OUTPUT
6174 RR ELEC. WINDOW CTRL VIA RELAY
6175 RR ELEC. WINDOW POWER SUPPLY (BSI)
6176 RR ELEC. WINDOW SWITCH OUTPUT (BSI)
6177 LH RR OT WINDOW RAISE OUTPUT (BSI)
6178 RH RR OT WINDOW RAISE OUTPUT (BSI)
6179 LH RR OT WINDOW LOWER OUTPUT (BSI)
618 RR RH ELECTRIC WINDOW CTRL
6180 RH RR OT WINDOW LOWER OUTPUT (BSI)
6181 OT WINDOW RR SWITCH OUTPUT (BSI)
6182 CONTROL PANEL/RR OTEW OUTPUT (BSI)
6183 RR INHIBIT INPUT (BSI)
6184 OT WINDOW FR SWITCH OUTPUT (BSI)
619 ELEC. WINDOWS CENTRAL OPENING
CLOSING
6190 REAR ELEC. WINDOW + HYDR. PUMP
POWER SUPPLY
6191
62A0
62A1
620
6200
6201
6202
6203
6204
6205
6206
6207
6208
6209
621
6210
6211
6212
6213
6214
6215
6216
6217
6218
6219
622
6220
6221
6222
6223
6224
6225
6226
6227
6228
6229
623
6230
6231
6232
6233
6234
6235
6236
6237
6238
6239
624
6240
6241
6242
6243
6244
6245
41
HP + EW FOLDING ROOF MOD. OUTPUT
CENTRAL LOCKING HF AER SUPPLY
CENTRAL LOCKING HF AER EARTH
CHILD SAFETY CTRL
DOOR OPEN WARNING LIGHT SIGNAL
FUEL FILLER FLAP OPEN INPUT (BSI)
FUEL FILLER FLAP OPEN OUTPUT (BSI)
FR LH EXT. MOT. CTRL
EXTERIOR MOTOR CTRL
LOCK COMMON CTRL
INTERIOR MOTOR CTRL
RR EXT. MOT. CTRL
RR LOCK COMMON CTRL
CHILD SAFETY/INT. MOT. CTRL
REAR SCREEN + BOOT LOCK PUSHBUTTON INPUT
BOOT ACTUATOR CTRL
REAR SCREEN ACTUATOR CTRL
BOOT CATCH CTRL SIGNAL
BOOT LOCK UNLOCKED SIGNAL
RETURN BOOT CATCH SIGNAL
DIAGNOSTIC LINE
BOOT OPENING OUTPUT
CENTRAL LOCKING INFO.
CENTRAL LOCK WARNING LIGHT OUTP.
ENGINE IMMOBILISER + CTRL
DEADLOCKING + CTRL
MOTOR CATCH RELAY OUTPUT
DOOR DEADLOCKING INPUT O
LH ENGINE CATCH CTRL
RH ENGINE CATCH CTRL
A1 REMOTE INPUT/LOCKING INPUT
HF RECEIVER BSI SERIAL LINK
LH CATCH SWITCH
RH CATCH SWITCH
BOOT PUSH-BUTTON SIGNAL
BOOT + OPENING CTRL
CENTRAL UNLOCKING SIGNAL
FR LH CENTRAL LOCKING INPUT +
UNLOCK. STATUS
FR RH CENTRAL LOCKING INPUT +
UNLOCK. STATUS
FR LH LOCK POS. INFO. +LOCK. STATUS
FR RH LOCK POS. INFO. +LOCK. STATUS.
AUTO LOCK INHIBIT CTRL
AUTO LOCK INHIBIT INFO.
AUTO LOCK INHIBIT WARNING LIGHT OUTP.
LH DOOR SENSOR + POWER SUPPLY
LH DOOR SENSOR - POWER SUPPLY
LH DOOR S1 SIGNAL
DOOR PRESENT CONTACT
LH DOOR S2 SIGNAL
LH DOOR + BRAKE
LH DOOR - BRAKE
LH SLIDING SIDE DOOR OPENING MOTOR
CTRL
LH SLIDING SIDE DOOR CLOSING MOTOR
CTRL
DIAGNOSTIC SIGNAL
6246
6247
6248
6249
625
6250
6291
6292
6293
6294
6295
6296
6297
6298
6299
LH SLIDING SIDE DOOR CLOSING CTRL
LH SLID.SIDE DOOR INTEG.SW.LOCK SIGNAL
RH SLID.SIDE DOOR INTEG.SW.LOCK SIGNAL
LH SLID.SIDE DOOR END.OPEN.SW.SIGNAL
RH SLID.SIDE DOOR OPENING CTRL
RR RH DOOR CHILD SAFETY SIGNAL
CENTRAL LOCKING
6251 RR LH DOOR CHILD SAFETY SIGNAL
6252 RH SLID.SIDE DOOR OPENING MOTOR CTRL
6253 RH SLID.SIDE DOOR CLOSING MOTOR
CTRLSLID.SIDE DOOR
6254 LH SLID.SIDE DOOR CLOS./OP. FR LH
PUSH-BUTTON SIGNAL
6255 RH SLID.SIDE DOOR CLOS./OP. FR RH
PUSH-BUTTON SIGNAL
6256 LH SLID.SIDE DOOR CLOS./OP. RR LH
PUSH-BUTTON SIGNAL
6257 RH SLID.SIDE DOOR CLOS./OP. RR RH
PUSH-BUTTON SIGNAL
6258 LH SSD LOCK OPEN ACTUATOR
6259 RH SSD LOCK OPEN ACTUATOR
626 WINDOW CLOSE CTRL
6260 DOORS OPEN INFORMATION
6261 RH DOOR SENSOR + POWER SUPPLY
6262 RH DOOR SENSOR - POWER SUPPLY
6263 RH DOOR S1 SIGNAL
6264 RH DOOR S2 SIGNAL
6265 RH DOOR + BRAKE
6266 RH DOOR - BRAKE
6267 FR LH CPO INFO.
6268 FR RH CPO INFO.
6269 LOCK STATUS + LOCK POS. INFO.
627 IR RECEIVER CENTRAL LOCKING CTRL
6270 HF RECEIVER CENTRAL LOCKING/
UNLOCKING CTRL
6271 REAR SCREEN + BOOT OPEN + CTRL AUTH.
6272 RH SSD END OF OPENING SWITCH SIGNAL
6273 RH DOOR OPENING BACKUP CTRL
6274 RH DOOR CLOSING BACKUP CTRL
6275 HF RECEIVER DEADLOCKING CTRL
6276 DEADLOCKING STATUS
6277 CHILD SAFETY WARNING LIGHT SIGNAL
6278 RH SSD CLOSING CTRL
6279 CHILD SAFETY RELAY OPEN OUTPUT
628 IR RECEIVER UNLOCKING CTRL
6280 FR LH OPEN DOOR SWITCH INPUT (MDP)
6281 TAILGATE CLOSED SWITCH INPUT (BSI)
6282 BOOT OPEN EXT. SWITCH SIGNAL
6283 BOOT OPENING DOOR SWITCH INPUT
6284 BOOT ISOLATION INPUT (BSI)
6285 FR RH OPEN DOOR SWITCH INPUT (MDP)
6286 FR LH EXT. OPENING SENSOR SIGNAL
6287 OPENING RR RH DOOR SWITCH INPUT. (BSI)
6288 OPENING RR LH DOOR SWITCH INPUT. (BSI)
6289 FR RH EXT. OPENING SENSOR SIGNAL
629 CHILD SAFETY PUSH-BUTTON
6290 REAR SCREEN CLOSING CTRL
FR LH CENTRAL LOCKING INPUT (SSD)
FR RH CENTRAL LOCKING INPUT (SSD)
LOCK. STATUS + RR LOCK POS. SIGNAL.
FR LH LOCKING BUTTON CTRL
FR RH LOCKING BUTTON CTRL
VEHICLE PROTECTION WARNING LIGHT CTRL (BSI)
HATCH/REAR SCREEN OPEN INPUT
TILTING SCREEN CENTRAL LOCKING
REAR SCREEN OPENING CTRL
HEATED SEATS
6300
6301
6302
6303
6304
6305
6306
6307
6308
6309
6310
6311
6312
6313
6314
6315
63A1
63A2
63A3
63A4
63A5
63A6
63A7
63A8
63A9
63B1
63B2
63B3
63B4
63B5
63B6
63B7
63B8
63B9
63C1
63C2
63C3
63C4
63C5
63C6
42
FR LH SEAT BELT INFO.
FR RH SEAT BELT INFO.
FR LH ELECTRIC SEAT POWER SUPPLY
FR RH ELECTRIC SEAT POWER SUPPLY
REAR PASS. SEAT BELT INFO.
CENTRAL RR SEAT BELT INFO.
RR LH SEAT BELT INFO.
RR RH SEAT BELT INFO.
FR LH SEAT BELT INFO.
FR RH SEAT BELT INFO.
SEAT BELT INFO.
DR RUNNER POS. INFO.
DR FR SEAT CUSHION POS. INFO.
RD RR SEAT CUSHION POS. INFO.
DR BACKREST POS. INFO.
RR LH 3RD ROW
SEAT BELT INFO.
REAR SEATS UNLOCK PUSH BUTTON SUPPLY
RR RH SEAT UNLOCKING CTRL
RR LH SEAT UNLOCKING CTRL
REAR RH SEAT UNLOCK ACTUATOR CTRL.
RR RH SEAT UNLOCKING ACTUATOR RETURN
RR LH SEAT UNLOCKING ACTUATOR CTRL
RR LH SEAT UNLOCKING ACTUATOR RETURN
FR LH HEATED SEAT CTRL
FR RH HEATED SEAT CTRL
DRIVER'S SEAT MASSAGE CTRL
DRIVER'S SEAT MASSAGE INDICATOR LIGHT CTRL.
INTERIOR STORAGE COMPARTMENTS
LOCKING CTRL
INTERIOR STORAGE COMPARTMENTS
UNLOCKING CTRL
INT. STORAGE COMPARTMENTS LOCK REL. CTRL.
DRIVER'S NECK-LEVEL HEATING RHEOSTAT
SUPPLY
PASSENGER'S NECK-LEVEL HEATING
RHEOSTAT SUPPLY
DRIVER'S NECK-LEVEL HEATING RHEOSTAT
SIGNAL
PASSENGER'S NECK-LEVEL HEATING
RHEOSTAT SIGNAL
NECK-LEVEL HEATING OP. AUTHORISATION
LSB NECK-LEVEL HEATING LOAD-SHEDDING
MSB NECK-LEVEL HEATING LOAD-SHEDDING
SEAT 1 RH SEAT BELT FASTENING + SIGNAL
SEAT 1 RH SEAT BELT FASTENING - SIGNAL
SEAT 1 LH SEAT BELT FASTENING + SIGNAL
63C7
63C8
63C9
63D1
63D2
63D3
63D4
63D5
63D6
63D7
63D8
63D9
63E1
63E2
63E3
63E4
63E5
63E6
63E7
63E8
63F1
63F2
6316
6317
6318
6319
632
6320
6321
6322
6323
6324
6325
6326
6327
6328
6329
633
6330
6331
6332
6334
6335
6336
6337
6338
6339
6340
SEAT 1 LH SEAT BELT FASTENING - SIGNAL
SEAT 2 RH SEAT BELT FASTENING + SIGNAL
SEAT 2 RH SEAT BELT FASTENING - SIGNAL
SEAT 2 LH SEAT BELT FASTENING + SIGNAL
SEAT 2 LH SEAT BELT FASTENING - SIGNAL
SEAT 3 RH SEAT BELT FASTENING + SIGNAL
SEAT 3 RH SEAT BELT FASTENING - SIGNAL
SEAT 3 LH SEAT BELT FASTENING + SIGNAL
SEAT 3 LH SEAT BELT FASTENING - SIGNAL
BSI WAKE-UP REQ. BY RH SEATBACK SWITCH
BSI WAKE-UP REQ. BY LH SEATBACK SWITCH
FOLDED DRIVER'S SEATBACK SWITCH SIGNAL
FOLDED PASSENGER SEATBACK SWITCH
SIGNAL
DRIVER'S SEATBACK COMFORT SWITCH
SIGNAL
PASSENGER SEATBACK COMFORT
SWITCH SIGNAL
DRIVER'S NECK-LEVEL HEATING
RHEOSTAT EARTH
PASSENGER'S NECK-LEVEL HEATING
RHEOSTAT EARTH
HEATED SEATS AUTHORISATION
DRIVER'S REAR SEAT ACCESS SWITCH SIG.
PASSENGER'S REAR SEAT ACCESS
SWITCH SIG.
DRIVER'S SEATBACK CUSHION PANEL
CONNECTION
PASSENGER SEATBACK CUSHION PANEL
CONNECTION
RR RH 3RD ROW
SEAT BELT INFO.
M MEMORY KEYPAD INFO.
MEMORY 1 KEYPAD INFO.
MEMORY 2 KEYPAD INFO.
FR LH SEAT ACQUIS.
DR SEAT FR RUNNER CTRL
DR SEAT FR RUNNER INFO.
BACKWARDS SEAT BACK TOP RECLINE
CONTROL
FORWARDS SEAT BACK TOP RECLINE
CONTROL
SEAT BACK TOP RECLINE SENSOR SIGNAL
DR SEAT RR RUNNER CTRL
DR SEAT RR RUNNER INFO.
FAST RUNNER ADJ. CTRL.
DR SEAT FRONT TOP SEAT CUSHION CTRL
DR SEAT FRONT TOP SEAT CUSHION INFO.
FR RH SEAT ACQUIS. SWITCH
DETECTION PANEL +
DETECTION PANEL FR RH SEAT ADJ. AUTHORISATION
DR SEAT RR TOP SEAT CUSHION CTRL
DR SEAT RR TOP SEAT CUSHION INFO.
DR SEAT FR LOWER SEAT CUSHION CTRL
DR SEAT FR LOWER SEAT CUSHION INFO.
DR SEAT RR LOWER SEAT CUSHION CTRL
DR SEAT RR LOWER SEAT CUSHION INFO.
FR RH PASS EXTERIOR PRESENT
6341
6342
6343
6344
6345
6346
6347
6348
6350
6351
6352
6353
6354
6355
6356
6357
6358
6359
6360
6361
6362
6363
6364
6365
6366
6367
6368
6369
6370
6371
6372
6373
6374
6375
6376
6377
6378
6379
638
6380
6381
6382
6383
6384
6385
6386
6387
639
6390
6391
6392
6394
6395
6396
6397
6398
43
FR RH PASS EXTERIOR FASTENED
FR RH PASS INTERIOR PRESENT
FR RH PASS INTERIOR FASTENED
UNFASTENED PRES. FR RH SENSOR REQ.
+ FR RH SEAT BELT BUCKLE SWITCH
- FR RH SEAT BELT BUCKLE SWITCH
BGBC BT SEAT BELT REMINDER BUZZER CTRL
BACKWARDS FAST RUNNER CTRL
DR SEATBACK FR ANGLE CTRL
DR SEATBACK FR ANGLE SENSOR
HORIZONTAL LUMBAR BACKWARDS CTRL
HORIZONTAL LUMBAR FORWARDS CTRL
HORIZONTAL LUMBAR SENSOR SIGNAL
DR SEAT BACK RR ANGLE CTRL
DR SEAT BACK RR ANGLE INFO.
VERTICAL LUMBAR UPWARDS CTRL
VERTICAL LUMBAR DOWNWARDS CTRL
VERTICAL LUMBAR SENSOR SIGNAL
DR SEAT POS. SENSOR + CTRL
DR ARMREST RAISE CTRL
DR ARMREST LOWER CTRL
SENSOR POWER SUPPLY
SENSOR EARTH 1
HEATED SEAT SWITCH CTRL.
DR HEATED SEAT POWER SUPPLY
PASS HEATED SEAT POWER SUPPLY
DR HEATED SEAT CTRL
PASS HEATED SEAT CTRL
FR HEATED SEAT SWITCH CTRL
RR LH HEATED SEAT CTRL
RR RH HEATED SEAT CTRL
RR HEATED SEAT SWITCH CTRL
HEATED SEAT PANEL EARTH
RR LH HEATED SEAT POWER SUPPLY
RR RH HEATED SEAT POWER SUPPLY
MULTI/RUNNER/SITE/COMMON
BACKREST/HEIGHT ADJUSTER COMMON
SENSOR EARTH 2
DR SEAT RHEOSTAT CTRL
DR SEAT RHEOSTAT INFO.
RR LH SEAT RHEOSTAT CTRL
RR LH SEAT RHEOSTAT INFO.
COMMON CEA
VOLTAGE LEVEL INFO.
HEIGHT RUNNER
HEIGHT ADJUSTER
SEATBACK TENSION LEVEL INFO.
BACKREST TOP
TENSION LEVEL INFO.
LUMBAR TENSION LEVEL INFO.
FR RH SEAT RHEOSTAT CTRL
FR RH SEAT RHEOSTAT INFO.
RR RH SEAT RHEOSTAT CTRL
RR RH SEAT RHEOSTAT INFO.
SEAT MEM. MOD. DIAG INFO.
MEMORY KEYPAD INFO.
MEM. KEYPAD LIGHTING CTRL.
MEM. KEYPAD WARNING LIGHT LIGHTING CTRL
COMMON MEMORY KEYPAD
REAR VIEW MIRRORS, STEERING COLUMN
640
6400
6401
6402
6403
6404
6405
6406
6407
6408
6409
6410
6411
6412
6413
6414
6415
6416
6417
6418
6419
642
6420
6421
6422
6423
6424
6425
6426
6427
6428
6429
643
6430
6431
6432
6433
6434
6435
6440
6441
6443
6444
6445
6446 ELECTROCHROME RR VIEW MIRROR
EARTH OUTPUT
6450 COMMON LH RR VIEW MIRROR MOTOR CTRL
6451 RR VIEW MIRROR UP/DOWN MOT. CTRL
6452 LH REAR-VIEW MIRROR RIGHT/LEFT MOT. CTRL
6453 COMMON RH RR VIEW MIRROR MOTOR CTRL
6454 RH RR VIEW MIRROR UP/DOWN MOT. CTRL
6455 RH RR VIEW MIRROR RIGHT/LEFT MOT. CTRL
6456 FOLD-IN LH RR VIEW MIRROR MOT. CTRL
6457 FOLD-OUT LH REAR VIEW MIRROR MOT. CTRL
6458 FOLD-IN RH RR VIEW MIRROR MOT. CTRL
6459 FOLD-OUT RH REAR VIEW MIRROR MOT. CTRL
646 FR LH/FR RH MEM. MOD. INFO.
6460 COLUMN INPUT CTRL
6461 COLUMN COMMON CTRL
6462 COLUMN RAISE CTRL
6463 COLUMN AXIAL POS. INFO.
6464 COLUMN RADIAL POS. INFO.
6465 COLUMN POS + SENSOR CTRL
6466 COLUMN POS SENSOR - CTRL
6467 COLUMN RADIAL MOT. CTRL INFO.
6468 COLUMN COMMON MOT. CTRL INFO.
6469 COLUMN AXIAL MOT. CTRL INFO.
6470 LH RR VIEW MIRROR UP/DOWN POS. INFO.
6471 DR REAR-VIEW MIRROR LEFT/RIGHT POS. INFO.
6472 LH REAR VIEW MIRROR POS. POTENTIOM.
+ CTRL
6473 LH REAR VIEW MIRROR POS. POTENTIOM. - CTRL
6474 RH REAR VIEW MIRROR UP/DOWN MOT. INFO.
6475 RH REAR VIEW MIRROR LEFT/RIGHT MOT. INFO.
6476 RH REAR VIEW MIRROR POS. POTENTIOM.
+ CTRL
6477 RH REAR VIEW MIRROR POS. POTENTIOM. - CTRL
6478 DRIVER'S REAR VIEW MIRROR FOLD-IN
MOT. CTRL.
6479 PASS. REAR VIEW MIRROR FOLD-IN MOT. CTRL
6480 LH CAMERA EARTH
6481 LH CAMERA SUPPLY
6482 LH CAMERA VIDEO + SIGNAL
6483 LH CAMERA VIDEO - SIGNAL
6484 LH PICTO CTRL
6485 RH CAMERA EARTH
6486 RH CAMERA SUPPLY
6487 RH CAMERA VIDEO + SIGNAL
6488 RH CAMERA VIDEO - SIGNAL
6489 RH PICTO CTRL
6490 LH CAMERA + DATA
6491 LH CAMERA - DATA
6492 RH CAMERA + DATA
6493 RH CAMERA - DATA
REAR VIEW MIRROR JOYSTICK POWER
SUPPLY OUTPUT (BSI)
COMMON DR REAR VIEW MIRROR MOTOR CTRL
DR REAR VIEW MIRROR UP/DOWN MOTOR CTRL
DR REAR VIEW MIRROR L/R MOT. CTRL
DR REAR VIEW MIRROR COMMON INFO.
DR REAR VIEW MIRROR UP/DOWN MOT. INFO.
DR REAR VIEW MIRROR L/R MOT. INFO.
PASS REAR VIEW MIRROR MOT. INFO.
PASS REAR VIEW MIRROR UP/DOWN MOT. INFO.
PASS REAR VIEW MIRROR L/R MOT. INFO.
DR REAR VIEW MIRROR UP/DOWN POS. INFO.
COMMON PASS REAR VIEW MIRROR
MOTOR CTRL
PASS REAR VIEW MIRROR UP/DOWN
MOTOR CTRL
PASS REAR VIEW MIRROR L/R MOT. CTRL
DR REAR VIEW MIRROR POS. + POTENTIOM. CTRL
PASS REAR VIEW MIRROR POS. - POTENTIOM. CTRL
DR REAR VIEW MIRROR POS. POTENTIOM. CTRL
PASS REAR VIEW MIRROR POS. +
POTENTIOM. CTRL
PASS REAR VIEW MIRROR UP/DOWN POS. INFO
PASS REAR VIEW MIRROR L/R POS. INFO
DR REAR VIEW MIRROR L/R POS. INFO.
REAR VIEW MIRROR FOLDING CTRL
REAR-VIEW MIRROR FOLDING INFO.
DRIVER FOLDING REAR VIEW MIRROR CTRL
PASSENGER FOLDING REAR VIEW MIRROR CTRL
REAR VIEW MIRROR ADJUSTMENT
ANALOG. INFO.
REAR VIEW MIRROR SELECTOR
ANALOGUE INFO.
COMMON FOLD.DR.REAR-VIEW MIRROR
MOT.CTRL
COMMON FOLD.PASS.REAR-VIEW MIRROR
MOT.CTRL
REAR VIEW MIRROR FOLD. REQ. INPUT
REAR VIEW MIRROR FOLD-IN RELAY CTRL
REAR VIEW MIRROR FOLD-OUT RELAY CTRL
REAR VIEW MIRROR FOLD-OUT CTRL
REAR-VIEW MIRROR FOLD-OUT INFO.
MANUAL REAR VIEW MIRROR FOLD.INFO.
EXTERIOR TEMPERATURE CTRL
EXTERIOR TEMPERATURE INFO.
COMMON EXTERIOR TEMP. INFO.
REAR VIEW MIRROR FOLD-IN/OUT INFO.
REVERSING RR VIEW MIRROR INDEX.
DIAG SIG.
REVERSING INFO.
ELECTROCHR.RR VIEW MIRROR ANALOG.
EARTH OUTPUT
ELECTROCHROME RR VIEW MIRROR INPUT
ELECTROCHROME RR VIEW MIRROR
POWER SUPPLY OUTPUT
SEAT BELTS
650
6500
6501
6502
6503
6504
44
FR LH PYRO SEAT BELT + CTRL
DR AIRBAG 2 + CTRL
DR AIRBAG 2 - CTRL
PASS AIRBAG 1 + CTRL
PASS AIRBAG 1 - CTRL
PASS AIRBAG 2 + CTRL
6505
6506
6507
6508
6509
651
65A0
65A1
65A2
65A3
65A4
65A5
65A6
65A7
65A8
65A9
6510
6511
6512
6513
6514
6515
6516
6517
6518
6519
652
6520
6521
6522
6523
6524
6525
6526
6527
6528
6529
653
6530
6531
6532
6533
6534
6535
6536
6537
6538
6539
654
6540
6541
6542
6543
6544
6545
6546
6547
6548
6549
655
6550
6551
6552
6553
6554
6555
6556
6557
6558
6559
656
6560
6561
6562
6563
6564
6565
6566
6567
6568
6569
657
6570
6571
6572
6573
6574
6575
6576
6577
6578
6579
658
6580
6581
6582
PASS AIRBAG 2 - CTRL
FR LH SIDE AIRBAG + CTRL
FR LH SIDE AIRBAG - CTRL
FR RH SIDE AIRBAG + CTRL
FR RH SIDE AIRBAG - CTRL
FR LH PYRO SEAT BELT - CTRL
FR RH HEAD-LEVEL SIDE AIRBAG + CTRL
FR RH HEAD-LEVEL SIDE AIRBAG - CTRL
FR LH HEAD-LEVEL SIDE AIRBAG + CTRL
FR LH HEAD-LEVEL SIDE AIRBAG - CTRL
FRONT STRAP PRETENS. MODULES COMMON
REAR STRAP PRETENS. MODULES COMMON
FR RH STRAP RET. PYRO. SEAT BELT + CTRL
FR LH STRAP RET. PYRO. SEAT BELT + CTRL
FR RH STRAP RET. PYRO. SEAT BELT - CTRL
FR LH STRAP RET. PYRO. SEAT BELT - CTRL
D1 AIRBAG + INFO.
D1 AIRBAG - INFO.
DRIVER KNEE AIRBAG + CTRL
DRIVER KNEE AIRBAG - CTRL
PASSENGER KNEE AIRBAG + CTRL
PASSENGER KNEE AIRBAG - CTRL
RR LH SIDE AIRBAG + CTRL
RR LH SIDE AIRBAG - CTRL
RR RH SIDE AIRBAG + CTRL
RR RH SIDE AIRBAG - CTRL
FR RH PYRO SEAT BELT + CTRL
FR LH SEAT POS. SENSOR + CTRL
FR LH SEAT POS. SENSOR - CTRL
FR RH SEAT POS. SENSOR + CTRL
FR RH SEAT POS. SENSOR - CTRL
FR RH SIDE IMPACT DETECTOR + CTRL
FR RH SIDE IMPACT DETECTOR - CTRL
FR LH SIDE IMPACT DETECTOR + CTRL
FR LH SIDE IMPACT DETECTOR - CTRL
RH CURTAIN AIRBAG + CTRL
RH CURTAIN AIRBAG - CTRL
FR RH PYRO SEAT BELT - CTRL
LH CURTAIN AIRBAG + CTRL
RR RH PYRO SEAT BELT + CTRL
RR RH PYRO SEAT BELT - CTRL
RR LH PYRO SEAT BELT + CTRL
RR LH PYRO SEAT BELT - CTRL
REAR CENT. PYRO SEAT BELT + CTRL
REAR CENT. PYRO SEAT BELT - CTRL
PYRO SEAT BELT DIAGNOSTIC INFO.
DR 1 AIRBAG + CTRL
DR 1 AIRBAG - CTRL
SEAT BELT PRESENCE WARNING LIGHT CTRL
AIRBAG DIAG. INFO.
AIRBAG WARNING LIGHT INFO.
FRONT AIRBAG WARNING LIGHT CTRL
SIDE/FRONT AIRBAG WARNING LIGHT CTRL
SIDE AIRBAG WARNING LIGHT CTRL
FR RH STRAP RET. PYRO. SEAT BELT + CTRL
PASS AIRBAG INHIBIT SWITCH INFO.
PASS AIRBAG INHIBIT SWITCH CTRL
AIRBAG INHIBIT WARNING LIGHT CTRL
LH CURTAIN AIRBAG - CTRL
6583
6584
6585
6586
6587
6588
6589
659
6590
6591
6592
6593
6594
6595
6596
6597
45
DR STRAP PYRO. SEAT BELT + CTRL
DR2 AIRBAG + INFO.
DR2 AIRBAG - INFO.
LH CURT./SIDE AIRBAGS MOD. CTRL
RH CURT./SIDE AIRBAGS MOD. CTRL
RR RH SIDE IMPACT DETECTOR + CTRL
RR RH SIDE IMPACT DETECTOR - CTRL
RR LH SIDE IMPACT DETECTOR + CTRL
RR LH SIDE IMPACT DETECTOR - CTRL
FR PRETENSIONER MOD. CTRL
RR PRETENSIONER MOD. CTRL
DR STRAP PYRO. SEAT BELT - CTRL
LH PRETENSIONER MOD. CTRL
RH PRETENSIONER MOD. CTRL
FR LH FRONT IMPACT DETECTOR + CTRL
FR LH FRONT IMPACT DETECTOR - CTRL
FR RH FRONT IMPACT DETECTOR + CTRL
FR RH FRONT IMPACT DETECTOR - CTRL
PASS. BELT RETURN PYRO SEAT BELT + CTRL
PASS. BELT RETURN PYRO SEAT BELT - CTRL
RR RH ROLL BAR + CTRL
RR RH ROLL BAR - CTRL
R3 RR LH PYRO SEAT BELT + CTRL
RR LH ROLL BAR + CTRL
RR LH ROLL BAR - CTRL
FR/RR LH SIDE AIRBAG MOD. COMMON
FR/RR RH SIDE AIRBAG MOD. COMMON
DR PEDESTRIAN IMPACT DETECTION + CTRL
DR PEDESTRIAN IMPACT DETECTION - CTRL
LH PEDESTRIAN IMPACT DETECTION + CTRL
LH PEDESTRIAN IMPACT DETECTION - CTRL
RH BONNET HINGE ACTUATOR + CTRL
RH BONNET HINGE ACTUATOR - CTRL
FR LH BELT RETURN PYRO SEAT BELT - CTRL.
LH BONNET HINGE ACTUATOR + CTRL
LH BONNET HINGE ACTUATOR - CTRL
PEDESTRIAN FR IMP. SENSOR + POWER
SUPPLY
PEDESTRIAN FR IMP. SENSOR EARTH
PEDESTRIAN FR IMP. SENSOR + SIGN.
PEDESTRIAN FR IMP. SENSOR - SIGN.
FR RH SEAT BELT UNBUCKLED WARNING
LIGHT
RR SEAT BELT UNBUCKLED WARNING LIGHT
RRC SEAT BELT UNBUCKLED WARNING LIGHT
RR LH SEAT BELT UNBUCKLED WARNING LIGHT
R3 REAR PRETENSIONERS SWITCH
RR RH SEAT BELT UNBUCKLED WARNING
LIGHT
FR LH SEAT BELT UNBUCKLED WARNING LIGHT
RH ANTI-SUBMARINING MOD. + CTRL
RH ANTI-SUBMARINING MOD. + CTRL
CENTRAL FR PYRO. SEAT BELT + CTRL
FR RH BELT RETURN PYRO SEAT BELT - CTRL.
CENTRAL FR PYRO. SEAT BELT - CTRL
EMERGENCY CALL CTRL
HEADLIGHT LEVELLER
6600
6601
6602
6603
6604
6605
6606
6607
6608
6609
6610
6611
6612
6613
6614
6615
6616
6621
6622
6623
6624
6715
6716
6717
6718
6719
672
6720
6721
6722
6723
6724
6725
6726
6727
6728
6729
673
6730
6731
6732
6733
6734
6735
6736
6737
6738
6739
674
6740
6741
6742
6743
6744
6745
6746
6747
6748
6749
675
6750
6751
6752
6753
6754
6755
6858
6859
686
6861
6862
6863
6864
6865
6866
6867
6868
6869
6870
6871
MANUAL HEADLIGHT CORR. AUTH.
HEADLIGHT LEVELLER MOD. INDICATOR CTRL.
LH HEADLIGHT LEVELLER CTRL
RH HEADLIGHT LEVELLER CTRL
FR BODY HEIGHT SENSOR SIGNAL
RR BODY HEIGHT SENSOR SIGNAL
FR BODY HEIGHT SENSOR + POWER SUPPLY
FR BODY HEIGHT SENSOR - POWER SUPPLY
RR BODY HEIGHT SENSOR + POWER SUPPLY
RR BODY HEIGHT SENSOR - POWER SUPPLY
HEADLIGHT CORR. DIAG.
LH LEVELLER PHASE 1_1
LH LEVELLER PHASE 1_2
LH LEVELLER PHASE 2_1
LH LEVELLER PHASE 2_2
BODY HEIGHT SENSOR + POWER SUPPLY
BODY HEIGHT SENSOR - POWER SUPPLY
RH LEVELLER PHASE 1_1
RH LEVELLER PHASE 1_2
RH LEVELLER PHASE 2_1
RH LEVELLER PHASE 2_2
GEARBOX AND TRANSMISSION ASSISTANCE
67A0
67A1
67A2
67A3
67A4
67A5
67A6
67A7
67A8
670
6700
6701
6702
6703
6704
6705
6706
6707
6708
6709
671
6710
6711
6712
6713
6714
CLUTCH 2 SENSOR POWER SUPPLY
CLUTCH SENSOR 1 OUTPUT
CLUTCH SENSOR 2 OUTPUT
VEH SPEED SIG. INTERFACE MODULE 1
OUTPUT + SIGNAL
VEH SPEED SIG. INTERFACE MODULE 1
OUTPUT - SIGNAL
VEH SPEED SIG. INTERFACE MODULE 2
OUTPUT + SIGNAL
VEH SPEED SIG. INTERFACE MODULE 2
OUTPUT - SIGNAL
VEH SPEED SIG. INTERFACE MODULE 3
OUTPUT + SIGNAL
VEH SPEED SIG. INTERFACE MODULE 3
OUTPUT - SIGNAL
MOTOR POS. SENSOR POWER SUPPLY
AUTOMATIC GEARBOX OPERATION MODE INFO.
STARTING PREVENTION REL. CTRL
REDUNDANT BRAKE SWITCH INFO.
SEQUENCE SV + POWER SUPPLY
MODULATION SV + POWER SUPPLY
BVA COOLANT SV + POWER SUPPLY
BVA COOLANT SV - POWER SUPPLY
AUTOMATIC GEARBOX DATA POSITION
- SIGNAL
LOCKUP SOLENOID VALVE CTRL
LOCKUP INFO.
ENGINE POS. SENSOR EARTH
AUTOMATIC GEARBOX OIL TEMP. + SIGNAL
AUTOMATIC GEARBOX OIL TEMP. - SIGNAL
AUTOMATIC GEARBOX POSITION + SIGNAL
AUTOMATIC GEARBOX POSITION - SIGNAL
GEARBOX SPEED SENSOR + SIGNAL
46
GEARBOX SPEED SENSOR - SIGNAL
GEARBOX OIL PRESSURE INFO.
GEARBOX OIL TEMPERATURE INFO.
SEQUENCE 1 SV CTRL
SEQUENCE 2 SV CTRL
SOLENOID EARTH
SEQUENCE 3 SV CTRL
SEQUENCE 4 SV CTRL
SEQUENCE 5 SV CTRL
SEQUENCE 6 SV CTRL
MODULATION 1 SV CTRL
START LOCK SIGNAL
GEAR LEVER SWITCH A1
GEAR LEVER SWITCH A2
GEAR LEVER SWITCH A3
GEAR LEVER SWITCH A4
ENGINE + CTRL
GEAR LEVER EARTH
LH STEERING WHEEL CONTROL SWITCH
RH STEERING WHEEL CONTROL SWITCH
STEERING WHEEL CONTROL EARTH
BVA DATA1 POS. SIGNAL
BVA DATA2 POS. SIGNAL
BVA DATA3 POS. SIGNAL
BVA DATA4 POS. SIGNAL
VEHICLE SPEED SIGNAL
VEHICLE SPEED INFORMATION
ENGINE - CTRL
BVA FAULT WARNING LIGHT CTRL
ENGINE POS. SENSOR SIGNAL
SHIFT LOCK RELAY CTRL
SHIFT LOCK CTRL
INHIBITED APR WARNING LIGHT CONTROL
SHIFT LOCK VIA RELAY + CTRL
SHIFT LOCK VIA RELAY - CTRL
SELECTION ACTUATOR CTRL
SELECTION ACTUATOR + POWER SUPPLY
SELECTION ACTUATOR - POWER SUPPLY
ENGINE POS. FEEDBACK SENSOR SIGNAL
SHIFT ACTUATOR CTRL
SHIFT ACTUATOR + POWER SUPPLY
SHIFT ACTUATOR - POWER SUPPLY
CLUTCH ACTUATOR CTRL
CLUTCH ACTUATOR + POWER SUPPLY
CLUTCH ACTUATOR - POWER SUPPLY
HYDRAU. PMP UNIT REL CTRL
SUNROOF AUTO CLOSE CTRL
FOLDING ROOF DIAGNOSTIC
ROOF CLOSED INFO. FOR BSI
BSC BEEP INFO. FOR BSI
LH LOCKED ROOF INFO.
RH LOCKED ROOF INFO.
CLOSED BOOT INFO.
CURTAIN DRAWN INFO.
ROOF CLOSED INFO.
ROOF OPEN INFO.
OPEN BOOT INFO.
POLE 1 THERMAL RESISTOR INFO.
POLE 2 THERMAL RESISTOR INFO.
6872
6873
6874
6875
6876
6877
6878
6879
6880
6881
6882
6883
6884
6890
6891
6892
6893
OPEN LH REAR QUARTER CTRL
OPEN RH REAR QUARTER CTRL
CLOSE LH REAR QUARTER CTRL
CLOSE RH REAR QUARTER CTRL
OPEN LH REAR QUARTER REMINDER CTRL
OPEN RH REAR QUARTER REMINDER CTRL
CLOSE LH REAR QUARTER REMINDER CTRL
CLOSE RH REAR QUARTER REMINDER CTRL
ECU WAKE-UP VIA REAR SCREEN
PARCEL SHELF STOWED/DEPLOYED INFO.
RH/LH LOCKED BOOT INFO.
RH/LH LOCKED BOOT COMMON INFO.
SWITCH ONE-TOUCH OUTP. INFO.
RELAY 2 CTRL
RELAY 1 CTRL
VALVE CTRL
HYDRAULIC PUMP UNIT RELAY EARTH
7051
7052
7057
7062
7063
7064
7065
7066
7070
7071
7072
7073
7086
7087
7088
7089
7090
7091
7092
7093
CENTRAL LOCKING (CONTINUED)
690
6900
6901
6902
6903
6904
6905
6906
6907
6908
6909
6910
6911
6912
6913
6914
6915
6916
6917
6918
6919
6920
6921
DOOR ACR. CUT-OFF MOD. OUTPUT STATUS
LH DOOR LOCK ACT. PLC MOD. CTRL
RH DOOR LOCK ACT. PLC MOD. CTRL
RR ACCESS CLOSED WARNING LIGHT
RR ACCESS CLOSED CTRL
LOCK COMMON REL. OUTPUT
RR LH EXT. OPEN SENSOR INFO.
