LIGHTING • ELECTRICAL SYSTEM
INDEX
LIGHTING and ELECTRICAL SYSTEM
Concorde Batteries ........................................... 255
Lights and Lenses............................................. 261
Anti-Collision Systems, Strobes, Beacons ......... 262
Power Supplies ................................................ 266
Whelen Installation Packages .......................... 267
Interior and Cockpit Lighting ........................... 267
Whelen Parts – Exploded Views ...................... 268
Solenoids ......................................................... 269
Concorde Batteries
Valve Regulated Sealed Lead Acid Batteries
• Redesigned for more power
• Aircraft type terminals
• Fully sealed for aerobatic applications
Part #
Volt
Amp/Hr
Ipr@ 23°C/74°F
Length
Width
Height
Weight (lbs)
Price
RG-25
12V
22AH
508A
7.50
4.97
6.81
23
$218.78
RG-35A
12V
29AH
898A
9.58
4.97
6.83
31
$278.98
RG-24-11M
24V
11AH
504A
7.90
7.31
6.75
26.5
$541.98
High Capacity Extra Cranking Power
RG-25XC
12V
24AH
597A
7.50
4.97
6.81
25
$263.18
RG-35AXC
12V
33AH
1096A
9.58
4.97
6.83
33
$297.75
24-volt Batteries
• Limited 12-month warranty on 24-volt batteries
Part #
RG-24-12
(CB-24-11)
RG-24-11M
(CB-24-11M)
5-hour
Capacity
Cold Crank
Emergency
Capacity
Length
Width
Height
Weight (in lbs)
Price
17AH
190A
13A
7.38
7.31
6.46
27
CALL
17AH
190A
16A
7.38
7.31
6.75
28
$541.98
M = manifold vented
Concorde 24-volt Platinum Series Battery
Part #
RG-24-15
(CB-24-11XC)
Rated
Capacity
Length
Width
Height
Weight
(in lbs)
Price
15AH
7.38
7.31
6.33
31
$558.78
Battery
Temperature
Peak Power
Amperes
Power Rating
Amperes
23°C
1064
643
-18°C
684
437
-30°C
533
310
Price and availability subject to change without notice • Shop online at www.univair.com
255
LIGHTING • ELECTRICAL SYSTEM
24-volt Batteries Commuter Series
• Limited 12-month warranty on 24-volt batteries
• “E” indicates an Elcon quick-disconnect which mates with an Elcon part number BD6-3 and BD13-1 quick-disconnect plug in the aircraft. Cannon-type connectors are available.
Part #
CB-24-380E
RG-390E (CB-24-390E)
RG-400E/13 (CB-24-40E)
5-hour Capacity
45AH
25AH
14AH
Emergency
Capacity
79A
42A
22A
Cold Crank
505A
345A
190A
Length
11.87
9.81
7.75
Width
9.84
9.90
7.63
Height
10.28
8.84
7.40
Weight
(in lbs)
80
55
34
Price
NLA
NLA
NLA
General Aviation 12-volt and 24-volt Batteries
• FAA/PMA approved or approval pending Valve Regulated, Sealed Lead Acid Battery (SLAB)
• These batteries are shipped serviced and charged
• Size varies slightly from the obsolete part numbers and modifications may be necessary for retrofit; installation may require field approval
Battery Type
12-volt
12-volt
12-volt
12-volt
24-volt
Part #
RG-25
RG-25XC
RG-35A
RG-35AXC
RG-24-11M
Ampere Hour
22
24
29
33
11
Shipping Weight (lbs)
23
25
31
33
26.5
Price
$218.78
$263.18
$278.98
$297.75
$541.98
Concorde Battery Prices
RG-24-12 (CB-24-11) ......................................................................... CALL
RG-24-11M (CB-24-11M) ..............................................................$541.98
CB-24-380E (CB-24-380C)....................................................................NLA
CB-25 (CB-12-9) ...................................................................................NLA
CB-25VP ...............................................................................................NLA
CB-25XC ...............................................................................................NLA
CB-25XCVP ...........................................................................................NLA
CB-2X4200 ...........................................................................................NLA
CB-35AVP (CB-12-11, CB-35) ..............................................................NLA
CB-35AXCVP .........................................................................................NLA
CBA4-3Q..........................................................................................$16.60
CBA6-2Q..........................................................................................$11.25
M83769/2-1.........................................................................................NLA
M83769/3-1.........................................................................................NLA
M83769/7-1.........................................................................................NLA
RG-24-11M .................................................................................. $541.98
RG-24-15 (CB-24-11XC) ............................................................... $558.78
RG-24-20 ..................................................................................... $698.78
RG-25 (CB-12-9M, CB-25M, GP-1234).......................................... $218.78
RG-25XC ....................................................................................... $263.18
RG-35A (RG-35, CB-12-11M, CB-35M) ......................................... $278.98
RG-35AXC ..................................................................................... $297.75
RG-390E (CB-24-39C, -390C, -390E) ................................................... NLA
RG-400E/13 (CB-24-40, -40E) ............................................................ NLA
CBA6-2Q......................................................................................... $11.25
CBA4-3Q......................................................................................... $16.60
See chart on next page for aircraft applicability
Concorde Battery Acid Solution
• 1.285 specific gravity
2-quart pack .......................................................................................................................... CBA6-2Q ............... $11.25
3-quart pack .......................................................................................................................... CBA4-3Q ............... $16.60
256
Price and availability subject to change without notice • Univair’s Toll Free Sales: 1-888-433-5433
LIGHTING • ELECTRICAL SYSTEM
Price chart on page 256
Aircraft Application Guide for Concorde Batteries
Note: The replacement data listed on this page is intended as a suggested reference guide only. Some installations may vary and require airframe or battery box modifications.
Local field approval, log book entry, or STC may be required. This is not a complete listing of all available applications.
