Floor Feeder
Repair Parts Manual
Volume II
(March 1990 to September 1996)
December 1996
MF1300A96
Warranty Information
Chore-Time Equipment warrants each new product manufactured by it to be free from defects in material or
workmanship for one year from the date of initial installation by the original purchaser. If such a defect is found
by Chore-Time to exist within the one year period, Chore-Time will, at its option, (a)repair or replace such
product free of charge, F.O.B. the factory of manufacture, or (b) refund to the original purchaser the original
purchase price, in lieu of such repair or replacement.
Additional extended warranties are herewith provided to the original purchaser as follows:
1.
*2.
3.
4.
5.
*6.
*7.
TURBO™ and RLX™ Fans, less motors, for three years from date of installation.
Poultry feeder pans that become unusable within five years from date of installation.
Warranty prorated after three years usage.
MEAL-TIME Hog Feeder pans that become unusable within five years of installation.
Rotating centerless augers, excluding applications involving High Moisture Corn
(exceeding 18%), for ten years from date of installation. Note: MULTIFLO and
applications involving High Moisture Corn are subject to a one year warranty.
Chore-Time manufactured roll-formed steel auger tubes for ten years from date of
installation.
Laying cages that become unusable within ten years. Warranty prorated after three years
usage.
ULTRAFLO Auger and ULTRAFLO Feed Trough (except ULTRAFLO Trough
Liners) are warranted for a period of five (5) years from date of original purchase against
repeated breakage of the auger or wear-through of the feed trough caused solely by the
auger.
Conditions and limitations:
1.
2.
3.
4.
5.
The product must be installed and operated in accordance with instructions published by
Chore-Time or warranty will be void.
Warranty is void if all components of a system are not supplied by Chore-Time.
This product must be purchased from and installed by an authorized Chore-Time dealer or
certified representative thereof, or the warranty will be void.
Malfunctions or failure resulting from misuse, abuse, negligence, alteration, accident, or
lack of proper maintenance shall not be considered defects under this warranty.
This warranty applies only to systems for the care of poultry and livestock. Other
applications in industry or commerce are not covered by this warranty.
Chore-Time shall not be liable for any consequential or special damage which any purchaser may suffer or claim
to have suffered as a result of any defect in the product. "Consequential" or "special damages" as used herein
include, but are not limited to, lost or damaged products or goods, costs of transportation, lost sales, lost orders,
lost income, increased overhead, labor and incidental costs and operational inefficiencies.
THIS WARRANTY CONSTITUTES CHORE-TIME’S ENTIRE AND SOLE WARRANTY AND CHORE-TIME
EXPRESSLY DISCLAIMS ANY AND ALL OTHER WARRANTIES, INCLUDING, BUT NOT LIMITED TO,
EXPRESS AND IMPLIED WARRANTIES AS TO MERCHANTABILITY, FITNESS FOR PARTICULAR
PURPOSE SOLD AND DESCRIPTION OR QUALITY OF THE PRODUCT FURNISHED HEREUNDER.
Any exceptions to this warranty must be authorized in writing by an officer of the company. Chore-Time reserves
the right to change models and specifications at any time without notice or obligation to improve previous models.
*See separate Chore-Time Cage Wire Warranty as to these products.
CHORE-TIME EQUIPMENT, A Division of CTB, Inc.
P.O. Box 2000, Milford, Indiana 46542-2000 U.S.A.
Purpose of the Repair Parts Manual
The purpose of the Repair Parts Manuals is to provide the CHORE-TIME Distributors & Dealers a
listing of current and discontinued parts for their reference in identifying and/or ordering parts.
Note: The Floor Feeder Repair Parts Manual has been divided into two separate volumes; Volume
I & Volume II.
Volume I includes Floor Feeder products up to March 1990.
Volume II includes Floor Feeder products that have been current anytime from March 1990
to present.
Products that were current before and after March 1990 appear in both volumes.
Additional copies of this book may be ordered through the CHORE-TIME Customer Service
Department. Refer to this manual by name, volume, and part number (MF1300) when ordering.
When ordering parts from this manual, please note the following:
1. Parts numbers that have a line through them (i.e. 3185) have been discontinued and are
no longer available.
2. All parts should be ordered by part number and description as listed in the parts list.
3. All parts are billed when shipped. If a returned part is defective and within warranty,
credit will be allowed against billing.
4. Check shipment for damages and shortages. All claims for damages or shortages
resulting from shipping must be filed with the carrier.
Floor Feeder Repair Parts Manual Volume II
3
Table of Contents
Control Units
Model C & CT Control Unit - Part No: 1878-8 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Model 2000 Control Unit - Part No: 1878-9 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Model C & CT Control Unit - Part No: 1878-8 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Model C End Control Unit - Part No: 24396 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Model C End Control Unit - Part No: 24396 (1-Phase), 27757 (3-Phase) . . . . . . . .
Model C2 End Control Unit - Part No: 28116 (1-Phase), 28270 (3-Phase) . . . . . . .
Model H2 End Control Unit - Part No: 24397 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Model H2 End Control Unit Part No: 24397 (1-Phase), 27762 (3-Phase) . . . . . . . .
Model 2000 End Control Unit - Part No: 24395-0 . . . . . . . . . . . . . . . . . . . . . . . . .
Model G End Control Unit - Part No: 29511 (1-Phase), 29521 (3-Phase) . . . . . . .
Adult Turkey Feeder Control Unit - Part No: 6035 . . . . . . . . . . . . . . . . . . . . . . . . .
Adult Turkey Feeder Control Unit - Part No: 6035 . . . . . . . . . . . . . . . . . . . . . . . . .
Adult Turkey Feeder Control Unit - Part No: 6035 . . . . . . . . . . . . . . . . . . . . . . . . .
Adult Turkey Feeder Drop Tube Assembly. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Model C, CT, H, & 2000 Intermediate Control Unit - Part No: 5302-0 . . . . . . . . . .
Model C & CT Intermediate Control Unit - Part No: 24190 . . . . . . . . . . . . . . . . . . .
Model C Intermediate Control Unit - Part No: 24190 (1-Phase), 27758 (3-Phase) .
Model C2 Intermediate Control Unit - Part No: 28117 (1-Phase), 28275 (3-Phase).
Model 2000 Intermediate Control Unit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Part No: 24191-1 (shallow pan), 24191-2 (deep pan) . . . . . . . . . . . . . . . . . . . . . . .
Model G Intermediate Control Unit - Part No: 29512 (1-Phase), 29522 (3-Phase) .
Model H2 Intermediate Control Unit - Part No: 25435 . . . . . . . . . . . . . . . . . . . . . .
Model H2 Intermediate Control Unit - Part No: 25435 (1-Phase), 27760 (3-Phase)
Adult Turkey Feeder Intermediate Control Unit - Part No: 6039. . . . . . . . . . . . . . .
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
. 6
. 6
. 8
. 9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
24
25
26
27
28
Power Units
Floor Feeder Power Units . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29
Floor Feeder Power Unit Miscellaneous Components . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 30
Boot Components
Single Boot Components - Part No: 6822 (Broiler), 6821 (ATF)
Twin Boot Components - Part No: 6824 (Broiler), 8460 (ATF) .
ULTRAPAN® Boot Assembly - Part No: 34824 . . . . . . . . . . . .
ULTRAPAN® Intake Cup Assembly - Part No: 28119 . . . . . . .
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
32
33
34
35
ULTRAFLO® Intake Cup Assembly - Part No: 25167 (domestic) & 27380 (Intn’l only) . . . . . . . . . . . . . . . . . . . . 36
Feed Hoppers
100# Feeder Line Hopper . . . . . . . . . . . . . . .
200# Feeder Line Hopper - Part No: 9474 . .
200# Feeder Line Hopper - Part No: 7941 . .
300# Feeder Line Hopper . . . . . . . . . . . . . . .
300# Breeder Feeder Hopper . . . . . . . . . . . .
400# Feeder Line Hopper - (Part No. 27530)
Lower Hopper Switch - (Part No. 8798) . . . .
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
37
38
39
40
41
42
43
G, 2000)
........
........
........
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
44
45
46
47
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
48
49
50
51
52
53
54
Feeder Line Components
Broiler, Cockerel, & ATF Feeder Line Components ULTRAPAN® Feeder Line Components . . . . . . . . .
ULTRAFLO® Feeder Line Components . . . . . . . . .
ULTRAFLO® Feeder Line Grill Options . . . . . . . . .
(Model C, C2 H, H2,
................
................
................
Feeder Assemblies
Model C . . .
Model C2 . .
Model H . . .
Model H2 . .
Model G . . .
Model 2000 .
Adult Turkey
......
......
......
......
......
......
Feeder
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
Floor Feeder Repair Parts Manual Volume II
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
4
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
Suspension Components
Miscellaneous Components . . . . . . . . . . . . . . . . . .
Power Winch: Part No. 2883 . . . . . . . . . . . . . . . . .
Electric Power Lift: Part No. 14580 . . . . . . . . . . . . .
Electric Power Lift: Part No. 14580 . . . . . . . . . . . . .
Switch Box (for Electric Power Lift): Part No. 14316
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
55
56
57
58
59
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
61
62
63
64
65
66
67
68
69
70
71
71
72
73
Electrical Controls and Components
Breeder Control Panel: Part No. 34380 . . . . . . . . . . . . . . . . . .
Breeder Control Panel: Part No. 25175 . . . . . . . . . . . . . . . . . .
Breeder Feeder Feed-Only Control Panel: Part No. 27440 . . .
Meal-Time Control Panel: Part No. 34385 . . . . . . . . . . . . . . . .
Time Clock Control: Part No. 34574 . . . . . . . . . . . . . . . . . . . .
Breeder Feeder Control: Part No. 8700A . . . . . . . . . . . . . . . . .
Meal-Time Control Panel: Part No. 7022A . . . . . . . . . . . . . . . .
Time Clock Control . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Time Clock Control . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Tork Time Clocks . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Contactor Control . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Contactor Control . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Hopper Level Control: Part No. 2912 . . . . . . . . . . . . . . . . . . .
Hopper Level Control: Part No. 14550 & 27761 (International)
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
Floor Feeder Scale Systems and Components
Weigh Scale Template: Part No. 5798 . . . . . . . . . . . . .
Weigh Scale Assembly . . . . . . . . . . . . . . . . . . . . . . . .
Beam Box Assembly: Part No. 5790 . . . . . . . . . . . . . .
5000# Weigh Beam Assembly: Part No. 9447* . . . . . .
8000# Weigh Beam Assembly: Part No. 6514* . . . . . .
Model 100 & Model 200 Digital Indicators . . . . . . . . . .
Connection Box: Part No. 30226 . . . . . . . . . . . . . . . .
J-Boxes & Cable Sets . . . . . . . . . . . . . . . . . . . . . . . .
J-Box Duplex Kit . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Duplex J-Box . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Miscellaneous Components and Cable Sets . . . . . . . .
Junction Control: Part No. 25784 . . . . . . . . . . . . . . . .
Junction Control w/Fill Option: Part No. 30240 . . . . . .
Load Cells and Mount Kits . . . . . . . . . . . . . . . . . . . . .
Load Cells and Mount Kits . . . . . . . . . . . . . . . . . . . . .
Power Supply . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Livestock Scale Indicators . . . . . . . . . . . . . . . . . . . . .
Livestock Scale Load Cells . . . . . . . . . . . . . . . . . . . . .
Hopper Scales: Part No. 24176 . . . . . . . . . . . . . . . . .
Hopper Scales Switch Assembly: Part No. 33653 . . . .
Hopper Scales Switch Box Assembly: Part No. 14613
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
74
75
76
77
77
78
78
79
79
80
80
81
82
83
84
84
85
85
86
87
87
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
88
89
89
90
91
91
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
92
92
92
93
94
Floor Feeder Screener Components
WEIGH-MATIC® Model 90 Screener: Part No. 25432
WEIGH-MATIC® Model 90 Screener Control Unit . . .
Junction Box Assembly: Part No. 25694 . . . . . . . . . .
WEIGH-MATIC® Model 90 Screener Power Units . . .
Model 90 Bin Fill Cap Kit: Part No. 25806 . . . . . . . . .
Model 75 Bin Fill Cap Kit: Part No. 6563 . . . . . . . . . .
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
Floor Feeder Miscellaneous Components
Hens Only Grill (for Pan Breeder Feeder)
Program Gauge: Part No. 14251 . . . . . .
Control Shield: Part No. 24887 . . . . . . . .
Winch Control: Part No. 34812 . . . . . . . .
Winchable Feed Level Tube Components
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
Floor Feeder Repair Parts Manual Volume II
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
5
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
Control Units
Item
1
2*
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
34
35
36
37
38
39
40
41
42
43
Model C & CT Control Unit
Model 2000 Control Unit
Part No: 1878-8
Part No: 1878-9
Manufactured from November
1983 to August 1988.
Manufactured from November
1983 to April 1991.
Description
Part No.
Item
Safety Hook
1980
Grill Lock
3294
Flat Bottom Pan
8892
Deep Pan
1654
Shallow Pan
8892
Control Unit Grill Assembly 1891
Agitator Assembly
2040
Paddle Shield Assembly
2856
Shield Retainer
2847
Shield
2854
6-32 x 7/8” Screw
1921
SPDT Switch
1901
Tube Clamp
24063
Switch Insulation
1907-2
Washer
149
6-32 x 7/8” Screw
1921
Adjusting Bracket
2972
1/16” Cable Clamp
1826
Switch Bracket Assembly
2846
6-32 Hex Nut
771
Control Adjustment Bracket 2326
Left Hand Side Bracket
1880
Top Closure Assembly
25121
Anti-Roost Guard
2798
Wing Nut (1/4-20)
1630
Outlet Tube Assembly
4570
Paddle
2853
Receptacle Box Cover (220) 4169
Receptacle Box Cover (110) 2027
Receptacle (220)
4227
Receptacle (110)
2028
Side Panel Assembly (220) 4267
Side Panel Assembly (110) 2857-1
Side Bracket (R.H.)
