MAKE: FREIGHTLINER
MODEL: M2-112
GENERAL APPLICATION INFORMATION
TRACTOR/TRAILER CONFIGURATION
DOMICILED, USA 50 STATES (INCLUDING CALIFORNIA AND CARB OPT-IN STATES)
MAXIMUM 8% EXPECTED GRADE
EXPECTED FRONT AXLE(S) LOAD
EXPECTED REAR DRIVE AXLE(S) LOAD
EXPECTED GROSS VEHICLE WEIGHT CAPACITY
EXPECTED GROSS COMBINATION WEIGHT
MAXIMUM GVW & AXLE SYSTEM CAPACITIES
CALC'D MAX CAPACITY FRONT AXLE(S)TOTAL
CALC'D MAX CAPACITY DRIVE AXLE(S) TOTAL
RATED MAXIMUM VEHICLE CAPACITY - GVWR
BASE MODEL
M2 112 CONVENTIONAL CHASSIS
FREIGHTLINER LEVEL I WARRANTY
SET BACK AXLE - TRACTOR
NO TRUCK PROVISION PACKAGE
LH PRIMARY STEERING LOCATION
ENGINE
CUM ISL G 320 HP @ 2000 RPM, 2200 GOV, N-GAS, 1000 LB/FT @ 1300 RPM
2007 EPA/CARB EMISSION CERTIFICATION
2008 CARB EMISSION CERTIFICATION - CLEAN
2010 EPA/CARB EMISSION COMPLIANT
IDLE (INCLUDES 6X4 INCH LABEL ON LEFT SIDE OF HOOD)
ENGINE AFTERTREATMENT DEVICE
CUMMINS ISL-G CM2180A J1939/J1587 ENGINE CONTROL UNIT
ENGINE EQUIPMENT
ENGINE MOUNTED OIL CHECK AND FILL
ONE PIECE VALVE COVER
SIDE OF HOOD AIR INTAKE WITH FIREWALL MOUNTED DONALDSON AIR CLEANER
DR 12V 160 AMP 36-SI BRUSHLESS QUADRAMOUNT PAD ALTERNATOR WITH
REMOTE BATTERY VOLT SENSE
(2) ALLIANCE MODEL 1131, GROUP 31, 12 VOLT MAINTENANCE FREE 1850 CCA
THREADED STUD BATTERIES
BATTERY BOX FRAME MOUNTED
SINGLE BATTERY BOX FRAME MOUNTED RH SIDE UNDER CAB
FRAME GROUND RETURN FOR BATTERY CABLES
LOCATE RAIL-TO-RAIL GND ON 561 XMBR
NON-POLISHED BATTERY BOX COVER
CUMMINS ENCORE ENGINE ELECTRONICS
NO CLUTCH
CUMMINS 18.7 CFM COMPRESSOR WITH INTERNAL SAFETY VALVE
STANDARD AIR COMPRESSOR GOVERNOR
TEFLON COMPRESSOR DISCHARGE LINE
ELECTRONIC ENGINE INTEGRAL SHUTDOWN PROTECTION SYSTEM
SINGLE HORIZONTAL MUFFLER WITH HORIZONTAL TAILPIPE EXHAUST, RH
MOUNTED
STANDARD EXHAUST SYSTEM LENGTH
12000 LBS
34000 LBS
46000 LBS
80000 LBS
12000 LBS
40000 LBS
52000 LBS

RH HORIZONTAL MUFFLER MOUNTING
RH STANDARD HORIZONTAL TAILPIPE
HORTON DRIVEMASTER ON/OFF FAN DRIVE
AUTOMATIC FAN CONTROL WITHOUT DASH SWITCH, NON ENGINE MOUNTED
CUMMINS SUPPLIED FLEETGUARD COALESCING FILTER (LOW PRESSURE) CNG
COMBINATION FULL FLOW/BYPASS OIL FILTER
1300 SQUARE INCH ALUMINUM RADIATOR
REMOTE MOUNTED SURGE TANK
ANTIFREEZE TO -34F, FLEETGUARD 'ES' EXTENDED SERVICE COOLANT
GATES BLUE STRIPE COOLANT HOSES OR EQUIVALENT
CONSTANT TENSION HOSE CLAMPS FOR COOLANT HOSES
ALUMINUM FLYWHEEL HOUSING
DELCO 12V 38MT HD STARTER WITH INTEGRATED MAGNETIC SWITCH
TRANSMISSION & EQUIPMENT
ALLISON 3000 HS AUTOMATIC TRANSMISSION