Aircraft Make
Aeronca
(see American
Champion)
Aircraft Model
LA
LB
0-58B, 60-TF
7-BC
7-CC
11-AC
7EC, 15-AC Chief
L-16B Champion
11-CC Super Chief
KF Series 50, 65
American
Champion
7EC, 7ECA, 7FC, 7GCAA, 7KCAB,
7GCBC, 7JC
Citabria 7ACA, 7EC, 7ECA, 7FC, 7GC,
7GCBC, 7HC, 7JC, 7KC, 7KCAB, 402
8GCBC, 8KCAB
All models prior to 1959
Aviat
Aviat Model A-1 and Aviat Pitts
Models S-1S, S-1T, S-2, S-2A, S-2S,
S-2B
CBC Part #
CB35A, RG-35A,
RG-35AXC
CB35A, RG-35A,
RG-35AXC
CB35A, RG-35A,
RG-35AXC
CB35A, RG-35A,
RG-35AXC
CB35A, RG-35A,
RG-35AXC
CB35A, RG-35A,
RG-35AXC
CB35A, RG-35A,
RG-35AXC
CB25, RG-25,
RG-25XC
CB25, RG-25,
RG-25XC
CB25, RG-25,
RG-25XC
CB25, RG-25,
RG-25XC
CB35A, RG-35A,
RG-35AXC
CB25, RG-25,
RG-25XC
CB25, RG-25,
RG-25XC
CB25, RG-25,
RG-25XC
CB35A, RG-35A,
RG-35AXC
Aires T250, Decathlon 8KCAB, Scout CB35A, RG-35A,
8GCBC
RG-35AXC
Citabria 7ACA, 7EC, 7ECA, 7FC, 7JC, CB35A, RG-35A,
7GCBC, 7HC, 7KC, 7KCAB
RG-35AXC
CB35A, RG-35A,
Lancer 402
RG-35AXC
CB25, RG-25,
Viking 14-13, -2, -3, -3W
RG-25XC
Viking 14-19, -2, -3, -3A, 17-30,
CB35A, RG-35A,
-30A, -31, -31ATC, -31TC
RG-35AXC
(2) CB25, RG-25,
U-3
RG-25XC
CB24-3151,
UC-78
RG-390E
O-1, L-19
CB24-3154
CB24-11, RG24-11,
O-2, T-41
RG24-15
Aircraft Make
Cessna
(continued)
Ercoupe
Great Lakes
Lake Aircraft
Cessna
120, 140, 177, 177RG
150, 152, A/F/FA 152,172, 172A,
172M P/R 172, FR172, 177RG, 175,
188, 310, 310G/L, 320, 320D/E, 340
172XP (1977), 180, 182, 185, A188,
205, P206, TP206, TU206, U206,
207, 210
152, A152, 172, 177, 177RG, 180,
182, T182, 185, A188, 210, P210,
T210, 337, P337, T337
152, A152, 172, 172R, 172S, R172,
182, T182, R182, TR182, 206, T206,
210, T210, T303
(SN T30300001-T30300117)
T303 (SN T30300118 and
subsequent)
310, 310R, 335, 340, 401, 402, 404,
411, 414, 421
See Univair
2T-1A-1, 2T-1A-2
LA-4 and LA-4-200 (12-volt)
(all) Model 250, SN 1 to 35 only
LA-4 and LA-4-200 (24-volt) (all)
Model 250 SN 1 to 35 only
Luscombe
Maule
Globe Temco
Bellanca
Aircraft Model
Mooney
8E, 8F, T8F, Silvaire
M-4, M-5, M-6, M-7, MX-7,
MX-7-160, MX-7-180A,
MX-7-180C, MXT-7-180,
MXT-7-180A, MXT-7-180B,
M-7-235 M-7-235C, MT-7-235,
MT-7-235B, M-7-260, M-7-260C,
M-8-235, MMT-420-AC
M-10, -18C, -18L, -18C-55, 20 (to SN
174)
Mark 20, 20A, M20C, M20D, M20E,
M20F, M20G, M20J, M20K (12-volt)
M20J, M20K, M20M, M20R, M20S
(24-volt)
M20L PFM Mooney Porsche, M20M
TLS
North American
T-6, P-51, AT-6
Navion
CBC Part #
CB25, RG-25,
RG-25XC
CB25, RG-25,
RG-25XC
CB35A, RG-35A,
RG-35AXC
CB24-11, RG24-11,
RG24-15
CB24-11M,
RG24-11M,
RG24-15
RG24-20
RG24-20
CB25, RG-25,
RG-25XC
CB35A, RG-35A,
RG-35AXC
CB24-11M,
RG24-11M, RG2415
CB25, RG-25,
RG-25XC
CB35A, RG-35A,
RG-35AXC
CB25, RG-25,
RG-25XC
CB35A, RG-35A,
RG-35AXC
CB24-11, CB2411M, RG24-11,
RG24-11M, RG2415
(2) CB24-11M,
RG24-11M
CB24-3150,
RG-380E/40B
RG-35A, RG-35AXC
• Part # RG-380E/44 is formerly part # RG-380E/40
• Part # CB24-20 has been discontinued
Price and availability subject to change without notice • Shop online at www.univair.com
257
LIGHTING • ELECTRICAL SYSTEM
Aircraft Make
Piper
Aircraft Model
PA-11
PA-12, PA-14, PA-16, PA-18 Super
Cub, PA-22, PA-23 (12v), PA-24
Comanche, PA-25 Pawnee, PA-28
Cherokee, PA-28-161 Warrior, PA-28181 Archer III, PA-28R Arrow,
PA-28R-201 Arrow, PA-28R-201T
Turbo Arrow, PA-30 Twin Comanche,
PA-32R Lance, PA-34 Seneca, PA-39
Twin Comanche, PA-44 Seminole
PA-23, PA-36 Pawnee Brave (24volt)
Raytheon
Beechcraft
258
CBC Part #
CB25, RG-25,
RG-25XC or CB35A,
RG-35A, RG-35AXC
Aircraft Make
Raytheon
Beechcraft
(continued)
Aircraft Model
T-34B
T-34C
Twin Bonanza 50
CB35A, RG-35A,
RG-35AXC
CB24-11, RG24-11,
RG24-15
CB24-11M,
PA-32R-301T
RG24-11M
PA-31 Navajo, Chieftain, T-1020
RG24-15
(2) CB25, RG-25,
RG-25XC or (2)
PA-36 Pawnee Brave (12-volt)
CB35A, RG-35A,
RG-35AXC
CB24-11M,
PA-41 Malibu
RG24-11M
CB35A, RG-35A,
17, B, C, D, E, F, GS
RG-35AXC
(2) CB35A, RG-35A,
18, E18S, G18S (12-volt)
RG-35AXC
D18D, E18S (24-volt)
CB24-3151
Baron Series, E55, 56, 58, 58TC, 58P, (2) CB25, RG-25,
95-B55
RG-25XC, RG-400E
Bonanza F33A, 35, A35, B35, C35,
35R, D35, E35, F35, G35, 1135, J35,
K35, M35, 35-33, N35, 35-A33,
35-B33,P35, S35, 35-C33, E-33, F33,
CB35A, RG-35A,
V35, V35A, V35B, 35-C33A, E33A,
RG-35AXC
E33C, 36, A36, F33A, F33C, B36TC,
23, A23, A23A, A23-19, A23-24,
A24, 19A, M19A, B19, B23, C23,
A24R, B24R, C24R (12-volt)
Bonanza F33A, F33C, V35B, A36,
CB24-11, RG24-11,
A36TC (24-volt)
RG24-15
RG-400E, RG-25,
Duke B-60
RG-25XC
CB35A, RG-35A,
Dutchess 76 (12-volt)
RG-35AXC
CB25, RG-25,
RG-25XC
Musketeer 19, 23, 24, 24R (12-volt) (Optional),
CB35A, RG-35A,
RG-35AXC
Musketeer 23 (SN M-2179 and
CB24-11, RG24-11,
subsequent) and 24R (SN MC-674
RG24-15
and subsequent)
CB25, RG-25,
Skipper 77
RG-25XC
CB24-3151, (2)
T-34A
RG-25
Queen Air 65, A65, 65-80, 65-A80,
65-B80, 65-88, 70
CBC Part #
CB24-3151E, (2)
RG-25
M83769/4-1,
D8565/9-1
(2) CB35A, RG-35A,
RG-35AXC,
RG-400E
RG-400E
CB25, RG-25,
RG-25XC
CB35A, RG-35A,
Seabee
RG-35AXC
Ag Cat B, Ag Cat G-164, Super Ag Cat (2) CB25, RG-25,
G-164-A, GR-164, GR-164-A, G-164B RG-25XC
CB35A, RG-35A,
TH-55 A, B, C
RG-35AXC
CB24-3151 or
Albatross, Goose, Mallard, Widgeon CB24-3150,
(24-volt)
CB24-380E,
RG-380E/44, 40B
CB35A, RG-35A,
Widgeon (12-volt)
RG-35AXC
CB25, RG-25,
269A, B, C 300 (12-volt)
RG-25XC
CB24-11M,
269A, B, C 300 (24-volt)
RG24-11M
CB24-11M,
300C
RG24-11M
CB24-11M,
300CB
RG24-11M
330SP
RG-206
RU-38A, RG-8A
RG-390E
See Univair
See Aviat
CB25, RG-25,
B12D, 15A Tourist, 20 Skyliner
RG-25XC, or CB35A,
RG-35A, RG-35AXC
CB25, RG-25,
F-19, F-21
RG-25XC
Ercoupe 415C, 415D
CB25, RG-25
Ercoupe 415D, 415E, 415G
