MATERIAL SAFETY DATA SHEET
PRODUCT NAME: Bucky's 9
DATE PRINTED:
PRODUCT TYPE: tire gloss
MANUFACTURER’S NAME: AMERICLEAN, INC.
4100 S. 76TH CIRCLE
OMAHA, NE 68127
402-593-9229
EMERGENCY RESPONSE: 1- 888-593-9229
7/01/09
SECTION I – HAZARDOUS INGREDIENTS/ SARA III INFORMATION
REPORTABLE COMPONENTS
CAS #
WEIGHT % TLV/PEL
TWA
STEL/CEILING SKIN
THIS PRODUCT DOES NOT CONTAIN ANY ACTIVE MATERIAL CONSIDERED HAZARDOUS AS
DEFINED IN 29 CFR 1910.120.
THIS MATERIAL IS FOR INDUSTRIAL USE ONLY, NOT FOR FOOD, MEDICAL OR DRUG USE
SECTION II – PHYSICAL / CHEMICAL CHARACTERISTICS
BOILING POINT: 100 C
SPECIFIC GRAVITY: (H2O=1) @ 25C: 1.0
FREEZE POINT: 0 C
PHYSICAL STATE: VISCOUS LIQUID
VAPOR DENSITY: (AIR=1) N/A
EVAPORATION RATE: NOT ESTABLISHED
PH CONCENTRATE: 4-6
SOLUBILITY IN WATER: 100%
APPEARANCE: COLORLESS TO YELLOWISH
ODOR: NONE
SECTION III – FIRE AND EXPLOSION HAZARD DATA
FLASH POINT: >100C
METHOD USED: PENSKY MARTENS CLOSED CUP
FLAMMABLE LIMITS IN AIR BY VOLUME – LOWER: N/A
UPPER: N/A
EXTINGUISHING MEDIA: WATER SPRAY, DRY FOAM, CO2, OR DRY CHEMICAL
HAZARDOUS COMBUSTION BY-PRODUCTS: SILICONE DIOXIDE. CARBON OXIDES AND TRACES
OF INCOMPLETELY BURNED CARBON COMPOUNDS
SPECIAL FIRE FIGHTING EQUIPMENT: FIREFIGHTERS SHOULD BE EQUIPPED TO PREVENT BREATHING
OF VAPORS. WEAR OSHA APPROVED SELF-CONTAINED BREATHING APPARATUS AND PROTECTIVE CLOTHING AS
SPECIFIED UNDER OCCUPATIONAL CONTROL PROCEDURES.
SECTION IV – REACTIVITY DATA
STABILITY: STABLE
CONDITIONS TO AVOID: NONE KNOWN
INCOMPATIBILITY (MATERIALS TO AVOID): REACTS WITH STRONG ACIDS, STRONG BASES,
STRONG OXIDISING AGENTS
HAZARDOUS POLYMERIZATION: DOES NOT OCCUR.
PRIMARY ROUTE(S) OF ENTRY INTO BODY: EYE AND SKIN CONTACT, INHALATION
ACUTE EFFECTS: EYES: MAY CAUSE EYE IRRITAION.. SKIN: REDNESS & IRRITATION THROUGH
REPEATED CONTACT. INHALATION: MAY CAUSE RESPIRATORY TRACT IRRITATION. INGESTION: MAY
CAUSE STOMACH IRRITATION, PAIN AND NAUSEA. SMALL AMOUNTS OF THE LIQUID ASPIRATED INTO
THE RESPIRATORY TRACT DURIN INGESTION OR VOMITING MAY CAUSE DAMAGE TO THE LUNGS.
CHRONIC EFFECTS: MAY CAUSE CHRONIC DERMATITIS
EMERGENCY FIRST AID PROCEDURES:
SKIN: WASH WITH SOAP AND WATER FOR FIFTEEN MINUTES, REMOVE CONTAMINATED CLOTHING. IF
IRRITATION OCCURS, GET MEDICAL ATTENTION.
EYES: FLUSH WITH CLEAN WATER FOR FIFTEEN MINUTES, LIFTING UPPER AND LOWER LIDS, SEEK
MEDICAL ATTENTION IF IRRITATION OCCURS.
INHALATION: NO FIRST AID SHOULD BE NEEDED. GET MEDICAL ATTENTION IF IRRITATION OCCURS OR
IF BREATHING BECOMES DIFFICULT.