PUSH BUTTON ELECTRONIC SHIFT CONTROL, DASH MOUNTED
WATER TO OIL TRANSMISSION COOLER, IN RADIATOR END TANK
TRANSMISSION OIL CHECK AND FILL WITH ELECTRONIC OIL LEVEL CHECK
MAGNETIC PLUGS, ENGINE DRAIN, TRANSMISSION DRAIN, AXLE(S) FILL AND
SYNTHETIC TRANSMISSION FLUID (TES-295 COMPLIANT)
FRONT AXLE, SUSPENSION & EQUIPMENT
SINGLE FRONT AXLE 12,000# CAPACITY
MERITOR 15X4 Q+ CAM FRONT BRAKES
NON-ASBESTOS FRONT BRAKE LINING
CONMET CAST IRON FRONT BRAKE DRUMS
CHICAGO RAWHIDE SCOTSEAL PLUS XL FRONT OIL SEALS
STEMCO ALUMINUM VENTED FRONT HUB CAPS WITH WINDOW AND CENTER AND
SIDE PLUGS - OIL
STANDARD SPINDLE NUTS FOR ALL AXLES
MERITOR AUTOMATIC FRONT SLACK ADJUSTERS
TRW THP-60 POWER STEERING
POWER STEERING PUMP
2 QUART SEE THROUGH POWER STEERING RESERVOIR
SYNTHETIC 75W-90 FRONT AXLE LUBE
12,000# TAPERLEAF FRONT SUSPENSION
MAINTENANCE FREE RUBBER BUSHINGS - FRONT
FRONT SHOCK ABSORBERS
REAR AXLE, SUSPENSION & EQUIPMENT
RT-40-145 40,000# R-SERIES TANDEM REAR AXLE
6.14 REAR AXLE RATIO
IRON REAR AXLE CARRIER WITH OPTIONAL HEAVY DUTY AXLE HOUSING
17T MERITOR MAIN DRIVELINE WITH HALF ROUND YOKES
17T MERITOR INTERAXLE DRIVELINE WITH HALF ROUND YOKES
(1) INTERAXLE LOCK CONTROL VALVE FOR TANDEM OR TRIDEM DRIVE AXLES
BLINKING LAMP WITH EACH MODE SWITCH, INTERAXLE UNLOCK DEFAULT WITH
IGNITION OFF
MERITOR 16.5X7 Q+ STAMPED SPIDER CAM REAR BRAKES, DOUBLE ANCHOR,
FABRICATED SHOES
NON-ASBESTOS REAR BRAKE LINING
BRAKE CAMS AND CHAMBERS ON FORWARD SIDE OF DRIVE AXLE(S) WITH
AUXILIARY SUPPORT BRACKETS

CONMET CAST IRON REAR BRAKE DRUMS
CHICAGO RAWHIDE SCOTSEAL PLUS XL REAR OIL SEALS
HALDEX GOLDSEAL LONGSTROKE 2-DRIVE AXLES
SPRING PARKING CHAMBERS
MERITOR AUTOMATIC REAR SLACK ADJUSTERS
SYNTHETIC 75W-90 REAR AXLE LUBE
AIRLINER 40,000# REAR SUSPENSION
AIRLINER HIGH POSITION RIDE HEIGHT
STANDARD U-BOLT PAD
51 INCH AXLE SPACING
MANUAL DUMP VALVE FOR AIR SUSPENSION WITH INDICATOR LIGHT AND GAUGE
SINGLE AIR REAR SUSPENSION LEVELING VALVE
TRANSVERSE CONTROL RODS
REAR SHOCK ABSORBERS - TWO AXLES (TANDEM) (AIR RIDE SUSPENSION)
BRAKE SYSTEM
AIR BRAKE PACKAGE
WABCO 4S/4M ABS WITH TRACTION CONTROL
REINFORCED NYLON, FABRIC BRAID AND WIRE
BRAID CHASSIS AIR LINES
FIBER BRAID PARKING BRAKE HOSE
STANDARD BRAKE SYSTEM VALVES
RELAY VALVE WITH 5-8 PSI CRACK PRESSURE,
BW AD-IS (DRM) BRAKE LINE AIR DRYER WITH SHIELD, HEATER AND INTEGRAL
RESERVOIR
AIR DRYER RESERVOIR MOUNTED
STEEL AIR BRAKE RESERVOIRS MOUNTED IN
CAB ENTRY STEPS WHEN POSSIBLE
PULL CABLES ON ALL AIR RESERVOIR(S)
15 FOOT COILED TRAILER AIR HOSE WITH 12 INCH TRACTOR, 12 INCH TRAILER