CB25, RG-25
Ercoupe Fornaire F1, F1A
CB25, RG-25
Alon A-2, A-2A
RG-25
Mooney M10
RG-25
Stinson Model 108-1, -2, -3, -5
CB35A, RG-35A
CB25, RG-25,
RV3, RV4, RV5, RV6, RV6A, RV8
RG-25XC
CB25, RG-25,
Kachina 2150-A
RG-25XC
S-220 Vela, M220-4 Minerva,
CB35A, RG-35A
SF-260-3 Meteor, YMF Super
Travel Air 95
Republic
Schweitzer
Stinson
Swift
Taylorcraft
Univair
Van’s Aircraft
Varga
Waco
Price chart on page 256
Price and availability subject to change without notice • Univair’s Toll Free Sales: 1-888-433-5433
LIGHTING • ELECTRICAL SYSTEM
Concorde Battery Cross Reference Guide
• Comparisons given are meant as reference guide only
• Modifications, STCs or field approvals may be required on certain installations
CBC Part #
RG121
CB25
RG25
RG25XC
CB35
RG35A
RG35AXC
CB12-88
CB24-11
CB24-11M
RG24-113
RG24-11M
RG24-15M3
CB24-20
RG24-203
CB24-3150
CB24-3150-1
CB24-3150E
CB24-3151
CB24-3151-1
CB24-3151E
CB24-3154
CB24-380C
CB24-380E
CB24-382E
CB24-39C
CB24-39E
M83769/1-1
M83769/2-1
M83769/3-1
M83769/4-1
M83769/5-1
M83769/6-1
M83769/7-1
RG-1093
RG-1251
RG-1261
RG-INS1
RG-206
RG-390E
RG-380E Series
RG-380E/K SERIES1
RG-380E/L SERIES1
RG-400E1
RG-500 SERIES3
Obsolete
N/A
CB12-9
CB12-9M or CB25M
CB12-9M or CB25M
CB12-11
CB12-11M or CB35M
CB12-11M or CB35M
CBC Alternate2
N/A
RG25 or RG25XC1
CB25
CB25
RG35 or RG35XC
CB35
CB35
CB24-9
CB24-9M
CB24-9
CB24-9M
RG24-113, -153
RG24-11M, -15M3
CB24-11
CB24-11M
Gill Part #
N/A
G25
G25 or G25M or AEROGEL 30
G25 or G25M or AEROGEL 30
G35
C35 or G35M
G35 or G35M
G88
G240 and G242
G241 and G243
G240 and G242
G241 and G243
Miscellaneous Cross Ref/Special Notes
Extra-cranking power
Extra-cranking power
6GA13 and 6FH13 and 88
High capacity replacement for RG24-11
RG24-253
CB24-20
AN-3150 or AN-3150-2
G244 or G246
G247
CE-50C
M518045-42
AN-3151-1
GE-50E
GE-51
Special: Aero Commander
Special: T-34 A and B
MS18045-41
AN-3154-1A
RG-380E Series
RG-380 Series
RG-390E
AN-3150
AN-3151
AN-3154
MS18045-41
MS18045-42
MS90379-1
CB24-39E
CB24-380E
GE-51E
GE-54C
G-638C or 6381C
G-638E or G-6381 E
G-639C
G-639E
G1-1
G2-1
03-1
04-1
G5-1
G6-1
G7-1
G-641E
G-639E
G-638E or G-6381 E
G-640E
Marathon: SP400, CA-5, MA-5; Saft: 4071, 4076
Marathon: CA4, CA9, SP900
Saft: 2371, 23180, 2376; CBC 131P
CBC 218
CBC 308
CBC 418
CBC 531
CBC 631
CBC 754
Marathon: CA21 and SP283
Marathon: CA-125
Marathon: CA-126
Marathon: CA54 and CA154
Special: Bell 206 A and B
Saft: 2371, 23180, 2376
Marathon: SP400, CA-5, MA-5
Special: Kingair
Special: Learjet
Marathon: CA7; Saft: 1277
Special: MD 500 or CB24-382E; Saft: 4071, 4076
1
This battery is currently PMA-pending. Please contact Concorde for current Approvals Listing.
Batteries listed here are the equivalents in the alternative technology.
3
This battery is in a developmental stage. Please contact the factory for an expected release date. Because the battery has not been produced, we do not have any approvals yet.
2
Price and availability subject to change without notice • Shop online at www.univair.com
259
LIGHTING • ELECTRICAL SYSTEM
Concorde’s HRMFB – High Reliability, Maintenance-Free Batteries
that have good wicking characteristics and promote
retention of the electrolyte. Electrolyte is absorbed
and held in place by the capillary action between
the fluid and the glass mat fibers. The mat is over
90 percent saturated with electrolyte. By design, it
is not totally saturated with electrolyte... a portion
is filled with gas. The void space provides the
channels by which oxygen travels in its path from
positive to negative plate.
This drawing represents the old flooded or
vented type lead acid battery on charge.
High Reliability, Maintenance-Free Batteries
– Their History
Since their introduction in 1986 the Concorde
Battery Corporation has developed several styles of
HRMFB, also known as VRSLAB (Valve Regulated
Sealed Lead Acid Batteries). Concorde Battery
Corporation has a dedicated Research and
Development Department that is continuously
improving and refining their sealed product line.
Formed in 1977, originally their factory was
dedicated to manufacturing dry charged (vented or
flooded electrolyte) aircraft batteries. But now,
with the Concorde VRSLAB’s proven reliability and
great acceptance in both military and commercial
aviation, over 80 percent of their manufacturing
facility has been changed over from dry charged to
VRSLAB production.
How They Differ
Some of the main differences between the old
vented lead acid aircraft batteries and the new valve
regulated sealed lead acid aircraft batteries are:
• The electrolyte is absorbed in a glass mat (AGM)
separator in the VRSLAB and it is spillable in the
flooded or vented type.
• The cells have two-way vent valves in the
VRSLAB that are designed to keep a positive
pressure in each cell. The older vented or flooded
type aircraft battery cells are open to atmosphere
through the vent cap holes (unless the battery is
tilted or inverted, when the vent caps’ shut-off
valves are supposed to close to prevent the
flooded electrolyte from spilling all over your
airplane).
• The plates in the old vented type are suspended
by their terminal lugs with loose fitting
separators and lots of space between the
positive and negative plates that are awash with
260
This drawing represents the recombination
of the gases on charge with the immobilized or
absorbed electrolyte design.
electrolyte. In contrast, VRSLAB has every square
inch of positive and negative plate material
tightly packed and compressed with the AGM
and supported by the walls of each cell jar.