RR RH EXT. OPEN SENSOR INFO.
FUEL FILLER FLAP RELAY OPEN OUTPUT
H_MAX SHUTTER POS
H_MIN SHUTTER POS
SHUTTER LH SENSOR + CTRL
SHUTTER LH SENSOR - CTRL
SHUTTER RH SENSOR + CTRL
SHUTTER RH SENSOR - CTRL
CPO_FR LH
CPO_FR RH
FR LH VER POS INFO.
FR RH VER POS INFO.
EXTERIOR LOCK LOCKING
REAR EXTERIOR LOCK LOCKING
FR LH EXT. OPENING SENSOR SIG.
FR RH EXT. OPENING SENSOR SIG.
VARIABLE POWER-ASSISTED STEERING (VPAS)
7100 VARIABLE POWER-ASSISTED STEERING INFO.
7101 VARIABLE POWER-ASSISTED STEERING CTRL
7102 VARIABLE POWER-ASSISTED STEERING
RELAY CTRL
7103 EL. STEERING WHEEL ANGLE + SPEED SIGNAL
7104 EL. STEERING WHEEL TORQUE SIGNAL
7105 EL. STEERING WHEEL CLUTCH CTRL
7106 VAR. PAS PROPORT. SV + CTRL
7107 CAR. PAS PROPORT. SV - CTRL
7108 VAR. PAS ECU POWER SUPPLY
7109 VAR. PAS LIMIT INFO.
7110 ELECT.PUMP.MOT.POWER REL.CTRL
7111 ELECTRIC PUMP MOTOR CTRL
7112 ANGLE SENSOR +12V POWER SUPPLY
7113 ANGLE SENSOR OUTPUT 1 INFO.
7114 ANGLE SENSOR OUTPUT 2 INFO.
7115 TORQUE SENSOR POWER SUPPLY
7116 TORQUE SENSOR EARTH
7117 PRIMARY TORQUE INFO.
7118 SECONDARY TORQUE INFO.
7119 ANGLE SENSOR EARTH
7120 TORQUE SENSOR TEMP. INFO.
7121 VAR. PAS VALVE COMMON
7122 VAR. PAS VALVE PHASE 1 + CTRL
7123 VAR. PAS VALVE PHASE 1 - CTRL
7124 VAR. PAS VALVE PHASE 2 + CTRL
7125 VAR. PAS VALVE PHASE 2 - CTRL
7126 POWER-ASSISTED STEERING SENSOR EARTH
ANTI-LOCK BRAKING SYSTEM
700
7001
7002
701
7011
7012
702
7021
7022
703
7031
7032
7045
ABS FUNCTION SIGNAL
ABS DIAGNOSTIC
ABS MODULE POWER SUPPLY
FR LH ACTIVATE/HOLD/EXHAUST SV CTRL
FR RH ACTIVATE/HOLD/EXHAUST SV CTRL
RR LH ACTIVATE/HOLD/EXHAUST SV CTRL
RR RH ACTIVATE/HOLD/EXHAUST SV CTRL
LDA SIGNAL
BRAKE PED. TRAVEL SENSOR 5V POWER
SUPPLY
BRAKE PED. TRAVEL SENSOR 1 SIGNAL
BRAKE PED. TRAVEL SENSOR 2 SIGNAL
SIGNAL EARTH
APR REGULATION WARNING LIGHT CTRL
ABS FAULT WARNING LIGHT CTRL
APR FAULT WARNING LIGHT CTRL
HILL HOLDER FAULT WARNING LIGHT CTRL
INHIBITED APR WARNING LIGHT CTRL
ABS INHIBIT CTRL
ASR INHIBITION CTRL
BRAKING DIST. FAULT WARNING LIGHT
FR LH WHEEL SPEED INFO.
FR LH WHEEL SPEED SIGNAL
FR LH WHEEL SPEED SIGNAL REF.
FR RH WHEEL SPEED INFO.
FR RH WHEEL SPEED SIGNAL
FR RH WHEEL SPEED SIGNAL REF.
RR LH WHEEL SPEED INFO.
RR LH WHEEL SPEED SIGNAL
RR LH WHEEL SPEED SIGNAL REF.
RR RH WHEEL SPEED INFO.
RR RH WHEEL SPEED SIGNAL
RR LH WHEEL SPEED SIGNAL REF.
CLUTCH SIGNAL
TRIP COMPUTER - CLOCK
720 LOWER SCREEN TILT CTRL (X+)
7200 COLOUR SCREEN POWER SUPPLY
7201 COLOUR SCREEN EARTH
47
7202
7203
7204
7205
7206
7207
7208
7209
721
7210
7211
7212
7213
7214
7215
7216
7217
7218
7219
7220
7221
7222
7223
7225
7226
7227
7228
7230
7231
7232
7233
7234
7235
7236
7237
7238
7239
7240
7243
7244
7245
7246
7247
7248
7249
7250
7251
7252
7253
7254
7255
7256
7257
7258
7259
7260
7261
7262
7263
7264
7265
7266
7267
7268
7269
7270
7271
7272
7273
7274
7275
7276
7277
7278
7279
7280
7281
7282
7283
7284
7285
7286
7287
7288
7289
7290
7291
SCREEN BRIGHTNESS INFO.
PAL/NTSC MODE INFO.
RED COLOUR INFO.
GREEN COLOUR INFO.
BLUE COLOUR INFO.
VIDEO EARTH
COLOUR SCREEN IR RECEIVER POWER SUPPLY
COL. SCREEN IR RECEIVER EARTH
TOP SCREEN TILT CTRL (X+)
IR RECEIVER TRANSMISS. INFO.
IR RECEIVER RECEPTION INFO.
IR RECEIVER MODE INFO.
COLOUR SCREEN SHIELDING
EXTERNAL VIDEO EARTH
EXTERNAL VIDEO INPUT
MULTIFUNCTION SCREEN EARTH
MULTIFUNCTION SCREEN POWER SUPPLY
MULTIFUNCTION SCREEN ON/OFF
MULTIFUNCTION SCREEN CAN HIGH
MULTIFUNCTION SCREEN CAN LOW
LH AUDIO AUXILIARY
RH AUDIO AUXILIARY
AUDIO EARTH
DISPLAY SCROLL INFO.
SCREEN DIMMER CRTL
FOLD. POS RETURN
FOLD. FORCED OPENING
COL. SCREEN POWER SUPPLY (JAPAN)
COL. SCREEN EARTH (JAPAN)
SCREEN BRIGHTNESS INFO. (JAPAN)
PAL/NTSC MODE INFO. (JAPAN)
RED COLOUR INFO. (JAPAN)
GREEN COLOUR INFO. (JAPAN)
BLUE COLOUR INFO. (JAPAN)
VIDEO EARTH (JAPAN)
COL. SCREEN IR REC. POWER SUPPLY.
(JAPAN)
BSI OUTPUT TO DIODE (JAPAN)
DIODE OUTPUT TO HANDBRAKE (JAP.)
COL. SCREEN SHIELDING (JAPAN)
LVDS CLK1+
LVDS CLK1LVDS A0+
LVDS A0LVDS A1+
LVDS A1LVDS A2+
LVDS A2LVDS EARTH
SCREEN 2 + LVDS CLK1 DIG. VIDEO SIG.
SCREEN 2 - LVDS CLK1 DIG. VIDEO SIG.
SCREEN 2 + LVDS A0 DIG. VIDEO SIG.
SCREEN 2 - LVDS A0 DIG. VIDEO SIG.
SCREEN 2 + LVDS A1 DIG. VIDEO SIG
SCREEN 2 - LVDS A1 DIG. VIDEO SIG
SCREEN 2 + LVDS A2 DIG. VIDEO SIG
SCREEN 2 - LVDS A2 DIG. VIDEO SIG
SCREEN 2 LVDS DIG. VIDEO SIG. EARTH
HEAD-UP VIEW ACTIVATION-DEACTIVATION
HEAD-UP VIEW STATUS LED CTRL
HEAD-UP VIEW + - HEIGHT ADJUST.
HEAD-UP VIEW + - LIGHT ADJUST.
HEAD-UP VIEW ADJUST. EARTH
LH AUDIO SIGNAL AUXILIARY 2
RH AUDIO SIGNAL AUXILIARY 2
AUDIO EARTH AUXILIARY 2
RH MOBILE AUX. AUDIO SOCKET
LH MOBILE AUX. AUDIO SOCKET
MOBILE AUX. AUDIO SOCKET EARTH
LH SCREEN + VIDEO SIGNAL
LH SCREEN - VIDEO SIGNAL
RH SCREEN + VIDEO SIGNAL
REAR RH SCREEN - VIDEO SIGNAL
REAR LH SCREEN SUPPLY
REAR LH SCREEN EARTH
REAR RH SCREEN SUPPLY
REAR RH SCREEN EARTH
MULTIMEDIA ASSEMBLY FUNC. AUTH
LH AUX. INPUT VIDEO SIGNAL
LH AUX. INPUT VIDEO EARTH
LH AUX. INPUT LH AUDIO SIGN.
LH AUX. INPUT RH AUDIO SIGN.
LH AUX. INPUT AUDIO EARTH
RH AUX. INPUT VIDEO SIGNAL
RH AUX. INPUT VIDEO EARTH
RH AUX. INPUT LH AUDIO SIGN.
RH AUX. INPUT RH AUDIO SIGN.
RH AUX. INPUT AUDIO EARTH
CRUISE CONTROL (RVV)
730
7300
7301
7302
7303
7304
7305
7306
7307
7309
731
7310
7311
7312
7313
7316
732
7320
7321
7322
7324
7325
7326
7327
7330
48
CRUISE CONTROL POWER SUPPLY
CANCELLATION SWITCH POWER SUPPLY
ACCEL/DECEL/MEM. SWITCH POWER SUPPLY.
CRUISE CONTROL MODULE POWER SUPPLY
RESUME CRUISE CONTROL INFO.
ACCEL/DECEL/MEM. INFO.
CRUISE CONTROL CANCELLATION SIGNAL
ACTION ON CLUTCH/GEAR INFO.
STARTER INHIBIT
REDUNDANT BRAKE SIGNAL
ACCEL. PEDAL RES.PT. SIGNAL.
ACCEL PEDAL RES.PT/C EARTH
CRUISE CONTROL PUMP CONTROL
CRUISE CONTROL SV CONTROL
SOLENOID VALVE/PUMP POWER SUPPLY
CRUISE CONTROL CUT-OFF REL. POWER
SUPPLY
ACCEL. PEDAL RES. POINT 2 SIGNAL
CRUISE CONTROL CUT-OFF SV POWER SUPPLY
CRUISE CONTROL SIGNAL
CRUISE CONTROL SIGNAL REF.
DECELERATION INFO.
ACCELERATION INFO.
CANCELLATION INFO.
MEMORY INFO.
SPEED LIMITER ANALOG/DIG. CONVERS.
MOD. +5V
7331
7332
7334
7335
7338
7340
7342
7345
7346
7347
7348
7349
7350
7351
CONVERS. MOD SIGNAL 1 OUTPUT
CONVERS. MOD SIGNAL 1 OUTPUT
MEM. RETURN ACCEL. SIGNAL
CONVERS. MOD. EARTH
DECEL. MEM. SIGNAL.
OVERSPEED WARNING MEM. CTRL
OVERSPEED WARNING IND. LIGHT INFO.
AUTHORISED SPEED STOP INFO.
AUTHORISED SPEED STOP WARNING
LIGHT CTRL
MODE INFO.
INTER-VEHICLE SAFE DISTANCE WARNING
CTRL
INTER-VEH SAFE DISTANCE WARNING
BUTTON LIGHT CTRL
INTER-VEHICLE SAFE DISTANCE WARNING
+ THRESHOLD CTRL
INTER-VEHICLE SAFE DISTANCE WARNING
- THRESHOLD CTRL
7545
7550
7551
7552
7553
7555
TYRE PRESSURE MONITORING
7600
7601
7602
7603
7604
7605
7606
7607
7608
7609
7610
7611
7612
FR LH TYRE PRESSURE DETECTION LF ANT. +
FR LH TYRE PRESSURE DETECTION LF ANT. FR RH TYRE PRESSURE DETECTION LF ANT. +
FR RH TYRE PRESSURE DETECTION LF ANT. RR LH TYRE PRESSURE DETECTION LF ANT. +
RR LH TYRE PRESSURE DETECTION LF ANT. RR RH TYRE PRESSURE DETECTION LF ANT. +
RR RH TYRE PRESSURE DETECTION LF ANT. FR TYRE PRESSURE DETECTION HF ANT. 1
FR TYRE PRESSURE DETECTION HF ANT. 2
RR TYRE PRESSURE DETECTION HF ANT. 1
RR TYRE PRESSURE DETECTION HF ANT. 2
RR TYRE PRESSURE DETECTION
INITIALISATION BUTTON
7613 TYRE PRESSURE 1 HF AERIAL
7614 TYRE PRESSURE 2 HF AERIAL
PARKING ASSISTANCE (AAS) - STL
7500
7501
7502
7503
7504
7505
7506
7507
7508
7509
7510
7511
7512
7513
7514
7515
7516
7517
7518
7519
7520
7521
7522
7523
7524
7525
7526
7527
7528
7538
7539
7540
7541
7542
7543
7544
CENTRE FR RH SENSOR SIGNAL
LAT. TRAJ. MON. SENSOR POWER SUPPLY
VIBRATORS POWER SUPPLY
LH VIBRATOR CTRL
RH VIBRATOR CTRL
LAT. TRAJ. MON. SENSOR 0_V
INT. RR LH SENSOR + CTRL
INT. RR LH SENSOR - CTRL
EXT. RR LH SENSOR + CTRL
EXT. RR LH SENSOR - CTRL
INT. RR RH SENSOR + CTRL
INT. RR RH SENSOR - CTRL
EXT. RR RH SENSOR + CTRL
EXT. RR RH SENSOR - CTRL
TRAILER INFO.
RR SPEAKER + CTRL
RR SPEAKER -CTRL
INT. RR LH SENSOR SIGNAL
EXT. RR LH SENSOR SIGNAL
INT. RR RH SENSOR SIGNAL
EXT. RR RH SENSOR SIGNAL
RR SENSOR + CTRL
RR SENSOR - CTRL
PARKING ASSISTANCE INHIBITION CTRL
PARK. ASSIST. PUSH-BUTTON WARNING
LIGHT CTRL
INT. FR LH SENSOR SIGNAL
EXT. FR LH SENSOR SIGNAL
INT. FR RH SENSOR SIGNAL
EXT. FR RH SENSOR SIGNAL
FR SENSOR + CTRL
FR SENSOR - CTRL
PARK. ASS. INHIBIT BUTTON INPUT
LAT. TRAJ. MON. INHIBIT BUTTON CTRL
PARK. ASS. INHIBIT BUTTON LED OUTPUT
LAT.TRAJ. MON. INHIBIT BUTTON LED OUTPUT
LH SIDE SENSOR SIGNAL
RH SIDE SENSOR SIGNAL
CENTRE FR LH SENSOR + CTRL
CENTRE FR LH SENSOR - CTRL
CENTRE FR RH SENSOR + CTRL
CENTRE FR RH SENSOR - CTRL
CENTRE FR LH SENSOR SIGNAL
SUSPENSION
770
7700
7701
7702
7703
7704
7705
7706
7707
7708
7709
771
7710
7711
7712
7713
7714
7715
7716
7717
7718
772
7720
7721
7722
7723
7724
7725
7726
7727
7728
49
SUSPENSION FAULT WARNING LIGHT CTRL
SPORT SUSPENSION WARNING LIGHT CTRL
ADAC FAULT WARNING LIGHT CTRL
VARIABLE DAMPER WARNING LIGHT CTRL
SPORT FAULT SUSP. WARNING LIGHT CTRL
SPORT NORMAL SELECTION
MINERAL HYDRAULIC FLUID LEVEL
RAISE BOOT CTRL
LOWER BOOT CTRL
FR RH ACTUATOR PHASE 1 + CTRL
FR RH ACTUATOR PHASE 1 - CTRL
VARIABLE DAMPING CTRL
FR RH ACTUATOR PHASE 2 + CTRL
FR RH ACTUATOR PHASE 2 - CTRL
RR RH ACTUATOR PHASE 1 + CTRL
RR RH ACTUATOR PHASE 1 - CTRL
STEERING WHEEL ANGLE SENSOR S3
THROTTLE ANGLE SIGNAL
THROTTLE ANGLE INFORMATION
RR RH ACTUATOR PHASE 2 + CTRL
RR RH ACTUATOR PHASE 2 - CTRL
FR SHOCK ABSORBER EARTH
FR LH ACTUATOR PHASE 1 + CTRL
FR LH SHOCK ABSORBER EARTH
FR RH SHOCK ABSORBER EARTH
FR LH ACTUATOR PHASE 1 - CTRL
FR BODY HEIGHT SENSOR SIGNAL
RR BODY HEIGHT SENSOR SIGNAL
FR BODY HEIGHT SENSOR + POWER SUPPLY
FR BODY HEIGHT SENSOR - POWER SUPPLY
RR BODY HEIGHT SENSOR + POWER SUPPLY
7729
773
7730
7731
7732
7733
7734
7735
7736
7737
7738
7739
774
7740
7741
7742
7743
7744
7745
7746
7747
7748
7749
775
7750
7751
7752
7753
7754
7755
7756
7757
7758
7759
776
7760
7761
7762
7763
7764
7765
7766
7767
7768
7769
777
7770
7771
7772
7773
7774
7775
7776
7777
7778
7779
778
7780
7781
7782
7783
7784
7785
7786
7787
7788
7789
7790
7791
7792
7793
7794
7795
7796
7797
7798
7799
RR BODY HEIGHT SENSOR - POWER SUPPLY
RR SHOCK ABSORBER EARTH
FR LH ACTUATOR PHASE 2 + CTRL
RR LH SHOCK ABSORBER EARTH
RR RH SHOCK ABSORBER EARTH
FR LH ACTUATOR PHASE 2 - CTRL
FR LH BODY HEIGHT SENSOR + POWER SUPPLY
FR LH BODY HEIGHT SENSOR - POWER SUPPLY
FR LH BODY HEIGHT SENSOR SIGNAL
FR RH BODY HEIGHT SENSOR + POWER SUPPLY
FR RH BODY HEIGHT SENSOR - POWER SUPPLY
FR RH BODY HEIGHT SENSOR SIGNAL
BODY HEIGHT SENSOR + POWER SUPPLY
FR LH BODY HEIGHT SENSOR + POWER SUPPLY
FR LH BODY HEIGHT SENSOR - POWER SUPPLY
FR LH BODY HEIGHT SENSOR SIGNAL
RR RH BODY HEIGHT SENSOR + POWER SUPPLY
RR RH BODY HEIGHT SENSOR -POWER SUPPLY
RR RH BODY HEIGHT SENSOR SIGNAL
FR SIDE LAT. ACCELERATION INFO.
RR LH ACTUATOR PHASE 1 + CTRL
FR LAT. ACCELEROMETER SENSOR +
POWER SUPPLY
FR LAT. ACCELEROMETER SENSOR POWER SUPPLY
BODY HEIGHT SENSOR - POWER SUPPLY
FR VERTICAL ACCELERATION INFO.
RR LH ACTUATOR PHASE 1 - CTRL
FR VERT. ACCELEROMETER SENSOR +
POWER SUPPLY
FR VERT. ACCELEROMETER SENSOR POWER SUPPLY
FR HYDRACTIVE SV CTRL
RR HYDRACTIVE SV CTRL
FR HYDRACTIVE SV + POWER SUPPLY
FR HYDRACTIVE SV - POWER SUPPLY
RR HYDRACTIVE SV + POWER SUPPLY
RR HYDRACTIVE SV - POWER SUPPLY
STEERING WHEEL ANGLE SIGNAL S1
ADAC PROPORT. SV 1 CTRL
ADAC PROPORT. SV 1 POWER SUPPLY
ADAC PROPORT. SV 2 CTRL
ADAC PROPORT. SV 2 POWER SUPPLY
ADAC SV 1 CTRL
ADAC SV 1 - POWER SUPPLY
ADAC SV 2 CTRL
ADAC SV 2 - POWER SUPPLY
FR ACTUATOR PHASE 1 + CTRL
FR ACTUATOR PHASE 1 - CTRL
E_HYD_SPORT
FR ACTUATOR PHASE 2 + CTRL
FR ACTUATOR PHASE 2 - CTRL
RR LH ACTUATOR PHASE 2 + CTRL
RR LH ACTUATOR PHASE 2 - CTRL
RR ACTUATOR PHASE 1 + CTRL
RR ACTUATOR PHASE 1 - CTRL
RR ACTUATOR PHASE 2 + CTRL
RR ACTUATOR PHASE 2 - CTRL
HYDRACTIVE INPUT + (BSI)
HYDRACTIVE INPUT - (BSI)
STEERING WHEEL ANGLE SIGNAL S2
BODY H BUZZER S_PILOT
HIGH SUSPENSION WARNING LIGHT INFO.
TRACK SUSPENSION WARNING LIGHT INFO.
NORMAL SUSPENSION WARNING LIGHT INFO.
LOW SUSPENSION WARNING LIGHT INFO.
BODY HEIGHT 1 INFO.
BODY HEIGHT 2 INFO.
HIGH SUSPENSION + CTRL
HIGH SUSPENSION - CTRL
HEIGHT PROGRAMMING CTRL
HYDRAULIC DIAGNOSTIC
RR ACCEL. SENSOR +5V POWER SUPPLY
RR ACCEL. SENSOR SIGNAL
RR SENSOR 5V EARTH
FR LH ACCEL. SENSOR POWER SUPPLY
FR LH ACCEL. SENSOR SIGNAL
FR LH SENSOR EARTH
FR RH ACCEL. SENSOR POWER SUPPLY
FR RH ACCEL. SENSOR SIGNAL
FR RH SENSOR EARTH
SUSPENS. + STABILITY PROGRAM
7800
7801
7802
7803
7804
7805
7806
7807
7809
7810
7811
7812
7813
7814
7815
7816
7817
7818
7819
7820
7821
7822
7823
7824
7825
7826
7827
7828
7829
7830
7831
7832
7833
7834
50
ESP FAULT WARNING LIGHT
ESP INHIBIT WARNING LIGHT CTRL
ESP REGULATION WARNING LIGHT CTRL
LATERAL ACCELEROMETER INFO.
LATERAL ACCELEROMETER SIGNAL
STEERING WHEEL ANGLE INFO.
STEERING WHEEL ANGLE SIGNAL
ESP CLUTCH SIGNAL
ESP PRELOAD. PUMP MOT. + CTRL
ESP PRELOAD. PUMP MOT. - CTRL
ESP BRAKE FLUID PRESSURE SENSOR 1 +
ESP BRAKE FLUID PRESSURE SENSOR 1 ESP BRAKE FLUID PRESSURE SENSOR 1 INFO.
ESP SV + POWER SUPPLY
ESP SV RELAY CTRL
ESP MOTOR + POWER SUPPLY
ESP MOTOR RELAY CTRL
CONTROL RELAY COILS + POWER SUPPLY.
FR LH INLET SOLENOID VALVE CTRL
FR RH INLET SOLENOID VALVE CTRL
RR LH INLET SOLENOID VALVE CTRL
RR RH INLET SOLENOID VALVE CTRL
FR LH EXHAUST SV CTRL
FR RH EXHAUST SV CTRL
RR LH EXHAUST SV CTRL
RR RH EXHAUST SV CTRL
USV1 SOLENOID VALVE CTRL
USV2 SOLENOID VALVE CTRL
HSV1 SOLENOID VALVE CTRL
HSV2 SOLENOID VALVE CTRL
ACCELEROM./GYROMETER + SENSOR
ACCELEROM./GYROMETER - SENSOR
ACCELEROMETER INFORMATION
GYROMETER INFORMATION
7835
7836
7837
7838
7839
7840
7841
7842
7843
7844
787
7870
7871
7872
7873
7874
7875
7876
7877
7878
7879
788
7880
7881
7882
7883
7884
7885
7886
7887
7888
7889
789
7890
7891
GYROM./ACCELEROM. SENSOR TEST OUTPUT
GYROM./ACCELEROM. SENSOR REF. INPUT
ESP INHIBIT CTRL
ESP PUSH-BUTTON WARNING LIGHT CTRL
ESP BRAKE FLUID PRESSURE SENSOR 2 +
ESP BRAKE FLUID PRESSURE SENSOR 2 ESP BRAKE FLUID PRESSURE SENSOR 2 INFO.
REMOTE WAKE-UP INFO.
VEHICLE DRIVING SIGNAL
ABS MOTORS SUPPLY RELAY SHUNT
+ COMPRESSOR
BUTTON POWER SUPPLY
LOWER BUTTON
RAISE BUTTON
ACCESSORY INFLATION CTRL
PROGRAMMED INFLATION CTRL
HEIGHT SENSOR SIGNAL FEEDBACK
ACCESSORY PRESENCE
+ TANK SV
- TANK SV
BUZZER
- COMPRESSOR
COMPRESSOR SV POWER SUPPLY
FR RH SV CTRL
RR LH SV CTRL
TANK SV CONTROL
EXHAUST SV CTRL
COMPR. PRESSURE SENSOR POWER SUPPLY
COMPR. PRESSURE SENSOR EARTH
COMPR. PRESSURE SENSOR SIGNAL
COMPR. TEMP. SENSOR SIGNAL
COMPR. TEMP. SENSOR EARTH
INHIBIT BUTTON CTRL
SYSTEM INHIBIT LED
ACCESSORY PRESENCE POWER SUPPLY
8016
8017
8018
8019
802
8020
8021
8022
8023
8024
8025
8026
8027
8028
8029
803
8030
8031
8032
8033
8034
8035
8036
8037
8038
8039
804
8040
8041
8042
8043
8044
8045
8046
8047
8048
8049
805
8050
8051
8052
8053
8054
8055
8056
8057
8058
8059
806
8060
8061
8062
8063
8064
8065
8066
CLIMATE CONTROL, AIR CONDITIONING
800 PASS CONTROL PANEL REF. +5V
8000 CLIMATE CONTROL MODULE CTRL
8001 CLIMATE CONTROL DIAGNOSTIC
INFORMATION
8002 PASS. COMPARTMENT AIR TEMP. SENSOR
DIAG. INFO.
8003 BRIGHTNESS SENSOR 1 SIGNAL
8004 BRIGHTNESS SENSOR 2 SIGNAL
8005 AMBIENT LIGHT SIGNAL
8006 SOLAR SENSOR SIGNAL
8007 TUNNEL LIGHT SIGNAL
8008 BRIGHTNESS SENSOR EARTH
8009 TWILIGHT LIGHT SIGNAL
801 START/STOP OPERATION AUTH.
8010 CLIM. CTRL. MODULE OPERATED BY
PRESSURE SWITCH
8011 WARM LOOP COOLANT PUMP RELAY CTRL
8012 PASS. CTRL. PANEL MIX. SETPOINT
8013 PASS. CTRL. PANEL REF. EARTH
8014 SINGLE/DUAL-ZONE MODE BUTTON
8015 BRIGHTNESS EARTH OUTPUT
51
SINGLE/DUAL-ZONE MODE WARNING LIGHT
WARM LOOP SV REL. CTRL
BLOWER CTRL MOD. SETPOINT
BLOWER CTRL MOD. DIAG.
LH BLOWN AIR SENSOR (RR ASSEMBLY)
CLIMATE CTRL MOTOR CTRL
CLIMATE CTRL MOTOR SPEED 1 CTRL
CLIMATE CTRL MOTOR SPEED 2 CTRL
CLIMATE CTRL MOTOR SPEED 3 CTRL
CLIMATE CTRL MOTOR SPEED 4 CTRL
RR LH CLIMATE CTRL PANEL SIGNAL
RR RH CLIMATE CTRL PANEL SIGNAL
STEPPER MOTOR BUS LINE + POWER SUPPLY
STEPPER MOTOR BUS LINE EARTH
PASS. COMPARTMENT AIR TEMP. SENSOR 0V
RH BLOWN AIR SENSOR (RR ASSEMBLY)
PASSENGER COMPARTMENT AIR TEMP. INFO.
PASS. COMPARTMENT AIR TEMP. SENSOR
POWER SUPPLY
AIR INTAKE MOTOR + POWER SUPPLY
AIR INTAKE MOTOR - POWER SUPPLY
AIR INTAKE MOTOR POTENTIOM. + POWER
SUPPLY.
AIR INTAKE MOTOR POTENTIOM. - POWER
SUPPLY.
AIR INTAKE MOTOR POTENTIOM. SIGNAL
COMPRESS. MAX. CAPACITY REQUEST
AIR INTAKE S_INFORMATION
RR ASSEMBLY EVAP. SENSOR
STEPPER MOTOR BUS LINE
ZERO BLOWER SPEED
RR BLOWER
RR LH BLOWER SETPOINT
RR RH BLOWER SETPOINT
RR LH BLOWER DIAG.
RR CLIMATE CTRL INHIBIT CTRL
RR CLIMATE CTRL INHIBIT WARNING LIGHT INFO.
RR RH BLOWER DIAG.
RR CLIMATE CONTROL PANEL REF. VOLTAGE
CLIMATE CTRL CTRL
ELECTRON. THERMOSTAT CTRL.
COMPRESSOR OPERATION INFO.
EVAPORATOR SENSOR CTRL
EVAPORATOR SENSOR INFO.
AC ON CTRL
COMPRESSOR CUT-OFF CTRL
AC ADJUSTMENT CTRL (AC/TH)
EVAPORATOR SENSOR ANALOGUE EARTH
AC/ON WARNING LIGHT OUTPUT
COMPRESSOR VALVE CTRL
DIESEL INFO.
AIR INTAKE MOT. CTRL
COMPRESSOR CTRL
AIR CON COOLANT TEMP. MODULE CTRL
RR RH CLIMATE CONTROL PANEL REF. VOLTAGE
CLIMATE CONTROL CUT-OFF CTRL
COOLANT TEMPERATURE SENSOR CTRL
COOLANT TEMPERATURE INFO.
TS1 + CTRL
8067
8068
8069
807
8071
8072
8073
8074
8075
8076
8077
8078
8079
808
8080
8081
8082
8083
8084
8085
8086
8087
8088
8089
809
8090
8091
8092
8093
8094
8095
8096
8097
8098
8099
80A0
80A1
80A2
80A3
80A4
80A5
80A6
80A7
80A8
80A9
80B0
80B1
80B2
TS2 + CTRL
TS3 + CTRL
COMPRESSOR EARTH OUTPUT
AIR INPUT MOTOR CTRL BIT 2
COMP. CUT-OFF RELAY POWER SUPPLY BY
PRESSURE SWITCH
BLOWER SPEED NOT ZERO
LH ADDIT. BLOWER MODUL. CTRL
RH ADDIT. BLOWER MODUL. CTRL
COMPRESSOR CUT-OFF RELAY CTRL.
FORCE FAST SPEED CTRL (MFU)
FORCE LOW SPEED CTRL (MFU)
FORCE AVERAGE SPEED CTRL (MFU)
INDEPENDENT HEATER RELAY CTRL
ADDITIONAL HEATING REQUEST
AIR CON COMPRESS. AUTHORISATION
INPUT (BSI)
AIR CON COMPRESS. AUTHORISATION
REQUEST OUTPUT.(BSI
ADD. HEATER FUEL PUMP + CONTROL.
ADD. HEATER FUEL PUMP - CONTROL.
ADDITIONAL HEATING REL. CTRL
LH ADDITIONAL BLOWER SWITCH INFO.
RH ADDITIONAL BLOWER SWITCH INFO.
ADDITIONAL BLOWER SWITCH POWER SUPPLY
RH ADDITIONAL BLOWER SWITCH EARTH
INDEPENDENT HEATING IGNITER CTRL
LOW SPEED RELAY CONTROL
PRESSURE SAFETY INFO.
HIGH SPEED RELAY CTRL
AIR CON PRESSURE SENSOR POWER SUPPLY
AIR CON PRESSURE SENSOR SIGNAL
AIR CON PRESSURE SENSOR EARTH
ADDITIONAL HEATING 1 CTRL
ADDITIONAL HEATING 2 CTRL
ADD. HEATING IGNITER CTRL
ADDITIONAL HEATING 3 CTRL
IGNITER DIAGNOSTIC INFO.
IGNITER CONTROL MODE
BSI WAKE-UP REQUEST FOR PRECONDITI.
THERM. PRECONDITIONING IND. LIGHT SIG.
FRONT A/C BLOWER SUPPLY
REAR LH A/C MOTOR SPEED 1 CTRL
REAR LH A/C MOTOR SPEED 2 CTRL
REAR LH A/C MOTOR SPEED 3 CTRL
REAR LH A/C MOTOR SPEED 4 CTRL
REAR RH A/C MOTOR SPEED 1 CTRL
REAR RH A/C MOTOR SPEED 2 CTRL
REAR RH A/C MOTOR SPEED 3 CTRL
REAR RH A/C MOTOR SPEED 4 CTRL
REAR A/C BLOWER SUPPLY
8104
8105
8106
8107
8108
811
8110
8111
8112
813
8130
8131
8132
8133
8140
8150
8151
8152
8153
81A1
CODED IMMOBILISER
8200
8201
8202
8203
8204
8205
8210
8211
8212
8213
8214
8215
8216
8217
8218
8223
8224
8225
8226
8227
8228
8229
8230
8231
8232
8233
8234
8235
8236
8237
8238
8239
8240
8241
8245
8246
HEATED COMPONENTS
810
8100
8101
8102
8103
HEATED RR SCREEN WARNING LIGHT OUTPUT
HEATED RR SCREEN RELAY OUTPUT
FAST DEMISTING BUTTON CONTROL
FAST DEMIST. INDICATOR OUTPUT
HEATED REAR SCREEN FILTER
HEATED REAR SCREEN CTRL
HEATED REAR SCREEN ACTIVATION INFO.
HEATED SCREEN 2 CTRL
PROTECTED HEATED REAR VIEW MIRROR CTRL
HEATED REAR VIEW MIRROR CTRL
DRIVER'S HEATED REAR VIEW MIRROR + CTRL
DRIVER'S HEATED REAR VIEW MIRROR - CTRL
PASS. HEATED REAR VIEW MIRROR + CTRL
PASS. HEATED REAR VIEW MIRROR - CTRL
HEATED WINDSCREEN OUTPUT
LH HEATED REAR VIEW MIRROR + CTRL
LH HEATED REAR VIEW MIRROR - CTRL
RH HEATED REAR VIEW MIRROR + CTRL
RH HEATED REAR VIEW MIRROR - CTRL
HEATED SCREEN AFTER-FILTER CTRL
HEATED RR SCREEN RELAY CTRL
HEATED RR SCREEN WARNING LIGHT CTRL
HEATED RR SCREEN WARNING LIGHT INFO.
HEATED REAR SCREEN EARTH
RR CIGARETTE LIGHTER CTRL VIA BSI
52
CODED IMMOBILISER OUTPUT INPUT INFO.
BSI LH UNLOCKING RELAY CTRL OUTPUT
GLOBAL UNLOCKING RELAY CTRL OUTPUT
SELECTIVE UNLOCKING RELAY CTRL OUTPUT
BSI RH UNLOCKING RELAY CTRL OUTPUT
SELECTIVE UNLOCKING RELAY CTRL INPUT
FR LH EXT. LF ANTEN. EARTH
FR RH EXT. LF ANTEN. EARTH
RR LH EXT. LF ANTEN. EARTH
RR RH EXT. LF ANTEN. EARTH
BOOT EXT. LF ANTEN. EARTH
FRONT INT. LF ANTEN. EARTH
PASS COMPT. INT. LF ANTEN. EARTH
BOOT INT. LF ANTEN. EARTH
EMERGENCY ANTENNA EARTH
RR LH DOOR HANDLE SWITCH
RR RH DOOR HANDLE SWITCH
FR LH DOOR HANDLE SWITCH
FR RH DOOR HANDLE SWITCH
FR LH DOOR CENTRAL LOCKING SWITCH
FR RH DOOR CENTRAL LOCKING SWITCH
BOOT OPENING SWITCH
BOOT CLOSING SWITCH
EMERGENCY ANTENNA EXCITATION
FR LH EXT. LF ANT. EXCITATION
FR RH EXT. LF ANT. EXCITATION
RR LH EXT. LF ANT. EXCITATION
RR RH EXT. LF ANT. EXCITATION
BOOT EXT. LF ANTEN. EXCITATION
FR INT. LF ANT. EXCITATION
PASS. COMPT. INT. LF ANTEN. EXCITATION
BOOT INT. LF ANTEN. EXCITATION
HF ANTENNA EXCITATION
HF ANTENNA EXCITATION1
LOCKS COMMON INPUT
FR INT. UNLOCKING REL. CTRL OUTPUT
8247
8248
8249
8250
8251
8265
8266
8267
8268
8269
8270
8272
8273
8274
8275
8276
8280
8281
8282
FR INT. UNLOCKING REL. CTRL INPUT
RR INT. UNLOCKING REL. CTRL OUTPUT
RR INT. UNLOCKING REL. CTRL INPUT
LOCKS COMMON OUTPUT
ANTI-THEFT POWER SUPPLY APPLICATION
AUTHORISATION
CODED IMMOBILISER MODULE POWER SUPPLY
CODED IMMOBILISER DIAG. INFO.
CODED IMMOBILISER INPUT
CODED IMMOBILISER OUTPUT
CODED IMMOBILISER WAKE-UP INFO.
TRANSPONDER + CTRL
TRANSPONDER - CTRL
TRANSPONDER CLOCK SIGNAL
TRANSPONDER INFORMATION
TRANSPONDER COIL + SIGNAL
TRANSPONDER COIL - SIGNAL
STARTING INFO.
ENGINE STARTING SWITCH WARNING
LIGHT (ADML)
JUMPER WIRE
84D3
84D4
84D5
84D6
84D7
8400
8401
8402
8403
8404
8405
8406
8407
8408
8410
8411
8413
8412
8414
8415
8417
8416
8418
8419
8420
8421
8422
8423
8424
8425
8426
8427
8428
8429
8430
8431
8432
8433
8434
8435
8436
8437
8440
8441
8445
8446
8450
8451
8452
8453
8454
8455
8456
8457
8458
8459
8460
8461
8462
RADIO TELEPHONE RADIO ANTENNA
84A0
84A1
84A2
84A3
84A4
84A5
84A6
84A7
84A8
84A9
84B0
84B1
84B2
84B3
84B4
84B5
84B6
84B7
84B8
84B9
84C0
84C1
84C2
84C3
84C4
84C5
84C6
84C7
84C8
84C9
84D0
84D1
84D2
RADIOPHONE MICRO MDS INPUT + SIGNAL
RADIOPHONE MICRO EARTH MDS INPUT
SIM CARD CLOCK
SIM CARD READER EARTH
SIM MDS DATA EXCHANGE
SIM CARD READER PRESENCE
SIM CARD READER SUPPLY
SIM CARD READER RESET
MDS + AUDIO OUTPUT
MDS - AUDIO OUTPUT
BRANDED EMERGENCY CALL BUTTON SIGNAL
EMERGENCY CALL BUTTON SIGNAL
EMERGENCY/BRANDED EMERGENCY CALL
BUTTON SUPP.