1879
Strain Relief Bushing
5412
Handy Box
1145
Cord Assembly (220)
8301
Cord Assembly (110)
714-1
Cord Set (220)
4999-30
Cord Set (110)
1900
Bottom Closure
1890
Control Body Assembly
4568
1/4-20 x 1/2” Screw
1629
Receptacle Shield
7732
Extension Ass’y (Mod. 2000) 8846
5/16-18 x 1/2” Hex Hd. Bolt 1839
5/16-18 Hex Lock Nut
2148
Coil
2860
Feed Baffle
14230
1
2*
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
34
35
36
37
38
39
40
41
42
43
6
Description
Part No.
Safety Hook
1980
Grill Lock
3294
Flat Bottom Pan
8892
Deep Pan
1654
Shallow Pan
8892
Control Unit Grill Assembly 1891
Agitator Assembly
2040
Paddle Shield Assembly
2856
Shield Retainer
2847
Shield
2854
6-32 x 7/8” Screw
1921
SPDT Switch
1901
Tube Clamp
24063
Switch Insulation
1907-2
Washer
149
6-32 x 7/8” Screw
1921
Adjusting Bracket
2972
1/16” Cable Clamp
1826
Switch Bracket Assembly
2846
6-32 Hex Nut
771
Control Adjustment Bracket 9118
Left Hand Side Bracket
1880
Top Closure Assembly
25121
Anti-Roost Guard
2798
Wing Nut (1/4-20)
1630
Outlet Tube Assembly
4570
Paddle
2853
Receptacle Box Cover (220) 4169
Receptacle Box Cover (110) 2027
Receptacle (220)
4227
Receptacle (110)
2028
Side Panel Assembly (220) 4267
Side Panel Assembly (110) 2857-1
Side Bracket (R.H.)
1879
Strain Relief Bushing
5412
Handy Box
1145
Cord Assembly (220)
8301
Cord Assembly (110)
714-1
Cord Set (220)
4999-30
Cord Set (110)
1900
Bottom Closure
1890
Control Body Assembly
4568
1/4-20 x 1/2” Screw
1629
Receptacle Shield
7732
Extension Ass’y (Mod. 2000) 8846
5/16-18 x 1/2” Hex Hd. Bolt 1839
5/16-18 Hex Lock Nut
2148
Coil
2860
Feed Baffle
14230
Control Units
Floor Feeder Repair Parts Manual Volume II
7
Control Units
Model C & CT Control Unit
Item
Part No: 1878-8
Item
1
2*
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
Description
Safety Hook
Grill Lock
Flat Bottom Pan
Control Unit Grill Assembly
Agitator Assembly
Paddle Shield Assembly
Shield Retainer
Shield
6-32 x 7/8” Screw
SPDT Switch
Tube Clamp
Switch Insulation
Washer
6-32 x 7/8” Screw
Adjusting Bracket
1/16” Cable Clamp
Switch Bracket Assembly
6-32 Hex Nut
Control Adjustment Bracket
Left Hand Side Bracket
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
Part No.
1980
3294
8892
1891
2040
2856
2847
2854
1921
1901
24063
1907-2
149
1921
2972
1826
2846
771
2326
1880
Manufactured from
August 1988 to
present.
Floor Feeder Repair Parts Manual Volume II
8
Description
Part No.
Top Closure Assembly
25121
Anti-Roost Guard
2798
Bracket Support Weldment 25108
Reinforcement Plate
25127
Paddle
2853
Receptacle Box Cover
4169
Receptacle
4227
Handy Box & Cord Assembly 4267
Side Bracket (R.H.)
25134
Strain Relief Bushing
5412
Handy Box
1145
Cord Assembly
8301
Extension Assembly
---Cord Set
4999-30
Bottom Closure
25126
Control Body Assembly
4568
10-24 x 3/8” Screw
25124
Receptacle Shield
7732
Feed Baffle
14230
5/16-18 x 1/2” Hex Hd. Bolt 1839
5/16-18 Hex Lock Nut
2148
Extension Assembly
8846
Control Units
Model C End Control Unit
Part No: 24396
Item
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
Description
Control Top Cover
Insulator
Support Bracket
Insert Assembly
Feed Level Tube
Feed Level Ring
Grill Assembly
Pan
Switch Bracket
Anchor
Control Box
Switch Box Mount
Gasket
10-32 Locknut
Spring
Part No.
Item
14433
2976
24683
6255
2508
8171
6269
7700
14435
4188
14434
25084
6968-1
6963
6972
16
17
18
19
20
21
22
23
24
25
26
27
28
----
Description
Paddle
Stop Panel
Switch Box Cover
Switch Box
Control Cord Assembly
1/2” Watertight Connector
Gasket
Switch
Bottom Cover
Mylar
Paddle Retainer
Liquid Tight Connector
Switch Bracket
Actuator Pin
Danger Decal
Anti-Roost Guard
Part No.
24848
25433
6776
24702
25495
26980
6777
7114
14432
25318
25045
24685
7068
6775
2527-9
2798
Manufactured from
1989 to January 1994.
Floor Feeder Repair Parts Manual Volume II
9
Control Units
Model C End Control Unit
Part No: 24396 (1-Phase), 27757 (3-Phase)
Item
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
Description
Cover & Insulator Ass’y
Insulator
Support Bracket
Insert Assembly
Feed Level Tube
Feed Level Ring
Grill Assembly
Feeder Pan
Deflector Panel
Anchor
Control Body
Switch Box Mount
Gasket
10-32 Lock Nut
Spring
Paddle
Stop Panel
Switch Box Cover
1 Phase
Part No.
3 Phase
Part No.
24682
2976
24683
6255
2508
8171
6269
7700
34310
4188
14434
25084
6968-1
6963
6972
24848
25433
6776
24682
2976
24683
6255
2508
8171
6269
7700
34310
4188
14434
25084
6968-1
6963
6972
24848
25433
6776
Item
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
----
Description
1 Phase
Part No.
Switch Box
24702
Control Cord Assembly 25495
1/2" Watertight Connector 26980
Gasket
6777
Actuator Switch
7114
Bottom Cover
14432
Mylar
25318
Paddle Retainer
25045
Liquid Tight Connector
24685
Mylar Insulation
1907-5
Terminal Block
---Switch Bracket
7068
Mount Bracket
34309
14" Flexible Conduit
26982-1
90 Degree Connector
23810
Switch Actuator Pin
8757
Danger Decal
2527-9
Anti-Roost Guard
2798
3 Phase
Part No.
7841
- - - - - - 6777
7114
14432
25318
25045
- - - 1907-5
34925-3
7068
34309
- - - 23810
8757
2527-9
2798
Manufactured from
January 1994 to present.
Floor Feeder Repair Parts Manual Volume II
10
Control Units
Model C2 End Control Unit
Part No: 28116 (1-Phase), 28270 (3-Phase)
Item
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
Description
Cover & Insulator Ass’y
Insulator
Support Bracket
Support Cone Assembly
Switch Bracket
Control Unit Sleeve
Grill Assembly
Feeder Pan
Deflector Panel
Anchor
Control Body
Switch Box Mount
Gasket
10-32 Locknut
Spring
Paddle
Stop Panel
Switch Box Cover
1 Phase
Part No.
3 Phase
Part No.
24682
2976
24683
35729
7068
29349
25280
25281
34310
4188
14434
25084
6968-1
6963
6972
24848
25433
6776
24682
2976
24683
35729
7068
29349
25280
25281
34310
4188
14434
25084
6968-1
6963
6972
24848
25433
6776
Item
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
----
Description
1 Phase
Part No.
Switch Box
24702
Control Cord Assembly 25495
1/2" Watertight Connector 26980
Gasket
6777
Actuator Switch
7114
Bottom Cover
14432
Mylar
25318
Paddle Retainer
25045
Liquid Tight Connector
24685
Terminal Block
---Mylar Insulation
1907-5
Mount Bracket
34309
Switch Actuation Pin
8757
14" Flexible Conduit
26982-1
90 Degree Connector
23810
Switch Actuator Pin
8757
Danger Decal
2527-9
Anti-Roost Guard
2798
3 Phase
Part No.
7841
- - - - - - 6777
7114
14432
25318
25045
- - - 34925-3
1907-5
34309
8757
- - - 23810
8757
2527-9
2798
Manufactured from April
1991 to present.
Floor Feeder Repair Parts Manual Volume II
11
Control Units
Model H2 End Control Unit
Part No: 24397
Item
1
2
4
5
6
7
8
9
10
11
12
13
Description
Cone Assembly
Pan
Support Bracket
Insulator
Gasket
Control Top Cover
10-32 Locknut
Spring
Gasket
Paddle
Stop Panel
Switch Bracket
Part No.
Item
25490
24901
24683
2976
6777
14433
6963
6972
6968-1
24848
25433
14435
14
15
16
17
18
19
20
21
22
----
Description
Control Box
Anchor
1/4-20 x 1/2” Hex Hd. Bolt
Switch Box Mount
Switch Box Cover
Switch Box
Control Cord Assembly
1/2” Watertight Connector
Actuator Switch
Actuator Pin
Danger Decal
Anti-Roost Guard
Part No.
14434
4188
1487
25084
6776
24702
25495
26980
7114
6775
2527-9
2798
Manufactured from
1988 to May 1990.
Floor Feeder Repair Parts Manual Volume II
12
Control Units
Model H2 End Control Unit
Part No: 24397 (1-Phase), 27762 (3-Phase)
Item
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
Description
Pan
Cone Assembly
Switch Bracket
Switch Bracket
Bottom Cover
Control Assembly Cover
Insulator
Support Bracket
Deflector Panel
Anchor
Control Body
Switch Box Mount
Gasket
10-32 Locknut
Spring
Paddle
Stop Panel
1 Phase
Part No.
3 Phase
Part No.
24901
34481
34309
7068
14432
24682
2976
24683
34310
4188
14434
25084
6968-1
6963
6972
24848
25433
24901
34481
34309
7068
14432
24682
2976
24683
34310
4188
14434
25084
6968-1
6963
6972
24848
25433
Item
18
19
20
21
22
23
24
25
26
27
28
29
30
----
Description
1 Phase
Part No.
Terminal Strip
---Switch Box
24702
Cord Assembly
25495
Reducing Seal
7815
1/2" Watertight Connector 26980
Actuator Switch
7114
Gasket
6777
Switch Box Cover
6776
1/2" Watertight Connector 24685
Paddle Retainer
25045
Mylar Assembly
25318
Switch Insulation
1907-5
14" Flexible Conduit
26982-1
90 Degree Connector
23810
Anti-Roost Guard
2798
Switch Actuation Pin
8757
Danger Decal
2527-9
3 Phase
Part No.
34925-3
7841
---------7114
6777
6776
---25045
25318
1907-5
---23810
2798
8757
2527-9
Part No. 24397: Manufactured from
May 1990 to present.
Part No. 27762: Manufactured from
January 1991 to present.
Floor Feeder Repair Parts Manual Volume II
13
Control Units
Model 2000 End Control Unit
Part No: 24395-0
Item
1
2
3
4
5
6
7
8
9
10
11
Description
Control Top Cover
Insulator
Support Bracket
Sleeve Assembly
Support Cone
Adjustment Ring
Feeder Grill
Shallow Pan
Deep Pan
Switch Bracket
Anchor
Control Box
Part No.
Item
14433
2976
24683
24686
8334
7728
7730
8764
24677
14435
4188
14434
12
13
14
15
16
17
18
19
20
21
22
23
24
----
Description
Switch Box Mount
Gasket
10-32 Locknut
Spring
Paddle
Stop Panel
Switch Box Cover
Switch Box
Control Cord Assembly
1/2” Liquid Tight Connector
Gasket
Switch
Bottom Cover
Actuator Pin
Danger Decal
Anti-Roost Guard
Part No.
25084
6968-1
6963
6972
24848
25433
6776
24702
25495
26980
6777
7114
14432
6775
2527-9
2798
The Model 2000 End Control with the Shallow
Pan may be ordered under Part No. 24395-1.
The Model 2000 End Control with the Deep Pan
may be ordered under Part No. 24395-2.
Manufactured from February
1989 to January 1994.
Floor Feeder Repair Parts Manual Volume II
14
Control Units
Model G End Control Unit
Part No: 29511 (1-Phase), 29521 (3-Phase)
Item
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
Description
1 Phase
Part No.
Anchor
4188
Control Body
14434
Switch Bracket
14435
Paddle Retainer
25045
Stop Panel
25433
Paddle
24848
Spring
6972
10-32 Locknut
6963
Gasket
6968-1
Switch Box Mount
25084
Mylar Assembly
25318
3-Terminal Block
---Bottom Cover
14432
Support Cone
28134
Control Adjustment Cone 29064
Feeder Pan
7700
3 Phase
Part No.
Item
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
----
4188
14434
14435
25045
25433
24848
6972
6963
6968-1
25084
25318
27845-3
14432
28134
29064
7700
Description
1 Phase
Part No.
Model G Grill Assembly 29300
Control Unit Sleeve
29349
Support Bracket
24683
Cord Stock
5044-3
Reducing Seal
7815
Vinyl Tubing
7814
1/2" Watertight Connector 24685
1/2" Watertight Connector 24680
Switch Insulation
1907-5
Switch Box
24702
Actuator Switch
7114
Switch Bracket
7068
Control Cord Assembly 25495
14” Flexible Conduit
26982-1
90 Degree Connector
23810
Anti-Roost Guard
2798
Danger Decal
2527-9
Anti-Roost Guard
2798
3 Phase
Part No.