INGESTION: IF CONSCIOUS, GIVE LARGE AMOUNTS OF WATER, DO NOT INDUCE VOMITING. IF VOMITING
DOES OCCUR, GIVE ADDITIONAL FLUIDS. DANGER OF ASPIRATION. SEEK MEDICAL ATTENTION IF
NEEDED.
SECTION VI – PRECAUTIONS FOR SAFE HANDLING
STORAGE: TIGHTLY CLOSED CONTAINERS, PRODUCT IS ‘NON-HAZARDOUS’.
HANDLING: WEAR PROPER PVD GLOVES AND SAFETY GLASSES WHEN HANDLING.
PRECAUTIONARY LABELING: NONE
STEPS TO BE TAKEN IF MATERIAL IS SPILLED: WEAR PROTECTIVE CLOTHING AS SPECIFIED
ABOVE. AVOID CONTACT WITH EYES AND SKIN. AVOID INHALING MISTS AND VAPORS. IF MATERIAL IS
RELEASED INDICATE RISK OF SLIPPING. CONTAINMENT: PREVENT MATERIAL FROM ENTERING
SURFACE WATERS, DRAINS OR SEWERS AND SOIL. CONTAIN ANY FLUID THAT RUNS OUT USING
SUITABLE MATERIAL. RETAIN CONTAMINATE WATER/EXTINGUISHING WATER.
WASTE DISPOSAL METHOD: DO NOT FLUSH AWAY WITH WATER. FOR SMALL AMOUNTS: ABSORB
WITH A LIQUID BONDING MATERIAL SUCH AS DIATOMACEOUS EARTH AND DISPOSE OF ACCORDING TO
LOCAL, STATE AND FEDERAL REGULATIONS. CONTAIN LARGER AMOUNTS AND PUMP UP INTO SUITABLE
CONTAINERS. CLEAN ANY SLIPPERY COATING THAT REMAINS USING A DETERGENT/SOAP SOLUTION OR
ANOTHER BIODEGRADABLE CLEANER. DISPOSE OF ACCORDING TO APPLICABLE STATE, FEDERAL AND
LOCAL LAWS.
OTHER PRECAUTIONS: EMPTY CONTAINERS – TRIPLE RINSE. DISPOSE OF ACCORDING TO LOCAL,
STATE AND FEDERAL REGULATIONS.
NOTE: THESE PRECAUTIONS ARE FOR ROOM TEMPERATURE HANDLING. USE AT ELEVATED
TEMPERATURES OR AEROSOL SPRAY APPLICATION MAY REQUIRE ADDED PRECAUTIONS.
ENVIRONMENTAL TOXICITY DATA: BIODEGRADABLE.
SECTION VII – OCCUPATION CONTROL PROCEDURES
VENTILATION: GENERAL VENTILATION
PERSONAL PROTECTION:
EYES: USE PROPER PROTECTION – SAFETY GLASSES AS A MINIMUM
SKIN: WASHING AT MEALTIME AND SHIFT END IS ADEQUATE.
GLOVES – NO SPECIAL PROTECTION IS NEEDED
RESPIRATOR TYPE: NONE REQUIRED
SECTION VIII – SHIPPING INFORMATION
D.O.T. CLASSIFICATION: NOT REGULATED FOR TRANSPORTATION
SECTION IX – PRECAUTIONARY STATEMENT
WARNING: THE INFORMATION CONTAINED IN THIS MSDS IS BASED ON THE DATA AVAILABLE TO US
FROM SOURCES WE BELIEVE TO BE RELIABLE. NO WARRANTY OR GUARANTY EXPRESSED OR IMPLIED
IS MADE REGARDING THE ACCURACY OF THIS DATA OR THE RESULTS OBTAINED FROM THE RELIANCE
ON THIS DATA. THE MANUFACTURER ASSUMES NO RESPONSIBILITY FOR INJURY FROM THE USE OF
THIS PRODUCT. TO BE SAFE – ALL PERSONS WHO MAY BE EXPOSED TO THIS PRODUCT SHOULD READ
THIS SAFETY INFORMATION. THIS IS REQUIRED BY FEDERAL LAW.
SECTION V – HEALTH HAZARD DATA