EMERG. CALL GREEN LIGHT SUPPLY
EMERG. CALL ORANGE LIGHT SUPPLY
DG4 SCREEN LIN BUS
USB SOCKET SUPPLY
USB SOCKET + DATA
USB SOCKET - DATA
USB SOCKET EARTH
EMERGENCY/BRANDED EMERGENCY CALL
BUTTON EARTH.
MDS MICRO + SIGNAL
MDS MICRO EARTH
CENTRE FRONT SPEAKER + CTRL
CENTRE FRONT SPEAKER - CTRL
MDS + AUDIO OUTPUT
MDS - AUDIO OUTPUT
JAPAN AUTO. TOLL DATA SIGNAL
JAPAN AUTO. TOLL DATA SIGNAL REF
JAPAN AUTO. TOLL DATA SIGNAL RET.
JAPAN AUTO. TOLL UNIT EARTH
JAPAN AUTO. TOLL UNIT SUPPLY
JAPAN TRAFFIC INFO DATA SIGNAL
53
JAPAN TRAFFIC INFO DATA SIGNAL REF
JAPAN TRAFFIC INFO UNIT +5V SUPPLY
JAPAN TRAFFIC INFO DATA SIGNAL RET.
JAPAN TRAFFIC INFO UNIT EARTH
JAPAN TRAFFIC INFO UNIT SUPPLY
ELECTRIC ANTENNA CTRL
STEERING COLUMN CTRL 1
STEERING COLUMN CTRL 2
STEERING COLUMN CTRL 3
STEERING COLUMN CTRL 4
STEERING COLUMN CTRL 5
LH AUDIO CD CHANGER CTRL
RH AUDIO CD CHANGER CTRL
EARTH AUDIO CTRL
FR LH SPEAKER + CTRL
FR LH SPEAKER - CTRL
FR LH BOOMER - CTRL
FR LH BOOMER + CTRL
AMPLIF. FR LH OUTPUT + CTRL
AMPLIF. FR LH OUTPUT - CTRL
RR LH BOOMER - CTRL
RR LH BOOMER + CTRL
RR RH BOOMER + CTRL
RR RH BOOMER - CTRL
FR LH TWEETER + CTRL
FR LH TWEETER - CTRL
FR RH TWEETER + CTRL
FR RH TWEETER - CTRL
RR LH TWEETER + CTRL
RR LH TWEETER - CTRL
RR RH TWEETER + CTRL
RR RH TWEETER - CTRL
RADIO VOLUME +/-SEARCH +/- INFO.
RADIO MEM. + OR -MUTE MODE INFO.
FR RH SPEAKER + CTRL
FR RH SPEAKER - CTRL
FR RH BOOMER + CTRL
FR RH BOOMER - CTRL
AMPLIF. FR RH OUTPUT + CTRL
AMPLIF. FR RH OUTPUT - CTRL
JBL AMPLIF. POWER SUPPLY VIA BSI
RADIO AMPLIF. POWER SUPPLY
RADIO TRANSMITTER FAN RADIO TRANSMITTER FAN +
RR LH BASS SYSTEM SPEAKER 1+ CTRL
RR LH BASS SYSTEM SPEAKER 1 - CTRL
RR LH SPEAKER + CTRL
RR LH SPEAKER - CTRL
AMPLIF. RR LH OUTPUT + CTRL
AMPLIF. RR LH OUTPUT - CTRL
AMPLI. SWITCH + CTRL
RR RH BASS SYSTEM SPEAKER 1+ CTRL
RR RH BASS SYSTEM SPEAKER 1 - CTRL
MUTE HIFI AMPLIFIER
RR LH BASS SYSTEM SPEAKER 2 + CTRL
RR LH BASS SYSTEM SPEAKER 2 - CTRL
RR RH BASS SYSTEM SPEAKER 2+ CTRL
RR RH BASS SYSTEM SPEAKER 2 -CTRL
AUDIO HANDS-FREE KIT +
8463
8464
8465
8466
8467
8468
8469
8470
8471
8472
8473
8479
8480
8481
8482
8483
8484
8485
8486
8487
8488
8489
849
8490
8491
8493
8494
8495
8496
8497
8498
8499
AUDIO HANDS-FREE KIT POLICE RADIO TELEPHONE - INFO.
POLICE RADIO TELEPHONE + INFO.
POLICE MOBILE CHARGER - INFO.
POLICE MOBILE CHARGER + INFO.
POLICE RADIO - INFO.
POLICE RADIO + INFO.
RR RH SPEAKER + CTRL
RR RH SPEAKER - CTRL
AMPLIF. RR RH OUTPUT + CTRL
AMPLIF. RR RH OUTPUT - CTRL
TELEPHONE MUTE
DISPLAY INFO.
NAVIGATION INFO.
RADIO TELEPHONE + INFO.
RADIO TELEPHONE - INFO.
HIFI EMERGENCY CALL SPEAKER + CTRL
HIFI EMERGENCY CALL SPEAKER - CTRL
ANTENNA COAXIAL
RADIOTEL. MIKE SIGNAL + INPUT.
RADIOTEL. MIKE EARTH INPUT.
EXT. DIVERSITY FUNCTION SWITCH
CD CHANGER +PERMANENT
CAN HIGH CD CHANGER
CAN LOW CD CHANGER
STEERING WHEEL CONTROL LIGHTING +
POWER SUPPLY
STEERING WHEEL CTRL EARTH
VAN DATA TRANSCEIVER RADIO TEL./CD
CHANGER
VAN DATA B TRANSCEIVER RADIO TEL./CD
CHANGER
CD CHANGER EARTH
VAN COMFORT + RADIO TEL.
TRANSCEIVER/CD CHANGER
BATTERY + RADIO TEL. TRANSCEIVER/CD
CHANGER
8520
8521
8522
8525
8526
8527
LH SPEECH SYNTHESIS - INFO.
TRAFFIC MASTER CTRL
TRAFFIC MASTER WARNING LIGHT CTRL
NAVIGATION DESIGNATOR 4 CTRL (JAPAN)
DESIGNATOR MANAGEMENT CTRL 1
DESIGNATOR MANAGEMENT CTRL 2
ANTI-THEFT ALARM
8601 OPEN BONNET INFO.
8602 ANTI-THEFT ALARM WARNING LIGHT
CONTROL
8603 ANTI-THEFT ALARM CUT-OFF CONTROL
8604 ANTI-THEFT ALARM SIREN CONTROL
8605 ANTI-THEFT ALARM SIREN INFO.
8606 TRANSMITTER + SIGNAL
8607 TRANSMITTER - SIGNAL
8608 RECEIVER + SIGNAL
8609 RECEIVER - SIGNAL
8610 ANTI-THEFT ALARM TRIGGER SIGNAL
8611 FR LH DOOR OPEN INFO.
8612 FR RH DOOR OPEN INFO.
8614 RR RH DOOR OPEN INFO.
8615 DIPPED HEADLIGHTS REL. CTRL
8616 BOOT OPEN INFO.
8617 ULTRASOUND MOD. LINK INPUT (BSI)
8618 ULTRASOUND MOD. POWER SUPPLY (BSI)
8619 ANTI-THEFT ALARM VOLUME INHIBIT INFO.
8620 ULTRASOUND MODULE CTRL
8621 ANTI-THEFT ALARM BUZZER CONTROL
8622 DOORS OPEN INFO.
8623 SYSTEM STATUS
8624 REMOTE ANTI-THEFT ALARM ON CTRL
8625 REMOTE ANTI-THEFT ALARM CONTROL
8626 ANTI-THEFT ALARM EARTH
8627 VOLUMETRIC INHIBIT CTRL
8628 VOLUMETRIC INHIBIT WARNING LIGHT INFO..
NAVIGATION, GUIDANCE
BLIND
8500
8501
8502
8503
8504
8505
8506
8507
8508
8509
8510
8511
8512
8513
8514
8515
8516
8517
8518
8519
8700
8701
8702
8703
8704
GPS AERIAL + INFO.
GPS AERIAL - INFO.
NAVIGATION DESIGNATOR 1 CTRL
NAVIGATION DESIGNATOR 2 CTRL
NAVIGATION DESIGNATOR 3 CTRL
NAVIGATION DESIGNATOR 4 CTRL
NAVIGATION DESIGNATOR 5 CTRL
NAVIGATION DESIGNATOR 6 CTRL
NAVIGATION DIAGNOSTIC INFORMATION
NAVIGATION AUDIO - INPUT
NAVIGATION AUDIO - INPUT
RH NAVIGATION AUDIO + INPUT
RH NAVIGATION AUDIO - INPUT
LH NAVIGATION AUDIO + INPUT
LH NAVIGATION AUDIO - INPUT
SPEECH SYNTHESIS + INFO.
SPEECH SYNTHESIS - INFO.
RH SPEECH SYNTHESIS + INFO.
RH SPEECH SYNTHESIS - INFO.
LH SPEECH SYNTHESIS + INFO.
BLIND CTRL
RAISE BLIND CTRL
LOWER BLIND CTRL
BLIND CENTRAL CLOSING
BLIND + SUNROOF MULTIPLEXING
CLIMATE CONTROL, AIR CONDITIONING
(CONTINUED)
8800
8801
8802
8803
8804
8805
8806
8807
8808
8830
8831
54
CONTROL PANEL BUS LINE + POWER SUPPLY
LIN BUS CTRL PANEL
CONTROL PANEL BUS LINE EARTH
BLOWN AIR SENSOR EARTH (RR)
RR EVAPORATOR SENSOR EARTH
COLD LOOP SOLENOID VALVE SUPPLY
COLD LOOP SOLENOID VALVE EARTH
WARM LOOP SOLENOID VALVE SUPPLY
WARM LOOP WATER PUMP POWER SUPPLY
TRAILER REFRIG. SOCKET POWER SUPPLY
REFRIG. SOCKET RELAY CONTROL
Reading schematic diagrams (on paper and Infotec)
I :Number of function concerned by
the cross reference
J :Represents existing wire according
to vehicle equipment
K :
Figure representing the device
L :
Married wires
M:
Represents a splice
A:
Earth connection symbol
B:
Equipment number
C:
Wire number
D :
Connector housing number
E :
Connector colour
F :
Connector housing number
G :
Fuse number
H :Represents signal to
another function
55
Reading wiring diagrams (on paper and Infotec)
N:
O:
P:
Q:
R:
S :
T :
Identification
Representation of a fuse box
Interconnection number
Number of interconnection tracks
Interconnection colour
Representation of a partial interconnection
Represents a splice
56
Reading location diagrams (on paper and Infotec)
Key:
1.
2.
3.
4.
5.
6.
7.
8.
9.
10.
Identification of the wiring harness represented
Identification of the equipment
Number of connector tracks
Connector colour
Representation of an earth socket
Representation of a splice
Identification of an interconnection
Identification of the connected wiring harness
Link to a detail in the box indicated
Location of the wiring harness label
57
Reading a flowchart diagram
Reading the main detail and wiring diagram
58
Reading a connector detail diagram
Reading a splice detail diagram
EM 57
10 PR
M57A
BSI 1
1282
8606
MPBSI
MC01
M1282
M6600
M8606
M8606
M8607
Reading the connector location diagram
59
MC57
C0O1
6600
8086
8087
60
EQUIPMENT
(B)
Display
Bus
Signal coding
EQUIPMENT
(C)
CD changer
0
1
EQUIPMENT
(E)
BSI
0: Dominant bit
1: Recessive bit
2: Start of frame
3: Identifier
4: Control field
5: Data to be transmitted
6: Control field
7: Acknowledgement
8: End of frame
Two twisted wires are called:
Data/DataB
EQUIPMENT
(D)
Navigation
The communication protocol defines the structure of a frame
The more equipment
The greater the number of signals to be exchanged
The more the multiplex solution is justified
EQUIPMENT
(A)
Radio
Multiplexing principles
Multiplexing application in the 1007
The BSI centralises and processes signals from 4 networks:
- CAN networks: 1320, 1660, 7126, 7800 (7804)
- VAN CAR1 networks: PSF1, 6570
- VAN CAR2 networks: 5007, 6239, 8602
- VAN Comfort networks: 0004, 7500, 8080 (8025), 8410 (8480), 8415
BLOCK
DIAGRAM
MOST
Optical link
VAN Comfort
TELEMATICS
61
Multiplexing application in 206 from October 2001
The increase in power of electronic on-board equipment for regulatory, comfort and passenger
safety reasons, requires an electronic
multiplex layout.
A multiplex network is a single circuit that connects the computers, reducing the number of
connections and wires. The multiplex layout gives the wiring harness a much higher level of
complexity and allows new features to be offered to the customer.
The built-in systems interface (BSI) centralises and processes data from 4 networks:
- a multi-master type CAN network, connecting the BSI to the computers: engine
management (1320), gearbox (1630), (intersystem network),
- a multi-master type VAN network, connecting the BSI to the equipment: controls
(0004) multifunction screen (7215), climate control computer (8080), radio
(8410), CD changers ( 8415), nav. computer (8500), VAN comfort network),
- two master/slave type VAN networks, connecting the BSI to the body fittings:
. BM34/- CV00/- 5007 (rain sensor) /- 6570 (airbag module) /
. 2003 (driving school monitor module) /- 8602 (alarm module)
VAN Comfort
62
Multiplexing application in the 207
The BSI centralises and processes signals from 3 networks
- CAN networks: 1320, 7600, 1660, 6606, 7800/7020, 7126
- CAN CAR networks: CV00, 6570, 8602, 5008, BSR1, PSF1
- CAN Comfort networks: 7500, 8480, 8080, 0004
CAN LS COMF
Depending on equipment
63
VAN - CAN Multiplexing application in the 307
The built-in systems interface (BSI) centralises and processes data from 4 networks:
- a multi-master type CAN network, connecting the BSI to the computers: engine management,
gearbox, anti-lock braking system or stability program, stability program steering wheel angle
sensor (intersystem network)
- a multi-master type VAN network, connecting the BSI to the equipment: controls, multifunction screen, computer, climate control, radio, CD changer, navigation computer (VAN comfort
network),
- two master/slave type VAN networks, connecting the BSI (master) to the bodywork fittings (slaves):
. 34 fuse engine systems interface, built-in systems interface, switching module under the steering wheel (VAN network bodywork 1),
. fuel additive computer, driving school monitor unit, passenger and driver standard front electric window modules + motors, anti-theft alarm volumetric module, sunroof motor and computer, central door locking infrared receiver (VAN network bodywork 2)
BLOCK DIAGRAM
VAN Comfort
64
Multiplexing application in the 308
The networks
308 is a FULL CAN vehicle which has a BSI (Built-in Systems Interface) called "Multi-range".
This centralises and processes signals from 3 networks:
- CAN HS/IS: CAN High Speed/Inter System (500Kbits/s), connecting the BSI and the dynamic
computers.
Wires code: CAN H "9000" and CAN L "9001"
- CAN LS CONF: CAN Low Speed CONfort (125Kbits/s), connecting the BSI and the comfort
network computers.
Wires code: CAN H "9024" and CAN L "9025"
- CAN LS CAR: CAN Low Speed (body) CARosserie (125Kbits/s), connecting the BSI and the
body computers.
Wires code: CAN H "9017" and CAN L "9018"
The CAN Low Speed networks have the special feature of withstanding some line faults: cut wire,
wire short circuit with a power supply and even short circuit on both lines together.
Warning: if one of the faults listed occurs, operation will be in degraded mode. This means that the
vehicle is operational, but more susceptible to electromagnetic disturbances. If several of the faults
occur at the same time, the network may no longer be able to operate.
This architecture is completed by several LIN networks which connect:
- The BSI to the belt unbuckled warning lights unit (4746)
- The BSI to the diesel additive pump (1283)
- the AFS computer (6606) to the two headlights
- The AFIL computer (7550) to its 6 sensors
- The driver's door unit (6036) to the 4 electric window motors as well as to the memory and lighting
unit for the passenger door mirror (6404)
The power feeds
5 types of power feed are distributed across the 308:
- +BAT: direct +12V battery feed. Wire code: ‘B---‘
- +APC: +12V after ignition feed. Wire code: ‘C---‘
To ensure that the feeds are managed by the BSI/PSF1 assembly, the key must be in the ignition
ON position (1st position).
Please note: The +accessories position has been removed.
- +RCD: Remote control wake-up, +12V SIGNAL. Wire code:’7842’
This is a signal line and a line for "waking up" certain computers.
- +CAN: 12V feed. Wire code: ‘Z---‘
These are feed lines and/or signal lines for certain computers on the CAN LS network.
While the +CAN is used as a signal line, it relates to management of emergency modes.
- +LIN: 12V feed
This is issued by the BSI and allows the operation of the computers linked to it.
65
VAN - CAN Multiplexing application in 406 D9
from DAM 9001
The BSI centralises and processes signals from 4 networks:
- CAN networks: 1320, 1630, 78-- incorporated in CV00, 7800
- VAN CAR1 networks: 5007, BM34, CV00, 6570
- VAN CAR2 networks: 8602, 1282
- VAN Comfort networks: 0004, 8080, 8415, 8500, 7215, 8410
66
VAN - CAN Multiplexing application in the 607
607 has an electronic layout comprised of three multiplex networks:
- CAN intersystem network
CAN = Controller Area Network
Protocol flow: 125 kbit/s
Request response time: 500 ms
- VAN comfort network
- VAN bodywork 1 network
- VAN bodywork 2 network
AMVAR
(with ESP)
Engine
management
Steering wheel
angle sensor
(with ESP)
RadioRadio
telephone
ESP or ABS
BVA
Intersystem
network
Controls
I/S Can
Air
conditioning
CD changer
Comfort VAN
network
VAN
Comfort
SMART
ACCESSORY
UNIT (BSI)
Airbags
Van Body-1
network
Parking aid
Multifunction
display
BMultifunction
screen C or D
Van Body-2
network
Onboard
guidance
system
Diesel
additives
Driver's door
plate
Passenger door
plate
Driver's seat
memory
BSI LUXE ergonomic pack
67
Automatic
activation of
lights
VAN - CAN Multiplexing application in the 807
The BSI centralises and processes signals from 4 networks:
- CAN networks: 1320, 1630, CV00, 7025, 7806
- VAN CAR1 networks: BM34, CV00, 6570
- VAN CAR2 networks: 1282, 6811, 6812, 6813, 6301, 8602, 9050, 9030, 6239
- VAN Comfort networks: 0004, 4645 (BTO), 7215, 7500, 8080, 8410, 8415, 8480, 8503
VAN BODY 2
(62.5 kTs/s)
VAN BODY 1
(62.5 kTs/s)
MOST Optical link
VAN Comfort
(125 kTs/s)
68
VAN - CAN multiplexing application in the Partner M59
The electric layout and components are taken from the 206 Full Mux
The BSI centralises and processes signals from 4 networks:
- CAN networks: 1320, CV00 (ESP), 7025, 7806
- VAN bodywork 1 networks: BM34, CV00, 6570
- VAN bodywork 2 networks: 8602
- VAN Comfort networks: 0004, 7215, 8410
Van
Body 2
network
62.5 Ts/s
Van Body 1
network
62.5 Ts/s
CAN
Intersystem
Network
250 Kbit/s
Comfort VAN
network125 Ts/s
Notes for the multiplex layout of the first generation Partner (up to No. DAM 8610):
- BSI1
- 8410
- 0004
69
Full CAN multiplex application in the 307, 407, 607 (Z9), 807
The BSI centralises and processes signals from 3 networks:
- CAN networks: 1320, 1630, 7122, 7600, 7700, 7715, 7800, 7804
- CAN CAR networks: BSC, BSM, BSR, CV00, 1282, 5008, 8602
-C
AN Comfort networks: 0004, 6031, 6032, 6338, 6811, 7500, 8080, 8415, 8480, 6304, 6239,
6812, 6813
CAN LS COMF (125 Kbits/s)
Note:
5025, 5030 and BSC are only present on the 407 all types.
BSC is only present on the 407 Hatch and Estate BSI 2003
6304 is only present on the 407 coupe
6239, 6812, 6813 are only present on the 807
70
Multiplexing application in the Bipper
The BSI centralises and processes signals from 3 networks:
- C-CAN network: High speed CAN (500Kbits/s) connecting the BSI and the engine and transmission assembly and ABS computers.
- B-CAN network: Low speed CAN (50Kbits/s) connecting the BSI and the bodywork and comfort
function computers.
- A-BUS network: low speed network (4.8 Kbits/s) solely for the alarm function. This is composed
of a wire connecting the BSI to the computer and the movement detection alarm.
71
Multiplexing application in the Boxer III
The BSI centralises and processes signals from 3 networks:
- C-CAN: High speed CAN (500Kbits/s), connecting the BSI to the computers and the dynamic
sensors. The line terminates in the BSI computer and the Multifunction Engine computer.
- B-CAN: Low speed CAN (50Kbits/s), connecting the BSI to the passenger compartment network
computers.
- A-BUS: Proprietary network connecting the BSI, the rain/light sensor, the alarm siren and the
anti-lift sensor.
Depending on equipment
72
Multiplexing application in the Expert II
The BSI centralises and processes signals from 3 networks:
- CAN HS/IS : CAN High Speed/Inter System (500Kbits/s), connecting the BSI and the dynamic
computers.
Wires code: CAN H "9000" and CAN L "9001"
- CAN LS CONF: CAN Low Speed CONfort (125Kbits/s), connecting the BSI and the comfort
network computers.
Wires code: CAN H "9024" and CAN L "9025"
- CAN LS CAR: CAN Low Speed (body) CARosserie (125Kbits/s), connecting the BSI and the
body computers.
Wires code: CAN H "9017" and CAN L "9018"
CAN
LS COMF
TELEMATICS
Depending on equipment
73
Multiplexing application in the New Partner (B9)
The electrical architecture is composed of the following elements:
-
CAN IS: connecting all the engine and transmission assembly computers.
CAN CAR: connecting the security systems.
CAN COMFORT: forming the vehicle's Man/Machine interface.
LIN
CAN IS: diagnostic socket, which allows some computers to be downloaded from the CAN I/S
network.
- CAN DIAG: enabling downloading, remote coding and diagnostics to be carried out on the
vehicle.
74
Precaution to take when working on multiplex vehicles
- E ngine management computer:
After the disappearance of the + CC feed, the engine management computer changes to the
POWER-LATCH function.
It is then necessary to wait 1 min after the + short-circuit cut-off (the controls are off) to remove the engine management computer. If the engine fan is running, wait for it to stop.
when refitting the engine management computer, it is necessary to perform an initialisation
procedure.
- Battery:
This must always be disconnected with the ignition off.
After the disappearance of the + CC feed (the controls are off), to disconnect the battery,
wait for the BSI to go on standby for 3 minutes. If the fan is running, wait for it to
stop.
After reconnecting the battery, wait 2 mins before restarting the engine. Carry out initialisation of
the following functions:
-
Engine management computer
Electric window/sunroof
807 automatic climate control
807 SSD
Not e for
807:
To disconnect the battery:
-
Remove the battery cover
Lower the FR RH window
Cut off the + CC
Close the door
Wait 3 mins
With the window down, disconnect the battery
Note for the 607 (Z9) and 407 Coupé (DT17):
To disconnect the battery:
-
Open the boot
Wait 3 mins
Disconnect the battery
Leave the boot open
75
Initialising engine management computers
After the following procedures:
-
clearing the computer memory,
disconnecting or replacing the computer,
downloading to the computer,
disconnecting the battery,
there may be a brief moment where normal driving performance is disrupted after clearing the
memories and self-adaptives.
To prevent this, carry out the following initialisation procedures:
Procedure according to injection type
Injection type
Carry out the procedure
MM G5
BOSCH monopoint A2.2, MA3.0
BOSCH multipoint M1.2, MP3., MP3.2, MP5.1
MM G6 (without vehicle speed sensor)
MN 8P (automatic gearbox) MM AP
MM G6 (with vehicle speed sensor)
MM 8P (manual gearbox)
BOSCH multipoint MP5.1.1, MP5.2, MP7.2, MP7.3
1+4+9
1+2+4+9
1+2+3+4+9
1+2+6+9
SAGEM 4GJ
1+2+9
SAGEM SL96/SAGEM 2000
1+2+8+9
BOSCH multipoint MP3.2, MP5.2, MP7.0 / MP7.4.4
BOSCH monopoint MA3.1/MA1.7
1+6+9
MM 1AP
1+2+7+9
Siemens (Fenix) all types
1+5+9
Procedure 1:
Use the diagnostic tool to clear faults and then check that no faults are stored. If there are,
deal with the fault first.
Procedure 2 - Resetting the stepper motor:
- Switch off the ignition for 10 seconds.
- Switch on the ignition for 10 seconds.
- Start the engine.
Procedure 3 - Recognition of gears:
- Engage 1st gear and drive up to 3500 rpm.
- Engage 2nd gear and drive up to 3500 rpm.
- Reduce the speed and re-engage 1st gear.
Do the same for the other gears.
76
Procedure 4 - Richness self-adaptation:
Warm engine (engine cooling fan engaged):
- 15 minutes min road test, moving through the various engine speeds particularly 2500 and
3500 rpm, including idle speed and full load (town driving).
Procedure 5:
Warm engine (engine cooling fan engaged):
-
Switch off the ignition.
Switch on the ignition.
Clear the ECU fault memory.
Switch off the ignition.
Disconnect the ECU - reconnect the ECU (self-adaptives clearing).
Switch on the ignition for 10 seconds.
Accessories off (heated screen, climate control, etc.):
- Start the engine (without gas).
- If the vehicle is fitted with an automatic gearbox, brake and engage the IDI gear, leave the
engine running like this for 2 to 3 minutes (recognition of compensated idle speed).
Check the throttle position using the diagnostic tool (parameter measurement):
- Correct indication: THROTT. POS.: idle speed.
- If this is not the case, start again from the beginning.
Then carry out procedure 4.
Procedure 6 - Warm engine (engine cooling fan on):
-
Switch off the ignition.
Start the engine.
Leave the engine running at idle speed for a few minutes.
Carry out a 5 minute road test changing between different speeds and loads.
Decelerate at least once (for longer than 5 seconds) from an engine speed greater than
4000 rpm.
Procedure 7 - Recognition of the full load position:
Warm engine (engine cooling fan engaged):
- Drive and accelerate at full load for 2 seconds.
Procedure 8 - Recognition of gearbox gears:
- Drive and change each gear after driving for at least 50m between shifts.
- Check the status of the gearbox in the parameters.
Procedure 9 - Final verification:
- Read the faults; if there are none, end of procedure.
- If a fault is present, deal with it and restart the initialisation.
77
Initialising engine management computers
MM 4.8/MM 4MP2 / MM 6LP
To initialise the self-adaptives, use the procedure to be found in the Peugeot Planet repair
tool 2000.
Procedure:
-
ECU consultation and services,
test by ECU,
engine, automatic gearbox,
select the engine for the vehicle concerned.
In the menu, select “initialisation or programming of self-adaptives”
Bosch ME 7.4.6
After the following interventions on:
Engine management computer motorised throttle valve, accelerator pedal sensor, downloading
to or remote coding of the engine management computer, it is necessary to program the throttle
valve and accelerator pedal position.
Procedure for the throttle valve:
- switch on the ignition,
- leave the ignition on for 10 seconds (do not depress the accelerator pedal during this
phase),
- switch off the ignition and leave it off for 10 seconds.
Procedure for accelerator pedal position sensor:
-
with the accelerator pedal in rest position, switch on the ignition,
press down fully on the accelerator pedal,
release the pedal,
start the engine without accelerating.
Siemens Sirius 81 (Direct injection - HPi)
After the replacing the engine management computer, or an engine management procedure or after downloading, it is necessary to reinitialise the engine management computer
Procedure:
- switch on the ignition, wait 20 seconds,
- start the engine, let it heat up to idle speed until the engine cooling fan (GMV) is triggered
with the climate control deactivated,
- drive at low load changing through the gears,
- release the accelerator pedal several times (from 3500 to 1500 rpm),
- switch off the ignition,
- wait 1 minute before starting (if the fan station is working, wait for it to stop),
- the reinitialisation procedure is complete.
78
Maintenance indicators initialisation procedure
Maintenance key resetting procedure
Any Peugeot vehicle with a maintenance key (except BOXER):
Press the odometer button, switch on the ignition.
A countdown appears on the counter, at the end of the countdown the maintenance key
is reinitialised for the programmed period (generally between 20,000 km and 30,000 km
depending on the vehicle and engine).
It is essential to use PP2000 to alter the maintenance period.
BOXER vehicle (see also on Infotec):
The parameter setting procedure consists of selecting the appropriate maintenance interval
for the vehicle conditions of use, from the values programmed in the controls.
This procedure is carried out by remote coding:
Put the ignition key in position (ON).
Wait until the key warning light stops flashing.
Press the button at (b) for 5 seconds.
The indication (cfg1) - (cfg 2) - (cfg 3) appears, the procedure is validated.
Briefly press button (b) to select the chosen configuration (cfg‑1 - cfg 2 - cfg 3).
Press button (b) for 5 seconds to store the configuration selected.
79
1007 location
BB00 Battery - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (engine compartment)
PSF1 Engine systems interface - - - - - - - - - - - - - - - - - - - - - - (engine compartment)
BSI1 Built-in systems interface - - - - - - - - - - - - - - - - - - - - (passenger compartment)
CV00 Switching module under the steering wheel (COM2000) - - - - - (passenger compartment)
C001 Diagnostic connector - - - - - - - - - - - - - - - - - - - - - - (passenger compartment)
0004 Controls - - - - - - - - - - - - - - - - - - - - - - - - - - - - (passenger compartment)
1320 Engine management computer- - - - - - - - - - - - - - - - - - - - (engine compartment)
1660 Controlled manual gearbox ECU (BVMP) - - - - - - - - - (engine compartment on BVMP)
4736 Seat belt fastening control unit - - - - - - - - - - - - - - - (front passenger seat runner)
5007 Rain and light sensor - - - - - - - - - - - - - - - - - - - - - - - - - - - - (windscreen)
6202 Driver's door lock assembly - - - - - - - - - - - - - - - - - - - - - - - - - (driver's door)
6207 Passenger door lock assembly - - - - - - - - - - - - - - - - - - - - - (passenger's door)
6208 LH motor striker panel - - - - - - - - - - - - - - - - - - - - - - - - - - -(left-hand door)
6209 RH motor striker panel - - - - - - - - - - - - - - - - - - - - - - - - - - (right-hand door)
6222 Boot lock assembly - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (boot)
6234 Motorised door actuators cut-off module - - - - - - - - - - - - - (passenger compartment)
6239 Motorised sliding side door module - - - - - - - - - - (passenger compartment on body)
6243 Left-hand sliding side door motor - - - - - - - - - - - (passenger compartment on body)
6248 Right-hand sliding side door motor - - - - - - - - - - - (passenger compartment on body)
6272 Left lock opening actuators - - - - - - - - - - - - - - - - - - - - - - - - (left-hand door)
6273 Right lock opening actuators - - - - - - - - - - - - - - - - - - - - - - - (right-hand door)
6570 Airbags and pretensioners module - - - - - - - - - - (passenger compartment on tunnel)
6573 Driver's side impact sensor - - - - - - - - - - - - - - (passenger compartment on body)
6574 Passenger side impact sensor - - - - - - - - - - - - - (passenger compartment on body)
7020 ABS ECU - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (engine compartment)
7126 Electric power steering ECU - - - - - - - - - - - - - - - - - - - - (engine compartment)
7215 Multifunction screen - - - - - - - - - - - - - - - - - - - - - - - (passenger compartment)
7500 Parking aid ECU - - - - - - - - - - - - - - - - - - - - - (under the front passenger seat)
7510 Outer rear left-hand proximity sensor - - - - - - - - - - - - - - - - - - - - (rear bumper)
7511 Inner rear left-hand proximity sensor - - - - - - - - - - - - - - - - - - - - - (rear bumper)
7512 Outer rear right-hand proximity sensor - - - - - - - - - - - - - - - - - - - - (rear bumper)
7513 Inner rear right-hand proximity sensor - - - - - - - - - - - - - - - - - - - - (rear bumper)
7800 Electronic stability program (ESP) ECU - - - - - - - - - - - - - - - (engine compartment)
7804 Accelerometer gyrometer (ESP) - - - - - - - - - - - - - - - - - (passenger compartment)
8025 Climate control control panel - - - - - - - - - - - - - - - - - - (passenger compartment)
8080 Air conditioning ECU - - - - - - - - - - - - - - - - - - - - - - (passenger compartment)
8406 GSM/GPS/radio aerial - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (roof)
8410 Car radio - - - - - - - - - - - - - - - - - - - - - - - - - - - - (passenger compartment)
8408 Radio amplifier (JBL) - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (boot)
8415 CD changer - - - - - - - - - - - - - - - - - - - - (passenger compartment in glove box)
8480 Telematics transceiver - - - - - - - - - - - - - - - - - - - - - - (passenger compartment)
8602 Anti-Theft alarm movement detection unit - - - - (passenger compartment above the BSI)
80
81
106 S1 location up to VIN no. 51 449 999
Label
1
2
3
4
5
6
BF01A
1005
C1300
1304
1315
1320
1500A/B
C1630
1630
2305
2665
4720
5010
6020
6235
C7000
7020
7115
7121
7125
8007(A)
8005
8006
8010
8015
8015A
8035
8070
8115
8116
Component
Shunt
Fuse
Fuse
Fuse
Fuse
Fuse
Fuse holder
Relay
Connector
Double relay
Resistance
ECU
1 or 2 relays
Connector
ECU
Central
Relay
Relay
Relay
Relay
Module
Connector
ECU
Relay
Diode
Relay
Pressure switch
Relay
Sensor
Module
Relay
Relay
Thermostat
Gear motor
Relay
Timed relay
Appearance
30 Amp.
30 Amp.
20 Amp.
15 Amp.
10 Amp.
5 Amp.
Brown
Green
Brown
White
Function
ABS
ABS
Replacement
Engine cooling fan
Fuel pump
Oxygen sensor heating
Automatic gearbox ECU
Starting safety (automatic gearbox)
Injection self-diagnostic
Injection/fuel pump
Central injector
Injection/Ignition
yellow/green/purple Engine cooling fan
Blue
Automatic gearbox
Automatic gearbox
Grey
Indicators
Yellow
Fog lights
White
Lights-on reminder buzzer
Black
Wiper timer
Yellow
Sunroof + electric window
Black
Door locking
Grey
ABS self-diagnostic
ABS
Green
Power steering pump
Power steering pump
Black
Power steering pump
Air conditioning
Black
AC compressor cut-off Via 8010
Evaporator
Black
AC coolant temp. (Bitron)
Purple
AC compressor cut-off Via 1320
Black
AC compressor cut-off Via 8010
Black
Manual AC
Black
Air recirculation flap
Yellow
Heated rear screen
Orange
Heated rear screen
82
83
106 S2 location from VIN no. 51 450 000
Label
BF00
BF01
1005
1150
1203
1269
1304
1320
1508
1509A/B
1630
2305
2685
2665
4720
5010
5400
6020
6235
6542
6570
7020
7115
7125
8004
8006
8010
8035
8070
8116
8204
8206
8207
8221
Component
Fuse box
Fuse box
Relay
Module
Inertia switch
Relay
Double relay
ECU
Central
Relay
Relay
Relay
Relay
Relay
Relay
Relay
Relay
Relay
Module
Module
Module
ECU
Relay
Power relay
Module
Sensor
Module
Thermostat
Gear motor
Timed relay
Relay
Diode
Relay
Module
Appearance
Brown
Black
Green
brown or black
Function
Passenger compartment
Engine comp.