29300
29349
24683
- - - - - - - - - 24685
24680
1907-5
7841
7114
7068
- - - - - - 23810
2798
2527-9
2798
Manufactured from June
1992 to present.
Floor Feeder Repair Parts Manual Volume II
15
Control Units
Adult Turkey Feeder Control Unit
Part No: 6035
Item
1
3
4
5
6
7*
8*
9*
10
11*
12*
13
14*
15*
16*
17*
18*
19*
20*
21*
22*
23*
24*
25*
26
27
28
29
Description
Part No.
Item
Anti-Roost Guard
2798
Cover Assembly
5687
Anti-Roost Insulator Bracket 29516
Body Weldment
29056
Tube Clamp
29520
Diaphragm Assembly
4889
Spacer Plate
4921
Paddle
4890
Paddle Guard
4892
Housing
6048
10-24 x 1/4” Screw
4417-2
Cover
6053
4-40 x 3/4” Screw
4143-2
Actuator Switch
6049
Spring
5820
Barrier
6936
10-32 x 7/8” Screw
4303-5
Switch Bracket
6045
4-40 Hex Nut
3511
6-32 x 5/16” Screw
4402-3
Wire Lead Assembly
2243-106
90° Connector
4228
Flex Cable
20140-4
Flex Connector
6042
Control Drop Tube
4180
Bottom Plate
4186
Handy Box
1145
Romex Connector
1317
Floor Feeder Repair Parts Manual Volume II
30
31
32
33
34
35
36
37
38
39
40
41
42
43
Description
Part No.
Turkey Pan
Handy Box Cover Plate
Feed Level Tube
Feed Level Ring
Pan Support
Drive Rivet
Pan Shield
Anchor Plate
Cord Guard
Cord Assembly
Safety Closure
“S” Hook
1/4-20 x .4” Screw
Spiroband
4193
711
4341
4196
4199
4200
4190
4188
1992
4166
4184
2805
2754
5915
* These items may be ordered as an
assembly under Part No. 6044-1
Manufactured from 1977
to May 1990.
16
Control Units
Adult Turkey Feeder Control Unit
Part No: 6035
Item
1**
2**
3**
4**
5**
6**
7
8**
9**
10**
11**
12
13
Description
Danger Decal
Tube Support
Handy Box
Stub Tube Weldment
Insulator
Body Cover
Anti-Roost Guard
Safety Cover Assembly
Cover
Danger Decal
Bottom Plate
Conduit Assembly
Pan Support
Part No.
Item
2527-9
27891
1145
27900
2976
27942
2798
27941
711
2527-25
27893
20140-4
4199
14*
15
16
Drop Tube Assembly
Feed Level Tube Assembly
Plastic Feeder Pan
Metal Feeder Pan
17
Swing Down Pan Support
18** Control Body
19
3/8” Flexible Cable
-Actuator Pin
-Anchor Plate
Part No.
6052
4341
29000
4193
24274
27889
20140-13
8757
4188
*See separate Parts List for Drop Tube Assembly on page 19.
**These components may be ordered as an
assembly under Chore-Time Part No. 27899.
Manufactured from May
1990 to January 1991.
Floor Feeder Repair Parts Manual Volume II
Description
17
Control Units
Adult Turkey Feeder Control Unit
Part No: 6035
Item
1**
2**
3**
4**
5**
6**
7
8**
9**
10**
11**
12
13
Description
Danger Decal
Tube Support
Mount Plate
Stub Tube Weldment
Insulator
Body Cover
Anti-Roost Guard
Safety Cover Assembly
Weatherproof Box
Danger Decal
Bottom Plate
Conduit Assembly
Pan Support
Part No.
Item
2527-9
27891
28615
27900
2976
27942
2798
27941
28660
2527-25
27893
27974
4199
14*
15
16
Drop Tube Assembly
Feed Level Tube Assembly
ATF Plastic Feeder Pan
ATF Metal Feeder Pan
17
Swing Down Pan Support
18** Control Body
-Actuator Pin
-Anchor Plate
Part No.
28072
4341
29000
4193
24274
27889
8757
4188
*See separate Parts List for Drop Tube Assembly on page 19.
**These components may be ordered as an
assembly under Chore-Time Part No. 27770.
Manufactured from
January 1991 to present.
Floor Feeder Repair Parts Manual Volume II
Description
18
Control Units
Adult Turkey Feeder Drop Tube Assembly
Part No. 28072
Item
1
2
3*
4
5
6
7
8
9
10
11
12
13
14
15
16
Description
Part No. 6052
Part No.
Item
Control Drop Tube Weldment 4180
Cover
6053
Switch Assembly
6044-3
Guard Assembly
4892
90 Degree Connector
---Switch Bracket Assembly
6045
Barrier
6936
3/8 Flex Connector
---Anti-Short Bushing
---Conduit Assembly
27866
Paddle
4890
Diaphragm Assembly
4889
Spacer Plate
4921
Actuator Switch
6049
Housing
6048
Torsion Spring
5820
1
2
3*
4
5
6
7
8
9
10
11
12
13
14
15
16
*Individual components include Items 5 thru 16.
Floor Feeder Repair Parts Manual Volume II
Description
Part No.
Control Drop Tube Weldment 4180
Cover
6053
Switch Assembly
6044-1
Guard Assembly
4892
90 Degree Connector
4228
Switch Bracket Assembly
6045
Barrier
6936
3/8 Flex Connector
6042
Anti-Short Bushing
6304
Flexible Cable
20140-4
Paddle
4890
Diaphragm Assembly
4889
Spacer Plate
4921
Actuator Switch
6049
Housing
6048
Torsion Spring
5820
*Individual components include Items 5 thru 16.
19
Control Units
Model C, CT, H, & 2000 Intermediate Control Unit
Part No: 5302-0
Item
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
Description
Part No.
Item
Safety Hook
1980
Grill Lock
3294
Epoxy Coated Pan
8892
Control Grill Assembly
1891
Agitator Assembly
2040
Paddle Shield Assembly
2856
Shield Retainer
2847
Shield
2854
6-32 x 7/8” Screw
1921
SPDT Switch
1901
Tube Clamp
24063
Switch Insulation
1907-2
Washer
149
6-32 x 7/8” Screw
1921
Adjusting Bracket
2972
Switch Bracket Assembly
2846
6-32 Hex Nut
771
Cover
5755
Insulator
5754
#10 x 1/2” Screw
3037
Outlet Tube Assembly
4570
Outlet Tube Assembly
5319
Paddle
2853
1/4-20 Hex Nut
751
1/4-20 x 7/8” Screw
1488
1/4-20 x 1/2” Screw
1487
*Control Adjustment Bracket 9118
Control Adjustment Bracket 2326
1/4” Hex Lock Nut
1269
1/4” Flat Washer
3239
Strain Relief Bushing
715
10-24 x 1/2” Screw
1795
32
33
34
35
36
37
38
#10 External Washer
10-24 P.M. Nut
Cord Set
Control Body Assembly
5/16-18 Hex Lock Nut
5/16-18 x 1/2” Screw
*Extension Assembly
Part No.
305
135
4999-13
4568
2148
1839
*Part are common for the 5302-1 & 5302-5 Intermediate Control Unit, except parts noted with an(*).
These parts are required on the 5302-5 version only.
Note:
Part No. 5302-1 Intermediate Control Unit is used
with the Model C, CT, and H Feeding Systems.
Part No. 5302-5 Intermediate Control Unit is used
with the Model 2000 Feeding System.
Part No. 5302-1: Manufactured
from 1974 to February 1994.
Part No. 5302-5: Manufactured
from 1986 to February 1994.
Floor Feeder Repair Parts Manual Volume II
Description
20
Control Units
Model C & CT Intermediate Control Unit
Part No: 24190
Item
1
2
3
4
5*
6
7
8
9*
10*
11*
12*
13*
14*
15*
----
Description
Feeder Pan
Grill Assembly
Feed Level Ring
Feed Level Tube
Switch Box Cover
Control Box Assembly
Insert Assembly
10-24 x 1-7/8” Screw
Switch Box
Gasket
Actuator Switch
Switch Bracket
Reducing Seal
Vinyl Tubing
Water Tight Connector
Spring
Switch Paddle
Mylar Assembly
Part No.
7700
6269
8171
2508
6776
24718
6255
4416-4
24678
6777
7114
7068
7815
7814
24685
6972
24848
25318
Manufactured from 1988 to
February 1991.
*These components may be ordered as an assembly
under Chore-Time Part No. 24317.
**The Intermediate Control may be ordered without
the Feeder Pan and Grill Assembly under
Chore-Time Part No. 25422.
Floor Feeder Repair Parts Manual Volume II
21
Control Units
Model C Intermediate Control Unit
Part No: 24190 (1-Phase), 27758 (3-Phase)
Item
1
2
3
4
5
6
7
8
9
10*
11*
12*
13*
14*
15*
16
Description
Feeder Pan
Grill Assembly
Feed Level Ring
Feed Level Tube
10-24 x 1-7/8” Screw
Front Panel
Insert Assembly
Switch Box
Switch Box Cover
Gasket
Actuator Switch
Switch Bracket
Reducing Seal
Vinyl Tubing
Water Tight Connector
Danger Decal
1 Phase
Part No.
3 Phase
Part No.
7700
6269
8171
2508
4416-4
25046
6255
34842
6776
6777
7114
7068
7815
7814
24685
2527-9
7700
6269
8171
2508
4416-4
25046
6255
7841
6776
6777
7114
7068
---------2527-9
Floor Feeder Repair Parts Manual Volume II
Item
17
18
19
20
21
22
23
------
Description
Tube Support
Switch Paddle
Tube Retainer
Mylar Assembly
Back Cover
Terminal Block
Switch Insulation
Spring
Gasket
Danger Decal
Pivot Bracket
Paddle Retainer
1 Phase
Part No.
14754
24848
14756
25318
25047
34925-2
1907-5
6972
6968-1
2527-25
25048
25045
3 Phase
Part No.
14754
24848
14756
25318
25047
34925-2
1907-5
6972
6968-1
2527-25
25048
25045
*These components may be ordered as an assembly
under Chore-Time Part No. 24317.
Manufactured from February
1991 to present.
22
Control Units
Model C2 Intermediate Control Unit
Part No: 28117 (1-Phase), 28275 (3-Phase)
Item
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
Description
Feeder Pan
Feeder Grill
Tube Support
Support Cone Assembly
10-24 x 1-3/4” Screw
Switch Box
Gasket
Switch Box Cover
Vinyl Tubing
Switch Bracket
Actuator Switch
Water Tight Connector
Reducing Seal
Front Panel
Back Cover
Tube Retainer
1 Phase
Part No.
3 Phase
Part No.
25281
25280
14754
35729
4416-4
34842
6777
6776
7814
7068
7114
24685
7815
25046
25047
14756
25281
25280
14754
35729
4416-4
7841
6777
6776
---7068
7114
------25046
25047
14756
Floor Feeder Repair Parts Manual Volume II
Item
17
18
19
20
------
Description
Danger Decal
Terminal Block
Control Unit Sleeve
Switch Insulation
Pivot Bracket
Paddle Retainer
Spring
Switch Paddle
Mylar Assembly
1 Phase
Part No.
3 Phase
Part No.
2527-9
---29349
1907-5
25048
25045
6972
24848
25318
2527-9
34925-2
29349
1907-5
25048
25045
6972
24848
25318
The Intermediate Control may be ordered without the
Pan, Grill, Adjustment Cone, and Support Cone
Assembly under Chore-Time Part No. 25422.
Manufactured from February
1991 to present.
23
Control Units
Model 2000 Intermediate Control Unit
Part No: 24191-1 (shallow pan), 24191-2 (deep pan)
Item
1
2
3
4
5
6*
7*
8*
9*
10*
11*
12*
13*
14
15
----
Description
Feeder Pan
Feeder Grill
Sleeve Assembly
Adjustment Ring
10-24 x 1-3/4” Screw
Switch Box
Gasket
Switch Box Cover
Vinyl Tubing
Switch Bracket
Actuator Switch
Water Tight Connector
Reducing Seal
Support Cone
Control Box Assembly
Spring
Switch Paddle
Mylar Assembly
24191-1
Part No.
24191-2
Part No.
8764
7730
24686
7728
4416-4
24678
6777
6776
7814
7068
7114
24685
7815
8334
24718
6972
24848
25318
8764
7730
24686
7728
4416-4
24678
6777
6776
7814
7068
7114
24685
7815
8334
24718
6972
24848
25318
Floor Feeder Repair Parts Manual Volume II
*These components may be ordered as an assembly
under Chore-Time Part No. 24317.
The Intermediate Control may be ordered without
the Pan, Grill, Sleeve Assembly, and Adjusting Ring,
under Chore-Time Part No. 25422.
Manufactured from 1989 to
February 1994.
24
Control Units
Model G Intermediate Control Unit
Part No: 29512 (1-Phase), 29522 (3-Phase)
Item
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
Description
Tube Retainer
Danger Decal
Support Cone Assembly
Model G Grill Assembly
Feeder Pan
Control Cord Assembly
Control Unit Sleeve
Switch Box Cover
Danger Decal
Switch Box
Front Panel
Back Cover
16-3 SJO Cord
1/2” Water Tight Conn.
Actuator Switch
Mylar Assembly
1 Phase
Part No.
14756
2527-9
35729
29300
7700
4999-49
29349
6776
2529-380
34842
25046
25047
2290-2
24685
7114
25318
3 Phase
Part No.
Item
17
18
19
20
21
22
23
24
25
26
----
14756
2527-9
35729
29300
7700
---29349
6776
2529-379
7841
25046
25047
------7114
25318
Floor Feeder Repair Parts Manual Volume II
Description
Paddle Switch
Switch Bracket
2-Terminal Block
Vinyl Tubing
Reducing Seal
Switch Insulation
Tube Support
Pivot Bracket
Paddle Retainer
Switch Box Cover Gasket
Switch Box Leveling Gasket
Gasket
Switch Actuation Pin
1 Phase
Part No.
