Material Safety Data Sheet
UBT 500 Medium
SECTION I: COMPANY IDENTIFICATION
Supplier:
Date prepared: 18/02/2013
LR Chem
8305, rue Pascal-Gagnon
Montréal (Québec)
Tel: (514) 324-8170
Fax: (514) 329-3877
EMERGENCY PHONE NUMBER: (613) 996-6666 Canutec 24h
SECTION II: HAZARD IDENTIFICATION
Product name: UBT 500 Medium
Formula: Solvent blend
WHMIS classification: B2, D2B
CAS no: N/A
LR Chem – UBT 500 Medium
1
SECTION III: HAZARDOUS INGREDIENTS
(%)
60-100%
1-5%
1-5%
10-30 %
Ingredient name
Toluene
N-Propyle Acetate
N-Butyl Acetate
Chloronated Solvent
CAS no
108-88-3
109-60-4
123-86-4
75-09-2
SECTION IV: FIRST AID MEASURES
Eye contact: Flush eyes with clear, running water for a minimum of 15 minutes while holding
eyelids open. If irritation persists, consult a physician.
Skin contact: Remove contaminated clothing; wash thoroughly with soap and water before
wearing clothing again. Consult a physician if irritation persists.
Inhalation: Remove victim to fresh air. If not breathing, qualified personnel should administer
artificial respiration. Get medical attention.
Ingestion: Do not induce vomiting. Obtain immediate medical attention.
SECTION V: FIRE AND EXPLOSION DATA
Extinguishing media:
Dry chemical
Foam.
Water spray.
Do not use water jet.
Special procedures:
Firefighters should wear adequate protective gear.
Self-contained breathing apparatus required.
Use water spray to cool fire exposed containers.
This material may produce a floating fire hazard.
LR Chem – UBT 500 Medium
2
SECTION VI: ACCIDENTAL RELEASE MEASURES
Leak/Spill:
Eliminate all source of ignition.
Dike area to prevent spreading.
Ventilate area.
Wear appropriate protective equipment.
Ground handling equipment.
Use non-sparking tools.
Explosion proof motors are recommended.
Pump to containers or soak up on inert absorbent.
Place in a closed container for disposal.
Do not flush to sewer.
.
SECTION VII: STORAGE AND HANDLING
Flash point: 8.2oC (closed cup, smallest value obtained)
Lower flammability limit: 1.16%
upper: 8.0%
Auto-ignition temperature: N/A
Handling procedures and equipment:
Keep away from heat, sparks and open flames.
Avoid breathing vapours/mists.
Use adequate ventilation.
Wear personal protective equipment appropriate to task.
Use proper grounding procedures.
Avoid contact with skin, eyes and clothing.
Do not cut, grind, weld or drill on near containers.
Launder contaminated clothing prior to reuse.
Do not ingest.
LR Chem – UBT 500 Medium
3
(Storage and Handling)
Attention – Cloth or paper soaked in these products may undergo
spontaneous ignition. Never discard wiping cloths soaked in this product
carelessly. Dry carefully before discarding.
SECTION VIII: EXPOSURE CONTROLS / PERSONAL PROTECTION
Glove / Type:
Nitrile or viton
Respiratory / Type: None required under normal use.
NIOSH approved respirator with organic vapour cartridge.
If material is hot and vapour is emitted.
Eye / Type:
Safety glasses with side-shields.
Footwear / Type:
Safety shoes per local regulations.
Clothing / Type:
Normal work clothes.
Other / Type:
Eye wash facility should be in close proximity.
Emergency shower should be in close proximity.
SECTION IX: PHYSICAL AND CHEMICAL DATA
Physical state: Liquid.
Appearance & odour: Acetate odour.
Odour threshold: Acetate odour.
Vapour pressure (mmHg): 4.2
Vapour density (air=1): 1.52
Volatile by volume: 100%
Specific gravity: 0.9.46
Evaporation rate (butyl acetate=1): 3.86
Initial Boiling point: 40oC Final boiling point : 111 oC
Solubility in water: No
LR Chem – UBT 500 Medium
4
SECTION X: STABILITY AND REACTIVITY
Chemical stability: Stable.
Conditions of instability: Stable under normal conditions.
Hazardous polymerization: Will not occur.
Incompatible substances: Avoid contact with concentrated chemicals with acid base.
Sensitivity to static discharge: Always have drums placed on the ground.
Sensitivity to mechanical impact: Not sensitive.
Hazardous combustion products: Carbon monoxide, carbon dioxide.
Explosive power: N/A.
N/A: Not available
SECTION XI: TOXICOLOGICAL PROPERTIES
(%)
DL50 (mg/kg)
(specie, route
LC50 (ppm)
(specie, period)
N-Butyl Acetate
1-5%
636 (oral)
1240 (dermal)
9380 (oral)
5000 (dermal)
10768 (oral)
4200 (dermal)
1600 (oral)
N/A (dermal)
8000 mg/m3
N-Propyle Acetate
60100%
1-5%
Ingredient name
Toluene
Chlorinated Solvent Blend
1030 %
8000 ppm/4h
390 ppm/4h
880G./.M3 30MIN
N/A: Not available
SECTION XII: ECOLOGICAL DATA
N/A
N/A: Not available
LR Chem – UBT 500 Medium
5
SECTION XIII: DISPOSAL CONSIDERATIONS
Waste disposal: Waste must be disposed of in accordance with environmental control
regulations.
SECTION XIV: TRANSPORT INFORMATIONS
TDG classification: FLAMMABLE LIQUIDE, N.O.S.
U.N. Number: 1993
Class: 3
Packaging group: II
SECTION XV: REGLEMENTATION INFORMATION
The components of this product are listed on the Canadian Domestic Substances List.
SECTION XVI: OTHER INFORMATIONS
LR Chem believes that the data contained herein are accurate and derived from qualified
sources; the data are not to be taken as a warranty or representation for which LR Chem
assumes legal responsibility. They are offered solely for your consideration, investigation and
verification. Any use of these data and information must be determined by the user to be in
accordance with applicable federal, state or provincial and local laws and regulations.
LR Chem – UBT 500 Medium
6