Starting safety (automatic gearbox)
Diesel preheating
Fuel supply cut-off
Inlet pipe heating resistor
Injection/fuel pump
green or purple
Engine cooling fan
green, purple or black Engine cooling fan
Automatic gearbox
Grey
Indicators
Yellow
Additional lights
Yellow
Fog lights
White
Lights-on reminder buzzer
Blue
Wiper timer
Grey
Headlight washer timer
Yellow
Sunroof + electric window
Black
Door locking
Black
Pyro seat belts
Orange
Double Airbag/pyro. seat belts
ABS
Green
Power steering pump
Grey
Power steering pump
Diesel AC cut-off
Evaporator temperature
Black
Coolant temp. (Bitron)
Black
Black
Air recirculation flap
Orange
Heated rear screen
Green
ADC TU5J2 resupply
ADC
Black
ADC Diesel resupply
Black
Transponder module
84
85
107 location
BB00
BF01
C001
0004
1320
1660
6021
6235
6570
6573
6574
7020
7126
8208
8410
Battery - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (engine compartment)
Engine fuse box - - - - - - - - - - - - - - - - - - - - - - - - - - (engine compartment)
Diagnostic connector - - - - - - - - - - - - - - - - - - - - - - (passenger compartment)
Controls - - - - - - - - - - - - - - - - - - - - - - - - - - - - (passenger compartment)
Multifunction engine management computer (CMM) - - - - - - - - (engine compartment)
Controlled manual gearbox ECU (BVMP) - - - - - - - - - - - - (passenger compartment)
Electric windows relay - - - - - - - - - - - - - - - - - - - - - (passenger compartment)
High frequency remote receiver module (HF) - - - - - - - - - (passenger compartment)
Airbags and pretensioners module - - - - - - - - - - - - - - - (passenger compartment)
Side impact LH satellite sensor - - - (passenger compartment/5 doors, rear door/3 doors)
Side impact RH satellite sensor - - - (passenger compartment/5 doors, rear door/3 doors)
ABS ECU - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (engine compartment)
Electric power steering ECU - - - - - - - - - - - - - - - - - - (passenger compartment)
Coded immobiliser module - - - - - - - - - - - - - - - - - - - (passenger compartment)
Car radio - - - - - - - - - - - - - - - - - - - - - - - - - - - - (passenger compartment)
86
Notes
87
206 location up to DAM 9064
Label
Component
Appearance
Function
"Indicators
FR/RR wiper
De-icer
Immobiliser
Lights on reminder buzzer
Ignition key reminder buzzer”
B1
BSI1
1030
1150
1246
1156
1213
1222
1302
1304
1320
1508/9
1630
25_
2665
6032
6570
6572
7020
8004
8006
8010
8035
8501
B2
“Built-in
systems
interface”
Mini-relay
Module
Relay
Relay
Mini-relay
Sensor
Relay
Double relay
ECU
Relay 1/2
ECU
Mini-relay
Mini-relay
Module
Module
Module
ECU
Module
Sensor
Module
Thermostat
Aerial
B4
“Central locking
HF remote control receiver
Courtesy light timer
Door open visual warning
Automatic wiper
Automatic gearbox audible warning”
“Deadlocking
Overspeed warning
Alarm”
Engine running
Diesel preheating
EGR/Diesel advance SV
Diesel advance solenoid valve
Blower air pump
Accelerometer
Immobiliser module power supply
Injection/fuel pump
Injection/Ignition
Engine cooling fan (GMV)
Automatic gearbox
Horn
Fog lights
Standard electric window
Airbag/pyrotechnic seat belts
Left-hand side airbag
ABS
AC compressor cut-off
Evaporator
AC coolant temp. (Bitron)
Manual AC
GPS aerial
Black
Black
Purple
Purple
Black
Black
Black/grey
Brown
Black
Black
Black
Black
Orange
Orange
Black
Black
Black
88
6572
2665
1213
1030
25--
8501
BSI1
8035
1150
6570
8010 1630
1156
1146
1302
7020
1320
8004
1304
1508
1509
89
206 location CC
Key
Component
6036
LH rear-view mirror/electric window control panel
6040
Front left electric window motor
6045
Front right electric window motor
6130
Rear left electric window motor
6135
Rear right electric window motor
6880
Open roof switch
6881
Boot switch
6883
LH locked roof switch
6884
RH locked roof switch
6885
Hydraulic pump block
6886
Curtain switch
6887
RH boot locked switch
6888
LH boot locked switch
6889
Roof closed switch
6890
Boot open switch
6891
Cover panel retracted switch
6892
Cover panel out switch
6893
Retractable roof ECU
6895
Retractable roof control
90
6884
6889
6883
6887
6888
6889
6890
6886
6036
6881
6040 driver's side
6045 passenger side
6130 driver's side
6135 passenger side
6893
6892
6891
6880
91
6885
206 Multiplex location from DAM 9065
BB00 Battery - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (engine compartment)
BM34 34-fuse engine systems interface - - - - - - - - - - - - - - - - (engine compartment)
BSI1 Built-in systems interface- - - - - - - - - - - - - - - - - - - (passenger compartment)
CV00 Switching module under the steering wheel (COM2000) - - - - (passenger compartment)
C001 Diagnostic connector - - - - - - - - - - - - - - - - - - - - - (passenger compartment)
0004 Controls - - - - - - - - - - - - - - - - - - - - - - - - - - - (passenger compartment)
1282 Diesel additive module - - - - - - - - - - - - - - - - - - - - (passenger compartment)
1320 Engine management computer - - - - - - - - - - - - - - - - - - (engine compartment)
1506 Dual speed resistor - - - - - - - - - - - - - - - - - - - (Engine cooling fan front panel)
1508 Low speed fan assembly supply relay - - - - - - - - - - (Engine cooling fan front panel)
1509 High speed fan assembly supply relay - - - - - - - - - - (Engine cooling fan front panel)
1630 Automatic gearbox ECU - - - - - - - - - - - - - - - - - - - - - (engine compartment)
2003 Driving school monitor module - - - - - - - - - - - - - - - - - - - - (glove box cover)
2520 Audible warning - - - - - - - - - - - - - - - - - - - - - - - - - - (RH side front panel)
5007 Rain and light sensor - - - - - - - - - - - - - - - - - - - - - - - - - - - (windscreen)
6036 Rear view mirror/electric window control panel - - - - - - - - - (passenger compartment)
6202 Front left-hand door lock assembly - - - - - - - - - - - - - - - - - - - - (driver's door)
6207 Front right-hand door lock assembly - - - - - - - - - - - - - - - - - (passenger's door)
6212 Rear left-hand door lock assembly - - - - - - - - - - - - - - - - - - - - (RR LH door)
6217 Rear right-hand door lock assembly - - - - - - - - - - - - - - - - - - - - (RR RH door)
6260 Boot lock motor - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (boot)
6415 Passenger rear view mirror (exterior air sensor) - - - - - - - - - - - (passenger's door)
6569 Passenger airbag deactivation switch - - - - - - - - - - - - - (passenger compartment)
6570 Airbags and pretensioners module - - - - - - - - - (passenger compartment on tunnel)
6573 Driver's side impact sensor - - - - - - - - - - - - - (passenger compartment on body)
6574 Passenger side impact sensor - - - - - - - - - - - - (passenger compartment on body)
7025 ABS hydraulic unit - - - - - - - - - - - - - - - - - - - - - - - - (engine compartment)
7215 Multifunction screen - - - - - - - - - - - - - - - - - - - - - - (passenger compartment)
8080 Air conditioning ECU - - - - - - - - - - - - - - - - - - - - - (passenger compartment)
8209 Transponder coil - - - - - - - - - - - - - - - - - - - - - - - (passenger compartment)
8410 Radio - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (passenger compartment)
8404 Radio antenna - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (roof)
8415 CD changer - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (boot)
8500 Navigation computer - - - - - - - - - - - - - - (passenger compartment in glove box)
8501 GPS aerial - - - - - - - - - - - - - - - - - - - - - - - - - (roof, 206CC RR seatback)
8602 Anti-theft alarm movement detection unit - - - (passenger compartment above the BSI)
8605 Anti-theft alarm horn - - - - - - - - - - - - - - - - - - - - - - - (engine compartment)
92
1282
93
Location 207
BCP3 3 relay protection and switching module - - - - - - - - - - - - - (engine compartment)
BMF4 Max-fuse module 4 - - - - - - - - - - - - - - - - - - - - - - - (engine compartment)
BSI1 Built-in systems interface - - - - - - - - - - - - - - - - - - - (passenger compartment)
CV00 Switching module under the steering wheel - - - - - - - - - - (passenger compartment)
PSF1 Engine systems interface (BSM) - - - - - - - - - - - - - - - - - (engine compartment)
0004 Controls - - - - - - - - - - - - - - - - - - - - - - - - - - - (passenger compartment)
1283 Fuel additive pump- - - - - - - - - - - - - - - - - - - - - - - - - - - - - (Under body)
1320 Multifunction engine management computer (CMM) - - - - - - - (engine compartment)
1660 Controlled manual gearbox computer - - - - - - - - - - - - - - (engine compartment)
2610 LH headlight - - - - - - - - - - - - - - - - - - - - - - - - - - - (engine compartment)
2615 RH headlight - - - - - - - - - - - - - - - - - - - - - - - - - - (engine compartment)
4746 Seat belt unbuckled warning light unit - - - - - - - - - - - - - (passenger compartment)
5008 Tunnel brightness sensor - - - - - - - - - - - - - - - - - - - (passenger compartment)
5015 Windscreen wiper motor - - - - - - - - - - - - - - - - - - - - - (engine compartment)
6570 Airbags and pretensioners module- - - - - - - - - - - - - - - (passenger compartment)
6606 Static Dynamic Lighting Module (EDS) - - - - - - - - - - - - (passenger compartment)
7020 ABS computer - - - - - - - - - - - - - - - - - - - - - - - - - - (engine compartment)
7126 Electric Power Steering ECU (DAE) - - - - - - - - - - - - - - (engine compartment)
7215 Multifunction screen - - - - - - - - - - - - - - - - - - - - - ((passenger compartment)
7500 Parking assistance ECU - - - - - - - - - - - - - - - - - - - - - - - - - (left rear wing)
7600 Tyre pressure control ECU - - - - - - - - - - - - - - - - - - (passenger compartment)
7800 Stability program ECU (ESP) - - - - - - - - - - - - - - - - - - (engine compartment)
7803 Steering wheel angle sensor - - - - - - - - - - - - - - - - - passenger compartment)
7804 Accelerometer gyrometer - - - - - - - - - - - - - - - - - - - (passenger compartment)
8080 Climate control control panel - - - - - - - - - - - - - - - - - (passenger compartment)
8406 Aerial amplifier - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (RR RH quarter)
8410 Radio - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (passenger compartment)
8415 CD changer - - - - - - - - - - - - - - - - - - - - - - - - - - (passenger compartment)
8480 Telematics transceiver - - - - - - - - - - - - - - - - - - - - - (passenger compartment)
8602 Anti-theft alarm movement detection unit - - - - - - - - - - - (passenger compartment)
94
95
306 N3 location up to chassis No. 32’000’000
Label
1 ( 7027)
2
3
4
5
6
1005
1156
1252
C 1300
1314
1315
1320
2305
2505
4720
5010
5400
6020
6126
6415
6235
C 6235
6540
C 6570
6570
6860
6870
6876
6875
7029
C 7000
C 8000
8005/8015 A
8015
8006
8010
8030
8031
8032
8048
8065
8070
8080
8116
8204
8206
Component
Fuse
Shunt
Fuse
Fuse
Fuse
Fuse
Relay
Relay
Relay
Connector
Altimetric sensor
Resistance
ECU
Module
Relay
Relay
Module
Relay
Relay
Relay
Temp. sensor
Module
Connector
Module
Connector
Module
Module
Relay
Diode
Relay
Maxi-fuse
Connector
Connector
Relay
Relay
Sensor
Module
Temp. sensor
Sensor
Temp. sensor
Relay
Gear motor
Gear motor
Module
Relay
Relay
Diode
Appearance
30 Amp.
Shunt
30 Amp.
30 Amp.
30 Amp.
30 Amp.
Brown
Black
Black
Green
Black
Function
Bendix ABS (Bosch)
ABS
Cooling fan assembly
Cooling fan assembly
Fuel pump
Throttle reheat. + lambda sensor
Safety (automatic gearbox)
Diesel postheating
EGR or Diesel advance correction
Injection self-diagnostic
Diesel advance correction
TU3M Injection
Injection/Ignition
Indicators
Horn compressor
Lights-on reminder buzzer
Windscreen wiper delay
Headlight washer timer
Sunroof + electric window
RR electric window
Exterior air for display
Door locking
Deadlocking self-diag
Pyrotechnic seat belts
Airbag/pyrotechnic seat belts
Airbag/pyrotechnic seat belts
Electric hood
Cabriolet hydraulic pump
Bonnet module protection
Bonnet buzzer
ABS pump
ABS self-diagnostic
Climate control self-test procedure
AC cut-off Via 8010
AC cut-off Via 1320
Evaporator temperature
Coolant temperature (AC)
Internal air (auto AC)
Heating coolant temp.
External air (auto AC)
Blower
Air mixing flap
Recirculation flap
Climate control
Rear view mirror + Heated rear screen timer
Diesel ADC power supply
Coded immobiliser
Grey
Green
White
Black
Green
Green
Black
Black
White
Alu
Black
Black
Green
50 Amp.
Grey
Brown
Black
Purple
Green
Orange
Black
96
Under the
rear seat
C6570
8204
7929
6570
6570
97
306 N5 location from chassis no. 32’000’001
Label
1005
1030
1156
1203
1244
1252
1302
1508
1509A/B
1630
2305
2665
5005
5010
5400
6020
6030
6125
6235
6570
8004
8005
8010
8048
8080
8116
8204
8206
8207
8221
8630
Component
Mini-relay
Relay
Relay
Inertia switch
Solenoid valve
Relay
Relay
Relay
Relay
ECU
Central
Relay
Relay
Module
Relay
Relay
Module
Relay
Module
Module
Module
Mini-relay
Module
Relay
Module
Relay
Relay
Diode
Relay
Module
Module
Appearance
Black
Black
Black
Black
Function
Automatic gearbox safety
Engine running
Diesel preheating
Pump cut-off in the event of an impact
Diesel EGR
EGR or Diesel advance corr.
Diesel injection supply
Engine cooling fan speed 1
Engine cooling fan speed 2
AL4 automatic gearbox
Indicators
Fog lights
Wiper with rain sensor
Windscreen wiper delay
Headlight washer timer
Sunroof + electric window
Standard electric window
RR electric window
Door locking
Airbag/pyrotechnic seat belts
Diesel AC cut-off
AC cut-off Via 1320
Coolant temperature (AC)
Blower
Climate control
Rear view mirror + Heated rear screen timer
Diesel ADC power supply
Coded immobiliser
Transponder module power supply
Immobiliser with transponder
Anti-theft from DAM 8211
Black
Black
Purple
Purple
Grey
Green
Purple
Black
Green
Green
Alu
Black
Black
Green
Orange
Black
Black
Black
Black
98
8221
5010
6570
8630
from AM99
under the seat
6235
6235
Cabriolet
1508
1509
6030
1030
8048
2305
2665
8116
6125
5005
6020
1630
8204
8207
1244
1302
1203
1156
8005
1005
8010
8004
1252
1150
1304
99
5400
307 location
BB00
BM34
BSI1
CP00
CP01
CV00
C001
0004
1282
1320
1506
1508
1509
1630
2003
2521
2522
5001
6005
6031
6032
6036
6202
6207
6212
6217
6237
6260
6415
6551
6552
6569
6570
6573
6574
6820
7025
7806
7122
7215
7804
8080
8033
8209
8410
8415
8480
8484
8602
Battery - - - - - - - - - - - - - - - - - - - - - - - - - - - - (engine compartment)
34-fuse engine systems interface - - - - - - - - - - - - - - - (engine compartment)
Built-in systems interface - - - - - - - - - - - - - - - - - (passenger compartment)
Rear 12 V socket - - - - - - - - - - - - - - - - - - - - - (passenger compartment)
Front 12 V socket - - - - - - - - - - - - - - - - - - - - - - passenger compartment)
Switching module under the steering wheel (COM2000) - - (passenger compartment)
Diagnostic connector - - - - - - - - - - - - - - - - - - - - (passenger compartment)
Controls - - - - - - - - - - - - - - - - - - - - - - - - - - (passenger compartment)
Fuel additive computer - - - - - - - - - - - - - - - - - - - - - - (under the LH seat)
Engine management computer - - - - - - - - - - - - - - - - - (engine compartment)
Dual speed resistor - - - - - - - - - - - - - - - - - - - - (Fan assembly front panel)
Low speed fan assembly supply relay - - - - - - - - - - - (Fan assembly front panel)
High speed fan assembly supply relay - - - - - - - - - - - (Fan assembly front panel)
Automatic gearbox ECU - - - - - - - - - - - - - - - - - - - - (engine compartment)
Driving school monitor module - - - - - - - - - - - - - - - (passenger compartment)
Low-tone audible warning - - - - - - - - - - - - - - - - - - - (FR LH wing/bumper)
High-tone audible warning - - - - - - - - - - - - - - - - - - - (FR LH wing/bumper)
Rain sensor - - - - - - - - - - - - - - - - - - (passenger compartment/windscreen)
RH door RH electric window switch - - - - - - - - - - - - - - - - (passenger's door)
Front passenger-side standard electric window motor + unit - - - - (passenger's door)
Front driver's side standard electric window motor + unit - - - - - - - - (driver's door)
rear view mirror/electric window control panel - - - - - - - - - - - - - (driver's door)
Front left-hand door lock assembly - - - - - - - - - - - - - - - - - - - (driver's door)
Front right door lock assembly - - - - - - - - - - - - - - - - - - - (passenger's door)
Rear left-hand door lock assembly - - - - - - - - - - - - - - - - - - - (RR LH door)
Rear right-hand door lock assembly - - - - - - - - - - - - - - - - - - (RR RH door)
Boot unlocking switch - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (boot)
Boot lock motor - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (boot)
Passenger rear view mirror (exterior air sensor) - - - - - - - - - - (passenger's door)
Right-hand curtain airbag module - - - - - - - - - - - - - - - - - - - - - - - - (roof)
Left-hand curtain airbag module - - - - - - - - - - - - - - - - - - - - - - - - (roof)
Passenger airbag deactivation switch - - - - - - - - - - - - - - - - (centre console)
Airbags and pretensioners module - - - - - - - - (passenger compartment on tunnel)
Driver's side impact sensor - - - - - - - - - - - - (passenger compartment on body)
Passenger side impact sensor - - - - - - - - - - - (passenger compartment on body)
Sunroof assembly - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (roof)
ABS hydraulic unit - - - - - - - - - - - - - - - - - - - - - - - - - - - (left front wing)
ESP hydraulic unit - - - - - - - - - - - - - - - - - - - - - - - - - - - (left front wing)
Power-assisted steering pump assembly - - - - - - - - - - - - - - - (right front wing)
Multifunction screen - - - - - - - - - - - - - - - - - - - - (passenger compartment)
Gyrometer/accelerometer sensor - - - - - - - - - (passenger compartment on tunnel)
Air conditioning ECU - - - - - - - - - - - - - - - - - - - - (passenger compartment)
Brightness thermistor - - - - - - - - - - - - - - - - - - - (passenger compartment)
Transponder coil - - - - - - - - - - - - - - - - - - - - - - (passenger compartment)
Car radio - - - - - - - - - - - - - - - - - - - - - - - - - (passenger compartment)
CD changer - - - - - - - - - - - - - - - - - - - - - - - - (passenger compartment)
Telematics transceiver - - - - - - - - - - - - - - - - - - - (passenger compartment)
Radiotelephone aerial - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (roof)
Anti-theft alarm movement detection unit - - - - - - - - - - - - - - - - (left front wing)
100
1282
101
307 Full Can location
BB00 Battery - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (engine compartment)
BM34 34-fuse engine systems interface - - - - - - - - - - - - - - - - (engine compartment)
BSI1 Built-in systems interface - - - - - - - - - - - - - - - - - - (passenger compartment)
BSR Trailer systems interface - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (boot)
CP00 Rear 12 V socket - - - - - - - - - - - - - - - - - - - - - - (passenger compartment)
CP01 Front 12 V socket - - - - - - - - - - - - - - - - - - - - - (passenger compartment)
CV00 Switching module under the steering wheel (COM2000) - - - (passenger compartment)
C001 Diagnostic connector - - - - - - - - - - - - - - - - - - - - (passenger compartment)
0004 Controls - - - - - - - - - - - - - - - - - - - - - - - - - - (passenger compartment)
1282 Fuel additive computer - - - - - - - - - - - - - - - - - - - (passenger compartment)
1320 Engine management computer - - - - - - - - - - - - - - - - - (engine compartment)
1630 Automatic gearbox ECU - - - - - - - - - - - - - - - - - - - - - (engine compartment)
2003 Driving school monitor module - - - - - - - - - - - - - - - (passenger compartment)
2521 Low-tone audible warning - - - - - - - - - - - - - - - - - - - - (FR LH wing/bumper)
2522 High-tone audible warning - - - - - - - - - - - - - - - - - - - - (FR LH wing/bumper)
5001 Rain sensor - - - - - - - - - - - - - - - - - - - (passenger compartment/windscreen)
5007 Rain/light sensor - - - - - - - - - - - - - - - - (passenger compartment/windscreen)
6005 RH door RH electric window switch - - - - - - - - - - - - - - - - - (passenger's door)
6031 Front passenger-side standard electric window motor + unit - - - - - (passenger's door)
6032 Front driver's side standard electric window motor + unit - - - - - - - - - (driver's door)
6036 Driver's side rear view mirror/electric window control panel - - - - - - - (driver's door)
6100 RR LH electric window rear switch - - - - - - - - - - - - - (passenger compartment)
6105 RR RH electric window rear switch - - - - - - - - - - - - - (passenger compartment)
6130 RR LH electric window motor - - - - - - - - - - - - - - - - (passenger compartment)
6135 RR RH electric window motor - - - - - - - - - - - - - - - - (passenger compartment)
6202 Front left-hand door lock assembly - - - - - - - - - - - - - - - - - - - (driver's door)
6207 Front right-hand door lock assembly - - - - - - - - - - - - - - - - - (passenger's door)
6212 Rear left-hand door lock assembly - - - - - - - - - - - - - - - - - - - - (RR LH door)
6213 FR LH exterior door handle sensor - - - - - - - - - - - - - - - - - - - - (FR LH door)
6214 FR RH exterior door handle sensor - - - - - - - - - - - - - - - - - - - (FR RH door)
6217 Rear right-hand door lock assembly - - - - - - - - - - - - - - - - - - - (RR RH door)
6237 Boot unlocking switch - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (boot)
6260 Boot lock motor - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (boot)
6415 Passenger rear view mirror (exterior air sensor) - - - - - - - - - - - (passenger's door)
6551 Right-hand curtain airbag module - - - - - - - - - - - - - - - - - - - - - - - - (roof)
6552 Left-hand curtain airbag module - - - - - - - - - - - - - - - - - - - - - - - - - (roof)
6558 Rear right-hand roll bar - - - - - - - - - - - - - - - - - - - (passenger compartment)
6559 Rear left-hand roll bar - - - - - - - - - - - - - - - - - - - - (passenger compartment)
6562 Chest and head front right side airbag module - - - - - - - - (passenger compartment)
6563 Chest and head front left side airbag module - - - - - - - - (passenger compartment)
6569 Passenger airbag deactivation switch - - - - - - - - - - - - - - - - - (centre console)
6570 Airbags and pretensioners module - - - - - - - - (passenger compartment on tunnel)
6573 Driver's side impact sensor - - - - - - - - - - - - - (passenger compartment on body)
6574 Passenger side impact sensor - - - - - - - - - - - (passenger compartment on body)
6820 Sunroof assembly - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (roof)
6852 Retractable roof adjustment solenoid valve - - - - - - - - - - - - (hydraulic pump unit)
6853 Retractable roof hydraulic unit R1 relay - - - - - - - - - - - - - - (hydraulic pump unit)
6854 Retractable roof hydraulic unit R2 relay - - - - - - - - - - - - - - (hydraulic pump unit)
6858 Left hinged cover switch - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (boot)
6858 ccarg = stored hinged cover,
6858 ccadg = deployed hinged cover,
6859 Right hinged cover switch, - - - - - - - - - - - - - - - - - - - - - - - - - - - (boot)
6859 ccard = stored hinged cover
102
6859 ccadd = deployed hinged cover,
6878 LH closed roof switch - - - - - - - - - - - - - - - - - - - - - - - (windscreen frame)
6880 Open roof switch - - - - - - - - - - - - - - - - - - - - - - (passenger compartment)
6882 Retractable roof hinged cover motor - - - - - - - - - - - - - - - - - - - - - - (boot)
6883 LH locked roof switch - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (roof)
6884 RH locked roof switch - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (roof)
6885 Hydraulic pump unit - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (boot)
6893 Retractable roof ECU - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (boot)
6895 Central electric window/retractable roof switch plate - - - - - (passenger compartment)
6896 Retractable roof boot assembly (computer) - - - - - - - - - - - - - - - - - - - (boot)
6897 LH locked boot switch - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (boot)
6898 RH locked boot switch - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (boot)
6899 Open boot switch - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (boot)
6900 Luggage cover curtain switch - - - - - - - - - - - - - - - - - - - - - - - - - - (boot)
7025 ABS hydraulic unit - - - - - - - - - - - - - - - - - - - - - - - - - - - (left front wing)
7122 Power-assisted steering pump assembly - - - - - - - - - - - - - - - (right front wing)
7215 Multifunction screen - - - - - - - - - - - - - - - - - - - - (passenger compartment)
7500 Parking aid ECU - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (boot)
7510 Outer rear left-hand proximity sensor - - - - - - - - - - - - - - - - - - (rear bumper)
7511 Inner rear left-hand proximity sensor - - - - - - - - - - - - - - - - - - (rear bumper)
7512 Outer rear right-hand proximity sensor - - - - - - - - - - - - - - - - - (rear bumper)
7513 Inner rear right-hand proximity sensor - - - - - - - - - - - - - - - - - (rear bumper)
7600 Tyre pressure control ECU - - - - - - - - - - - - - - - - - (passenger compartment)
7804 Gyrometer/accelerometer sensor - - - - - - - - - (passenger compartment on tunnel)
7800 ESP - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (left front wing)
8038 brightness sensor - - - - - - - - - - - - - - - - - - - - - (passenger compartment)
8080 Air conditioning control panel - - - - - - - - - - - - - - - - (passenger compartment)
8404 Aerial - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (boot)
8406 Aerial amplifier - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (boot)
8410 Car radio - - - - - - - - - - - - - - - - - - - - - - - - - - (passenger compartment)
8415 CD changer - - - - - - - - - - - - - - - - - - - - - - - - (passenger compartment)
8480 Telematics transceiver - - - - - - - - - - - - - - - - - - - (passenger compartment)
8484 Radiotelephone aerial - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (roof)
8492 Hands-free kit - - - - - - - - - - - - - - - - - - - - - - - (passenger compartment)
8501 GSM/GPS aerial - - - - - - - - - - - - - - - - (passenger compartment/windscreen)
8602 Anti-theft alarm movement detection unit - - - (passenger compartment above the BSI)
8605 Anti-theft alarm horn - - - - - - - - - - - - - - - - - - - - - - - - - - (left front wing)
V1 Right-hand boot stay - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (boot)
V2 Left-hand boot stay - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (boot)
V3 Right-hand roof stay - - - - - - - - - - - - - - - - - - - - - (passenger compartment)
V4 Left-hand roof stay - - - - - - - - - - - - - - - - - - - - - - (passenger compartment)
V5 Roof lock stay - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (roof)
103
104
Notes
105
308 location
BB00 Battery- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (engine compartment)
BB00 Battery- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (engine compartment)
BCP3 3 relay protection and switching module- - - - - - - - - - - - - - - - - - - (engine compartment)
BFBD Fuse box from battery- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (engine compartment)
BSI1 Built-in systems interface 1- - - - - - - - - - - - - - - - - - - - - - - - - - (passenger compartment)
BSR1 Trailer systems interface- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (left rear wing)
CV00 Switching module under the steering wheel - - - - - - - - - - - - - - - - - - - - - - - (dashboard)
C001 Diagnostic connector- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (dashboard)
PSF1 Engine systems interface (BSM) - - - - - - - - - - - - - - - - - - - - - - - - (engine compartment)
0004 Controls - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (dashboard)
1283 Fuel additive pump - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (fuel tank)
1320 Multifunction engine management computer (CMM)- - - - - - - - - - - (engine compartment)
1630 Automatic gearbox computer - - - - - - - - - - - - - - - - - - - - - - - - - - - (engine compartment)
1660 Controlled manual gearbox computer - - - - - - - - - - - - - - - - - - - - - (engine compartment)
4746 Belt unbuckled warning lights unit- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (roof)
5008 Tunnel light sensor- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (windscreen)
6031 Front passenger-side standard electric window motor + unit- - - - - - - - - - - - - - - - (door)
6032 Front driver's side standard electric window motor + unit- - - - - - - - - - - - - - - - - - - (door)
6036 Driver's door rear view mirror/electric window control panel- - - - - - - - - - - - - - - - - (door)
6131 Rear right electric window + motor - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (door)
6132 Rear left electric window + motor - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (door)
6338 Seat memory unit - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (passenger compartment)
6404 Passenger door mirror memory and lighting unit- - - - - - - - - - - (passenger compartment)
6570 Airbags and pretensioners module - - - - - - - - - - - - - - - - - - - - - - - - - - - (centre console)
6606 Headlight dynamic correction unit- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (left wing)
7122 Power-assisted steering pump assembly- - - - - - - - - - - - - - - - - - - (engine compartment)
7215 Multifunction screen- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (passenger compartment)
7500 Parking aid ECU - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (left rear wing)
7550 Lateral trajectory monitoring computer- - - - - - - - - - - - - - - - - - - - - - - - - - - - (dashboard)
7600 Tyre pressure control ECU- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (centre console)
7800 Stability program ECU (ESP) - - - - - - - - - - - - - - - - - - - - - - - - - - - (engine compartment)
7804 Stability program accelerometer gyrometer - - - - - - - - - - - - - - - - - - - - - (centre console)
8025 Air conditioning control panel - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (dashboard)
8080 Air conditioning ECU - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (dashboard)
8410 Car radio- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (dashboard)
8415 CD changer- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (dashboard)
8424 Audio amplifier- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (boot)
8480 Telematics transceiver - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (dashboard)
8492 Hands-free kit - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (centre console)
8602 Anti-theft alarm movement detection unit- - - - - - - - - - - - - - - - - - - - - - - - - - (dashboard)
106
107
405 location from AM93
Label
1
2
3
4
1250
1304
1314
1500
2305
2505
2665
3005
4720
5010
6020
6030
Component
Relay
Relay
Relay
Relay
Relay
10 amp fuse
10 amp fuse
15 amp. fuse
10 amp fuse
Connector
Connector
Relay
ECU
ECU
Relay
Relay
Fuse
Fuse
1 or 2 fuses
1 or 2 shunts
Fuse
Fuse
Module
Double relay
Sensor
2 or 3 relays
Central
Relay
Relay
Relay
Relay
Module
Relay
Module
Appearance
Purple
Purple
Purple
Purple
Black
Wires 122/123
Wires 120/121
Wires 126/127
Wires B45/BB26
Green
Grey
Pink
Black
Green
5 Amp.
30 Amp.
30 Amp.
20 Amp.
30 Amp.
Black
Brown
Black
Black
Grey
Green
Green
Black
White
Function
Diesel advance corrector
Diesel postheating
Automatic gearbox starting safety
AC cut-off Via 1320
Turbocharger coolant pump
Oxygen sensor heating
Fuel pump
Throttle valve heat.
Turbocharger coolant pump
Injection/ignition self-diag.
ABS self-diag
Headlight washer timer
Injection/Ignition
ABS
AC cut-off Via 8010
Lights
X4 Susp. level regulation
ABS
Engine cooling fans
X4 Susp. level regulation
RR diff. locking SRI X4
Diesel EGR
Injection/fuel pump
Diesel advance corr.
Engine cooling fans
Indicators
Horn compressor
Fog lights
Courtesy light timer
Lights-on reminder buzzer
Windscreen wiper delay
Sunroof + electric window
Standard electric window
Green
108
405 location from AM93 (cont.)
Label
Component
6126
6235
6540
6625
6630
6631
6636
6637
C 6640
6720
6740
7016
7307
7310
8006
8010
8030
8032
8048
8080
8116
Relay
Elec. module
Module
Switch
Relay
Relay
Relay
Relay
Connector
Module
Relay
Sensor
Relay
Module
Sensor
Elec. module
Temp. sensor
Temp. sensor
Relay
Module
Relay
8206
Diode
Appearance
Green
Function
RR electric window
Door locking
Pyrotechnic seat belts
RR susp. top position
Handbrake signal
Brake pedal signal
Ride height corr. pump
Ride height corr. solenoid valve
Ride height corr. circuit bleed
Differential lock
Differential lock
Accelerometer
Cruise control safety
Cruise control
Evaporator temperature
Coolant temp. (AC)
Internal air (auto AC)
External air (auto AC)
Blower
Climate control
Black
Purple
Purple
Purple
Purple
Brown
Black
Purple
Black
Green
Black
Yellow
Orange
Rear view mirror + Heated rear screen
timer
Coded immobiliser
109
110
Notes
111
406 location (D8)
Component
Label
Function
Appearance
BMF…
M. fuse box
see owner's manual
BMF3
M. fuse box
Add. heater. (HDI)
BF2
Fuse box
1005
Relay
Purple
Automatic gearbox starting safety
1030
Mini-relay
Black
Engine running
1230
Relay
Green
Add. heater. (HDI)
1304
Double relay
Brown
Inject./fuel pump.
1320
ECU
1325
ECU
1500
Relay 1/3
1625
Module
1630
ECU
2305
Central
Grey
Indicators
2505
Relay
Green
Horn compressor
2665
Mini-relay
Black
FR fog lights
4440
Module
4720
Relay
White
Lights-on reminder buzzer
5001
Sensor
Black
Wiper rain detection
5002
Relay
Black
Low speed wiper
5003
Relay
Black
High-speed wiper
5010
Module
Yellow
Timed wiper
6020
Relay
Yellow
Sunroof + electric window
6030
Module
6125
Relay
6230
Receiver
6231
Receiver
6235
Elec. module
6301
Module
Black
Rear view mirror/seat mem.
6407
Module
Blue
Folding rear view mirror
6560
Module
Orange
Airbags/pyro seat belts
7020
ECU
7105
ECU
7307
Relay
Purple
Cruise control
7310
Module
Black
Cruise control
7715
ECU
Suspension
8010
Elec. module
Coolant temp. (AC)
8030
Temp. sensor
Automatic A/C inter. air
8033
Sensor
Brightness
8080
Module
8116
Relay
8206
Diode
8221
Module
8600
Module
see owner's manual
Inject./ignition
Diesel injection
Black
Engine cooling fans
Speed interface
Automatic gearbox
Blown bulb detection
Anti-p./Sequ. elec. window
Brown
RR electric window
IR locking
Black
HF locking
Door locking
ABS
Var. power steering
Automatic climate control
Orange
Heated screen + rear view mirror
Coded immobiliser
Black
Transponder module
Anti-theft alarm
112
6030
6020 6125
4720
7307
6407
Coupé
1230B+C
1030
2665
1230A
7105
5010
8116 5002 5003
ADC: Activation LED
Part no.: 6555.QG,
to DAM no.: 7324 in
bottom of the centre pillar
from DAM: 7324 FR LH
113
BMF3
406 D9 location from chassis no. 80,800,000
Label
Component
Appearance
Function
Indicators, hazard warning lights
Blown bulbs
Reversing light
Windscreen wiper
De-icer
Locking
HF remote control
Immobiliser
Timed interior lighting
B0
B2
Sunroof + electric window power supply
Lights on reminder audible + visual warning
B1
BSI
B3
Built-in
systems
interface
Ignition key reminder buzzer
B4
Automatic gearbox safety buzzer
Overspeed buzzer
HF remote battery buzzer
Transponder buzzer
Battery charge visual warning
Doors audible + visual warning
Counter (Odometer)
Computer
Rain sensor
Air conditioning
RR wiper and switch Tailgate
Door sills lighting
Deadlocking
BSM
Engine systems interface
See owner's manual
1005
Relay
Purple
Automatic gearbox starting safety
1304
Double relay
Brown
Injection/fuel pump
1320
ECU
1325
1 or 3 relays
1500
ECU
1630
Relay
2505
Sensor
Green
Horn compressor
5001
Module
Black
Wiper rain detection
6030
Module
6301
Module
Black
Rear view mirrors/seat mem.
6407
Module
Blue
Rear view mirror fold in
6560
Module
Orange
Airbags/pyro seat belts
7020
ECU
ABS
7105
ECU
Variable power-assisted steering
7715
ECU
Suspension
8010
Elect. module.
Coolant temperature (AC)
8030
Temp. sensor
Interior air for automatic air conditioning
8033
Sensor
Brightness
8501
Aerial
GPS aerial
Injection/Ignition
Diesel injection
Black
Engine cooling fans
Automatic gearbox
Anti-pinch + seq. electric window
114
6030
6407
Coupé
Shunt
1242
1005
2505
7105
115
406 D9 location from DAM 9001
Label
BSI
Component
Built-in
systems
interface
Appearance
B0
B1
B2
B3
B4
Function
B5
B6
Indicators, hazard warning lights
Blown bulbs
Reversing light
Windscreen wiper
De-icer
Locking
HF remote control
Immobiliser
Timed interior lights
Sunroof + electric window power supply
Lights on reminder audible + visual warning
Ignition key reminder aud. + vis. warning
Automatic gearbox safety aud. + vis. warning
Overspeed buzzer
HF remote battery aud. + vis. warning
Transponder aud. + vis. warning
Battery charge visual warning
Doors audible + visual warning
Counter (Odometer)
Trip computer
Rain sensor
Air conditioning
RR wiper + tailgate switch
Headlights washer timer
Door sill lighting
Deadlocking
Alarm
Engine ECU
Automatic gearbox
Steering wheel angle sensor
ESP ECU
Fuel additive ECU
1005
1030
1242
1304
1320
1500
1625
1630
2400
2505
2665
4440
5001
6230
6231
6235
6301
6560
7310
7715
7801
7804
7805
8030
8033
8080
8221
8501
Starter inhibit relay
Engine running signal relay
Blower relay
Double multifunction relay
Engine management computer
Cooling fan assembly relay (MFU)
Vehic. speed interface mod
Automatic gearbox ECU
Daytime running lights/side lights relay
Horn compressor relay
Fog lights relay
Blown bulb detection unit
Rain sensor
Remote lock. IR receiver
116
Locking HF receiver
Locking module
Rear view mirror/seats mem. module
Airbag computer
Cruise control ECU
Suspension ECU
ESP/Traction control cut-off switch
ESP accelerom. gyrometer
ESP pre-loading pump
Passenger compartment air thermistor
Brightness thermist.
Air conditioning ECU
Transponder control module
GPS aerial
7800
ESP ECU
117
406 D9 location from DAM 9001
Location: 406 Full Multiplex from 2001
Ref.
Part
Ref.