3 Phase
Part No.
24848
7068
---7814
7815
1907-5
14754
25048
25045
6777
6972
6968-1
8757
24848
7068
34925-2
- - - ---1907-5
14754
25048
25045
6777
6972
6968-1
8757
Manufactured from February
1991 to present.
25
Control Units
Model H2 Intermediate Control Unit
Part No: 25435
Item
1
2
3
4
5
6
7
8
9
10
11
12
Description
Feeder Pan
Cone Assembly
10-24 x 1-3/4” Screw
Tube Retainer
1/2” Water Tight Connector
Reducing Seal
Vinyl Tubing
Actuator Switch
Switch Bracket
Switch Box
Switch Box Cover
Gasket
Part No.
24901
25490
4416-4
14756
24685
7815
7814
7114
7068
24678
6776
6777
Floor Feeder Repair Parts Manual Volume II
Manufactured from 1989 to
February 1991.
26
Control Units
Model H2 Intermediate Control Unit
Part No: 25435 (1-Phase), 27760 (3-Phase)
Item
1
2
3
4
5
6
7
8*
9
10
11
12
13
Description
Pan
Cone Assembly
Terminal Block
Tube Support
10-24 x 1-3/4” Screw
Switch Box
Gasket
Switch Box Cover
Danger Decal
Tube Retainer
Front Panel
Back Cover
Switch Paddle
1 Phase
Part No.
3 Phase
Part No.
24901
34481
---14754
4416-4
34842
6777
6776
2527-9
14756
25046
25047
24848
24901
34481
34925-2
14754
4416-4
7841
6777
6776
2527-9
14756
25046
25047
24848
Item
17
18
19
20
14
15
16
------
Description
Water Tight Connector
Vinyl Tubing
Reducing Seal
Switch Insulation
Mylar Assembly
Switch Bracket
Actuator Switch
Spring
Gasket
Switch Actuation Pin
Pivot Bracket
Paddle Retainer
1 Phase
Part No.
3 Phase
Part No.
24685
7814
7815
1907-5
25318
7068
7114
6972
6968-1
8757
25048
25045
- - - - - - - - - 1907-5
25318
7068
7114
6972
6968-1
8757
25048
25045
Part No. 25435: Manufactured
from July 1989 to present.
Part No. 27760: Manufactured
from January 1991 to present.
Floor Feeder Repair Parts Manual Volume II
27
Control Units
Adult Turkey Feeder Intermediate Control Unit
Part No: 6039
Item
1
2
3
4*
5*
6*
7*
8*
9
10*
11*
12*
13*
14*
15*
16*
17*
18*
19*
20*
21*
22*
23
--
Description
Insulator
Drop Tube Weldment
Paddle Guard
Diaphragm Assembly
Spacer Plate
Paddle
Housing
10-24 x 1/4” Screw
Cover
4-40 x 3/4” Screw
Actuator Switch
Spring
Barrier
10-32 x 7/8” Screw
Switch Bracket Assembly
4-40 Hex Nut
6-32 x 5/16” Screw
90° Connector
Flex Cable
Flex Connector
Wire Lead Assembly
Anti-Short Bushing
Pan Shield Support
Feed Level Tube
Part No.
5754
6446
6771
4889
4921
4890
6048
4417-2
6053
4143-2
6049
5820
6936
4303-5
6045
3511
4402-3
4228
20140-5
6042
2243-112
6304
6443
4341
Manufactured from 1989 to
February 1991.
*Indicates components of Switch Assembly
Part No. 6044-2.
Floor Feeder Repair Parts Manual Volume II
28
Power Units
Floor Feeder Power Units
Power
Unit
Motor
H.P.
Type
Hz.
Gearhead
RPM
Pinion
Motor Shield
3259-1
2599
1/4
SP
60
3261-1
216
3249R
N/A
3259-2
1854
1/6
SP
60
3261-1
216
3249R
N/A
3259-7
4229
1/3
SP
60
3261-1
216
3249R
4266-Doer,
6815-GE,
6781-EM,
3259-8
4229
1/3
SP
60
3261-5
348
5046R
4266-Doer,
6815-GE,
6781-EM,
3259-25
5703
1/2
SP
60
3261-5
348
5046R
6815-GE
3259-26
3967
1/4
SP
60
3261-1
216
3249R
6815-GE,
6781-EM
3259-29
5976
1/3
C
50
3261-1
180
3249R
4266-Doer,
5711-GE
3259-30
5977
1/2
C
50
3261-5
293
5046R
4266-Doer,
5711-GE
3259-34
4229
1/3
SP
60
3261-5
348
5046R
6815-GE,
6781-EM
3259-39
5703
1/2
SP
60
3261-5
348
5046R
N/A
3259-41
5977
1/2
C
50
3261-5
293
5046R
N/A
3259-51
5050
1/2
C
60
3261-7
348
5046R
N/A
3259-53
6305
3/4
C
50
3261-7
285
5046R
N/A
3259-55
7520
1/4
SP
60
3261-1
216
3249R
6815-GE,
6781-EM
3259-56
7520
1/4
SP
60
3261-1
216
3249R
6815-GE,
6781-EM
3259-57
7522
3/4
C
60
3261-5
696
5046R
6772-GE,
6815-EM
3259-58
4229
1/3
SP
60
3261-5
348
5046R
6815-GE,
6781-EM
3259-59
5703
1/2
--
60
3261-5
348
5046R
6815
3259-60 exp
5977
1/2
C
50
3261-5
290
5046R
5711-GE
3259-61
4229
1/3
SP
60
3261-1
216
3249R
6815-GE,
6781-EM
Floor Feeder Repair Parts Manual Volume II
29
Power Units
Floor Feeder Power Units
Power
Unit
Motor
H.P.
Type
Hz.
Gearhead
RPM
Pinion
Motor Shield
3259-62
7520
1/4
SP
60
3261-1
216
3249R
6815-GE,
6781-EM
3259-63
5976
1/3
C
50
3261-1
180
3249R
5711-GE
3259-77
5050
1/2
C
60
3261-10
425
5046R
N/A
3259-78
5050
3/4
C
60
3261-10
425
5046R
N/A
3259-79
6847
1
C
60
3261-10
425
6104R
N/A
3259-81
7522
3/4
C
50/60
3261-11
708
5046R
N/A
3259-82
7520
1/4
SP
60
3261-1
216
3249R
N/A
3259-83
4229
1/3
SP
60
3261-1
216
3249R
6815-GE,
6781-EM
3259-84
4229
1/3
SP
60
3261-5
348
5046R
6815-GE,
6781-EM
3259-85
5703
1/2
SP
60
3261-5
348
5046R
6815-GE
3259-86
5976
1/3
C
50
3261-5
288
5046R
5711-GE
3259-98
5477
1/2
C
50
3261-11
5046R
N/A
3259-100
28031
1/2
3-PH
50
3261-11
348
5046R
N/A
3259-101
28032
3/4
3-PH
50
3261-11
696
5046R
N/A
Floor Feeder Repair Parts Manual Volume II
30
Power Units
Floor Feeder Power Unit Miscellaneous Components
Item
1
5
6
7
8
9
10
11
12
13
14
15
16
17
Description
Pinion Assembly
--216 RPM
--348 RPM
--354 RPM
Motor
5/16-18 x 3/4” Screw
Gearhead Assembly
1/4-20 x 1-1/2” Screw
Pipe Plug
Flat Washer
Drive Tube
--3/4” O.D.
--7/8” O.D.
Drive Block
Vented Plug
Ground Wire (16 AWG)
Anti-Short Bushing
90° Connector
Connector
Wire Lead Assembly
--without terminal
--with terminal
Item
Part No.
18
19
3249R
5046R
4450
- - - -*
4412-1R
- - - -**
2919
2755R
1484
20
21
22
23
24
25
26
27
28
29
30
31
32
---
1048
2920
4642
3523R
2243-178
6304
4228
1317
Cord Assembly
Cord Guard
--for 1/3 H.P. Motor
--for 1/2 H.P. Motor
90° Liquid Tight Connector
Flexible PVC Tubing
“8” Hook
5/16” Flat Washer
5/16-18 x 1-1/4” Screw
Hanger Bracket
Motor Shield
Motor Shield
Motor Shield
Motor Shield
Motor Shield
Motor Shield for ATF
Cord Support
“S” Hook
Magnetic Pipe Plug
Part No.
- - - -* **
4168
5712
7953
8028-1
2759
2230
4412-8
8475
6781
4266
6772
6815
5711
2973
4327
4270
30160
*See individual Power Units on page 29-30.
**See individual Gearheads on page 29-30.
***Source Cord Assemblies locally.
2243-134
2243-138
Floor Feeder Repair Parts Manual Volume II
Description
31
Boot Components
Single Boot Components
Part No: 6822 (Broiler), 6821 (ATF)
Item
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
--
6822
Part No.
Description
Boot Weldment
Tube Clamp
Outlet Tube
Sleeve
3/16 x 1” Pin
Bearing
Washer
Anchor
Set Screw
Anchor & Bearing Ass’y
Cannonball
Cotter Pin
Chain
Latch Pin Assembly
Cap
Danger Decal
3760
24063
4556
5648
2960-1
2689
2955-14
6818
1174
6817
3531
1639
2128-1
2683
29373
2527-9
6821
Part No.
4224
24063
4556
5648
2960-1
2689
2955-14
6818
1174
6817
3531
1639
2128-1
2683
29373
2527-9
Part No. 6821: Manufactured from
October 1979 to present.
Part No. 6822: Manufactured from
October 1979 to present.
Floor Feeder Repair Parts Manual Volume II
32
Boot Components
Twin Boot Components
Part No: 6824 (Broiler), 8460 (ATF)
Item
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
--
6824
Part No.
Description
Boot Weldment
Tube Clamp
Outlet Tube
Sleeve
3/16 x 1” Pin
Bearing
Washer
Anchor
Set Screw
Anchor & Bearing Ass’y
Cannonball
Cotter Pin
Chain
Latch Pin Assembly
Cap
Danger Decal
3932
24063
4556
5648
2960-1
2689
2955-14
6818
1174
6817
3531
1639
2128-1
2683
29373
2527-9
8460
Part No.
8461
24063
4556
5648
2960-1
2689
2955-14
6818
1174
29530
3531
1639
2128-1
2683
29523
2527-9
Part No. 6824: Manufactured from
October 1979 to present.
Part No. 8460: Manufactured from
October 1979 to present.
Floor Feeder Repair Parts Manual Volume II
33
Boot Components
ULTRAPAN® Boot Assembly
Part No: 34824
Item
1
2
3
3
4
5
Description
Part No.
Boot Weldment
Agitator Assembly
Agitator Ball
Latch Pin Assembly
Danger Decal
5/16” U-Bolt
Floor Feeder Repair Parts Manual Volume II
34
34811
34804
34803
2683
2527-9
34823
Boot Components
ULTRAPAN® Intake Cup Assembly
Part No: 28119
Item
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
Manufactured from May 1991 to
November 1994.
Floor Feeder Repair Parts Manual Volume II
35
Description
Part No.
Cup Weldment
Anti-Roost Wire
Hopper Sprocket
Agitator Rod
Spacer
Clamping Bolt
Insulator Mounting Strap
Bearing Assembly
1/4-20 Hex Nut
1/4-20 x 5/8” Button Hd. Sc.
3/32” Clamp
7/16” Washer
1/4” Lock Washer
Insulator
Hopper Adapter
24561
29696
25286
24571
24558
24552
---14144
751
2432
1826
2955-25
1667
2976
25165
Boot Components
ULTRAFLO® Intake Cup Assembly
Part No: 25167 (domestic) & 27380 (Intn’l only)
Item
1
2
3
4
5
6
7
8
9
10
11
12
13
14
Floor Feeder Repair Parts Manual Volume II
36
Description
Intake Cup Weldment
Clamping Bolt
Spacer
7/16” Flat Washer
7/16” Lock Nut
Bearing Assembly
Actuator Rod
Restrictor Plate
Hopper Sprocket
Hopper Adapter Weld.
5/16-18 Wing Nut
Flat Washer
Baffle
Bearing Spacer
Part No.
Part No.
25466
24552
24558
2955-25
2428
14144
24571
37338
25286
25165
---------28646
27383
24552
24558
2955-25
2428
14144
29518
37338
25286
25165
2146
5933
27382
28646
Feed Hoppers
100# Feeder Line Hopper
Key
1*
2*
3
4
5
6
7
8
9
10
11
Description
Part No.
Hopper Cover (w/o hole)
Hopper Cover (w/ hole)
Tube Support Assembly
Hopper Hanger
Adjustment Bracket
Cotter Pin
Hair Pin
Hopper Side (w/o hole)
Hopper Side (w/ hole)
Boot Hanger
H.L.C. Mounting Bracket
28211
28212
14367
28165
2706
2797-1
2664
28164
24241
28168
28267
NOTES
*Items 1 & 2 may be ordered as an assembly under Part No. 28210.
The 100# Hopper Assembly (no Cover) may be ordered under Part No. 28220.
The 100# Hopper Assembly, including the Cover, may be ordered under Part No. 28240.
The 100# Hopper Assembly, including an 8798 Switch (not shown), may be ordered under Part No. 28242.
The 100# Hopper Assembly, including the Cover and an 8798 Switch, may be ordered under Part No. 28240.
Floor Feeder Repair Parts Manual Volume II
37
Feed Hoppers
200# Feeder Line Hopper
Part No: 9474
Item
1
2
3
4
5
6
7
8
9*
10*
11
Description
Part No.
