MATERIAL SAFETY DATA SHEET
PRODUCT NAME:
DATE REVISED:
Econo-AF3
FEBRUARY 26, 2009
For Chemical Emergency (Spill, Leak, Fire, Exposure or Accident)
CALL CHEMTREC Day or Night 800-424-9300
For International, Call 703-527-3887 (Collect Calls Accepted)
SECTION I -PRODUCT IDENTIFICATION
Trade Name Econo-AF3
Product Use - Multi-Use Foamer
Chemical Name Cocamidopropyl Betaine
Department of Transportation (DOT) Classification- Not Regulated
CAS#
61789-40-0
590-29-4
SECTION II- COMPOSITION, INFORMATION ON INGREDIENTS
Chemical Name
Percent
TLV
LD(50)
Cocamidopropyl Betaine 70-85
NA
NA
Potassium Formate
0-25
NA
Oral, mouse
5500 mg/kg
Appearance
Odor
Specific gravity
Vapor Pressure
pH
SECTION III – PHYSICAL PROPERTIES:
clear yellow liquid
Solubility in water at 20oC
mild organic
Boiling Point
1.046
Freezing Point
Approx 20
% Volatiles
NA
Flash point
LC(50)
NA
NA
soluble
100oC
-20oC
ND
>100oC
SECTION IV – FIRE AND EXPLOSION DATA
FIRE FIGHTING MEASURES
Flash Point: >200oC (PMCC)
Conditions of Flammability: Will not burn unless preheated
Extinguishing media: Water fog, dry chemical, CO2, foam, water spray
Special Fire Fighting Procedures: Do not enter confined space without full bunker gear and a self
contained breathing apparatus. Cool exposed containers. Product on floor may become slippery.
Explosion Limits (% by Volume):
LEL – NA
UEL - NA
Autoignition Temperature: NA
Sensitivity to Static Discharge: No
Sensitivity to Mechanical Impact: No
SECTION V – REACTIVITY DATA
Chemical Stability:
Stable under normal conditions of storage and use
Incompatible Material: Avoid contact with strong oxidizing agents or open flames
Conditions of Reactivity: With incompatible materials; excessive heat
Economy
Polymers & Chemicals
P.O. Box 450246
Houston, TX 77245-0246
USA Toll free: (800) 231-2066
Phone: (713) 723-8416
Fax: (713) 723-1845
URL: www.EconomyPolymers.com
E-mail: economy@economypolymers.com
Hazardous Decomposition Products:
oxides of carbon, irritating and toxic fumes and gasses
Hazardous Polymerization:
Has not been reported
SECTION VI – TOXICOLOGICAL PROPERTIES
Routes of Entry:
Acute Overexposure Effects:
Inhalation: Airborne concentrations of dust, mist or spray, may cause
irritation or damage to the upper respiratory tract, or lung tissue.
Depending on the severity of exposure, chemical pneumonia.
Eye Contact: Short term exposure may cause irritation. Prolonged
contact may cause irreversible damage to the eye.
Skin Contact: Prolonged exposure may cause irritation or burn.
Ingestion: This product is not acutely toxic. May cause irritation or
burn.
Chronic Overexposure Effects: This product is a typical surface active agent. It has the potential to
cause irritation if more than transient contact occurs.
Sensitization:
NA
Carcinogenicity:
Ingredients not listed
Mutagenicity:
NA
Teretogenicity:
NA
Reproductive Toxicity:
NA
Synergistic Products:
NA
SECTION VII – PREVENTIVE MEASURES
Personal Protective Equipment:
CSA/MSA/NIOSHA approved protection equipment:
Chemical goggles and face shield, natural or butyl rubber
gloves and boots; coveralls or other protective clothing;
respiratory protection is not required during normal use but
should be considered when mixing
Specific Engineering Controls:
Eye wash and deluge shower should be nearby
Leak and Spill Procedures:
Shut off leak at source. Dike large spills and scavenge
material. Small spills should be scooped up and transferred to
salvage drums. Wear protective equipment as noted above.
Waste Disposal:
Dispose of in accordance with local, provincial and federal
regulations. This product is not a hazardous waste.
Handling/Storage Requirements:
Avoid excessive heat and contact with skin and eyes. Do not
store with incompatible materials. Wash after using.
Special Shipping Information:
None
SECTION VIII – FIRST AID MEASURES
Inhalation: Move to fresh air. If breathing is difficult, administer oxygen. Consult a physician.
Ingestion: If victim is conscious and alert, give one-two glasses of water or milk. Consult a physician.
Eyes: Flush with plenty of water for 15 minutes, occasionally lifting upper and lower eyelids. Get medical
attention if irritation persists.
Skin: Flush skin with plenty of water. If irritation develops consult a physician. Wash/launder
clothing/footwear thoroughly before reuse.
Shipping Names:
TRGR Class:
Economy
Polymers & Chemicals
SECTION IX – CLASSIFICATION
Not Regulated
Not Restricted, ERAP – Not Required
P.O. Box 450246
Houston, TX 77245-0246
USA Toll free: (800) 231-2066
Phone: (713) 723-8416
Fax: (713) 723-1845
URL: www.EconomyPolymers.com
E-mail: economy@economypolymers.com
WHMIS:
DSL:
D-2B
Disclaimer:
THE INFORMATION WHICH IS IN THIS DOCUMENT IS BASED UPON AVAILABLE DATA AND
BELIEVED TO BE CORRECT; HOWEVER, THE PRODUCT DISCUSSED HEREIN IS SOLD
WITHOUT ANY WARRANTY, EXPRESSED OR IMPLIED, AS TO MERCHANTIBILITY OR
FITNESS FOR A PARTICULAR PURPOSE.
Economy
Polymers & Chemicals
P.O. Box 450246
Houston, TX 77245-0246
USA Toll free: (800) 231-2066
Phone: (713) 723-8416
Fax: (713) 723-1845
URL: www.EconomyPolymers.com
E-mail: economy@economypolymers.com