Because of this type of construction the new
VRSLAB have much lower internal resistance and
obviously have greater starting power, particularly
at cold temperatures. This support provides a much
higher degree of shock and vibration than the old
flooded type. The VRSLAB performance is
comparable to nickel cadmium aircraft batteries
without their expensive temperature monitoring or
maintenance requirements.
How They Work
The old flooded electrolyte electric storage batteries
consume water in service because the battery
generates hydrogen from the negative plates and
oxygen from the positive plates at the end of the
charging cycle. The battery evolves flammable
percentages of hydrogen and oxygen gases that
escape through the open vent cap holes. This escape
of gases known as electrolysis reduces the water
content of the electrolyte and requires the water to
be replaced periodically in order to maintain the
correct specific gravity and electrolyte level.
Not a Gelled Electrolyte
The new Concorde VRSLAB is a recombinant gas
(RG) absorbed electrolyte battery. The Concorde RG
battery cells are sealed with two-way pressure
relief valves that provide a positive or higher
pressure within the battery and prevent the battery
case from rupturing at any altitude. The design of
the Concorde RG Series Aircraft Batteries utilizes a
greater quantity of negatively active material than
positive active material. The plates are sandwiched
with a micro fibrous silica glass mat consisting of a
blend of glass fibers of varying length and diameter
The void spaces allow the freshly generated gases,
which are in their atomic state and very reactive, to
recombine rapidly and safely. This re-combination
passivates the negative slightly, reducing
electrolysis and ultimately eliminating the need to
add water, making the battery maintenance-free.
Charge Without Fading on a Constant
Potential (Voltage) Buss
Concorde RG Series Aircraft Batteries simply work
better than nickel cadmium batteries do in aircraft
that are not equipped with dedicated nickel
cadmium battery chargers.
Charge Retention
Three times better than the old vented type.
Safe
By design Concorde Recombinant Gas Aircraft
Batteries produce less than 2 percent hydrogen
gas during a severe overcharge (4.1 percent is
required for flammability in air). They meet or
exceed the requirements of MIL-SPEC B-8565 and
FAR 23.1353, 25.1353(c), 27.1353, 29.1353(3),
25.853(a) amendment 25-72 appendix F, part 1
paragraph (a)(1)(i).
Reliable
Ask the U.S. Navy and Air Force. The F/A-18 and the
F-117A were reported to have had trouble-free
batteries during Desert Storm (both types were
equipped with Concorde VRSLAB).
FAA Approval
Concorde RG Series batteries have been approved in
One-Fifties to Falcon Nine Hundreds.
Shipping... AOG?
Concorde RG Series Batteries are not restricted for
shipment by air or any other means of
transportation. They are classified as nondangerous, are shipped fully charged, and are not
required to have corrosive labels on their shipping
cartons.
Recyclable
Can be recycled at any smelter that recycles
automobile batteries.
Price and availability subject to change without notice • Univair’s Toll Free Sales: 1-888-433-5433
LIGHTING • ELECTRICAL SYSTEM
Lights and Lenses
Description
Part #
Price
Green Light Assembly .....................................................AN3157-3 ............ $5.16
Amber Light Assembly ....................................................AN3157-4 ............ $6.19
Grimes Lights
Grimes Map Light
• 12-volt or 24-volt
• Will mount over instruments or any
place convenient in the cockpit
2
1
Map Light .............................................................................A1719 .......... $29.97
Steel Formed Navigation Light Plates
1) Grimes Type B Wing Light
Red Lens ................................................................A2430-2R-94 ........$187.67
Green Lens .............................................................A2430-2G-94 ........$187.67
2) Grimes Type A Wing Light
Red Lens ................................................................A1228-1R-93 ........$297.41
Green Lens .............................................................A1228-1G-93 ........$297.41
Grimes Type A, B, C
Lens Bail ...........................................................................A1234 ............ $6.50
Lens Gasket ......................................................................A1232 ............ $1.78
A
B
A) Light Plate for Model S Tail Light .................................0400-113 .......... $26.58
• Can be welded or screwed to rudder to attach model S light
Grimes Lenses
B) Light Plate for Model E Navigation Light .....................0400-112 .......... $27.99
• Can be welded or screwed to wingtip bows to attach model E light
Strobe Light Bracket
• Can be used on the top of Piper rudders
• FAA field approval required
1
2
3
Strobe Light Bracket.......... U15722-002 .... $110.61
4
Navigation Light Fairing
This plastic fairing is required to convert
model B type wing lights to the more
streamlined model E navigational lights
on Ercoupe 415-C, -D, and -G.
5
6
1) Model A and B Red Lens ...............................................A1233A2 .......... $43.90
2) Model A and B Green Lens ............................................A1233A3 .......... $42.60
3) Model A and C Clear Lens..............................................A1233A1 .......... $40.36
4) Model E Red Lens (A1280-2) ....................................... W1284-R .......... $39.69
5) Model E Green Lens (A1280-3) ....................................W1284-G .......... $46.62
6) Model S Clear Lens ........................................................ A4513-1 .......... $21.00
210346-005 ..................................$41.02
Warning Lights
Sealed Beam Bulb Unit
Warning Lights, glass jewel type, with 12-volt bulb
Red ....................................... AH-133R...... $15.19
Green .................................... AH-133G...... $15.19
Amber .................................. AH-133A...... $15.19
• For all popular aircraft landing lights
Sealed Beam Bulb .......................4509 .......$12.88
Halogen Unit .............................Q4509 .......$27.12
Price and availability subject to change without notice • Shop online at www.univair.com
261
LIGHTING • ELECTRICAL SYSTEM
Circuit Breakers and Switches
Bendix Ignition Switch
• For all light planes
C
B
A
D
E
G
F
I
J
H
K
A) Circuit Breaker, 5-amp ................................................AN3160-5 .......... $57.50
B) Spring Loaded “On-Off” Switch .................................AN3022-7B .......... $11.62
C) Regular “On-Off” Switch (31TS1-2) .............................AN3022-2 ........ $136.00
D) Double Pole, “On-Momentary On” ............................AN3023-10 .......... $57.40
E) Fuse Clip, composition base .................................................. FC1 ............ $2.99
F) C6363 Circuit Breaker – Klixon, 5-amp ..........................C6363-5 ........$105.68
15-amp........................................................................C6363-15 ........$105.84
30-amp........................................................................C6363-30 ........$161.94
G) Klixon PM Circuit Breaker, 5-amp ...................................... PM-5 .......... $27.06
10-amp............................................................................ PM-10 .......... $27.06
20-amp............................................................................ PM-20 .......... $27.06
35-amp............................................................................ PM-35 .......... $27.06
40-amp............................................................................ PM-40 .......... $27.06
H) Klixon PSM Circuit Breaker, 5-amp ...................................PSM-5 .......... $43.82
10-amp................................................................W23X1A1G-10 .......... $27.37
15-amp...........................................................................PSM-15 .......... $33.38
20-amp................................................................W23X1A1G-20 .......... $32.50
25-amp...........................................................................PSM-25 .......... $33.38
I) Klixon CM Circuit Breaker, 15-amp .....................................CM-15 .......... $25.23
J) Ohmite Rheostat, for instrument panel lights .......................OR1 .......... $47.33
K) Microswitch*, 10-amp rating at 125 volts .................. RD7-1P2T .......... $26.35
*May be installed in either “normally open” or “normally closed” position.