LEADS
18 INCH STAINLESS STEEL SLIDE BAR WITH SPRING TYPE TRAILER AIR HOSE
HANGER
COMBINATION DUMMY GLAD HANDS AND LIGHT PLUG HOLDER
PRIMARY CONNECTOR/RECEPTACLE CENTER PIN
POWERED THROUGH IGNITION
SAE J560 7-WAY PRIMARY TRAILER CABLE RECEPTACLE BRACKET MOUNTED LH
DECK BACK OF CAB
UPGRADED CHASSIS MULTIPLEXING UNIT
UPGRADED BULKHEAD MULTIPLEXING UNIT
SUPPLEMENTAL ISO 3731 7-WAY RECEPTACLE LOCATED WITH PRIMARY
RECEPTACLE
15 FOOT DETACHABLE COILED PRIMARY TRAILER ELECTRICAL CABLE WITH SAE
J560 CONNECT OR WITH 12 INCH TRACTOR, 12 INCH TRAILER LEADS
FRAME & WHEELBASE
4625MM (182 INCH) WHEELBASE
11/32X3-1/2X10-3/16 INCH STEEL FRAME (8.73MMX258.8MM/0.344X10.19 INCH)
120KSI
NO FRONT FRAME EXTENSION
1425MM (56 INCH) REAR FRAME OVERHANG
FLANGED TAPERED END OF FRAME
FRONT CLOSING CROSSMEMBER

STANDARD WEIGHT ENGINE CROSSMEMBER
STANDARD MIDSHIP #1 CROSSMEMBER(S)
UNDERSLUNG CROSSMEMBER
STANDARD SUSPENSION CROSSMEMBER
INVERTED U TRACTOR CROSSMEMBER
CHASSIS EQUIPMENT
LH BACK OF CAB ACCESS
28 INCH (700MM) DECK PLATE FLUSH MOUNTED BETWEEN RAILS
THREE-PIECE 14 INCH CHROMED STEEL BUMPER WITH COLLAPSIBLE ENDS
REMOVABLE FRONT TOW HOOKS STORED ON CHASSIS FRAME
BUMPER MOUNTING FOR SINGLE LICENSE PLATE
BETTS B-25 PAINTED MUDFLAP BRACKETS
BLACK MUDFLAPS
HUCK-SPIN ROUND COLLAR CHASSIS FASTENERS EXCLUDING FIFTH WHEEL
PLASTIC QUARTER FENDERS WITHOUT LOGO
FIFTH WHEEL & EQUIPMENT
HOLLAND FW35 ILS 36.0 INCH AIR SLIDE FIFTH WHEEL - 2 INCH SLIDE
FIFTH WHEEL 610MM (24.0 INCHES) AHEAD OF SUSPENSION CENTERLINE
219MM (8.62 INCH) FIFTH WHEEL HEIGHT
CALC'D UNLADEN 5TH WHEEL HEIGHT +/-0.5"
OUTBOARD ANGLE - FIFTH WHEEL MOUNTING
DASH MOUNTED CONTROL VALVE AND PLUMBING FOR FIFTH WHEEL
LH FIFTH WHEEL RELEASE
FUEL TANK(S) & EQUIPMENT
150 GALLON CHART LNG STAINLESS
STEEL FUEL TANK WITH VALVES - LH
26 INCH DIAMETER FUEL TANK(S)
PLAIN ALUMINUM/PAINTED STEEL FUEL/HYDRAULIC TANK(S) WITH PAINTED
FUEL TANK(S) FORWARD
PLAIN STEP FINISH
CNG/LNG PARKER HANNIFIN TYPE LH FILLER
RECEPTACLE AND DUST CAP
LNG FUEL HEATER/VAPORIZER
SINGLE LNG FUEL LINE WITH IN-LINE SOLENOID SHUTOFF VALVE AND PRESSURE
REGULATOR
LNG ALL STAINLESS STEEL HOSE AND CNG TEFLON HOSE WITH STAINLESS
STEEL WIRE BRAID JACKET
TIRES
47.191 IN
CONTINENTAL HSR 275/80R22.5 16 PLY RADIAL FRONT TIRES
CONTINENTAL HSR 275/80R22.5 16 PLY RADIAL REAR TIRES
HUBS
CONMET PRE-SET BEARING IRON FRONT HUBS
CONMET PRE-SET BEARING IRON REAR HUBS
WHEELS
ACCURIDE ACCU-LITE 50408 22.5X8.25 10-HUB PILOT 2-HAND STEEL DISC FRONT
WHEELS
