Engine 6/8 Apparatus Basic Familiarization
Thursday, August 1, 13
Cab Layout
Thursday, August 1, 13
Cab Layout
Thursday, August 1, 13
Captain Side Cab Layout
Thursday, August 1, 13
Front Bumper Line
Thursday, August 1, 13
Captain Side Discharge
Thursday, August 1, 13
Backboard Storage
Thursday, August 1, 13
Captain Side Front
Thursday, August 1, 13
Captain Side Middle
Thursday, August 1, 13
Captain Side Rear
Thursday, August 1, 13
Rear Layout
Thursday, August 1, 13
Rear Compartment with Booster
Reel
Thursday, August 1, 13
Rear Ladder Compartment
Thursday, August 1, 13
Rear Storage
Thursday, August 1, 13
Hosebed Storage
Captain Side Front
Captain Side Rear
Engineer Side Front
Engineer Side Rear
Thursday, August 1, 13
Well
Thursday, August 1, 13
Engineer Side Intake
Thursday, August 1, 13
Engineer Front Compartment/Pump
Panel
Thursday, August 1, 13
Engineer Side Middle
Compartment
Thursday, August 1, 13
Engineer Side Rear
Thursday, August 1, 13
Under the Cab
Autolube
-Goes through manifolds to lubricate
any grease fitting except the drive shaft
Thursday, August 1, 13
Under the Cab
Fuel Screen
Fuel Filter
Thursday, August 1, 13
Primer Pump
Under the Cab
Hydraulic pump for foam pump.
-foam pump is gear driven hydraulic
pump
Thursday, August 1, 13
Under the Cab
front transmission cooler
Thursday, August 1, 13
Under the Cab
Power steering cooler
Thursday, August 1, 13
Under the Cab
Ball joint bootlook for rips, water can get in and
cause ball joint failure
Thursday, August 1, 13
Under the Cab
The blue is torque seal.
if there is a crack, the screw has
loosened
Thursday, August 1, 13
Under the Cab
Power steering pump
Thursday, August 1, 13
Under the Cab
Air compressor
Thursday, August 1, 13
Under the Cab
Fuel Pump
Thursday, August 1, 13
Under the Cab
Hydraulic fluid filters
Thursday, August 1, 13
Under the Cab
Check screws regularly.
The air filter has come down in the
past
Thursday, August 1, 13
Under the Cab
Tak-4-Suspension Gear Box
Check for leaks
Thursday, August 1, 13
Under the Cab
Coolant Screen/filter
Oil Filter
Water pump
Thursday, August 1, 13
Engine Special Information
• E6 DIFFERENCES FROM E8
E6 is 3” lower than E8
E6 has lights on the sides
E6 has a sight glass for water level
E6 has different cab controls
E6 has monitor control in pump panel
• UNDER THE CAB
E6 metal in-front of turbo is a heat shield
After treatment device (DPF - Diesel Particulate Filter)
goes to muffler and out the tailpipe exhaust
holds suit etc. regen gets so hot it burns all the bad stuff out. if
you dont regen the after treatment device can get plugged up
and you will loose power
deisel exhaust fuel - def - gets injected into the after treatment
device. this is a fuel that gets hot and burns everything off
Starter is located underneath the exhaust/turbo
Torsion bar tape
look for rips, can cause failure because of water damage
Auto-lube fault
manually lube
we dont use (for shops use)
PUMP
PANEL
SPECIAL
•
PCM
