MODEL
Advanced combustion
Hi-lo fired oil burners
with
technology
(with up to 2:1 turndown)
C arlin EZ-H2L
advanced combustion residential oil burner
Features
Features
The EZ-H2L residentail oil burner is a highly advanced
step modulation, Lo-Hi-Lo burner that offers operational efficiencies never before available in a residential
burner. Built upon the reliability of the EZ-oil burner
design and performance, this new state-of-the-art
burner incorporates most of the same components used
on all standard EZ-oil burners.
Firing rates up to 1.5 GPH
Specifications
Input
High Fire......................................... 0.5 to 1.5 GPH
Low Fire......................................... 0.25 to 0.75 GPH
............................................70,000 to 210,000 Btuh
....................No. 1 or No. 2 Heating oil (ASTM D396)
Low firing rates down to 0.25 GPH
Current..................................... Approximately 2.5 amps
Lo-Hi-Off or Lo-Hi-Lo modes of operation available with the
appropriate operating control
Limit circuit input.................................120 vac/60 hz
Fires a wide variety of heat exchanger designs including:
boilers, furnaces, storage water heaters, and other similar
appliances
Oil valve power.....................................120 vac/60 hz
Supplied with outside combustion air connection as standard
equipment.
Available with appliance specific energy savings modulating
controls
Most components (primary control, ignitor, motor, blower wheel,
coupling, nozzle, electrode set, etc. are all available at most
plumbing and heating supply houses.
Power ..................................... 120 vac/60 hz/1-phase
Motor (PSC) ....................................1/6 hp, 3450 rpm
Nozzle line heater.................................120 vac/60 hz
60200 Alarm contacts (isolated).....24 vac/vdc, 2 amps
65000 Alarm output . ..................... 120 vac, 2.5 amps
• Oil preheat regulation and 2-speed motor for
optimal efficiency
• Automatic or manual select for low or high fire
• Quick wire plug/recepticle for fast servicing
• USB port for laptop setup and diagnostics
• Alarm output
• For use with Carlin 60200 primary control and
Carlin EZ-Temp “G” temperature controls only
Operating temperature limits
Maximum ambient...............................104 °F (40 °C)
Agencies
UL Listed ............................................ (US & Canada)
Ignition
Carlin Model 41000 solid state electronic ignitor
Ignition voltage...................................... 14,000 volts
Primary Control
Carlin Model 60200 microprocessor control............
Variable frequency motor speed control offers unmatched quiet
operation on low fire
• 15-sec. Trial for Ignition (TFI)
Optional Limit Controls
• 1.3-sec. FFRT
Applications
A coverless version may be provided with warm air
furnaces to accomodate limited space within the
vestibles.
• 15-sec. pre-purge and 30-sec. post-purge
Optional Limit Controls for Lo-Hi-Lo operation for direct
fired storage water heaters.
Carlin EZ-Temp 90000G Commercial Step Modulating
Operating Limit with smart slope logic for maximum
storage water heater efficiency and performance and
manual reset high limit for safety and code compliance.
Carlin Model 65000 microprocessor control............
• Status and diagnostic LED’s with fault codes
Electrical
Turndown ratios up to 50% (2 to 1)
Dual Firing Rate Control
• Reset protection
Fuels
Specifications
• Serviceman reset protection
(Latch-up after three consective lockouts)
®
• Interrupted duty ignition
• Recycle on flame failure
For Hot Water Supply Boilers
Carlin EZ-Temp 90524G Triple Limit control with smart
slope logic enabled step modulating operatiing limit for
cold start boiler operation or maintaining a set boiler
temperature for internal tankless coil applications.
Warning — This burner should be serviced only by a certified EZ-H2L
service technician.
T e c h s u p p o r t h o t l i n e 800-989-2275
Carlin Combustion Technology, Inc.
70 Maple Street East Longmeadow, MA 01028
e-mail us at: info@carlincombustion.com
© Copyright 2010 — Carlin Combustion Technology, Inc.
Phone 413–525–7700
Fax 413–525–8306
visit our website: www.carlincombustion.com
Carlin part number MNEZH2LC Rev. 10/26/10