ACCURIDE ACCU-LITE 50408 22.5X8.25 10-HUB PILOT 2-HAND STEEL DISC REAR
WHEELS
CAB EXTERIOR
112 INCH BBC FLAT ROOF ALUMINUM CONVENTIONAL CAB
LH CAB DOOR(S) WITH 70 DEGREE DOOR STOP

AIR CAB MOUNTS
NONREMOVABLE BUGSCREEN MOUNTED BEHIND GRILLE
LH AND RH GRAB HANDLES
HOOD MOUNTED CHROMED PLASTIC GRILLE
FIBERGLASS HOOD
CHROMED HOOD MOUNTED AIR INTAKE GRILLE
DUAL 26 INCH RECTANGULAR POLISHED ALUMINUM AIR HORNS ROOF MOUNTED
SINGLE ELECTRIC HORN
DUAL HORN SHIELDS
DOOR LOCKS AND IGNITION SWITCH KEYED THE SAME
REAR LICENSE PLATE MOUNT END OF FRAME INTEGRAL HEADLIGHT/MARKER
ASSEMBLY WITH CHROME BEZEL
FREIGHTLINER LED AERODYNAMIC MARKER LIGHTS
FREIGHTLINER LED FLANGE MOUNTED STOP/TAIL/TURN LIGHTS WITH SEPARATE
INCANDESCENT
BACKUP LIGHTS
STANDARD FRONT TURN SIGNAL LAMPS
(1) SWIVEL UTILITY LIGHT ROOF MOUNTED
DUAL WEST COAST BRIGHT FINISH MIRRORS
DOOR MOUNTED MIRRORS
102 INCH EQUIPMENT WIDTH
LH AND RH 8" BRIGHT FINISH CONVEX MIRROR
S MOUNTED UNDER PRIMARY MIRRORS
RH DOWN VIEW MIRROR
RH SURE PLUS 8" BRIGHT FINISH FENDER MOUNTED CONVEX MIRROR WITH
BRACKET
STANDARD SIDE/REAR REFLECTORS
REAR REFLECTIVE DEVICE
COMPOSITE EXTERIOR SUN VISOR
63X14 INCH TINTED REAR WINDOW
TINTED DOOR GLASS LH AND RH WITH TINTED
OPERATING WING WINDOWS
MANUAL DOOR WINDOW REGULATORS
TINTED WINDSHIELD
8 LITER WINDSHIELD WASHER RESERVOIR, CAB MOUNTED, WITHOUT FLUID
LEVEL INDICATOR
CAB INTERIOR
OPAL GRAY VINYL INTERIOR
M2 INTERIOR CONVENIENCE PACKAGE
MOLDED DOOR PANEL WITH UPPER VINYL INSERTS
MOLDED DOOR PANEL WITH UPPER VINYL INSERTS
BLACK MATS WITH SINGLE INSULATION
DASH MOUNTED ASH TRAYS AND LIGHTER
FORWARD ROOF MOUNTED CONSOLE WITH UPPER STORAGE COMPARTMENTS
WITHOUT NETTING
CENTER STORAGE CONSOLE MOUNTED ON BACKWALL
(2) CUP HOLDERS LH AND RH DASH
GRAY/CHARCOAL WING DASH
2-1/2 LB. FIRE EXTINGUISHER
METHANE DETECTION SYSTEM WITH (1) SENSOR IN CAB AND (1) SENSOR IN
ENGINE COMPARTMENT

HEATER, DEFROSTER AND AIR CONDITIONER
STANDARD HVAC DUCTING
MAIN HVAC CONTROLS WITH RECIRCULATION SWITCH
STANDARD PLUMBING WITH SHUTOFF VALVES
SANDEN HEAVY DUTY AIR CONDITIONER COMPRESSOR
RADIATOR MOUNTED AIR CONDITIONER CONDENSER
BINARY CONTROL, R-134A
CAB INSULATION
SOLID-STATE CIRCUIT PROTECTION AND FUSES
12V NEGATIVE GROUND ELECTRICAL SYSTEM
DOME DOOR ACTIVATED LH AND RH, DUAL READING LIGHTS, FORWARD CAB
CAB DOOR LATCHES WITH MANUAL DOOR LOCKS
(1) 12 VOLT POWER SUPPLY IN DASH
TRIANGULAR REFLECTORS WITHOUT FLARES
NATIONAL 2000 SERIES HIGH BACK AIR SUSPENSION DRIVER SEAT WITH ACTIVE
AIR LUMBAR SUPPORT
HIGH BACK NON SUSPENSION PASSENGER SEAT