Hopper Cover (optional)
28206
Tube Support Assembly
14367
Clamp
13948
Chain
2128-1
Hopper Side (w/o hole)
2680
Boot Hanger
2671
Hanger Bracket Assembly 2681
Adjustment Bracket (2 req’d) 2706
Hair Pin
2664
Clevis Pin, 5/16 x 1"
2797-1
Diaphragm Assembly
7900
Boot Switch
7840
Hopper Side Panel (w/ hole) 8791
*These items are components of the 8798
Switch Kit. See separate parts listing for individual components.
Floor Feeder Repair Parts Manual Volume II
38
Feed Hoppers
200# Feeder Line Hopper
Part No: 7941
Item
1*
2
3
4
5
6
7
8
Description
Part No.
Hopper Cover Kit (optional) 28206
Cover Half (Removable)
28208
Cover Half (Stationary)
28207
Tube Support Assembly
14367
Clamp
13948
Chain
2128-1
Hopper Side (4 req’d)
2680
Boot Hanger
2671
Hanger Bracket Assembly 2681
Adjustment Bracket (2 req’d) 2706
Hair Pin
2664
Clevis Pin, 5/16 x 1"
2797-1
*Hopper Cover not included, must be ordered
separately.
Floor Feeder Repair Parts Manual Volume II
39
Feed Hoppers
300# Feeder Line Hopper
Item
1
2
3
4
5
6*
7*
8
9*
10*
11*
12*
13*
14*
15*
16*
17*
18*
19*
Description
Item
Part No.
20*
21
22**
23**
24
Hopper Support
24427
Hanger Bracket Assembly 2681
Hopper Hanger
24426
Hopper Side
24423
Boot Hanger
24425
Diaphragm Assembly
7900
Deflector Shield
28281
Hopper Side (w/Switch Hole) 24424
Mounting Plate
7908
Switch Box
7841
Gasket
6777
Switch Box Cover
6776
6-32 x 7/8” Screw
1921
Pin
8757
Spring
6972
Switch Bracket
7068
SPDT Actuator Switch
7114
Paddle
7896
Switch Insulation
1907-5
Floor Feeder Repair Parts Manual Volume II
Description
#10 Twin Helix Screw
H.L.C. Support Plate
Hopper Cover (w/clamps)
Hopper Cover
Cover Plate
Part No.
6980
28267
28202
28203
28369
*These components may be ordered as an
assembly under Part No. 8798.
**These components may be ordered as an
assembly under Part No. 28201.
Note: An Extension Kit for the 300# Hopper is
available under Part No. 36319.
Hopper Assembly Part Numbers:
Hopper Assembly w/o Switch or Cover: 28359.
Hopper Assembly w/ Cover only: 28360.
Hopper Assembly w/ Switch only: 24436.
40
Feed Hoppers
300# Breeder Feeder Hopper
Item
1
2
3
4
5
6**
7**
8
Description
Part No.
Hopper Hanger
Hanger Bracket Assembly
Hopper Brace
Hopper Side
Boot Hanger
Diaphragm Assembly
Boot Switch
Switch Hopper Side
24427
2681
24426
24423
24425
7900
7900
24424
**Components of the 8798 Lower Hopper Switch.
Floor Feeder Repair Parts Manual Volume II
41
Feed Hoppers
400# Feeder Line Hopper
(Part No. 27530)
Item
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
Description
Part No.
Hopper Cover
Top Plate Weldment
Leg Weldment
Pulley Wheel
Anchor
Brace (L.H.)
Brace (R.H.)
Pawl
Crank Arm Weldment
Ratchet Weldment
Lower Leg Weldment
Cable Shaft
400# Hopper Extension
Hopper Side
Hopper Ledge
3/4” Set Collar
Cable
452 0
4527
27615
2503
27609
27533-1
27533-2
6672
27613
27604
27614
27612
27601
4836
4837
1049
27534
The hardware and miscellaneous components
may be ordered under Chore-Time 27531
Hardware Package.
Floor Feeder Repair Parts Manual Volume II
42
Feed Hoppers
Lower Hopper Switch
(Part No. 8798)
Item
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
--
Floor Feeder Repair Parts Manual Volume II
43
Description
6-32 x 7/8" Rd. Hd. M.S.
SPDT Actuator Switch
Switch Insulation
Switch Bracket
#6 x 3/8" Screw
6-32 Hex Nut
Pin
Switch Box
10-32 Hex Lock Nut
Spring
10-32 Hex Nut
Mounting Plate
#10 Twin Helix Screw
Switch Box Cover
Gasket
Gasket
Paddle
Diaphragm Assembly
Deflector
Part No.
1921
7114
1907-5
7068
6782
771
8757
7841
6963
6972
4297
7908
6980
6776
6777
6968-1
7896
7900
28281
Feeder Line Components
Broiler, Cockerel, & ATF Feeder Line Components
(Model C, C2 H, H2, G, 2000)
Item
1
2
3
4*
5
6
7
Description
1/16” Cable
3/32” Cable
Charger Wire (165’)
Charger Wire (330’)
Poultry Trainer (110 V)
Poultry Trainer (220 V)
Auger
1/16” Cable Clamp
3/32” Cable Clamp
Spring
Auger Tube
-12 ft., 5 Hole Tube
-12 ft., 4 Hole Tube
-10 ft., 4 Hole Tube
-10 ft., 3 Hole Tube
-9 ft., 4 Hole Tube
-10 ft., 1 Hole Tube (ATF)
-10 ft., 2 Hole Tube (ATF)
-10 ft., 3 Hole Tube (ATF)
Item
Part No.
8
1922
4973
28994-165
28994-330
29333
29325
6820-0
1826
1826
7551
9
10
11
12
13
14
15
16
17
18
6854-6
6854-7
6854-4
6854-5
6854-1
6684
6685
6686
Floor Feeder Repair Parts Manual Volume II
Description
Line Charger (110 V)
Line Charger (220 V)
Hanger (ATF only)
Hanger Strap
Hanger Bracket
Hanger Kit
Tube Clamp
Tube Clamp (ATF)
Anti-Roost Bracket
Anti-Roost Bracket (ATF)
Hanger Assembly
Grommet
Feeder Lock
Feed Level Tube
Part No.
29317
29341
4207
7298
7297
7299
24063
29520
24060
29516
7604
14899
34570
8790
*Round up to the nearest 10’. Auger lengths
from 50 to 500 feet. Example: 6820-200 would
be a 200’ roll of 6820 Auger.
44
Feeder Line Components
ULTRAPAN® Feeder Line Components
Item
15
Item
1
2
3
4
5
6
7
8
9
10+
11+
12
13
14
Description
16**
17*
18*
19*
20
21
22
23
24
25
Part No.
90 Degree elbow
28125
Tube Coupling (1-3/4" diameter) 2123
Tube Coupling (2" diameter) 29691
Hanger
4207
Insulator Bracket
24060
Tube Clamp
24063
2" Tube Clamp
29520
3/32” Cable Clamp
1826
Spring
7551
Tube Adaptor
28107
Belled Adapter Tube
29693
Adjustable Hanger
14780
Grommet
14899
Welding Fixture
25494
Anti-Roost Wire
28108
4’ Extension Tube
28128
Floor Feeder Repair Parts Manual Volume II
26
27
28
Description
Roll-Formed Feeder Tube
--12’ /4 - hole
--10’ /4 - hole
Auger
Service Section Base
Service Section Clamp
Service Section Cover
1/16 Cable
Poultry Trainer
Auger Driver
Line Charger
1/8" Cable Clamp
Hi-Voltage Cable (330’)
Hi-Voltage Cable (165’)
Auger Connector
S Hook
Model C2 Lock
Part No.
6854-7
6854-4
28103-0
28153
28151
28152
1922
29333
28126
29317
14898
28994-330
28994-165
29055-2
723
34570
+ These components may be ordered as an
assembly under Chore-Time P/N 7604.
* These components may be ordered as an
assembly under Chore-Time P/N 28127.
**The Auger may be ordered in lengths from 100’
to 330’. Include the specific length as a suffix to
the part number (example: 28103-220 is a 220’ roll
of auger).
45
Feeder Line Components
ULTRAFLO® Feeder Line Components
Item
1
2***
3
4
5
6***
7
8
9
10
11§
12*
13
14
Description
Part No.
90 Degree Elbow
Connector Tube
5’ Belled Tube
Trough -10’ (3 m)
Grill End Cap
Tube Clamp
End Cap
Welding Fixture
Trough Hanger
Clean-Out
Auger
Auger Connector Ass’y
Clean-Out Lock
Clean-Out Assembly
25170
29691
35627
14159-3
25464
29775
25169
25494
25010
25502
25058-0
28091-2
35865
35802
*includes two connectors & (4) set screws.
***(1) Connector Tube and (2) Tube Clamps may
be ordered as a kit under part no. 29802.
§Round up to nearest 10 foot interval.
Floor Feeder Repair Parts Manual Volume II
46
Feeder Line Components
ULTRAFLO® Feeder Line Grill Options
Grill Style: Standard
Grill Style: Cross
Grill Style: Hi-Contour
Part
Number
Grill
Style
Dimension “A”
Dimension “B”
Dimension “C”
Grill
Retainer
24774-5
Standard
2.000” (50.80 mm)
N/A
4.50” (11.43 cm)
Not Required
24774-7
Standard
1.625” (41.28 mm)
N/A
4.50” (11.43 cm)
Not Required
24774-8
Standard
1.810” (46.00 mm)
N/A
4.50” (11.43 cm)
Not Required
24774-10
Standard
1.688” (42.86 mm)
N/A
4.50” (11.43 cm)
Not Required
24774-12
Standard
1.732” (44.00 mm)
N/A
4.50” (11.43 cm)
Not Required
28644-1
Cross (2)*
1.653” (41.99 mm)
2.77” (70.36 mm)
5.51” (14.00 cm)
Not Required
28644-2
Cross (2)*
1.810” (46.00 mm)
2.24” (56.90 mm)
4.50” (11.43 cm)
Not Required
28644-3
Cross (1)*
1.732” (44.00 mm)
3.13” (79.50 mm)
4.50” (11.43 cm)
Not Required
28644-4
Cross (2)*
1.688” (42.86 mm)
2.56” (65.02 mm)
4.50” (11.43 cm)
Not Required
28644-5
Cross (2)*
1.732” (44.00 mm)
2.50” (63.50 mm)
4.50” (11.43 cm)
Not Required
28644-6
Cross (2)*
1.750” (44.45 mm)
2.24” (56.90 mm)
4.50” (11.43 cm)
Not Required
28244
Hi-Contour
1.688” (42.86 mm)
3.00” (76.20 mm)
5.550” (14.10 cm)
27909
28249
Hi-Contour
1.625” (41.28 mm)
3.00” (76.20 mm)
5.550” (14.10 cm)
27909
28839
Hi-Contour
1.732” (44.00 mm)
3.00” (76.20 mm)
5.550” (14.10 cm)
27909
34945
Hi-Contour
1.688” (42.86 mm)
2.50” (63.50 mm)
6.500” (16.51 cm)
27909
*Denote number of cross wires.
Floor Feeder Repair Parts Manual Volume II
47
Feeder Assemblies
Model C
Standard Model C Feeder
Item
1
2
3
4
5
Description
Part No.
Grill
6906
Grill Support
6461
Feed Level Tube
2508
Feed Level Tube for Turkeys 4329
Feed Level Ring
8171
Plastic "V" Bottom Pan
7700
Model C Feeder (Slide Top)
Item
1
3
4
5
6*
7*
8*
Description
Grill
Feed Level Tube
Feed Level Tube for Turkeys
Feed Level Ring
Plastic "V" Bottom Pan
Support Cap
Support Insert (swinging)
Grill Support
Part No.
6906
2508
4329
8171
7700
25052
28356
25051
*These components may be ordered under Chore-Time Part
No. 25055.
Floor Feeder Repair Parts Manual Volume II
48
Feeder Assemblies
Model C2
2-Piece Model C2 Feeder
Item
1
2*
3
4
5
Description
Model C2 Feeder Pan
Adjustment Cone
Support Cone
Grill
2-Piece Model C2 Feeder
Part No.
25281
29064
25282
25280
28110
Model C2 Feeder (Slide Top)
Item
1
2*
3
4
5
6*
7
Description
Grill
Adjustment Cone
Model C2 Feeder Pan
Support Cap
Support Insert (Swinging)
Support Cone
Model C2 Ass’y (Slide Top)
Part No.
25280
29064
25281
25052
28356
25283
28115
*These items may be ordered as an assembly under
Part No. 29514.
1-Piece Model C2 Feeder
(Note: This feeder is used with Cockerel Feeder Systems)
Item
1
2
3
4
Description
Model C2 Feeder Pan
1-Pc Cone (windowless)
Grill
1-Piece Model C2 Feeder
Part No.
25281
33885
25280
34569
Floor Feeder Repair Parts Manual Volume II
49
Feeder Assemblies
Model H
Item
3
8
9
Description
Part No.
Shallow V Bottom Pan
Pan Support Wire
Feed Cone
5831
5807
5120
A Support Cone Repair Kit, consisting of (10) 7016
Repair Plates and (40) 3/16” Short Pop Rivets,
may be ordered under Chore-Time Part No. 7017.
Floor Feeder Repair Parts Manual Volume II
50
Feeder Assemblies
Model H2
Item
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
Description
Part No.