Requires 1⁄16-inch travel to actuate, with 7⁄32-inch additional override. Perfect for
mechanisms, door lights, trunk lights or hood lights. Makes excellent push-button
for starter solenoids.
Switch with no “Start” position .................................. 10-357290-1 ........ $352.53
Switch with “Start” position ....................................... 10-357200-1 ........ $495.98
Plate for part number 10-357200-1
(“Off, R, L, Both, Start”) .............................................10-126676 ............ $5.10
Switch Shield ....................................................................0311777 ........$303.00
Strobe Heads, Beacons,
Anti-Collision Systems,
Single Light Remote Systems
Whitaker Mount
For installation of Grimes and Whelen rotating
beacon or strobe light on rudder. STC approved on
Piper PA-11 to PA-25.
AW221 .........................................................$69.50
Whelen Landing Light Mount
Standard equipment on new Beechcraft, and will
retrofit into older aircraft as well. Accommodates
PAR 36 lamp. Lamp element sold separately.
Specifications: Weight 0.4 lbs • Diameter 4.75
inches • Length 6.5 inches • Depth 2.12 inches
Landing Light.......................... A715-1 .....$214.83
A470A Whelen Strobe Head
The A470A can be installed on the vertical fin or
frame. It incorporates a vibration-proof flash tube
which allows flush mounting. Available with Aviation
Red, Aviation White or Split Aviation Red/White optic
lens.
Specifications: Weight 0.3 lbs • Exposed height 3.75
inches • Diameter 2.5 inches • Lexan lens material
Relay Type Flasher Unit
Relay operates two sets of contact points
which may be wired in normally open or
normally closed position. Flasher may be
used for navigation or warning lights.
Relay Type Flasher Unit ............. RELAY .......$29.71
262
Red Lens ................................. A470A-R......$131.63
White Lens ............................. A470A-W......$131.63
Split Red/White Lens ...............A470A-S......$131.63
When ordering with Aviation Red or Split Aviation Red/White lens, the A490A-TSDF-14/28 may be used; with Aviation White, use the A490A-T-DF-14/28. When
installing the system, use special 3-conductor shielded cable between light
assembly and power supply. HD-5 (5-foot cable); HD-10 (10-foot cable).
Price and availability subject to change without notice • Univair’s Toll Free Sales: 1-888-433-5433
LIGHTING • ELECTRICAL SYSTEM
Anti-Collision Light System
Position Lights and Anti-Collision Light
Distribution Patterns Requirements
Anti-Collision Systems
from Whelen Aviation Lighting
An approved anti-collision strobe light
system must project light 360° around the
aircraft’s vertical axis. One or more strobe
lights can be used.
An approved anti-collision strobe light
system must project light + or -30° above
and below the horizontal plane of the
aircraft. One or more strobe lights can be
used. The + or -75° projected light is
required since July 18, 1977.
Approved light pattern in the horizontal
plane. The anti-collision wingtip mounted
lights must converge within 1200 feet
directly in front and rear of the aircraft on
center line. If the wingtip strobe light
convergence is greater than 1200 ft. in back
of the aircraft, a third light is necessary.
2-Light Strobe Package
W2000 $733.68
• For use with existing model E style lights
Strobe Lights, 2 each................................................... A650 ....$146.25
Power Supply, 1 each ....................................A413AHDA-CF ....$483.00
60-foot Wiring Package, 1 each ................................ HD-60 ....$142.80
Locations On The Aircraft For Anti-Collision Strobe Lights,
To Comply With Light Pattern Requirements
3-Light Strobe Package
W3000 $954.54
• 14-volt lights are listed; 28-volt lights are also available
Strobe Lights, 2 each................................................... A650 ....$146.25
Tail Strobe Lights, horizontal, 1 each................A500A-H-14 ....$215.28
Power Supply, 1 each ....................................A413AHDA-CF ....$483.00
90-foot Wiring Package, 1 each ............................HD,T3-90 ....$159.12
VERTICAL FIN
WING TIP
Whelen Mounting Adapters
ENCLOSED WING TIP
FUSELAGE
VERTICAL FIN: One anti-collision strobe light mounted on the vertical fin
will meet the minimum requirements on most aircraft. A half red and half
white lens is recommended.
WING TIP: Two wing tip strobe lights that protrude beyond the wing tip,
their light converging in front and back of the aircraft within 1200 ft. is an
approved anti-collision strobe light system.
ENCLOSED WING TIP: Enclosed wingtip anti-collision strobe lights
require a third strobe light on the tail or vertical fin to fill in the required
light envelope. This is an approved anti-collision system.
FUSELAGE: A frame mounted anti-collision strobe light system requires a
minimum of two strobe lights to get the required vertical coverage. This is
an approved anti-collision system.
These adapters are designed for the A470A,
A450 and 70509. The H103 (shown on top) is
designed to allow strobe light head
assemblies to be installed in 3¾-inch
diameter standard rotating beacon mounting.
The H102 (shown on bottom) allows direct
mounting of the strobe light head assembly
to the skin of the frame or the top of a
2½-inch diameter Cessna vertical stabilizer
fairing.
Whelen A Mounting Adapter (shown top) ..............................H103 .......... $71.37
Whelen B Mounting Adapter (shown bottom)........................H102 .......... $12.60
• Available for frame installations of
models HR-CFA and SA-CF
Mounting Adapter ......................A440 .......$28.67
Price and availability subject to change without notice • Shop online at www.univair.com
263
LIGHTING • ELECTRICAL SYSTEM
Whelen Self-Contained Strobe
Whelen Flashing Anti-Collision Light
The SA, CF is a self-contained CometFlash anti-collision
strobe light. With a glass dome (Aviation White), the
rugged SA is ideal for agricultural applications where
chemicals are used. The SA, CF has an effective intensity of
300 candles in a hemisphere.
Specifications:
• Current Draw: 2.7 amps @ 14 volts, 1.35 amps @ 28 volts
• Weight: .27 lbs
• Wire: 20 AWG Teflon
• Lamp: 35W Halogen
• Filament: CC-8 (axial)
• Lens: Lexan® Polycarbonate
Specifications: Power Consumption: 3.2 amps @ 14
volts DC, 1.6 amps @ 28 volts DC • Weight: 1.5 lbs •
Diameter: 3.71 inches • Height: 5.50” • Flash rate: 50+/-5
FPM • Dome material: Pyrex glass, Aviation White only.
Flash Tube Replacement: The SA406 flash tube used in the SA, CF is a plug-in
type easily replaced with minimum labor and time.
Whelen Self-contained Strobe ....................................SA-CF-14/28 ........$581.25
Whelen Anti-Collision Systems
with Self-Contained Power Supplies
Whelen Engineering introduces the Model 70509 Flasher, a totally new selfcontained, flashing anti-collision light assembly that is FAA TSO-C96A approved.
The Model 70509 FLASHER features a rugged polycarbonate lens with internal
optics (patent pending), replaceable halogen lamp and flasher assemblies. It can
be installed as a replacement on 1967-1979 Cessna aircraft, on most general
aviation aircraft, home builts, and ultralights. A separate flasher power pack is not
needed because the unit is completely self-contained.
Specifications: Power consumption: 3.2 amps @ 14
volts DC, 1.6 amps @ 28 volts DC • Weight 1.5 lbs •
Diameter 3.71 inches • Height 7.25 inches • Flash rate
50 ± 5 FPM • Lens material Lexan • Lens colors Aviation
Red, Aviation White, or Split Aviation Red/White.
