Material Safety Data Sheet
EMERGENCY NUMBERS:
(USA) CHEMTREC : 1(800) 424-9300 (24hrs)
(CAN) CANUTEC : 1(613) 996-6666 (24hrs)
(USA) Anachemia : 1(518) 297-4444
(CAN) Anachemia : 1(514) 489-5711
WHMIS
Protective Clothing
TDG Road/Rail
WHMIS CLASS: D-1A
TDG CLASS: 6.1
PIN: UN1548 PG: III
Section I. Product Identification and Uses
Product name
ANILINE HYDROCHLORIDE
CI#
Not available.
CAS#
142-04-1
Chemical formula
C6H5NH2HCl
Synonyms
Aniline chloride, Anilinium chloride, benzenamine Code
hydrochloride, C.I. 76001, Hydrochloride benzenamide,
Phenylamine hydrochloride, AC-0775, 07360
Formula weight
Supplier
Anachemia Canada.
255 Norman.
Lachine (Montreal), Que
H8R 1A3
Material uses
Not available.
AC-0775
129.60
Supersedes
Section II. Ingredients
Name
CAS #
%
TLV
1) ANILINE HYDROCHLORIDE
142-04-1
97
Not established by ACGIH
Toxicity values of the
hazardous ingredients
ANILINE HYDROCHLORIDE:
ORAL (LD50): Acute: 840 mg/kg (Rat). 841 mg/kg (Mouse).
INTRAPERITONEAL (LD50): Acute: 460 mg/kg (Rat). 300 mg/kg (Mouse).
Section III. Physical Data
Physical state and
appearance / Odor
pH (1% soln/water)
Green crystalline powder.
Odor threshold
Not available.
Percent volatile
Not available.
Freezing point
196-198°C
Boiling point
Not available.
Specific gravity
Not available.
Vapor density
4.46
Vapor pressure
Not available.
Water/oil dist. coeff.
Not available.
Evaporation rate
Not available.
Solubility
Soluble in water.
ANILINE HYDROCHLORIDE
page 2/4
Not available.
Section IV. Fire and Explosion Data
Flash point
193°C cc
Flammable limits
LEL: Not available. UEL: Not available.
Auto-ignition temperature Not available.
Fire degradation
products
Oxides of carbon and nitrogen. Hydrogen chloride.
Fire extinguishing
procedures
Use DRY chemical, carbon dioxide, or foam. Wear adequate personal protection to prevent contact with material or
its combustion products. Self contained breathing apparatus with a full facepiece operated in a pressure demand or
other positive pressure mode.
Fire and Explosion
Hazards
The sensitivity to static discharge is not available. The sensitivity to impact is not available. Emits toxic fumes
under fire conditions.
Section V. Toxicological Properties
Routes of entry
Inhalation and ingestion. Eye contact. Skin contact. Skin absorption.
Effects of Acute
Exposure
May be fatal by ingestion, inhalation, or by skin absorption. Irritant. Target organs: blood, central nervous system.
Eye
Causes irritation. IRRITATION: EYE-RABBIT 20 mg/24H MODERATE.
Skin
Causes skin irritation. Readily absorbed.
Inhalation
May cause respiratory tract inflammation. Material is irritating to mucous membranes. May cause headache,
nausea, vomiting, drowsiness, dizziness, dyspnea, incoordination, unconsciousness and possibly death. Acute
effects may be delayed.
Ingestion
Not available.
Section V. Toxicological Properties
Effects of Chronic
Overexposure
ANILINE HYDROCHLORIDE
page 3/4
May cause allergic skin reactions. Possible mutagen. Animal: Carcinogen. To the best of our knowledge the chronic
toxicity of this substance has not been fully investigated.
Section VI. First Aid Measures
Eye contact
Wash eyes and skin with copious quantities of water for at least 15 minutes, occasionally lifting the upper and lower
eyelids. Call a physician.
Skin contact
Wash skin with copious quantities of water for at least 15 minutes. Remove contaminated clothing and shoes. Call a
physician. Wash contaminated clothing before reusing.
Inhalation
Remove patient to fresh air. Administer approved oxygen supply if breathing is difficult. Administer artificial respiration
or CPR if breathing has ceased. Call a physician.
Ingestion
If conscious, wash out mouth with water. Never give anything by mouth to an unconscious or convulsing person.
Call a physician.
Section VII. Reactivity Data
Stability
Stable. Conditions to avoid: High temperatures, sparks, open flames and all other sources of ignition,
contamination.
Hazardous decomp.
products
Not available.
Incompatibility
Strong oxidizing agents. Strong acids.
Reaction Products
Not available. Hazardous polymerization will not occur.
Section VIII. Preventive Measures
ANILINE HYDROCHLORIDE
page 4/4
Protective Clothing in Wear self-contained breathing apparatus, rubber boots and heavy rubber gloves.
case of spill and leak
Spill and leak
Evacuate. Wear self-contained breathing apparatus, rubber boots and heavy rubber gloves. Sweep up and place in
container for disposal. Avoid raising dust. Ventilate area and wash spill site after material pick up is complete. Avoid
run off.
Waste disposal
Dissolve or mix the material with a combustible solvent and burn in a chemical incinerator equipped with an after
burner and scrubber. According to all applicable regulations.
Storage and Handling
Store in a cool place away from heated areas, sparks, and flame. Store in a well ventilated area. Store away from
incompatible materials. Do not add any other material to the container. Do not wash down the drain. Do not breathe
dust. Keep away from direct sunlight or strong incandescent light. Keep container tightly closed and dry. Manipulate
under an adequate fume hood. Avoid raising dust. Empty containers may contain a hazardous residue. Handle and
open container with care. Minimize dust generation and exposure - use dust mask or appropriate protection. Take off
immediately all contaminated clothing. This product must be manipulated by qualified personnel. Do not get in eyes, on
skin, or on clothing. Wash well after use. In accordance with good storage and handling practices. Do not allow
smoking and food consumption while handling. In case of accident or if you feel unwell, seek medical advice
immediately (show the label when possible.).
Section IX. Protective Measures
Protective clothing
Wear appropriate OSHA/MSHA approved chemical cartridge respirator. Impervious gloves. Apron or clothing to
protect skin. Sufficient to protect skin. Safety glasses.
Engineering controls
Use in a chemical fume hood. Use adequate ventilation. Make eye bath and emergency shower available. Do not
use in unventilated spaces.
Section X. Other Information
Special Precautions or Highly toxic. Carcinogen. Mutagen. Irritant. Do not breathe dust. Avoid all contact with the
comments
product. Avoid prolonged or repeated exposure. Light sensitive. Use in a chemical fume
hood.
RTECS NO: CY0875000. (Aniline hydrochloride)
NFPA
Prepared by MSDS Department/Département de F.S..
Validated 11-Dec-2013
EMERGENCY NUMBERS:
(USA) CHEMTREC :
1(800) 424-9300 (24hrs)
(CAN) CANUTEC :
1(613) 996-6666 (24hrs)
(USA) Anachemia :
1(518) 297-4444
(CAN) Anachemia :
1(514) 489-5711
While the company believes the data set forth herein are accurate as of the date hereof, the company makes no warranty with respect thereto
and expressly disclaims all liability for reliance thereon. Such data are offered solely for your consideration, investigation and verification.