Model H2 Cone (w/o Feed Windows)
Model H2 Feeder Pan
Feed Chute
Model H2 Cone (w/ Feed Windows)
Flood Collar
Support Cap
Support Insert (swinging)
Model H2 Cone (Slide Top, w/o Windows)
Model H2 Cone (Slide Top, w/Windows)
Model H2 1-Piece Feeder (w/o Windows)
Model H2 1-Piece Feeder (w/ Feed Chute)
Model H2 1-Piece Feeder (w/ Flood Collar)
Model H2 2-Piece Feeder (w/o Windows)
Model H2 2-Piece Feeder (w/ Feed Chute)
Model H2 2-Piece Feeder (w/ Flood Collar)
24900-5
24901
25320-1
24900-6
25360
25052
28356
24900-3
24900-4
27110
27115
27120
28112
28113
28114
Floor Feeder Repair Parts Manual Volume II
51
Feeder Assemblies
Model G
2-Piece Model G Feeder
Item
1
2*
3*
4
5
Description
Feeder Pan
Support Cone
Adjustment Cone
Grill
2-Piece Model G Feeder
Part No.
7700
25282
30730
29300
29560
*These items may be ordered as an assembly
under Part No. 30735.
Model G Feeder (Slide Top)
Item
1
2*
3*
4
5
6
7
Description
Feeder Pan
Support Cone
Adjustment Cone
Grill
Support Insert (Swinging)
Support Cap
Model G Ass’y (Slide Top)
Part No.
7700
25283
30730
29300
28356
25052
29565
*These items may be ordered as an assembly under
Part No. 34538.
1-Piece Model G Feeder
Item
1
2
3
4
Description
Feeder Pan
1-Pc Cone (windowless)
Grill
1-Piece Model G Feeder
Part No.
7700
33885
29300
34567
Floor Feeder Repair Parts Manual Volume II
52
Feeder Assemblies
Model 2000
Item
1
3
4
9
Description
Part No.
Feeder Grill
7730
Feeder Grill (split ring)
14150
Red Plastic Pan
7729
Deep Plastic Pan
24000
Shallow “V” Bottom Pan
24000
Feed Level Ring
7728
Feed Cone
7731
Feed Cone (field repair only) 14949
Floor Feeder Repair Parts Manual Volume II
53
Feeder Assemblies
Adult Turkey Feeder
Item
1
2
3
4
5*
6
7*
8
9
Description
Part No.
Pan Shield
Swing Down Pan Support
Pan Support
ATF Plastic Feeder Pan
Insulator
Pan Shield Support
Drop Tube
Feed Level Tube
Feed Level Ring
4192
24274
4199
29000
5754
6443
5758
4194
29320
*These Items (#5 & #7) may be ordered as an
assembly under Chore-Time Part No. 5806.
Floor Feeder Repair Parts Manual Volume II
54
Suspension Components
Miscellaneous Components
Item
1
Description
3/32” Cable
3/16” Cable
1/8” Cable
2
Cable Lock
3
Pulley (w/Swivel)
4
Double Eye Pulley
5
Pulley
6
3/16” Cable Clamp
1/8” Cable Clamp
7
Standard Screw Hook
Large Screw Hook
8
7” Screw Hook
9
Pulley Assembly
10
Ceiling Hook
11* Handle Shank
12** Drill Adapter Shaft
13
Winch Handle Pin
14
Winch Drive Tube (4’)
Winch Drive Tube (8’)
15
Pulley
16
Clevis Pin
Part No.
Item
4973
1213
27975
14337
3004
2501
2500
732
14898
1214
2041
28357
28429
28550
2148
3151
3761
2884-1
2884-2
2503
2498-1
Floor Feeder Repair Parts Manual Volume II
17
18
19
20
21
22
23
24
25
Description
Side Bracket
Spacer
Eye Bolt
Foot
Cable Assembly
Double Sheave Pulley
Screw Hook Driver (short)
Screw Hook Driver (long)
Hand Winch Bracket
Hand Winch
Part No.
2522
2524
6362
1586
2809-2
2502
13150-1
13150-2
1193
1212
Item 11 and 13 may be ordered as a kit under
Part No. 2885.
Item 12 and Item 13 may be ordered as a kit
under Part No. 2886.
The Full Line Suspension Kit including items
15 through 21 may be ordered under Part No.
7948.
55
Suspension Components
Power Winch: Part No. 2883
Item
1
2
3
4
5
6
7
8
9
10
11
12
13
14
Description
Input Shaft Assembly
Flange Bushing
Drive Stud
Shoulder Bolt
Pawl
5/16" Flat Washer
Spring
Spring Washer
Intermediate Gear
Flange Bushing
Spirol Pin
Bushing
Washer
Retaining Ring
Part No.
Item
14885
2967-2
4128-1
4022-2
6672
2955-44
1543
4023
2890
3252
2960-3
2967-4
2955-1
2958-1
15
16
17
18
19
20
21
22
23
24
25
26
27
28
Floor Feeder Repair Parts Manual Volume II
56
Description
Drive Pinion
Woodruff Key
1" Bearing
Spacer
Retaining Ring
Washer
Winch Drum
Drum Shaft
Setscrew
Winch Frame
Setscrew
Cable Hook
Grease Zerk
Washer
Part No.
2962
2959
4937
4936
3556
2955-2
3723
3637
603
3719
3727
2985
24499
2499
Suspension Components
Electric Power Lift: Part No. 14580
Manufactured from April 1986 to October 1990.
Item
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
--
Description
Power Unit
5/16-18 x 3/4” H.H. Screw
5/16” Flat Washer
1/4-20 Lock Nut
Power Winch
5/16” Washer
5/16-18 Hex Nut
5/16-18 x 2-1/2” H.H. Bolt
3/8-16 x 1” H.H. Bolt
3/8” Washer
3/8” Patch Lock Nut
5/16-18 x 3/4” H.H. Screw
5/16” Locknut
Input Shaft Assembly
1/4-20 x 1-1/2” S. H. Screw
Universal Joint
Power Unit Bracket
Winch Bracket
Switch Box Assembly
Part No.
3259-7
2046
2230
1269
2883
2230
2148
2753
2555
4967
2183
2046
2148
14885
5083-8
27840
14587
24401
14613
Floor Feeder Repair Parts Manual Volume II
•
The entire assembly, except Item #4, may be
ordered under Part No. 14560 Electric Winch Kit.
•
The entire assembly, except Items #1 & #4, may be
ordered under Part No. 24508 Power Lift Parts Kit.
57
Suspension Components
Electric Power Lift: Part No. 14580
Manufactured from November 1990 to Present
Item
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
--
Description
Power Unit
5/16-18 x 3/4” H.H. Screw
5/16” Flat Washer
1/4-20 Locknut
Power Winch
5/16” Washer
5/16-18 Hex Nut
5/16-18 x 2-1/2” H.H. Bolt
3/8-16 x 1” H.H. Bolt
3/8” Washer
3/8” Patch Lock Nut
5/16-18 x 3/4” H.H. Screw
5/16” Locknut
Input Shaft Assembly
1/4-20 x 1-1/2” S. H. Screw
Universal Joint
Power Unit Bracket
Winch Bracket
Switch Box Assembly
Part No.
3259-7
2046
2230
1269
2883
2230
2148
2753
2555
4967
2183
2046
2148
14885
5083-8
27840
14587
24401
14613
Floor Feeder Repair Parts Manual Volume II
•
The entire assembly, except Item #4, may be
ordered under Part No. 14560 Electric Winch Kit.
•
The entire assembly, except Items #1 & #4, may be
ordered under Part No. 24508 Power Lift Parts Kit.
58
Suspension Components
Switch Box (for Electric Power Lift): Part No. 14316
Item
1
2
3
4
5
6
Floor Feeder Repair Parts Manual Volume II
59
Description
Box and Cover
Momentary Switch
Toggle Switch
Grounding Plate
Toggle Switch Boot
Push Button Boot
Part No.
14611
5785
6014
14604
1739
20784
This page is left blank intentionally.
Floor Feeder Repair Parts Manual Volume II
60
Electrical Controls and Components
Breeder Control Panel: Part No. 34380
Item
1
2
3
4
5
6
7
8
9
10
11
12
13
Description
Control Box
Clear Cover
Control Box Latch Pivot
Control Box Latch
Fuse Holder
Control Box Mount Panel
Back Mount Panel
Front Panel
Time Clock Connector
Terminal Strip
Terminal Mount Bracket
3 Amp Fuse (Slow Blow)
Terminal Mount Bracket
Part No.
Item
30860-4
30859-1
30863
30862
24431
34852
34564
34565
34457
34925-8
35094
20472
34563
14
15
16
17
18
19
20
21
22
23
24
25
26
Floor Feeder Repair Parts Manual Volume II
61
Description
Terminal Strip
P & B Relay (240 V)
Transformer
Mount Bracket
Battery Box Assembly
AAA Battery
Terminal Block
Pilot Light
Toggle Switch
Toggle Switch
Toggle Switch
MOV
Circuit Board
Part No
34925
34733
34571
34562
35095
34584
7347
29708
34579
34389
34578
14063-1
34384
Electrical Controls and Components
Breeder Control Panel: Part No. 25175
Item
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
Description
Control Mounting Plate
Control Box
Time Clock (220 v)
Timer
Toggle Switch Boot
Push Button Boot
Shoulder Nut
Toggle Switch Boot
Fuse Holder
1 amp, 3 AG Fuse
Contactor
Pipe Plug
Inner Box Mounting Plate
Terminal Block
Toggle Switch
Momentary Switch
Ground Plate
Toggle Switch
Mounting Adapter
Mounting Adapter
Pilot Light
Timer Socket
Timer Cover
Part No.
26861
25336
26251
25476
1739
20784
13407
13406
24431
2935
4283
24458-2
25293
7270
7767
5785
25483
6014
25478
25480
7044
25477
25479
Floor Feeder Repair Parts Manual Volume II
62
Electrical Controls and Components
Breeder Feeder Feed-Only Control Panel: Part No. 27440
Item
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
Description
Part No.
#10 External Lock Washer 305
Fuse Holder
24431
1 Amp Fuse (3 AG)
2935
Contactor
4283
Control Box
27577
Control Panel Mounting Panel 26797
Control Mounting Panel
27575
Terminal Block
26862
10-32 Ground Screw
4968
Cup Washer
5775
Pilot Light
7044
Toggle Switch
7767
Toggle Switch Boot
13406
Shoulder Nut
13407
Time Clock (230 V)
26795
Mounting Adapter
25480
Timer
25476
Timer Socket
25477
Mounting Adapter
25478
Cover
25479
Floor Feeder Repair Parts Manual Volume II
63
Electrical Controls and Components
Meal-Time Control Panel: Part No. 34385
Item
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
Description
Part No
Control Box
Clear Lid
Control Box Latch Pivot
Control Box Latch
Fuse Holder
Control Box Mount Panel
Back Mount Panel
Front Panel
Time Clock Connector
3 Amp Fuse
Terminal Mount Bracket
Terminal Strip (12 position)
P & B Relay (240 VAC)
Dual Transform. (115/230V)
Mount Bracket
Item
30860-4
30859-1
30863
30862
24431
34852
34564
34565
35464
20472
34563
34925
34733
34571
34562
Floor Feeder Repair Parts Manual Volume II
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
64
Description
Battery Box Assembly
“AAA” Battery (1.5V)
Seal
Strapping
Terminal Block
Pilot Light
Toggle Switch
Toggle Switch
MOV
Nylon Hex Nut 1/4-20
Circuit Board
Pilot Light Assembly
Terminal Mount Bracket
Terminal Strip
Current Monitor
Part No
35095
34584
34767
29014-4
7347
29708
34388
34578
14063-1
8916
34384
35461
35094
34925-6
35460
Electrical Controls and Components
Time Clock Control: Part No. 34574
Item
1
2
3
4
5
6
7
8
9
10
11
12
13
Description
Control Box
Clear Lid
Control Box Latch Pivot
Control Box Latch
Fuse Holder
Control Box Mount Panel
Back Mount Panel
Front Panel
Time Clock Connector
3 Amp Fuse
Terminal Mount Bracket
Terminal Strip (12 position)
P & B Relay (240 VAC)
Part No
Item
30860-4
30859-1
30863
30862
24431
34852
34564
34565
35467
20472
34563
34925
34733
Floor Feeder Repair Parts Manual Volume II
14
15
16
17
18
19
20
21
22
23
24
25
26
27
65
Description
Part No
Dual Transformer (115/230
Mount Bracket
Battery Box Assembly
“AAA” Battery (1.5V)
Seal
Strapping
Terminal Block
Pilot Light
Toggle Switch
Toggle Switch
MOV
Nylon Hex Nut 1/4-20
Circuit Board
Pilot Light Assembly
V) 34571
34562
35095
34584
34767
29014-4
7270
29708
34388
34578
14063-1
8916
34384
35461
Electrical Control and Components
Breeder Feeder Control: Part No. 8700A
Item
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
Description
Part No.
Control Mounting Plate
Contactor
#10 Ext. Lock Washer
10-32 Hex Nut
10-32 Ground Screw
Cup Washer
Inner Box Mounting Plate
Inner Box Mounting Plate
Pipe Plug
Terminal Block
10-32 x 3/8” Pan Hd. Screw
15/32 Ext. Lock Washer
Toggle Switch
Momentary Switch
Ground Plate
Toggle Switch
Control Box
Mounting Adapter
Time Clock
Fuse Holder
1 Amp Fuse
Toggle Switch Boot
Shoulder Nut
Push Button Boot
26861
4283
305
4297
4968
5775
25293
25293
24458-2
7270
4418-4
24671
7767
5785
25483
6014
26269
25480
35401
24431
2935
13406
13407
20784
Floor Feeder Repair Parts Manual Volume II
66
Electrical Controls and Components
Meal-Time Control Panel: Part No. 7022A
Item
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
Description
Part No
Control Panel Mount. Plate 26797
Control Box
26799
Component Mounting Panel 26798
Contactor
4283
Mounting Track
4829
Current Monitor Circuit Panel7253
8-32 x 5/16” Pan Hd. Screw 801
10-32 x 1” Pan Hd. Screw 4418-1
Terminal Block
8848
Pipe Plug
24458-2
10-32 Ground Screw
4968
Cup Washer
5775
#10 Ext. Lock Washer
305
Fuse Holder
24431
1 Amp Fuse
2935
Pilot Light
7044
Toggle Switch
20135
15/32 Ext. Lock Washer
24671
Mounting Adapter
25480
Time Clock (230 V)
26795
Floor Feeder Repair Parts Manual Volume II
67
Electrical Controls and Components
Time Clock Control
Item
1
2
3
4
5
6
7
8
9
10
11
12
13
110 V.
(27250)
Part No.