Description
Part #
Price
28 Volt Flasher Assembly (Red/White) ................... 01-0770509-05 ........ $128.70
28 Volt Flasher Assembly (White) .......................... 01-0770509-04 ........ $128.70
28 Volt Flasher Assembly (Red) .............................. 01-0770509-03 ........ $128.70
14 Volt Flasher Assembly (Red/White) ................... 01-0770509-02 ........ $128.70
14 Volt Flasher Assembly (White) .......................... 01-0770509-01 ........ $128.70
14 Volt Flasher Assembly (Red) .............................. 01-0770509-00 ........ $128.70
14 Volt Replacement Lamp .................................... 02-0350433-00 .......... $29.84
28 Volt Replacement Lamp .................................... 02-0350433-01 .......... $29.84
Flash Tube Replacement: The A469A flash tube used in the HR-CFA is a plug-in
type easily replaced with a minimum of labor and time.
A500A Whelen Tail Position/
Strobe Light
White Lens ............................................................ HR-CFA-14/28W ........$408.00
Red Lens ................................................................ HR-CFA-14/28R ........$408.00
Split-White/Red Lens ..............................................HR-CFA-14/28S ........$408.00
Combination strobe/tail navigation light used when the
wing tip anti-collision lights are mounted in an enclosure
and can provide 360° of strobe coverage. It is a direct
replacement for the standard tail position light.
• 3¼-inch diameter base
A555A Whelen Tail Position Light
Specifications: Weight 0.3 lbs; Exposed height 1.75
inches; Diameter 1.5 inches
Manufactured of non-magnetic materials, the A555
tail position light is available in Aviation White only.
Dome material is Pyrex glass.
Horizontal Installation, 14 volt.................................... A500A-H-14 ........$215.28
Horizontal Installation, 28 volt.................................... A500A-H-28 ........$201.24
Vertical Installation, 14 volt .........................................A500A-V-14 ........ $215.28
Vertical Installation, 28 volt .........................................A500A-V-28 ........ $215.28
Specifications: Weight 0.3 lbs • Exposed height 1.75
inches • Diameter 1.5 inches
A600 PR/PG Series Whelen Wingtip Light
Horizontal Installation, 14 volt.................................... A555A-H-14 ........$148.59
Horizontal Installation, 28 volt.................................... A555A-H-28 ........$148.59
Vertical Installation, 14 volt .........................................A555A-V-14 ........ $148.59
Vertical Installation, 28 volt .........................................A555A-V-28 ........ $148.59
Ready to install, this strobe light head assembly will equip the aircraft with
forward and tail position lights. Some installations may require this series rather
than the A650 PR/PG series. For system installation,
substitute the A600 PR/PG lights with the A650
PR/PG lights.
A450 Whelen Strobe Head
This is optional for the A470 light shown at right. The
A450 is equipped with Pyrex glass (clear only) designed
for use in severe vibration, chemical and moisture
conditions.
Specifications: Exposed height 2.25 inches • Diameter 2.5 inches • Weight 0.3 lbs
Whelen Strobe Head Assembly ...............................................A450 ........ $217.13
264
Specifications:
• Weight: 0.5 lbs
• Exposed Height: 2.4 inches
• Length: 5.625 inches
• Lens: A612 magnifying lens
• Please specify 14 or 28 volts when ordering
Red Light .....................................................................A600-PR-14 ........$442.85
Green Light ..................................................................A600-PG-14 ........$442.85
Price and availability subject to change without notice • Univair’s Toll Free Sales: 1-888-433-5433
LIGHTING • ELECTRICAL SYSTEM
A650 Whelen Wingtip Strobe Assembly
W1250 Whelen Position Light
The A650 may be added to the existing Type E
position light with a minimum of structural
modification. Only a ¼-inch hole in the position
light is required. The wingtip strobe retainer
supports the position light tip as the original
retainer did. The A650 is electronically and
mechanically interchangeable with the Whelen
A429.
• TSO-C30b Approval
Specifications: Weight: 0.2 lbs • Exposed height: 2.4 inches • A612 magnifying lens
The W1250PG and W1250PR are approved position
lights. They are designed to fit underneath the
wingtip fairings.
Specifications: Weight: 0.3 lbs • Exposed height:
1.25 inches • Length: 2.75 inches
Red Light ................................................................... W1250PR-14 ........$196.56
Green Light ................................................................W1250PG-14 ........$196.56
Wingtip Light ..........................................................................A650 ........$146.25
A650 PR/PG Whelen Wingtip Light
This wingtip light can be installed with almost no
modifications to the aircraft’s structure. This position
and strobe light is electronically and mechanically
interchangeable with the Whelen A429 PG/PR.
Specifications: Weight: 0.4 lbs • Exposed Height: 2.4 inches • Length: 4 inches •
Lens: A612 magnifying lens
A625 Whelen Strobe Light
• For aircraft with wingtip tanks
• For aircraft with enclosed position lights
Specifications: Weight: 0.2 lbs • Exposed height: 113⁄32
inches
Strobe Light .................................... A625.........$129.06
• 14-volt lights are listed; 28-volt lights are also available
Red Light .....................................................................A650-PR-14 ........$380.25
Green Light ..................................................................A650-PG-14 ........$380.25
W1555A Whelen Tail Light
• TSO-C30b Approval
The W1555A position light features two 25 watt hard
glass Halogen lamps separately controlled by an
electronic switch. If the primary light fails, the second
lamp is electronically activated. Available in 14 volt or
28 volt.
Specifications: Weight: 0.3 lbs • Diameter: 1.50 inches
• Exposed height: 1.75 inches
14 volt, vertical mount............................................... W1555AV-14 ........ $201.60
28 volt, vertical mount............................................... W1555AV-28 ........ $217.00
28 volt, horizontal mount ..........................................W1555AH-28 ........$217.00
A675 PG/PR Whelen Tail Position Light
W1285 Whelen Wingtip and Tail Position Lights
• TSO-C30b approval
• Direct replacement for model E Grimes lights
The W1285PG and W1285PR are approved
position lights available in red or green. They
are manufactured of non-magnetic materials.
Specifications: Weight: 0.2 lbs • Exposed
height: 1.25 inches • Length: 4 inches
Red............................................................................. W1285PR-14 ........$297.00
Green .........................................................................W1285PG-14 ........$297.00
Whelen Strobe Tube Assembly and Lens
• For Cessna single engine aircraft 1972 and later
Ready to install, this light assembly will equip
the aircraft with forward and tail position lights.
Available in red or green, 14 volt and 28 volt.
In this system the A610 and A612 are mounted directly
onto the wingtip retainer. Use the A612 as a template for
cutting a hole in the existing light shield. This system
requires very little time or labor to install. The A612
magnifying lens increases the light intensity by two to
three times in the horizontal plane.