power control module
like check engine light - comes on with an audible alarm
Reel blowout is a reel drain that pumps water out of reel line
Thursday, August 1, 13
Engine Inventory
Date:
Fluids / Mileage
Engineer:
Engineers Compartment
Driver Rear Tall Compartment
Well
Mileage: See Daily Check-off
Air Hose
Flat Head Axe
(4) Wildland Packs
Fuel
Tool Box
Pick head Axe
(2) 100' 1 1/2" Wildland Hose Rolls
Oil
Foxtail Brush
Halligan Bar
Lateral bag
Radiator
High Rise Pack
Ram Bar
Master Stream Fog Nozzle
Transmission
Pry bar
Smooth Bore Tips
Tank water
Wire Cutters
Stream Straightener
Cab
Driver Front Tall Compartment
Spare SCBA
Bolt Cutters
Deluge Gun Stand
(3) Traffic Cones
(2) Hay Hooks
5 Gal. F-500
(3) Motorola XTS 5000's
Chock Block
Sledge Hammer
5 Gal. B Foam
(4) Headsets
Roll of 1-1/2" Hose
Lockout Kit
Absorbent
Knox Keys
(2) 4" Spanners
Drywall Hook
ECFD Run Maps
2 1/2" Soft Sleeve
Gas Blower
Hose Bed
Complex Map Book
Rubber Mallet
9430 RALS Pelican Light
1000' 2 1/2" Hose
Thomas Bros. Map Book
Accountability Board
Pigtails and Adapters
750' 4" Hose
SMG,LKS,SNT,ECO Maps
Holmatro w/ 2 Batteries
Extension Cord
(2) 100' 1 1/2" & 1 3/4" Hose Bundles
FOG Guide
Round Tip Shovel
(2) Backboards
RCS Book
Driver Lift Compartment
Saw Tool Box
ERG Guide
4" Discharge Cap
MCI Guide
4" Double Male
Rear Tailboard Compartment
24' Ladder
Door Opener
(2) 4" Double Females
(2) Salvage Covers
14' Ladder
(3) BA's
(2) 2 1/2" Double Males
(2) Hall Runners
Attic Ladder
PDA/ Cell Phone & Charger
(2) 2 1/2" Double Females
Hose Clamp
10' Pike pole
Thermal Imaging Camera
2" Discharge Cap
Water Thief
6' Pike Pole
(3) BK Radios w/ Clamshells
(2) 2 1/2"-Garden Hose Reducer
(2) 1 1/4" Smooth Bore Tips
Rubbish Hook
(5) Spare XTS 5000 Batteries
(2) Wildland Nozzles
(2) Double Males
(4) BA Bottles
Kestrel Weather Monitor
1 1/2" Fog Nozzle Tip
(2) Double Females
Gated Wye Rear 2 1/2" Dis.
Binoculars
1 1/2" x 1/2" smoothbore tip
(2) 2 1/2" Fog Nozzles
2 1/2" Discharge Elbow
Radiation Pager
(3) Akron Spanners
(2) 2 1/2" Playpipe
Digital Camera
Cab Lift Handle
(2) Hydrant Wrenches
Multi Gas Detector
Fire Investigators Box
(4) Safety Vests
TAC Stick
Pass. Rear Lower Compartment
(4) Web Gear
Caution Tape
DryChem & PW Extinguisher
LED Puck Light
Spare BA Mask
Trauma Bag
Cooler
Overhaul Bag
Suction Unit
Pod
Computer
(2) O2 Bottles
(4) Chairs
Airway bag
(4) Cots
Hose Bed Box
Preconnects
Miscellaneous
Running Board Well
Hydrant Wrench
4" Supply
4" - 2 1/2" Increaser
McLoud
LifePak 12 ECG Monitor
(4) Sleeping Bags
Shovels (Round & Square Nose)
Drug Box
(4) Sleeping Pads
Coffee Pot
Propane Stove
1 1/2" 150' Transverse / Fog
Broom
1 3/4" 150' Transverse / Fog
Chainsaw
Pass. Front Lower Compartment
2 1/2" 150' Hose Bed / Gated Wye
(2) Gas Cans- Mix & Regular
RIC Bag
(2) Propane Bottles
1 1/2" 150' Tailboard / SBT
Pulaski Tool
Rescue Hardware Bag
Coffee Condiments
Swift water Rescue Bag
WMD Bag
(2) Rope Bags
Thursday, August 1, 13
NOTES ON BACK