Tri-Lamp
Handpiece Tubing
1/8" Line
Water
Y O U R
P R A C T I C E
P E R F E C T®
Contents
• StarDental® Tubing Installation
• Cleaning Tubing
• Troubleshooting
• Replacement Part Numbers
• Warranty
Materials Provided:
Tubing
Three 1/8" Ferrules
Instruction Manual
Electrical Jack
Jacket
Drive Air
(Clear)
Exhaust Air
(Red)
Coolant Air
(Green)
Coolant Water
(Blue)
2-Line H/P Control
Signal Air
Drive Air
‘Y’ Assembly
Reducing ‘T’
Electrical Receptacle
(Clear)
(Red)
Coolant Air
Allen Wrench
Seven 1/4" Ferrules
1. Place tubing coupler in hanger. Route tubing to handpiece delivery head. Adjust tubing length in
delivery head to obtain desired length outside to prevent kinking.
2. Connect air and water. See illustrations for correct connections on 2-, 4-, and 6-line units.
(Green)
Coolant Water
(Blue)
5. Route signal air tubing from ‘Y’ to lamp control. Cut signal air tubing to a convenient length. Place a brass
ferrule onto the signal air tubing as shown above. Install tubing onto a barb, and slide the ferrule forward
to secure. Signal air tubing must be free of kinks to activate lamp control properly.
6. Insert electrical jack into the corresponding electrical receptacle on the lamp control.
Barb
Electrical
Receptacle
Drive Air
‘Y’ Assembly
Signal Air
Tubing
Brass Ferrule
1/4" Line
1/8"
Coolant
Water
Line
1/4" Signal Air
1/4" Line
3. Identify each of the four service tubes shown to the
right.
4. Select a position on drive air tubing near lamp control.
It may be necessary to trim back outer tube jacket to get
correct position of drive air tube (clear). Cut drive air
tubing and slide a brass ferrule over each end of the cut
tubing. Install the ‘Y’ assembly by sliding each cut tubing
onto each barb of the ‘Y’. Push brass ferrules over tubing
at each barb to lock tubing in place.
Exhaust Air
Tubing is available in a variety of lengths. See Replacement Part Numbers for a complete listing.
Note: Install tubing to COLORight Quad Lamp Control in an identical manner as the Tri-Lamp Control.
Water
Tri-Lamp Control
‘Y’ Assembly
Brass Ferrules
StarDental Tubing Installation
Tools Required:
Utility Knife
Barb
Coolant Air
Drive Air
1/8" Line
Instruction Manual
M A K E S
Electrical Receptacle
4-Line & 6-Line H/P Control
‘Y’ Assembly
1/8" Coolant
Air Line
Tri-Lamp Control
1/4" Signal Air
1/4" Line
Reducing Tee
1/4" Signal Air
Barb
Cleaning
PLEASE NOTE:
Clean outside surfaces with a non-alcohol based disinfectant only.
Use of alcohol based cleaner will discolor tubing.
For new products, manuals and technical information, call
1-866-DTE-INFO or visit our web site @ www.dentalez.com.
Trouble Shooting
Problem: NO LIGHT OR INTERMITTENT LIGHT
Cause: Electrical connections
Correction: Verify three connections:
1. Wall outlet – power pack
2. Power pack – lamp control
3. Lamp control – tubing electrical jack
IMPORTANT NOTICE ABOUT RETURNING PRODUCT TO THE DENTALEZ GROUP
Anyone wishing to return any DentalEZ® Group product to a DentalEZ facility MUST obtain
the proper RETURN AUTHORIZATION NUMBER from the Customer Service Department.
The RA Number must appear clearly marked on both the outside and inside of the returned
product carton. When calling for a return authorization number you will be asked to provide
the following information:
Cause: Crimped signal air line to lamp control
Correction: Straighten signal air line to allow air flow.
Cause: Wire broken at tubing coupler
Correction: Re-strip wire 1/8", flow solder into strands and lock set screw with .035 Allen
wrench.
Problem: REDUCED LIGHT
Cause: Low voltage
Correction: For StarDental® tubing, contact customer service at the number listed below.
For other brand tubing, verify correct calibration of the lamp control, refer
to Non-Star Tubing Installation in Tri-Lamp Manual StarDental Part Number
063325.
Problem: NO WATER FLOW
Cause: Faulty delivery head
Correction: Disconnect tubing at delivery head; check water flow.
Cause: Clogged tubing
Correction: Remove handpiece and connector from tubing. Verify water flow through
tubing.
Note: I f a problem persists, contact dealer for further assistance or contact StarDental technical
service at 1-866-DTE-INFO.
Replacement Part Numbers
Always insist on StarDental parts for best performance.
Description
To Obtain A Return
Authorization Number,
Call 1-866-DTE-INFO
• Product Name, Model Number or Part Number
• Serial Number of Product
• Dealer Return Purchase Order Number
• Reason For Return
• Copy of Invoice Showing Purchase
Items will be evaluated. Return Authorization Number is not a guarantee for credit. Your
cooperation with this procedure will help us expedite processing of any returns.
Limited Warranty
StarDental® Tri-Lamp Handpiece Tubings are warranted against defects in material and
workmanship for 12 months from date of purchase. Lamps are specifically excluded from this
warranty. This warranty is subject to the following conditions:
This product must not be abused and must have been operated in accordance with procedures
detailed in this manual.
Any replacement parts must be genuine StarDental parts.
Warranty validation card must be completed and returned within 15 days of purchase.
StarDental will, without charge, repair or replace (at its sole discretion) any defective part(s)
covered in this warranty, providing above conditions are met and the product is returned through
an authorized StarDental dealer. You must have a copy of your original invoice to qualify.
THIS WARRANTY IS IN LIEU OF ALL OTHER WARRANTIES, EXPRESSED OR IMPLIED, INCLUDING
ANY IMPLIED WARRANTIES OF MERCHANTABILITY OR FITNESS FOR USE.
Tri-Lamp Tubing Item Number
6' Straight, Sterling................................................................................................. 265573
6' Straight Sandstone............................................................................................. 265580
9' Straight, Sterling................................................................................................. 265574
13' Straight, Sterling............................................................................................... 265575
DentalEZ Dental Products (GB) Ltd.,
Cleveland Way,
Hemel Hempstead, Hertfordshire
HP2 7DY, ENGLAND
065588 Rev B Date of Issue: 8/25/2011
Division of DentalEZ Group
Lancaster, PA 17601 U.S.A.
Printed in the U.S.A.
©
2011 DentalEZ, Inc.
Product complies
with MDD 93/42/EEC