Specifications: Weight: 0.5 lbs • Exposed
height: 1.25 inches • Length: 5.625 inches
Strobe Tube Assembly ........................... A610 ........$70.20
Magnifying Lens ................................... A612 ........$35.28
• FAA/TSO-C30b Approval
Green Light, 14 volt.......................................................A675PG-14 ........ $282.56
Green Light, 28 volt.......................................................A675PG-28 ........ $282.56
Red Light, 14 volt .......................................................... A675PR-14 ........$282.56
Red Light, 28 volt .......................................................... A675PR-28 ........$282.56
A610
A612
Order online at www.univair.com
Price and availability subject to change without notice • Shop online at www.univair.com
265
LIGHTING • ELECTRICAL SYSTEM
Effective Candles Produced Using Whelen Double
Flash Power Supplies
Model
A600 PG/PR
A650 PG/PR
A650
A500
A625
A450
A470A in
Aviation White
A470A in
Aviation Red
25 Joules
per Flash
660
660
660
330
660
330
20 Joules
per Flash
600
600
600
300
600
300
12 Joules
per Flash
380
380
380
190
380
190
825
825
500
180
165
unavailable
About CometFlash ®
Whelen Engineering is proud to have pioneered and introduced the
NEW CometFlash CF, a major advancement in the field of safety lighting.
By pulsing the flash tube four times in rapid succession, the effective
“on-time” of the strobe is increased from 2/1000 of a second to 4/10 of
a second. This increases your airplanes visibility. The development of the
CometFlash reflects Whelen’s dedication to safety.
Toll Free Sales: 1-888-433-5433
Whelen Power Supply – Model HDA-CF
The HDA-CF is the finest power supply system
available. It has the capacity for simultaneous
flashing, alternate flashing, or both. A 2-light
system alternate flashing produces 25 joules to
each light. A 2-light system simultaneous
flashing produces 12 joules to each light. A
3-light system produces 12 joules to each
simultaneous light, and 25 joules to the third
light. A 4-light system produces 12 joules of
energy to each light. The HDA-CF requires a
special 3-conductor cable cord routed from the
power supply to the light assemblies.
Recommended Components: For 2 lights: 1 HD-60 installation package • For
3 lights: 1 HD, T3-90 installation package • For 4 lights: 2 HD-60 installation
packages
Specifications: Power consumption: 7.0 amps @ 14 volts DC, 3.5 amps @ 28
volts DC • Weight: 3 lbs • Length: 5.5 inches • Width: 5 inches • Height: 3.25 inches
• Flash rate: Alternately at 90+/- 5FPM, simultaneously at 50 +/- 5FPM
Power Supply HDA-CF ...............................................A413AHDA-CF ........$483.00
Power Supplies
Whelen Power Supply – Model HTS-CF
The HDA-CF is our most versatile and advance power supply made for two or three
lights and offers the choice of alternate flashing, simultaneous flashing or both.
The HTS-CF produces an estimated 34 joules of
energy. It can be equipped to flash simultaneously
with up to 5 other HTS-CF power supplies by
connecting an 18 gauge wire between the
synchronization mechanisms in each power supply.
An 18 gauge low voltage wire supplies power to
each HTS power supply.
The HTS-CF is designed for installation adjacent to the strobe light head
assembly thus eliminating long run of high voltage cables. It powers one light
and a simple connection to another HTS-CF provides simultaneous flashing.
Specifications: Power consumption: 2.9 amps @ 14 volts DC, 1.7 amps @ 28
volts DC • Weight: 1.5 lbs • Length: 5.0 inches • Width: 3.12 inches • Height: 3.06
inches • Flash rate: 50+/-5 FPM
The HT-CF is our most economical power supply when adding only one light. The
HT-CF is designed for installation adjacent to the strobe light head assembly. The
compact size gives it unparalleled versatility.
Power Supply HTS-CF ........................................... A490ATSCF14/28 ........$444.60
How to Choose a Power Supply
The power supply system you choose determines the number of lights you can
add to your airplane.
All power supplies can operate between 13-30 VDC.
Whelen Power Supply – Model HT-CF
Whelen Power Supply – Model HDS
The HDS produces 20 joules of energy alternating
between two light assemblies. This unit produces
a single flash and has a low current draw.
Our most compact, single-source power
supply produces an accumulated 19 joules of
energy.
Specifications: Power Consumption: 4 amps @
14 volts DC, 2 amps @ 28 volts DC • Weight 2 lbs •
Height 2.375 inches • Length 5.5 inches • Width 5.0 inches • Flash rate alternately
at 90+/-5 FPM
Specifications: Power consumption: 1.7
amps @ 14 volts DC, .85 amps @ 28 volts DC
• Weight: 1.2 lbs • Length: 5.0 inches • Width:
3.12 inches • Height: 2.25 inches • Flash rate:
50+/-5FPM
Power Supply HDS............................................... A413AHDS-14/28 ........ $483.60
Power Supply HT-CF .............................................. A490T-CF-14/28 ........$335.40
266
Price and availability subject to change without notice • Univair’s Toll Free Sales: 1-888-433-5433
LIGHTING • ELECTRICAL SYSTEM
Whelen Installation Packages
Description
Part #
Price
SA/HR Installation Package ...................................................SA/HR .......... $21.00
HS-30 Installation Package (30-foot cable)........................... HS-30 .......... $76.86
HS-5 Wingtip Installation Package (5-foot cable) ................... HS-5 .......... $39.06
HD-60 Installation Package (60-foot cable) ..........................HD-60 ........$142.80
HT Installation Package (HT-1)....................................................HT .......... $18.27
HD, T3-90 Installation Package (90-foot cable) ................ HD,T3-90 ........$159.12
HT 10 Installation Package (10-foot cable) ............................HT-10 .......... $42.21
Interior and Cockpit Lighting
A300 Whelen Map Reading Light
Designed for indirect cockpit illumination. The A300
will upgrade your aircraft cockpit with greater
illumination. Slide switch permits direct chart
reading. Available with red or instrument white lens.
Specifications: 6 watt lamp • Diameter: 4.125
inches • Depth behind mounting flange: 1.06 inches
• Weight: 0.16 lbs
70339 Dome Flood and Compartment Light
The 70339 is designed for recessed overhead or wall
mounting with minimal depth. It can be supplied with an
on/off switch.
Specifications: 6 Watt Lamp • Diameter: 4.125 inches •
Depth behind mounting flange: 1.06 inches • Weight:
0.16 lbs
14 Volts DC .......................................................................70339-01 ........$141.57
28 Volts DC .......................................................................70339-02 ........$141.57
14 Volts DC with Switch ...................................................70339-03 ........$158.54
28 Volts DC with Switch ...................................................70339-04 ........$158.54
70820 Series Map Light
The model 70820 Series are LED (Light Emitting
Diode) interior map/reading light assemblies.
They are designed for cabin or cockpit illumination.
It has a 360° swivel base, allowing for infinite
light angle adjustment. Utilizing LED technology,
the following advantages are offered:
• Long life (approximately 20,000 hours)
• Reduced power consumption (compared to alternative light sources)
• Shock and vibration resistant
Map Reading Light, 14 volt ............................................... A300-14 ........ $193.90
Map Reading Light, 28 volt ............................................... A300-28 ........ $193.90
Specifications: Current draw: 0.02 amps @ 14 VDC, 0.02 amps @ 28 VDC •
Weight: 0.19 lbs
Specify red or white lens color when ordering
14 Volt Map Light
Natural Aluminum Finish, White ....................... 01-0770820-01 ........$144.00
Black Anodized Finish, White............................. 01-0770820-02 ........$144.00
Black Anodized Finish, Red ................................ 01-0770820-04 ........$180.80
A315-LO Cockpit Utility Light
Unit rotates for convenience in reading maps and
illuminating instrument panel. Also available with
right angle bracket. Requires remote switch control.