Description
Control Box
Contactor
#10 Ext. Lock Washer
10-32 Hex Nut
Mounting Plate Support
10-32 Ground Screw
Cup Washer
Toggle Switch
15/32 Ext. Lock Washer
Mounting Adapter
Time Clock
Boot
Pilot Light
27131
4122
305
4297
27132
4968
5775
20135
5773
25480
27299
1739
7044
220 V.
(26230)
Part No.
27131
4122
305
4297
27132
4968
5775
20135
24671
25480
26795
1739
2058
The Time Clock Control (110 V.) may be ordered under Part No. 27250
The Time Clock Control (220 V.) may be ordered under Part No. 26230.
Note: This version of the 26230 Time Clock Control was discontinued on June 15, 1995.
Floor Feeder Repair Parts Manual Volume II
68
Electrical Controls and Components
Time Clock Control
Item
1
2
3
4
5
6
7
8
9
10
11
12
13
Description
Clear Box Lid
Time Clock Control Decal
Control Box Mount Panel
Control Box
208-240 V Contactor
Terminal Block
Toggle Switch
Pilot Light
Front Panel
Time Clock Assembly
Control Box Latch Pivot
Control Box Latch
Back Panel
Part No.
30859-1
2529-259
34852
30860-3
4283
26862
20135
7044
36112
34912
30863
30862
36111
The Time Clock Control (220 V.) may be ordered under Part No. 26230.
Note: This version of the 26230 Time Clock Control was released on June 15, 1995.
Floor Feeder Repair Parts Manual Volume II
69
Electrical Controls and Components
Tork Time Clocks
Part
Number
Time
Period
Timing
Motor
Tork
Model Number
1977
24 Hour
120 V. 60 Hz.
8001
3710
24 Hour
240 V. 60 Hz.
2-8001 or 8004
3711
24 Hour
240 V. 50 Hz.
2-8001
4719
48 Hour
220 V. 50 Hz.
2-8001-2D or 8005-2D
4816
12 Minute
120 V. 60 Hz.
12M8001
5781
48 Hour
240 V. 60 Hz.
8004-2D
Contactor Control
Item
1
2
3
4
5
6
7
8
9
Description
Part No
10-32 x 1/2” Binder Hd. M.S. 4303-4
Cup Washer
5775
#10 Star Washer
305
#10-32 Hex Nut
4297
Contactor Housing
4124
#8 Hex Washer Hd. S.M.S. 6054
#8-32 x 5/16” Rd. Hd. M.S. 801
Contactor (110 V)
4122
Contactor (230 V)
4283
Contactor Cover
4121
The complete 110 V Contactor Control may be
ordered under Part No. 4119.
The complete 220 V Contactor Control may be
ordered under Part No. 4283.
Floor Feeder Repair Parts Manual Volume II
70
Electrical Controls and Components
Contactor Control
Item
1
2
3
4
5
6
7
Description
Box and Cover
Mounting Plate Support
#10 Ext. Lock Washer
#10-32 Hex Screw
Cup Washer
Contactor (220 V)
Contactor (110 V0
#10-24 Pan Head Screw
Part No.
7368
24292
305
4968
5775
4283
4122
4418-3
The Contactor Box containing (1) 4283 Contactor
may be ordered under Part No. 24392-1.
The Contactor Box containing (2) 4283 Contactors
may be ordered under Part No. 24392-2.
The Contactor Box containing (1) 4122 Contactor
may be ordered under Part No. 24545-1.
The Contactor Box containing (2) 4122 Contactors
may be ordered under Part No. 24545-2.
Floor Feeder Repair Parts Manual Volume II
71
Electrical Controls and Components
Hopper Level Control: Part No. 2912
Item
Description
Part No.
1
2
3
4
5
6
High Differential Shield
Paddle Cover
Paddle
6-32 Hex Nut
SPDT Switch
Frame Weldment
24993
2708
2709
771
2702
2711
8
9
10
11
12
13
14
15
16
17
18
19
Fabric Retainer
Back
Mounting Bracket
Switch Bracket
Mounting Bracket Assembly
Cover
Handy Box
6-32 x 7/8” Screw
Grommet
Flat Washer
10-32 Crown Lock Nut
Spring
2705
2707
2703
24991
2911
711
1145
1921
24
2955-19
6963
24992
Floor Feeder Repair Parts Manual Volume II
72
Electrical Controls and Components
Hopper Level Control: Part No. 14550 & 27761 (International)
Item
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
----
Description
14550
Part No.
27761
Part No.
Gasket
Switch Box Cover
Switch Box
10-32 Hex Nut
#10 Lock Washer
Cup Washer
10-32 Stud
Paddle Shield
Switch Brace Bracket
Switch Frame Assembly
Paddle
Switch Frame Assembly
Diaphragm
High Differential Shield
Switch Bracket
Gasket
Spring
10-32 Lock Nut
Pin
Switch Insulation
SPDT Switch
Danger Decal
Mounting Bracket Assembly
1/2” Liquid Tight Connector
2-Terminal Block
6777
6776
24678
4297
305
5775
7007
24059
2703
14499
14519
14498
28157
7808
7068
6968-1
6972
6963
6775
1907-5
7069
2527-35
2911
23779
----
6777
6776
7841
------------24059
2703
14499
14519
14498
28157
7808
7068
6968-1
6972
6963
6775
1907-5
7069
2527-35
2911
---34925-2
Floor Feeder Repair Parts Manual Volume II
73
Floor Feeder Scale Systems and Components
Weigh Scale Template: Part No. 5798
Key
1
2
3
4
5
6
Description
Part No.
Rear Plate
Side Plate
Beam Box Leg Plate
Connector Plate
Center Plate
Front Plate
Floor Feeder Repair Parts Manual Volume II
74
5984
5988
5986
5985
5989
5987
Floor Feeder Scale Systems and Components
Weigh Scale Assembly
Item
1
2
3
4
5
6
7
8
9
10
Description
Lower Main Stand
Upper Main Stand Assembly
Left Main Lever Assembly
Right Main Lever Assembly
Steelyard Rod
Trip Loop
Transverse Lever Assembly
Shackle
Load Loop
Transverse Stand Assembly
Part No.
Complete 5,000 Lbs Bin Scale Assembly is Winslow
Part No. CT1819.
7A
9A
1AL
1AR
25
15
10A
19
18
21A
Floor Feeder Repair Parts Manual Volume II
Complete 8,000 Lbs Bin Scale Assembly is Winslow
Part No. CT6514.
The complete Bin Scale Components must be
ordered through:
Winslow Scale Company
25th and Haythorne, P.O. Box 1523
Terre Haute, IN 47808
Phone: 812/466-5265.
75
Floor Feeder Scale Systems and Components
Beam Box Assembly: Part No. 5790
Item
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
Description
Case Weldment
Over Center Clamp
10-24 P.M. Nut
10-24 x 3/8" Rd. Hd. M.S.
4-40 Hex Nut
Trig Loop
4-40 x 5/8" Rd. Hd. M.S.
Proximity Sensor
Liquid Tight Connector
Momentary Switch
Push Button Boot
Terminal Block
Terminal Box Decal
Switch Box Cover
Switch Mount Bracket
Water Tight Connector
Terminal Mount Box
Gasket
4-40 x 3/4" Rd. Hd. M.S.
Magnetic Actuator
Terminal Mount
Part No.
Item
5797
2536
135
1553
3511
7472
3510
6689
13477
5785
20784
7270
2529-326
6776
28247
23779
28597
6777
4143-2
5789
28599
Floor Feeder Repair Parts Manual Volume II
22
23
24
25
26
27
28
29
30
31
32
33
Description
3/8-16x3/4 HHCS
Pivot Bracket
3/8-16 Hex Nut
Weigh Beam Assembly
10-24x3/8 Truss Screw
Cover Weldment
Leg Support
Leg Weldment
Channel
Romex Connector
Resistor, 390 ohm
Mounting Cover
Part No.
2182
5803
1549
See Note Below
501
5799
5924
5793
7589
1317
1709-19
6956
Note: The applicable Weigh Beam Assembly must be ordered through:
Winslow Scale Company
25th and Haythorne, P.O. Box 1523
Terre Haute, IN 47808
Phone: 812/466-5265.
76
Floor Feeder Scale Systems and Components
5000# Weigh Beam Assembly: Part No. 9447*
Description
Part No.
Bearing
Pivot
Loop Assembly
Back Balance Assembly
Pivot
Poise
Weigh Beam
Face Plate
7
4
6
11
12
10
15
14
*The complete Weigh Beam Assembly must be ordered through:
Winslow Scale Company
25th and Haythorne, P.O. Box 1523
Terre Haute, IN 47808
Phone: 812/466-5265.
Floor Feeder Scale Systems and Components
8000# Weigh Beam Assembly: Part No. 6514*
Description
Weigh Beam
Main Poise
Aux. Poise
Back Balance Assembly
Loop Assembly
Part No.
1
2
3
4
5
*The complete Weigh Beam Assembly must be ordered through:
Winslow Scale Company
25th and Haythorne, P.O. Box 1523
Terre Haute, IN 47808
Phone: 812/466-5265.
Floor Feeder Repair Parts Manual Volume II
77
Floor Feeder Scale Systems and Components
Model 100 & Model 200 Digital Indicators
Model 100 Indicator
Description
Model 200 Indicator
Part No.
Description
Part No.
Model 100 Indicator w/Computer Interface 30210
Model 200 Indicator w/Computer Interface 30225
Model 100 Indicator w/Computer Interface
and Connection Box
30232
Model 200 Indicator w/Pulsed Output
34454
Model 200 Indicator w/Computer Interface
and Junction Control
30228
Not Shown
Cable for RS232 Port
Power Cable
10’ Data Cable
20 Milliampere Connector
Not Shown
Cable for RS232 Port
Power Cable
10’ Data Cable
20 Milliampere Connector
30189
30177
30194
30187
Connection Box: Part No. 30226
Floor Feeder Repair Parts Manual Volume II
78
30189
30177
30194
30187
Floor Feeder Scale Systems and Components
J-Boxes & Cable Sets
Description
J-Box
J-Box
J-Box
J-Box
J-Box
J-Box
Part No.
w/30’ Cord
w/50’ Cord
w/70’ Cord
w/90’ Cord
Assembly (no Plug)
Assembly
Not Shown
J-Box Extension Plug Kit (Plugs Only)
J-Box Extension Cable (Cable only)
30201*
30202*
30203*
30204*
30182
30235
30192
30190
*Includes Power Cable and Cord (as specified)
Note: J-Box Cables may be ordered separately. See
Miscellaneous Components and Cable Sets Parts
List on page 80.
J-Box Duplex Kit
Description
J-Box
J-Box
J-Box
J-Box
Floor Feeder Repair Parts Manual Volume II
79
Duplex
Duplex
Duplex
Duplex
Kit
Kit
Kit
Kit
w/30’
w/50’
w/70’
w/90’
Part No.
Cord
Cord
Cord
Cord
30207
36752
36753
36754
Floor Feeder Scale Systems and Components
Duplex J-Box
Description
Duplex J-Box w/50’ Cord
Duplex J-Box w/70’ Cord
Duplex J-Box w/90’ Cord
Miscellaneous Components and Cable Sets
Description
Part No.
J-Box Cable (30’)
J-Box Cable (50’)
J-Box Cable (70’)
J-Box Cable (90’)
J-Box Extension Kit (Plugs only, no Cable)
J-Box Extension Cable (Cable only)
J-Box Extension Cable Assembly
Cable for RS232 Port
Power Cable
10’ Data Cable
20 Milliampere Connector
“Y” Cable (2 female, 1A male Connector)
36690
36691
36692
36693
30192
30190
30188*
30189
30177
30194
30187
37692**
*Includes (1) male and (1) female Cannon Plug
**Used with Livestock Scales only
Floor Feeder Repair Parts Manual Volume II
80
Part No.
36687
36688
36689
Floor Feeder Scale Systems and Components
Junction Control: Part No. 25784
Item
1
2
3
4
5
6
7
8
9
10
Description
Part No.
Item
Control Box
29011
Terminal Block Bracket
30233
Grommet
8514
#10-32 x 3/8” Pan Hd. Screw 4418-3
Terminal Block
7270
#6-32 x 1/2” Pan Hd. Screw 4402-6
Scale Reset Terminal Decal 2526-318
Relay Socket
30234
Relay
30236
#10 External Lock Washer 305
Floor Feeder Repair Parts Manual Volume II
11
12
13
14
15
16
17
18
19
81
Description
#10-32 Ground Screw
Cup Washer
Momentary Switch
Grounding Plate
Push Button Boot
Warning Decal
Mounting Plate
Conduit Lock Washer
Liquid Tight Connector
Part No.
4968
5775
5785
30237
20784
2527-15
30143
3357
23779
Floor Feeder Scale Systems and Components
Junction Control w/Fill Option: Part No. 30240
Item
1
2
3
4
5
6
7
8
9
10
11
Description
Part No.