Part
BB00
Battery
6569
RH airbag deactivation switch
BM34
Engine compartment fuse box
6570
Airbags and pretensioners module
BSI1
BSI
6573
Driver's side impact sensor
CP01
FR 12 V socket
6574
Passenger side impact sensor
CV00
Diagnostic connector
7025
ABS hydraulic unit
0004
Controls
7105
Power steering computer
1282
Fuel additive ECU
7215
Multifunction screen
1320
Engine management computer
7800
ESP ECU
1506
Dual speed resistor
7804
Gyrometer/accelerometer sensor
1508
Cooling fan assembly supply
relay (low speed)
7806
ESP hydraulic unit
1509
Cooling fan assembly supply
relay (high speed)
8033
Brightness thermistor
1630
Automatic gearbox ECU
8080
Air conditioning ECU
1800
Gas ECU (LPG)
8209
Transponder coil
2521
Low tone horn
8408
Amplifier (JBL) RR RH or RR LH
2522
High tone horn
8410
Car radio
5007
Rain/light sensor
8415
CD changer
6005
Right-hand electric window switch 8500
6036
Rear view mirror/electric window
control panel
6202
Front left door lock assembly
6207
Front right door lock assembly
8602
Anti-theft alarm movement
detection module
6212
RR LH door lock assembly
8605
Anti-theft alarm siren
6217
RR RH door lock assembly
6260
Boot lock motor
6415
Passenger rear view mirror.
and air sensor
8501
118
Navigation computer
GPS aerial (hatch/coupé
rear parcel shelf/roof estate)
119
Location 407
BSI1 Built-in systems interface (BSI) - - - - - - - - - - - - - - - - - (passenger compartment)
PSF2 Boot systems interface (BSC) - - - - - - - - - - - - - - - - - - - - - - - (left rear wing)
PSF1 Engine systems interface (BSM) - - - - - - - - - - - - - - - - - - (engine compartment)
BSR1 Trailer systems interface (BSR) - - - - - - - - - - - - - - - - - - - - - - (left rear wing)
C001 Diagnostic connector - - - - - - - - - - - - - - - - - - - - - - (passenger compartment)
CV00 Switching module under the steering wheel - - - - - - - - - - - (passenger compartment)
0004 Controls - - - - - - - - - - - - - - - - - - - - - - - - - - - - (passenger compartment)
1282 Fuel additive computer - - - - - - - - - - - - - - - - - - - - - (passenger compartment)
1320 Engine ECU - - - - - - - - - - - - - - - - - - - - - - - - - - - - (engine compartment)
1630 Automatic gearbox ECU - - - - - - - - - - - - - - - - - - - - - - - (engine compartment)
2610 Left-hand headlight - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (front)
2615 Right-hand headlight - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (front)
5008 Rain/light sensor - - - - - - - - - - - - - - - - - - - - - - - - (passenger compartment)
5025 Front left wiper motor - - - - - - - - - - - - - - - - - - - - - - - - (engine compartment)
5030 Front right wiper motor - - - - - - - - - - - - - - - - - - - - - - - (engine compartment)
6031 Passenger standard front electric window motor + unit - - - - - - (passenger compartment)
6032 Driver's standard front electric window motor + unit - - - - - - - (passenger compartment)
6237 Boot unlocking switch - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (boot)
6260 Boot lock motor - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (boot)
6338 Driver's seat position memory module - - - - - - - - - - - - - - (passenger compartment)
6566 Right rear side airbag module - - - - - - - - - - - - - - - - - - (passenger compartment)
6567 Left rear side airbag module - - - - - - - - - - - - - - - - - - - (passenger compartment)
6570 Airbags and pretensioners modules - - - - - - - - - - - - - - - (passenger compartment)
6577 Rear left pretensioner - - - - - - - - - - - - - - - - - - - - - - (passenger compartment)
6578 Rear right pretensioner - - - - - - - - - - - - - - - - - - - - - (passenger compartment)
6580 Rear left side impact sensor - - - - - - - - - - - - - - - - - - - (passenger compartment)
6581 Rear right side impact sensor - - - - - - - - - - - - - - - - - - (passenger compartment)
6811 One-touch sunroof motor - - - - - - - - - - - - - - - - - - - - (passenger compartment)
7122 Power-assisted steering pump assembly - - - - - - - - - - - - - - (engine compartment)
7215 Multifunction screen - - - - - - - - - - - - - - - - - - - - - - - (passenger compartment)
7500 Parking aid ECU - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (boot)
7510 Outer rear left-hand proximity sensor - - - - - - - - - - - - - - - - - - - - (rear bumper)
7511 Inner rear left-hand proximity sensor - - - - - - - - - - - - - - - - - - - - - (rear bumper)
7512 Outer rear right-hand proximity sensor - - - - - - - - - - - - - - - - - - - - (rear bumper)
7513 Inner rear right-hand proximity sensor - - - - - - - - - - - - - - - - - - - - (rear bumper)
7600 Tyre pressure control ECU - - - - - - - - - - - - - - - - - - - (passenger compartment)
7700 Steering wheel angle sensor - - - - - - - - - - - - - - - - - - (passenger compartment)
7715 Suspension system ECU - - - - - - - - - - - - - - - - - - - - - - - - - (left rear wing)
7800 Stability program ECU - - - - - - - - - - - - - - - - - - - - - - - (engine compartment)
7804 ESP accelerometer gyrometer - - - - - - - - - - - - - - - - - - (passenger compartment)
8033 Brightness sensor - - - - - - - - - - - - - - - - - - - - - - - - (passenger compartment)
8080 Air conditioning control panel - - - - - - - - - - - - - - - - - - (passenger compartment)
8099 Additional heating igniter - - - - - - - - - - - - - - - - - - - - - - (engine compartment)
8408 Audio amplifier - - - - - - - - - - - - - - - - - - - - - - - - - (passenger compartment)
8415 CD charger - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (right rear wing)
8426 Bass speaker - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (right rear wing)
8480 Telematics unit - - - - - - - - - - - - - - - - - - - - - - - - - (passenger compartment)
8602 Anti-theft alarm movement detection unit - - - - - - - - - - - - (passenger compartment)
8605 Anti-theft alarm horn - - - - - - - - - - - - - - - - - - - - - - - - - - - (left front wing)
120
121
Location 407 Coupé
BSI1 Built-in systems interface - - - - - - - - - - - - - - - - - - (passenger compartment)
BSR1 Trailer systems interface - - - - - - - - - - - - - - - - - - - - - - - - (left rear wing)
CV00 Switching module under the steering wheel - - - - - - - - - (passenger compartment)
PSF1 Engine systems interface (BSM) - - - - - - - - - - - - - - - - (engine compartment)
0004 Controls - - - - - - - - - - - - - - - - - - - - - - - - - - (passenger compartment)
1320 Multifunction engine management computer (CMM) - - - - - - - (engine compartment)
1630 Automatic gearbox ECU - - - - - - - - - - - - - - - - - - - - - (engine compartment)
2610 Left-hand headlight - - - - - - - - - - - - - - - - - - - - - - - (engine compartment)
2615 Right-hand headlight - - - - - - - - - - - - - - - - - - - - - - (engine compartment)
5008 Tunnel light sensor - - - - - - - - - - - - - - - - - - - - - (passenger compartment)
5025 Left-hand wiper motor - - - - - - - - - - - - - - - - - - - - - - (engine compartment)
5030 Right-hand wiper motor - - - - - - - - - - - - - - - - - - - - - (engine compartment)
6031 Passenger standard front electric window motor + unit - - - - (passenger compartment)
6032 Driver's standard front electric window motor + unit - - - - - (passenger compartment)
6338 Seat memory module - - - - - - - - - - - - - - - - - - - - (passenger compartment)
6304 Seat position memory module (passenger) - - - - - - - - - (passenger compartment)
6570 Airbags and pretensioners module - - - - - - - - - - - - - - (passenger compartment)
6606 Dynamic correction of headlights module - - - - - - - - - - (passenger compartment)
7122 Power-assisted steering pump assembly (except ES/DT) - - - - (engine compartment)
7215 Multifunction screen - - - - - - - - - - - - - - - - - - - - - (passenger compartment)
7500 Parking aid ECU - - - - - - - - - - - - - - - - - - - - - - - - - - - (right rear wing)
7600 Tyre pressure control ECU - - - - - - - - - - - - - - - - - (passenger compartment)
7715 Suspension ECU - - - - - - - - - - - - - - - - - - - - - - - - (engine compartment)
7800 ESP ECU - - - - - - - - - - - - - - - - - - - - - - - - - - - - (engine compartment)
7804 Accelerometer gyrometer - - - - - - - - - - - - - - - - - - (passenger compartment)
8080 Climate control front panel - - - - - - - - - - - - - - - - - (passenger compartment)
8415 CD charger - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (right rear wing)
8480 Telematics transceiver - - - - - - - - - - - - - - - - - - - - (passenger compartment)
8602 Anti-theft alarm movement detection unit - - - - - - - - - - (passenger compartment)
122
123
Location 4007
BSI1 Built-in systems interface (BSI)
CV00 Switching module under the steering wheel.- - - - - - - - - - - - - (passenger
0004 Controls - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (passenger
1282 Fuel additive computer- - - - - - - - - - - - - - - - - - - - - - - - - - - - - (passenger
1320 Engine ECU - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (engine
1650 Continuously variable transmission ECU- - - - - - - - - - - - - - - - - - - (engine
6005 Passenger door electric window switch
6036 Driver control panel
6100 Left rear electric window switch
6105 Right rear electric window switch
6570 Airbag computer
6750 Rear axle controlled clutch computer
6830 Sunroof unit
7020 ABS system
7800 Electronic stability program (ASC/ESP) computer
7803 Steering wheel angle sensor (ASC/ESP)
7804 Accelerometer gyrometer (ASC/ESP)
8080 Air conditioning ECU
8208 Locking and immobiliser control module
8410 Car radio
8480 Telematics transceiver
8492 Bluetooth hands-free kit unit
124
compartment)
compartment)
compartment)
compartment)
compartment)
125
605 engine compartment location
Label
1
2
3
4
5
6
7
8
9
10
11
Component
Connectors
ECU 1320
ECU 1325
ECU 7020
ECU 7715
Module 8010 (Bitron)
Double relay 1304
Controller 7100
Relay 1302
Relay 1005
Relay 1246
Relay 1127
Relay 1200
Relay 1345
Relay 8015
Appearance
Black
Brown
Brown
Purple
Brown
Yellow
Yellow
Purple
Black
AC compress. cut-off via ECU
1320
Relay 8016
Purple
2 fuses
1 fuse shunt
1 fuse
1 fuse
Connector
2 or 3 relays 1500
1 relay 2505
ECU 7050
Module 6032
30 Amp.
40 Amp.
30 Amp.
30 Amp.
Brown
Wires 126..
Wires 23/24
Black
Function
Self-diagnosis
Injection/Ignition
Diesel injection
ABS
Suspension
Coolant temperature (AC)
Inject./fuel pump from AM93
Mechatronic steering
Injection
BVAEGR starting safety
Diesel
Ignition ZP J4
Fuel pump
Oxygen sensor heating
AC cut-off via module 8010
Engine cooling fans
ABS
Horn compressor
Replacement
Clim. lockup from ch 90.807.392
Engine cooling fans
Horn
ASR + ABS Traction control
Anti-pinch electric window
126
605 Passenger compartment location
Label
C001
1030
1625
2305
2665
3005
4440
4720
5010
5400
6020
6025
6030
6125
6126
6231
6235
6540
6541
6560
7307
7310
8006
8030
8031
8032
8035
8048
8080
8115
8116
Component
Connector
Relay
Module
Central
Relay
Relay
Module
Relay
Module
Relay
Relay
Relay
Module
Relay
Relay
Module
Module
Module
Module
ECU
Relay
ECU
Sensor
Sensor
Sensor
Sensor
Module
Relay
Module
Relay
Relay
Appearance
Function
Diagnostic
Engine running power supply
Speed interface
Indicators
Fog lights
Courtesy light timer
Blown brake light bulb
Lights-on reminder buzzer
Wiper
Headlight washer timer
Sunroof + FR electric window
Sunroof + electric window resupply
Standard electric window
RR electric window
+AA RR electric window
Locking HF receiver
Locking
LH pyro seat belts
RH pyro seat belts
Airbag
Cruise control safety
Cruise control
Evaporator temp.
Passenger compartment air temp.
Heating temp.
External air temp.
AC thermostat
Blower
Automatic AC
Heated rear screen
Timed heated screen
Green
Black
Grey
Green
Black
Black
White
Blue
Pink
Green
Black
Black
Green
Green
Black
Black
Black
Black
orange
Green
Grey
Black
Yellow
Orange
127
607 location (Z8)
BB00 Battery - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (engine compartment)
BB01 battery assembly - - - - - - - - - - - - - - - - - - - - - - - - - (luggage compartment)
BCP3 3 relay protection and switching module. - - - - - - - - - - - - - - (engine compartment)
BM34 34-fuse engine systems interface - - - - - - - - - - - - - - - - - - (engine compartment)
BMF1 maxi-fuse module - - - - - - - - - - - - - - - - - - - - - - - - - (engine compartment)
BMF2 maxi-fuse module - - - - - - - - - - - - - - - - - - - - - - - - (luggage compartment)
BSI1 built-in systems interface - - - - - - - - - - - - - - - - - - - - (passenger compartment)
C001 diagnostic connector - - - - - - - - - - - - - - - - - - - - - - (passenger compartment)
0004 controls - - - - - - - - - - - - - - - - - - - - - - - - - - - - (passenger compartment)
1025 dual battery unit - - - - - - - - - - - - - - - - - - - - - - - - - - (engine compartment)
1150 pre-heating module - - - - - - - - - - - - - - - - - - - - - - - - (engine compartment)
1203 inertia switch - - - - - - - - - - - - - - - - - - - - - - - - - - - - (engine compartment)
1282 fuel additive - - - - - - - - - - - - - - - - - - - - - - - - - - - (luggage compartment)
1304 engine management multifunction double relay - - - - - - - - - - - (engine compartment)
1320 engine management computer - - - - - - - - - - - - - - - - - - - (engine compartment)
1630 automatic gearbox ECU - - - - - - - - - - - - - - - - - - - - - - (engine compartment)
5001 rain sensor - - - - - - - - - - - - - - - - - - - - - - - - - - - (passenger compartment)
6036 rear view mirror/electric window control panel - - - - - - - - - - - - - - - - (driver's door)
6037 rear view mirror/electric window control panel - - - - - - - - - - - - - (passenger's door)
6231 central locking high frequency receiver - - - - - - - - - - - - - - - - - (rear parcel shelf)
6301 rear view mirror + seat position memory module - - - - - - - - (passenger compartment)
6551 right side curtain airbag module - - - - - - - - - - - - - - - - (passenger compartment)
6552 left side curtain airbag module - - - - - - - - - - - - - - - - - (passenger compartment)
6570 airbag and pretensioners ECU - - - - - - - - - - - - - - - - - (passenger compartment)
6573 driver's side impact detector - - - - - - - - - - - - - - - - - - (passenger compartment)
6574 passenger side impact detector - - - - - - - - - - - - - - - - (passenger compartment)
6605 headlight leveller module - - - - - - - - - - - - - - - - - - - - (passenger compartment)
6610 left headlight leveller motor - - - - - - - - - - - - - - - - - - - - - (engine compartment)
6615 right headlight leveller motor - - - - - - - - - - - - - - - - - - - - (engine compartment)
6616 front body height sensor - - - - - - - - - - - - - - - - - - - - - - (engine compartment)
6617 rear body height sensor - - - - - - - - - - - - - - - - - - - - - - - - - - - (under body)
6820 sunroof assembly - - - - - - - - - - - - - - - - - - - - - - - (passenger compartment)
7020 ABS ECU - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (engine compartment)
7025 ABS hydraulic unit (GPF) - - - - - - - - - - - - - - - - - - - - - - - - - - - (front wing)
7201 colour display control module - - - - - - - - - - - - - - - - - - (passenger compartment)
7215 multifunction screen - - - - - - - - - - - - - - - - - - - - - - (passenger compartment)
7500 parking aid ECU - - - - - - - - - - - - - - - - - - - - - - - - - (luggage compartment)
7504 parking aid rear speakers - - - - - - - - - - - - - - - - - - - - - - - (rear parcel shelf)
7510 proximity sensor - - - - - - - - - - - - - - - - - - - - - - - - (outer - left rear bumper)
7511 proximity sensor - - - - - - - - - - - - - - - - - - - - - - - - (inner - left rear bumper)
7512 proximity sensor - - - - - - - - - - - - - - - - - - - - - - - - (outer - right rear bumper)
7513 proximity sensor - - - - - - - - - - - - - - - - - - - - - - - - (inner - right rear bumper)
7600 tyre pressure control ECU - - - - - - - - - - - - - - - - - - - - - - - (rear parcel shelf)
7715 suspension ECU - - - - - - - - - - - - - - - - - - - - - - - - (passenger compartment)
7720 left-hand front shock absorber actuator - - - - - - - - - - - - - - - (engine compartment)
7723 accelerometer - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (left front wing)
7725 right-hand front shock absorber actuator
7730 left-hand rear shock absorber actuator
7735 right-hand rear shock absorber actuator
7800 stability program ECU - - - - - - - - - - - - - - - - - - - - - - - - - - (left front wing)
7803 stability program steering wheel angle sensor - - - - - - - - - (passenger compartment)
7804 stability program gyrometer - - - - - - - - - - - - - - - - - - - (passenger compartment)
7805 engine management preload pump - - - - - - - - - - - - - - - - - - - - (left front wing)
7806 stability program hydraulic assembly - - - - - - - - - - - - - - - - (engine compartment)
128
8080
8408
8409
8410
8415
8482
8484
8500
8501
8602
8700
9056
air conditioning ECU - - - - - - - - - - - - - - - - - - - - - - (passenger compartment)
radio amplifier - - - - - - - - - - - - - - - - - - - - - - - - - - (luggage compartment)
heated rear screen aerial assembly - - - - - - - - - - - - - - (passenger compartment)
radio - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (passenger compartment)
CD changer - - - - - - - - - - - - - - - - - - - - - - - - - - - (luggage compartment)
radiotelephone microphone - - - - - - - - - - - - - - - - - - - (passenger compartment)
radiotelephone aerial - - - - - - - - - - - - - - - - - - - - - - - - - - - - (rear bumper)
navigation computer - - - - - - - - - - - - - - - - - - - - - - - (luggage compartment)
GPS aerial - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (rear parcel shelf)
Anti-theft alarm movement detection unit - - - - - - - - - - - - (passenger compartment)
electric blind motor - - - - - - - - - - - - - - - - - - - - - - - - - - - (rear parcel shelf)
automatic lighting ECU - - - - - - - - - - - - - - - - - - - - - - - (engine compartment)
129
607 location (Z9)
BB00 Battery - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (boot left side)
BB10 Power supply module - - - - - - - - - - - - - - - - - - - - - - - - - - - (boot left side)
BB12 + battery connection terminal - - - - - - - - - - - - - - - - - - - - (engine compartment)
BCP3 3 relay protection and switching module - - - - - - - - - - - - - - (engine compartment)
BSI1 Built-in systems interface - - - - - - - - - - - - - - - - - - - - (passenger compartment)
BSR1 Trailer systems interface - - - - - - - - - - - - - - - - - - - - - - - - - (boot left side)
C001 Diagnostic connector - - - - - - - - - - - - - - - - - - - - - - (passenger compartment)
CV00 Switching module under the steering wheel - - - - - - - - - - - (passenger compartment)
PSF1 Fuse box - control panel (BSM) - - - - - - - - - - - - - - - - - - - (engine compartment)
0004 Controls - - - - - - - - - - - - - - - - - - - - - - - - - - - - (passenger compartment)
1158 Pre/postheating control unit - - - - - - - - - - - - - - - - - - - - - (engine compartment)
1282 Fuel additive computer - - - - - - - - - - - - - - - - - - - - - - - - - - - (boot left side)
1320 Engine management computer - - - - - - - - - - - - - - - - - - - (engine compartment)
1630 Automatic gearbox ECU - - - - - - - - - - - - - - - - - - - - - - - (engine compartment)
5008 Rain/Light/Tunnel Sensor - - - - - - - - - - - - - - - - - - - - (passenger compartment)
6036 Rear view mirror/electric window control panel - - - - - - - - - - - - - - - - (driver's door)
6037 Rear view mirror/electric window control panel - - - - - - - - - - - - - (passenger's door)
6222 Boot locking assembly - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (boot)
6265 Fuel filler flap lock motor - - - - - - - - - - - - - - - - - - - - - - - - - (right rear wing)
6289 Boot electric striker plate - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (boot)
6290 Boot manoeuvre unit - - - - - - - - - - - - - - - - - - - - - - - - - - - (boot right side)
6301 Rear view mirror + seat position memory module - - - - - - - - (passenger compartment)
6570 Airbags and pretensioners module - - - - - - - - - - - - - - - (passenger compartment)
6573 Driver's side impact sensor - - - - - - - - - - - - - - - - - - - (passenger compartment)
6574 Passenger side impact sensor - - - - - - - - - - - - - - - - - (passenger compartment)
6605 Headlight leveller unit - - - - - - - - - - - - - - - - - - - - - - (passenger compartment)
6610 Left-hand headlight leveller module - - - - - - - - - - - - - - - - - (engine compartment)
6615 Right-hand headlight leveller module - - - - - - - - - - - - - - - - (engine compartment)
6616 Front body height sensor - - - - - - - - - - - - - - - - - - - - - - - - - - (under body)
6617 Rear body height sensor - - - - - - - - - - - - - - - - - - - - - - - - - - - (under body)
7215 Multifunction screen - - - - - - - - - - - - - - - - - - - - - - - (passenger compartment)
7500 Parking aid ECU - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (boot right side)
7506 Outer front left-hand proximity sensor - - - - - - - - - - - - - - - - - - - (front bumper)
7507 Inner front left-hand proximity sensor - - - - - - - - - - - - - - - - - - - - (front bumper)
7508 Outer front right-hand proximity sensor - - - - - - - - - - - - - - - - - - - (front bumper)
7509 Inner front right-hand proximity sensor - - - - - - - - - - - - - - - - - - - (front bumper)
7510 Outer rear left-hand proximity sensor - - - - - - - - - - - - - - - - - - - - (rear bumper)
7511 Inner rear left-hand proximity sensor - - - - - - - - - - - - - - - - - - - - - (rear bumper)
7512 Outer rear right-hand proximity sensor - - - - - - - - - - - - - - - - - - - - (rear bumper)
7513 Inner rear right-hand proximity sensor - - - - - - - - - - - - - - - - - - - - (rear bumper)
7600 Tyre pressure control ECU - - - - - - - - - - - - - - - - - - - - - - - - (boot right side)
7715 Suspension ECU - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (left front wing)
7720 Left-hand front shock absorber actuator - - - - - - - - - - - - - - - (engine compartment)
7725 Right-hand front shock absorber actuator - - - - - - - - - - - - - - (engine compartment)
7730 Left-hand rear shock absorber actuator - - - - - - - - - - - - - - - - - - - (under body)
7735 Right -hand rear shock absorber actuator - - - - - - - - - - - - - - - - - - (under body)
7751 Left-hand front body height sensor - - - - - - - - - - - - - - - - - - - - - - (under body)
7752 Right-hand front body height sensor - - - - - - - - - - - - - - - - - - - - - (under body)
7753 Left-hand rear body height sensor - - - - - - - - - - - - - - - - - - - - - - (under body)
7754 Right-hand rear body height sensor - - - - - - - - - - - - - - - - - - - - - (under body)
7800 Stability program ECU - - - - - - - - - - - - - - - - - - - - - - - (engine compartment)
7804 Stability program accelerometer gyrometer - - - - - - - - - - - (passenger compartment)
8080 Air conditioning ECU - - - - - - - - - - - - - - - - - - - - - - (passenger compartment)
8406 Aerial amplifier (RT3) (GPS/GSM) - - - - - - - - - - - - - - - - - - - - - - - - - - (roof)
130
8408 Radio amplifier (JBL) - - - - - - - - - - - - - - - - - - - - - - - - - - - (boot left side)
8409 Heated rear screen aerial assembly (AM-FM1) - - - - - - - - - - (Left-hand rear screen)
8409 Heated rear screen aerial assembly (FM2) - - - - - - - - - - - - (Right-hand rear screen)
8410/8480 Radio/Radiotelephone transceiver - - - - - - - - - - - - - (passenger compartment)
8415 CD changer - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (boot right side)
8482 Radiotelephone microphone - - - - - - - - - - - - - - - - - - - (passenger compartment)
8492 Hands-free kit - - - - - - - - - - - - - - - - - - - - - - - - - - (passenger compartment)
8602 Anti-theft alarm movement detection unit - - - - - - - - - - - - (passenger compartment)
8700 Electric blind motor - - - - - - - - - - - - - - - - - - - - - - - - - - - (rear parcel shelf)
131
806/Expert location
Label
PSF1
1156
1203
1204
1252
1304
1320
1506
2305
3005
4720
5010
6020
6030
6125
6235
6407
6542
6570
6830
7000
7020
8004
8006
8010
8033
8035
8048
8080
8116
8204
8206
8207
8308
8630
Component
Control plate
Relay
Module
Relay
Relay
Double relay
ECU
Resistance
Central
Relay
Relay
Module
Relay
Module
Relay
Module
Module
Module
Module
Module
Fuse holder
ECU
Module
Sensor
Module
Sensor
Module
Relay
ECU
Relay
Relay
Diode
Relay
Relay
Module
Appearance
Purple
Black
Black
Purple
Brown
Grey
Black
Bench
Green
Red
Green
Brown
Black
Orange
Black
Black
Black
Black
Green
Panel
Orange
Black
Black
Black
Black
132
Function
Relays, fuses (key, see cover)
Postheating
Inertia switch
Inertia switch
EGR/Advance correct.
Injection/Ignition
Injection/Ignition
Cooling fan assembly
Indicators
Courtesy light timer
Lights-on reminder buzzer
Windscreen wiper delay
Sunroof + electric window
Standard electric window
RR electric window
Door locking
Folding rear view mirrors
Pyrotechnic seat belts
Airbag/pyrotechnic seat belts
Sunroof anti-pinch
Bosch 5.3 ABS
Bosch 5.3 ABS
AC cut-off (Diesel)
Evaporator temp.
Coolant temp. (AC)
Brightness
AC thermostat
Blower
Automatic A/C
Rear view mirror + Heated rear screen timer
Diesel ADC power supply
Coded immobiliser
Diesel ADC power supply
Heated seat
Passenger compartment protection unit (CPH)
8004
8204
8207
8098
1506
1242
1241
C7001
2400
8048
8206
8308
E811 1642 4720
2305
ICA1B
IC95
C001
BF00 5010
IC91E
133
8115 6021 4740
807 location
BB00 Battery - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (passenger compartment)
BH12 Passenger compartment 12-fuse box - - - - - - - - - - - - - - (passenger compartment)
BM34 34-fuse engine systems interface - - - - - - - - - - - - - - - - - - (engine compartment)
BSI1 Built-in systems interface - - - - - - - - - - - - - - - - - - - - - - - - - - - (glove box)
CV00 Switching module under the steering wheel (COM2000) - - - - (passenger compartment)
C001 Diagnostic connector - - - - - - - - - - - - - - - - - - - - - - (passenger compartment)
0004 Controls - - - - - - - - - - - - - - - - - - - - - - - - - - - - (passenger compartment)
1150 Pre-heating unit - - - - - - - - - - - - - - - - - - - - - - - - - - (engine compartment)
1241 Pulsair pump - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (front bumper)
1282 Fuel additive computer - - - - - - - - - - - - - - - - - - - - - - - - (behind glove box)
1320 Engine management computer - - - - - - - - - - - - - - - - - - - (engine compartment)
1506 Engine cooling fan dual speed resistor - - - - - - - - - - - - - - - (engine compartment)
1508 / 1509 High/low speed engine cooling fan power supply relay - - - - (engine compartment)
1630 Automatic gearbox ECU - - - - - - - - - - - - - - - - - - - - - - (engine compartment)
2520 Horn - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (engine compartment)
4645 / 9035 Odometer/warning lights electronic module (BTO) - - - - (passenger compartment)
5001 Rain sensor - - - - - - - - - - - - - - - - - - - - (passenger compartment/windscreen)
6202 Front left-hand door lock assembly - - - - - - - - - - - - - - - - - - - - - (driver's door)
6207 Front right-hand door lock assembly - - - - - - - - - - - - - - - - - (passenger's door)
6237 Boot unlocking switch - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (boot)
6239 Sliding side door module - - - - - - - - - - - - - - - - - - - - (passenger compartment)
6243 Left-hand sliding side door motor - - - - - - - - - - - - - - - - (passenger compartment)
6248 Right-hand sliding side door motor - - - - - - - - - - - - - - - (passenger compartment)
6250 Rear left-hand door locking motor - - - - - - - - - - - - - - - - - - - - - (left rear door)
6255 Rear right-hand door locking motor - - - - - - - - - - - - - - - - - - - - (right rear door)
6260 Boot lock motor - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (boot)
6263 Left-hand door child safety motor - - - - - - - - - - - - - - - - - - - - - (left rear door)
6264 Child safety relay - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (glove box)
6267 Right-hand door child safety motor - - - - - - - - - - - - - - - - - - - - (right rear door)
6272 Left lock opening actuator - - - - - - - - - - - - - - - - - - - - - - - - - (left rear door)
6273 Right lock opening actuator - - - - - - - - - - - - - - - - - - - - - - - (right rear door)
6301 Seat memory ECU - - - - - - - - - - - - - - - - - - - - - - - - (under the driver's seat)
6415 Passenger rear view mirror (exterior air sensor) - - - - - - - - - - - - (passenger's door)
6551 Right-hand curtain airbag module - - - - - - - - - - - - - - - - - - - - - - - - - (roof)
6552 Left-hand curtain airbag module - - - - - - - - - - - - - - - - - - - - - - - - - - (roof)
6569 Passenger airbag deactivation switch - - - - - - - - - - - - - - (passenger compartment)
6570 Pretensioners and airbag module - - - - - - - - - - - - - - - - - - - - - (under the floor)
6573 Front left side impact sensor - - - - - - - - - - - - - - - - - - - - - - - (under the floor)
6574 Front right side impact sensor - - - - - - - - - - - - - - - - - - - - - - (under the floor)
6610 / 6615 RH/LH headlight leveller - - - - - - - - - - - - - - - - - - - - - (LH/RH headlight)
6616 Front body height sensor - - - - - - - - - - - - - - - - - - - - (passenger compartment)
6617 Rear body height sensor - - - - - - - - - - - - - - - - - - - - (passenger compartment)
6811 One-touch sunroof motor - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (roof)
6812 Row 2 one-touch sunroof motor - - - - - - - - - - - - - - - - - - - - - - - - - - - (roof)
6813 Row 3 one-touch sunroof motor - - - - - - - - - - - - - - - - - - - - - - - - - - - (roof)
7025 / 7806/7800 ABS/ESP hydraulic unit - - - - - - - - - - - - - - - - - (engine compartment)
7215 Multifunction screen - - - - - - - - - - - - - - - - - - - - - - (passenger compartment)
7500 Parking assistance ECU/C200 socket - - - - - - - - - - - - - (passenger compartment)
7510 Outer rear left-hand proximity sensor - - - - - - - - - - - - - - - - - - - - (rear bumper)
7511 Inner rear left-hand proximity sensor - - - - - - - - - - - - - - - - - - - - (rear bumper)
7512 Outer rear right-hand proximity sensor - - - - - - - - - - - - - - - - - - - (rear bumper)
7513 Inner rear right-hand proximity sensor - - - - - - - - - - - - - - - - - - - (rear bumper)
7804 Gyrometer/accelerometer sensor - - - - - - - - - - - - - - - - - - - - - (under the floor)
134
8007
8030
8033
8050
8053
8054
8080
8086
8087
8099
8410
8415
8417
8482
8484
8486
8501
8503
8602
8603
8605
9030
9050
Pressure switch - - - - - - - - - - - - - - - - - - - - - - - - - - (engine compartment)
Passenger compartment air thermistor - - - - - - - - - - - - - (passenger compartment)
Light/brightness dual sensor - - - - - - - - - - - - - - - - - - - - - - (instrument panel)
Blower motor - - - - - - - - - - - - - - - - - - - - - - - - - - (passenger compartment)
Left-hand additional blower speed switch - - - - - - - - - - - - (passenger compartment)
Right-hand additional blower speed switch - - - - - - - - - - - (passenger compartment)
Air conditioning ECU - - - - - - - - - - - - - - - - - - - - - - (passenger compartment)
Left-hand additional blower unit - - - - - - - - - - - - - - - - (passenger compartment)
Right-hand additional blower unit - - - - - - - - - - - - - - - - (passenger compartment)
Additional heating igniter - - - - - - - - - - - - - - - - - - - - - - - - - - (under body)
/ 8480 Radio/telematics - - - - - - - - - - - - - - - - - - - - - (passenger compartment)
CD changer - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (glove box)
Radio receiver/transmitter fan - - - - - - - - - - - - - - - - - (passenger compartment)
Radiotelephone microphone - - - - - - - - - - - - - - - - - - (passenger compartment)
Radiotelephone aerial - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (roof)
External video audio input unit - - - - - - - - - - - - - - - - - (passenger compartment)
GPS aerial - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (roof)
Control keypad - - - - - - - - - - - - - - - - - - - - - - - - - (passenger compartment)
Anti-theft alarm movement detection unit - - - - - - - - - - - - - - - (behind glove box)
Anti-theft alarm switch - - - - - - - - - - - - - - - - - - - - - (passenger compartment)
Anti-theft alarm siren - - - - - - - - - - - - - - - - - - - - - - - - - - (right front wing)
Front left-hand door station - - - - - - - - - - - - - - - - - - - (passenger compartment)
Front right-hand door station - - - - - - - - - - - - - - - - - - (passenger compartment)
135
807 location
6264
8030
136
Notes
137
807 Full Can location
BB00 Battery - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (passenger compartment)
BH12 Passenger compartment 12-fuse box - - - - - - - - - - - - - - (passenger compartment)
BMF1 Fuse box from battery - - - - - - - - - - - - - - - - - - - - - (passenger compartment)
BSI1 Built-in systems interface - - - - - - - - - - - - - - - (front RH passenger compartment)
BSR1 Trailer systems interface - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (boot)
C001 Diagnostic connector - - - - - - - - - - - - - - - - - - - - - - (passenger compartment)
CV00 Switching module under the steering wheel (COM2003) - - - - - (passenger compartment)
MFAV Front fuse information display - - - - - - - - - - - - - - - - - - - (engine compartment)
PSF1 34-fuse engine systems interface (BM34) - - - - - - - - - - - - - - (engine compartment)
0004 Controls - - - - - - - - - - - - - - - - - - - - - - - - - - - - (passenger compartment)
1150 Pre/postheating module - - - - - - - - - - - - - - - - - - - - - - - (engine compartment)
1282 Fuel additive computer - - - - - - - - - - - - - - - - - - - - - (passenger compartment)
1320 Engine management computer - - - - - - - - - - - - - - - - - - - (engine compartment)
1630 Automatic gearbox ECU - - - - - - - - - - - - - - - - - - - - - - - (engine compartment)
4645 Odometer/warning lights electronic module - - - - - - - - - - - (passenger compartment)
5007 Rain/light sensor - - - - - - - - - - - - - - - - - - (passenger compartment/windscreen)
6031 Passenger standard front actuator - - - - - - - - - - - - - - - - - - - - - (right front door)
6032 Driver's standard front actuator - - - - - - - - - - - - - - - - - - - - - - (left front door)
6202 Front left-hand door lock assembly - - - - - - - - - - - - - - - - - - - - - (left front door)
6207 Front right-hand door lock assembly - - - - - - - - - - - - - - - - - - - - (right front door)
6234 Door actuators cut-off module (BCAP) - - - - - - - - - - - - - - (passenger compartment)
6237 Boot unlocking switch - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (boot)
6239 Sliding side door module - - - - - - - - - - - - - - - - - - - - (passenger compartment)
6243 Left-hand sliding side door motor - - - - - - - - - - - - - - - - (passenger compartment)
6248 Right-hand sliding side door motor - - - - - - - - - - - - - - - (passenger compartment)
6250 Rear left-hand door locking motor - - - - - - - - - - - - - - - - - - - - - - (left rear door)
6255 Rear right-hand door locking motor - - - - - - - - - - - - - - - - - - - - (right rear door)
6260 Boot lock motor - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (boot)
6263 Left-hand door child safety motor - - - - - - - - - - - - - - - - - - - - - - (left rear door)
6267 Right-hand door child safety motor - - - - - - - - - - - - - - - - - - - - (right rear door)
6272 Left lock opening actuator - - - - - - - - - - - - - - - - - - - - - - - - - - (left rear door)
6273 Right lock opening actuator - - - - - - - - - - - - - - - - - - - - - - - - (right rear door)
6301 Seat memory ECU - - - - - - - - - - - - - - - - - - - - - - - - (under the driver's seat)
6415 RH rear view mirror (exterior air temperature sensor) - - - - - - - - - - - (right front door)
6551 Right-hand curtain airbag module - - - - - - - - - - - - - - - - - - - - - - - - - - (roof)
6552 Left-hand curtain airbag module - - - - - - - - - - - - - - - - - - - - - - - - - - - (roof)
6569 Passenger airbag deactivation switch - - - - - - - - - - - - - - - - - - - (centre console)
6570 Airbags and pretensioners module - - - - - - - - - - (passenger compartment on tunnel)
6573 Driver's side impact sensor - - - - - - - - - - - - - - - - - - - - - - - - (under the floor)
6574 Passenger side impact sensor - - - - - - - - - - - - - - - - - - - - - - (under the floor)
6610 Left-hand headlight leveller - - - - - - - - - - - - - - - - - - - - - - (left-hand headlight)
6615 Right-hand headlight leveller - - - - - - - - - - - - - - - - - - - - (right-hand headlight)
6616 Front body height sensor - - - - - - - - - - - - - - - - - - - - (passenger compartment)
6617 Rear body height sensor - - - - - - - - - - - - - - - - - - - - (passenger compartment)
6811 One-touch sunroof motor - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (roof)
6812 Row 2 one-touch sunroof motor - - - - - - - - - - - - - - - - - - - - - - - - - - (roof)
6813 Row 3 one-touch sunroof motor - - - - - - - - - - - - - - - - - - - - - - - - - - (roof)
7122 Power-assisted steering pump assembly- - - - - - - - - - - - - - - - - - (left front wing)
7215 Multifunction screen - - - - - - - - - - - - - - - - - - - - - - (passenger compartment)
7500 Parking aid ECU - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (boot)
7510 Outer rear left-hand proximity sensor - - - - - - - - - - - - - - - - - - - - (rear bumper)
7511 Inner rear left-hand proximity sensor - - - - - - - - - - - - - - - - - - - - (rear bumper)
7512 Outer rear right-hand proximity sensor - - - - - - - - - - - - - - - - - - - (rear bumper)
7513 Inner rear right-hand proximity sensor - - - - - - - - - - - - - - - - - - - (rear bumper)
138
7600
7804
7806
8050
8053
8054
8080
8086
8087
8099
8410
8415
8417
8480
8482
8484
8486
8491
8501
8503
8602
8603
8605
Tyre pressure control ECU - - - - - - - - - - - - - - - (rear left passenger compartment)
Gyrometer/accelerometer sensor - - - - - - - - - - - - - - - - - - - - - (under the floor)
ESP hydraulic unit - - - - - - - - - - - - - - - - - - - - - - - - - (engine compartment)
Blower motor - - - - - - - - - - - - - - - - - - - - - - - - - (passenger compartment)
Left-hand additional blower speed switch - - - - - - - - - - - - (passenger compartment)
Right-hand additional blower speed switch - - - - - - - - - - - (passenger compartment)
Air conditioning ECU - - - - - - - - - - - - - - - - - - - - - - (passenger compartment)
Left-hand additional blower unit - - - - - - - - - - - - - - - - (passenger compartment)
Right-hand additional blower unit - - - - - - - - - - - - - - - - (passenger compartment)
Additional heating igniter - - - - - - - - - - - - - - - - - - - - - - - - - - (under body)
Car radio - - - - - - - - - - - - - - - - - - - - - - - - - - - (passenger compartment)
CD changer - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (glove box)
Radio receiver/transmitter fan - - - - - - - - - - - - - - - - - (passenger compartment)
Telematics transceiver - - - - - - - - - - - - - - - - - - - - - (passenger compartment)
Radiotelephone microphone - - - - - - - - - - - - - - - - - - (passenger compartment)
Radiotelephone aerial - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (roof)
External video audio input unit - - - - - - - - - - - - - - - - - (passenger compartment)
Aerial switching unit (Diversity) - - - - - - - - - - - - - - - - - - - - - - - - - - - (boot)
GPS aerial - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (roof)
Control keypad - - - - - - - - - - - - - - - - - - - - - - - - - (passenger compartment)
Anti-theft alarm movement detection unit - - - - - - - - - - - - (passenger compartment)
Anti-theft alarm switch - - - - - - - - - - - - - - - - - - - - - (passenger compartment)
Anti-theft alarm horn - - - - - - - - - - - - - - - - - - - - - - - - - (behind glove box)
139
807 Full Can location
140
Notes
141
Partner location (M49) up to 2002 model
Label
Component
Appearance
Function
BF00
Fuse box
Passenger compartment
BF01
Fuse box
Engine comp.