BLACK SUSPENSION COVER FOR AIR DRIVER SEAT
DUAL DRIVER SEAT ARMRESTS, NO PASSENGER SEAT ARMRESTS
LH AND RH INTEGRAL DOOR PANEL ARMRESTS
BLACK MORDURA CLOTH DRIVER SEAT COVER
BLACK MORDURA CLOTH PASSENGER SEAT COVER
3 POINT FIXED D-RING RETRACTOR DRIVER AND PASSENGER SEAT BELTS
ADJUSTABLE TILT AND TELESCOPING STEERING COLUMN
4-SPOKE 18 INCH (450MM) STEERING WHEEL
DRIVER AND PASSENGER INTERIOR SUN VISORS
CONTROLS & INSTRUMENTS
BLACK GAUGE BEZELS
WOODGRAIN DRIVER INSTRUMENT PANEL
WOODGRAIN CENTER INSTRUMENT PANEL
LOW AIR PRESSURE LIGHT AND BUZZER
2 INCH PRIMARY AND SECONDARY AIR PRESSURE GAUGES
DASH MOUNTED AIR RESTRICTION INDICATOR WITH GRADUATIONS
PRECO 1040 87 DB TO 112 DB AUTOMATIC SELF-ADJUSTING BACKUP ALARM
KEY OPERATED IGNITION SWITCH AND INTEGRAL START POSITION; 4 POSITION
OFF/RUN/START/ACCESSORY
ODOMETER/TRIP/HOUR/DIAGNOSTIC/VOLTAGE DISPLAY: 1X7 CHARACTER, 26
WARNING LAMPS, DATA LINKED, ICU3
DIAGNOSTIC INTERFACE CONNECTOR, 9 PIN, SAE J1587/1708/1939, LOCATED
BELOW DASH
2 INCH ELECTRIC FUEL GAUGE
PROGRAMMABLE RPM CONTROL - ELECTRONIC ENGINE
ELECTRICAL ENGINE COOLANT TEMPERATURE GAUGE
TRANSMISSION OIL TEMPERATURE INDICATOR LIGHT
ENGINE AND TRIP HOUR METERS INTEGRAL WITHIN DRIVER DISPLAY
ELECTRIC ENGINE OIL PRESSURE GAUGE
AM/FM/WB RADIO
(2) RADIO SPEAKERS IN CAB
AM/FM ANTENNA MOUNTED ON FORWARD LH ROOF ELECTRONIC MPH
SPEEDOMETER WITH SECONDARY KPH SCALE, WITHOUT ODOMETER
STANDARD VEHICLE SPEED SENSOR

ELECTRONIC 3000 RPM TACHOMETER
IGNITION SWITCH CONTROLLED ENGINE STOP
BW TRACTOR PROTECTION VALVE
TRAILER HAND CONTROL BRAKE VALVE
DIGITAL VOLTAGE DISPLAY INTEGRAL WITH DRIVER DISPLAY
SINGLE ELECTRIC WINDSHIELD WIPER MOTOR WITH DELAY
MARKER LIGHT/HEADLIGHT SWITCH WITH SEPARATE INTERRUPTER FOR
CLEARANCE LIGHTS
TWO VALVE PARKING BRAKE SYSTEM WITH WARNING INDICATOR
SELF CANCELING TURN SIGNAL SWITCH WITH DIMMER, WASHER/WIPER AND
HAZARD IN HANDLE
INTEGRAL ELECTRONIC TURN SIGNAL FLASHER WITH HAZARD LAMPS
OVERRIDING STOP LAMPS
PAINT
PAINT: ONE SOLID COLOR
CAB COLOR A: N0006EA WHITE ELITE SS
BLACK, HIGH SOLIDS POLYURETHANE CHASSIS
VENDOR WHITE FRONT WHEELS/RIMS
VENDOR WHITE REAR WHEELS/RIMS
SUNVISOR PAINTED SAME AS CAB COLOR A
WARRANTY
TOWING EXTENDED/ROADSIDE SERVICE WARRANTY, 2 YEAR/UNLIMITED
BASIC VEHICLE WARRANTY, 2 YEAR/UNLIMITED MILEAGE
ENGINE WARRANTY - CUMMINS-WESTPORT PROTECTION PLAN II, 5 YEARS /
150,000 MILES
BATTERIES WARRANTY, 1 YEAR / 100,000 MILES
FRAME AND CROSSMEMBER WARRANTY, 6 YEARS / 750,000 MILES
TRANSMISSION WARRANTY, 3 YEARS / UNLIMTED MILEAGE