Item
Control Box
30238
Terminal Block Bracket
30233
Grommet
8514
#10-32 x 3/8” Pan Hd. Screw 4418-3
Terminal Block
7347
#6-32 x 1/2” Pan Hd. Screw 4402-6
Scale Reset Terminal Decal 2526-319
Relay Socket
30234
Relay
30236
#10 External Lock Washer 305
#10-32 Ground Screw
4968
Floor Feeder Repair Parts Manual Volume II
12
13
14
15
16
17
18
19
20
21
22
82
Description
Cup Washer
Momentary Switch
Grounding Plate
Push Button Boot
Warning Decal
Mounting Plate
Toggle Switch
Relay
Toggle Switch Boot
Conduit Lock Washer
Liquid Tight Connector
Part No.
5775
5785
30237
20784
2527-15
30143
20135
27051
1739
3357
23779
Floor Feeder Scale Systems and Components
Load Cells and Mount Kits
T.C. 15
Item
2
3
5*
Description
Top Plate
T.C. 15 Load Cell
Mount Kit for T.C. 15
Part No.
---30219
30176
*The Mount Kit does not include the Item #3.
T.C. 35 & 125
Item
1
2
3
4
5*
Description
3/4" x 6" Quick Pin
Top Plate
T.C. 35 Load Cell
T.C. 125 Load Cell
5/8" x 5" Quick Pin
Mount Kit for T.C. 35
Mount Kit for T.C. 125
Part No.
------30221
30222
---30216
30217
*The Mount Kit does not include the Item #3.
T.C. 180
Item
2
3
5*
Description
Part No.
Top Plate
T.C. 180 Load Cell
T.C. 180 Load Cell w/21’ cord
Mount Kit for T.C. 180
---30223
30224
30218
*The Mount Kit does not include the Item #3.
Floor Feeder Repair Parts Manual Volume II
83
Floor Feeder Scale Systems and Components
Load Cells and Mount Kits
C.T. 30K
Item
1
2
3
4
5
6
7
8
9
10
11
Description
C.T. 30 Load Cell
C.T. Mount Half
M16 x mm Hex Nut
M16 Lock Washer
Threaded Plate
Rubber Shim
Pin
Cotter Pin
M16 x 2 mm x 65 mm Nut
Welded Plate
Sealing Sponge Ring
Part No.
35018
-------------------------------
Note: Items 2 - 11 may be ordered as a Mount Kit for
C.T. 30 Scale under Part No. 35017.
6-Legged Bin Adapter Kit
Description
Beam Assembly
Power Supply
Part No.
30183
The 6-Legged Bin Adapter Kit, including (2) Beam
Assemblies and (1) Beam Assembly Hardware Kit,
may be ordered under Part No. 30208.
Scale Systems available (by weight):
5,000 Lbs.
12,000 Lbs.
48,000 Lbs. (7’ Bins)
48,000 Lbs. (9’ Bins)
60,000 Lbs.
60,000 Lbs.
80,000 Lbs.
90,000 Lbs.
120,000 Lbs.
30209
30211
30213
30212
30214
34580
34575
30215
35020
Item
Note: Scale Systems include the Junction Box (or
Duplex Kit), Load Cells and Mounts. The Digital
Floor Feeder Repair Parts Manual Volume II
1
2
3
4
-84
Description
Power
Power
Power
Power
Power
Part No.
Cord (220 V)
Supply (220 V)
Supply (includ. cord)
Supply (110 V)
Cord for Indicator
30682
30683
30200
30206
30177
Floor Feeder Scale Systems and Components
Livestock Scale Indicators
Description
Model
Model
Model
Model
Model
Model
100
111
210
115
116
215
Indicator
Indicator
Indicator
Indicator
Indicator
Indicator
Part No.
(2,000 lbs)
(907 kg)
(2,000 lbs/907 kg)
(6,000 lbs)
(2,721 kg)
(6,000 lbs/2,721 kg)
34435
34817
34581
34436
34818
34582
Notes:
Model 100 shown.
Mounting Bracket included with Indicator.
Livestock Scale Load Cells
Description
Part No.
2,000 lbs (907 kg) Load Cell (2 req.)
6,000 lbs (2,721 kg) Load Cell (2 req.)
Floor Feeder Repair Parts Manual Volume II
85
34437
34438
Floor Feeder Scale Systems and Components
Hopper Scales: Part No. 24176
Item
1
2
3
4
5
6
7
8
9
10
11
Description
Part No.
Switch Assembly
Counterbalance Weight
Sliding Weight
Beam Assembly
Eyebolt
Weight Washer
5# Weight Plate
Master Suspension Cable
3/6” Cable Clamp
Cable Plate
1/8” Cable Clamp
3/32” Stainless Steel Cable
Floor Feeder Repair Parts Manual Volume II
86
24171
24162
24163
24177
24175
2955-30
24164
---732
24172
14898
7130
Floor Feeder Scale Systems and Components
Hopper Scales Switch Assembly: Part No. 33653
Item
1
2
3
4
5
6
7
8
9
10
11
12*
13
Description
Part No.
Relay Assembly
Terminal Box
Box Cover
Gasket
Danger Decal
Momentary Switch
Push Button Boot
1/2” Conduit Locknut
Proximity Switch Assembly
Proximity Switch
Liquid Tight Connector
1/4” Vinyl Tubing
Liquid Tight Connector
Switch Mount Assembly
Scale Bar Guide
Switch Mount
24174
33654
6776
6777
2527-25
5785
20784
3357
33605
6689
23779
14454-7
23779
33655
33613
33615
*Item #12 is a component of Item #11.
Hopper Scales Switch Box Assembly: Part No. 14613
Item
1
2
3
4
5
6
Description
Box and Cover
Momentary Switch
Toggle Switch
Grounding Plate
Toggle Switch Boot
Push Button Boot
Floor Feeder Repair Parts Manual Volume II
Part No.
14611
5785
20135
14604
1739
20784
87
Floor Feeder Screener Components
WEIGH-MATIC® Model 90 Screener: Part No. 25432
Item
1
2
3
4
5***
6***
7***
8***
9
10
11
12
13*
14*
15**
16**
17**
18**
19**
20**
21**
--§
--
Description
Control Unit Head
Seal
Screener Body
Clamp
Screen
Extruded Plate
Anchor Tube
Screen Retainer
Lid Seal Gasket
Flexible Drop Tube
Drop Tube
Power Unit
Agitator
Driver Assembly
Top Channel
Corner Support
Support Channel
Foot (L.H.)
Support Channel Extension
“U” Bolt
Foot (R.H.)
Junction Box Assembly
Screener Cover
Part No.
25720
4873
25446
6183
7436
22084
5069
24796
5928
25702
6381
3259-52
25674
25705
25469
25470
25468
25467-1
35800
28874
25467-2
25694
25701
Floor Feeder Repair Parts Manual Volume II
*May be ordered as an assembly under Part No. 25704.
**May be ordered as an assembly under Part No. 25472.
***May be ordered as an assembly under Part No. 27426.
§Junction Box-not shown • See individual parts list on
page 89.
The entire WEIGH-MATIC Model 90 Screener including:
-25432 Screener (components shown),
-4347 upper boot,
-9301 lower boot,
-6942-25 auger,
-6293 10’ auger tubes,
-7357 90 degree elbows,
-9301 boot assembly,
-5790 Beam Box, and
-3259-52 power unit
may be ordered under Chore-Time Part No. 25790.
88
Floor Feeder Screener Components
WEIGH-MATIC® Model 90 Screener Control Unit
Item
1*
2*
3*
4*
5*
6*
7*
8*
9*
10*
11*
Description
Part No.
10-32 Lock Nut
Spring
Gasket
Paddle
Pin
Mounting Plate Assembly
Pilot Light Assembly
1/2" Liquid Tight Fitting
Switch Bracket
SPDT Actuator Switch
Switch Box
Item
6963
6972
6968-1
7896
6775
7908
7044
26980
7068
7114
25696
Description
Part No.
12
Drop
6091
13
Slide
5073
14
Body Assembly
24268
15* Gasket
6777
16* Switch Box Cover
6776
17
1/2" Flexible Conduit
26982-9
18
Water Tight Connector
23810
-Diaphragm Assembly
7900
*These items may be ordered as an assembly under
part no. 25697.
The complete Control Unit (including Driver Assembly and Junction Box Assembly) may be ordered
under part no. 25720.
Junction Box Assembly: Part No. 25694
Item
1
2
3
4
5
6
7
8
9
10
Floor Feeder Repair Parts Manual Volume II
89
Description
Part No.
Junction Box Mount
25692
Junction Box (including cover) 25693
Mounting Panel
25691
Toggle Switch
7767
Toggle Switch Boot
13406
Pilot Light
7044
Terminal Block
8848
10-32 Ground Screw
4968
10 ext. Lock Washer
305
Cup Washer
5775
Floor Feeder Screener Components
WEIGH-MATIC® Model 90 Screener Power Units
Screener Power Unit • 60 Hz.
Key
1
2
3
4
5
6
7
8
9
10
Description
Part No.
Motor--3/4 HP / 230V.
90 Degree Connector
Anti-Short Bushing
Pipe Plug
Magnetic Pipe Plug
"S" Hook
Pinion Assembly
Vent Plug
5/16-18x5/8" Hx Hd M S
Gearhead Assembly-348 RPM
5051
4228
6304
2755
30160
4270
5046
3523
4412-1
3261-7
Complete Power Units
3/4 HP, 348 RPM Power Unit
Screener Power Units • 50 Hz.
Key
1
2
3
4
5
6
7
8
9
10
Description
Part No.
Motor--3/4 HP, 3-Phs, 220/380 V,
Motor--3/4 HP, 1-Phs. 220/380 V,
90 Degree Connector
Anti-Short Bushing
Pipe Plug
Magnetic Pipe Plug
"S" Hook
Pinion Assembly- for 1 HP Motors
Vent Plug
5/16-18x5/8" Hx Hd M S
Gearhead Assembly-425 RPM
28034
6305
4288
6304
2755
30160
4270
5046
3523
4412-1
3261-10
Part No.
3259-52
Complete Power Units
3/4 HP, 348 RPM, 3-Phs, Power Unit
3/4 HP, 348 RPM, 1-Phs, Power Unit
Floor Feeder Repair Parts Manual Volume II
90
Part No.
3259-104
3259-88
Floor Feeder Screener Components
Model 90 Bin Fill Cap Kit: Part No. 25806
Model 75 Bin Fill Cap Kit: Part No. 6563
Item
1
2
3
4
5
6
7
8
Description
Part No.
Lid Ass’y
Tube Anchor Weldment (Mod. 90)
Tube Anchor Weldment (Mod. 75)
Over Center Clamp
Tube Clamp (Mod. 90)
Tube Clamp (Mod. 75)
Tube Insert (Mod. 75 steel systems)
Sponge Tubing
Driver Assembly (Mod. 90)
Driver Assembly (Mod. 75)
Cover Weldment
Floor Feeder Repair Parts Manual Volume II
91
7689
5069
6518
2536
6721-1
6515-1
6524
5928
6861
6862
7690
Floor Feeder Miscellaneous Components
Hens Only Grill (for Pan Breeder Feeder)
Part No.
Description
Width “A”
Height “B”
Height “C”
24487
Pan Shield
1.688” (42.86 mm)
2.750” (69.99 mm)
3.300” (83.82 mm)
30244
Pan Shield
1.732” (44.00 mm)
2.750” (69.99 mm)
----
30246
Pan Shield
1.811” (46.00 mm)
2.250” (57.15 mm)
2.500” (63.50 mm)
Program Gauge: Part No. 14251
2
3
4
1
Item
1
2
3
4
Control Shield: Part No. 24887
Description
Level Glass
Gauge Clamp Weldment
Pointer Assembly
Indexing Gauge Decal
Part No.
4853
14523
4852
2529-207
Floor Feeder Repair Parts Manual Volume II
92
Floor Feeder Miscellaneous Components
Winch Control: Part No. 34812
Key
1
2
3
4
5
6
7
8
9
10
Description
Switch Lock
Toggle Switch (DPDT)
Clear Lid
Control Box Latch
Fuse Holder
Relay
4 PDT Relay (230 V)
Terminal Mount Bracket
Back Mount
Control Box Mount Panel
Part No.
Key
34984
20135
30859-1
30862
24431
5574
34910
34563
34383
34852
11
12
13
14
15
16
17
18
19
20
Floor Feeder Repair Parts Manual Volume II
93
Description
Momentary Switch
Toggle Switch
Pilot Light
Winch Control Panel
Time Clock
Track Mounting Socket
Terminal Strip
Control Box Latch Pivot
10 Amp Fuse
Control Box
Part No.
5785
6014
7044
34382
34912
34909
34925
308 63
7350
34985
Floor Feeder Miscellaneous Components
Winchable Feed Level Tube Components
Key
1*
2*
3*
4*
5*
6*
7*
8*
9*
10
11
12
13
14
15
16
17
Description
Part No.
Crank
Spring Pin
Drum
1/4-20 x 1/2” Bolt
1/4-20 Locknut
1/4-20 Jam Nut
Stop
Spring
Ratchet Body
Cable Assembly
Tube Clamp
Spring
Cable Clamp
3/16” Pop Rivet
Tube Guide
Feed Level Tube
3/32” Galvanized Cable
Optional Stain. Steel Cable
14877
14881-1
14678
1487
1269
20826
14677
1543
14675
14278
24302
14898
4629
24113
14280
4973
7130
*These items may be ordered as a Feed Tube Winch
Assembly under Chore-Time Part No. 14680).
Floor Feeder Repair Parts Manual Volume II
94
Floor Feeder Repair Parts Manual Volume II
95
Made to work.
Built to last.™
Contact your nearby Chore-Time distributor or representative for additional parts and information.
Chore-Time Equipment, A Division of CTB, Inc.
P.O. Box 2000, Milford, Indiana 46542-2000 U.S.A.
Printed in the U.S.A.
Phone: 219-658-4101 • E-Mail: ctb@ctbinc.com