1030
Relay
1086
Relay
Black
Starter cut-off via alarm
1150
Module
Black
Diesel preheating
1202
Tachom. relay.
Brown
EGR (DW8 engine)
1203
Inertia switch
1246
Relay
Black
EGR function power supply
1252
Relay
Black
Diesel advance correction
1269
Relay
Green
Inlet pipe heating resistor
1304
Double relay
Brown
Injection/fuel pump
1320
ECU
1500
Relay
Green
Engine cooling fan
1504
Relay
gr or bl
Engine cooling fan
1508
Relay
Green
Engine cooling fan
1509
Relay
Green
Engine cooling fan
2305
Central
Grey
Indicators
2665
Relay
Yellow
Fog lights
4720
Relay
White
Lights-on reminder buzzer
5010
Relay
Blue
Wiper timer
5210
Relay
5400
Relay
Grey
Headlights washer timer
6020
Relay
Yellow
Sunroof + electric window
6030
Module
6031
Module
Black
HF locking receiver
6235
Module
Black
Door locking
6542
Module
Black
Pyrotechnic seat belts
6570
Module
Orange
Airbag/pyrotechnic seat belts
7020
ECU
8004
Module
8005
Relay
Black
AC cut-off by 1320
8010
Module
Black
Coolant temp. (Bitron)
8015
Relay
Yellow
AC cut-off by 8010
8035
Thermostat
Black
Manual AC
8048
Relay
Black
Blower power supply
8115
Relay
8116
Timed relay
8221
Module
Transponder module
8617
Relay
Alarm siren
Engine running
Fuel supply cut-off
Injection/Ignition
Rear screen wiper timer
Standard electric window
ABS
AC cut-off
Heated rear screen
Orange
Heated rear screen
142
8221
8004
6231
8035
1320
1504
1508
1509
7020
6542
6570
1086
6030
1203
6235
1304
8010
2665
1500
8005
1150
4720
5400
1252
1246
BF00
5210
8617
1030
8116
BF01
7803
2305
1269
8015
BMF1
8048
8115
5010
6020
BMF2
BSI from No. DAM 8610:
Multiplex management: radio,
controls, electronic immobiliser, opening element, alarm, air conditioning,
audio, wiping and washing, lighting,
signalling.
1.
2.
3.
4.
5.
143
1030:
2605:
2400:
8308:
5401:
Engine running signal relay
Dipped headlights relay
Daytime running lights relay
Heated seats relay
Headlight washer relay
Restyled partner location (from 2003 model)
BB00
BM34
BSI1
CV00
C001
0004
1320
6202
6207
6250
6255
6256
6258
6569
6570
6573
6574
7025
7215
8025
8099
8209
8404
8406
8410
8602
Battery
34-fuse engine systems interface
Built-in systems interface
(COM2000) Communication module under the steering wheel
Diagnostic connector
Controls
Engine management computer
Front left-hand door lock assembly
Front right-hand door lock assembly
Rear left-hand door locking motor
Rear right-hand door locking motor
Rear hatch locking motor
Rear right-hand hinged door locking motor
Passenger airbag deactivation switch
Airbags and pretensioners module
Left side impact sensor
Right side impact sensor
ABS hydraulic unit
Multifunction screen
Air conditioning control panel
Additional heating igniter
Transponder coil
Radio aerial
Aerial amplifier
Car radio
Anti-theft alarm movement detection unit
144
145
Partner III location (B9)
BB00
Battery
BSI1
Built-in systems interface
BSR1
Tow support unit
BTC
Body transformer unit
CV00
(COM2000) Communication module under the steering wheel
PSF1
Fuse support board – engine compartment
C001
Diagnostic connector
0004
Controls
1320
Engine management computer
5007
Rain/light sensor
6570
Airbags and pretensioners module
7122
Power-assisted steering pump assembly
7215
Multifunction screen
7500
Parking aid ECU
7600
Tyre pressure control ECU
7020/7800 Electronic stability program (ESP) computer or anti-lock braking system (ABS)
computer
7803
Steering wheel angle sensor
7804
Accelerometer and gyrometer dual sensor (dynamic stability control)
8080
Air conditioning ECU
8410
Car radio
8415
CD changer
8480
Telematics transceiver
8492
Hands-free kit
8602
Anti-theft alarm movement detection unit
146
147
Boxer location up to chassis No. 17’000’000
17
Label
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
Component
Appearance
Function
1320
Fuse
Fuse
Double relay 1304
2 relays 1500
SV canister
1/2 fuse.
1 fuse
Module 1150
Inertia switch A
Connector
Connector
Relay 1526
Relay 8005
10 Amp.
10 Amp.
Brown
Black con.
Brown
30 / 50 Amp.
30 Amp.
Black con.
Black con.
Grey
Green
Blue con.
Brown con.
Injec. Ignition
Fuel pump
Lambda sensor
Injection/fuel pump
Engine cooling fan
Fuel vapour recirculation
Engine cooling fan
ABS
Diesel pre/postheating
Fuel pump cut-off
ABS self-diagnostic
Injection self-diagnostic
Cooling fan assembly timer (A/C)
1st speed blower + compressor cut-off (AC)
Relay 8015
Black con.
AC compress. cut-off via ECU 1320
Module 4309
Relay 2305
Relay 8061
Relay 8115
Relay 1204
Relay 6021
Relay 1005
Relay 2605
Relay 2606
Relay 1156
Relay 8048
Relay 1252
6235
ECU 7020
Module 8221
6v white
Blue con.
White con.
Purple con.
Green con.
Green/yellow con.
Red con.
White con.
White con.
Black con.
Green con.
Black con.
5v grey
Fuel gauge damper
Flasher sensor
Air conditioning
Heated rear screen
Inertia switch
Electric windows
Starter
Dipped headlights
Main beam headlights
Diesel postheating
Additional heater
Diesel advance correction
Locking
ABS
Transponder module
148
Boxer location from chassis No. 17,000,001
A: F70 = 150 A supply BF01
B: F71 = 80 A supply PSF0
C: F73 = 70 A engineer's socket
D: F72 = 70/100/125 A alternator
1
2
3
4
5
: Max. fuse module under bonnet (BMF1)
: Preheating relay
: ECR proportional solenoid valve
: Throttle + EGR solenoid valve
: 23 fuse box (BF01)
149
Boxer location from chassis No. 17,000,001
F34
PSFO
8482
8445
8410
8221
BB00
BMF1
CA00
8440
C001
8423 8503
8422
B001
BF00
F27
150
Notes
151
Boxer III location
BF00 Fuse module- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (dashboard)
BF01 Fuse module- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (engine compartment)
BMF Maxi-fuse module- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (battery)
BSI1 Built-in systems interface - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (dashboard)
C001 Diagnostic connector- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (dashboard)
PSF0 Optional fuse module - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (passenger compartment)
0004 Controls - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (dashboard)
1203 Inertia switch- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (passenger compartment)
1320 Multifunction engine ECU- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (engine compartment)
4635 Chronotachograph electronic converter- - - - - - - - - - - - - - - - - - - - - - - - - - - (over-cab area)
5007 Rain/light sensor - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (passenger compartment)
6235 Central locking unit - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (passenger compartment)
6570 Airbags and pretensioners module - - - - - - - - - - - - - - - - - - - - - - (passenger compartment)
7020/7800 ABS / ESP - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (engine compartment)
7105 Variable power-assisted steering ECU- - - - - - - - - - - - - - - - - - - - (passenger compartment)
7500 Parking aid ECU - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (loading area)
7803 ESP steering wheel angle sensor- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (dashboard)
7804 ESP accelerometer gyrometer - - - - - - - - - - - - - - - - - - - - - - - - - (passenger compartment)
8025 Air conditioning control panel - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (dashboard)
8410 Car radio- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (dashboard)
8480 Telematics transceiver - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (dashboard)
8605 Anti-theft alarm siren - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (engine compartment)
8618 Anti-lift switch - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (passenger compartment)
152
153
Bipper location
BSI1
C001
0004
1320
1660
6570
7020
7500
8602
8605
8410
Built-in systems interface
Diagnostic connector
Controls
Multifunction engine ECU
Controlled gearbox ECU
Airbags and pretensioners module
Anti-lock braking system computer
Parking aid ECU
Anti-theft alarm movement detection unit
Anti-theft alarm siren
Car radio
154
Location on Expert II
BTC Body transformer unit- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (left rear wing)
BSI1 Built-in systems interface- - - - - - - - - - - - - - - - - - - - - - - - - - - - - (passenger compartment)
BSR1 Trailer systems interface- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (left rear wing)
CV00 Switching module under the steering wheel - - - - - - - - - - - - - - - (passenger compartment)
PSF1 Engine systems interface (BSM) - - - - - - - - - - - - - - - - - - - - - - - - - - (engine compartment)
0004 Controls - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (passenger compartment)
1022 Alternator filtering condenser - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (engine compartment)
1320 Multifunction engine management computer (CMM)- - - - - - - - - - - - - (engine compartment)
5007 Rain/Light/Tunnel Sensor- - - - - - - - - - - - - - - - - - - - - - - - - - - - - (passenger compartment)
6570 Airbags and pretensioners module - - - - - - - - - - - - - - - - - - - - - - (passenger compartment)
7020 ABS ECU - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (engine compartment)
7122 Power-assisted steering pump assembly (GEP DA)- - - - - - - - - - - - - (engine compartment)
7215 Multifunction screen (EMF)- - - - - - - - - - - - - - - - - - - - - - - - - - - - (passenger compartment)
7500 Parking assistance ECU (AAS)- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (left rear wing)
7715 Rear Ride Height Correction ECU (CAAR)- - - - - - - - - - - - - - - - - - - - (engine compartment)
7800 ESP ECU - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (engine compartment)
7804 Accelerometer gyrometer- - - - - - - - - - - - - - - - - - - - - - - - - - - - - (passenger compartment)
8026 Additional air conditioning control panel- - - - - - - - - - - - - - - - - - - (passenger compartment)
8080 Air conditioning control panel - - - - - - - - - - - - - - - - - - - - - - - - - - (passenger compartment)
8410 Car radio- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (passenger compartment)
8415 CD changer- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (passenger compartment)
8480 Telematics transceiver - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (passenger compartment)
8492 Hands-Free Kit (KML) - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - (passenger compartment)
8602 Anti-theft alarm movement detection unit- - - - - - - - - - - - - - - - - - (passenger compartment)
155
156
Boxer transponder system from chassis No. 17’000’001
BB00
BMF1
BF01
BF00
B001
CA00
IC01 /B
IC04/A
1320
8221
MC40
8220
Key:
BB00 :
B001 :
BF00 :
BMF1 :
C001 :
IC01 :
IC04 :
MC40 :
0004 :
1320 :
8220 :
8221 :
8410 :
8422 :
8423 :
8440 :
8482 :
Battery
Equipotential terminal
Engine comp. fuse box
Maxi fuse box
Diagnostic connector
Interconnection “B”
Interconnection “A”
Earth terminal
Controls
Engine management computer
Module transponder
Control module transponder
Radio
LH door speaker
RH door speaker
LH tweeter
Radio telephone mike
157
0004
Multiplex engine systems interface, BSM or BM34
or PSF1
Module 2
Module 1
Operation
The BM34 module 1 ensures distribution and protection by maxi fuses.
The BM34 module 2 ensures the distribution and protection of the BB+ and +CC power supplies
of the main wiring harness and the engine wiring harness.
By command from the engine management computer (1320) BM34 module 2 supplies the
engine actuators (equivalent role to the dual relay).
BM34 module 2 communicates in slave mode with the BSI via the multiplex network
Diagnostic
The diagnostic tool does not communicate with BM34. The fault finding procedure (reading faults,
actuator test, etc.) is carried out over the VAN-Body network.
The BM34 faults are stored in the BSI. BM34 module 1 has no
fault finding procedure.
Important: There are several levels of BM34.
For example: If there is an irregularity in the electrical equipment, it is necessary to check whether
BM34 corresponds to the vehicle equipment.
158
Multiplex switching module under the steering wheel CV00
A3
A1
A2
B1
A4
B3
B2
A5
D2
D4
C4
C1
C5
D5
D3
C6
D1
C2
C3
Module CV00 (COM 200X) is a monobloc module including:
-
the
the
the
the
the
main steering column switches (lighting, signalling and wiping)
secondary steering column switches (cruise control and radio control)
HF receiver (locking/unlocking the doors, detection of under-inflation)
buzzer and the rotary switch
connections (transponder aerial, airbags, horn, steering wheel angle sensor)
To use the steering column switches, refer to the user guide located in the vehicle or on Infotec.
Diagnostic function:
Procedure:
- User guide
- Select the vehicle
- Function index
- Select the relevant function
Notes or specific points:
- Microprocessor operating faults
- Transponder faults
- HF reception faults
(locking, unlocking, under-inflation)
- Main control faults,
secondary controls or others
- Parameter measurements
- Secondary commands (radio with or without telephone, cruise control) are
independent of CV00 and can be added in an equipment station without changing
VC00.
- The CV00 controls the transponder, HF reception and buzzer functions.
- The rotary switch and steering wheel angle sensor are incorporated in CV00.
When replacing a CV00, there is no initialisation procedure to be carried out (except for
calibrating the ESP steering wheel angle sensor).
159
Special notes 206 CC
Hydraulics and switches (folding roof)
Hydraulic circuit
Roof stays
Boot stays
right
left
left
Parcel shelf stays
right
1
2
1
5
3
4
1. Anti-return valve
2. Solenoid valve
3. Depressurisation screw
4. Discharge valve
5. Hydraulic pump
Switch status
Switch open
Switch closed
160
Special notes 206 CC - Closing the roof in manual mode
- Open the windows.
- Switch off the ignition.
- Open the boot.
- Store the canopy.
- Take the key located in the
spare tyre inflator box.
- Depressurise the pump (1/2 turn, screw (1) in
1
the RR RH boot, do not leave the key in
the boot).
2
- Pull on the cord (2) to store
the parcel shelf.
- Free the boot locks at (3),
see the white hooks.
3
161
- Close the boot.
4
- Open the boot and pull forward in the
middle.
- Lock the boot using the Allen
key (4) on the right hinge.
- with a second person, fold back the roof
watching the position of your hands.
- Close the roof hooks.
- Remove the Allen key.
- Close the boot.
- Open the boot.
- Lock the locks with the
5
white stops (5) in
manual position.
- Close the boot.
Important:
After the procedure (repair):
- refit the white stops (5) in the top holes
- close the filled screw (1) on the pump
- rethread the cord (2)
162
Location of folding roof sensors 307 CC
Key:
6858
6859
6878
6880
6883
6884
6886
6897
6898
6899
Left-hand flap switches
(Stowed flap switch and deployed flap switch)
Right-hand flap switches
(Stowed flap switch and deployed flap switch)
Closed roof switch (switch located on the windscreen frame)
Open roof switch
Left-hand locked roof switch
Right-hand locked roof switch
Pulled canopy switch
Left-hand locked boot switch
Right-hand locked boot switch
Open boot switch
163
164
coupe position
close hatch
stored flaps position
flap storage
closed roof position
close roof
vertical Parcel shelf position
parcel shelf movement
open hatch
cabriolet position
Folding roof status
Roof
closed
switch
Open
roof
switch
LH/RH roof
locked switches
Open hatch
switch
LH/RH locked
hatch switches
LH/RH stowed
flap switches
Status of the switches: Change from cabriolet to coupé
LH/RH
deployed flap
switches
Pulled canopy
switch
165
coupe position
close hatch
stored flaps position
flap storage
closed roof position
vertical Parcel shelf position
parcel shelf movement
cabriolet position
Folding roof status
Roof
closed
switch
Open
roof switch
LH/RH roof
locked switches
Open hatch
switch
LH/RH locked
hatch switches
LH/RH stowed
flap switches
Status of the switches: Change from coupé to cabriolet
LH/RH
deployed flap
switches
Pulled canopy
switch
Coolant temperature sensors' function
(from AM90)
Sensor
Petrol
Diesel
Without AC
- Controls
indication
With AC
- Controls
Indication
Without AC
- Controls
indication
- Overheating
warning light
With AC
- Controls
indication
DW8 Engine:
- Controls
indication
- Overheating
warning light
- Cooling fan
assembly trigger
- Triggering AC
- Post-cooling
- Overheating
warning light
Blue
DW10ATED engine
- Engine management
- Post-cooling
- Trigger AC compressor
- Indication on the controls
- Cooling fan assembly trigger
Green
Injection
Green
EW10/12
Brown
Postcooling
Injection
Postheating
60°C advance correction
EGR 48°C or engine management
computer management
ç from AM99 1/2
è
DW10/12
- Engine management
DV4
- Cooling fan assembly trigger
- Post-cooling
- BSI: climate control/controls indication
- Cooling fan
assembly trigger
- Trigger AC
- Controls
- Postcooling
166
- Postcooling
- Cooling fan
assembly trigger
- Trigger AC
- Overheating
warning light
- Postcooling
Abbreviation of radio and display keys
(Blaupunkt/Clarion/Magnetti Marelli/Philips-VDO)
HELP
“PEUGEOT-ASSISTANCE” direct call
AUDIO/AUD Adjustment of low tone, high tone and volume of the
sound distribution (Volume available depending on the device)
BAND AST
Selection of FM1, FM2, FMast and AM wavelength ranges
BLS
Blank Skip Switch:
Skips blanks over 4 secs (cassette/CD)
BND/AST
Selection of bandwidth ranges: FM/FMI/FMII/FM III
AM and pressure over 2 secs: station automatic storage
BNR/NL Dolby: Noise reduction (cassette)
CPS/APC
MSS
Automatic Program Control/Music Search Sensor:
or
searches for blanks of 4 secs min. (cassette/CD)
CL
Clear
DARK
First press: displays the top band
Second press: entire screen off (black screen)
Third press: return to the function displayed
DX
Station search maximum sensitivity
EON
Enhanced Other Network:
Network of transmitters distributing traffic information
ESC
Abandon the procedure in progress
EXM / SCN / PS
Scanning, Preset Scan:
Exploration of memory (radio or CD tracks)
FMT/MA /
AST/SAM
Autostore:
Automatic transmitter storage system
GEO
Balance and fader adjustment
167
LD/LOUD
Loudness: Tonal improvement at low volume (cassette)
LIST REFRESH
Displays local stations or range of CDs
LO
Local: High transmission station search
MAN
Manual or automatic station search
MENU
General menu display
MODE
CD/cassette/radio selector
Fader/balance/high tone/low tone selection
Screen display mode selection
MTL/ME-CR
Selection of metal/chrome or normal cassettes
MUTE
Sound interrupted
ON/VOL
Radio on/off - Volume adjustment
PRG
Selection of special functions using successive presses
PTY
Program Type: Selection of stations transmitting a certain
type of program
RDM/RND
Random: CD random reading
RDS/AF
Alternative Frequency (RDS= Radio Data System),
automatic transmitter selection
REG
Regional:
Station transmitting a regional program
RM
Radio Monitor:
listening to the radio as the cassette rewinds
RPT/REP
Repeat:
Automatic rereading of the same track (cassette/CD)
168
SC
Scanning:
Stops for 5 secs on each radio station
SCN /SCAN
Automatic listening from the start of each track (CD)
SEL/SRC
Change of sound source without ejecting cassette
or: source selection: radio, cassette, CD
SOURCE
Source selection: radio, CD changer CD
T.MD/T.M/MAN
Tuner Mode: Manual or automatic search for stations
TA
Traffic Alarm:
Search for stations broadcasting traffic information
TON
Adjustment of tonality, balance and fader
TP
Appears on the display when a station broadcasts
traffic information
Adjustment of tonality, balance and fader
Selection of cassette source, reverses the direction of play for the cassette - press for more than 2 secs.
CD changer source select program.,
press for more than 2 secs: random play
Selection of radio source, selection of wave bands: FM1, FM2, FMast, AM, press for more than
2 secs: automatic storage of stations (autostore)
1 2 .. 9 *#
Telephone keypad
# TA
Traffic information decoding function activation,
higher audio adjustment - TA, press for longer than 2 secs.:
PTY programme
Long press on the SOS key: emergency call
Access to the “PEUGEOT” service menu
Pick-up button
Hang-up button
169
Radio/Telephone/Telematics abbreviation
DCS
GPRS
GSM
GPS
ISDN
MOST
MP3
RAM
RDS
ISDN
ROM
SIM
SMS
TTS
TMC
WAP
Digital cellular system (in GSM-Standard = 1800 MHz)
General packet radio service
Global system for mobile communication
Global positioning system
(RNIS) Interrogation Service Digital Network
Media oriented systems transport (bus)
Mpeg audio layer 3
Random Access Memory (working memory)
Radio Data System
Integration of services digital network
Read Only Memory (dead memory)
Subscriber Identification module
Short message service
Text to speech
Traffic message channel
Wireless application protocol
170
Notes
171
Radio decoding
Clarion method
Decoding
• Enter the code on keys 1 to 6.
If an error occurs
• Clear the display by pressing >3 secs on the BND key
6055 press > 3 secs on the MODE key.
3035 press > 3 secs on the ~ key
1010/1030/3020: Display of ...... re-enter the code.
1035: After 3 wrong attempts, locked. Press BND: display ----- leave
on for 1 hour.
6030/6050/6055: SECURITY display, wait and re-enter the code. After 3 incorrect
attempts = leave on for 1 hour. For each new mistake = leave
on for 1 hour.
4030/4050: SECURITY display, wait 2 minutes, re-enter the code.
After 3 incorrect attempts = leave on for 2 hours.
Blaupunkt Decoding method
•
•
•
•
Key 1 = 1st digit of the code with successive presses
Key 2 = 2nd digit of the code, etc.
Confirm the code by pressing key 6 (Partner: key ^ )
2030/2040: Enter the code on keys 1 to 6 (VN: active test mode
= wait 3 minutes before entering the code).
If an error occurs
• Wait for CODE to be displayed and re-enter the code.
After > 3 incorrect attempts = 1 minute wait.
After 20 incorrect attempts = leave on for 48 hours.
• 2030/2040: 1 incorrect attempt = 5 min. wait > 4 incorrect attempts = leave on 1 hr.
Philips Decoding method
a) Press key 1
b) Increase or decrease the digit using the UP and DOWN keys ( σ τ ).
• Start again at (a) for the other digits.
• Confirm by pressing key 1.once again
8050: Code input using keys 1 to 6. Confirmation by MODE key.
If
•
•
•
an error occurs
Display of WAIT or ERR CODE.
Wait a maximum of 32 minutes without cutting off the power supply.
When CODE appears, restart.
8050: ERROR display. New attempt possible after max. 50 minutes.
14 incorrect attempts lead to definitive locking.
172
Radio identification before AM99 1/2
106
Clarion 1010
Clarion 1035
206
Blaupunkt 2030
Clarion 1030
A
A
A
Blaupunkt 2040
G
306
G
Clarion 3020
Blaupunkt 3030/3040
C
C
Clarion 3025/3035
C
405
Clarion 4030
Clarion 4050
D
E
406
Philips 4030
Philips 4050
D
D
173
605
Clarion PC 300
Clarion 6030
D
E
Clarion 6050
Clarion 6055
D
B
806
Clarion 4030
Clarion 4050
E
Partner
E
Blaupunkt 1021
F
Tool A: 7.1209
(9769.41)
tool C 7.1211
(9769.96)
Tool B: 7.1210
(9769.79)
Tool F: Screwdriver
Universal torx
Tool D: 7.1212
(9769.A7)
Tool G: Screwdriver
universal
Tool E:9769.C2
174
Radio identification from AM99 1/2
106/206/306/Partner:Clarion RD1
106/306: Philips RB1
D
D
307/807/Partner (M59): Clar. RB3 (*)
1007/206/307/807/Partner (M59):
Clarion/VDO RD3 (*)
E
E
406 (D9)/607 (Z8): Clarion RM2 (*)
1007/206/307/407/607 (Z9)/807:
Clarion RT3 (*)
D
E
406 (D9): Philips RB2 (*)
406 (D9): Clarion RD2/RD3 (*)
D
D
307/407/607 (Z9): Blaupunkt RD4 (*)
E
607 (Z8): Clarion RT2 (*)
G
Special notes:
- (*) Fault finding on these devices is carried out using the central diagnostic socket with
the diagnostic tool
- When the battery is disconnected, the VIN no. is not lost
- Fitting a post-equipment radio for 1007/206 MUX /207/307/406 MUX/407/Partner (M59)/807 FULL
CAN: use the interface according to the accessories Infotec catalogue.
175
Infrared locking
Infrared remote locking
- Paired receiver and remote; Parts Catalogue order with
digital code written on the receiver and remote
(enter the first 5 characters)
- Several remotes possible on one vehicle
1 button
2 batteries
Infrared remote deadlocking
(306S16, 806 depending on equipment and AM)
Programming the remote in the
deadlocking module:
- switch on the ignition with the spare key
- point remote no. 1 in the direction of the receiver at a
max. distance of 10 cm, and press the button
- do the same with remote no. 2 (if there is one)
Note: comply with a max period of 10 secs between
these phases
- switch off the ignition, close all the doors, check
operation
2 buttons
2 batteries
Notes:
- Deadlocking does not work if a door is open (806: boot also)
- The code is stored in the module 6235.
Replacing the module involves a new programming procedure
- Any deadlocking remote (with 2 buttons) can be programmed, but a
maximum of 2 remotes per car.
- The remote and receiver are not a pair; they can be replaced separately.
- If only one remote is programmed, the 2 memories M1 and M2 will be occupied by the same
code
= cancellation of any other remote
176
Remote locking/ HF (remote) deadlocking
Module: Locking/
Deadlocking
HF receiver
HF remote
Synchronisation of the remote and receiver
206, 406, 605, Partner (also Multiplex vehicle):
- Switch on the ignition, press the remote button within 10 secs.
! ! Vehicle with deadlocking action on the 2 remote buttons
307/ 607/807: - switch on the ignition, - press the remote button within
10 secs for 10 secs. (see also AGIR info.)
206 (1st Version):
1. Press the remote button until the LED goes out (approximately 10 secs)
2. Release the button; the diode lights up continuously.
3. Press the button twice.
4. Switch on the ignition, wait 3 seconds, switch off the ignition.
5. After 3 seconds, the remote is operational.
Notes
• The high frequency code emitted by the remote changes with each use.
• Replacing the remote or receiver or after programming a 2nd remote requires a new synchronisation procedure.
Ordering an additional remote
• The remote is paired with the receiver (except for 806 and 206). When replacing or ordering
an additional remote, tell the Parts Department the 5 character alphanumeric code on the
label (inside the remote or receiver),
followed by the following differentiation character:
605 : 0 = remote no. 1 1 = remote no. 2
406 : P = Primary remote S = Secondary remote
Partner: PRI = primary SEC = secondary
406 example: CR4FT2.P = Primary remote, CR4FT2.S = secondary remote
Important:
- When replacing a remote, order it using an identical code.
- When adding a remote, order it using the code followed by a different differentiation character (2 identical remotes will not work together).
806 (from AM98), 306/Expert (from AM2000) with CPH: No pairing. Each remote can be programmed in the Passenger compartment Central Protection Unit via a dialogue procedure with
TEP 92 or PP2000 (the customer's CODE card is required as well as all the vehicle's keys).
206 / 406 (D9): No pairing. Each remote can be programmed in the BSI using a dialogue
procedure with TEP92 or PP2000 (the customer's CODE card is required as well as all the
vehicle's keys).
177
Coded immobiliser (ADC)
Keypad A
Spare part no. 6160.19
Keypad C
Spare part no. 6160.32
Keypad B
Spare part no. 6160.29
Keypad D
Spare part no. 6160.36 ♥ (Soft 1)
Spare part no. 6160.38 - ← (Soft 3)
Spare part no. 6160.40 ⁄ (Soft 5)
Spare part no. 6160.43 ≈ (Soft 6)
Spare part no. 6160.46 - (Soft 7)
Special notes
⁄≈
Possibility of automatic unlocking using the HF remote: - 406 from code ~6965
- 605 from 07.96
- Partner
≈
Max period of 30 secs to switch on the ignition after unlocking
Improved dialogue with Bosch computers
Type of keypad
A
B
C
D
Initialisation code
0001
0001
1111
1111
Change code
Deactivate
Differentiate
Service code
HF remote initialisation
Keypad replacement
Computer replacement
Loss of code
P
r
o
c
e
d
u
r
e
No.:
by Door opening,
after:
by locking,
after:
without action,
after:
Locking after 3 code errors
Locking
of the computer
1
1
1
1
1.1
1.1
-
-
1.2
1.2
-
-
-
-
-
♥←: 2
-
-
-
-
-
-
⁄≈ : 3 (3.1, 3.2)
⁄≈: 3 (3.1, 3.2)
♥←: 4
⁄≈: 4 + 3
5
5
5
5
Replace
ECU
Replace
ECU
10 seconds
Replace
ECU
10 seconds
Replace
ECU
30 seconds
10 seconds
10 seconds
10 seconds
30 seconds
1 hour
1 hour
1 hour
10 minutes
1 minute
1 minute
1 minute
♥: 1 min.
←⁄≈: 30 min.
178
179
6.95è
Boxer
6965-7146
7092-7125
S2è
D⁄
6160.40
Soft 5
7112è
7.96è
7147-7272
7126-7393
D≈
6160.43
Soft 6
Soft 1 = 96 200 525 ZL or 96 200 527 ZL
Soft 3 = 96 255 839 ZL or 96 255 838 ZL
Soft 5 = 96 267 808 ZL or 96 267 809 ZL
AM97è
optional
Transp.
FIAT
N5è
series
Transp.
Siemens
Soft 6 = 96 276 404 ZL or 96 276 403 ZL
Soft 7 = 96 297 433 ZL or 96 297 434 ZL
Identifying D keypads by their label:
7273è
7394è
D
6160.46
Soft 7
Note: Keypad 6140.40 replaces keypads 6160.36 and 6160.38
Keypad 6160.46 replaces keypads 6160.43
7000-7111
7000-7111
è7014
7000-7091
D←
6160.38
Soft 3
7112è
è6999
è6999
è6.95
è6.95
6783-6999
è6.95
D♥
6160.36
Soft 1
Startè
è6778
AM94-6.95
è6.95
è6782
è6.95
C
6160.32
Expert
èAM93
è6.95
è6782
è6.95
B
6160.29
Partner
806
607
605
406
405
307
306
206
106
A
6160.19
Allocation of immobiliser devices
Transp.
VALEO
AM98è
standard
AM98è
standard
AM2000è
AM98è
standard
AM2000è
standard
CPH Texton
DAM 8610è
AM2000è
standard
AM99è
(D9)
AM2001è
AM99è
standard
BSI
Preliminary note:
The codes 1-2-3-4 and 5-6-7-8 used below are
user code examples.
Procedure 1 - Changing code
Ignition on 1-2-3-4
C
5-6-7-8
C
- The old code (1-2-3-4) will only be definitively replaced after
the first use of the new code (5-6-7-8)
Procedure 1.1 - Deactivation
Ignition on 1-2-3-4
N press >2s
Ignition on 1-2-3-4
C
or
0-0-0-0
C
Cancellation of deactivation:
Ignition on 1-2-3-4
Procedure 1.2 - One hour deferred locking
Ignition off max. 20 secs
D
- The computer locks after 1 hour.
- Deferred locking is reset each time the ignition is switched off.
Cancellation of deferred locking:
Ignition off max. 20 secs
D
Procedure 2 - Service mode
Ignition on 1-2-3-4
S
5-6-7-8
S
with 6 bleeps
- The code 1-2-3-4 is stored in the memory of the keypad and computer. The
service code is stored in the keypad.
Cancellation of the service code:
Ignition on 1-2-3-4
180
Procedure 3 - Programming HF transmitter(s) code
Ignition on 1-2-3-4
C-C ....................................................................................................with
Activate transmitter no. 1...................................................................with
Activate transmitter no. 2...................................................................with
(If absent, activate transmitter no. 1 again)
C-C ....................................................................................................with
Note: comply with a max. period of 10 seconds between each phase!
2 bleeps
3 bleeps
4 bleeps
5 bleeps
Procedure 3.1 - Setting the keypad to automatic mode
Ignition on 1-2-3-4
C-1-C
with 4 bleeps
Note:
comply with a max. period of 10 seconds between the 2 phases!
(When changing code, go to manual mode)
Procedure 3.2 - Setting the keypad to manual mode
Ignition on 1-2-3-4
C-0-C
Note:
with 4 bleeps
comply with a max. period of 10 seconds between the 2 phases!
Procedure 4 - Replacing the keypad
Ignition on 1-2-3-4
C
1-2-3-4
C
Procedure 5 - Replacing the injection computer
Ignition on 0-0-0-1 or 1-1-1-1 C
1-2-3-4
C
Notes:
-Red and green diodes lit = dialogue fault: switch on the ignition for 1min, then
switch off/disconnect/reconnect the keypad or check that the diagnostic tool is
not connected.
- If the computer is locked = code 56 injection self-diagnostic (except BOSCH).
- If the BOSCH computer is locked = diagnostic warning light flashes.
See also:
- Lesson archive no. 17 - Chapter 4.
-ADC brochure ref. 12091 (lesson archive no. 21) or ref. 491 (General
Information archive).
- Lesson archive no. 23 - Chapter 8.
- Lesson archive no. 24 - Chapter 6.
181
1st generation transponder immobiliser
The Expert access code is stored in the transponder unit 8221 or BSI
206,406 (D9) or CPH: 806 (at AM 98) ,306/Expert (at AM 2000) and in the injection computer 1320.
This storage is definitive and cannot be altered.
Computer 1320 only locks and unlocks if its code corresponds
to the transponder unit code.
Access code
Switching on the ignition
Issue
unlocking order
4P 8G
4P 8G
BSI
8221
the 8221 electronics
are integrated in the BSI
4P8G4P 8G
Switching the ignition off:
- Locking 10 secs after opening door
- Locking after 5 mins without opening door
1320
Note for Diesel engines:
- Same operation but computer 1320 replaced by module 8208 on
mechanical
injection pump
- Intervention on STOP module or solenoid valve, see pink brochure CIR no. 967
“Diesel all types diagnostic”
Replacing or adding a key or remote:
- The code transmitted by the key must be stored in the transponder unit
- Each key transmits a different code
- It is possible to store 5 keys at most simultaneously
- During the key initialisation procedure with the diagnostic tool, the memories
are cleared first and only the keys presented are recorded.
- It is therefore always necessary to reprogram all the keys for the vehicle to
program one key
- This procedure requires the Peugeot card access code to be entered
Note during the key operation test: comply with the 10 sec period, with FR door open, for
relocking computer 1320 between testing 2 keys.
The engine does not start:
- Carry out a parameter test on the transponder unit
- key code received? - key code valid?
- Carry out an operation test: - computer 1320 locked or unlocked?
- Carry out an “operating problem in the absence of faults” test
182
Replacing the 1320 engine computer
New part:
- The computer is delivered blank and enables starting without another.
- The immobiliser will be activated during initialisation procedure PP2000, with the access code.
Part from another vehicle:
- Switch on the ignition, switch off the ignition, do not open a door, disconnect the computer within 5 minutes to keep it unlocked, remove it.
- Fit it to the vehicle to be tested after having temporarily deactivated the transponder unit by
disconnecting fuse F8 (106, 306 with BF 13), F25 (306, 406), F6 (306 with CPH), F15 (806),
F14 (806 CPH/Expert CPH.
- 206: deactivate the BSI by removing fuses F4 and F9 (Note, all the BSI functions become
inactive).
- 1007 / 206 MUX / 207 / 307 / 406 MUX / 407 / 607 / 807 / Boxer from 97 / Partner from
2003:
the transponder system can no longer be neutralised.
Replacing the transponder unit or BSI
New part:
- The unit is delivered blank. For it to work, the new part must be programmed and initialised
with PP2000 via the “Spare part” or “Diagnostic” menu.
Follow the indication according to the PP2000. screen
Note: the HF keys must also be synchronised see page 127, chapter HF deadlocking.
Part from another vehicle (only in very special cases):
Never initialise the computer or BSI on parts that have already been initialised.
The procedure is strictly reserved for new and blank parts from the Parts Department.
- Remote coding: This menu allows certain BSI functions to be activated or deactivated.
Reactivation of the immobiliser function (concerns 206-/806 1st series):
After a procedure, reactivate the immobiliser function using the following procedure:
- Disconnect the diagnostic tool
- Close the driver's door
- Switch on the ignition, wait 15 secs
- Switch off the ignition, remove the key
- Open and close the driver's door
- Wait 20 secs before starting the engine
FIAT system transponder immobiliser:
See: - Training handbook from 1997 or workshop brochure no. 892 Boxer electricity
Note: Never user the "red" key for driving!
183
ADC2 version transponder immobiliser:
1007/206/406 Full Mux/207/307/407/607/807/Restyled
Partner
1320
6220
Button 1
Button 2
CV00
BSI1
ADC2 specific points (second generation):
- When it is turned on, the engine management computer systematically takes on locked status
- The engine management computer is delivered locked
- The second generation transponder immobiliser is not compatible with the previous generation
Engine management computer unlocking (CCM) when starting +AA:
- The engine management computer transmits a random number (authentication request) to the
BSI via the CAN network
- The BS I detects the presence of the key on the immobiliser and reads the response label in
the key.
- Slow flashing (1Hz) = Engine management ECU locked
- Rapid flashing (5Hz) = Engine management ECU is not unlocked
- LED continuously lit = the BSI is not receiving the random number from the engine management ECU- no recognition of the response label
Note:
The keys are paired with a vehicle and cannot be exchanged between two vehicles.