Cockpit Utility Light A315-LO .......................................A315-LO-14 .......... $40.60
A350 Instrument Post Light
Illuminates the instrument panel and functions as
one of the instrument mounting bolts. The A350
can be equipped with a dimmer if desired.
28 volt versions of the above lights are available
Radio Noise Suppression
Whelen strobe light lenses part number A428 and the A402A are
available with an advanced RF shielding technique that Whelen
Engineering developed to reduce radio interference. When properly
grounded to the aircraft structure, these radio shielded strobe light
heads will reduce the radiated RF energy created by the trigger pulse
as much as 15-17 DB. (To locate RF shielded parts, refer to Whelen
Engineering’s strobe light parts list).
Instrument Post Light ...... A350CBS14V......$40.60
A429 Strobe Light Head – Use the A428-D which is an RF shielded
A428 lens epoxied into an A426 retainer.
A315-HI Cockpit Utility Light
A470A – Can be radio shielded by replacing the existing lens with part
number A402A-D (color).
Identical to utility light, except equipped with
instrument white lens assembly.
A500A – Use the A457A-D which is an RF shielded A612 lens epoxied
into an A606 lens retainer.
Cockpit Light
Blue ..........................A315-HI-14-B .....$102.90
Red ...........................A315-HI-14-R .....$102.90
White .......................A315-HI-14-W .....$107.80
A650 Strobe Light Head – Use the A626-D which is a RF shielded
A612 lens epoxied into an A626 lens retainer.
Price and availability subject to change without notice • Shop online at www.univair.com
267
LIGHTING • ELECTRICAL SYSTEM
Whelen Parts – Exploded Views
Wing Tip Strobe
(Replaced by A650)
A429
A426
Wing Tip Strobe/
Position Light
A600 PG/PR Series
W1284
W1283
W1290
A427-4
A426-D
A430
A507
A606 A612-D
A436
A457A
A444
Ref.
A435
A457A-D
OPTIONAL
A444
Ref.
A610
A612
Tail Strobe LIght
A425
A615
A508
A450
A650 PG/PR Series
W1290
W1284
Strobe Light
A444
Ref.
A409
38-0230946-00
A626
SA406
A500A
A616
Wing Tip Strobe/
Position Light
W1283
SA402
A605
A444
Ref.
A427
A428
Price chart on page 269
A612
A427-4
A610
W1285-2
A444
Ref.
A626-D
Tail Strobe Light
A650
Wing Tip Strobe
A444
Ref.
A508 A509
A612
A425
A457A
A457A-D
OPTIONAL
A455
A510
A506
A444
Ref.
A626
A444
Ref.
A610
A626-D
A470A Series
Strobe Head
A402 (-W, -R, -G, -R/W)
A555A
Tail Position Light
A508 A509 A507
A425
A457A
A455
A510
A504
A625
A424
Strobe Light
A612
A62B-D
OPTIONAL
268
A629
A627
A444
Ref.
A469A
01-0450682-00
W1285
Position Light
W1284
A628
A465
A467
A444
Ref.
A441
Ref.
W1283
W1290
W1282
Price and availability subject to change without notice • Univair’s Toll Free Sales: 1-888-433-5433
W1285-2
LIGHTING • ELECTRICAL SYSTEM
Prices for Whelen Parts
A402A New Style Optic Lens – Red ...................................A402A-R .......... $31.50
Split Red/White ............................................................ A402A-S .......... $31.50
White ...........................................................................A402A-W .......... $31.50
A402 Old Style Optic Lens – Red ......................................... A402-R .......... $27.72
White .............................................................................A402-W .......... $27.72
Green ..............................................................................A402-G .......... $29.40
Split Red/White ......................................................... A402-R/W .......... $32.13
Clamp Ring (A409) ................................................. 01-0450685-00 .......... $13.30
Tail Strobe Lens Retainer .........................................................A425 .......... $20.30
Lens Retainer ..........................................................................A426 .......... $89.46
Strobe Flash Tube Assembly ....................................................A427 .......... $78.75
Wingtip Strobe Lens, Clear ......................................................A428 ........ $105.00
Flash Tube Assembly ...............................................................A435 .......... $85.05
Gasket .....................................................................................A436 ............ $3.50
Gasket (for A430) ....................................................................A455 ............ $7.56
Lens, Clear.............................................................................A457A .......... $35.70
Gasket (2.5” diameter, .046” thick)..........................................A467 ............ $7.61
Flash Tube Assembly .............................................................A469B .......... $70.20
Flash Tube Assembly (for A500A series) ..................................A506 ........$154.35
Socket Assembly .....................................................................A507 .......... $19.53
Halogen Lamp, 14 volt, 25W ............................................. A508-14 .......... $23.94
Halogen Lamp, 28 volt, 25W ............................................. A508-28 .......... $23.94
Lang Driving Washer ...............................................................A509 ............ $5.20
Lang Driving Washer ...............................................................A510 ............ $1.24
Lens Retainer (19-170049-009) ..............................................A606 .......... $46.90
Flash Tube Assembly ...............................................................A610 .......... $70.20
Magnifying Lens, Clear............................................................A612 .......... $35.28
Lens ........................................................................................A615 .......... $69.93
Retainer Lens ..........................................................................A626 .......... $42.21
Flash Tube Assembly ...............................................................A627 .......... $82.53
Lens Assembly, Clear Glass ....................................................SA402 ........ $180.18
Flash Tube .............................................................................SA406 .......... $76.86
Navigation Light Cover (for W1285 series) ...........................W1282 .......... $34.65
Gasket ..................................................................................W1283 ............ $8.19
Model E Green Lens..........................................................W1284-G .......... $46.62
Model E Red Lens ............................................................. W1284-R .......... $39.69
Position Light Base Assembly........................................... W1285-2 .......... $97.65
Reflector Lamp, 14 volt, 26W ......................................... W1290-14 .......... $38.43
Reflector Lamp, 28 volt, 26W ......................................... W1290-28 .......... $44.47
Notes:
• The A429 head assembly has been replaced with the A650 head assembly.
• The A600 head assembly can be used with any wingtip system.
• The A490-TS, A490A-TS-CF, and A413A-HDA power supplies provide 400 effective candles ref STC SA21NE, when used with the A600 and A650 head assembly.
• The A490-TS-DF replaces the A412A-HS strobe light power supply.
• All Whelen aviation strobe products are manufactured under Product Manufacturing Authority from the Federal Aviation Administration, assuring top
quality, reliable design and construction, and conforming to all applicable FAA regulations.
Solenoids
Solenoids
• Single pole
• Normally open
• Used on all 108 Stinsons as Master Solenoid
Single Pole Solenoid
(70-918) ............... 70-111226-5 ......$26.11
• Double pole
• Normally open
• Used on Swifts
Pictures from Oshkosh 2014, taken by Univair employee Jason Huber
Double Pole Solenoid ..........70-902 ......$30.84
Piper Starter Solenoid
• With 5⁄16” terminals
This FAA/PMA approved solenoid is a 6 volt unit.
It is a direct replacement for the original Piper
solenoid. The 6 volt unit has larger contacts than
a 12 volt unit thus providing a longer service life.
The existing wiring is adequate for a 12 volt
electrical system using this solenoid.
Starter Solenoid .............................................................. U487-149 .......... $80.79
Price and availability subject to change without notice • Shop online at www.univair.com
269