184
Coded immobiliser 107
Transponder
coil
Wire link
Engine
Management
Computer (CMM)
IMMO
module
System principle:
• Self-programming when the + after ignition feed comes on for the first time:
- From the keys to the IMMO module
- From the IMMO module to the CMM
• For paired CMM and IMMO modules, pre-authorisation to start before confirmation.
- The CMM transmits an unlocking request.
- The CMM is unlocked while waiting for the response from the IMMO module.
• Dependent on engine speed, an unlocking confirmation is issued.
Breakdown of the ADC function:
• In the event of replacing the IMMO module:
- It is necessary to reprogram the keys.
- The CMM must be cleared.
To do this, use tool PP2000 in the coded immobiliser computer for the keys and in the CMM
computer to clear it.
• When replacing the CMM:
- The ADC code is automatically programmed the first time the + after ignition feed comes on.
• When replacing keys:
- Use tool PP2000 in the ADC computer to program the keys.
185
Locking/unlocking/deadlocking on:
206/406 Full Mux/307/607/807/Restyled Partner
Locking, unlocking, deadlocking:
• via the HF remote control
• by key via the driver's door lock
• via the central control button
Depending on the equipment, the vehicle may be fitted with standard locking or deadlocking.
Example of
design
for the 307
BSI1 (built-in systems interface) controls deadlocking, locking, unlocking, the location of the vehicle and protection of the actuators.
CV00 (switch module under the steering wheel) incorporates the HF receiver and controls reception of the signal.
0004 (controls) acquires the door exit locking switch status (6220).
6202/6207/6212/6217 (door lock assembly) includes:
• an actuator that enables the vehicle to be deadlocked, locked/unlocked
• a switch that provides the door status information (open/closed)
NB:
only the driver's door has a lock that enables deadlocking, locking and unlocking of the vehicle
using the key.
6220 (door exit locking switch) on 307/607/807/Part. from mod. 2003 is used to lock or unlock
the vehicle from the inside.
6222 or 6258) on 307/607/807/Partner from mod 2003 includes:
• an actuator that enables the boot to be unlocked
• a switch that supplies the boot status (open/closed)
6237 (boot unlocking switch) used to open the boot.
6570 (airbags and pretensioners module) detects impacts.
206 MUX/406 Full MUX/307/807/Partner from mod 2003: after unlocking, (if no door is opened
within 30 secs) the vehicle locks automatically.
186
Summary of keys: transponder electronic immobiliser (ADC 1/2)
with or without remote - Central door locking
Peugeot
Models
Management
Number of possifor the door
ble keys to be
and/or rear view
programmed/
mirror and seat
No. of buttons
mem. (*)
1007 (BSI)
5 (4 buttons)
106 |> AM1998
5 (1 button)
106 |> AM2000
(DAM 8330)
107
Notes:
Key programming or control
procedure
Peugeot card
code required
(Yes/No)
Synchronisation/
General information
2 HF
Yes
5 HF
Yes
5 (2 buttons)
2 HF
Yes
5 (2 buttons)
5 HF
No
- See the
corresponding page
or the indication
on screen of the
diagnostic tool after
the programming of
keys.
206 without Full multi5 (1 button)
plex (BSI)
5 HF
Yes
206 Full Mux (BSI)
5 (2 buttons)
2 HF
Yes
306 |> AM2000
(CPH)
5 (2 buttons)
4 HF
307 (BSI)
5 (2 buttons)
2 HF
406 D9 |>
80,800,001 (BSI)
5 (1 button)
5 HF
406 D9 |>
DAM 9002 (BSI)
5 (2 buttons)
2 HF
407 (BSI)
5 (3 buttons)
2 HF (*)
Yes
607 (BSI)
5 (3 buttons)
2 HF (*)
607 (Z8): In addition
use the code in the
Yes
key for programming
806 |> AM2000
(CPH)
5 (2 buttons)
4 HF
807 (BSI)
5 (4 buttons)
2 HF (*)
Partner |>
DAM‑8610 (BSI)
5 (1 button)
2 HF
Partner Full Mux
(BSI)
5 (2 buttons)
2 HF
Expert |> AM2000
(BSI)
5 (1 button)
2 HF
Boxer |> 17,000,001
1 to 8 (2 buttons)
1 to 8 HF
Without master key
Yes
Boxer |> 17,000,000
3 min/8 max
IR
With master key
No
Yes
See AGIR
Yes
Yes
New keys are not
identical to the 406
D9 1st generation
keys (without HF
code)
Yes
- Note: if the
synchronisation has
failed, carry out a
2nd or 3rd attempt.
- If the result is
still negative:
disconnect the
battery/diagnostic
tool, wait a few
minutes and start
the synchronisation
procedure again
(see also AGIR).
Yes
Yes
HF code
prim./sec.
Yes
Yes
Yes
Never use as an
ignition key; this is
exclusively for AfterSales operations‑!
Key summary: Coded immobiliser (ADC) with or without Remote
Central door locking
605 |> 91,000,001
Free (2 buttons)
2 HF
605 |> AM1995
Free (1 button)
2 HF
605 |> AM1995
Free (1 button)
IR free
406 D8 |> DAM‑7014 Free (2 buttons)
With prim./sec. code
or code: 0/1
in the key shell
2 HF
187
Synchronisation
required
No synchronisation
Wiper with rain sensor
Each time the ignition is switched off in AUTO
position, the system must be reactivated, 2
methods:
1. Switch from pos. 1/2 or AUTO to zero, then
return to AUTO = 1 scan
2. Switch from zero pos. to. AUTO = 1 initialisation
scan
Seat and rear view mirror with memory
Memory reminder
Storing an adjustment:
Door open, ignition off: short
press on key 1 or 2.
- ignition on
- continuous press on the button (M)
- within 4 secs press
(1) or (2) = 2 bleeps
Door closed, ignition on: short
press on key 1 or 2.
188
Anti-pinch electric window (1007/206/306/307/406/407/605/607/807)
Deactivation of the anti-pinch system:
• In the event of the window being impossible to close due to ice or another reason:
- within 5 seconds of an obstacle being detected, lower the window to its limit manually (1st
position), and press down for a few seconds,
- after 1 second, raise the window in manual mode
- the anti-pinch is reactivated automatically after the switch is released.
Initialisation of the anti-pinch system:
• In the event of permanent + feed cut-off with the
window open.
Detection area
• When replacing the electric window.
• When there is a fault in the anti-pinch system.
605 :
- lower the window to its limit manually (1st‑position),
- press and hold for a few seconds,
- raise the window (in increments of 50 mm),
- press and hold for a few seconds at the top limit,
306/406/607:
- lower the window to its limit manually (1st‑position),
1st position
2nd
position
- press and hold till you hear the relay sound,
- within 2 seconds, raise the window (in increments of
50 mm),
- press and hold for a few seconds,
1007/206/307/407/807:
- raise the window in steps until the top limit and hold the switch for 1 second.
Note:
• The module monitors the motor operating time and cuts it off to prevent overheating.
806 anti-pinch sunroof, deactivation of the anti-pinch system:
• When transporting objects across the sunroof opening.
• When there is a fault in the anti-pinch system.
• Detection of an obstacle when closing the sunroof.
• Within 2 seconds, open the sunroof in manual mode (1st position).
• Within 2 seconds, at the end of opening, close the sunroof in manual mode (in 10 cm steps).
Important:comply with a max. period of 2 seconds between each press.
189
Initialisation of electric windows
Introduction
The initialisation enables the motor computer to program its opening and closing limits to
guarantee the Anti-pinch function.
This initialisation must be carried out under the following circumstances:
-
Removing and refitting a motor.
Disconnecting the battery (In some cases).
Replacing the computer or motor.
Removing and refitting or replacing the electric window mechanism.
The initialisation procedures are described below:
All vehicles (Except for the Coupé and Cabriolet)
- Raise the window to the mechanical stop and hold the switch for 1 second.
- Lower the window to the mechanical stop and hold the switch for 1 second.
- The windows are then initialised
Coupé and cabriolet (Vehicles with no door pillar)
- Close the door and window concerned
- Raise the window to the mechanical stop and hold the switch for 1 second.
- Lower the window to the mechanical stop and hold the switch for 1 second.
- The windows are then initialised
190
Airbag/Pyrotechnic seat belts
106/306/405/605 to AM95/806/Expert
Deactivation procedure:
1
-switch off the ignition, remove the
key
-disconnect the negative battery
terminal
-protect the cable and terminal
-wait 10 mins
-disconnect the orange connector
on the right underneath the dashboard
2
Airbag self diagnostic by: 2-track white socket under the bonnet
Seat belt self diagnostic: none
Airbag all models
Deactivation procedure:
1
-switch off the ignition, remove the
key
-disconnect the negative battery
terminal
-protect the cable and terminal
-if an airbag no longer operates (red
LED does not go out)
-wait 10 min. before removing the
airbag.
2
Airbag self-diagnostic: none
Seat belt self-diagnostic with 2 modules: none
Seat belt self-diagnostic with 1 module (605/806/Expert): via socket IPC 30
191
Airbag/Centralised system seat belts
The 607 is fitted with:
- 2 frontal airbags.
- 2 side airbags in the front seats.
- Two curtain airbags.
- Five seat belts with force limiters, front pyrotechnic inertia reels.
Airbag self-diagnostic/ seat belts 106S2, 406, 605, 806, Partner, Expert: via IPC‑30.socket
Airbag self-diagnostic/seat belts 306N3 : via white 2-track socket under the RR seat.
Airbag self-diagnostic/seat belts 306N5 and all types from AM98: via 16-track EURO socket.
Airbag reactivation all types:
- check that the battery is disconnected,
- attach the airbag,
- reconnect the battery,
- move away from the bag deployment space,
- switch on the ignition,
- check that the warning light is working.
Notes:
• In the event of an average strength frontal impact, only the pyrotechnic seat belts may be
triggered.
• Always store the airbag facing upwards.
• Write the validity date in the Maintenance Booklet.
• Do not use a measurement instrument on an explosive module.
See also:
- IS 240/96 - Parts to be replaced after operation, also see the "Protection and
Security" diagnostic brochures for each different model.
- IS 372/98 - Recommendation. FR seats con. with side airbag, for 306, 406,
605.
- 607, see presentation brochure page 130.
192
206 from DAM 9065/406 from DAM 9001/307/807: Airbags
and pyrotechnic seat belts
Introduction:
- The frontal airbags are the new SMART AIRBAGS design with offset triggering in accordance
with the impact.
- The inertia switch function is performed by the airbag computer (front, side and rear "impact
detection" signal distribution).
- Resupply of the fuel pump (after an impact): switch the +CC off and on again.
- The rotary switch for the driver's airbag is incorporated in CV00.
- 406 is never fitted with curtain side airbags.
Operation:
During a frontal impact, the airbags and pretensioners module simultaneously controls:
- triggering of the pretensioners,
- triggering of the airbags using the level 1 pyrotechnic module then level 2, offset according
to the type of impact
- issuing of the "impact detection" signal.
Type of impact:
- low speed => delay of approximately 150 ms,
- average speed => delay of approximately 30 ms,
- high speed => delay of approximately 3 ms,
During a side impact, the airbags and pretensioners unit controls the simultaneous triggering (on
the impact side):
- of the side chest airbag,
- of the side curtain airbag (on 307 / 807),
- issuing of the "impact detection" signal.
During a rear impact, the airbags and pretensioners module controls the triggering of the front
pyrotechnic seat belt modules (as on the 307) and sends the "impact detection" signal.
Detection of an impact - the BSI requests:
- the fuel pump to be cut-off (resupply of the fuel pump: cut off and starting of +CC),
- the hazard warning lights to come on,
- the doors to be automatically unlocked (except for impacts at low speed),
- the additional heater to stop (diesel engine).
Instrument panel warning lights:
- "system fault" warning light,
- "inhibit passenger airbag" warning light,
- "driver's seat belt reminder" warning light.
193
307 Tilting and sliding sunroof
Opening/Closing
The sunroof is open or closed using the rotary switch that controls the preselected
positions (closed: 3 tilt positions and 6 open positions).
The sunroof works:
- with + AA present
A Hall effect sensor incorporated in the motor is used:
- to determine the roof position
- to protect the motor
Tilt speed override
When the vehicle speed is greater than 100 km/h, if the roof is tilted to the maximum
or in the intermediate position, it will close by one position.
Below 5 km/h, the roof will go back to its initial position.
Position reminder
The position reminder allows the driver to go back to the position selected by the
switch with a single press on the rotary switch (e.g. tilt speed override, open roof closing when deadlocking with the HF remote).
Anti-pinch
when closing, after encountering resistance, the sunroof retracts by 50 mm.
The anti-pinch function is temporarily inhibited by holding the rotary switch down
("CLOSE" position).
Initialising the sunroof
In the case of losing the +BB feed, the sunroof must be initialised (as for the standard
electric windows).
The initialisation is only carried out in the maximum tilt position by pressing for
more than one second on the sunroof switch.
194
Sunroof/blind initialisation
Introduction
The initialisation enables the sunroof or blind motor/computer to program its opening and
closing limits to ensure the anti-pinch function.
This initialisation must be carried out under the following circumstances:
-
removing and refitting a motor.
disconnecting the battery (In some cases).
replacing the computer or motor.
removing and refitting or replacing the frame of the sunroof or blind.
The initialisation procedures are described below:
Sunroof /Blind 207/1007/407 SW
1 : Set the control to the closed position (0 for a sunroof) or shaded (9 for a blind).
2 : Press it, wait 3 seconds, the mobile panel (Sunroof or blind) moves to the closing limit,
then shifts slightly by a few millimetres in the direction of opening.
3 : Release the control during the 5 seconds that follow the immobilisation of the mobile
panel.
4 : During the next 2 seconds, quickly press the control for at least one second.
5 : During the next 5 seconds, press again for more than 4 seconds on the control and
release it when the panel has completed the following cycle:
- Sliding open
- Sliding closed
Information:
If the control is released during the cycles above, the panel will stop and wait
to be reinitialised to be able to function.
6 : The roof or blind is then initialised.
Sunroof 407 Hatch/307 (Except 307 SW)
Automatic procedure ( Except 307 VAN )
The automatic initialisation procedure is possible by going through the spare parts PP2000
menu
Manual procedure:
1 : Set the control to the maximum tilt position.
2 : Press it, wait 3 seconds, the mobile panel will go to the tilt limit then back to its initial
position.
3 : Release the control during the 5 seconds that follow the immobilisation of the mobile
panel.
195
4 : During the next 2 seconds, quickly press the control for at least one second.
5 : During the next 5 seconds, press again for more than 4 seconds on the control and
release it when the panel has completed the following cycle:
- Sliding open
- Sliding closed
- Tilt opening
Information: If the control is released during the cycles above, the panel will stop and wait to
be reinitialised to be able to function.
6 : The roof is then initialised.
Procedures for 607 sunroof and 307 SW sunblind
For the Sunroof
1 : Opening the mobile panel at the tilt "mechanical limit".
2 : Release the control.
For the sunblind:
1 : Open the panoramic blind to the limit
2 : Once the blind is fully open, close it until it reaches its limit
Sunroof 407 Coupe
1 : Close the panel by pressing and holding the (1st or 2nd position) two way tilt switch.
2 : Hold down the tilt switch for 1 second after the mobile panel stops at the closing slide
mechanical limit.
3 : Release it then press and hold the control switch again in the close position for under 5
seconds.
4 : The panel opens fully after you begin to press then closes fully.
5 : Release the switch, the roof is then initialised
Information: If the control is released during the initialisation cycle, the panel will stop and
wait to be reinitialised to be able to function.
196
Notes
197
IPC 30-track diagnostic connector
1
Permanent + feed
Rev counter
Injection/Ignition
Cooling fan assembly
ABS
Air conditioning
Automatic gearbox
A
B
C
D
E
F
G
H
I
J
2
+ Accessories feed
Earth
Injection/Ignition
Pyro seat belts
Suspension
Seat mem.
Alarm
3
Earth
Rev counter
Ignition/injection warning light
Variable steering
Airbag
Locking
ADC
EURO 16-track diagnostic connector
Terminal
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
Line
Function
+ After ignition feed
Tester power supply (max. A4)
K8
AC diagnostic
Engine speed/ CAN IS H
Engine speed signal/CAN Diag High
GND
Tester earth
S GND
Reference earth
K2/CAN DIAG H
Seat mem. diagnostic/Transponder/CAN Intersystem High
K ISO
Automatic gearbox/engine diagnostic
L IS CAN/Cooling fan assembly
Low
testIntersystem CAN/Cooling fan assembly test
607 Dual battery test
For connection of the additive module
Engine relay
Engine running relay signal
K9
Variable steering servo diagnostic
K3
Alarm diagnostic
K4
Electronic suspension/ABS diagnostic
K6
Deadlocking diagnostic/CAN Diag Low
L DIAG CAN/K5
Engine diagnostic/Automatic gearbox/CAN Intersystem Low
L (ISO 8)
Permanent + power supply
+ Battery feed
Installation of all brand terminals in compliance with EURO‑2000, EOBD standards
198
Peugeot Planet System PPS (PPO, PP2000, PPD, PPM)
The computer does not respond
To be checked:
-
Battery voltage (Umin = 10 V): Connect a rechargeable battery parallel to the battery
Vehicle selection
Internet network unavailable
PPI connection (LED on PPI lit)
PPO version not actualised
Password, identifier
Task management fault: disconnect the PPI from the PPS and vehicle after a PPO reboot
Incorrect computer supply (shunt, double relay)
Order to be carried out with Peugeot Planet Diagnostic:
1 - Configuration check
2 - Straight to the point
3 - Guided diagnostic
199
Headings available in PPD by vehicle
1 - Configuration
check
2 – Straight to the
point information
3 - Guided
diagnostic
107
Available
Available
206 mux
Available
Ranges:
Non-removable
106
207
Available
Controls/EMF
Available
Available
306
307 VAN
Available
Available
307 CAN
Available
Available
Available
307R
Available
Available
Available
308
Available
Available
Available
405
406 mux
407
Available
Available
4007
Controls/EMF
Available
Available
Available
Available
Available
Available
607
607R
Controls/EMF
Available
807 VAN
Available
(1)
807 CAN
Available
Available
Available
1007 VAN
Available
Available
Available
1007 CAN
Available
Available
Available
Available
Available
Available
Available
Available
Available
Available
Available
Available
Available
Bipper
Partner
Partner – B9
Expert
Expert II
Boxer
Boxer III
(1) Only the telematics function is available.
200
Controls/EMF
Controls/EMF
Notes
201
Options for DIAG 2000/DIAG 2000 NG/PPS
DIAG 2000/DIAG 2000 NG adaptors
Ref.
Spare Part No.
35-track computer
9799.93
55-track computer
9799.94
2 x 15-track computer
9799.95
Diagnostic socket switch
P.02 switch
Actia
Standard resistor 100 Ohm
SL‑310‑15
9776.R7
4-track lambda sensor (to be used with CS02 wire)
7.1217
9770.55
2 x 13-track deadlocking module
(to be used with AC92 Spare art no. 9776.A2)
7.1218
9770.56
Locked 15-track double relay (replaced by 7.1229)
7.1216
9770.54
2 x 15-track + 1 x 15-track air conditioning module
(also can be used for ADC keypad)
7.1219
9776.C2
18-track airbag module
7.1220
9770.59
22 + 12-track air conditioning module
7.1223
9770.62
ZF 4HP20 88-track automatic gearbox computer
7.1224
9770.63
Bosch 5 40-track ABS computer
7.1222
9770.61
Teves 25-track ABS computer
7.1225
9770.69
2x 26 track controls
7.1226
9770.64
12-track side airbag module
7.1232
9770.81
Dual locking relay/Electronic
suspension computer (replaces 7.1216)
7.1229
9770.70
Bosch 5.3 31 track ABS computer
7.1233
9770.80
Boxer 5.3 ABS Male/Female
7.1233A
9770.94
18 + 6-tracks transponder unit
C.1234
9770.79
16-track EURO central diagnostic socket
A.1236
9770.83
806 passenger compartment protection unit
C.1237
9770.85
AL4 Automatic gearbox
C.1238
9770.88
B1 level BSI 206
C.1240
9770.91
B2/B4 BSI 206
C.1241
9770.87
206 climate control
C.1243
9770.92
Navigation + Controls 206/306
C.1245
9770.93
406 D9 Controls
C.1246
9770.97
106/406 injection
C.1247
9770.98
206/406 112-track injection
C.1248
9770.99
D9 406 radio
D9 406 climate control
Add. connector for the Boxer diagnostic from 2002
C.1249
C.1250
A.1254
9770.A0
9770.A1
9780.E3
Ref.
Spare Part No.
Peugeot Planet Measure PPM
PPS options
-
9780.Q2
Cigarette lighter adapter for portable PPS
-
9780.Q8
Wiring harness tester tool (test pin)
-
9780.G7
202
Branching wiring bundles
Spare part ref no.
BSI CAN computer
4348-T
4350-T
4265-T
4266-T
BSI BI-VAN CAN computer
4265-T
4266-T
BSR computer
4350-T
4265-T
BSC computer
4350-T
4265-T
BTC computer
4350-T
4265-T
PSF1 BI-VAN CAN computer
4265-T
PSF1 CAN computer
4391-T
TU3JP computer
4229-T
TU3A computer
4371-T
4229-T
4382-T
ET3 (MM6LP) computer
4229-T
ET3 (MM6LPC) computer
4371-T
4229-T
4382-T
TU5JP computer
4229-T
EWxJ4 computer
4229-T
EWxA computer
4371-T
4229-T
4382-T
EP computer
4229-T
4393-T
4401-T
ES9A computer
4229-T
4382-T
DVx computer
4229-T
DW10/12A (EDC15C2 injection and SID 801) computer
4229-T
DW10B (DCM3.4 injection and SID 803) computer
4229-T
4340-T
DW12B (ED16CP39 injection) computer
4229-T
4340-T
4382-T
P22DT computer
4229-T
DT17 computer
4229-T
4340-T
4382-T
BVMP MCP computer
4389-T
BVA AM6 computer
4345-T
203
Electrical measurements with differentiator C.1247 of 128track engine management computers: Bosch M E7.4.6 etc.
48-track connector, NR
Computer
terminals
Differentiator
terminals
Computer
terminals
Differentiator
terminals
Computer
terminals
Differentiator
terminals
Computer
terminals
Differentiator
terminals
A1
B1
C1
D1
E1
F1
G1
H1
J1
K1
L1
M1
001
002
003
004
005
006
007
008
009
010
011
012
A2
B2
C2
D2
E2
F2
G2
H2
J2
K2
L2
M2
013
014
015
016
017
018
019
020
021
022
023
024
A3
B3
C3
D3
E3
F3
G3
H3
J3
K3
L3
M3
025
026
027
028
029
030
031
032
033
034
035
036
A4
B4
C4
D4
E4
F4
G4
H4
J4
K4
L4
M4
037
038
039
040
041
042
043
044
045
046
047
048
Computer
terminals
Differentiator
terminals
48-track connector, MR
Computer
terminals
Differentiator
terminals
Computer
terminals
Differentiator
terminals
Computer
terminals
Differentiator
terminals
A1
B1
C1
D1
E1
F1
G1
H1
J1
K1
L1
M1
049
050
051
052
053
054
055
056
057
058
059
060
A2
B2
C2
D2
E2
F2
G2
H2
J2
K2
L2
M2
061
062
063
064
065
066
067
068
069
070
071
072
A3
B3
C3
D3
E3
F3
G3
H3
J3
K3
L3
M3
073
074
075
076
077
078
079
080
081
082
083
084
A4
B4
C4
D4
E4
F4
G4
H4
J4
K4
L4
M4
085
086
087
088
089
090
091
092
093
094
095
096
32-track connector, GR
Computer
terminals
Differentiator
terminals
Computer
terminals
Differentiator
terminals
Computer
terminals
Differentiator
terminals
Computer
terminals
Differentiator
terminals
A1
B1
C1
D1
E1
F1
G1
H1
097
098
099
100
101
102
103
104
A2
B2
C2
D2
E2
F2
G2
H2
105
106
107
108
109
110
111
112
A3
B3
C3
D3
E3
F3
G3
H3
113
114
115
116
117
118
119
120
A4
B4
C4
D4
E4
F4
G4
H4
121
122
123
124
125
126
127
128
204
Electrical measurements with differentiator C.1248 and
112-track computers: MM 4.8P/Sirius 81 etc.
32-track connector, NR (CLM1 = engine link connector)
Computer
terminals
Differentiator
terminals
Computer
terminals
Differentiator
terminals
Computer
terminals
Differentiator
terminals
Computer
terminals
Differentiator
terminals
A1
B1
C1
D1
E1
F1
G1
H1
001
002
003
004
005
006
007
008
A2
B2
C2
D2
E2
F2
G2
H2
009
010
011
012
013
014
015
016
A3
B3
C3
D3
E3
F3
G3
H3
017
018
019
020
021
022
023
024
A4
B4
C4
D4
E4
F4
G4
H4
025
026
027
028
029
030
031
032
32-track connector, NR (CLM1 = engine link connector)
Computer
terminals
Differentiator
terminals
Computer
terminals
Differentiator
terminals
Computer
terminals
Differentiator
terminals
Computer
terminals
Differentiator
terminals
A1
B1
C1
D1
E1
F1
G1
H1
081
082
083
084
085
086
087
088
A2
B2
C2
D2
E2
F2
G2
H2
089
090
091
092
093
094
095
096
A3
B3
C3
D3
E3
F3
G3
H3
097
098
099
100
101
102
103
104
A4
B4
C4
D4
E4
F4
G4
H4
105
106
107
108
109
110
111
112
48-track connector, MR (CLC1 = body link connector)
Computer
terminals
Differentiator
terminals
Computer
terminals
Differentiator
terminals
Computer
terminals
Differentiator
terminals
Computer
terminals
Differentiator
terminals
A1
B1
C1
D1
E1
F1
G1
H1
J1
K1
L1
M1
033
034
035
036
037
038
039
040
041
042
043
044
A2
B2
C2
D2
E2
F2
G2
H2
J2
K2
L2
M2
045
046
047
048
049
050
051
052
053
054
055
056
A3
B3
C3
D3
E3
F3
G3
H3
J3
K3
L3
M3
057
058
059
060
061
062
063
064
065
066
067
068
A4
B4
C4
D4
E4
F4
G4
H4
J4
K4
L4
M4
069
070
071
072
073
074
075
076
077
078
079
080
205
BSI - Electrical measurements with differentiator C1240
Selection according to the numbers of the terminals to be measured
Differentiator C 1240
Selection by
wiring harness
tester
1
1
2
2
3
3
4
4
5
5
6
6
7
7
8
8
9
9
10
10
11
11
12
12
Differentiator C 1240
BSI connector
Selection by
12 tracks yellow wiring harness tester
1
13
2
14
3
15
4
16
5
17
6
18
7
19
8
20
9
21
10
22
11
23
12
24
13
25
14
26
15
27
16
28
17
29
18
30
19
31
20
32
21
33
22
34
23
35
24
36
25
37
26
38
BSI connector
12 tracks blue
Differentiator C 1241
Selection by
wiring harness
tester
1
39
2
40
3
41
4
42
5
43
6
44
7
45
8
46
9
47
10
48
11
49
12
50
BSI connector
12 tracks brown
206
BSI - Electrical measurements with differentiator C1241
Selection according to the numbers of the terminals to be measured
Differentiator C 1241
BSI connectorI
12 tracks black
Selection by
wiring harness tester
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
Differentiator C 1241
BSI connector
Selection by
12 tracks blue
wiring harness tester
1
3
2
4
3
5
4
6
5
7
6
8
7
9
8
10
9
11
10
12
11
13
12
14
13
15
14
16
15
17
16
18
17
19
18
20
19
21
20
22
21
23
22
24
23
25
24
26
25
27
26
28
Differentiator C 1241
BSI connector
12 tracks green
Selection by
wiring harness tester
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
45
46
47
48
49
50
51
52
53
54
55
56
57
58
59
60
207
Notes
208
Refrigeration circuit capacities
Model
Version
R134a [gr]
R12 [gr]
106
S1
875±25
975±25
S2
890±25
S2
915±25
TU5J4/TUD5
850±25
TU5J4/TUD5
860±25
384/F
450±25
DV4TD
500±25
TT Europe
500±25
TT Mercosur
600±25
205
TU/XU
675±25
206
TU/ET/DV/DW
700±25
EW/DW10
675±25
DV6
630±25
TU3AE4
450±25
ET3J4E4
450±25
EP6 MAR/MA
450±25
EP6 AL4
500±25
EP6DTE4
500±25
EP6DTSE4
500±25
TU5JP4E4
450±25
107
1007
207
TU5JP4E5
500±25
DV4TDE4 MA5
450±25 Air con 37°
500±25 Air con 45°
DV4TDE4 MAP STT2
450±25 Air con 37°
500±25 Air con 45°
DV6ATED4E4
500±25
DV6TED4E4
500±25
306
N3
900±25
N5
725±25
307
TT except DV6 (up to OPR 10080)
585±25
TT except DV6 (from OPR 10080)
450±25
DV6 (up to OPR 10218)
585±25
DV6 (from OPR 10218)
450±25
307 Restyle
TT
450±25
308
TT
450±25
405
TT
675±25
305
309
800±25
900±25
TT
1100±25
209
Refrigeration circuits capacities (continued)
Model
Version
R134a [gr]
406 (D8)
XU/XUD
800±25
R12 [gr]
ES
750±25
XUD 7448
750±25
XU/ES9
775±25
EW/DW
625±25
TT
625±25
up to AM01
775±25
AM01
750±25
407
TT except DT17/DW12B
625±25
407
DT17/DW12B
525±25
607
TT
625±25
607 Restyle
TT except DT17
625±25
DT17
600±25
Petrol
850±25
1000±25
Diesel
765±25
900±25
TT
885±25
406 (D9)
406 Coupe
505
605
Z7
885±25
ES9
875±25
Z7 DK5
850±25
up to AM01
975±25
AM01
950±25
807
TT
600±25
807 Restyle
DW10/DW12
540±25
EW10A/EW12/ES9
675±25
4007
TT
500±20
Bipper
TT
500±25
Partner
TU
875±25
XU/XUD/DW
725±25
DW8
775±25
Partner II
TT
575±25
Expert
TT
975±25
Expert II
TT
950±25
Expert III
Petrol single loop
675±25 (1)
806
Diesel single loop
540±25 (1)
Petrol long version double loop
1075±25 (2)
Petrol short version double loop
950±25 (2)
Diesel long version double loop
950±25 (2)
Diesel short version double loop
850±25 (2)
210
Refrigeration circuits capacities (continued)
Model
Version
R134a [gr]
Boxer
up to AM96
Single circuit
1000±50
from AM96
Dual circuit
1200±50
Boxer III
AM96
Single circuit
800±50
AM96
Dual circuit
1000±50
550±25 (1)
TT
950±25 (2)
(1) Simple climate control
(2) Additional climate control
211
R12 [gr]
Petrol engine coolant circuits capacities
Vehicle
Engine family
Engine plate
107
384F
CFA
4
TU3JP
KFV
5.4
TU5JP4
NFU
5.9
ET3J4
KFU
1007
206
TU1JP
HFX HFY
TU3JP
K6C K6D KFW KFX
TU3A
K6D KFW
TU3AF
N/A
ET3JA
KFU
TU5JP4
N6A NFU
TU5JP4
NFZ
EW10J4
207
Capacity in litres (± 0.25)
7
5.6
RFN RFK
7
Temperate climate (37°C)
5
Temperate climate (45°C)
5.3
EW10J4S
RFK
5.3
TU3A
KFV K6E
5.3
ET3J4
KFU
5.7
TU5JP4
NFU
5.4
EP3
8FS
EP6
5FW
EP6DT
5FX
EP6DTS
5FY
TU3JP
K6D KFW
6
ET3J4
KFU
6.2
TU5JP4
N6A NFU
EW10A
RFJ
5.27
307
EW10J4
307 Restyle
Misc.
RFN RFK
EW10J4S
RFK
ET3J4
KFU
TU5JP4
N6A NFU
EW10A
RFJ
EW10J4S
RFK
Manual gearbox
5.8
Automatic gearbox
Temperate climates
(37°C) Manual gearbox
6.2
Temperate climates
(45°C) Automatic gearbox
6.8
Temperate climates
(37°C) Manual gearbox
6.6
Temperate climates
(45°C) Automatic gearbox
6.9
6.6
5.8
Manual gearbox
6.2
Automatic gearbox
6.7
Automatic gearbox
6.8
6.6
212
Petrol engine coolant circuits capacities (continued)
Vehicle
308
407
607
Engine family
Engine plate
EP3
8FS
EP6
5FW
EP6DT
5FX
EP6DTS
5FY
EW7A
6FY
6FZ
EW10A
RFJ
EW10JA
RFN
EW12J4
3FY 3FZ
ES9A
XFV
EW10J4
RFN
EW12J4
3FZ
ES9J4S
XFX
EW12J4
3FY 3FZ
807
EW10A
RFJ
EW10J4
RFN
EW12J4
3FZ
ES9J4S
XFW
6
Automatic gearbox
6.2
Automatic gearbox (AL4)
6.4
7.5
Manual gearbox
7.3
Automatic gearbox
8.1
Manual gearbox
7.3
Automatic gearbox
8.1
Manual gearbox
7.9
Automatic gearbox
8.4
Automatic gearbox
9.8
7.4
607 Restyle
XFV
Capacity in litres (± 0.25)
6
EW7J4
ES9A
Misc.
Manual gearbox
Manual gearbox
7.6
Automatic gearbox
8.2
Manual gearbox
10
Automatic gearbox
10.1
Manual gearbox
7.6
Automatic gearbox
8.2
Manual gearbox
10
Automatic gearbox
10.1
Manual gearbox
7
Automatic gearbox
7.2
Manual gearbox
7
Automatic gearbox
7.2
Automatic gearbox
10.5
7.2
4007
4B12-MMC
N/A
7.5
Bipper
TU3A
KFV
5.6
TU1JP
HFX
TU3A
K6D KFW
With refrigeration
5.6
TU3JP
K6D KFW
Without refrigeration
7
TU3JP/NGV/LPG
KFW
TU5JP4
NFU
EW10A
RFH
Partner II
Expert III
6.5
8.5
213
Diesel engine coolant circuits capacities
Vehicle
Engine family
Engine plate
107
DV4TD
8HX
4.4
DV4TD
8HX
5.6
DV6TED4
9HZ
6.2
DV4TD
8HX 8HZ
5.7
DW8
WJZ
1007
206
207
307
307 Restyle
308
407
607
Misc.
Capacity in litres (± 0.25)
8.2
DW8B
WJY
DV6TED4
9HZ 9HY
6
DW10TD
RHY
6.3
DV4TD
8HZ
DV6TED4
9HZ 9HY
DV6TED4B
9HV
DV6ATED4
9HX
DV4TD
8HZ
DV6TED4
9HZ 9HY
DV6ATED4
9HX
DW10TD
RHY
6
RHS
RHR
DV6TED4
9HY 9HZ
DV6ATED4
9HX
9HV
DW10TD
RHY
DW10ATED
RHZ
DW10ATED4
RHR
6.5
8.3
DW10ATED4
DW10BTED4
DV6TED4B
5.6
8.1
6.5
8.1
DV6TED4
9HZ 9HY
DV6TED4B
9HV
DV6AATED4
9HX
DW10BTED4
RHR
DV6TED4
9HZ 9HY
DW10BTED4
RHR RHL
DW12BTED4
4HP 4HR 4HT
10.7
DT17
UHZ
13.2
DW10ATED4
RHZ RHS
DW12TED4
6
4HX
214
Manual gearbox
7.8
Automatic gearbox
8.2
7.2
Manual gearbox
9
Automatic gearbox
10
9.3
Manual gearbox
9.8
Automatic gearbox
10.3
Diesel engine coolant circuits capacities (continued)
Vehicle
607 Restyle
Engine family
Engine plate
DW10ATED
RHS
DW0BTED4
RHL RHR
DW12TED4
4HX
DW12BTED4
4HP 4HR 4HT
DT17
UHZ
DW10ATED4
RHW RHM RHT
DW10BTED4
RHR
DW10UTED4
RHK
DW12TED4
4HW
Misc.
Capacity in litres (± 0.25)
9.3
Manual gearbox
9.8
Automatic gearbox
10.3
Manual gearbox
9.8
Automatic gearbox
10.3
11.1
Without particle filter
With particle filter
Without particle filter
With particle filter
807
Without particle filter
With particle filter
11.3
DW12BTED4
4HP 4HR 4HT 4HS
4007
DW12MTED4
4HN
8
Bipper
DV4TD
8HS
7.35
Partner II
Expert III
DV6ATED4
0HX
DV6BTED4
9HW
DW8B
WJY
DW10TD
RHY
DV6UTED4
9HU
DW10UTED4
RHK
DW10BTED4
RHR
PUMA 22DT (100CV)
hv
PUMA 22DT (12CV)
hu
PUMA 22DT (130CV)
hm
SOFIM
fȈdt
11
9
Without additional heating
9
With additional heating
10
10.02
Boxer III
With refrigeration
12
Without refrigeration
11.5
With refrigeration
12
Without refrigeration
11.5
With refrigeration
Without refrigeration
215
With refrigeration
11.6
Without refrigeration
11.1
Oils and special fluids can be delivered by Parts Dept.
Component
Quality
Add. tank (HDI/PF)
“EOLYS DPX42” additive batch
“EOLYS 176” additive batch
Spare part ref.
Quantity
9979.95
9736.65
9736.86
9736.85
5.0 lit
1.0 lit
3.0 lit
1.0 lit
Manual gearbox
Gearbox transmission total
75W - 80W
9730.A2
2.0 lit
Automatic gearbox
ZF 3H012 - 3HP22
ZF 4HP14 - 4HP18 - 4HP22
GM: MB3
Total “AT42”
9730.A3
1.0 lit
Automatic gearbox
ZF 4HP20/AL4
Esso ATF
4HP20/AL4
9736.22
2.0 lit
Automatic gearbox
AM 6
Esso JWS 3309
9980.D4
2.0 lit
FR/RR axle and transfer module
(Hypoid)
X4 transmission total
9730.A4
2.0 lit
405 X4
Hydraulic RR susp.
Esso LHM
9979.64
1.0 lit
Power steering (except 307, 407,
Scandinavia)
Total “AT42”
9730.A3
1.0 lit
Pump assembly power steering (except
307, 407, Scandinavia)
"PAS fluid" total
9730.A1
1.0 lit
Shock absorber oil
Esso “Oleo Fluid PA”
9730.27
2.0 lit
205/306 Cabriolet/307CC
Electric hood oil
Equivis “XV 32”
9735.57
0.25 lit
206 CC
Retractable roof oil
ARAL Vitamol ZH/M
9734.NO
0.125 lit
R12
Air conditioning
compressor
R134a
9735.H8
0.125 lit
Variable capacity
“SANDEN SP10”
SANDEN compressor
(SD7V12, SD7V16
+‑new models)
“LUNARIA -S”
9735.C5
0.04 lit
9735.C4
0.25 lit
Fixed capacity
“SANDEN SP20”
SANDEN compressor
(SD7H13, SD7H15)
9735.C8
0.04 lit
9735.C6
0.25 lit
DELPHI-HARRISON “PAG 488”
compr. (V5)
9979.41
0.04 lit
9979.40
0.25 lit
216
Notes
217
Identification of petrol engines from AM 83
Type
Code
Model
cm∆
Manual/Auto
gearbox
kW/CV
Power supply
XW7
109X
205
1124
36/50
BH3
SC
XY6B
150Z
205
1360
52/72
BH3
DC
XY7CP
KAZ
205
1360
40/54
BH3
Controlled carburettor
TU3CP
KAY
205
1360
44/60
MA
Controlled carburettor
TU9ML/Z
CDY
106
954
33/45
MA
M.-Motro. MA3.0
TU9MZ
CDZ
106/205
954
37/50
MA
M.-Motro. MA3.0
TU1M(Z)
HDZ
106/205
1124
44/60
MA
Mono-Jetr. A2.2
M.M.G6/Bo.MA3.0
TU1M+
HDZ
106/Partner
1124
44/60
MA
M.-Motro. MA3.1
TU1JPL3
HDZ
206
1124
44/60
MA
M.M.1AP
TU32J2Z
HFZ
106
1294
72/100
MA
M.M.8P
TU3M(Z)
MFZ
205/309
1360
55/75
MA
M.-Jetronic A.2.2
TU3M(Z)
KDZ
106/205/309
1360
55/75
MA
M.-Jetronic A.2.2
“TU3(F)
MCZ
KDY
106/205/306
1360
55/75
MA
M.-Motro. MA3.0
M.M.G6
TU3FJ2Z
KFZ
106
1360
69/95
MA
Motronic MP3.1
TU3JPL3
KFX
106S2/306N5/
206/Partner
1360
55/75
MA
M.M.1AP
MP7.3 (L4)
TU5JPZL3
NFZ
106/106S2/
306
1587
65/90
MA/MB3
MP5.1/MP5.2
MP7.2
TU5JPL3
NFZ
206
1587
65/90
MA/AL4
Motronic MP7.2
TU5J2Z
NFY
106
1587
76/105
MA
M.M.8P
TU5J2L3
NFW
106
1587
74/103
MA
M.M.8P
TU5J4L3
NFX
106S2
1587
87/120
MA
M.M.1AP
XU5CP
BAZ
205/305/309
1580
54.5/76
BE1/ZF4HP14
Controlled carburettor
XU5CP
BAY
205/309
1580
54.5/76
BE1/ZF4HP14
Controlled carburettor
XU5J1
180Z
205/309
1580
76/105
BE1
LE-Jetronic
XU5JPZ
BFZ
405/406
1580
65/90
BE3
M.M.8P/Sag.4GJ
XU5M(Z)
BDZ
309/405
1580
65/90
BE3
M.M.G5
XU5M2Z
BDY
205/309/405
1580
65/90
BE3
M.M.G5
XU5M3Z
BDY
205/309/405
1580
65/90
BE3
M.M.G6
1580SPI
220A2
Expert
1580
58/80
BE3
M.-Motro. MA1.7
XU7JB
LFX
406/Partner
1761
66/90
BE3
M.M.1AP
XU7JPZ(L3)
LFZ
405/306
1761
74/103
BE3/ZF4HP14
Bosch MP5.1/
M.M.8P
XU7JP4Z(L3)
LFY
306N5/406
1761
81/112
BE3
MP5.1.1/MP5.2/
Sag.SL960/MP7.3
XU9S
159Z
305
1905
75/102
BE1/ZF4HP14
DC
XU9M
DDZ
309/405
1905
80/110
BE1/BE3
Inj.centr.Fenix1B
XU9J1
DFZ
205/305/
309/405
1905
77/105
BE1/ZF4HP14
LU-Jetronic
218
Oil capacity
BVM4 4.5
BVM5 5.0
3.2 (except
206/Partner 3.0)
3.25
T: è 92 : 5.0
93 è 4.5
A: è 92 4.7
92 è 4.2
3.7
T: 4.7
A: 4.2
(SI510/99)
T: è 92 : 5.0
93 è 4.5
A: è 92 4.7
92 è 4.2
Type
Code
Model
cm∆
kW/CV
Manual/Auto
gearbox
Power supply
Oil capacity
XU9JAZ
DKZ
205/309/
405
1905
88/122
BE1/BE3/
ZF4HP14
Motro. M1.3
(standard type)
XU9J4
DFW
405
1905
108/148
BE1/BE3
Motro. M1.3
XU9J4Z
DFW
309/405
1905
108/148
BE3
Motro. M1.3
XU10J2Z
RFZ
605
1998
89/123
BE3/ZF4HP18
Motro. MP3.1 MP5.1
XU10J2CZ
RFX
306/405
1998
89/123
BE3/ZF4HP18
MM8P
T:4.5/A:4.2
XU10J2CZ
RFU
806
1998
89/123
BE3
MM8P
T:4.8/A:4.5
XU10J2
RFW
Boxer
1998
80/110
ME5T/MG5T
MM8P
T:4.8/A:4.5
XU0J2TEZ
RGY
605
1998
105/145
ME5T/ZF4HP18 Motro. MP3.2
T:4.5/A:4.3
XU10J2 (C)/
TEZ
RGX
406/806/
605
1998
108/150
ME5T/ME5K/
ML5/ZF4HP18
Motro. MP3.2
605: B:4.5/
A:4.3
406/806:
T:4.8/A:4.5
XU10J4Z
RFY
306/405
1998
111/155
BE3
Motro. MP3.2
XU10J4Z
RFT
306/405
1998
108/150
BE3
Motro. MP3.2
T: 4.8/A: 4.3
XU10J4R
RFV
306N5/
406/605
1998
97/135
BE3/
ZF4HP18/
ZF4HP20/
AL4
Motro. MP5.1.1
MP5.2/SA.LS96
MP7.3 (L4)
4.25
XU10J4RS
RFS
306
1998
120/167
BE3/6
MM 1AP
4.2
XU10J4TEZ
RGZ
405
1998
144/200
ME5KX
MM AP
4.2
EW10J4
RFR
206 / 406
1998
99/135
BE4/AL4
MM 4.8P
4.2
XN1TACP
170D
J5
1971
62/85
M5
Controlled carburettor
N9TE
176X
505
2155
110/154
BA10
LU-Jetronic
N9TE
176Y
505
2155
114/160
BA10
L-Jetronic
N9TEA
176W
505
2155
128/180
BA10
LU-Jetronic
ZDJL
851Y
505
2165
89/130
BA7/ZF4HP20
LE-Jetronic
ZDJL
851X
505
2165
84/115
BA7/ZF4HP20
LU-Jetronic
5.5
ZN3J
154X
505
2849
105/143
BA10/ZF4HP22
LH-Jetronic
6.5
ZPJ4Z (*)
UKZ
605
2963
147/200
ME5T
Siem.Fenix 4
6.5
ZPJZ (*)
UFZ
605
2963
123/170
ME5/4HP18
Siem.Fenix 3B
6.5
ZPJ4Z
SKZ
605
2975
147/200
ME5T/MG5TB
Siem.Fenix 4
6.5
ZPJZ (*)
SFZ
605
2975
123/170
ME5T/MG5TB/
ZF4HP18
Siem.Fenix 3B
EW10J4
R6F
807
1997
100/136
BE4
MM 4.8P
4.25
ES9J4
XFZ
406 / 605
2946
140/192
ML5T/ZF4HP20
Motro. MP7.0
4.75
Key:
Same as XU9J1
5.3
5.3
T:4.5/A:4.2
4.0
5.0
5.0
5.0
5.5
6.5
SC = Single casing carburettor/ T = Metal housing
DC = Dual casing carburettor/ A = Aluminium housing
è 93 = up to MJ93/Oil capacity = gravity-assisted draining with filter
93 è = from MJ93 / MM =Magneti Marelli / L,LH,MP,Motro. = Bosch
In all cases, check and correct the level if necessary
See IS No. 606/607 from 05.2001 (*) IS No. 34 from 1993
219
Identification of petrol engines
Emission control: L4/W4 (Euro III)/IFL5/L5 (Euro IV)
Type
Code
Model
cm∆
(*)
Manual/Auto
gearbox
Oil capacity
(**)
Power supply
384F (L5)
with VVT
1KR
(CFA)
107
998
50/68
C550/C550P
Bosch ME7.9.5
3.1
TU1JP (L4)
HFX
106/206
1124
44/60
MA
Motro
P7.4.4/MM 4.8P
3.25
ET3J4
(L4/L5)
with VVT
KFU
206/207/
307/1007
1360
65/88
MA
MM 6LP
3.25
TU3JP
(L4/L5)
KFV
1007
1360
54/73
MA/MAP
Sagem S2000
3.25
TU3JP
(L4/IFL5)
TU3JP+ (L4)
KFW
106/206/306/
307/ Partner
1360
55/75
MA/AL4
Sagem S2000
3.25
TU3A (L3/L4)
K6E
207
1360
53/72
MA
JCAE J34P
3.25
TU3A (L5)
KFV
1007/207
1360
54/73
MA
MAP
JCAE J34P
TU3A (L4/L5)
KFW
206/Partner
1360
55/75
MA
JCAE J34P
3.25
TU5JP (L4)
NFT
306
1587
72/98
MA
Motro P7.4.4
3.25
TU5J4 (L4)
NFX
106
1587
87/120
MA
MM 4.8P
3.25
TU5JP4
(L4/IFL5)
NFU
206/Partner/307
1587
80/109
MA
MAP
BE4
AL4
Motro P7.4.4
Bosch ME7.4.4
3.25
TU5JP4 (L5)
NFU
307
1587
80/109
ML5C
AL4
MAP
Bosch ME7.4.5
3.25
EP6 (L5)
5FW
207
1598
85/115
MA/AL4
Bosch MEU17.4
4
EP6DT (L5)
5FX
207
1598
110/150
BE4
Bosch MED17.4
4
EW7A (L5)
with VVT
6FY
407
1749
92/125
BE4
MM 6LPB
4.25
EW7J4 (L4)
6FZ
406
1749
85/117
BE4
Sagem S2000PL4
Sagem S2000PM2
4.25
XU7JP4 (L4)
LFY
306/406
1761
81/110
BE4
Motro. MP7.3
4.2
EW10J4/K
R6F
807
1997
100/139
BE4/5T
MM 4.8P
4.25
EW10A (L5)
with VVT
RFJ
307/407/807
1997
103/140
BE4/5S/AL4
MM 6LPB
4.25
EW10J4S
(L4/IFL5)
with VVT
RFK
206/307
1997
130/177
BE4/5T
MM 6LP
5.5
EW10J4
(L4/IFL5)
RFN
206/307/
406/407/806/
807/Expert
1997
100/137
BE4/5S/AL4
MM 4.8P
MM 4MP2
MM 6LP
4.25
Key:
(*)
(**)
VTC
MM
3.25
Power indication according to technical documentation Oil capacity = gravity-assisted draining with filter (see Infotec)
Valve Timing Control
VVT
Variable Valve Timing
Magneti Marelli
Motro. Motronic Bosch
220
Identification of petrol engines
Emission control: L4/W4 (Euro III)/IFL5/L5 (Euro IV)
(continued)
Type
Code
Model
cm∆
(*)
Manual/Auto
gearbox
Power supply
Oil capacity
(**)
EW10D (L4)
RLZ
406
1997
103/140
BE4
Siemens/Sirius 81
(direct injection)
4.25
XU10J2U
(W4)
RFW
Boxer
(until 2002)
1998
80/109
MLGU
MM 4.8P
4.25
XU10J2U
(W4/K4)
RFL
Boxer
(from 2002)
1998
81/110
MLGU
MM 4.8P
4.25
EW12E4 (L5)
with VTC
3FY
407/607
2230
120/163
ML6C/
ZF4HP20
MM 6LPB
4.25
EW12J4 (L4)
with VTC
3FZ
406/407/
607/807
2230
116/160
ML5C/T/
ZF4HP20/
ML6C
MM 4MP18
MM 4MP2
MM6LP
4.25
ES9J4S (L4)
with VTC
XFX
406/607
2946
152/207
ML5T/ZF4HP20
Bosch ME7.4.6
4.75
ES9J4S (L4)
with VTC
XFW
807
2946
150/204
ZF4HP20
Bosch ME7.4.6
4.75
ES9A (L5)
with VVT
XFV
407/607
2946
155/211
AM6
ML6C
Bosch ME7.4.7
4.75
4B12-MMC
SFZ
4007
2360
122/158
N/A
N/A
N/A
221
Identification of diesel engines from AM83
Type
Code
Model
cm∆
kW/CV
Manual/Auto
gearbox
Power supply
Oil capacity
(*)
TUD3Y
K9Y
106
1360
37/50
MA
Catalytic converter
TUD5Y
VJZ
106
1527
42/58
MA
Catalytic converter/EGR 4.75
XUD7TEY
AJZ
405
1768
66/90
BE1/BE3
Turbocharger/Catalytic
converter
XUD9
162
309
1905
47/65
BE1/BE3
XUD9Y
DJZ
205/309/306/
405
1905
47/65
BE1/BE3
EGR/Catalytic
converter
XUD9A
D9B
J5/Exp./Part.
1905
51/70
M5/BE3
EGR/Catalytic converter
XUD9AY
DJY
306/Partner
1905
51/70
BE3
EGR/Catalytic converter
XUD9TF
D8B
Expert
1905
67/92
ME5K
Turbo/Catalyt./EGR
XUD9TF
D8C
Boxer
1905
67/92
ME5K
Turbo/Catalyt./EGR
XUD9TF
DHX
806
1905
66/90
ME5K
Turbo/Catalyt./
ALFB/EGR
XUD9UTF
DHX
Boxer/Exp.
1905
66/90
ME5TU
Turbocharger/Catalytic
converter
XUD9BTF
DHX
406/Exp.
1905
66/90
BE3
VP 20/EGR/Cata.
XUD9TEY
DHY
306/405
1905
66/90
BE3
Turbo/Catalyt./
ALFB/EGR
DW8
WJZ
206/306/Partner
1868
51/70
BE4
EGR/Catalyt./
Advance SV
DW8B
WJY
Partner
1868
51/70
BE4
EGR/Catalyt./
Advance SV
XUD11ATEY
PHZ
605
2087
80/110
ME5TU
Turbo/Catalyt./EGR
XUD11BTE
P8C
406/806/ 605Z7
2087
80/110
ML5T
Lucas EPIC/
Turbo/ EGR/Cata.
DW10TD
RHY
206/306/Partner
1996
66/90
BE4
Comm. Rail Bosch
DW10ATED
DW10CTED
RHZ
406/806/Expert
1996
80/110
ML5T
EGR/Catalytic
converter
DW10BTED
RHX
Expert
1996
69/95
DW12TED4
(L4)
4HX
607
2179
98/136
ML5T/
ZF4HP20
sequential
Comm. Rail Bosch
EDC15C2, EGR/
Cata.
4.75
XD3P
157
J9
2497
53/73
BC3
Diesel roto
7.7
CRD93L
U25/661
J5
2500
54/74
M5
Diesel roto
4.7
CRD93LS
U25/673
J5
2500
70/95
M5
Turbo
M705T
280A1.000
J5
1929
60/82
M5
Turbocharger/Catalytic
converter
DJ5T
THZ
Boxer
2446
76/104
MG5TU
Turbo/Catalyt./EGR
DJ5T
T8A
Boxer
2446
76/104
MG5TU
Turbo/Catalyt./EGR
DK5TEY
THY
605Z7
2446
95/130
MG5T
Bosch MSA 11 3.6
VP 36
DK5ATEL3
THY
605Z7
2446
95/130
MG5T
Bosch MSA 11 3.6
VP 36 (air flow
sensor)
THX
Boxer
2446
79/110
MG5T
Direct injection/EGR
DJ5TED
Key:
B: 5/A: 4.7
SI 606/607 5.2001
B: 4.75 A: 4.5
4.75
4.5
Comm. Rail Bosch
T = Metal housing
C = Aluminium housing
Oil capacity = draining with filter (in all cases, check the level!)
See IS No. 606/607 from 05.2001
222
3.75
8.0
Notes
223
Identification of diesel engines
Emission control: L4/W4 (Euro III) / L5 (Euro IV)
Type
DV4TD (L4)
Code
8HX
8HZ
DV4TD (L5)
8HT
DV4TD
DV6TED4
(L4)
DV6TED4
Model
1007/206/307/
207
cmΔ
kW/CV
1398
50/70
40/54
Manual/
Auto
gearbox
MA
107
1398
C550
8HS
Bipper
1398
50/75
N/A
9HY
307/207/308/407
1560
80/109
BE4
Power supply
Com. Rail/Bosch
EDC16C3
Com. Rail/
Siemens 5WS
N/A
Com. Rail/Bosch
EDC16C3
Com. Rail/Bosch
Oil capacity (*)
3.75
3.75
3.75
3.5
9HZ
206/307/407/
1007/207/308
1560
80/109
BE4
DV6TED4B
9HV
207/307/308
1560
66.2/86
N/A
N/A
3.5
DV6ATED4
9HX
207/307
/Partner II
1560
66.2/86
N/A
N/A
3.5
DV6AATED4
9HX
308
1560
66.2/86
N/A
N/A
3.5
DV6BTED4
9HW
Partner II
1560
55.2/72
N/A
N/A
3.5
DV6UTED4
9HU
Expert III
1560
66.2/86
N/A
N/A
3.5
RHM
807
1997
80/110
AL4
(L4) FAP
DW10ATED4
(L4) FAP
DW10BTED4
(L4/L5) FAP
DW10ATED
(L4) FAP
RHR
RHS
307/807/
607/407/308/ Expert III
307/406/607
1997
100/136
1997
79/109
DW10ATED4
(L4) FAP
RHT
807
1997
80/110
EDC16C3
Com. Rail/Bosch
EDC15C2
ML6C
Com. Rail/
ZF4HP20
Siemens SID 803
BE4
Com. Rail/
AL4
Bosch EDC15C2
ML5C
Com. Rail/Bosch
AL4
EDC15C2
3.5
4.5
5.25
4.5
4.5
MAP
DW10UTD
DW10ATED4
(L4)
DW10BTED
(L4)
RHV
RHW
RHX
Boxer
806/807/Expert
Expert
1997
1997
62/85
80/110
1997
69/95
MLUC
ML5TAL4
BE4
206/306/307/
DW10TD (L4)
RHY
406/ Partner/ Partner II
Com. Rail/Bosch
EDC15C7
Com. Rail/Bosch
EDC15C2
Com. Rail/Bosch
EDC15C2
6.3
4.5
4.5
Com. Rail/Bosch
1997
66/90
BE4
EDC15C2/
4.5
Siemens SID 801
DW10ATED
(L4)
Key:
RHZ
(*)
FAP
TD
ATED
SOFIM
406/806/607
1997
80/110
BE4/ML5T/
AL4
Com. Rail/Bosch
EDC15C2
Oil capacity = gravity drainage with filter (see IS No. 606 /607)
Particle filter
Turbocharger without exchanger
Turbocharger with exchanger
Franco-Italian Engine Company
224
4.5
Identification of diesel engines
Emission control: L4/W4 (Euro III) / L5 (Euro IV)
(continued)
Type
DW10BTED4
Code
Model
cmΔ
kW/CV
Manual/
Auto
gearbox
RHL
407/607
1997
93/126
ML6C/
4HP20
FAP(L5)
DW10BTED4
(L5/L4)
DW10UTED4
RHR
RHK
(L5)
DW12BTED4
FAP(L5)
DW12BTED4
FAP(L5)
DW12BTED4
FAP(L5)
DW12BTED4
FAP(L5)
4HP
4HR
4HS
307/407
1997
807 (without FAP)/
Expert III
1997
407/607/807
2179
407/607/807
407/607/807
100/136
88/120
ML6C
Com. Rail/
Siemens
Oil capacity (*)
5.25
SID803
Com. Rail/Delphi
DCM3.4
Com. Rail/
Siemens
5.25
5.25
SID803
2179
2179
120/163
20/163
125/170
ML6C
AM6
AM6
Com. Rail/Bosch
EDC16CP39
Com. Rail/Bosch
EDC16CP39
Com. Rail/Bosch
EDC16CP39
Com. Rail/Bosch
5.25
5.25
5.25
4HT
407/607/807
2179
125/170
ML6C
ML5T
Com. Rail/Bosch
4HX
406/607
2179
98/136
ML6C
EDC15C2
4.75
DW12TED4
(L4) FAP
ML6C/
4HP20
Power supply
EDC16CP39
5.25
ZF4HP20
DW12MTED4
4HN
4007
2179
115/150
N/A
Com. Rail/Bosch
EDC16CP39
5.25
PUMA 22DT
(100cv)
4HV
Expert III
2198
74/96
N/A
Com. Rail/Bosch
EDC16CP39
5.75
PUMA 22DT
(120cv)
4HU
Expert III
2198
88/114
N/A
Com. Rail/Bosch
EDC16CP39
5.75
PUMA 22DT
(130cv)
4HM
Expert III
2198
99.5/130
N/A
Com. Rail/Bosch
EDC16CP39
5.75
SOFIM (W4)
FICE0481D
Expert III
N/A
N/A
N/A
N/A
4HY
Boxer
2179
74/101
MLGU
DW12UTED
(W4)
DW12TED4
(L4) FAP
4HW
807
2179
94/130
Com. Rail/Bosch
EDC15C7
ML5C
Com. Rail/Bosch
ML6C
EDC15C2
N/A
4.75
4.75
MAP
SOFIM (W4)
8140
without EGR
43N
SOFIM (W4)
DT17TED4
8140
43S
UHZ
Boxer
Boxer
407/607
2800
2800
2720
225
107/146
94/128
150/204
MLGU
MLGU
ZF4HP20
AM6
Com. Rail/Bosch
EDC15C7
Com. Rail/Bosch
EDC15C7
Com. Rail/
Siemens SID 201
7
7
5.55
Abbreviation of emission control standards
Suffix with
Microfiche or Infotec
Peugeot engine
indication
type
Approx. start at
Peugeot
Official standard
CH
Vehicle
Type
CEE
Z
US83
AGV1/US83
MJ 87
VP/VU
Petrol
Y
US87
AGV1/US87 I
MJ 88
VP
Diesel
L
CEE 19-5
CEE 92
CEE 93/59
EURO I
MJ93
VP
Petrol/Diesel
L3
CEE 95
EURO 96
CEE 94/12
EURO II
EURO 96
MJ 96
VP
Petrol/Diesel
D3 (Germany)
CEE 2000
EURO 2000
EURO III
MJ 99
VP
Petrol with EOBD
L4
CEE 2000
EURO 2000
EURO III
New models from 1. 2000
Existing models from 1. 2001
Petrol with EOBD/
Diesel
L5
CEE 2005
EURO IV
CEE 98/69
New models
from 1. 2005 Existing models from 1. 2006
Petrol with EOBD/
Diesel
X1
US84
AGV1/US84
MJ 89
VU
Petrol/Diesel
X2
US87
AGV1/US87
MJ 91
VU
Diesel
X3
EGRX3
US90
AGV1/US90
VU
Petrol/Diesel
W2
CEEW2
CEE 93/59
EURO 93
EURO I”
MJ 93
VU
Petrol/Diesel
W3
CEE95
CEEW3
CEE 94/12
EURO II
EURO 90
MJ96
MJ96
VU
Petrol/Diesel
W4
EURO 2000
EURO III
2001
2001
VU
Petrol/Diesel
W5
Euro 2005
EURO IV
2005
2005
VU
Petrol/Diesel
OEV1 =
CEE =
US
=
VU
=
VP
=
(see also
MJ 96
MJ 93
Regulation on vehicle equipment (CH standard)
UE (European Union)
Limit values in accordance with American standards (USA)
Commercial vehicle
Passenger vehicle
SI No. 416/98)
226
Notes
227
Vehicle identification
Location of the identification label
Pillar A: 106/306/307/406 D9/407/Partner/Boxer
Pillar B: 107/1007/206/607 Z9
Pillar C: 207/807/806/Expert
Identification label key:
A
C
B
1
2
3
4
5
6
7
Tyre pressure
Tyre dimension
Certified tyres
DAM No.:
Factory no.
Identification of paintwork
Sequence No.:
Location of regulation plate on 607 Z8
(*)
Regulation plate example (from 01.01.1998)
A
N.B.: On new models, instead of the
aluminium plate, there is a sticker on
pillar B/C.
Key:
C
A
Manufacturer's name
B
European receipt no.
D
C
VIN (VF3...)
D
Maximum gross vehicle weight
E
E
Maximum driving vehicle weight
F
Permissible tech. weight. (FR axle)
F
G
Admissible tech. weight. (RR axle)
H
Free line (emission control)
G
B
H
See also the information in
SI No. 497/07.99
228
Vehicle identification
VF3 6 D XFV J
Model:
1
2
3
4
6
6
7
8
9
=
=
=
=
=
=
=
=
=
106
206
309
405
407
605
306
406
607
Gear
box
Manual gearbox 4
Manual gearbox 5
Manual gearbox 6
Automatic gearbox 4
Automatic gearbox 6
Specific gearbox
Other possib.
No gearbox
L
L3/W3
L4
L5
A
D
G
N
B
E
H
P
F/A
J
R/B
A
G
B
S
V
T
W
U
X
Z
M
V
L4:
L5:
407/607 407/607
B
G
E
D
K
M
C
H
F
J
L
See petrol/diesel engines chapter
Bodywork
5-door hatch
4-door hatch
2/3-door hatch/3-door coupe
Cabriolet (206 CC, 407/607 Z8 4 doors)
5-seat estate/ SW
7-seat estate
Van (206 3-door sport)
Coupe from 2001 (206 5-door sport)
Sport Estate
3-door commercial
5-door commercial
4-door hatch saloon (607 Z9)
Peugeot codification
A
B
C
D
E
F
H
J
K
S
T
U
229
106
206
306
309 from AM90
405 from AM90
406
407
605
607
Vehicle identification
VF3 3 E NF U E
3 =
W=
4 =
307
207
308
Gearbox
L
L3/W3
Manual gearbox 5
Manual gearbox 6
Automatic gearbox 4
Automatic gearbox 6
B
G
E
D
C
H
F
J
See petrol/diesel engines chapter
Bodywork
3-door hatch
Cabriolet
5-door hatch
4-door hatch saloon
Estate
MPV (SW)
Peugeot codification
A
B
C
D
E
H
207
307
308
230
Vehicle identification
VF3 15 B DF 4
205 from AM88
309
| AM90
405
| AM93
Gearbox type spec.
2
4
7
8
9
= Manual gearbox 5
= Automatic gearbox
=4x4
= Long spec. gearbox
= Specific gearbox
See petrol/diesel engines chapter
Bodywork:
A = 5-door Hatch
B = 4-door Hatch
C = 3-door Hatch (Cp.)
D = Cabriolet
E = Estate
S = Commercial
T = Mini-van
205
309
405
231
Vehicle identification
VF3 5 A HDZ A
5 = Partner
M49
Gearbox label character Emission Control
A = Manual gearbox 4
L/W2
B = Manual gearbox 4
L/W3
D = Manual gearbox 5
Z/L
E = Manual gearbox 5
L3
T = Specific gearbox
L3
F = Manual gearbox 5
L4
O = Electric
See petrol/diesel engines chapter
Bodywork:
A=
B=
C=
D=
E=
F=
G=
H=
Van 475 kg
Van 600 kg
Van 800 kg
Flatbed truck 600 kg
Flatbed truck 800 kg
Estate/Combi
Van 575 kg
Electric
Partner M49
232
Vehicle identification
VF3 G J NFU B
Gearbox label character
A = Manual gearbox 5
B = Manual gearbox 5
C = Manual gearbox 5
Z = No gearbox
G = Partner
M59
Emission Control
L/W2
L/W3
Z/L
See petrol/diesel engines chapter
Bodywork:
B=
C=
E=
H=
J=
Van 600 kg
Van 800 kg
Flatbed truck
Van 500 kg (Electr.)
Family 5 seats
Manufacturer's plate/labels:
A=
B=
C=
D=
E=
Gearbox identification label
Engine identification plate
Manufacturer's plate
VIN no. stamped on the body
Brake limiter
adjustment label
(vehicle without ABS)
F = Tare plate
(commercial vehicle)
G = Printed airbags
H = (1) Inflation pressure
(2) DAM no./paintwork no.
I = Lubricant recommendation
Partner M59
233
Vehicle identification
VF3 7 A HDZ A
7 =Partner II
(B9)
Gearbox label character Emission Control
B = Manual gearbox 5
L/W4
C = Manual gearbox 4
Euro 4
P = Manual gearbox 5
US 83/87
See petrol/diesel engines chapter
Bodywork:
A=
B=
C=
D=
E=
F=
G=
H=
J=
K=
L=
M=
N=
P=
R=
S=
2-seater 675 kg
3-seater 675 kg
2-seater 850 kg
3-seater 850 kg
2-seater 750 kg
3-seater 750 kg
Flatbed truck
2-seater 800 kg
5-seater MPV
3-seater 800 kg
2-seater 800 kg
Extended cab
MPV (5-seater)
MPV (5-seater)
3-seater 800 kg
7-seater MPV
van
van
van
van
long van
long van
van
van
long van
long van
Partner II
234
Vehicle identification
VF3 22 1 RA 2
22
22
A
B
=
=
=
=
806
Expert
806
Expert
Gearbox type repres. character:
A/B/2 = Manual gearbox 5
D/E/3
= Automatic gearbox 4
4
= 4x4
G/H/5/9 = Specific gearbox
Engine:
Bodywork:
AA = AA2
DA = D8B
DB = D9B
DH = DHX
DH = DHX
DW = WJY
PA = P8C
LA = LFW
LB = L6B
RA = RGX
RB = RFU
RC = RFV
RFN
WJZ
RHX
RHZ
RHW
1 = 806 (VAN)
2 = Van expert
3 = Chassis-Cab expert
4 = Combi expert
5 = Window van (Expert)
6 = Expert Long C. Chas
A = 5 seats
B = 6 seats
C = 5, 6 or 7 seats
D = 8 seats
E = 9 seats
F = 5, 6, 7 or 8 seats
G = 7 or 8 seats
S = 900kg long van
T = 815kg long van
U = 900kg long flatbed
V = 815kg long flatbed
W = 900kg flatbed
X = 815kg flatbed
Y C = 900 kg van
Z C = 815 kg van
(1580 SPI)
(XUD9TF)
(XUD9A)
(XUD9TF)
(XUD9BTE)
(DW8B)
(XUD11BTE)
(XU7JP)
(XU7JP)
(XU10J2TE)
(XU10J2C)
(XU10J4R)
(EW10J4)
(DW8)
(DW10BTED)
(DW10CTED)
(DW10ATED4)
806
Expert
235
Vehicle identification
VF3 A B DFC 4
X = Expert II
Gearbox type character:
B = Manual 5 (L4/W4)
C = Manual 5 (Euro 4)
5 = Manual 5 (K or K’)
G = Manual 6 (L4/W4)
H = Manual 6 (Euro 4)
See petrol/diesel engines chapter
Bodywork:
A=
B=
C=
D=
E=
F=
G=
5/6-seater short combi
5/6-seater long combi
8/9-seater short combi
8/9-seater long combi
8/9-seater long combi, reinforced payload
Short weekend combi
Long weekend combi
Expert II
236
Vehicle identification
VF3 K M NFU C
E = 807
K = 1007
P = 107
Emission Control
Gearbox
Manual gearbox 5
Manual gearbox 6
Automatic gearbox 4
Automatic gearbox 6
L3
L4
L5
A
B
G
E
D
C
H
F
J
See petrol/diesel engines chapter
A
B
M
N
= MPV (max. 7 seats)
= MPV (max. 8 seats)
= 3-door hatch (4 seats)
= 5-door hatch (4 seats)
107
1007
807
237
Vehicle identification
VF3 23 2 G 5 2
Gearbox type repres.
character:
2 = Manual gearbox 5
3 = Auto gearbox 4
4=4x4
5 = Manual gearbox (Electric
vehicle)
23 = Boxer
Wheel base:
1
2
3
4
=
=
=
=
short (2.85m)
medium (3.20m)
long (3.70m)
very long (4.05m)
Bodywork:
A
B
C
D
E
F
G
H
J
K
L
N
U
V
=
=
=
=
=
=
=
=
=
=
=
=
=
=
10Q Van
14Q Van
10Q Combi
Minibus
10Q Chassis
14Q Flatbed
14Q Chassis
14Q Drop-side
18Q Van
18Q Chassis
18Q Drop-side
18Q Drop-side
10Q Drop-side
14Q Combi
Engine:
2 =
4 =
5 =
6 =
7 =
8 =
9 =
A=
L =
RFW (XU10J2U)
THX (DJ5TED)
T9A (DJ5)
D9B (XUD9AU)
D8C (XUD9UTF)
DHX (XUD9TF)
T8A (DJ5T)
Electric
8140.43S Sofim 2.8L
without EGR
H = 8140.43S Sofim 2.8L
with EGR
Boxer up to
VIN 17,000,000
238
Vehicle identification
VF3 Z B P M F C/Version
Z = Boxer
Payload:
Wheel base:
A = 11 Q
B = 15 Q
C = 18 Q
D = Reduced
MGVW
A
B
C
G
Engine type:
Type of bodywork:
A
P
R
T
Z
A
B
C
D
F
G
H
M
N
= RHV (DW10UTD)
= 8140.43S (2.8 HDI 127CH)
= 4HY (DW12UTD)
= RFL (XU10J2U)
= 8140.43N (2.8 HDI 146CH)
= Short: 2850 mm
= Medium: 3200 mm
= Long: 3700 mm
= Very long: 4050 mm
Chassis-cab
Bare chassis
Flatbed truck
Pick Up
Van
Pick Up D.-cabin
Chassis-D.-cabin
Minibus 15 s.
Van
(high sides)
P = Minibus 8/9 seats
R = Combi 6/9 seats
Type of transmission:
A = Automatic
M = M5
W = 4X4
=
=
=
=
=
=
=
=
=
Version (Information supplied at the bottom of the manufacturer's plate):
Commercial vehicle versions:
AX
= with EGR
BX
= Raised roof with EGR
AM = Natural gas fuel commercial vehicle
AG = LPG Commercial vehicle
AXC = Camper van with EGR
BXC = Special camper van with EGR
ZX
= Mixed combi N1 (5/6 seats) ITAL.
AY
= without EGR
BY
= Raised roof without EGR
BM = NGF raised roof
BG = LPG raised roof
AYC = Camper van without EGR
BYC = Camper van without EGR
VP versions:
H = Combi raised roof
MH = NGF combi raised roof
M = Natural gas fuel combi
GH = LPG combi raised roof
G = LPG combi
Minibus versions:
AX = 15 s bus 2 pt seat belts with EGR
AX2 = 14 s bus 3 pt seat belts with EGR
AY = 15 s bus 2 pt seat belts without EGR
AY2 = 14 s bus 3 pt seat belts without EGR
SX = GO Bus with EGR 12 s 3 pt (CH)
SY = GO Bus without EGR 12 s 3 pt (CH)
SX1 = GO Bus with EGR 13 s 3 pt (CH)
SY1 = GO Bus without EGR 13 s 3 pt (CH)
AX1 = 16 s bus 2 pt seat belts with EGR
AX3 = 15 s bus 3 pt seat belts with EGR
AY1 = 16 s bus 2 pt seat belts without EGR
AY3 = 15 s bus 3 pt seat belts without EGR
Boxer from
VIN 17,000,001
239
Vehicle identification
VF3 A B DFC 4
A = Bipper
Gearbox type character:
B = Manual 5 (L4/W4)
C = Manual 5 (Euro 4)
L = Axle and/or
gearbox ratio (Euro 4)
See petrol/diesel engines chapter
Bodywork:
A = 2-seater cargo
B = 4-seater combi
J = 5-seater combi
Bipper
240
Vehicle identification
VF3 A B DFC 4
V = 4007
Gearbox type character:
C = Manual 5
F = CVT
H = Manual 6
See petrol/diesel engines chapter
Bodywork:
U = 5 door estate 5-seater 4x4
V = 5 door estate 7-seater 4x4
4007
241
Vehicle identification
VF3 Z B P M F C/Version
Y = Boxer II
Payload:
A = 3000
B = 3300
C = 3500
D = 3500
Heavy
E = 4000
Wheel base:
kg
kg
kg
kg
A
B
C
G
kg
Type of bodywork:
Engine type:
A
B
F
D
= Short: 3000 mm
= Medium: 3450 mm
= Long: 4035 mm
= Very long: 3800 mm
A
A
B
C
D
F
G
H
R
= 4HV
= 4HU
= 4HM
= F1CE0481D
Type of transmission:
A = Automatic
M = Manual
Boxer II
242
=
=
=
=
=
=
=
=
=
Chassis-cab
Chassis-cab
Bare chassis
Flatbed truck
Panel van
Van
Double cab panel van
Chassis-D.-cabin
Combi 5/6/8/9 seats
Identification of manufacturing locations of Peugeot factories
(See the latest figures from the DAM no.)
Aulnay (F):
Buenos Aires (RA):
Heuliez (F):
Kolin (CZ):
Madrid (E):
Mangualde (P):
Mulhouse (F):
Poissy (F):
Porto Real (BR):
Rennes (F):
Ryton (GB):
Sevel Nord Valenciennes (F):
Sevel Sud Val di Sangro (I):
Sochaux (F):
Trnava (SK):
Turin (I):
Vesoul (F):
Vigo (E):
Wuhan (RC):
CA
77
U7
UT
82
FL
88
81
78
CJ
83
U9
U8
89
76
U5
85
FV
UW
Argentina:
Brazil:
CKD:
Egypt:
Indonesia:
Newco (Brazil):
Nigeria:
77
78
85
UJ
YA
UB
YC
243
Notes
244
Design
: PA Peugeot (Switzerland) & DTAV/MPDE
Produced by : DTAV/PIMS
Printing
: EDIPRO
Print run
10,000 copies/12th edition
Ref.
: 007RQ - F - 07/2006
245
Download
Random flashcards
State Flags

50 Cards Education

Countries of Europe

44 Cards Education

Art History

20 Cards StudyJedi

Sign language alphabet

26 Cards StudyJedi

Create flashcards